Professional Documents
Culture Documents
VGN-S430P/S460/S460P/S470P/S480/S480B/S480P
SERVICE MANUAL
Ver. 1 2005D
l
Revision History
n t i a
e
VGN-S73PB/B
Japanese Japanese
VGN-S93PS/S∗
d
VGN-S93PSY∗
i
VGN-S93S/S∗
f
VGN-S430P/S
VGN-S460/B
n
VGN-S460P/B
US Canadian VGN-S470P/S
o
American VGN-S480∗
VGN-S480B∗
C
VGN-S480P∗
S400
ᧄᯏߩ᭽߅ࠃ߮ᄖⷰߪޔᡷ⦟ߩߚ੍๔ߥߊᄌ
ᦝߔࠆߎߣ߇ࠅ߹ߔ߇ੌߏޔᛚߊߛߐޕ
PERSONAL COMPUTER
∗ : CTO Model
9-876-417-01
Information in this document is subject to Caution Markings for Lithium/Ion Battery - The Service and Inspection Precautions
change without notice. following or similar texts shall be provided on
battery pack of equipment or in both the operating
Sony, VAIO and CLIE are trademarks or regis- and the service instructions. 1. Obey precautionary markings and 4. Inspect after completing service
tered trademarks of Sony. Microsoft, Windows, instructions
Windows Media, Outlook, Bookshelf and other After servicing, inspect to make sure that all
CAUTION: Danger of explosion if battery is
Microsoft products are trademarks or registered Labels and stamps on the cabinet, chassis, and screws, components, and wiring have been
incorrectly replaced. Replace only with the same returned to their original condition. Also check
trademarks of Microsoft Corporation in the components identify are as requiring special
or equivalent type recommended by the manu- precautions. Be sure to observe these precautions, the area around the repair location to ensure that
United States and other countries. The word
facturer. Discard used batteries according to the as well as all precautions listed in the operating repair work has caused no damage, and confirm
Bluetooth and the Bluetooth logo are trademarks
of Bluetooth SIG, Inc. AMD, AMD logo, AMD manufacturer’s instructions. manual and other associated documents. safety.
Duron and combinations there of, 3DNow!, are
trademarks of Advanced Micro Devices, Inc. Intel CAUTION: The battery pack used in this device 2. Use designated parts only 5. When replacing chip components...
Inside logo, Pentium and Celeron are trademarks may present a fire or chemical burn hazard if mis-
or registered trademarks of Intel Corporation. treated. Do not disassemble, heat above 100°C The set’s components possess important safety Never reuse components. Also remember that
Transmeta, the Transmeta logo, Crusoe Processor, (212°F) or incinerate. Dispose of used battery characteristics, such as noncombustibility and the negative side of tantalum capacitors is easily
the Crusoe logo and combinations there of are the ability to tolerate large voltages. Be sure that damaged by heat.
promptly. Keep away from children.
trademarks of Transmeta Corporation in the USA replacement parts possess the same safety charac-
and other countries. Graffiti, HotSync, Palm- teristics as the originals. Also remember that the 6. When handling flexible print
CAUTION: Changing the back up battery. mark, which appears in circuit diagrams and
Modem, and Palm OS are registered trademarks, boards...
• Overcharging, short circuiting, reverse charg- parts lists, denotes components that have particu-
and the Hotsync logo and Palm are trademarks of
ing, multilati on or incineration of the cells
Palm, Inc. or its subsidiaries. (M) and Motrola are larly important safety functions; be extra sure to • The temperature of the soldering-iron tip
must be avoided to prevent one or more of the use only the designated components.
trademarks of Motrora, Inc. Other Motrola prod- should be about 270°C.
following occurrences; release of toxic materi-
ucts and services with (R) mark like Dragomball • Do not apply the tip more than three times to
als, release of hydrogen and/or oxygen gas, rise
are the trademarks of Motrola, Inc. 3. Always follow the original design the same pattern.
in surface temperature.
when mounting parts and routing • Handle patterns with care; never apply force.
• If a cell has leaked or vented, it should be
All other names of systems, products and services wires
replaced immediately while avoiding to touch
in this manual are trademarks or registered trade- Caution: Remember that hard disk drives are
it without any protection.
marks of their respective owners. In this manual, The original layout includes various safety fea- easily damaged by vibration. Always handle
the (TM) or (R) mark are not specified. tures, such as inclusion of insulating materials with care.
(tubes and tape) and the mounting of parts above
the printer board. In addition, internal wiring has
been routed and clamped so as to keep it away
from hot or high-voltage parts. When mounting
parts or routing wires, therefore, be sure to du-
plicate the original layout.
Confidential
VGN-S53B/S73PB/S93PS/S93PSY/S93S (J)
VGN-S430P/S460/S460P/S470P/S480/S480B/S480P (AM)
—2—
TABLE OF CONTENTS
CHAPTER 4. EXPLODED VIEWS AND PARTS LIST History of the changes is shown as the "Revision
Palmrest
History" at the end of this data.
