Professional Documents
Culture Documents
De: HV Marketing
Date: 27/04/01
Please find here after some explanations and copies of screens extracted from
MiCOM Zgraph.
After having opened the connection to the device (same front panel serial port &
cable as S1),the settings from the relay could be extracted and displayed :
1°) Open the connection to the relay :Device\open connection\Address1 OK
ANNEX :
Possibility to create (« utils\.set to rio ») & modify the settings in a RIO file which
could be replayed by a CMC test device.
A file opened and modified with Zgraph could be saved again :
1 – When you are connected to the relay ,you can change the settings and load it
again in the protection ; a save file couldn’t be created in that case (when the
connection is opened ,the file in the explorer couldn’t be used)
2 – When a file is opened from the disk,then settings could be modified and saved
in a new created file.But in that part of the soft there is no access to the relay
communication.
The 2 applications are split and separated (it is an exclusive choice).It is due to the
structure of the program.