Professional Documents
Culture Documents
Pressure Vessel RT Test
Pressure Vessel RT Test
The Pressure Vessel RT Test article provides you with information about Radiography
testing in the pressure vessel manufacturing process and related items in pressure vessel
inspection.
Do you know what your pressure vessel RT test requirements are? Is full radiography
mandatory for your vessel? When is full radiography mandatory? What are the acceptance
criteria? What are the RT symbols?
So if you need this information, this article answers all of these questions.
We recommend that you to review this article in conjunction with the ASME Pressure Vessel
Joint Efficiencies article.
Before going into the RT test, we need to know about joint categories. These categories are
base on ASME Code Section VIII:
Category A:
Category B:
Category C and D are flange welds and nozzle attachment welds respectively
Longitudinal weld (Category A) is more critical because it is subjected to double the stress
than Circ. Weld (Category B) and this the reason in different part of the ASME code, we
have stringent rules in category A joints compared to category B joints.
When one of following conditions is existing, you need to do the full radiography:
4. All category A and D butt welds in a vessel when “Full Radiography” is optionally
selected
5. As you see, the item numbers 1, 2 and 3 are really mandatory for a full RT test;
6. But pressure vessel manufacturers can make an optional decision for full radiography
in item number 4
8. Because the joint efficiency in the full radiography condition is 1, the higher joint
efficiency in the pressure vessel wall thickness formula causes less wall thickness.
The manufacturer might save lots of money with a lower thickness plate material.
9. But code has given some bonus to manufacturers in item 4, because it is not
mandated to do full radiography in all butt welds. Manufacturers can do spot
radiography in B and C joints with the same joint efficiency of item 1.
10. Item number 2 describes thickness limitations. Any pressure vessel material is
designated to the specific P. Number by ASME section IX, so there are several
tables in ASME Code Section VIII Div. 1 Subsection C, which determine this
limitation.
11. For example, SA 516 material is P Number 1, and needs to be fully radiographed if
its thickness is greater than 1.25 of an inch. At the same time, SA 204 material is P
Number 3 and needs to be fully radiographed if the thickness is greater than 0.75 of
an inch.
13. Acceptance criteria for welding defects in full radiography is stringent. These criteria
are stated in UW-51 and UW-52 in ASME Code Section VIII Div. 1
14. It means there is a defect if interpreted based on the full radiography criteria in UW-
51, and it might be rejected, but if it is interpreted by the spot radiography criteria in
UW-52, it might be accepted.
One spot shall be examined on each vessel for each 50 ft. increment
Each spot examination will be made as soon as practicable after the completion of
the increment of weld to be examined
The location of the spot shall be chosen by the Inspector after the completion of the
increment of welding to be examined
In fact, SNT-TC-1A can be used as a guideline for manufacturers to establish their written
practice for qualification and certification of their personnel.
ASME Code Section VIII Div 1 mandates that all tests shall be done based on ASME Code
Section V, article number 2.