Professional Documents
Culture Documents
This document is designed to be used for safe and correct diagnosis of the electrically
controlled DAEWOO Diesel DL08 and DV11 engine.
It is recommended that all information in this manual as well as the engine service man-
ual and electrical wiring diagrams be fully understood before diagnosis with the diagno-
sis device (SCAN200) for accurate and effective service and shorter service hours.
If there is any incorrect information or type in this manual, feel free to contact Daewoo
Bus Corporation.
The specifications contained in this manual are subject to change without notice.
November 2009
Daewoo Bus Corporation
A/S team
Table of contents
This manual mainly describes diagnosis procedures with the device (SCAN-200) for
faster and accurate diagnosis.
3
8
4
5
2
6
1. ENTER key (to move next step) 5. HELP key (to help screen)
2. Arrow keys (changes selected value or mode) 6. ESC key (to previous step)
3. PgUp and PgDn keys (to upper or lower page) 7. ENTER key (to move next step)
4. Select key (scrolls up and down to select) 8. PWR(power)
7
System Diagnostic Manual
Diagnostic adapter
2. Push the vehicle main switch(Berrery main S/W)to the “ON” position.
8
System Diagnostic Manual
Press
9
System Diagnostic Manual
10
System Diagnostic Manual
Press
[PgDn] key
11. Engine brake #1 operation············· [OFF] 21. Faulty charged air temperature sensor···· 0
12. Engine brake #2 operation············· [OFF] 22. Faulty cam sensor································· 0
Press
13. ECU condenser #1 voltage··········81.0 [V] [PgDn]
23. Cruise SET/UP S/W······················· [OFF]
14. Faulty condenser #1 voltage status······· 0 key 24. Cruise SET/DOWN S/W················· [OFF]
15. ECU condenser #2 voltage··········81.1 [V] 25. Cruise RESUME S/W····················· [OFF]
16. Faulty condenser #2 voltage status······· 0 26. Cruise OFF S/W·······························[ON]
17. Boost pressure·························997 [hPa] 27. Cruise speed control················· [ACTIVE]
18. Faulty boost pressure sensor················ 0 28. Clutch S/W·····························[INACTIVE]
19. Charged air amount·············· 2357 mg/st] 29. Faulty clutch S/W··································· 0
20. Charged air temperature··········· 28.5 [°C] 30. Faulty crank sensor······························· 0
▲,▼ ▲,▼
Fix Un Main Fix Un Main
11
System Diagnostic Manual
Press
[PgDn] key
31. Coolant temperature·················· 25.0 [°C] 41. Faulty cooling fan speed sensor············ 0
32. Faulty coolant temperature sensor········ 0 42. Cooling fan speed··················· 2000 [rpm]
Press
33. Engine brake #1 S/W·············[INACTIVE] [PgDn]
43. Fuel temperature······················· 25.5 [°C]
34. Engine brake #2 S/W·············[INACTIVE] key 44. Faulty fuel temperature sensor············· 0
35. Driving mode········································· 0 45. Ignition switch···································[ON]
36. Normal engine RPM······························ 1 46. Engine oil pressure···················845 [hPa]
37. Faulty engine RPM································ 0 47. Faulty engine oil pressure sensor·········· 0
38. Engine RPM································· 0 [rpm] 48. Engine oil temperature·············· 27.1 [°C]
39. Fuel supply pressure·················0.3[MPa] 49. Faulty engine oil temperature sensor···· 0
40. Faulty fuel supply pressure sensor········ 0 50. Parking brake switch················ [ACTIVE]
▲,▼ ▲,▼
Fix Un Main Fix Un Main
Press
[PgDn] key
Check sensor data Check sensor data
61. External fuel supply amount··· 0.0 [mg/st] 51. Retarder S/W·························[INACTIVE]
62. Fuel supply amount················ 0.0 [mg/st] 52. Foot brake S/W #1·················[INACTIVE]
Press
63. Limited fuel supply amount··· 87.2 [mg/st] [PgDn]
53. Foot brake S/W #2·················[INACTIVE]
64. PTO RPM control fuel amount··· 0.0 [mg/st] key 54. Foot brake S/W #3·················[INACTIVE]
65. Faulty injector 1 (DV11:1)······················ 0 55. Faulty foot brake S/W···························· 0
66. Faulty injector 2 (DV11:4)······················ 0 56. Engine stop S/W····························· [OFF]
67. Faulty injector 3 (DV11:2)······················ 0 57. Gear ratio·····························0.500 [min/s]
68. Faulty injector 4 (DV11:5)······················ 0 58. Vehicle speed·························· 0.0 [km/h]
69. Faulty injector 5 (DV11:3)······················ 0 59. Faulty vehicle speed sensor·················· 0
70. Faulty injector 6 (DV11:6)······················ 0 60. Faulty fuel high-pressure generator······· 0
▲,▼ ▲,▼
Fix Un Main Fix Un Main
Press
[PgDn] key
12
System Diagnostic Manual
Press
[PgDn] key
Check sensor data Check sensor data
21. Driving distance after starting········ 0 [km] 11. Faulty engine brake #2 output··············· 1
