Professional Documents
Culture Documents
Vetoproof EC720
Non-toxic solvent free epoxy
waterproof wall, floor & tank coating
Uses
uu Waterproofing of concrete, asbestos, cement
and gypsum board surfaces.
uu Water tanks and reservoirs.
uu Hospital clean rooms.
uu Food processing areas.
Product Description
Vetoproof EC720 is a two component non-toxic high performance solvent free epoxy coating system that adheres
perfectly to concrete substrates. Once cured, the product has excellent abrasion and chemical resistance. Vetoproof
EC720 provides an attractive hard wearing and easily cleanable hygienic coating.
Cleaning
Usage Instructions
Tools and equipment should be cleaned with Vetonit
Surface Preparation Solvent XX400 immediately after use.
All surfaces should be dry and free from contamination
such as oil, grease, loose particles, decayed matter, Limitations
moss algal growth, laitence, and all traces of mould hh As with all epoxies; Vetoproof EC720 will yellow
release oils and curing compounds. This is best when exposed to UV
achieved by lightly grit-blasting the surface. Where
moss, algae or similar growths have occurred, hh Before filling the tank with water, Vetoproof EC720
treatment with a proprietary biocide should be carried must be fully cured for 7days at 20ºC
out after the grit-blasting process. Spalled and deeply
disintegrated concrete should be removed to sound
Packaging & Coverage
concrete and repaired with a Saveto repair system.
Theoratical
Minor irregularities leveling and pin hole filling can be Product Pack Size
Coverage
achieved using Vetorep ER350.
5 m²/liter @ 200
Vetoproof EC720 4 Liter Kit
Priming microns
Vetoprime EP491 or
Priming is not normally required provided the substrate 4 Liter Kits 7-10 m2/ Liter
Vetoprime EP490
is sound, prepared and good quality non porous
concrete. However, if concrete surface is porous, or w/c Stated consumptions data are for general guidance.
ratio is >0.5 it is recommended to use Vetoprime EP491 Actual consumption depends on the nature of
or EP490. substrate, method of application and wastage.
Vetoprime EP491 or EP490 should be mixed in the Shelf Life & Storage
proportions supplied. Add the entire contents of the
hardener can to the base can. When thoroughly mixed, Original sealed bag of Vetoproof EC720 has a shelf life
preferably using a slow speed mixer, the primer should of 12 months provided it is stored clear of ground in a
be applied in a thin, continuous film using rollers or dry and shaded place below 35ºC.
stiff brushes. Work the primer well into the surface
of the concrete taking care to avoid ponding or over Health & Safety
application. The primer should be left to achieve a tack-
free condition before applying the top coat. Vetoproof EC720, Vetoprime EP491, vetoprime EP490,
Technical Data Sheet -Vetoproof EC720