Professional Documents
Culture Documents
Digital Sound Level Meter: Caution
Digital Sound Level Meter: Caution
LCD
2. Specifications CAUTION
DIGITAL 2-1. GENERAL SPECIFICATIONS ・Do not apply strong shock to the instrument, such
as dropping off or vibration.
SOUND LEVEL 1. DISPLAY (LCD) :
・Do not get the instrument wet. Keep dry.
METER a. Numerical Display : 11mm high
b. Units and Symbols : dBA, dBC, FAST, SLOW, MAX,
・Do not polish the case with the fluid that
contains alcohol to prevent the cracking.
MIN, HOLD, ,
Instruction Manual ・Remove the battery when the instrument is
2. MICROPHONE : 1/2 inch Electret condenser microphone
out of use for a long time. The exhaust battery
KG-70 3. MEASURING RANGE :
might leak electrolyte and corrode the inside.
Fig-2
A Weighting : 30dB to 125dB,
・Do not use any battery that have wrong rated : Low battery warning
C Weighting : 30dB to 125dB
specification.
4. SAMPLING RATE : 2 times/second : Auto power off
・Install the battery with the correct polarity as
5. ACCURACY : ±5dB : MAX measurement
shown in the plus○ + and minus○ − indications.
6. FREQUENCY RANGE : 31.5Hz to 8kHz : MIN measurement
・Dispose the exhausted battery in accordance
7. DYNAMIC RANGE : 50dB
with the local government rule after applying : Frequency weighting A is selected
8. RESOLUTION : 0.1dB
adhesive tape to both electrodes to make : Frequency weighting C is selected
9. OVERRANGE INDICATION :
them insulated. : Display Hold
"OL" appears when the upper limit of measuring
For Safety Measurements!! range is exceeded. : FAST mode is selected
To prevent an electrical shock hazard to the operator "Lo" appears when the measured value is below the : SLOW mode is selected
Cautions for safekeeping
and/or damage to the instruments, read this instruction lower limit.
10. TIME WEIGHTING : Do not keep the instrument in the following place.
manual carefully before using the instrument. WARNINGS Tear off the Display Film on LCD when using this
125ms (FAST mode) or 1s (SLOW mode) ・The place where has the water splash
with the symbol on the instrument and this instruction instrument for the first time.
11. BATTERY WARNING : ・The place where applies the hard shock
manual are highly important.
" " indication at approx. 7.2V or less ・-10℃ or less, 60℃ or more, 70%RH or more
The symbol listed in IEC 61010- 12. DISPLAY HOLD : Hold indicating values by HOLD Key ・The place where has the condensation
4-2.WIND SCREEN
1 and ISO 3864 means "Caution" 13. AUTO POWER OFF : ・The place where is exposed to direct sunlight
Power turns off automatically after If the wind speed exceeds 10m/sec, please attach the
(refer to instruction manual).
approx. 5 minutes (cancelable) wind screen to the microphone by inserting the
The symbol in this manual 14. OPERATING TEMPERATURE & HUMIDITY : microphone nozzle into the insertion hole of the wind
advises the user of an electrical 5℃ to 40℃, less than 80%RH in non-condensing
WARNING shock hazard that could result 15. STORAGE TEMPERATURE & HUMIDITY :
screen. This can decrease the measurement errors caused
by wind noises.
in serious injury or even death. -10℃ to 60℃, less than 70%RH in non-condensing 4. Name Illustration
16. ALTITUDE : Up to 2000m
The symbol in this manual 17. POWER SUPPLY : 9V 6F22 x 1 4-3. POWER Key
advises the user of an electrical 18. POWER CONSUMPTION : Press this key to turn on / turn off.
CAUTION shock hazard that could cause 12mA in normal, 13mA with LCD Backlight on
WIND SCREEN
injury or material damages. 19. OPERATING POWER SUPPLY VOLTAGE : MICROPHONE 4-4.LIGHT Key (LCD Backlight)
approx. 7.2V up to 9.6V
Press this key to turn on / turn off the LCD backlight.
20. CONTINUOUS OPERATING TIME : approx. 18 hours
21. DIMENSIONS : 193(H) x 67(W) x 44(D)mm
Introduction 4-5.HOLD Key (Display Hold)
(Wind Screen detached)
Thank you for purchasing "KG-70 DIGITAL SOUND LEVEL 22. WEIGHT : Approx. 184g (include battery) Press this key to hold displayed value on LCD.
METER". To obtain the maximum performance of this 23. ACCESSORIES : Wind Screen, KG-70 ("HOLD" lights up).
SOUND LEVEL METER
instrument, read this Instruction Manual carefully, and 9V 6F22 Battery x 1(Installed), Instruction Manual To release it : Press HOLD Key again.
take safe measurement. 24. OPTIONAL ACCESSORIES : 1026 Carrying Case LCD