Professional Documents
Culture Documents
Home
New
Top
Sitemap
Contacts
Search
General maintenance
1. General notes
a. check that the coolant level is between the ”full” and ”low” lines on the see–through
reservoir.
a. check that the front of the radiator is clean and free of leaves, dirt and bugs.
b. check the hoses for cracks, kinks, rotting loose connections.
a. by rocking the vehicle, check that the electrolyte level of all the battery cells is between
the upper and lower lines on the case.
a. check that the brake fluid levels are near the upper level line on the see–through
reservoirs.
a. check the drive belt for fraying, cracks, wear and oiliness.
a. check if the level of engine oil is between ”f” and ”l” on the dipstick with the engine
turned off.
Hint
: after extended driving under harsh conditions (high speeds, hot weather, heavy traffic or pulling
a trailer), let the engine cool down for approximately 30 minutes before checking the fluid level.
a. check for unusual exhaust sounds or abnormal exhaust fumes. Locate the cause and
correct it.
Inside vehicle Engine
General maintenance Performing On–vehicle inspection Hint: inspect
these maintenance checks on the vehicle these items on a cooled down engine. 1.
in the owner’s responsibility. The owner Inspect drive belt 2. Replace spark plugs 3.
may perform the maintenance or take the Inspect air filter Remove the air filter.
vehicle to a service center. Check the pa ... visually check ...
Other materials:
Replacement
1. Remove front door scuff plate rh Using a screwdriver, remove the front door scuff plate rh.
Hint: tape the screwdriver tip before use. Remove front door scuff plate lh Remove rear door
scuff plate rh Using a screwdriver, remove the rear door scuff plate rh. Hint: tap ...
Overhaul
1. Remove manual transmission filler plug Remove the manual transmission filler plug and
gasket from the manual transmission case. 2. Remove drain (mtm) plug sub–assy Remove the
drain (mtm) plug sub–assy and gasket from the manual transmission case. 3. Remove
speedometer se ...
Inspection procedure
1 Inspect transmission wire(sl) Disconnect the transmission wire connector from the transaxle.
measure the resistance according to the value(s) in the table below. Standard: 2 Check harness
and connector(transmission wire – ecm) Connect the transmission wire con ...