P-1 ............................................................................................................................................4-2
Main Board
ᄌᦝጁᱧߪ㧘
̌4GXKUKQP*KUVQT[̍
ߣߒߡ㧘
ᧄ࠺࠲ᧃߦ⸥
M-1 ...........................................................................................................................................4-4
Bottom タߒߡࠅ߹ߔޕ
B-1 ............................................................................................................................................4-6
LCD
L-1. 13.3-inch WXGA (Brighter) – Made by TO – .................................................................4-8
L-2. 13.3-inch WXGA (Brighter) – Made by SH – ...............................................................4-10
L-3. 13.3-inch WXGA............................................................................................................4-12
Accessories
A-1..........................................................................................................................................4-14
(to 4-14)
Confidential
VGN-S53B/S73PB/S93PS/S93PSY/S93S (J)
VGN-S430P/S460/S460P/S470P/S480/S480B/S480P (AM)
—3—
CHAPTER 1.
SPECIFICATIONS
1-1. Specifications
J AM
Model VGN-S73PB/B VGN-S53B/S VGN-S93PS/S∗ VGN-S93PSY∗ VGN-S93S/S∗ VGN-S460P/B VGN-S470P/S
CelM/Do/360/1.40GHz or CelM/Do/360/1.40GHz or CelM/Do/360/1.40GHz or
PM/Do/730/1.60GHz or PM/Do/730/1.60GHz or PM/Do/730/1.60GHz or
CPU PM/Do/750/1.86GHz PM/Do/730/1.60GHz PM/Do/740/1.73GHz PM/Do/740/1.73GHz
PM/Do/750/1.86GHz or PM/Do/750/1.86GHz or PM/Do/750/1.86GHz or
PM/Do/770/2.13GHz PM/Do/770/2.13GHz PM/Do/770/2.13GHz
Chipset 915PM 915GM 915GM or 915PM 915GM or 915PM 915GM or 915PM 915PM 915PM
915GM Integrated or 915GM Integrated or 915GM Integrated or
Graphics NV44M-V (TC32MB) 915GM Integrated NV44M-V (TC32MB) NV44M-V (TC32MB)
NV44M-V (TC32MB) NV44M-V (TC32MB) NV44M-V (TC32MB)
13.3/WXGA/BR or 13.3/WXGA/BR or 13.3/WXGA/BR or
LCD 13.3/WXGA/BR 13.3/WXGA/BR 13.3/WXGA/BR 13.3/WXGA/BR
13.3/WXGA 13.3/WXGA 13.3/WXGA
100GB or 40GB or 100GB or 40GB or 100GB or 40GB or
HDD 80GB 60GB 80GB 80GB
60GB or 80GB 60GB or 80GB 60GB or 80GB
512MB(256MBx2) or 512MB(256MBx2) or 512MB(256MBx2) or
256MB(256MBx1) or 256MB(256MBx1) or 256MB(256MBx1) or
Memory Std 512MB(512MBx1) 256MB(256MBx1) 512MB(256MBx2) 512MB(512MBx1)
1GB(512MBx2) or 1GB(512MBx2) or 1GB(512MBx2) or
2GB(1GBx2) 2GB(1GBx2) 2GB(1GBx2)
Memory Max 2GB 2GB 2GB 2GB 2GB 2GB 2GB
Combo/9.5/x24 or Combo/9.5/x24 or Combo/9.5/x24 or
Optical SuperMulti/9.5/x4/+DL SuperMulti/9.5/x4/+DL DVD+-RW/9.5/x4/+DL DVD+-RW/9.5/x4/+DL
SuperMulti/9.5/x4/+DL SuperMulti/9.5/x4/+DL SuperMulti/9.5/x4/+DL
Wireless LAN 802.11b/g 802.11b/g 802.11b/g 802.11b/g 802.11b/g 802.11b/g 802.11b/g
AC adaptor VGP-AC19V11 VGP-AC19V11 VGP-AC19V11 VGP-AC19V11 VGP-AC19V11 VGP-AC19V10 VGP-AC19V10
Battery VGP-BPS2 VGP-BPS2 VGP-BPS2 or VGP-BPL2 VGP-BPS2 or VGP-BPL2 VGP-BPS2 or VGP-BPL2 VGP-BPS2 VGP-BPS2
Bluetooth × × × × × × ×
OS XP Pro XP Home XP Pro XP Pro XP Home XP Pro XP Pro
Color Variation Black Silver Silver Silver Silver Black Silver
2003 Personal or 2003 Personal or 2003 Personal or
Office 2003 Personal 2003 Personal None None
2003 Professional or None 2003 Professional or None 2003 Professional or None
