Professional Documents
Culture Documents
Miniature Electret
25 m m
Condenser
(0.99 in.)
Omnidirectional
10.5 m m
(0.41 in.) Microphone
• Microphone capsule measures
less than 1 inch in length
• Durable 10-foot miniature cable
provides excellent flex life
• Dual-power configuration (both
phantom and/or battery) insures
against signal loss
use and superior emi/rfi attenuation. The phantom power. The connecting cable used
Description
CO100 may be powered by either an inter- should be standard two-conductor shielded
The CO100 is a miniature, omnidirectional nal 1.5-volt AAA alkaline battery or exter- type; the shield is used as ground return and
back-electret lavalier microphone designed nal 9- to 52-volt phantom power. If desired, must be connected properly to avoid electri-
specifically for broadcast and sound rein- the CO100 can be operated in a dual mode cal noise.
forcement applications where acoustic feed- employing both battery and phantom power.
Battery
back problems are minimal. (The EV CS200 The advantage of this configuration is the
unidirectional lavalier microphone is de- insurance against loss of signal should the Because the current drain on the battery is
signed for live sound applications where phantom voltage fail. When phantom volt- so small (approximately 150 microamps) the
feedback is a problem.) The frequency re- age is present, the battery is deactivated; battery may be left on continuously with a
sponse of the CO100 microphone provides however, should the phantom voltage fail, useful life expectancy of approximately
a full-range, well-balanced sound character the battery will automatically power the elec- 1000 hours. The battery may remain within
for clean and accurate sound reproduction. tronics module. The AAA alkaline battery the electronics module when phantom power
The microphone’s omnidirectional polar will power the microphone for a minimum is used.
characteristic provides a uniform output re- of 1000 hours.
gardless of the direction of the sound. The Battery Replacement Guide
Operation
CO100 is designed to attach to the per- Duracell MN2400
former’s clothing using the supplied tie clasp To operate the CO100 by the simplest Eveready E92
or the optional 390 dual-microphone tie method, internal battery power, first open the Bright Star 7526
clasp. Supplied with each microphone is a battery compartment by turning the sleeve Burgess B24A
foam wind or pop screen to reduce unwanted Ray-O-Vac 824
counterclockwise. Insert the AAA-size bat-
Panasonic AM4
breath and wind noise. The microphone ele- tery into the battery compartment, checking
ment is attached to the electronics module Varta 4003
for correct polarity (see Figure 3). Close the
by a 3.1-meter (10-foot) length of black, compartment by turning the sleeve clock- Architects’ and Engineers’
durable miniature cable. wise. Be sure to screw the sleeve firmly to Specifications
avoid mechanical noise.
Powering the CO100 The microphone shall be a miniature, back-
To operate the CO100 by phantom power:
The battery/electronics module is con- electret condenser with an omnidirectional
using high-quality balanced cable with XLR
structed of steel tubing to form an extremely polar pattern. The microphone shall be used
connectors, connect the electronics module
durable housing assembly for long reliable to the mixer input which is providing the
shall be 2.0 mV/pascal. The microphone of the product; or (e) malfunction occurring cause for two (2) years from the date of origi-
capsule shall be made of brass; the electron- at any time after repairs have been made to nal purchase. In addition, the Limited War-
ics module shall be made of steel. The mi- the product by anyone other than EVI Audio ranty for the acoustic system contained in
crophone shall be permanently connected to Service or any of its authorized service repre- these microphones shall apply for the life of
its electronics module with a 3.1-m (10-ft) sentatives. Obtaining Warranty Service: To the product, defined as a period of ten (10)
length of rugged, two-conductor, shielded, obtain warranty service, a customer must years from the date that the manufacture of
miniature audio cable. The microphone shall deliver the product, prepaid, to EVI Audio the specific microphone has been discontin-
be supplied with a windscreen, tie clasp and Service or any of its authorized service rep- ued. Any and all active electronics incorpo-
storage pouch. The CO100 is specified. resentatives together with proof of purchase rated in these microphones are guaranteed
of the product in the form of a bill of sale or against malfunction due to defects in mate-
Limited Warranty
receipted invoice. A list of authorized ser- rials or workmanship for a period of three
Electro-Voice products are guaranteed vice representatives is available from (3) years from the date of original purchase.
against malfunction due to defects in mate- EVI Audio Service at 600 Cecil Street, The Limited Warranty does not extend to
rials or workmanship for a specified period, Buchanan, MI 49107 (800/234-6831 or FAX cables, cable connectors, or switches. Addi-
as noted in the individual product-line 616/695-4743). Incidental and Conse- tional details are included in the Uniform
statement(s) below, or in the individual prod- quential Damages Excluded: Product re- Limited Warranty statement.
uct data sheet or owner’s manual, beginning pair or replacement and return to the cus- For warranty repair or service informa-
with the date of original purchase. If such tomer are the only remedies provided to the tion, contact the service repair department
malfunction occurs during the specified pe- customer. Electro-Voice shall not be liable at: 616/695-6831 or 800/685-2606.
riod, the product will be repaired or replaced for any incidental or consequential damages
For technical assistance, contact Technical
(at our option) without charge. The product including, without limitation, injury to per-
Support at 800/234-6831 or 616/695-6831,
will be returned to the customer prepaid. Ex- sons or property or loss of use. Some states
M-F, 8:00 a.m. to 5:00 p.m. Eastern Stan-
clusions and Limitations: The Limited do not allow the exclusion or limitation of
dard Time.
Warranty does not apply to: (a) exterior fin- incidental or consequential damages so the
above limitation or exclusion may not apply Specifications subject to change without
ish or appearance; (b) certain specific items
to you. Other Rights: This warranty gives notice.
described in the individual product-line
statement(s) below, or in the individual prod-
10.5 m m
(0.41 in.)
127 m m
(5.00 in.)
-
Figure 3—Battery Compartment
+
0
Figure 4—Polar Response 330
o
30
o
o o
300 60
90
o
270
o o
240 120
o o
CO 100E
Figure 5—CO100E Schematic
FE T AM P PO W ER M O DULE
CABLE
W HITE BROW N
TRANSDUCER +
-
1.5V RED
2
AAA
SHIELD BLACK
1
CO 100
SHIELD E
R= B-3.7
A .00025
CO100 Miniature Electret Condenser Omnidirectional Microphone
WHITE
RED 6.8k
SHIELD E
R= B-3.7
B .00025
TO NEG 5 TO
30 VOLTS DC