Professional Documents
Culture Documents
ACR50estima Manual Book
ACR50estima Manual Book
・Driving defends traffic rule manners, and distributes the nature to a natural environmental protection.
・Please read "HDD navigation system manual" of the separate volume also if you
installed the HDD navigation system.
・Please read "..esthetics.. Masa id lift up seat manual" of the separate volume also the
installation of the side lift up seat.
・Toyota..shop..install..equipment..shop..installation..option..handle..
the..commodity..attachment..manual..read.・Please
claim the catalog about equipment in the shop.
・Please ask the charge sales staff an uncertain point.
Please acknowledge the content of this book to be might not corresponding to the car because of the change in the specification etc. of the car.
..PM page..2 3
Chapter 1: I must would like you to defend without fail for the safety drive.
"It is likely to reach injury and a serious accident and the vehicle fire" "General attention"
and the evasion method consolidate in this chapter and, and, it is described. It is
important, and read, please.
Chapter 7: Maintenance
It explains the method and the daily check of the maintenance of the car.
Other displays
"Thing convenient when knowing" and "It would like you to know" have
been described by the following display.
- It describes in this book based on the international unit system (unit of abbreviation SI) along with the enforcement of
new Measurement Law, and it describes during {} so far.
- Because this page is a sample, the content of the description is different from an actual car.
..PM page..5 6
Contents
Illustration contents 8
I must would like you to
・For safety and a comfortable drive 14
defend without fail for the ・About the safety equipment 41
safety drive. 13
Basic operation understanding ・Opening and shutting of each part 108
(To the person who takes this car for the first time. ) ・Adjustment of seat 110
・Wearing of seat belt 112
107
・Smart entry & start
system 126
Handling of driving ・Opening and shutting of door door the glass etc. 164
・Adjustment of seat 214
device 124 ・Seat arrangement 236
・Wearing of seat belt 266
Contents
The
・How to use of the indoor
・Handling of ETC 456 Handling indoor
fixture (room lamp etc.). 472 equipment
How and
to attention
・Economical driving 560
associate
・For the environmental protection 563 . drinking..
car
Myriad
・Tire blowout emergency repair kit 664 ・About pulling 666
・When the battery goes up, 658. ・When the accident happens 670
One[Notoki]
・When overheating 662
Illustration contents
Instrument panel
The reception desk window shield glass switch with heat ray 372
Accessories outlet main switch 496
Intelligent parking assistance main switch
Refer to separate volume "HDD navigation system manual".
Light switch 356
Direction instruction lever 3 5 9
Fog lamp switch 362
Driver's seat upper box 482
Meter, warning light, and pilot light 3 1 6
Wiper & washer switch 363
Engine switch 139
Emergency blinking light switch 3 7 3
Gear-shift 296、302
- The difference of equipment and the option equipment, etc. are contained.
..PM page..9
Contents
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
Power slide . drinking..
door main switch 175 car
Horn 375
One[Notoki]
Distance between two cars switch switch 3 8 6
Driver's seat under box 483
Index
- The difference of equipment and the option equipment, etc. are contained.
..PM page..10
Illustration contents
Room -
Sun visor/vanity mirror 472
Inner mirror 291
Integral reception desk personal lamp of room lamp 477
Power slide door switch (both sides power slide door installation car) 177
Power backing door switch 189
Rear sun shade switch 198
Reception desk San shade 199
Power window switch (driver's seat) 192
SRS curtain shield air bag 503
Nine type in rear seat wide display
Refer to separate volume "HDD navigation system manual".
Reception desk seat belt 269
Adjustable seat belt anchor 270
Rear air conditioner/rear cooler function 446
Rear sun shade switch 198
Rear sun shade 198
Rear personal lamp 478
Long slide
console 487
Reception desk seat 216
SRS side air bag 503
Power window
switch rear 192
Second seat 222
Rear armrest 227
Third seat 232
Separation storage type seat belt 273
The difference of equipment and the option equipment, etc. are contained.
10
..PM page..11
Illustration contents
Vehicle externals Contents
Number-plate light 5 8 8 、 6 1 1
Rear wiper 364
Warning
High-mount stoplamp 588、611
Backing door 1 8 3
Taillight and retreat light 5 8 8 、 6 1 1
Taillight and rear turning indicator and braking light/emergency blinking light 588、611
. earliness.. Basic
Slide door 170 operation
Child protector 182 [wakari]
device
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
Reception desk direction instruction light and emergency blinking light 588、611 How and
to attention
Headlamp (high beam) 588、611
Reception desk fog lamp 588、611 associate
. drinking..
Headlamp (low beam) 588、611 car
Front position light 588、611
Tire 575、615
Supplementary confirmation device 2 9 5
Side direction instruction light and emergency blinking light 5 8 8 、 6 1 1 Maintenance
Fuel lid (fuel supply inlet ) 205
[Aerasu]
Reception desk fog lamp 588、611
Myriad
One[Notoki]
Index
- The difference of equipment and the option equipment, etc. are contained.
11
..PM page..12
12
..PM page..13
. . . . . . . for safety
2. Attention of 4WD
car 70
Warning
13
f
com
a
o r]
Fsu
[Ya
Please execute maintenance.
[N i]
It might cause a serious car trouble if
it doesn't execute it and is dangerous.
Warning
1.
1. Asking for maintenance execution
Asking
for
maintenance
execution
[**]Please execute maintenance.
14
f
com
a
o r]
Fsu
Please defend the following matter before
[Ya
going out.
[N i]
In the worst case, it reaches an unexpected
accident and serious injury if it doesn't guard or,
Warning
it is likely to lead to the death.
2. Attention at the previous state of going out 2.
Attention
at the
[**]Please never do the engine start outside the window of the car. previous
state
- It might cause an unexpected accident, it is dangerous, and get under the wheel, of going
out
please.
- The catalytic device causes the abnormal combustion by the unburned gas in the state of [**] machine shortage, and
it is likely to damage it. -
[**] machine is enough by extent where the indicator of the water temperature meter begins to move.
- It might become impossible to ventilate enough in the car because air cannot be introduced,
humidity in the car such as rain go up, the glass become cloudy, and view worsen.
15
For safety and a comfortable drive
Attention
at the - If the fixation of the steering wheel is insufficient, it divides as the position of the steering wheel is sudden, might
previous cause an unexpected accident, and is dangerous while running.
state
of going
out
- It becomes impossible to narrow in the brake pedal and the gas pedal when there are an empty
can etc. , and to operate the brake, and it might cause an unexpected accident as the gas pedal
doesn't return and is dangerous. Moreover, it is disturbed the movement of the seat, and cannot
fix the seat, might cause an unexpected accident, and is dangerous.
16
For safety and a comfortable drive
[**]Please do not use the floor mat not suitable for the car.
- Correctly it doesn't pave, and it becomes an
obstruction of the operation of the brake pedal,
and the return of the gas pedal worsens if
the floor mat is paved repeatedly, and the floor Warning
Attention
at the
previous
- Please pave what suitable for the car correctly. state
of going
Moreover, please fix with a fixed clip out
etc. so as not to shift. The hole of
the carpet is for the fixed clip installation
used to prevent the Toyota pure floor
mat from shifting.
Fixed clip
Hole of carpet
- It dashes out when time that slammed on the brakes and the car are turning luggage, might
cause an unexpected accident by the nature's hitting the crew, damaging luggage, and being
taken in luggage, and is dangerous. -
Please put luggage on the luggage room in the stable footing (For instance, to evenness forward
of the luggage room). Please fix luggage with the net and the rope, etc. with
a deck hook of the luggage room if necessary. (Refer to P.492. )
17
For safety and a comfortable drive
2.
Attention
at the - It ignites at the emergency, might cause the vehicle fire, and is dangerous.
previous
state
of going
out
18
For safety and a comfortable drive
2.
Attention
- Drunken driving is prohibited by the law. - at the
Drunken driving exerts the influence on the judgment, eyesight, and powers of attention, might cause a previous
serious accident, and is dangerous also in very danger, and very small amount alcohol. state
of going
out
[**]Please confirm in the body below the floor level in the engine room, there are no
animals of small size of the cat and the rat, etc.
- It might cause the function trouble by animals of small size' being rolled in the fan
and the belt when the engine starts.
19
f
coma
o r]
Fsu
Please defend the following matter when you
[Ya
[N i]
replenish the fuel.
Important injury might be received if it
Warning doesn't guard and it is dangerous.
3.
3. Attention at fueling
Attention
at
fueling
- In a specified fuel of the car, equipped with 2AZ FE engine, nonlead regular gasoline and a specified
fuel of the car equipped with 2GR-FE engine are nonlead premium (nonlead high octane) gasoline.
Please confirm the fuel specified when refueling. The phenomenon of the output
decrease of the engine etc. is generated though it is possible to use also with the nonlead regular gasoline
when the nonlead premium gasoline is unavailable in the car equipped with 2GR-FE engine. -
The start of the engine might worsen, the knock be generated, and the output decrease if
the fuels (inferior gasoline, light oil, kerosene, and alcohol system fuel, etc.) other
than specification are used. As it is..use..accident to the
engine..fuel..part..damage..fuel..leak..cause..specification..fuel..
excluding..use.
