Professional Documents
Culture Documents
Note: Review Machine & S·O·S History and check for Active Service Letters prior to inspection.
Is PL activated?
Is PL functioning properly?
1.8
1.9
1.10
2.2 Fenders
2.18
2.19
2.20
3.7
3.8
3.9
4.8 Turbocharger
4.12
4.13
4.14
5.8 Stabilizers
5.18
5.19
5.20
Guidelines:
Wiring Harness Inspection Guidelines
Check for tubes, hoses, and wiring harnesses rubbing against:
One another
Sharp corners
Bolt heads
Check for tubes, hoses, and wiring harness not properly secured:
Missing clips and/or wire ties
P-clips not attached
1. Inspection Preparation:
2 Lower-Level Inspections:
3 Middle-Level Inspections:
4 Upper-Level Inspections:
5 Implement/Attachment Inspections:
ction procedure)
the following:
he final drive housing
or to the exhaust pipe which would indicate:
ck would indicate:
Lower - 2.8
Sec
*Status Description Units Observed Min. Time Max. Time Comments
Loader Circuit on Parallel Lift Machines
Bucket Dump - -
Regenerative Dump - -
Opening Bucket - -
Closing Bucket - -
Lower - -
- Backhoe Circuit
Stabilizer Up Sec - -
2.1.3 Ride Control Test - - See Ride Control Test in Tables tab.
2.1.6 Brake System Test (Test from OMM) - - See Service Brake Test in Tables tab.
2.1.7 Parking Brake Check (Test from OMM) - - See Parking Brake Test in Tables tab.
Ride Control - Test
Note: Stay clear of the machine when you are performing this test.
1. Start the engine. Keep the direction control lever in the NEUTRAL position. Keep the parking brake engaged.
2. Lower the stabilizers in order to raise the machine to 305 mm to 455 mm (12 inch to 18 inch).
3. Lower the bucket in order to raise the machine to 305 mm to 455 mm (12 inch to 18 inch).
5. The machine must not lower to the ground. If the machine lowers to the ground, then the following condition is
parking brake engaged. 2. Apply the service brake. Release the parking brake.
4. Gradually increase the engine speed to high idle. The machine should not m
5. Reduce the engine speed to low idle. Move the transmission to NEUTRAL
ground. Stop the engine.
The machine should not move. Note: The parking brake indicator light shou
ansmission to NEUTRAL. Engage the parking brake. Lower the bucket to the 4. Gradually increase the engine speed to hi
ake Holding Ability Test
. Raise the bucket slightly.
mission control lever to THIRD SPEED FORWARD, then to NEUTRAL, then back to THIRD SPEED FORWARD.
brake indicator light should come on and the parking brake alarm should sound.
se the engine speed to high idle. The machine should not move.