Professional Documents
Culture Documents
ENGINEERING DEPARTMENT
1
OILY WATER SEPARATER
(OWS) 2
INTRODUCTION
• Oil water separator is mainly use to separate the oil and water in the bilge wells before transfer
to outboard.
• There are 08 bilge wells in SLNS PARAKRAMABAHU. Three of them are placed in Forward
auxiliary engine room, Two wells located in main engine room, Two of them located in port
and Stbd shaft alleyways and the last one located in After auxiliary engine room. Where the
OWS also fitted.
3
TECHNICAL DETAILS
Model : YWC-1.00
Treatment capacity : 01 m3/h
Pressure at discharge outlet : < 0.12 Mpa
Pump suction height : <5m
Discharging height : <5m
Discharge water quantity : < 5 m3/h
Gross power : 4 Kw
Holding tank for oil water : 3 m3
Dry weight : 700 kg
Wet weight : 1400 kg
Dimensions : 1000 X 1000 X1650 mm
Space of operation : front<600,left<600
4
MAIN COMPONENTS
• The plant take the suction from storage tank to separate oil and water. The plant consist of,
• Mono pump.(vacuum pump / screw pump).
• Primary filter.
• Secondary filter.
• Membrane.
• Dosing pump.
• Pneumatic three way valve.
• Concentration meter.
• Double needle pressure gauge.
• Vacuum pressure gauge.
• Temperature gauge.
• Flow meter.
• Control panel.
• Electric heater
5
ENVIRONMENTAL CONDITIONS
• Temperature - 0-55 °C
• Humidity - ≤ 98%
• Heel - ±15
• Roll - ±45 (7s -10s cycle)
• Pitch - ±10 (3s -5s cycle)
6
SYSTEM DIAGRAM
7
≤15 PPM
Collecting tank
Sludge tank
8
≥15 PPM
Collecting tank
Sludge tank
9
10
OWS PLANT TALLY PLATE
11
Thank you
12