20
For safety and a comfortable drive
3.
21
f
coma
o r]
Fsu
Please defend the following matter
[Ya
when you run.
[N i]
In the worst case, it reaches an unexpected
accident and serious injury if it doesn't guard or,
Warning
it is likely to lead to the death.
4.
4. Attention when running
Attention
when
running
- It might work neither the brake twice power device nor the power steering, worsen working
of the brake, become very heavy the steering wheel, cause an unexpected accident, and
be dangerous if it doesn't engine starts. -
It might cause an unexpected accident when it keeps pushing the engine switch by mistake, and
the engine stops and is dangerous while running.
- Driving is mistaken while adjusting it, and it moves suddenly the seat, might cause an unexpected
accident, and is dangerous.
22
For safety and a comfortable drive
Warning
4.
Attention
[**]Please do not put the foot on
when
the brake pedal, and run with
running
the parking brake put.
- It wears out the brake pad early, and overheats the brake, worsens working of the brake,
might cause an unexpected accident, and is dangerous.
- Working of the brake might worsen by overheating when keeping stepping on the brake pedal
and it is dangerous.
23
For safety and a comfortable drive
[**]Please start the engine when you move the car a little.
- It might work neither the brake twice power device nor the power steering, worsen working
of the brake, become very heavy the steering wheel, cause an unexpected accident, and
be dangerous if it doesn't engine starts. -
Warning It might cause an unexpected accident when the car is moved by not starting up an engine, and using the
slope and is dangerous.
4.
Attention
when
running
- To prevent the motor and the computer from becoming hot too much when it kept being long, the
steering wheel control might become heavy the state spent fully the steering wheel the repetition of the
steering wheel control when being stopping and minute and low-speed running.
In this case, the steering wheel control returns normally when putting it without operating the steering
wheel at a while.
- It is prohibited to use the car telephone and cellular phones other than hands-free while those
who drive are driving by the law. -
It turns to the telephone when it calls it and when it has had a telephone call note,
might cause an unexpected accident, and is dangerous.
Please use it after it stops in the place of safety when those who drive use the car telephone
and cellular phones other than hands-free.
24
For safety and a comfortable drive
4.
- Please the bumper might be damaged, and risk the speed and run carefully Attention
when you run in the following places.
[**]When passing over the place with the difference in the doorway etc. of the parking lot. when
[**]When you run in the place where the inclination like the slope etc. of the multistory parking garage is sudden. running
[**]When garrisoning stopping along the place and the shoulder that includes trigs etc.
[**]When you run on the road in the ruggedness and the rut that is.
[**]When you pass the hollow (hole) etc.
[**]When it goes into the acclivity and the downward slope from the smooth road, and it goes into the smooth road from
the acclivity and the downward slope.
- The sudden braking, the rapid acceleration, and the abrupt steering in a slippery road become impossible for
the tire to slip, and to control the car it, might cause an unexpected accident, and are dangerous. -
An engine brake by the improvement shift down of the shift and a rapid change in the engine
rotational speed might cause an unexpected accident by sideslipping by the car and are
dangerous. -
Please decelerate beforehand in a frozen place such as on the bridge and shade when it is
cold, and run carefully. -
Please run carefully in beginning get off about rain so that the road is slipperier.
25
For safety and a comfortable drive
4.
Attention - It might cause a serious car trouble to damage the engine by not only the engine stall if running
on the water-covered road but also the inhalation of the short of electrical equipment and water.
when Please check the following item etc. in the Toyota shop when running on the water-covered
running road by any chance, and soaked in water.
[**]Effective condition of brake.
[**]Change in amount of oil and quality such as engine transmission
transfer (4WD car) differential. (Because water mixes when becoming cloudy,
the exchange of oil is necessary. )
[**]Lubrication is defective in the propeller shaft (4WD car) and each bear and collaborate each.
[**]Please do not push the reception desk defroster switch when you
operate the air conditioner when humidity is very high.
- It is cloudy in the surface of the outside of the window glass in the temperatures fluctuate of air and the
window glass, and might disturb view.
26
For safety and a comfortable drive
- Please confirm surrounding safety enough when you attempt the escape from the Attention
stack. The one is damaged by the power of the escape, and the accident resulting in injury or death might be caused
and it is dangerous. - when
Please do not rotate the tire at high speed. The burst (explosion), and the tire might running
cause an unexpected accident by abnormal overheating in the driving part (differential
gear etc.) and is dangerous. -
Please note the following might damage a transmission and a differential
gear, etc. when you unavoidably repeat advancement and the retreat for
the escape from the stack.
[**]The gear-shift [**]O r , [**]After it puts it in certain [ni], ..gas pedal.. [n] ..lightly.. ..stepping...
Please give [de] to me. Moreover, please never step on the gas pedal while operating
the gear-shift.
[**]Please race neither excessive revving nor the tire.
[**]Please operate the brake gradually after the engine rotation lowers when the
tire runs idle in excess.
[**]Please discontinue this operation when you cannot escape even if it goes several times. -
The following method is effective for the stack escape.
[**]The soil and the snow before and behind the tire are removed.
[**]The tree and the stone, etc. under the tire are allotted.
- When the rope is pulled to the draw hook and the suspension parts, etc. putting
it, the draw hook and the suspension parts might be damaged. Please do not forcibly
pull, and request it from the Toyota shop and JAF, etc.
27
For safety and a comfortable drive
Attention - When the brake pad is wet, it worsens working of the brake, and is taken the steering wheel
effective only of one that has not been wet, might cause an unexpected accident, and is dangerous. -
when Please confirm the brake works normally lightly stepping on the brake pedal several times
running until effective recovers very noting surrounding safety when effective is bad.
- It flies the body when time that slammed on the brakes and colliding, and the head etc. are strongly
stricken, and it reaches important injury or, in the worst case, it is likely to lead to the death.
- In the worst case, it reaches important injury or, it is likely to lead to the death by hitting the one
outside the car etc. , and throwing the head at the window frame at a rapid brake while running when the hand and
the face have been produced.
28
For safety and a comfortable drive
- In the worst case, it reaches important injury when placed between the San shade of the door glass Attention
and the large-scale Moon roof or, it is likely to lead to the death.
when
running
[**]Please do not run with the cap of the glove box and small articles
putting opened.
- It dashes out when slamming on the brakes luggage, might cause an unexpected accident,
and is dangerous.
- It disturbs driving person's view, and becomes an obstruction of the safe driving while starting
and running, might cause an unexpected accident, and is dangerous when running with the one put.
[**]Please do not pull the driver's seat door lever while running.
- Please do not pull the driver's seat door lever while running. In the worst case, it reaches
important injury or, it is likely to lead to the death by the door's opening and being thrown out outside
the car.
[**]Please confirm the triangular emergency sign is surely fixed when you store the
triangular emergency sign in the triangular emergency sign storage space.
- It dashes out when slamming on the brakes if not fixed surely the triangular emergency
sign, might cause an unexpected accident, and is dangerous.
29
f
com
a
o r]
Fsu
Please defend the following matter while running
[Ya
when abnormally noticing.
[N i]
It might cause an unexpected accident and
serious injury if it doesn't guard and is
Warning
dangerous.
5.
5. While running when
abnormally noticing
While
running
when
abnormally
[**]Please stop in the place of safety,
noticing and treat it at once when the warning
light is lit and blinks.
- An unexpected accident might be caused, and the engine etc. be damaged when
running while light and blinked. Please confirm the content of the warning light, and do appropriate treatment.
(Refer to P.328. )
- Please stop in the place of safety at once and contact the Toyota shop when the warning light
becomes the following.
[**]In the state of lighting even if you release the parking brake while the engine is rotating.
In this case, it might cause an unexpected accident as working of the brake worsens, and the slip
distance for brake becomes long and is dangerous. Please step on the brake pedal hard when
effective is bad.
[**]The brake warning light : the ABS& brake assistance warning light or in the state of lighting at the
same time as ..the ABS warning light...
In this case, abnormality might not only occur in ABS or the brake assistance but
also the vehicle becomes unstable in the brake of strengthening.
30
For safety and a comfortable drive
5.
While
running
when
abnormally
- Please firmly have the steering wheel, apply the brakes gradually, and reduce speed.
It becomes impossible for the sudden braking and the abrupt steering to control the vehicle. -
The blowout and the burst are thought at the following time.
[**]When the steering wheel is taken.
[**]When there is an abnormal vibration.
[**]When the vehicle inclines abnormally.
- Please do not run while blowing out. It becomes an unstable running if keeping running
while blowing out, might cause an unexpected accident, and is dangerous. Moreover, the tire
disc wheel and the suspension and the body might be damaged. The spare
tire installation car exchanges at once for the spare tire (Refer to P.634), and the emergency
repair of the tire blowout emergency repair kit installation car (Refer to P.650).
