Professional Documents
Culture Documents
PORTABLE MONITOR
TECHNICAL DATA :
MODEL VAJRA – 322P
After few initial successful test, an authorized person WARNING:Low nozzle elevation angle can cause por-
must be trained to perform the inspection and testing table monitor to slide or lift off the ground, which may
of the monitor. result in injury or death.DO NOT OPERATE THE MONI-
TOR ON THE PORTABLE BASE BELOW THE ELEVATED
The monitor should be always ready for use. To achieve
SAFETY STOP..
this condition, scheduled inspection and maintenance
operation should be performed and recorded in the
WARNING:The monitor when used on the portable
maintenance register book indicating the requirement
base, the nozzle stream must be kept as close to inline
or recommendation. The recommended maintenance
with the anchor strop to maintain the reaction force
procedure must be followed as given in the manual
of the nozzle on the strop. It is possible to slide the
and also as per the local authority having jurisdiction.
Monitor in an arc around the anchor point, but greater
It is recommended to carry out weekly physical the horizontal angle between the strap & the nozzle
inspection of the monitor. The inspection should verify stream, the greater the danger of sliding. ‘Keep the
that no damage has taken place to any component rotation lock locked, when not rotating the Monitor.
and the monitor is ready for use.
WARNING:Incorrect hose layout may cause instabil-
Carry out functional test every month for the flow, ity. Use two hoses and bring both hoses straight back
regular rotation in horizontal and vertical plane for paralleled to each other. Loosely tie the hoses to-
the entire operating angle to observe any leakage. gether 3 meters from the monitor with a hose and
ladder strap, rope etc. as shown in figure 1.
At least once in three months proper greasing through
grease nipple provided on bearing, worm wheel and WARNING:When unit is operating in the portable mode,
worm shaft must be ensured. Each monitor must be do not attempt to move or pick up any part of the
operated with the full flow in accordance to the base or supply hoses.
guidelines of the organisation having local jurisdiction.
CAUTION:
A trained personnel for fire fighting must use the
monitor. Appropriate guidance and training must be
given to reduce the risk of injure. The nozzle must be
fixed to the monitor carefully, mismatched or damaged
threads may cause leakage or uncouple the nozzle
during operation.
6 2
7
13 1
ELEVATION 8 12 9
SIDE VIEW
PART LIST
ITEM NO. DESCRIPTION MATERIAL SPECIFICATION
1 BASE ALUMINIUM *
2 SWIVEL JOINT ALUMINIUM *
3 ELBOW ALUMINIUM *
4 NOZZLE ELBOW ALUMINIUM*
5 WORM SHAFT STAINLESS STEEL
6 HAND WHEEL ALUMINIUM *
7 KNOB BAKELITE
8 COUPLING BRASS
9 LEGS ALUMINIUM *
10 PRESSURE GAUGE 0-16 KG/SQ CM
11 HANDLE GRIP RUBBER
12 SPIKES CARBIDE TIPS
13 LOCK PIN STAINLESS STEEL/BRASS
C-3/6, THE NANDANVAN IND. ESTATE, L.B.S. MARG, THANE 400 604., INDIA.
PHONES : +(91) 22 2583 5434 2582 6958 2582 6793
FAX : +(91) 22 2581 2524 6796 9049
EMAIL : info@hdfire.com WEBSITE : www.hdfire.com