Professional Documents
Culture Documents
Basic Command For 2G BTS
Basic Command For 2G BTS
2. If site down check the condition of PCM –if it is ABL (not working) verify the
loop test to identify the fault and if PCM is working check the alarm on BTS.
It gives TG VAULE
NTCOP: SNT=snt$;
Find the device no that is used in dev$ and corresponding vaule of DIP
5. If PCM condition found working then BLOCK /DEBLOCK to get managed object
in working condition use command
RXBLI:MO=mo$,subord,force;
RXESE:MO=mo$,subord;
RXESI:MO=mo$,subord;
RXBLE:MO=mo$,subord;
Page 1 of 4
6. For finding the faulty managed object use command
This alarm list contains various alarms like BTS INT UNAFFECTED, BTS INT
AFFECTED, PERMANENT FAULT, some alarms can be removed by using
BLOCK/DEBLOCK commands.
RXMFP: MO=mo$;
This command shows fault code class and code some description is bellow
Page 2 of 4
Wait for operation condition by 5minute if not operational block/deblock from
BSC if not work contact with MSC Gorakhpur
Same processors adopt for CDU replacement (except Local/remote)
Caution must be taken for wiring of units
Page 4 of 4