By Gohar Zaman Equipment Tag E-555 Job Title Strength Weld Calculation of E-555 Input Data Tube Outisde dia, do 19.05 mm Nominal tube thickness, t 2.11 mm Allowable stess in tube, Sa 138 Mpa from ASME II-D Table A-1 Allowable stress of material to which tube is welded, St 138 MPa *from ASME II-D Table A-1 Allowable stess in weld, Sw 138 Mpa Lesser of Sa and St Fillet Weld Leg, af 2 mm Groove Weld Leg, ag 0.4 mm Full Strength Weld UW-20.6 (Fillet as per sketch a)
Weld Strength Factor, fw 1 (fw= Sa/Sw)
Ratio of design strength to tube strength, fd 1 1 for full strength weld Minimum required length of fillet weld leg, ar 3.082362931 mm (as per equation 20.6(a) above)
Fillet Weld leg, af 2 mm (as per UW-20.6(a)(1)
Greater of ar or t 3.08236293 mm af< [greater of ar or t], Fillet size NOT OK
Full Strength Weld UW-20.6 (Fillet + Grove as per sketch d) af≠ag
Axial Tube Strength, Ft 15498.19527 N Groove Weld Strength, Fg 2847.91056 N Ratio of design strength to tube strength, fd 1 1 for full strength weld Ratio of fillet weld strength to design strength, ff 0.816242439 Minimum required length of fillet weld leg, ar 2.558305729 mm
Fillet Weld leg, af 2 mm
Groove Weld Leg, ag 0.4 mm Combined weld leg, ac 2.4 mm af + ag ar + ag 2.9583057 mm Greater of (ar + ag) or t 2.95830573 mm ac < [greater of ar + ag or t], Weld size in NOT OK