Professional Documents
Culture Documents
ENGINEERING
LAB REPORT # 9
DE-42 EE-A
Page | 1
EXPERIMENT NO – 09
Analysis of Active Band Pass Filter using R, C & OP AMP
OBJECTIVE:
To study the response of Active RC Band Pass Filter
THEORY:
Band pass filter is a combination of both low pass filter and high pass filter. The name of the filter
itself indicates that it allows only a certain band of frequencies and blocks all the remaining frequencies
Active Band pass filter is obtained by cascading active high pass and active low pass filters. This
arrangement will provide a selective filter which passes only certain frequencies.
Active Active
HPF LPF
So by cascading Active RC High Pass Filter with active RC Low Pass Filter we can have RC Active Band
Pass Filter.
Design Parametrs:
Band Width = 1 KHz
fL= 4000 Hz fH=
5000 Hz
Pass band gain High Pass Filter Av1= 2
Pass band gain Low Pass Filter Av2 = 2 Formulae
To Be Utilized:
=
Av1= +
Av2= +
APPARATUS:
(1) Function Generator
(2) Digital Multimeter
(3) Resistors
(4) Capacitor
(5) Op-amp (LM353 or LM 741)
(6) Breadboard
(7) Connecting Wires
Page | 2
FIGURE:
PROCEDURE:
- Determine the component values and construct the circuit bread board as shown in the
figure above
- Apply DC voltage of +10V to +Vcc / A+ and -10V to -Vcc/ A- - Apply the sinosoidal
input voltage from function generator.
- Alter the frequency and measure corresponding gain.
- Obtain Gain vs Frequency curve
- Perform Error Analysis
Page | 3
OBSERVATIONS:
Page | 4
Page | 5
Page | 6
Page | 7
Page | 8
Page | 9
Page | 10
Graph (Gain vs. Frequency):
0.8
0.6
0.4
0.2
0
0 5000 10000 15000 20000 25000 30000 35000 40000 45000
Frequency
Page | 11
Lower Cut-Off Frequency (measured) = __________4.28141 K Hz____________
Higher Cut-Off Frequency (measured) = ___________13.0370 KHz_____________
Error Analysis = ___________6.878%____________
Page | 12