Professional Documents
Culture Documents
Description
June 2013, Revision A Exhibit “A”
Beginning with Serial # 2001
S P E C I F I C AT I O N A N D D E S C R I P T I O N
EXHIBIT “A”
JUNE 2013
BEGINNING WITH SERIAL # 2001
REVISION A
INTRODUCTION
This document is published for the purpose of providing shall govern. Due to the time span between the date of
general information for the evaluation of design, perfor- -
mance and equipment of the TTx Model T240. Should livery date of the aircraft, Cessna reserves the right to
more information be required, please contact: -
uct improvements, government regulations or other good
Cessna Aircraft Company cause.
Single Engine Piston Aircraft
P.O. Box 7706
Wichita, Kansas 67277-7706
1-800-4-CESSNA
www.se.cessna.com
1
June 2013, Revision A
TA B L E O F C O N T E N T S
Section Page
1. General Description .......................................................................................................................... 3
3
1.2 Approximate Dimensions ...................................................................................................... 3
1.3 Design Weights and Capacities ........................................................................................... 6
2. Performance ..................................................................................................................................... 7
3. Powerplant & Accessories ................................................................................................................ 7
4. TTx Equipment List ........................................................................................................................... 8
5. Instrument Panel ............................................................................................................................... 9
6. Electrical Power ................................................................................................................................ 10
7. Engine Indicating System ................................................................................................................. 10
8. Environmental ................................................................................................................................... 10
9. Exterior .............................................................................................................................................. 10
10. Exterior Lights ................................................................................................................................... 10
11. Flight Controls ................................................................................................................................... 11
12. Fuel System ...................................................................................................................................... 11
13. Interior ............................................................................................................................................... 11
14. Interior Lighting .................................................................................................................................. 12
15. Exterior Striping Options .................................................................................................................... 12
16. Training ............................................................................................................................................. 12
17. Limited Warranties ............................................................................................................................ 13
17.1 Cessna’s Limited Warranty - Single Engine Piston Aircraft .................................................. 13
17.2 Aircraft Paint and Graphics - Single Engine Piston Aircraft .................................................. 13
17.3 Continental Motors - Premium Engine Warranty .................................................................. 14
17.4 Hartzell Propeller Inc. Limited Warranty ................................................................................15
17.5 Garmin Avionics - Limited Warranty ...................................................................................... 16
2
June 2013, Revision A
1. GENERAL DESCRIPTION
All information herein applies to the TTx Model T240.
The TTx Model T240 is a pre-molded, composite built,
semi-monocoque, four seat, single engine, low wing, tri-
cycle design airplane. Suitable allowance for luggage is
provided.
Wing
35 ft 10 in (10.92 m)
Span (overall) ................................................................................................................................
Area ...................................................................................................................................141.2 sq ft (13.1 sq m)
Cabin
Height (max) ................................................................................................................................49 in (124.5 cm)
Width (max) ................................................................................................................................. 49 in (124.5 cm)
140 in (354.6 cm)
Cabin Door
Minimum Entry Width .................................................................................................................... 33 in (83.8 cm)
Minimum Entry Height ................................................................................................................... 33 in (83.8 cm)
Maximum Entry Clearance .......................................................................................................... 46 in (116.8 cm)
Baggage Compartment
Maximum Baggage Compartment Width ...................................................................................... 39 in (97.8 cm)
Maximum Baggage Compartment Length .......................................................... 52 in (132 cm) (Including Shelf)
Maximum Baggage Compartment Height ..................................................................................... 35 in (87.6 cm)
Maximum Baggage Entry Width ........................................................... 28 in (71.1 cm) (Diagonal Measurement)
3
June 2013, Revision A
Firewall
(124.5 CM)
(87.6 CM)
Baggage Shelf
(354.6 CM)
Firewall
(124.5 cm)
Baggage
(97.8 cm) Shelf
(71.1cm)
5
June 2013, Revision A
Fuel Capacity
Total Capacity ................................................................................................................................106 gal (401 L)
6
June 2013, Revision A
2. PERFORMANCE
All estimated performance data are based on airplane weights at 3,600 pounds; standard atmospheric conditions;
-
formance.
