Professional Documents
Culture Documents
T.Thrylbkya
ENGINEERING GRAPHICS UNIT-I
CYCLOIDS
General cycloid
DIfferential cyclofd
Epi cycloid Hypo cyclod
Cycloi d cuyve
Shaighl Poth
Ta Co 2TIY
Rolling civele
DIYecti ng ciyce
366
TRadus of
Yollng cce
eRoellus o" dhecling c cle
Hypo cycoid: The Yollin9oCYcle olls nstde Of the
Roll n Cicle
dtrecting chcle
Diy eclin9
PAGE NO-33
civcle
360
Hypo-uclodiak Rodlus of solling chce
CU YVEe
coclus of decling etvole
Thnyloky
UNIT-I
ENGINEERING GRAPHICS
)Gieneral cycloid
to the
diameter.draw a normal and tangent
1.construct a cycloid having a rolling circle of 50mm
Curve at a point 35mm above the base line
PAGE NO-34
20A AOSI
20 A IAOS
Thryookya
ENGINEERING GRAPHICS UNIT-I
2.construct a cycloid having a rolling circle of 40mm diameter.draw a normal and tangent to the
Curve at a point 30mm above the base line.
9
DA z
-r
PAGE NO-3S
20A IAoS8
JThylokya
Epi cycloid
1.A circle of 50mm diameter rolls on the circumference ofanother circle of 175mn dhameter
and outside it.trace the locus of a point on the circumference of the rolling circlefor one
complete revolution.also draw a set of tangentand normal to the curve ata disthhce of90 mm
from the center of the directing circle.
PAGE NO-1L
J.Thrylokya
20AAUS18
ENGINEERING GRAPHICS
UNIT-I
83
PAGE NO-7
20A6 AO 518
TThy okya
ENGINEERING GRAPHICS
UNIT-I
PAGE NO
90AGIADS
Thxylo ky
ENGINEERING GRAPHICS
UNIT-
diameter
1.A circle of 40mm diameter rolls on the circumference of another circle of 160mm
on the circumference of the rolling circle
for one
and inside it.trace the locus of a point
complete revolution.allso draw a set of tangent and normal to the curve at a distance ofSD-mm
from the center of the directing circle.
PAGE NO-