Professional Documents
Culture Documents
of LiFePO4
POSTEF: 48V50Ah
Model: SDA10-4850
2019
Declaration
1. The specification details the performance of the battery pack. Please read the specification carefully
before operations and please abide by relevant industrial safety regulations. We will not be
responsible for any damage to the product due to improper operations or use under conditions that
are not prescribed in the specification.
2. As the product version upgrades or other reasons, this document is subject to change without
notice. Unless otherwise agreed, this document only as a guide, all statements, information, and
recommendations in this document do not constitute any express or implied warranty.
Contact information:
POST AND TELECOMMUNICATION EQUIPMENT JOINT STOCK COMPANY
Head Office: 61 Tran Phu – Ba Dinh – Ha Noi – Viet nam
Factory: No 15, 12th Street, VSIP Industrial Zone, Bac Ninh Province
1 Model SDA10-4850
18 Cycle Life
≥3000(DOD 80%) @0.5C Charge & Discharge, 45℃
Less than 12 months : -
20~25℃
less than 3 months: - 60±25%R.H.
19 Storage Temperature Range
20~40℃ at the shipment state
Less than 7 day : -
20~65℃
20 Months Self Discharge ≤3% @25℃ & Sleep mode
Protection Parameter
No Item Description Value Unit
Unit Overcharge Warning
3600 mV
Voltage
Unit Overcharge Protection
3700 mV
Voltage
1 Over Charge
Battery pack over charge
Parameter 54.0 V
warning voltage
Battery Pack over charge
55.5 V
protection voltage
Unit Overdischarge Warning
2800 mV
Voltage
Unit Overcharge Protection
2700 mV
Over Voltage
2
Discharge Battery pack over discharge
42 V
Parameter warning voltage
Battery Pack over discharge
40.5 V
protection voltage
Charge Over Current 55 A
Warning
Charge Over
3 Charge 1st over current / A
Current
Parameter Charge 2nd over current 60 A
Short circuit at charging port YES
Discharge over current
55 A
warning
Discharge Over Discharge 1st over current 60 A
4
Current Discharge 2nd over current 80 A
Parameter
Short circuit at discharging
YES
port
High temperature warning 55 ℃
Low temperature warning 0 ℃
Charge
High temperature protection 65 ℃
Temperature Low temperature protection -5 ℃
5 Protection
High temperature warning 55 ℃
Low temperature warning -15 ℃
Disch
arge High temperature protection 65 ℃
Low temperature protection -20 ℃
Noted:
1. The cell is firmly connected each other and to battery case via metal frame. Identification code on each
cell are marked
2. The Cell temperature sensors are firmly fixed by glue.
3. The Power cable and signal cable inside battery are firmly fixed by cable tie and fixed
points. Each cable is marked
4. Work normally after vibration test of UL1642, test 16: Amplitude: 0.8mm. Vibration frequency:
Change with rate 1Hz/min from 10Hz-50Hz in at least 90mins. Direction: 2 axis: horizontal and vertical.
5. Function Description
Note:
Address Switch function (Only in Parallel, Currently support max 15 batteries in parallel. The
maximum deviation current is 0.1C.)
All the batteries in parallel should be not less than 80% SOH and the Voltage difference should be
not higher than 2V while installation
When battery work in parallel, main pack and slave packs need address as follows:
The battery system operates with hazardous voltages. Only qualified maintenance personnel may
carry out repairs.
Even after the unit is disconnected from the mains, components inside are still connected to the
battery cells, which are potentially dangerous.
Before carrying out any kind of service and/or maintenance, disconnect the batteries and verify that
no current is present and no hazardous voltage exists in the terminals.
Only persons are adequately familiar with batteries and with the required precautionary measures
may replace batteries and supervise operations. Unauthorized persons must be kept well away from the
batteries.
Verify that no voltage between the battery terminals and the ground is present before maintenance
or repair. In this product, the battery circuit is not isolated from the input voltage. Hazardous voltages may
occur between the battery terminals and the ground.
Batteries may cause electric shock and have a high short-circuit current. Please remove all
wristwatches, rings and other metal personal objects before maintenance or repair, and only use tools with
insulated grips and handles for maintaining or repairing.
When replace the batteries, install the same number and same type of batteries.
When replace the parallel batteries, make sure the new battery is full charged.
Do not open or destroy batteries. Escaping electrolyte can cause injury to the skin and eyes. It may be
toxic.
Please replace the fuse only with the same type and amperage in order to avoid fire hazards.
8.2 We will not send separate notice, provided that the contents of this specification are changed due to
improvement of product quality or technological upgrading; provided that you want to understand the latest
information of this product, please contact us.
8.3 The warranty period of this product is within 60 months after it is delivered. We will maintain the
product, which is in the warranty period for free of charge, provided that it has any product quality problems within
the specified operation range, we may replace the relevant parts, if we fail to maintain it, so as to achieve the
purpose of sustainable use without performance reduction, our after-sales service personnel will propose the specific
maintenance and troubleshooting methods.
9. Graph
9.1 . Graph of cycle life at different DOD 100%, 80%, 60%, 40% at 25℃
9.2 . Graph of cycle life at different DOD 100%, 80%, 60%, 40% at 30℃
9.4 . Graph of cycle life at different DOD 100%, 80%, 60%, 40% at 40℃
9.5 . Graph of cycle life at different DOD 100%, 80%, 60%, 40% at 45℃