Professional Documents
Culture Documents
(Regulations 2017)
15 10 45 10 10 10 100
1.
(i) Using standard 2D CAD software, Create the 2D Drafting of Assembled BUSHED
BEARING in the following views.
1. Front View With right half in section
2. Top View
3. Side View. (65 Marks)
2.
(i) Using standard 2D CAD software, Create the 2D Drafting of Assembled PLUMMER
BLOCK in the following views.
3. (i) Using standard 2D CAD software, Create the 2D drafting sectioned-Front View of Assembled
NON-RETURN VALVE. (65 Marks)
(ii) Sketch the following types of keys in two views, as fitted in position between a shaft and the
Mounting. Choose the shaft diameter as 30 mm and the hub diameter of the mounting as 60 mm:
(a) Hollow saddle key, (b) flat saddle key, (c) taper sunk key, (d) Single headed feather key, (e)
Woodruff key.
Page 4 of 20
4. Using standard 3D CAD software, Create the 3D modelling and assembly of PROTECTED
FLANGE coupling. (65 Marks)
5. Using standard 3D CAD software, Create the 3D modelling and assembly of Universal Coupling
6. (i) Using standard 3D CAD software, Create the 3D modelling and assembly of OLDHAM coupling
(65 Marks)
7. (i) Using the standard 3D CAD software, Create the 3D modelling and assembly of MUFF
COULPING. Assume D=45mm. (65 Marks)
8. (i) Using standard 3D CAD software, Create the 3D modelling and assembly of KNUCKLE Joint.
(65 Marks)
(ii) Sketch and Explain any 10 riveted Symbols used in Engineering Drawings
Page 9 of 20
9. (i) Using standard 3D CAD software, Create the 3D modelling and assembly of GIB and COTTER
JOINT. (65 Marks)
10. Using standard 3D CAD software, Create the 3D modelling and assembly of CROSSHEAD. (65
Marks)
11. (i) Using standard 3D CAD software, Create the 3D modelling and assembly of Sleeve and Cotter
Joint. (65 Marks)
12.
Using standard 3D CAD software, Create the 3D modelling and assembly of PISTON Joint. (65
Marks)
13.
Using standard 3D CAD software, Create the 3D modelling and assembly of CONNECTING ROD.
(65 Marks)
14. Using standard 3D CAD software, Create the 3D modelling and assembly of STUFFING BOX. (65
Marks)
15. Using standard 3D CAD software, Create the 3D modelling and assembly of SCREW JACK. (65
Marks)
16. Using standard 3D CAD software, Create the 3D modelling and assembly of MACHINE VICE. (65
Marks)
17. Using standard 3D CAD software, Create the 3D modelling and assembly of TAIL STOCK. (65
Marks)
18. Using standard 3D CAD software, Create the 3D modelling and assembly of TAIL STOCK. (65
Marks)
19. Using standard 3D CAD software, Create the 3D modelling and assembly of Vane PUMP. (65
Marks)
20. Using standard 3D CAD software, Create the 3D modelling and assembly of GEAR PUMP. (65
Marks)