31
For safety and a comfortable drive
- The warning sound generates the warning sound (metallic sound "Key key") by the one
by the brake pad wear indicator while running, and informs those who drive that it approached
the use limit by the brake pad.
Please receive the check at once in the Toyota shop when you generate the warning sound.
- It is lost of the brake pad when keeping running with the warning sound generated,
damages the brake parts, and worsens effective, might cause an unexpected accident, and is
dangerous.
32
f
com
a
o r]
Fsu
Please defend the following matter when you
[Ya
stop garrisoning.
[N i]
In the worst case, it reaches an unexpected
accident and serious injury if it doesn't guard or,
Warning
it is likely to lead to the death.
6. Attention when stopping garrisoning 6.
Attention
when
[**]The parking brake is put, and please stop, and lock the stopping
engine when parting from the car.
- When parting from the car, the engine is obligated to stop without fail, and to be garrisoning
locked by the law. Moreover, the one in the vehicle theft and the car might not be stolen,
and do not put valuables etc. in the car, please. -
Please defend following when parting from the car. It begins to move by uninhabited by the
car if it doesn't defend, might cause an unexpected accident, and is dangerous.
[**]The gear-shift [**][Nisuru].
[**]The parking brake is put.
[**]The engine is stopped.
[**]The door is locked.
- It might connect with a fire when there are combustible one in the rear side of the vehicle and the vicinity of the exhaust
tube and is dangerous. -
Please stop the rear end of the vehicle about 30cm or more apart when the rear side of the vehicle includes
wood and plywood, etc.It discolors and it transforms it with the vehicle exhaust emission, and when the space is a
little, it might connect with a fire and is dangerous. -
Neither dry grass nor the wastepaper must not run on, and pull up a car though is
combustible. When it is to become a high temperature, and near the combustible, it is likely to connect with a fire and the exhaust
tube and the vehicle exhaust emission are dangerous.
33
For safety and a comfortable drive
6.
Attention
- It overheats the exhaust tube, might cause the vehicle fire, and is dangerous.
when
stopping
garrisoning
- It might leak, explode naturally because it becomes a high temperature very much in the car the gas
of the writer and the spray can, cause the vehicle fire, and be dangerous. -
The can of the carbonated drink explodes and the room might be made dirty, and Electricity
Division goods cause to be short. -
The transformation and the crack of glasses of a plastic lens and a plastic material might be caused
because it becomes a high temperature very much in the car.
- It might cause the vehicle fire by an abnormal overheating of the accident by the jack rabbit
start of the car and the engine by unconsciously moving the gear-shift, and depressing the gas pedal
when taking a nap while started up an engine and is dangerous.
The exhaust tube has been damaged, and moreover, the vehicle exhaust emission invades in the car, it becomes
CO intoxication, and it reaches important injury or, in the worst case, it is likely to lead to the death in the
place where ventilation is bad.
34
f
com
a
o r]
Fsu
Please defend the following matter to prevent
[Ya
the gas inhalation.
[N i]
In the worst case, it reaches important
injury if it doesn't guard or, it is likely to
Warning
lead to the death.
7. Attention to vehicle exhaust emission 7.
Attention
to
vehicle
exhaust
- It becomes CO intoxication with carbon monoxide (CO) that fills the vehicle exhaust emission, and is contained
in the vehicle exhaust emission, and it reaches important injury or, in the worst case, it is likely to lead to
the death in the place enclosed in the garage etc.
- The vehicle exhaust emission invades in the car, it becomes CO intoxication if the snow piles in the circumference
of the car while started up an engine, and it reaches important injury or, in the worst case, it is likely
to lead to the death.
35
For safety and a comfortable drive
7.
Attention
- Please receive maintenance in the Toyota shop when you notice abnormality etc. of the damage of the
to
vehicle hole, the crack such as the corrosion of the exhaust tube, and the joint and the exhaust sounds. The vehicle
exhaust emission invades in the car, it becomes CO intoxication if it uses it as it is, and it reaches
exhaust
important injury or, in the worst case, it is likely to lead to the death. -
emission
The exhaust tube becomes a high temperature with the vehicle exhaust emission. Please do after cooling the exhaust tube enough
when you touch the exhaust tube by the check etc.
- The vehicle exhaust emission invades in the car, it becomes CO intoxication if running while opened,
and it reaches important injury or, in the worst case, it is likely to lead to the death. Please confirm
the backing door has closed without fail before it runs.
36
For safety and a comfortable drive
Attention
- Please completely open all windows. -
to
Please receive maintenance promptly in the Toyota shop. It becomes CO intoxication with vehicle
the vehicle exhaust emission when leaving it as it is, and it reaches important injury or, in the worst exhaust
case, it is likely to lead to the death. emission
37
f
coma
o r]
Fsu
Please defend the following matter when
[Ya
you take the child.
[N i]
In the worst case, it reaches an unexpected
accident and serious injury if it doesn't guard or,
Warning
it is likely to lead to the death.
8.
8. Attention when child is
taken
Attention
when
child
is
[**]The child must let me sit on
taken the rear seat.
- The child might cause an unexpected accident the child's operation is anxious in the passenger's seat, and it
not only becomes an obstruction of driving but also touching the driving device and it is dangerous. -
Please use the child protector when you make the child sit on the
rear seat. The door can be prevented the child's mistaking and being opened in the car.
Please refer to P.182 for the use of the child protector.
38
For safety and a comfortable drive
8.
- Might it be not possible to finish supporting when the sudden braking and colliding when the Attention
child is embraced on the knee, the child throw out, and it reaches important injury or, in the
worst case, it lead to the death. - when
Please wear the seat belt even to the rear seat. (Refer to P.266. ) child
- Only the direction up which it winds up operates when the seat belt with the child seat
fixation mechanism draws out the belt to the last minute fully with the mechanism used when
the child seat is fixed (lock mode). (Refer to P.286. )-
It becomes impossible to draw out the belt when it operates the child's playing with the seat belt and
by mistake, and the belt coils around the neck by any chance and it reaches important injury like suffocation
etc. or, in the worst case, it is likely to lead to the death.
Please cut the seat belt with scissors etc. when it enters such a state by any
chance by mistake, and the buckle cannot be removed.
39
For safety and a comfortable drive
Attention - In the worst case, it reaches important injury by placing the hand, the head, and the neck, etc. when
closing when the child operates it or, it is likely to lead to the death. -
when The door might be opened while running, the child throw out outside the car, and it reaches
child important injury or, in the worst case, it lead to the death. -
The child must not operate it with child protector (P.182)
is and window lock switch (P.195) by mistake. Moreover, please operate
taken
it noting that other people's hand, arm or neither head nor necks, etc. are not placed and
rolled when the door glass is opened and when it closes.
- In the car under hot weather, it becomes heatstroke and dehydration if it becomes a high temperature very much,
and the child is left, and it reaches important injury or, in the worst case, it is likely to lead to the death. -
It might cause the vehicle fire by playing with
fire of the match writer and the departure flame cylinder
when the child is left and is dangerous. -
The hand, the head, and the neck, etc. are placed
operating the switch of the power window and [riyasanshe-do]
when the child is left in the car with the power
supply turned on, and by mistake, and it reaches
important injury or, in the worst case, it is likely
to lead to the death.
Moreover, it moves the driving device, might cause
an unexpected accident, and is dangerous. Please
do not leave the child in the car with the power
supply absolutely turned on.
40
f
sa
h e
u tt
o
Ab
Please defend the following matter
about the seat.
In the worst case, it reaches an unexpected
accident and serious injury if it doesn't guard or,
Warning
it is likely to lead to the death.
1. Attention of seat 1.
Attention
of
- The driving operation is mistaken if correct driving posture is not taken and it not only causes an unexpected
accident but also the effects such as the seat belt, supplemental restraint system airbags, and headrests are not demonstrated,
and it reaches important injury or, in the worst case, it is likely to lead to the death.
Please refer to P.214 for correct driving posture.
- Important injury that moves if not fixed the seat, causes an unexpected accident, and is related
to the life might be received and it is dangerous.
41
About the safety equipment
Warning
1.
Attention
[**]The back must not run knocking down the drip
of more than the necessity either.
seat
- The waist belt shifts from the hipbone when collide or bumped from behind when the back also knocks
down the drip more than the necessity, the body receives slipping and strong pressure under the seat belt,
and it reaches important injury or, in the worst case, it is likely to lead to the death.
- Important injury that is not demonstrated the effect of the seat belt and the headrest enough when cannot
not only take correct driving posture but also colliding, and is related to the life might be received and
it is dangerous.
42
About the safety equipment
1.
- A big impact joins the neck when colliding, the important injury related to the life might Attention
be received, and it is dangerous. Please adjust height so that the center of the headrest may
become behind the ear. -
of
The headrest is only for the seat of each row. Please confirm hearing "[Kachi]" and the sound
seat
and fixation when you install it. The important injury related to the life when it is
not possible to fix when the headrest is installed by mistake, and it collides might be received
and it is dangerous.