Keyboard Japanese Japanese English or Japanese English or Japanese English or Japanese English English
AM
Model VGN-S460/B VGN-S480∗ VGN-S480P∗ VGN-S480B∗ VGN-S430P/S
CelM/Do/360/1.40GHz or CelM/Do/360/1.40GHz or CelM/Do/360/1.40GHz or
PM/Do/730/1.60GHz or PM/Do/730/1.60GHz or PM/Do/730/1.60GHz or
PM/Do/740/1.73GHz or PM/Do/740/1.73GHz or PM/Do/740/1.73GHz or
CPU PM/Do/740/1.73GHz PM/Do/730/1.60GHz
PM/Do/750/1.86GHz or PM/Do/750/1.86GHz or PM/Do/750/1.86GHz or
PM/Do/760/2GHz or PM/Do/760/2GHz or PM/Do/760/2GHz or
PM/Do/770/2.13GHz PM/Do/770/2.13GHz PM/Do/770/2.13GHz
Chipset 915PM 915GM or 915PM 915GM or 915PM 915GM or 915PM 915GM
915GM Integrated or 915GM Integrated or 915GM Integrated or
Graphics NV44M-V (TC32MB) 915GM Integrated
NV44M-V (TC32MB) NV44M-V (TC32MB) NV44M-V (TC32MB)
13.3/WXGA/BR or 13.3/WXGA/BR or 13.3/WXGA/BR or
LCD 13.3/WXGA/BR 13.3/WXGA/BR
13.3/WXGA 13.3/WXGA 13.3/WXGA
100GB or 40GB or 100GB or 40GB or 100GB or 40GB or
HDD 80GB 60GB
60GB or 80GB 60GB or 80GB 60GB or 80GB
512MB(256MBx2) or 512MB(256MBx2) or 512MB(256MBx2) or
512MB(512MBx1) or 512MB(512MBx1) or 512MB(512MBx1) or
256MB(256MBx1) or 256MB(256MBx1) or 256MB(256MBx1) or
Memory Std 512MB(256MBx2) 512MB(512MBx1)
1GB(512MBx2) or 1GB(512MBx2) or 1GB(512MBx2) or
2GB(1GBx2) or 2GB(1GBx2) or 2GB(1GBx2) or
1GB(1GBx1) 1GB(1GBx1) 1GB(1GBx1)
Memory Max 2GB 2GB 2GB 2GB 2GB
Combo/9.5/x24 or Combo/9.5/x24 or Combo/9.5/x24 or
Optical DVD+-RW/9.5/x4/+DL Combo/9.5/x24
DVD+-RW/9.5/x4/+DL DVD+-RW/9.5/x4/+DL DVD+-RW/9.5/x4/+DL
Wireless LAN 802.11b/g 802.11a/b/g or 802.11b/g 802.11a/b/g or 802.11b/g 802.11a/b/g or 802.11b/g 802.11b/g
AC adaptor VGP-AC19V10 VGP-AC19V10 VGP-AC19V10 VGP-AC19V10 VGP-AC19V10
Battery VGP-BPS2 VGP-BPS2 or VGP-BPL2 VGP-BPS2 or VGP-BPL2 VGP-BPS2 or VGP-BPL2 VGP-BPS2
Bluetooth × 䂾 or × 䂾 or × 䂾 or × ×
OS XP Home XP Home XP Pro XP Pro XP Pro
Color Variation Black Black Black Black Silver
Office None CTO CTO CTO None
Keyboard English English English English English
L
DVI-D
(socket) LVDS
A
PSB 㪚㪥㪯㪄㪉㪐㪏 VGA
I
VGA
PCI Express Graphics
T
㪙㫌㫋㫋㫆㫅㩷㫆㫉㩷㪪㫎㫀㫋㪺㪿㫊
㪄㩷㪦㫇㫋㫀㪺㪸㫃㩷㪛㫉㫀㫍㪼㩷㪦㫇㪼㫅 nVIDIA NV44M-V
㩷㪄㩷㪧㪚㩷㪚㪸㫉㪻㩷㪜㫁㪼㪺㫋
400 Microphone
Alviso-GM
NV44M-V
N
㪣㪜㪯㪄㪍㪎 MHz GMCH
㪙㫌㫋㫋㫆㫅 or Switchs
uFCBGA1257
Model only 㪚㪥㪯㪄㪉㪌㪉
- WLAN On/Off DDR2 Audio Headphone
E
VGA CODEC
LEDs
- Power
- Standby Azalia Internal
ID
- Battery
- HDD Stereo
- Optical Drive
- Memory Stick SO-DIMM DMI 㪠㪝㪯㪄㪊㪏㪌 Speaker
- WLAN On (WLAN Model Only)
MDC
F
- BT (BT Model Only)
Modem
RJ-11
㪪㪮 㪯㪄 㪈 㪏 㪎 Magnet RJ-45
N
㪙㫌㫋㫋㫆㫅㩷㫆㫉㩷㪪㫎㫀㫋㪺㪿㫊 EEPROM Ether Module
㩷㩷㪄
㪄㩷㪫㫆㫌㪺㪿㩷㪧㪸㪻㩷㪣㪆㪩 LPC (33 MHz) (MAC address)
Intel Kinnereth
Magnet
RJ-45
ICH6-M (100BASE) Module
O
㪪㪮 㪯㪄 㪈 㪏 㪍 421BGA USB BT
㪠㪝㪯㪄㪊㪊㪈
㩷㪙㫌㫋㫋㫆㫅㩷㫆㫉㩷㪪㫎㫀㫋㪺㪿㫊 Port 4 BT
㩷㪄㩷㩷㪧㫆㫎㪼㫉 Module Antenna
Debug
C
㩷㪄㩷㪪㫇㪼㪺㫀㪸㫃㩷㪇
㩷㪄㩷㪪㫇㪼㪺㫀㪸㫃㩷㪈
EC/ FWH PCI Bus (33 MHz)
KBC 㪙㪫㩷㪤㫆㪻㪼㫃㩷㫆㫅㫃㫐
㪣㪜㪛㫊 Port 0
USB1
Y
㩷㩿㪁㩷㪑㩷㪥㪆㪘㩷㫎㪿㪼㫅㩷㪣㪚㪛㩷㪺㫃㫆㫊㪼㪻㪀
㩷㪄㩷㪁㪥㫌㫄㩷㪣㫆㪺㫂 EEPROM Port 2 USB
㩷㪄㩷㪁㪚㪸㫇㫊㪣㫆㪺㫂
(password) IDE i.LINK & USB2
㩷㪄㩷㪁㪪㪺㫉㫆㫃㫃㩷㪣㫆㪺㫂 Port 1 USB 2.0
N
㪚㪥㪯㪄㪉㪐㪐 W-LAN PC Card Hub
USB
EEPROM
SATA TI PCI7420B (GUID) Port 5
USB
O
PATA (Mini PCI Port 6
TouchPad Internal Keyboard
Type III B socket)
S
Port 7
Confidential
VGN-S53B/S73PB/S93PS/S93PSY/S93S (J)
VGN-S430P/S460/S460P/S470P/S480/S480B/S480P (AM)
2-1
(END)
CHAPTER 3.
