Technical Reference Manual 1MRS7522 63-MUM Group selection: * Switching between group 1 and group 2 is accomplished by means of a digital input Switching between setting groups through group sele has higher priority than through group configuration. The setting values can be altered via the HMI or with a PC provided with Relay Setting Tool. Before the relay is connected to a system it must be assured that the relay been given the correct settings. If there is any doubt, the setting values sh be read with the relay trip circuits disconnected or tested with current injection; refer to section Check lists for additional information. Table 5.1.4.12.-1 Setting values Setting Description Setting range PU scale Protected unit scaling factor 0.50. 2.50a) t 6x Safe stall time 2...120 sb) p Weighting factor 20...100% Kc Time constant multiplier 1...64 θa > Prior alarm level 50...100% θi > Restart inhibit level 20...80% T amb Ambient temperature 0...70°C Is>/In Start-up current for motor or start 1.00…10.0 x In value of stage Is> ts> Start-up time for motor or operate 0.30. 80.0 s time of stage Is> I>>/In Start value of stage I>> 0.50. 20.0 x In t>> Operate time of stage I>> 0.05. 30.0 s I0>/In Start value of stage I0> 1.0...100% In t0> Operate time of stage I0> 0.05...300 s I</In Start value of stage I< 30...80% In t< Operate time of stage I< 2...600 s I2>/In Start value of stage I2> 0.10…0.50 x In K2 Time constant of stage I2> at IDMT 5...100 characteristic Σtsi Restart inhibit value 5...500 s ΔΣts/Δt Countdown rate of start-up time 2...250 s/h counter CBFP Operate time of CBFP 0.10. 60.0 s Ta1> Alarm value Ta1> 0...200°C ta1> Operate time ta1> 1...100 s Tp1> Trip value Tp1> 0...200°C tp1> Operate time tp1> 1...100 s Default setting 1 2s 50 % 1 95% 40% 40°C 1.00 x In
0.30 s
1.00 x In 0.05 s 1.0% In 0.05 s 50% In 2s 0.20 x In 5