[**]Please guard the following about the getting on going down to the third
seat.
- Please let me be sure to fix [sekandoshi-to] after it gets on the third seat and it descends.
The important injury related to the life by the movement of the seat when time that slammed on the brakes
and colliding, except for no fixation, and the hit to the crew, etc. might be received and it is dangerous.
43
About the safety equipment
[**]Please do not run taking the person in space to which the back knocked down is
expanded by after the drip and the luggage room and the seat arrangement, etc.
- The important injury related to the life might be received when time that slammed on the brakes
and colliding and it is dangerous.
44
About the safety equipment
[**]Please be too hot and note that the low temperature burn (erythema
and blister) might be caused enough while using the seat heater. (seat
heater installation car)
- Next, please be too hot and note that the low temperature burn (erythema and
blister) might be caused enough while using the heater when it is used to correspond.
[**]Baby and child, elderly person, sick person, and physically handicapped person.
[**]Person to whom skin is weak.
[**]Person with intense tiredness.
[**]Person who used medicine (sleeping medicine and cold [kusuri], etc.) that invites drinking too much and can sleep peel. -
Please do not use it with the good one of the heat-retaining property such as blankets and cushions put.
It overheats abnormally the seat, might lead to the breakdown of the low temperature burn and the seat, and
is dangerous.
45
f
sa
h e
u tt
o
Ab
Please defend the following matter about the
seat only for the child.
In the worst case, it reaches an unexpected
accident and serious injury if it doesn't guard or,
Warning
it is likely to lead to the death.
2.
2. Attention of seat only
for child
Attention
of
[**]Please let a small child who cannot correctly wear the seat belt of the car
seat sit on the seat only for the child appropriate for the body.
only - A complete safety protection support (baby seat) is necessary for the baby including the head and the neck. The
for head because extremely heavily compared with other parts baby's neck is not steady.
child The baby must let me sit on an appropriate baby seat. -
Infant's figure is different from the adult who is the design object of the seat belt.
Infant's pelvis is small, and it hangs to not only the position where the pelvis is low but also
the abdomen in a usual seat belt. In the worst case, strong pressure is received to the abdomen with
the seat belt when colliding, it reaches important injury or, it is likely to lead to the death.
The infant must let me sit on the seat only for an appropriate child.
46
About the safety equipment
Please consult the Toyota shop about the base for bar & [topputeza-anka-] only only
for the seat child seat fixation only for the child. for
child
Standard of selection of seat only for child (For a Toyota pure goods).
Child seat baby seat fixed with bar
& [topputeza-anka-] only for child
seat fixation of this car The above-mentioned is excluded.
Weight Height Reference age Weight Height Reference age
Baby ..less ..less Nine months Baby Less 105 Newborn baby
seat than 9kg.. than of newborn baby - seat than 10kg ..75cm Nine months of
Child nine-18 70cm.. 70-100 nine months- Four Child 9. or -12 months- four
seat .... kg .... cm years old seat 18kg less.. 75- years old
junior 15. cm 100- four years old-
seat 32kg 135cm Ten years old
[**]Please install the seat only for the child to fix surely.
Please install the seat only for the child surely noting the installation position and the direction of the
installation. In the worst case, the seat only for the child doesn't function correctly when the sudden
braking and colliding when the installation is improper, it reaches important injury or, it is likely to
lead to the death.
47
About the safety equipment
- Please never install the seat only for the child in the passenger's seat for [ushiro].
- The high impact joins the back of the seat only
for the child when passenger's seat S RS air bag
swells when installing it for [ushiro] and it
is dangerous.
Warning
2.
Attention
- When the seat (child seat baby seat) only for the child who fixes with bar &
[topputeza-anka-] only for the child seat fixation is installed, please confirm
there is neither foreign body around bar & [topputeza-anka-] only for the child
seat fixation is including the god such as seat belts.
- In the worst case, it flies when the seat only for the child is not fixed when the foreign body and the
seat belt, etc. are bitten and it crowds, and it collides, it reaches important injury or, it is likely
to lead to the death.
48
About the safety equipment
- Please multiply the tension until [teza-beruto] picks up the slack without fail when you install the
seat only for the child.
- The important injury related to the life when colliding might be received if [teza-beruto]
doesn't correctly put it and it is dangerous.
Warning
2.
Attention
of
seat
only
for
- Please pass [teza-beruto] under the headrest.
child
- The important injury related to the life when the seat only for the child is not firmly fixed
when multiplying on the headrest, and it collides might be received and it is dangerous.
- It might cause an unexpected accident by hitting the crew and the one, etc. when having
applied the brakes when indoors leaving it while detached from the seat and is dangerous.
49
f
sa
he
u tt
o
Ab
Please defend the following matter
about the seat belt.
In the worst case, it reaches important
injury if it doesn't guard or, it is likely to
Warning
lead to the death.
3.
3. Attention of seat
belt
Attention
of
seat
[**]All members must wear the seat
belt
belt correctly when you take the
car.
- When the body is not maintained in the seat when time that slammed on the brakes and colliding
if the seat belt is not worn or it doesn't correctly wear it, and the body is thrown or
the S RS air bag swells, the high impact is received and it is dangerous. Moreover, it reaches
important injury by being thrown out outside the car or, in the worst case, it is likely to lead to
the death.
- The back also must adjust the drip, set up the upper
part of the body, sit deeply, and sit.
Shoulder department belt
- Put it enough on the shoulder.
(Do not hang to the neck, and shift from the shoulder. )
- Wearing the seat belt is obligated
by the law. Those who drive must run
after all crew confirm whether to have worn
the seat belt correctly according to the
following use.
Waist belt
- The hipbone must make them
stick to a low position as
much as possible.
- Do not twist.
50
About the safety equipment
- Please wear the seat belt while setting up the upper part of the body, and having sat deeply on the seat.
- Please refer to P.214 for the good posture.
- Please do not wear the shoulder department belt of the seat belt by hanging to the neck and
passing the armpit. Warning
seat
- In the reception desk seat, please adjust the adjustable seat belt anchor belt
surely. (Refer to P.270. )
- Please adjust it at the position where it is high only for the seat belt to finish not hitting the neck and
to take enough to the center of the shoulder. -
Please confirm fixation surely after it adjusts it.
- Please wear it when you use the armrest of [sekandoshi-to] with the waist belt
passed under the armrest without fail.
- Important injury that doesn't demonstrate the effect with an enough seat belt when colliding when
wearing it while having hung to the armrest, and is related to the life might be received and it is dangerous.
- The waist belt of the seat belt must make them stick to a low position as much as possible
and wear the hipbone.
- Strong pressure is received to the abdomen etc. when
colliding when the waist belt of the seat belt shifts
from the hipbone and it is dangerous.
51
About the safety equipment
3.
Attention
of [**]The woman during pregnancy also must wear the seat belt correctly.
However, please confirm notes to the doctor. -
seat The waist belt must wear the hipbone under the swelling of the stomach about wearing the
belt seat belt under the pregnancy to hang to a low position as much as possible though it is similar
to the time usually basically worn.
Moreover, please surely avoid the swelling of the stomach through the shoulder and wear the shoulder department
belt to hang to the chest. -
The belt digs into to the swelling of the stomach when time that slammed on the brakes and colliding
if the belt has not been correctly worn, and not only the mother's body but even also the embryo
reaches important injury or, in the worst case, it is likely to lead to the death.
Waist belt
- Wear the hipbone under the swelling
of the stomach to hang to a low
position as much as possible.
[**]Please wear the seat belt correctly if you have the disease.
However, please confirm notes to the doctor.
52
About the safety equipment
In the worst case, correct driving posture is not demonstrated the effect with Attention
an enough seat belt when colliding when the seat belt twists, is loose or it
doesn't lock surely, reaches important injury or, might lead to the death. -
of
The impact power cannot be distributed enough when colliding when twisting and it is
dangerous. - seat
Please unpick it to install it correctly when the belt has twisted. Please belt
consult the Toyota shop when the twist doesn't get loose well.
- Please do not use it applying slack to the seat belt with the clothespin and the
clip, etc.
- The high impact is received when the distance until the
body is restrained with the belt when colliding when the
shoulder department belt is too loose grows, the head is
thrown at the steering wheel or the supplemental restraint
system airbag swells and it is dangerous.
- When the plate is inserted in the buckle, the plate and the buckle hear "[Kachi]" and the
sound and confirm that it is to the god combination surely.
- The seat belt comes off when the plate might
not completely fit in the buckle when the
foreign body enters, and it collides and it is
dangerous.
53
About the safety equipment
Attention In the worst case, the effect with an enough seat belt is not demonstrated when colliding
when the damaged seat belt is used as it is, it reaches important injury or, it is likely to lead
to the death. -
of
Please place neither seat belt nor the plate between the seat and the door. It might
seat be damaged when narrowing, and dangerous when using it as it is.
belt
- Please it becomes loose, it is possible to be worn out, and exchange seat belts that do not
operate normally at once. Moreover, please do not receive the high impact due to the accident,
and do not use a damaged seat belt. It becomes impossible to demonstrate an original function enough
when colliding.