FRAME HARNESS DIAGRAM
Side L
LCD 㪝㫉㫆㫄㩷㪹㫆㪸㫉㪻㩷㫋㫆㩷㪺㫆㫅㫅㪼㪺㫋㫆㫉㩷㩿㪻㫀㫉㪼㪺㫋㩷㪺㫆㫅㫅㪼㪺㫋㫀㫆㫅㪀
8 1 㪟㪸㫉㫅㪼㫊㫊㩷㩿㫎㫀㫋㪿㩷㪺㫆㫅㫅㪼㪺㫋㫆㫉㫊㩷㫆㫅㩷㪹㫆㫋㪿㩷㪼㫅㪻㫊㪀
LAN 11 12
MODEM
MODEM 㪟㪸㫉㫅㪼㫊㫊㩷㩿㫊㫆㫃㪻㪼㫉㫀㫅㪾㩷㫆㫅㩷㪼㫀㫋㪿㪼㫉㩷㪼㫅㪻㪀
CARD 1 2 IFX-385
BOARD SIDE A
AUDIO IN
㪣㪠㪫㪟㪠㪬㪤㪠㪦㪥
1 1 2 㪙㪘㪫㪫㪜㪩㪰㩷㪧㪘㪚㪢
AUDIO OUT LCD
INVERTER
HARNESS
FFC (CNX-IFX) 39 40 UNIT
22
1 2 1 2 2 1 㪪㪧㪜㪚㪠㪘㪣
㪧㪦㪮㪜㪩
VGA Rear
2 40 㪙㪬㪫㪫㪦㪥
20 19 10 1
SPEAKER 6 1
1 39 2 1
SPEAKER 1 2 Side R
10 9
CNX-298 SWX-186
39 40 㪛㪅㪚㪅㩷㪝㪘㪥 BOARD SIDE B
BOARD SIDE B
BLUETOOTH 2 1 DC HARNESS
MODULE 2 200
2 1 1 199
COAXIAL CABLE
1 50 2 50
IFX-331 1 49
BOARD SIDE A CNX-299 MEMORY
BOARD SIDE B FFC (CNX-MBX) 1 2
49 1
KEYBOARD AF26 AF1
50 2
23 24
㪚㪧㪬
DRIVE 15 16
FFC (SWX-MBX) MBX-129
BOARD SIDE A
FFC (SWX-TOUCH PAD) 1 2 A26 A2
NICKEL HYDROGEN 2 1
BATTERY
USB
TOUCH PAD
1 16 1 12 1 10
LEX-67 10 1 USB
BOARD SIDE B
iLINK
SWX-187 FFC (SWX-LEX) W-LAN SW
BOARD SIDE A
LEFT RIGHT 1 199
BUTTON BUTTON
LID SW 1 10 1 123 1 2 2 200
2 19 20
124
2
1 MEMORY
STICK MEMORY
PC CARD
53 1
FPC (HDD)
80 79 54 2
W-LAN CARD
3-1
(END)
Palmrest
CHAPTER 4. Palmrest
Section Page
Bottom Bottom
B-1 ............................................................................................ 4-6 LCD
LCD
L-1. 13.3-inch WXGA (Brighter) – Made by TO – ................. 4-8
L-2. 13.3-inch WXGA (Brighter) – Made by SH – ............... 4-10
L-3. 13.3-inch WXGA............................................................ 4-12
Accessory Bottom
A-1.......................................................................................... 4-14
NOTE: ↪ޣߩᵈᗧޤ
Items marked "*" are not stocked since they are seldom required for *ශߩㇱຠߪᏱᐶߒߡ߅ࠅ߹ߖࠎޕ
routine service. Some delay should be anticipated when ordering ࿑㕙⇟ภߩߥㇱຠߪଏ⛎ߒ߹ߖࠎޕ
these items. ૬⸥ㇱຠߩ႐ว㧘ㇱ⸥タㇱຠࠍࡔࠗࡦㇱຠߣߒߡ↪ߒߡߊߛߐޕ
The mechanical parts with no reference number in the exploded
views are not supplied. ㇱຠฬ⒓ߩ೨ߦශߩߟߚㇱຠߪ㧘*KIJ8CNWG/QFWNG㧔*8/㧕ߢߔޕ
When two or more parts are shown, use the part described first as the ຠฬ⒓ߩ೨ߦශߩߟߚㇱຠߪ㧘ࡃࠦ࠼ࡌ࡞⾍ઃㇱຠߢߔޕ
main part. ࡃࠦ࠼ࡌ࡞ߦߟߡߪ%*#26'4ࠍෳᾖߒߡߊߛߐޕ
The parts marked " $ " are the High Value Modules (HVM).