Maximum Cruise Speed (85% at 25,0000 ft) ...................................................................................... 235 kts / 270 mph
Economy Cruise Speed (55% at 25,0000 ft) ....................................................................................... 208 kts / 239 mph
Landing Distance Ground Roll (S.L., at Max Landing Weight 3,420 lbs) ..............................................................1,250 ft
Landing Distance To Clear 50 ft. Obstacle (S.L., at Max Landing Weight 3,420 lbs) ........................................... 2,600 ft
7
June 2013, Revision A
8
June 2013, Revision A
5 . I N S T R U M E N TAT I O N
11 12
13
10 14
15
16
6 5
4
17
7
3 18
2
19
20
9
June 2013, Revision A
6. ELECTRICAL POWER
Belt Driven Alternator, 28 Volts, 70 amps rated Overhead Master Switch Panel
Gear Driven Alternator, 28 Volts, 70 amps rated Dual 12 Volt, 2 amp Auxiliary Power Outlets
Dual 28 Volt, 8.5 AH Batteries External Ground Power Plug
Dual Voltage Regulators, 28 Volt
Cross-Tie ability during alternator failure
Cold Weather starting ability with either Battery or
both Batteries
Battery Charging Circuit
Digital Display of the Battery amps, Alternator amps,
and BUS voltages on MFD
7 . E N G I N E I N D I C AT I N G S Y S T E M
Ammeter LH/RH Fuel Quantity
Voltmeter CHT - Cylinder Head Temperature (6)
Manifold Pressure EGT - Exhaust Gas Temperature (6)
Oil Pressure and Temperature TIT - Turbo Inlet Temperature (2)
Tachometer - Hour Recorder Annunciation – Caution and Warning Alerts (PFD)
Fuel Flow (GPH)
Cruise % Power
8 . E N V I R O N M E N TA L
Integrated Automatic Climate Control System Floor Vent System
(ACCS) Defrosting System
Built in Oxygen (4 Places)
Individual Eyeball Vents CO Detector/Pulse Oximeter
9. EXTERIOR
Fiberglass and Honeycomb Structure Tube Type Tires
LH and RH Gull Wing Style Doors w/Lock and Key
Remote Keyless Entry with Automatic Light System
Pneumatic Door Seal System Static Wicks (9)
LH Cargo Door, w/Lock and Key Emergency Exterior Door Release
Fixed Landing Gear w/castering Nose Wheel Rear Tinted Passenger Windows
Lighted Entrance Step
Entry Assist and Exit Handles
Main Gear Fairings
Nose Gear and Strut Fairings
Tie Down Rings, LH/RH Wing & Tail
10
June 2013, Revision A
13. INTERIOR
Intuitive design, comfortable seating and quality
leathers. Four distinct, attractive interior selections
available.
Air Conditioned, Controllable Air Vents (6)
Reclining Front Sport Seats
Rear Seat and Seatback Cushion
Pilot’s and Copilot’s Three Point Restraint System
Rear Seat Passengers Three Point Restraint Sys-
tem
Baggage Tie Downs and Restraining Net
Fire Extinguisher and Mounting Bracket
Pilot’s Check List
Pilot’s Operating Handbook
Instrument Panel Glareshield
Rosen Sun Visors
Center Console Storage Area
Radio Call Plate
Console Headset Hanger
Rear Passenger Entry/Exit Assist Strap
Pilot and Copilot Cupholders
Aux Audio Input
Headset with Microphone (1)
11
June 2013, Revision A
16. TRAINING
Cessna will offer one TTx Intrinzic training course at
no additional charge and one TTx Intrinzic ground
school course for a second person at no additional
charge, with purchase of a new aircraft. This offer is
valid for 12 months after aircraft delivery.
12
June 2013, Revision A
13
June 2013, Revision A
should be avoided to prevent damage to the paint sur- activation date CMI will, except as excluded below, at
face. its option repair or replace on an exchange basis any
engine, component or part manufactured or supplied by
Normal paint maintenance will include but is not limited it which within the applicable sixty (60) month or TBO
to; touchup of abrasion and wear of the paint on screws period is returned to a CMI representative authorized to
heads, around access panels, wing leading edges, ver- handle the engine covered by this warranty and which
tical and horizontal stabilizer leading edges, windshield upon examination is found to the satisfaction of CMI to
retainers and other leading edge surfaces including parts be defective in material or workmanship. The warranty
on the landing gear subject to damage or erosion from activation date is the aircraft in-service date or the 180th
airborne particles. Proper maintenance includes keep-
ing surfaces clean, polished, and touching up chipped or
eroded areas to prevent further damage and corrosion. applicable sixty (60) month period described above, CMI
will not assume any responsibility for the repair or re-
Paint and graphics warranty applies only to defects in
placement of the starter or alternators, which have been
material and workmanship for a period of one (1) year
purchased by CMI from a manufacturer as a complete
from the Warranty Start Date. Deterioration of paint and
-
graphics due to normal wear, exposure, or improper care
gine without altering the unit. After the expiration of the
is not covered by the warranty. If proper paint mainte-
initial twenty-four (24) month period, accessories will be
nance procedures have been followed and paint peeling,
subject to such warranty coverage as may be provided
blistering or cracking is evident in areas other than im-
by their manufacturer.