- There is a possibility that the belt cuts
when colliding when using it as it is. Moreover,
it doesn't work normally, the effect with an enough seat belt is
not demonstrated, and it is dangerous. -
Please exchange it at once for the new article
of pure Toyota when the seat belt doesn't
function normally.
54
About the safety equipment
- Please remodel, resolve or neither installation nor detach the seat belt.
- The seat belt doesn't operate normally when colliding. Please consult the
Toyota shop about the installation, detaching, and the exchange of seat belts.
- Please remodel, resolve or neither installation nor detach the seat belt. Warning
- It is likely not to operate normally
when the seat belt is inadequately 3.
handled, and repair in the Toyota shop,
please. Attention
of
seat
belt
- Please do not use organic solvents such as benzine and gasoline to clean the seat
belt. Moreover, please do not bleach, and do not dye the belt. Strength decreases.
- The effect with an enough seat belt is not demonstrated
when the performance of the seat belt decreases, and
it collides and it is dangerous. -
Please do not use the seat belt until drying
by using the soapless soap or lukewarm water
when you clean it.
55
f
sa
h e
u tt
o
Ab
Please defend the following matter about the
supplemental restraint system airbag.
In the worst case, it reaches important
injury if it doesn't guard or, it is likely to
Warning
lead to the death.
4.
4. Attention of supplemental
restraint system airbag
Attention
[**]The supplemental restraint system airbag is a device that assists the seat belt,
of
S
and no one to take the place of the seat belt.
R In the worst case, the effect of the supplemental restraint system airbag might not be able not
S only to be demonstrated enough when colliding if it sits on the seat by the good posture, and the
air
seat belt is not worn correctly but also it reaches important injury by a strong impact when the
bag
SR S air bag swells or, lead to the death.
Please refer to P.266 for a correct wearing the seat belt.
- Please adjust the seat at a correct position, and sit on the seat by correct posture that the back also applied
the back to the drip.
- The high impact is received when the supplemental restraint system airbag swells when it gets on the middle paragraph of the
supplemental restraint system airbag by the cover guess worth and posture that approaches too much and it is dangerous.
56
About the safety equipment
- Please do not run with the one put with the crew as the one is held on the knee between
supplemental restraint system airbags.
- It flies the one when the supplemental restraint system
airbag swelled and it strikes the face, and normal operation
of the supplemental restraint system airbag is disturbed and
Warning
it is dangerous.
4.
Attention
of
S
- Please start not leaning against the door, and do not approach the reception desk center R
rear pillar and the roof side part. (SRS side air bag &SRS curtain shield air
S
bag installation car) air
- The high impact is received to the head etc. when the supplemental bag
restraint system airbag swells and it is dangerous.
Especially, be careful when the child
is taken.
- Please do not run in the state that makes the child stand in front of the passenger's seat supplemental
restraint system airbag, and holds on the knee.
- The high impact is received when the supplemental restraint
system airbag swells and it is dangerous.
57
About the safety equipment
58
About the safety equipment
[**]Please guard the following when you install the car articles etc.
The supplemental restraint system airbag might not operate normally, and it swells by mistake, it reaches
important injury or, in the worst case, it lead to the death if it doesn't defend. -
Please do not cover the middle paragraph of the supplemental Sticker
restraint system airbag with the cover and the sticker, etc. Warning
Attention
Sticker of
S
R
- Please do not put the one of the aromatic
S
substance etc. on the Instrument panel and the air
dashboard, and do not lean the umbrella etc.It flies
bag
when the passenger's seat supplemental restraint
system airbag doesn't operate normally or the supplemental
restraint system airbag swells and is dangerous.
- The electric wave etc. of the wireless machine might negatively affect the computer that operates the supplemental
restraint system airbag, mis-operate the supplemental restraint system airbag, and are dangerous. Please
consult the Toyota shop when you install the wireless machine etc.
Accessories etc.
- Please do not install accessories etc.
around the SRS [ni-eabaggu] development
department under the Instrument panel. It flies
when SRS [ni-eabaggu] swells and
is dangerous.
SRS [ni-eabaggu]
59
About the safety equipment
- Please install neither accessories nor a Supplemental restraint system airbag development department
hands-free mike, etc. around the SRS curtain
shield air bag development department like the
reception desk window glass, the side door
glass, the reception desk pillar rear pillar,
the roof side part, and assist grip, etc.It
flies when back and forth seat SRS curtain Accessories etc.
shield air bag swells and is
dangerous.
60
About the safety equipment
Attention
Supplemental restraint system airbag development department
61
About the safety equipment
Attention - Important injury such as the burns might be received because complete parts are very hot and
it is dangerous.
of
S
R
S
air
bag
62
f
sa
h e
u tt
o
Ab
Please EBD assistant ABS and defend the
following matter about the brake assistance.
It might lead to the important injury related
to an unexpected accident and the life if it doesn't
Warning
guard and is dangerous.
5. EBD assistant ABS and 5.
attention of brake assistance E
BD
assistant
[**]Be overconfident in neither EBD assistant ABS nor the brake assistance. A
- There are limits in the control of slipping and how of the steering wheel to work, and an impossible driving B S・
might cause an unexpected accident and is dangerous also in the state that EBD assistant ABS and the brake
assistance operate. Attention
Neither EBD assistant ABS nor the brake assistance are overconfident, the speed is suppressed, the distance between two cars is
taken enough, and ..safe driving.. bear it in mind, please.
of
[**]When the grip limit of the tire is exceeded or hydroplaning * happens,
brake
EBD assistant ABS cannot demonstrate the effect.
- Phenomenon to generate water film by high speed operation etc. of rain between tire and road, and to lose earth power.
- EBD assistant ABS is not a device to shorten the slip distance for brake. assistance
In the following cases, the slip distance for brake might become long compared with the vehicle to which EBD
assistant ABS is not lucky. Please do the speed with unassuming modesty and take the distance between two cars enough.
[**]When you run on the gravel walk and the new snow road.
[**]When you install the tire chain.
[**]When you get over the difference such as seams on the road.
[**]When you run in the irregularity road and the bad road of stone [dataminado].
- The brake assistance is not a device that draws out the performance that exceeds an ability the
brake original. The vehicle and the distance between two cars, etc. are very noted and ..safe driving.. bear it in mind, please.
63
f
sa
h e
u tt
o
Ab
Please defend the following matter
about TRC. S-VSC.
It might lead to the important injury related
to an unexpected accident and the life if it doesn't
Warning
guard and is dangerous.
6.
6.Attention of
T
TRC. S-VSC
R
C ・
- There is a limit in securing the direction stability of the vehicle, and an impossible driving might cause an
Attention unexpected accident and is dangerous also in the state that TRC operates. Please drive especially carefully when
the safe driving is always borne in mind, and the slipping pilot light (Refer to P.326) blinks.
of
S
C
[**]Be not overconfident in S-VSC.
- The state that S-VSC operates is in securing the direction stability of the vehicle the limit, and an impossible fate.
It might connect and is dangerous in [ha] and an unexpected . turning.. accident. Please drive especial y carefully when the safe driving is always borne in mind, the SVSC operation warning buzzer (discontinuous
sounds) rings or the slipping pilot light (Refer to P.326) blinks.
64
f
sa
h e
u tt
o
Ab
Please defend the following
matter about the pre-crash safety
system.
It might lead to the important injury related
to an unexpected accident and the life if it doesn't Warning
guard and is dangerous.
7.Attention of pre-crash 7.
safety system
Attention
[**]Be not overconfident in the pre-crash safety system.
- Surrounding circumstances are always noted, the obstacle etc. of the traveling direction are recognized, and ..safe driving..
of
bear it in mind, please when you drive.
worn the seat belt in the situation in which the collision is not avoided
at the time of the operating state. Moreover, [purikurasshubure-kiashisuto]
doesn't operate if not stepping on the brake pedal. safety
[**]Please stop in the place of safety promptly when locking with system
65
Please defend the following matter
about the automatic car.
In the worst case, it reaches an unexpected
accident and serious injury if it doesn't guard or,
Warning
it is likely to lead to the death.
1.
1. Attention of
automatic car
Attention
- The car starts rapidly when the gas pedal is mistaken for the brake pedal and it steps, it causes an
unexpected accident, and it reaches important injury or, in the worst case, it is likely to lead to the
death. -
When retreating, it becomes difficult to operate
the pedal because it becomes posture in which the body
is twisted. Please note that it can ensure
the pedal operation. -
Can take be correct driving posture
when move the car a little, and step on
the brake pedal and the gas pedal
surely.
66
About the driving device
- The brakes operation in the left leg might cause an unexpected accident as the reaction in the emergency Attention
is delayed and is dangerous.
of
automatic
[**]Starting up an engine must start up an engine with stepping
on the brake pedal firmly. car
- As for the gear-shift, the wheel is fixed because of safety. [**][Ni] it puts, and the brake pedal is ..paving.. [].
