Professional Documents
Culture Documents
CO
X4.
R 4
P
W
. V INSTALLATION MANUAL
W PT-017
W
INSTALLATION INSTRUCTIONS
TOYOTA HILUX REAR BUMPER WITH LEDS
PT-017
SAFETY TIPS
1. We have summarized instruc ons to prevent any hazardous situa on that could hurt you or others.
2. Use your good judgment, read this en re manual before installing our product, and take your me to fully
understand the process. If you need any addi onal informa on, do not hesitate to contact us.
3. Do a job safety analysis of the working area, remove any poten al risk iden fied.
4. Use all the personal safety equipment: glasses, boots, and gloves. Your safety is very important for us.
1. Make sure your vehicle is shut down. Set up the emergency brake and use re blocks.
5. Do not remove any part of the vehicle –not men oned- in this manual
3
1 6
1 4 2
1/2"X11/2 HEXAGONAL 6/32"X3/4" STAINLESS STEEL 3/8"x1" 1/2" HEXAGONAL
14 8 8
HEAD SCREW ALLEN SCREW HEAD SCREW
6 STICKER
1
2 6/32"X3/8" STAINLESS STEEL
4 ALLEN SCREW
LICENSE PLATE 1
5 6/32" STAINLESS STEEL
4 FLANGE NUT
2
5/16X1" STAINLESS STEEL
2 ALLEN SCREW
1. Place all the kit's elements of your TOYOTA HILUX REAR BUMPER WITH LEDS PT-017, by groups as described
previously, to simplify the installa on process. All the parts required are classified.
2. Remove the original rear bumper of your vehicle. Put aside its spare re carrier.
4.1 Toyota Plaque: Install and place on the bumper using hardware described on Sec on 4. Fully adjust in four
areas.
4.2 VIPER S cker: Install and place on the bumper as shown on Sec on 6.
4.3 LEDS: There are 2 led lights per side, gently place on the bumper using hardware from sec on 2. Fully adjust
from the inside.
4.4 License Plate: Using hardware from sec on 5, install your license plate.
5. Place the bumper bases into the ends of the frame, on both sides le -right. Use hardware from Sec on 1 and fully
ghten on the three areas per side.
6. Proceed to install reinforcement parts to the vehicle frame; we have provided 2 units, use hardware from Sec on 3.
7. Install the rear bumper with the help of a second person and proceed to adjust to vehicle frame/bases, using bolts
and washers from Sec on 1. Do not fully ghten. Align. Repeat both sides.