mediate leading edge surfaces, warranty consideration
may be requested thorough a Cessna Service Station. (b) CMI will pay for reasonable labor costs associated
with repairs or replacements under paragraph 1(a) of
to a limited surface area. Workmanship or material de- with identifying the need for such repairs or replace-
ments, when coordinated through an authorized CMI
that were improperly prepared prior to paint application, representative. The amount of repair and replacement
or to areas where the paint or subsurface primer has labor costs allowed will be in accordance with the latest
been improperly applied. revision of the warranty labor allowance schedule, form
X30552, published by CMI. The amount of “troubleshoot-
Complete strip and repaint of an entire airplane can
ONLY be authorized if there is evidence of paint defects circumstances of identifying the need for such repairs or
on several major surface areas of the aircraft. Contact
your Cessna Field Service Engineer concerning paint
defects on any major surface of an aircraft. costs associated with such repairs or replacements al-
14
June 2013, Revision A
“Internal combustion engine, other than Radial Cyl RVNX non-calibrated engine gauges, improper fuel system ad-
- justment, non-CMI approved fuel and oil grades or addi-
nents or parts will be the actual surface freight charge tives or installation of parts, components or accessories
for shipment of the component or part or the currently that alter the engine’s original type design.
published UPS surface rate schedule, whichever is less. 8. The provisions of this warranty do not apply to normal
2. CMI reserves the right at its option to replace any de- maintenance service (such as engine tune-ups, adjust-
fective engine or part with either a new or rebuilt engine ments, inspections, engine or component overhaul re-
or part sulting from time between overhaul (TBO) recommenda-
3. Repair or replacement of any engine or part under this tions, etc.) or to the replacement of normal service items
warranty will not extend the period of warranty coverage
set forth above. 9. CMI reserves the right to change any engine or part
4. This warranty applies only to engines in which parts -
manufactured or supplied by CMI or parts manufac- bility with regard to engines or parts previously sold or
tured pursuant to an FAA Parts Manufacturer Approval replaced.
have been used and nothing contained herein should be 10. THIS WARRANTY IS A WARRANTY TO REPAIR
construed as a warranty by CMI of any engine or part OR REPLACE AND NOT A WARRANTY OF THE CON-
not manufactured or supplied by CMI. CMI accepts no DITION OR FUTURE PERFORMANCE OF THE PROD-
responsibility for the failure of any engine or part which UCTS WHICH IT COVERS. THERE ARE NO OTHER
it does not manufacture or supply or damage resulting WARRANTIES, EXPRESSED OR IMPLIED, SPECIFI-
from such failure. CALLY, BUT WITHOUT LIMITATION, THERE ARE
5. This warranty applies only to engines which have been NO IMPLIED WARRANTIES OF MERCHANTABILITY
installed by the Original Equipment Manufacturer on a OR FITNESS FOR A PARTICULAR PURPOSE. IN NO
newly manufactured aircraft and have been inspected EVENT WILL CMI BE RESPONSIBLE FOR ANY INCI-
and maintained after original delivery in accordance with DENTAL OR CONSEQUENTIAL DAMAGES ARISING
the instructions for continued airworthiness, including OUT OF ANY DEFECT IN ANY ENGINE OR PART,
compliance with all applicable service bulletins issued ARISING OUT OF THE FAILURE OF ANY ENGINE OR
by CMI, the aircraft manufacturer or any accessory or PART TO OPERATE PROPERLY, OR ARISING OUT
component manufacturer. Performance of recommend- OF ANY BREACH OF THE WARRANTY MADE HERE-
ed inspections and maintenance must be documented IN. NO PERSON IS AUTHORIZED TO GIVE ANY OTH-
by appropriate logbook entries and the logbook must ac- ER WARRANTY OR TO ASSUME ANY ADDITIONAL
company any engine being returned for warranty consid- OBLIGATION OR LIABILITY ON BEHALF OF CMI.
eration.