The borrowing stepping engine must start.
67
About the driving device
Attention
- [**]It might cause an unexpected accident because neither [nisuruto] nor the engine brake work
completely and is dangerous. -
of [**]The lubrication of oil in an automatic transmission worsens when running at
[nishitamama] [naga] time, and it is likely to break down.
automatic
- [**]・ [**]It is, and the car starts rapidly, and it might cause an unexpected accident and is dangerous.
68
About the driving device
[**]The gear-shift in 2.4L car on the slope etc. [**] and [**]In 3.5L car 1.
The gear-shift [**] and [**] Retreating by inertia with [ni] put is absolute.
Mother-of-pearl. Attention
69
Please defend the following matter
about 4WD car.
In the worst case, it reaches an unexpected
accident and serious injury if it doesn't guard or,
Warning
it is likely to lead to the death.
2. 4
2. Attention of 4WD car
Attention
of
W
D
- 4WD of this car (active torque control 4WD) is only for the on-road.
Please be not, and do not drive putting for running in the off-road and the rally running,
etc. because 4WD of securing roadholding in a general road ..impossibility...
- No versatile car even if it is called 4WD car. Please do carefully as well as a general car, and always
bear the safe driving in mind about the operation of the accelerator, the steering wheel, and the brake.
70
About the driving device
car
- It might cause a serious car trouble to damage the engine by not only the engine stall if the underwater
running of the cross a river etc. is done but also the inhalation of the short of electrical equipment and
water. -
Please check the following item etc. in the Toyota shop when soaked in
water by any chance.
[**]Effective condition of brake.
[**]Change in amount of oil and quality such as engine transmission
transfer differential. (Because water mixes when becoming cloudy, the exchange
of oil is necessary. )
[**]Lubrication is defective in the propeller shaft, each bear, and collaborate each.
71
About the driving device
Normal tire
Attention
Studless tire
. coexistence use example .
of
W - Please install all tires of the same size, the same manufacturer, the same brand, and the
D
same tread pattern (ditch pattern) in the tire by a specified size. Moreover, please do not install
car
the tire with a remarkable wear-out difference mixing it. -
It might cause the vehicle fire in the worst case by oil leaking and burning by the temperature of oil
generating an always abnormal rotation difference by the tire in the front, back, left and right if the
tire is existing together used, applying impossible power to the drive and the system parts (differential
gear), and rising and is dangerous.
- The drive and the system parts are negatively affected in the following cases as well as the coexistence use for the tire,
and execute the check of the air pressure in the tires, please.
[**]When the difference of the air pressure of four wheels is remarkable.
[**]When the air pressure shifts from a specified value. -
Please rotate the tire around the tire wear to keep even, and to extend longevity
to four wheels. (Refer to P.575. )-
Please do not install the disc wheels other than specification when you exchange
the disc wheels. (Refer to P.615. )
72
Please defend the following matter
about the radar cruise control.
It might cause an unexpected accident and
serious injury if it doesn't guard and is
Warning
dangerous.
3.Attention of radar cruise 3.
control (with brake control)
Attention
of
control)(with
- The radar cruise control is operated by mistake, and it might cause an unexpected
accident and is dangerous.
brake
[**]Be not overconfident in the control mode between cars. There is a limit in the distance
control between cars. It decelerates, and please always note surrounding circumstances, it control
steps on the brake pedal according to the situation, and secure the distance between two cars of
a proceeding vehicle and the following car by accelerating stepping on the gas pedal and ..safe
driving.. bear it in mind when you drive.
- No mode that automatically operates the brake until the vehicle is stopped. There is a
limit in the deceleration, and moreover, an enough deceleration cannot be likely to be done, and to approach the proceeding
vehicle when it is large the deceleration combination about the proceeding vehicle and another car interrupts the car
front though the brake is controlled. In this case, the approach warning operates and attention is prompted.
(Refer to P.402. )Moreover, the warning sound is released and when ringing, the control is released , saying that "[Pippi]"
when the velocity of the car becomes about 40 km/h or less. (The brake control is released. )
- No one to assist a careless person before boiling looking driving and it drives dimly.
73
About the driving device
[**]It might cause an unexpected accident when the radar cruise control
is used and is dangerous at the following situations.
- It might cause an unexpected accident because the distance between two cars with the proceeding vehicle might not be
able to be measured accurately and is dangerous because of bad weather (rain, fog, snow, and black blizzard, etc.).
Warning
The radar cruise control is automatically released, and it enters the state of the set
standby if the wiper is operated at high speed. (It is not released in low-speed operation or intermittent
3.
operation. )-
It might cause an unexpected accident because the distance between two cars with the proceeding vehicle might
Attention
not be able to be measured accurately when the drop and the snow, etc. adhere to the front of the radar sensor
and is dangerous. -
of It might cause an unexpected accident because it is not possible to run the speed suitable for the situation of the road on
radar the road where a lot of traffic exists and the road in the dogleg that is and is dangerous. -
The tire runs idle, the control of the car might be lost, and it is dangerous on a slippery road on
the frozen road and the snowfall road, etc.-
cruise
It exceeds the set speed because the engine brake doesn't work enough in the sharp
incline, might cause an unexpected accident, and is dangerous. -
It might cause an unexpected accident because it is not possible to run the speed suitable for the situation of the road in
control)(with a traffic situation in which acceleration and the deceleration are frequently repeated and is dangerous. -
It might cause an unexpected accident because the proceeding vehicle cannot be detected on the road where a sudden acclivity
and the downward slope are repeated, and it is likely to approach the proceeding vehicle too much and is dangerous. -
brake When going into the interchange coverage parking area etc. with the expressway etc. when being following
running to a car that is slower than the velocity of the car of the set car (Go out of the main
control line), it is gone because the car leaves the main line of the proceeding vehicle, accelerates up to the
velocity of the set car, might cause an unexpected accident, and is dangerous. -
It might cause an unexpected accident because neither the control of the radar cruise control nor the approach
warning are done and is dangerous for a vehicle that is more extremely slower than the vehicle and the velocity of the car
under the stop. Please note the stop in the tail of the toll gate and congestion and vehicles, etc. where the velocity of the
car is extremely slow enough. -
It cannot keep the distance between two cars appropriate because the detection of the proceeding vehicle that interrupts
closely cannot be delayed because the detection area of the radar sensor is narrow in the short distance, and the two-wheeled
vehicle that runs on the edge of the lane be detected, might cause an unexpected accident, and is dangerous. -
Because this system controls the reflection electric wave on the rear end side of the proceeding vehicle chiefly detecting
it, it cannot in the following cases keep the distance between two cars appropriate because the proceeding vehicle
cannot be detected accurately, might cause an unexpected accident, and is dangerous.
[**]When the proceeding vehicle and the vehicle in another lane reel, raise water and the snow etc. of the road, and it runs.
[**]The proceeding vehicle : when the vehicle rear end area is extremely little like the trailer etc. of an empty load.
74
About the driving device
- The radar sensor is not versatile though judges the dirt of the window of the sensor by the automatic
operation, and has the function to inform them of it.
Even if the front of the sensor is dirty, it is not likely to be able to judge according to the situation. Moreover,
a plastic bag (one that the metal was coated etc.) that is transparent and translucent (Colored
is included) might not be able to be judged when adhering sticking, ice, and [tsuraranado].
Warning
The distance between two cars cannot be kept appropriate in such a situation, it might cause an
unexpected accident, it is dangerous, and run always forward carefully, please. When dirt is judged,
3.
the control is automatically released.
Moreover, please always clean the front of the sensor. (Refer to P.404. )-
Attention
Road..shape..curve..road..right and left..curve..continue..road..curve..gateway..under
construction..lane..restriction..lane width..narrow..road..car..situation..steering wheel
control..lane..position..accident..breakdown..run..unstable circumstance..temporary.. of
next..lane..vehicle..one..detect..control..approach..warn..operate..temporary..proceeding radar
vehicle..detection..proceeding vehicle..approach..unexpected..accident..connect..dangerous.
[**]In the situation in which the approach warning operates frequently, cruise
The approach warning might operate temporarily detecting a vehicle in the next lane and a peripheral thing
according to the situation of the road shape (curve etc.) and cars (position in the steering wheel control
and the lane).
[**]Please note the following when you use the radar cruise control
in the fixed velocity control mode.
- In the fixed velocity control mode, it doesn't operate because it doesn't judge the distance between two cars of presence and
the proceeding vehicle of the proceeding vehicle in the control mode between cars the approach warning, be likely to cause an
unexpected accident, and is dangerous. Please note the distance between two cars with the proceeding vehicle enough. -
Please do not use the radar cruise control (fixed velocity control mode) at
the following situations. It might cause an unexpected accident when using it and is
dangerous.
