Professional Documents
Culture Documents
{First of all, read the instructions given at the end of this document carefully. Delete all red text in the final report.}
Sample Material Grade Cross Section Side Length/ Section Length of Test
No. Type Diameter Thickness Sample
(mm/inch) (mm/inch) (mm/inch)
1 AISI 1018 circular 1.6 360
Mention the name of laboratory and full address where the material testing was performed.
Yield strength
Ultimate Tensile Strength
% Elongation etc.
4. TEST METHOD:
5. DATE OF TESTING:
6. RESULTS:
NAME NAME
ANNEXURE-1
NAME NAME
Annexure-1 (continued)
3. GRAPHS RECORDED DURING TESTING OF SAMPLE-1:
NAME NAME
Annexure-1 (continued)
4. SETUP FOR TESTING OF SAMPLE-2:
NAME NAME
Annexure-1 (continued)
6. GRAPHS RECORDED DURING TESTING OF SAMPLE-2:
NAME NAME
ANNEXURE-2
Include the copy of test report from external laboratory (if applicable). Include only 1 page of report on each page of this
document. All items should be legible.
NAME NAME
ANNEXURE-2 (CONTINUED)
Add more pages if required.
NAME NAME
Guidelines
1. The document must be prepared in this template
only. Change in format (header/footer/sequence)
will not be accepted. Any heading cannot be
omitted.
2. Document size should not exceed 5MB, whereas
number of pages is not restricted.
3. This format is a 97-9003 word template. Document
must be saved as Team ID_Team Name_Material
Testing Report as a separate ‘.pdf’ file.
4. The file must be sent to efficycle.reports@icat.in
before 12th September, 2018 05:00pm. Mail subject
name must be Team ID_Team Name_Material
Testing Report.
5. Mails not sent with proper subject name or proper
file name, as given above, will be summarily reject
without any prior intimation and it will be considered
as non-submission of document.
6. No request for deadlines extension shall be
considered.
7. The font must be “Helvetica”, black, 10 size.
8. All pages have the all details filled with signatures
as required in signature box at the bottom of each
page.
NAME NAME