22. Engine running time after starting···· 0.0 [h] 12. Faulty engine brake #1 output··············· 0
Press
23. PTO operating time after starting···· 0.0 [h] [PgDn]
13. Faulty RPM tachometer························· 0
24. fuel amount for PTO operation after starting·0 [L] key 14. Faulty cruise operation lamp················· 1
25. Fuel consumption after starting (km/L)·0.00 [km/L] 15. Faulty high-pressure pump pulse·········· 0
26. ECU operating time after starting····· 0.1 [h] 16. Faulty rail pressure regulating valve······ 0
27. Fuel amount for idling after starting··· 0[L] 17. Starting fuel amount··············· 0.0 [mg/st]
28. Instant fuel consumption (km/L)·0.00 [km/L] 18. Max. engine RPM after starting····· 0[rpm]
29. Instant fuel consumption (L/km)·0.00 [L/km] 19. Idling time after starting················· 0.0 [h]
· ····································································· 20. Used fuel amount after starting········ 0 [L]
▲,▼ ▲,▼
Fix Un Main Fix Un Main
13
System Diagnostic Manual
Press
[PgDn] key
Check sensor data
14
System Diagnostic Manual
Press
[Enter] key
Check sensor data Check sensor data
11. Fuel supply pressure·················0.3[MPa] 01. Accelerator pedal depression······· 0.0 [%]
12. Fuel temperature······················· 25.5 [°C] 02. Battery voltage·····························24.1 [V]
Press
13. Ignition switch···································[ON] [PgDn]
03. Boost pressure·························997 [hPa]
14. Engine oil pressure··················· 845 [hpa] key 04. Charged air temperature··········· 28.6 [°C]
15. Engine oil temperature·············· 27.2 [°C] 05. Faulty cam sensor································· 0
16. Vehicle speed·························· 0.0 [km/h] 06. Faulty crank sensor······························· 0
17. Faulty fuel high-pressure generator······· 0 07. Coolant temperature·················· 25.0 [°C]
18. External fuel supply amount··· 0.0 [mg/st] 08. Normal engine RPM······························ 1
19. Fuel supply amount················ 0.0 [mg/st] 09. Faulty engine RPM································ 0
20. Heater relay operation···················· [OFF] 10. Engine RPM································· 0 [rpm]
▲,▼ ▲,▼
Fix Un Main Fix Un Main
Press
[PgDn] key
15
System Diagnostic Manual
Press
[PgDn] key
Check sensor data Check sensor data
21. #3 Cyl Dynamic compensation fuel amount········0.0[mg/st] 11. Fuel supply amount················ 0.0 [mg/st]
22. #4 Cyl Dynamic compensation fuel amount········0.0[mg/st] 12. Limited fuel supply amount··· 87.2 [mg/st]
Press
23. #5 Cyl Dynamic compensation fuel amount········0.0[mg/st] [PgDn]
13. Faulty injector 1 (DV11:1)······················ 0
24. #6 Cyl Dynamic compensation fuel amount········0.0[mg/st] key 14. Faulty injector 2 (DV11:4)······················ 0
25. A class static compensation fuel amount····0.0[mg/st] 15. Faulty injector 3 (DV11:2)······················ 0
26. B class static compensation fuel amount····0.0[mg/st] 16. Faulty injector 4 (DV11:5)······················ 0
27. C class static compensation fuel amount····0.0[mg/st] 17. Faulty injector 5 (DV11:3)······················ 0
28. D class static compensation fuel amount····0.0[mg/st] 18. Faulty injector 6 (DV11:6)······················ 0
29. D class static compensation fuel amount····0.0[mg/st] 19. #1 Cyl Dynamic compensation fuel amount·······0.0[mg/st]
30. F class static compensation fuel amount·····0.0[mg/st] 20. #2 Cyl Dynamic compensation fuel amount·······0.0[mg/st]
▲,▼ ▲,▼
Fix Un Main Fix Un Main
Press
[PgDn] key
16
System Diagnostic Manual
Press
[PgDn] key
Check sensor data Check sensor data
17
System Diagnostic Manual
Press
[PgDn] key
Check sensor data
18
System Diagnostic Manual
Press
[PgDn] key
Check sensor data Check sensor data
21. Fuel supply amount················ 0.0 [mg/st] 11. Faulty engine oil pressure sensor·········· 0
· ····································································· 12. Engine oil temperature·············· 27.5 [°C]
Press
01. Accelerator pedal depression······· 0.0 [%] [PgDn]
13. Faulty engine oil temperature sensor···· 0
02. Faulty accelerator pedal sensor············ 0 key 14. Parking brake switch················ [ACTIVE]
03. Engine brake #1 operation············· [OFF] 15. Foot brake S/W #1·················[INACTIVE]
04. Engine brake #2 operation············· [OFF] 16. Foot brake S/W #2·················[INACTIVE]
05. Clutch S/W·····························[INACTIVE] 17. Foot brake S/W #3·················[INACTIVE]
06. Faulty clutch S/W··································· 0 18. Faulty foot brake S/W···························· 0
07. Engine brake #1 S/W·············[INACTIVE] 19. Vehicle speed·························· 0.0 [km/h]
08. Engine brake #2 S/W················ [ACTIVE] 20. Faulty vehicle speed sensor·················· 0
▲,▼ ▲,▼
Fix Un Main Fix Un Main
19