[**]It might cause an unexpected accident because it is not possible to run the speed suitable for the situation of the road
on the road where a lot of traffic exists and the road in the dogleg that is and is dangerous.
[**]The tire runs idle, the control of the car might be lost, and it is dangerous on a slippery road on
the frozen road and the snowfall road, etc.
[**]It exceeds the set speed because the engine brake doesn't work enough in the sharp
incline, might cause an unexpected accident, and is dangerous.
75
Please defend the following matter
about the cruise control.
It might cause an unexpected accident and
serious injury if it doesn't guard and is
Warning
dangerous.
4.
4.Attention of
cruise control
Attention
of
[**]Please turn off the main
cruise switch when you do not use
the cruise control.
control
- The cruise control is operated by mistake, and it might cause an unexpected accident
and is dangerous.
76
Please defend the following matter
about the lane keeping assistance.
It might cause an unexpected accident and
serious injury if it doesn't guard and is
Warning
dangerous.
5.Attention of lane keeping 5.
assistance
Attention
carelessly with the system that warns the lane deviating, and supports running in the lane. Please do the steering wheel control lane
always voluntarily, correct the course, and ..safe driving.. bear it in mind.
keeping
[**]The system might correctly cause it is possible to being likely to do the function
and an unexpected accident when the lane keeping assistance is used at the following
situations and it is dangerous. Please turn off the system and run. assistance
- When ..white (yellow).. line doesn't get hoarse or it is not easy to see it by becoming dirty. -
When you do not see ..white (yellow).. line easily by rain, the snow, the fog, and the backlight, etc.-
When time when the lens of the headlamp is dirty and the irradiation is weak and an optical axis shift. -
When ..white (yellow).. line becomes interrupted like the examination of tickets place and the toll gate, etc.-
When the change in rapid brightness is consecutive. -
When ..white (yellow).. line and a confusing line look like the rut etc. where the erasing remainder line, the shadow, the remaining snow,
and rain of the road repair collect. -
When you run in lanes other than the main line (cruising lane and overtaking lane) in the expressway etc.-
When you run in the lane of the lane restriction and the temporary housing by construction. -
When the width of the lane is extremely narrow and when it is wide. -
When the distance between two cars with the preceding vehicle shortens extremely. -
When the vehicle has inclined remarkably in heavy loading of luggage and a defective adjustment of the tire inflation pressure, etc.-
When you run on an undulate road and the robbed road. -
When you run rain and the snowfall and to freeze on a slippery road road.
[**]The lane deviating warning function doesn't automatically prevent the lane
deviating.
- When the system judges that it deviates from the lane under running, the lane deviating warning function doesn't
automatically prevent the lane deviating by the function to press the course correction by driving person's steering
wheel control according to warning. Please correct the course by an always own steering wheel control, and ..safe
driving.. bear it in mind. -
The lane maintenance support function is not the one (the assistance of driving person's steering wheel control power, and
running at the center of the lane automatically by the function to support driving). Please correct the course by an always
own steering wheel control, and ..safe driving.. bear it in mind.
- The lane deviating warning might not be operated and operate early according to the running condition
and the road condition. Please always confirm the course, and ..safe driving.. bear it in mind.
77
Please defend the following
matter about smart entry & start
system.
It might cause an unexpected accident and
Warning serious injury if it doesn't guard and is
dangerous.
6.
6.Attention of smart
entry & start system
Smart
entry
[**]The implanted cardiac pacemaker and the planting type defibrillator must
not approach the person in whom the implanted cardiac pacemaker and the
planting type defibrillator are installed from a car indoor transmitter and auto
Attention outdoor transmitter within about 22cm.
- It might influence the operation of the implanted cardiac pacemaker and the planting type
of defibrillator by the electric wave. -
& Please confirm the influence by the electric wave to an electric equipment manufacturers for the medical treatment
start etc. beforehand when an electric equipment for medical treatments other than the implanted cardiac pacemaker and
the planting type defibrillator is used. It might influence the movement of an electric equipment for the medical treatment
by the electric wave. -
system A smart entry & start system is able not to be operated.
Please consult the Toyota shop in detail.
78
Please defend the following matter
about clearance sonar & backing sonar.
It might cause an unexpected accident and
serious injury if it doesn't guard and is
Warning
dangerous.
7.Clearance sonar & backing sonar 7.
Attention of [nitsuite]
Clearance
sonar
backing
- The detectable area of clearance sonar & backing sonar is limited to the vehicle corner part
and the posterior region. Please drive while confirming safety around the vehicle without fail slowly sonar
when you make the car advance and retreat.
[**]Within the range that the sensor perceives, please do not install the
accessories articles etc.
- It doesn't operate normally clearance sonar & backing sonar, be likely to cause an unexpected
accident, and is dangerous.
[**]Please remove the foreign body that attaches to the sensor assembly.
- It doesn't operate normally when mud and [kooriyuki] adhere to the sensor assembly clearance sonar
& backing sonar, be likely to cause an unexpected accident, and is dangerous.
[**]The distance that can be perceived according to the obstacle and the condition might not be
able to shorten, and to perceive it.
- The distance that can be perceived according to the obstacle and the condition shortens, and because it is not likely
to be able to perceive it, it drives while confirming surrounding circumstances without fail.
79
About the driving device
[**]In the following cases, it might not operate normally the device, might cause
an unexpected accident, and is dangerous.
- In the following cases, it might not operate normally the device, might cause an unexpected accident,
and is dangerous. Please drive carefully.
Warning
[**]When ice, the snow, and mud, etc. adhered to the sensor (Return normally if it removes).
[**]When the sensor assembly froze (Return normally if it melts).
7.
[**]When you close the sensor with the hand.
[**]When the vehicle posture inclines greatly.
Clearance
[**]At the hot weather under and the cold.
[**]At irregularity road, slope, gravel walk, and grassy place running etc.
sonar [**]When the one to generate the supersonic wave such as clearance sonar & backing sonars of the airbrake sound
of the engine sound of another car horn and the motorcycle and large-sized cars and another cars approaches
Attention
[**]When downpour and the spray hang.
[**]When you apply an antenna for fender Paul and the wireless machine on the market to the car.
[**]When you advance toward a tall curb and the curb of the right angle.
of
& [**]The detection distance might become short according to the object of the sign etc.
[**]The vicinity of the right under of the bumper is not perceived. No neither object that is lower than the sensor nor a
backing
thin paling, etc. might be suddenly perceived when approaching even if it perceives it once.
[**]When the obstacle approaches the sensor too much, it is likely not to operate.
sonar - The following one might not perceive, might cause an unexpected accident, and is
dangerous. Please drive carefully.
[**]The thin one such as wires and ropes.
[**]The one to absorb sound waves such as cotton and snows easily.
[**]The one with acute angle shape.
[**]It is tall and the one that the part projects.
[**]The short one.
80
i
ma
t
ou
Ab Please defend the following matter when it checks
and you maintain it.
It might cause an unexpected accident and
serious injury if it doesn't guard and is
dangerous.
Warning
Please read "Maintenance note"
1. Attention when checking and maintaining it about details of maintenance.
1.
Check
・
Attention
when
[**]P l e a s e s t o p t h e e n g i n e maintaining
when you check the engine it
- It touches the rotation parts such as belts and fans while the engine is rotating or it approaches,
and the hand and clothes and the tool, etc. are rolled, and it might connect and is dangerous in an unexpected
accident. Moreover, please note that the cooler fan might begin to turn suddenly when the
temperature of cooling water is high even if the engine has stopped. Please do not bring the
fire close to the battery and the fuel piping. It explodes, important injury might be received,
and it is dangerous.
[**]It is not necessary to touch the hot section such as the engine, the exhaust tubes, and
radiators immediately after the engine stop.
- The burn might be done. Please note that oil and other
liquids might be high temperatures.
- It might be short-circuited of electrical equipment, cause the breakdown and the vehicle fire when water
is sprinkled in the engine room, and be dangerous.
81
About maintenance
1.
Check
・ - It causes the car breakdown, and when water splashes to electric parts etc. that the audio and
Attention floor carpet under includes, it might cause the vehicle fire and is dangerous.
when
maintaining
[**]Please note that water doesn't splash directly to the brake when you
it wash a car.
- It becomes impossible for working of the brake to worsen, and to rust, might cause
clinging of the brake, and to run by freezing when water enters in the brake device.
[**]Please do not use fuses other than regulated capacity when you
exchange fuses.
- It overheats, damages wiring by a fire, might connect with a fire, and is dangerous.
[**]Please exchange it after getting cold the lamp when you exchange lamps.
- Please exchange it after getting cold the lamp of turning off each lamp when you exchange lamps.
The burn might be done.
[**]Please do not replenish the washer fluid when time when the
engine is hot and the engine start.
- It might break out when hanging to the engine etc. because an alcoholic element is included
in the washer fluid and is dangerous.
[**]Please confirm neither the tool nor the cloth are left behind in
the engine room after checking the engine room.
