Professional Documents
Culture Documents
BBBG Era 12
BBBG Era 12
This document contains a brief description on how to install a SAU IP plug-in unit in a MINI-LINK E
Access Module Magazine (AMM) and how to configure the unit in order to access the complete online
manual via the embedded web server of the SAU IP.
Note: The installation of MINI-LINK E equipment must be completed according to MINI-LINK E ETSI
Indoor Installation Manual and MINI-LINK E ANSI Indoor Installation Manual prior to installing the SAU
IP.
Hardware Installation
24/48/60 V 24/48/60 V
Q6974 Q6975
a. Loosen the two screws (D). b. Remove the plug-in unit using the appropriate
tools found on the inside of the front cover.
2. Insert the SAU IP plug-in into the top-most position of the AMM:
24/48/60 V
24/48/60 V
Pos Unit
4
Type
Ordering
Code
Site name
Near ID.
AM pos.
A
3 Far ID.
2 Site name
Pos Unit AM pos.
1 Type
4 Ordering
Code
Near ID.
3 Far ID.
2
1
Q6977 Q6979
a. For AMM 2U-3: Remove the protective cap, if b. Loosen the two screws (A) and insert the unit
present, by pulling the plastic while observing the direction of the arrows (B).
handle.
24/48/60 V
24/48/60 V
Site name
Pos Unit AM pos.
C 4
3
2
Type
Ordering
Code
Near ID.
Far ID.
Site name
Pos Unit AM pos.
Type
4 Ordering
Code
Near ID.
3 Far ID.
2
1
Q6978 Q6980
c. Press in the plug-in unit. Make sure it is d. Tighten the two screws to secure the plug-in
pressed in straight and connects to the back of unit (C).
the AMM.
PEN/LZT7120208
This instruction assumes that the SAU IP has not been previously installed, meaning that it will start up in
installation mode when powered on. This is indicated by a green flashing LED on the SAU IP front panel.
1. Connect an Ethernet cable (crossed, twisted pair) between your PC and any of the two 10/100BASE-
T connectors on the front of the SAU IP. Make sure that the corresponding yellow LED turns ON
indicating link up.
2. Configure the PC to use a dynamic IP address obtained from the DHCP server in the SAU IP.
Note: It is also possible to configure the PC to use the static IP address 10.0.0.2.
3. Start a Web browser and make sure your browser is configured not to use a proxy server.
4. Enter the URL http://10.0.0.1 and open the online help by clicking Help.
Related documents
More information on the hardware installation is found in the MINI-LINK E ETSI Indoor Installation Manual
(EN/LZT 712 0176) and the MINI-LINK E ANSI Indoor Installation Manual (AE/LZT 712 0189).
Complete documentation of the SAU IP is obtained from the online help and also in printed form from your
local Ericsson representative as document EN/LZT 712 0207.
Ericsson AB
Transmission & Transport Networks
SE-431 81 Mölndal, Sweden
Telephone +46 31 747 00 00
Telefax +46 31 27 72 25 EN/LZT 712 0208 R1A
www.ericsson.com © Ericsson AB 2004 – All Rights Reserved