ㇱຠฬ⒓ߩ೨ߦශߩߟߚㇱຠߪ㧘߅ቴ᭽⓹ญߥߤߢ߽឵น⢻ߥ%WUVQOGT
The parts marked " # " are the parts on which barcode label is attached.
For the barcode label, refer to CHAPTER 5. 4GRNCECDNG2CTV㧔%42㧕ߢߔޕ
The parts marked "&" are the "Customer Replacable Parts (CRP)" ․ߦ ߩߟߚㇱຠߪ㧘ಽߌ߇ᔅⷐߥㇱຠߢߔߩߢ㧘ಽ⸃࿑ߢ%WUVQOGT
that can be replaced by Field Customer Support. 4GRNCECDNG2CTVUኻ⽎ㇱຠ߆㧘ኻ⽎ᄖㇱຠ߆ࠍᔅߕᓮ⏕ߊߛߐޕ
Especially the parts with the <&> mark require the special attention to
use them. Here fore, check first whether the desired part is one of the
targetted parts of the Customer Replaceable Parts (CRP), or the non-
targetted parts by referring to the exploded view.
4-1
P-1
P-1. Palmrest
14
16
A
M-1 B1
12
24
B2
B
M-1 B1
C
M-1
17
B2
E
10 (1) B-1
D 12
B-1
18 8
7
6
3 1 The form and the printing of LED cover differs for every part number.
5
B2 F
19 M-1 4-683-211-01 COVER LED
G 11
23 M-1 20
13 B2
4-683-211-11/4-683-211-31 COVER LED
4
9
B2
Confidential
VGN-S53B/S73PB/S93PS/S93PSY/S93S (J)
VGN-S430P/S460/S460P/S470P/S480/S480B/S480P (AM)
4-2
P-1
P-1. Palmrest
Ref. No. Part No. Description J AM
S93PS/S∗
S93PSY∗
S73PB/B
S460P/B
S470P/S
S430P/S
S93S/S∗
S480P∗
S480B∗
S53B/S
S460/B
S480∗
3 1-830-252-12 CABLE, FLEXIBLE FLAT (10PIN)
Ref.No. Part No. Description
4 1-830-252-41 CABLE, FLEXIBLE FLAT (10PIN) 2 X-2025-555-2
X-2048-845-2
ASSY PALMREST
ASSY PALMREST(SILVER)
z
z z z z
z
z
z z z z
z
5 1-829-195-11 CABLE, FLEXIBLE FLAT (12PIN) 10 4-683-211-31
4-683-211-01
COVER LED
COVER LED
z z z z z
z z z
z
Confidential
VGN-S53B/S73PB/S93PS/S93PSY/S93S (J)
VGN-S430P/S460/S460P/S470P/S480/S480B/S480P (AM)
4-3
M-1
M-1. Main Board
324
314
13
BT model only
13 22
302
22 B5
I 312
B-1 B3
B4 J 327
B-1
303 B4
B4 315
307 331 K 335 (4)
321 B P-1 B-1 Q
326 333 L-1, 2
319 A
C P-1 309 (4)
P-1 320
319 G
P-1
F 332
P-1 B4 328
B12 B4
304 N H
B-1 B-1
333
B3 M
305 B-1
301
316
328
L
329 B-1
310
310 U
13 B-1
B13 B5
325
P
L-1, 2 O
L-1, 2 4 Ref. No. 333 and 335 are parts used only for Ref. No. 305: A-1124-111-A.
