Professional Documents
Culture Documents
Check (√ ) Yes or No
6 Place the patient in supine position, lower side rails for easier access
7 Spike IV solution, prime the drip chamber of the tubing and clamp it
Increase the pressure in pressure bag by pumping until the green line is visible and
turn the stopcock off to the bag
8 Fix the transducer to the IV pole such that it is zeroed at the ‘X’ mark
9 Position the zero point of the transducer, it should be on the level with the patient
right atrium (phlebostatic axis)
10 Mark the phlebostatic axis using waterproof ink
12 Connect the IV fluid to a three-way stopcock and flush the other two ports and
connect the stopcock
14 Connect the CVP tubing from the client to the second side port of the stopcock
16 Turn stopcock off to client and open the port in the transducer for zeoring
17 Select zeroing in the monitor, and put the stopcock off to the port
SL. PROCEDURE STEPS YES NO COMMENTS
NO
18 Note the wave pattern of CVP and record the pressure.
19 Label the IV tubing and flush solution with the date and time they were first
used with nurse’s initials
20 Document the findings on nursing assessment sheet.
Date