Professional Documents
Culture Documents
Turning Tools: General Turning - Parting & Grooving - Tooling Systems
Turning Tools: General Turning - Parting & Grooving - Tooling Systems
Turning tools
GENERAL TURNING | PARTING & GROOVING | THREADING | TOOLING SYSTEMS
2012
A
TURN - ENG
x
B
z
mm
inch
Total infeed
Total infeed
J
C 71
A
TURN - ENG
THREADING Infeed recommendations
mm
inch
Total infeed
Total infeed
J
C 72
A
TURN - ENG
Total infeed
External x
H
z
Internal x
Total infeed
J
C 73
A
TURN - ENG
THREADING Infeed recommendations
mm
inch
G Total infeed
Round 30° Din405 (RN) internal NPT (NT), external and internal
Pitch, TPI Pitch, TPI
x External x
z z
Internal x
No. of infeeds Radial infeed per pass
z
Total infeed
Total infeed
C 74
A
TURN - ENG
z Dimensions x and z
B
No. of infeeds Radial infeed per pass
mm
inch
Total infeed
z
H
No. of infeeds Radial infeed per pass
C 75
A
TURN - ENG
THREADING Infeed recommendations
mm
inch
Total infeed
C 76
A
TURN - ENG
External x
B
z
Internal x
mm
inch
Total infeed
C 77
A
TURN - ENG
THREADING Infeed recommendations
UNJ, external
Pitch, TPI Dimensions x and z
B x
mm
inch
Total infeed
Total infeed
Total infeed
C 78
A
TURN - ENG
API Buttress
Dimensions x and z
mm
I
inch
C 79
A
TURN - ENG
THREADING Infeed recommendations
Multi-point
NPT Dimensions x and z
ISO Metric (MM) ISO inch (UN), external Whitworth (WH) (NT)
B Pitch,
Pitch, mm Pitch, TPI Pitch, TPI TPI
x
External
C
Total infeed
Internal
Pitch,
Pitch, mm Pitch, TPI Pitch, TPI TPI
x
Total infeed
C 80
A
TURN - ENG
Infeed recommendations
The type of infeed, number of passes and size of infeed can have a - When using a Cubic Boron Nitride (CBN) grade the max infeed value
decisive impact on the threading operation. The infeed recommendations should be 0.07 mm (.003 inch).
are intended as starting values. Suitable number of passes must be - For C-geometry inserts, spring pass (a pass without infeed) should not
determined by trial and error. The harder the workpiece the more number be used. B
of passes. - For Multi-point inserts it is essential that the recommendations on
- The workpiece diameter should not be more than 0.14 mm (.006 inch) page C80 are used.
larger than the max diameter of the thread to achieve optimum tool - For V-profile inserts the recommended number of passes that is used
life. for full form inserts can be used.
- Infeeds of less than 0.05 mm (.002 inch) should be avoided, for
austenitic stainless steels not less than 0.08 mm (.003 inch).
C
A-geometry
C-geometry
F-geometry
Radial infeed Modified flank infeed Incremental infeed Modified flank infeed 1°
Cutting speed
Starting cutting speed recommendations are given on page C82. Careful
observation on the cutting edge can help you to achieve the best possible
H
threading results.
- A cutting speed that is too low can result in built-up edge
- A cutting speed that is too high can result in plastic deformation of the
edge
vc m/min
Formula ft/min
Formula to calculate infeed for each pass in a reduced series. I
C 81