Professional Documents
Culture Documents
Please EDIT the text HIGHLIGHTED in RED as per the experiment before printing
TESTING OF A RECTIFIER CIRCUIT
Aim/Objective:
1.To study and perform soldering of a full wave bridge rectifier circuit on a
printed circuit board.
Equipment/Components Required:
Precautions:
Procedure:
1. Select the required devices from the proteus 8 software.
2. Arrange the set-up as shown in the figure below.
3. Click ‘run’ to run the circuit.
4. Obtain the graph.
Circuit Diagram:
The fan speed is minimum in this case. The lamp glows as the circuit is
complete.
The regulator is at 50%, hence the speed of the fan is slower than 100% and
faster than 0%. The lamp will glow since the switch is turned on.
The regulator is at 100%, hence the speed of the fan is the maximum. And the
lamp glows since the circuit is complete.
APPENDIX