334 4 4GH0Q㧘ߪ㧘4GH0Q㧦##ߩߺߦ↪ߔࠆㇱຠߢߔޕ
309
Confidential
Memory x2 model VGN-S53B/S73PB/S93PS/S93PSY/S93S (J)
VGN-S430P/S460/S460P/S470P/S480/S480B/S480P (AM)
4-4
M-1
M-1. Main Board
J AM
Ref. No. Part No. Description
S93PS/S∗
S93PSY∗
S73PB/B
S460P/B
S470P/S
S430P/S
S93S/S∗
S480P∗
S480B∗
S53B/S
S460/B
S480∗
13 4-662-881-02 CUSHION, KEY BOARD
Ref.No. Part No. Description
22 4-672-493-01 COVER (SC) 302 1-805-554-21 BLUETOOTH MODULE z z z
303 1-829-369-11 CABLE, COAXIAL (WITH U.F.L CON) z z z
301 1-756-544-11 LITHIUM RECHARGEABLE BATTERY 305 A-1124-110-A $ # COMPLETE MBX-129 (EXT) (S) z z z z z z z z z z
A-1124-111-A $ # COMPLETE PWB MBX-129 (INT) (S) z z z z z z z z
304 1-417-539-12 # CARD, MODEM 309 6-707-355-01
6-707-504-01
#
#
IC EBE52UD6ABSA-4A-E
IC HYS64T128021HDL-5-A
z z
z
z
z
z
z
z
z z z
z
6-708-087-01 # IC M470T3354BZ0-CCC z
6-707-350-01 # IC HYS64T64020HDL-5-A z z z
310 1-794-548-21 CONNECTOR, USB(A) 316 6-707-252-01
6-707-258-01
IC RH80536GE0252MSL86G
IC RH80536GE0302MSL7SA
z z z z z
z z z z
z
z
z z
z
312 1-787-301-11 FAN,DC(5V) 6-707-259-01
6-707-260-01
IC RH80536GE0362MSL7S9
IC RH80536GE0412MSL7SM
z z z z z
z
z
z
z
z
314 1-962-758-21 HARNESS ,RJ-45/21 6-707-261-01
6-707-715-01
IC RH80536GE0462MSL7SL
IC RH80536NC0171MSL86K
z z z
z z z
z
z
z
z
z
z
315 2-580-414-01 HEATSINK UNIT 329 1-761-864-51
1-761-864-61
WIRELESS LAN CARD
WIRELESS LAN CARD z z z z z
z z z z z z z
Confidential
VGN-S53B/S73PB/S93PS/S93PSY/S93S (J)
VGN-S430P/S460/S460P/S470P/S480/S480B/S480P (AM)
4-5
B10
B4
B-1
B-1. Bottom 512
B4
B4
513
B6 540 518
519
539
514 509
501 B7 D
P-1
506
B11 (1, 2 ) B4 E
B4 (3 ) P-1
508 B8 505 U B9
530 M-1
B8
B1
B1 526
L
M M-1 544 526
M-1 532
B1
1 Since Ref No. B11 is special screw, one of the following special tools is needed for removal.
1022 1 4GH0Q$ߪ㧘․ᱶࡆࠬߩߚขࠅᄖߒߦߪᰴߩߕࠇ߆ߩኾ↪Ꮏౕ߇ᔅⷐߢߔޕ
520
534 B1
504 DRIVER (H4M 6.0G), SPECIAL
(Part No.: J-2507-713-1)
B9 (3 ) 2 Ref No. B11 is parts used only for Ref No. 329:1-789-095-11.
2 4GH0Q$ߪ㧘4GH0Qߩߺߦ↪ߔࠆㇱຠߢߔޕ
3 Ref No. B4 and B9 are parts used only for models are used for Ref No. 329:1-761-864-51,1-761-864-61.
3 4GH0Q$㧘$ߪ㧘4GH0Qࠍ↪ߔࠆᯏ⒳ߩߺߦ↪ߔࠆㇱຠߢߔޕ
Confidential
VGN-S53B/S73PB/S93PS/S93PSY/S93S (J)
VGN-S430P/S460/S460P/S470P/S480/S480B/S480P (AM)
4-6
B-1
B-1. Bottom
J AM
Ref. No. Part No. Description
S93PS/S∗
S93PSY∗
S73PB/B
S460P/B
S470P/S
S430P/S
S93S/S∗
S480P∗
S480B∗
S53B/S
S460/B
S480∗
503 X-4626-768-2 ASSY ESCUTCHEON L
Ref.No. Part No. Description
505 X-2048-427-4 ASSY HOUSING BOTTOM 501 X-2024-607-1 ASSY BEZEL OPT COMBO z z z z z z z
X-2055-753-1 ASSY BEZEL OPT +-RW DL z z z z z z
506 X-2048-428-1 & ASSY LID DIMM X-2055-734-1 ASSY BEZEL OPT MLT DL z z z z z
504 A-1105-612-A $ # HDD (100GB,HTS541010) (S) z z z z z z
507 2-024-006-01 BRACKET DC JACK A-1108-510-A $ # HDD (MHT2080-80GB) (S) z z z
* 508 2-548-545-01 BRACKET HDD A-1108-509-A
A-1109-275-A
$
$
#
#
HDD (MHT2080-60GB) (S)
HDD (MHT2040-40GB) (S)
z z z z z z z z
z z z
A-1105-615-A $ # HDD (40GB,HTS541040) (S) z z z
A-1105-613-A $ # HDD (80GB,HTS541080) (S) z z z z z z z
* 509 4-683-190-01 BRACKET KENJINGTON 516