6. This warranty does not apply to any engine, compo- 17.4 Hartzell Propeller Inc. Limited Warranty
nent or part manufactured or supplied by CMI which (1)
has been subject to misuse, neglect or accident; (2) has
been installed, repaired, maintained or altered in any components thereof, including those returned for ex-
way that in the judgment of CMI has adversely affect- change. Seller expressly warrants that all Products and
ed the condition of the engine; (3) has been operated services furnished hereunder shall (1) conform to all spec-
inconsistent with CMI and aircraft manufacturer recom-
mendations and limitations (such as, but not limited to and to all other requirements of this purchase order; (2)
be free from defects in material and workmanship of nor-
and proper system adjustment) or (4) has been changed
operating hours or a period of one (1) year from the date
7. CMI will not be responsible for repair or replacement of
any engine, component or part damaged or worn as a re- extent such Products are not manufactured pursuant to
sult of corrosion, pre-ignition/detonation, operation with detailed designs of Buyer, be free from defects in design;
(3) be free of operational or functional problems caused
15
June 2013, Revision A
by computer software, processes or systems; and (4) be IN NO EVENT SHALL GARMIN BE LIABLE FOR ANY
free from defects in title and any claims of any third par- INCIDENTAL, SPECIAL, INDIRECT OR CONSEQUEN-
ties. Such warranties, shall survive inspection, test, ac- TIAL DAMAGES, WHETHER RESULTING FROM THE
ceptance of, and payment for the Products and shall run USE, MISUSE OR INABILITY TO USE THIS PRODUCT
to Buyer, its successors, assigns, customers at any tier, OR FROM DEFECTS IN THE PRODUCT. Some states
and all end users. In the event the Products are de- do not allow the exclusion of incidental or consequential
fective and/or nonconforming, Buyer shall so notify damages, so the above limitations may not apply to you.
Seller in writing with Seller’s Warranty Claim Form GARMIN retains the exclusive right to repair or replace
and Seller shall give instructions prior to returning the product or offer a full refund of the purchase price at
any Products, and at Seller’s discretion, return the its sole discretion. SUCH REMEDY SHALL BE YOUR
defective/non-conforming Products to Seller. The re- SOLE AND EXCLUSIVE REMEDY FOR ANY BREACH
turn to Seller of any defective or non-conforming Prod- OF WARRANTY.
ucts and delivery to Buyer of any corrected or replaced
Products shall be at Seller’s expense. Products, which
have been rejected or required to be corrected, shall not To obtain warranty service, contact your local GARMIN
thereafter be tendered for acceptance unless the former authorized Service Center. For assistance in locating a
rejection or correction requirement is disclosed in writing. Service Center near you, call GARMIN Customer Ser-
vice at one of the numbers shown below.
shall survive the cancellation, termination, or completion
of any Orders. The terms of this limited warranty are not
intended to control third party claims against Buyer.
GARMIN International
1200 East 151st Street
17.5 Garmin Avionics - Limited Warranty
Olathe, Kansas 66062, U.S.A.
Aircraft OEM-Installed Avionics 2-Year Limited War- Toll free: 1-800-800-1020
ranty Policy
Phone: 1-913-397-8200
This GARMIN Product is warranted to be free from de- FAX: 1-913-397-0836
fects in materials or workmanship for two years from the
date of warranty activation. Within this period, GARMIN
International, Inc. will at its sole option, repair or replace GARMIN (Europe) Ltd.
any components which fail in normal use. Such repairs Unit 5, The Quadrangle
or replacement will be made at no charge to the cus-
tomer for parts or labor, provided that the customer shall Abbey Park Industrial Estate
be responsible for any transportation cost. This warranty Romsey, SO51 9AQ, U.K.
does not cover failures due to abuse, misuse, accident or Phone: 44-1794-519944
unauthorized alteration or repairs.
FAX: 44-1794-519222
THE WARRANTIES AND REMEDIES CONTAINED
HEREIN ARE EXCLUSIVE AND IN LIEU OF ALL OTH- Visit our web site at: www.garmin.com
ER WARRANTIES EXPRESS OR IMPLIED OR STATU-
TORY, INCLUDING ANY LIABILITY ARISING UNDER
ANY WARRANTY OF MERCHANTABILITY OR FIT-
NESS FOR A PARTICULAR PURPOSE, STATUTO-
RY OR OTHERWISE. THIS WARRANTY GIVES YOU
SPECIFIC LEGAL RIGHTS, WHICH MAY VARY FROM
STATE TO STATE.
16
Cessna Single Engine Piston Aircraft, 2625 S. Hoover Rd, Wichita, Kansas 67215, Telefax 316-517-2772