Professional Documents
Culture Documents
Astm C 113-02
Astm C 113-02
This standard has been approved for use by agencies of the Department of Defense.
Copyright © ASTM International, 100 Barr Harbor Drive, PO Box C700, West Conshohocken, PA 19428-2959, United States.
--`-`-`,,`,,`,`,,`---
--`-`-`,,`,,`,`,,`---
6.4 Test Temperature Schedule—Operate the kiln so as to
conform to the appropriate heating schedule for the class of 9. Keywords
refractory being tested as shown in Table 1. Adjust the firing 9.1 heating schedule; refractory brick; reheat change; tem-
during the hold period so that the temperatures will average the perature measurements; test atmosphere
NOTE—Relative precision does not apply since values pass through the point of zero.
Schedule B Schedule C Schedule H Pooled
2550°F 2910°F 3090°F Precision
Hi-Duty 70 % S. Duty 70 % 90 % 70 % 90 %
Fireclay Alumina Fireclay Alumina Alumina Alumina Alumina
Linear change
average % −0.11 +0.79 −0.49 +2.89 +0.16 +2.43 +0.83 ...
Precision
Repeatability II 0.32 0.34 0.35 0.36 0.18 0.53 0.41 0.36
Reproducibility IR 0.34 0.72 0.81 0.56 0.25 0.79 0.49 0.60
ASTM International takes no position respecting the validity of any patent rights asserted in connection with any item mentioned
in this standard. Users of this standard are expressly advised that determination of the validity of any such patent rights, and the risk
of infringement of such rights, are entirely their own responsibility.
This standard is subject to revision at any time by the responsible technical committee and must be reviewed every five years and
if not revised, either reapproved or withdrawn. Your comments are invited either for revision of this standard or for additional standards
and should be addressed to ASTM International Headquarters. Your comments will receive careful consideration at a meeting of the
responsible technical committee, which you may attend. If you feel that your comments have not received a fair hearing you should
make your views known to the ASTM Committee on Standards, at the address shown below.
This standard is copyrighted by ASTM International, 100 Barr Harbor Drive, PO Box C700, West Conshohocken, PA 19428-2959,
United States. Individual reprints (single or multiple copies) of this standard may be obtained by contacting ASTM at the above
address or at 610-832-9585 (phone), 610-832-9555 (fax), or service@astm.org (e-mail); or through the ASTM website
(www.astm.org).
--`-`-`,,`,,`,`,,`---