Professional Documents
Culture Documents
Previous Screen
Product: WHEEL LOADER
Model: 926 WHEEL LOADER 94Z
Configuration: 926E WHEEL LOADER 94Z02209-UP (MACHINE) POWERED BY 3204 ENGINE
Camshaft Bearings
SMCS - 1211-011; 1211-012
START BY:
a. remove camshaft
NOTE: The camshaft bearings may be pulled toward the inside or the outside of the cylinder block
for removal.
NOTICE
Install the camshaft bearings with the oil hole in the bearing in
alignment with the oil hole in the block and with the joint of the
bearing above a horizontal center line through the bore of the bearing.
1. Install the camshaft bearings in the cylinder block with tools (A) and (B) as follows:
a. Install the center bearing to a depth of 287.5 ± 0.8 mm (11.32 ± .03 in.) [Dimension (A)] from the
front surface of the block.
b. Install the rear bearing to a depth of 556.8 ± 0.08 mm (21.92 ± .03 in.) [Dimension (B)] from the
front surface of the block.
c. Install the front bearing even (flush) with the front surface of the block and no more than 0.5 mm
(.02 in.) [Dimension (C)] deep.
END BY:
c. install camshaft
Copyright 1993 - 2020 Caterpillar Inc. Sun Sep 13 16:26:19 UTC+0700 2020
All Rights Reserved.
Private Network For SIS Licensees.