A-1121-699-A
1-797-054-11
$ #
#
HDD (MK1032GSX-100GB) (S)
COMBO DRIVE (UJDA765,9.5MM)
z
z
z
z
z
z
z z z
z z z z
* 510 4-683-231-02 BRACKET OPT L 1-797-273-11
1-797-272-11
#
#
DVDRWSM(UJ-832B,9.5MM)
DVD+-RW(UJ-832B,9.5MM)
z z z z z
z z z z z z
511 2-548-551-01 BRACKET OPT R 538
B9
A-1124-285-A
4-673-648-01
$
&
COMPLETE PWB IFX331 (-21) (S)
GRIP, M2 (+B) (EG) z z z z z
z
z z z z
z
z
z
z z
512 2-548-546-01 BRACKET PCCARD B11 4-681-432-21 & SCREW (M2) (SPIN) z z z
Confidential
VGN-S53B/S73PB/S93PS/S93PSY/S93S (J)
VGN-S430P/S460/S460P/S470P/S480/S480B/S480P (AM)
4-7
L-1
L-1. LCD 13.3-inch WXGA (Brighter)
1017
– Made by TO –
1016
1019
B4
B7
1010 1020
S
B-1 B4
1007
1022 B7
B3
1002
1015
1018
B7
B4 B4
1013
1001 T
B-1 1011
B3 R B4
1004 B-1
B3 13 1008
U
O P
13 M-1 M-1 1023 1021
1006 B3 1003
B7
1014
Q
1009 M-1
B3 U
1006
B4
1005 13
B4
1009
1012
1009
1005
B4 Confidential
VGN-S53B/S73PB/S93PS/S93PSY/S93S (J)
VGN-S430P/S460/S460P/S470P/S480/S480B/S480P (AM)
4-8
L-1
L-1. LCD 13.3-inch WXGA (Brighter)
– Made by TO –
J AM
Ref. No. Part No. Description
S93PS/S∗
S93PSY∗
S73PB/B
S460P/B
S470P/S
S93S/S∗
S53B/S
S460/B
13 4-662-881-02 CUSHION, KEY BOARD
Ref.No. Part No. Description
1001 A-1072-481-A $ # LCD UNIT(13.3 WXGA) (S) 1005 4-683-220-01 & COVER DISPLAY SCREW LO z z z
4-683-220-11 & COVER DISPLAY SCREW LO z z z z z
* 1002 4-683-218-01 BRACKET LCD L 1006 4-683-221-01
4-683-221-11
&
&
COVER DISPLAY SCREW UP
COVER DISPLAY SCREW UP
z
z z z z
z
z
z
ߎߩㇱຠߪ㧘ᯏ⒳ㅢߩㇱຠߣ㧘ᯏ⒳ߦࠃߞߡಽߌ߇ᔅⷐߥㇱຠߦಽ߆ࠇߡ߹ߔޕ
Confidential
VGN-S53B/S73PB/S93PS/S93PSY/S93S (J)
VGN-S430P/S460/S460P/S470P/S480/S480B/S480P (AM)
4-9
L-2
L-2. LCD 13.3-inch WXGA (Brighter)
1017
– Made by SH –
1016
1019
B4
B7
1010 1020
S
B-1 B4
1007
1022 B7
B3
1002
1102
1018
B7
B4 B4
1013
1101 T
B-1 1011
B3 R B4
1004 B-1
B3 13 1008
U
O P
13 M-1 M-1 1023 1021
1006 B3 1003
B7
1014
Q
1009 M-1
B3 U
1006
B4
1005 13
B4
1009
1012
1009
1005
B4 Confidential
VGN-S53B/S73PB/S93PS/S93PSY/S93S (J)
VGN-S430P/S460/S460P/S470P/S480/S480B/S480P (AM)
4-10
L-2
L-2. LCD 13.3-inch WXGA (Brighter)
– Made by SH –
Ref. No. Part No. Description AM
S430P/S
S480P∗
S480B∗
S480∗
13 4-662-881-02 CUSHION, KEY BOARD
Ref.No. Part No. Description
* 1002 4-683-218-01 BRACKET LCD L 1005 4-683-220-01 & COVER DISPLAY SCREW LO z z z
4-683-220-11 & COVER DISPLAY SCREW LO z
* 1003 4-683-219-01 BRACKET LCD R 1006 4-683-221-01
4-683-221-11
&
&
COVER DISPLAY SCREW UP
COVER DISPLAY SCREW UP
z z z
z
1004 4-673-031-01 COPPER TAPE(LCD) 1007 4-683-222-01
4-683-222-11
COVER HINGE L
COVER HINGE L
z z z
z
1010 4-683-225-02 HINGE L 1008 4-683-223-03
4-683-223-12
COVER HINGE R
COVER HINGE R
z z z
z
1009 4-683-224-01 & CUSHION BEZEL z z z
4-683-224-11 & CUSHION BEZEL z
1011 4-683-226-02 HINGE R 1012 4-683-217-03
4-683-217-11
HOUSING BEZEL
HOUSING BEZEL
z z z
z
1013 1-478-924-31 INVERTER UNIT 1014
ߎߩㇱຠߪ㧘ᯏ⒳ㅢߩㇱຠߣ㧘ᯏ⒳ߦࠃߞߡಽߌ߇ᔅⷐߥㇱຠߦಽ߆ࠇߡ߹ߔޕ
Confidential
VGN-S53B/S73PB/S93PS/S93PSY/S93S (J)
VGN-S430P/S460/S460P/S470P/S480/S480B/S480P (AM)
4-11
L-3
L-3. LCD 13.3-inch WXGA
1017
1016
1019
B4
B7
1010 1020
S
B-1 B4
1007
1022 B7
B3
1002
1015
1018
B7
B4 B4
1013
1201 T
