Professional Documents
Culture Documents
MII 15026
INSTALLATION QUICK SHIFTER
P/N 08U70-MJM-D10 VFR800F/FD Issue Date
INSTRUCTIONS 08U70-MJM-D11
June 2013
(6)
1. Remove the main seat and passenger seat as
shown.
PASSENGER SEAT
No. Description Qty
TORQUE CHART
Tighten all screws, bolts, and nuts to their specified
torque values. Refer to the Service Manual for the torque
values of the removed parts.
CLIP
CLIP
BATTERY COVER
CLIP
CLIP
CLIP
BOLT
WASHER
2 of 8
8. Remove the bolts and clips as shown. 10. Turn up the rubber flap and remove the dummy
<Left side> connector as shown.
CLIP
BOLT
RUBBER FLAP
Turn up.
BOLT
CLIP
9. Remove the left inner lower cowl and left middle cowl
as shown.
<Left side>
LEFT INNER LOWER COWL MOTORCYCLE’S
2-PIN WATERPROOF
CONNECTOR (Blue)
2-PIN WATERPROOF
DUMMY CONNECTOR
(Blue) (Save)
BOLT (Save)
3 of 8
12. Remove the clip as shown. 14. Remove the indicated bolt.
<Left side>
CLIP (Save)
Remove while turning
to the left.
BOLT
MARKER
200 mm
BELLOWS
85 mm
BOLT
Contract the (Reuse)
bellows part. GEAR CHANGE
PEDAL
CLAMP
4 of 8
16. Install the accessory gear change pedal as shown. 18. Install the 6 mm flange bolt as shown.
ACCESSORY GEAR
CHANGE PEDAL
GEAR CHANGE
PEDAL
6 mm FLANGE BOLT
Position the arm as shown.
ARM
19. Route the gear change pedal harness as shown.
Align.
WAVE
WASHER
GREASE
Apply.
PIVOT BOLT
GEAR CHANGE
PEDAL
5 of 8
20. Secure the gear change pedal harness with the 22. Carefully pull out the hose from the stay as shown.
clamp as shown.
GEAR CHANGE
PEDAL HARNESS
CLAMP
Pull out.
MARK
(85 mm)
STAY HOSE
Install the clip to the hose and the gear change pedal
harness at the marked point as shown.
CLIP
MARK (200 mm)
6 of 8
24. Route the gear change pedal harness as shown. 26. Connect the gear change pedal harness as shown.
GEAR CHANGE
PEDAL HARNESS
GEAR CHANGE
PEDAL HARNESS
7 of 8
OPERATING INSTRUCTIONS
This accessory enables very quick up-shifting without
clutch or throttle operations during acceleration (Engine
speed is more than 1,500 rpm).
• If the gear position display is abnormal, the shift
feeling may change.
• If the accessory quick shifter does not operate
normally, the clutch can be used to complete the
shift operation.
<Shift up>
• Up-shift without clutch and throttle operations.
<Shift down>
• Make sure to operate clutch when down-shifting.
TROUBLESHOOTING
If you cannot shift up by operating the shift pedal during
acceleration (Engine speed is more than 1,500 rpm), a
failure may have occured. Use a test meter and follow
the diagnostic procedure below.
Disconnect the gear change pedal 2P waterproof
connector (Black).
8 of 8