Professional Documents
Culture Documents
[CLEAR]
*Press [FUNCTION CLEAR] to enter minus (-). (Corrects value)
Procedure 2
[ENTER] [FAX]
[0][5]
[POWER]
(Code) [START] ( Value
displayed ) or
[INTERRUPT] [START]
[POWER]
OFF/ON
(Exit)
(Value unchangeable) (Test copy)
Procedure 3
Procedure 4
[CANCEL]
[START]
[ENTER] [FAX]
[0][5] [Digital key] [START] [Digital key] [START] [Digital key] or [POWER]
[POWER] (Code) (Sub code) *[FUNCTION CLEAR] [INTERRUPT] OFF/ON
[START] (Exit)
(Key in a value) Stores value
[CLEAR]
(Corrects value)
( in RAM ) (Test copy)
[CLEAR]
(Corrects value)
*Press [FUNCTION CLEAR] to enter minus (-).
Procedure 6
[CANCEL]
[ENTER] [FAX]
[0][5] [Digital key] Automatic [POWER]
[POWER] (Code)
[START] ( adjustment ) ( Stores value
in RAM ) [START] OFF/ON
(Exit)
*[CANCEL] or [CLEAR] (Test copy)
Procedure 10
[POWER]
[0][5] [Digital key] [Digital key] Value
[POWER] (Code)
[START]
(Sub code)
[START] ( displayed ) [START] OFF/ON
(Exit)
[SET] or [INTERRUPT]
(Value unchangeable)
Procedure 17
[CANCEL] or [CLEAR]
[ENTER] [FAX]
( )
[0][5] [Digital key] [UP] [POWER]
[POWER] (Code)
[START]
( Automatic
adjustment ) or
or
[INTERRUPT] [STAR T]
OFF/ON
[DOWN] (Exit)
Manual
(Adjust a value) (Stores value
in RAM )
(Test copy)
adjustment
[UP] [ENTER]
or or
[DOWN] [INTERRUPT]
(Adjust a value)
[CANCEL] or [CLEAR] (Stores value
in RAM )
* When the “storing is not performed within 2 minutes after pressing the [START] button at the
manual adjustment, the “automatic adjustment” starts automatically.
Note:
The fuser roller temperature control at the adjustment mode is different from that at the normal
state.
Therefore, the problem of fusing efficiency may be occurred in the test copy at the adjustment
mode. In that case, turn ON the power normally, leave the equipment for approx. 3 minutes after
it has become ready state and then start up the adjustment mode again.