Professional Documents
Culture Documents
Palo Alto: Lab Prepration Guide
Palo Alto: Lab Prepration Guide
Username: admin
Password: admin
>configure
#commit
Step3- verify
Note:- when you are not specifying source while doing ping, it’ll take management ip address in
source.
By GUI
Note: System clock changes occur immediately and do not require a commit.
Step2- Type admin in both the Name and Password fields & Click Login.
Type the new password again in the Confirm New Password field.
Click OK
2- DNS and NTP setting
Step1- go to device > setup >services > edit
Step3- For NTP setting, so to NTP tab, enter primary and secondary NTP server
By default, the firewall uses management interface to communicate to various servers including
DNS, Email, Palo Alto Updates, User-ID agent, Syslog, Panorama etc. Service routes are used so that
the communication between the firewall and servers go through the dataplane.
Setting a Service Route for Services to Use a Dataplane Interface from the Web UI and CLI
Web UI
Go to Device > Setup > Services > Service Route Configuration and configure the
appropriate service routes.
To configure service routes for non-predefined services, the destination addresses can be manually
entered, as shown below:
LAB 3 How to Factory Reset a Palo Alto Firewall
Note- Before factory reset, save all configuration, logs etc.
Step3- During the boot sequence, the screen should look like this:
Step2- Reboot your Palo Alto Networks device into maintenance mode with
User: maintd