B-1 1011
B3 R B4
1004 B-1
B3 13 1008
U
O P
13 M-1 M-1 1023 1021
1006 B3 1003
B7
1014
Q
1009 M-1
B3 U
1006
B4
1005 13
B4
1009
1012
1009
1005
B4 Confidential
VGN-S53B/S73PB/S93PS/S93PSY/S93S (J)
VGN-S430P/S460/S460P/S470P/S480/S480B/S480P (AM)
4-12
L-3
L-3. LCD 13.3-inch WXGA
J AM
Ref. No. Part No. Description
S93PS/S∗
S93PSY∗
S93S/S∗
S480P∗
S480B∗
S480∗
13 4-662-881-02 CUSHION, KEY BOARD
Ref.No. Part No. Description
* 1002 4-683-218-01 BRACKET LCD L 1005 4-683-220-01 & COVER DISPLAY SCREW LO z z z
4-683-220-11 & COVER DISPLAY SCREW LO z z z
* 1003 4-683-219-01 BRACKET LCD R 1006 4-683-221-01 & COVER DISPLAY SCREW UP z z z
4-683-221-11 & COVER DISPLAY SCREW UP z z z
1004 4-673-031-01 COPPER TAPE(LCD) 1007 4-683-222-01
4-683-222-11
COVER HINGE L
COVER HINGE L z z z
z z z
Confidential
VGN-S53B/S73PB/S93PS/S93PSY/S93S (J)
VGN-S430P/S460/S460P/S470P/S480/S480B/S480P (AM)
4-13
A-1
A-1. Accessories
J AM
2001
S93PS/S∗
S93PSY∗
S73PB/B
S460P/B
S470P/S
S430P/S
S93S/S∗
S480P∗
S480B∗
S53B/S
S460/B
S480∗
AC Adaptor Ref.No. Part No. Description
0 2001 1-479-114-23 $ & ADAPTOR, AC z z z z z z z
2003
- 2-629-486-01 & Instruction䇭Manual (XP Professional,XP Home Edition) z z z z z
Battery
2004 2017
L Battery Power Cord
ߎߩㇱຠߪ㧘ᯏ⒳ㅢߩㇱຠߣ㧘ᯏ⒳ߦࠃߞߡಽߌ߇ᔅⷐߥㇱຠߦಽ߆ࠇߡ߹ߔޕ
2007
Power Cord
Confidential
VGN-S53B/S73PB/S93PS/S93PSY/S93S (J)
VGN-S430P/S460/S460P/S470P/S480/S480B/S480P (AM)
4-14
(END)
CHAPTER 5.
OTHER
5-1. The Barcode Label
The hatched portion of the barcode is used as the repair data.
ࡃࠦ࠼ࡌ࡞ߩ✂ដߌㇱߪ㧘ୃℂ࠺࠲ߣߒߡ↪ߚߒ߹ߔޕ
[MBX-129 Board] [MBX-129 Board] [Drive] [HDD (FUJITSU)]
(Side A) (Side B) (Rear) (Top)
A,B
D
[W-LAN Card] [HDD (HITACHI)]
E (Top) (Top)
F C
D
B
[MODEM Card]
(Rear)
A
[Memory ]
(Top)
A,B
A : Part No.
B : Serial No.
C : Revision No.
D : Maker Barcode
E : Global User ID (iLink) Confidential
F : Mac Address
VGN-S53B/S73PB/S93PS/S93PSY/S93S (J)
VGN-S430P/S460/S460P/S470P/S480/S480B/S480P (AM)
5-1
5-2. Replacing the CPU
Note: We have two kinds of CPU for this set, and either of them is used.
Two kinds of CPU have differences in the lock position and the unlock position.
CPU CPU
mark mark
CPU CPU
mark mark
Note: Lock the CPU properly, or operation Note: Lock the CPU properly, or operation
Confidential
becomes unstable. becomes unstable. VGN-S53B/S73PB/S93PS/S93PSY/S93S (J)
VGN-S430P/S460/S460P/S470P/S480/S480B/S480P (AM)
5-2
(END)
VGN-S53B/S73PB/S93PS/S93PSY/S93S (J)
VGN-S430P/S460/S460P/S470P/S480/S480B/S480P (AM)
VGN-S73PB/B VGN-S460/B
VGN-S93PS/S∗
VGN-S93PSY∗ VGN-S460P/B
VGN-S93S/S∗ VGN-S470P/S
VGN-S480∗ This manual and the constituent data may not be
VGN-S480B∗
9-876-417-XX
VGN-S480P∗
* replicated, copied nor reprinted in whole or in part
without prior written authorization of Sony Corporation.
ᧄࡑ࠾ࡘࠕ࡞ߩ৻ㇱ㧘߹ߚߪోㇱߦߟߡ㧘ήᢿߢ
࠺࠲ߩⶄ㧘ⶄ౮㧘ォタߔࠆߎߣࠍߓ߹ߔޕ
* ∗ : CTO Model
: Additional Models
English/Japanese
2005D0500-1
9-876-417-01 Sony Corporation © 2005 Sony Corporation
— 23 — Published by Sony EMCS NAGANO TEC
Revision History
<Remarks>
151 [Confidential]
VGN-S53B/S73PB/S93PS/S93PSY/S93S (J)
VGN-S430P/S460/S460P/S470P/S480/S480B/S480P (AM)