- It causes the breakdown, and when the tool and the cloth, etc. used for the check and the cleaning
are left behind in the engine room, it might cause the vehicle fire because it becomes a high temperature
and in the engine room, is dangerous.
82
i
ma
t
ou
Ab
Please defend the following matter
about the tire.
In the worst case, it reaches an unexpected
accident and serious injury if it doesn't guard or,
Warning
it is likely to lead to the death.
2. Attention of tire 2.
Attention
- Please adjust the specified air pressure after confirming correct air pressure with the table or P.615
of "Tire inflation pressure" pasted to the body side where the driver's seat door was opened.
The stability of the vehicle not only is ruined when it is lower than the specified air pressure but also the tire
does [katayomametsu]. The tire is a burst (explosion), might cause an unexpected accident
by standing wave phenomenon * when high-speed running, and it is dangerous. Please
include the spare tire by the daily check, and check that the tire inflation pressure is specified
air always pressure.
- When running at high speed, the tire is a wave [utsu] phenomenon.
83
About maintenance
Studless tire
Normal tire Studless tire
- The drive and the system parts are negatively affected in the following cases as well as the coexistence use for the tire
and execute the check of the air pressure in the tires, please.
[**]When the difference of the air pressure of four wheels is remarkable.
[**]When the air pressure shifts from a specified value. -
Please rotate the tire around the tire wear to keep even, and to extend longevity
to four wheels. (Refer to P.575. )-
Please do not install the disc wheels other than specification when you exchange
the disc wheels. (Refer to P.615. )
84
About maintenance
- It becomes impossible the performance of the car (stability and slip distance for brake etc. of fuel cost and
the vehicle) is not able not only to be demonstrated enough when the not same tire as tires other than specification
and four wheels is installed but also to generate the rotation difference in the tire in the front, back, left and
right, and to detect an accurate speed of the vehicle and the following system might not operate normally.
[**]A B S
Warning
[**]Brake assistance
[**]T R C ・ S - V S C
2.
[**]Backing guide monitor
[**]GPS voice navigation system
Attention
[**]Window shade corner monitor
[**]Radar cruise control
[**]C r u i s e c o n t r o l of
[**]P r e - c r a s h s a f e t y tire
[**]I n t e l l i g e n t A F S
[**]NAVI. AI. SHIFT
[**]Lane keeping assistance
[**]Please do not use the tire that exceeds the wear limit.
- Tire..ditch..depth..few..tire..slip sign..wear limit..display..go
out..tire..as it is..use..slip distance for brake..long..beco
me..rain..day..hydroplaning..steering wheel..operation..tire..bu
rst..explosion..unexpected..accident..connect..dangerous.Please exchange
it promptly for a normal tire when slip sign appears.
Mark that shows position of slip sign
Slip sign
Slip sign
. example: State that slip sign has not gone out . *2 . example: State that slip sign has gone out . *2
- 1 Phenomenon of steering wheel and brake's tire's water's entering between tire and road when running at
high speed on road where water collects, floating from road, and not working. -
2 The illustration is an example for the explanation, and it is actually different.
85
About maintenance
[**]Please do not install an abnormal tire that there are a wound and a crack in the
side wall of a tire etc.
- When the tire in which abnormality is found is installed, I might feel a vibration that is taken the
steering wheel when running, and is abnormal.
Warning
The damage such as bursts (explosion) that cannot be repaired is given to the tire, and moreover,
the tire might cause an unexpected accident as the sideslip etc. and it is dangerous.
2.
Please promptly receive the check in the Toyota shop, and exchange it for a normal tire while
running when you feel an abnormal vibration. -
Attention
It might not be able not only to demonstrate the performance of the car (stability and slip distance for brake etc. of
fuel cost and the vehicle) enough when the tire in which abnormality is found is installed but also cause an unexpected accident
of and be dangerous. Moreover, it might cause the breakdown as parts are negatively affected.
tire
[**]Please install the same kind of tire without fail when you install the tire for winter by
the same specified size as a standard tire, and run by the specified air pressure.
- When the tire for winter is installed, it is similar to a standard tire. Moreover, please avoid the high speed operation
for safety when you install the tire for winter.
[**]Please refrain from the speed and drive carefully when you install the tire chain.
- Please run below the speed limit of about 30 km/h or the chain manufacturer recommendation
when you install the tire chain. Moreover, please run carefully to influence
running. -
When the tire chain is installed and you run, please do not do the brakes operation etc. that
the projection and the hole are got over, and the abrupt steering and the wheel lock. It does unexpected
movement by the vehicle, might cause the accident, and is dangerous.
Moreover, the slip distance for brake might become long when ABS operates, and drive
carefully, please.
86
About maintenance
tires.
2.
- The wheel installation bolt and the brake parts are damaged, and it might cause an Attention
unexpected accident as the disc wheel comes off and is dangerous if not surely shutting.
Please tighten the nut in the reference value with the torque wrench in the Toyota shop as soon as
of
possible after exchanging tires.
tire
Tightening torque: About 105N. m{1050kgf・cm} -
Please no oil and grease it to the nut and the bolt that installs the tire.
The bolt might be damaged, and the disc wheel be damaged when tightening more
than the necessity. Moreover, it might cause an unexpected accident as the tire comes off while
the nut's loosening and running and is dangerous.
[**]Please receive the check in the Toyota shop etc. when abnormalities such as
collapsing and the cracks are found in the bolt hole of the thread part and the disc
wheel of the disc wheel installation bolt and the nut.
- It might cause an unexpected accident as it doesn't shut enough even if the nut is tightened when
abnormalities such as collapsing and the cracks are found, and the disc wheel comes off and is dangerous.
[**]Please note that the tire doesn't hit the curb etc. of the pavement.
- The tire disc wheel might be damaged.
87
About maintenance
[**]Please note the following points about the temporal spare tire (spare tire
installation car).
- The temporal spare tire is a tire temporarily used when a standard tire blows out.
Please exchange it for a standard tire as soon as possible. -
Warning
Please check the air pressure of the temporal spare tire. It might cause an unexpected accident
because the difference of the diameter of the tire grows further if running in the state where the air pressure
2.
is insufficient and is dangerous.
Air pressure (gage pressure) when tire is cold: 420kPa { 4.2kg/ [**] }
Attention
- The temporal spare tire installed by the car is only for customer's car. Please do not combine
with other tires and the disc wheels, do not use for other cars, and use the temporal
of spare tire of other cars for customer's car. It goes out to run the adverse effect, might cause
tire an unexpected accident, and is dangerous.
[**]Please do not touch the disc wheel and the brake circumference, etc. immediately
after running.
- The disc wheel and the brake circumference immediately after running are high temperatures. When the
hand and the foot, etc. touch by the tire exchange etc. , the burn might be done.
88
i
ma
t
ou
Ab
Please defend the following matter
about the battery.
Important injury might be received if it
doesn't guard and it is dangerous. Warning
3. Attention of 3.
battery
Attention
it like LOWER LEVEL or less that each [ekisou] is displayed on the battery side (lower bound), heat is
battery
generated and might the explosion is dangerous. Please replenish the check method when liquid measure
is a little referring to "Maintenance note".
- Important injury such as losing sight might be received when the battery liquid that contains diluted sulphuric acid
that it is poisonous and the causticity is high might spout from the battery, and it adheres to eyes and the skins and it
is dangerous while charging it. Please take off clothes at once, wash the part of the body that adheres the liquid
with bags of water, and receive the doctor's examination when adhering by any chance.
89
About maintenance
Warning
3.
- It surely installs or doesn't tighten, and might cause the vehicle fire by
clamping coming off while running and shorting and be dangerous.
90
i
ma
t
ou
Ab
Please defend the following matter about
the jack improvement.
In the worst case, it reaches an unexpected
accident and serious injury if it doesn't guard or,
Warning
it is likely to lead to the death.
4. Attention of 4.
jack improvement
Attention
- The body becomes the a celluloid board laid under written paper of the car if the jack comes off by any chance, and it reaches
important injury or, in the worst case, it is likely to lead to the death. -
Please do not use the jack of an in-vehicle tool excluding the tire exchange and the tire chain
detaching.
91
About maintenance
[**]When the jack improves, the body is damaged, and the jack comes off, important
injury might be received, and it is dangerous if the following respect
is not noted.
- The jack must not improve with the person taken. -
Warning
Please on the jack and do not place the one below when the jack improves. -
When the jack is improved, the jack is a surely position where the body
4.
is set the jack Please confirm hanging to (Refer to P.635). -
Please lift only height necessary for the tire exchange to the body. -
Attention
The jack's having improved must not start up an engine. -
of Please confirm surroundings, and work while noting it enough when you sell the body that improves
the jack wholesale.
jack
improvement
92
About maintenance
[**]Please guard the following when the jack improves with jacks
other than the jack installed by the car.
- A special tool is needed, and when using it by mistake because the special attention is
needed for handling, the vehicle is damaged, and when the jack improves with jacks other
Warning
than the jack installed by the car, it might cause an unexpected accident and is dangerous.
Moreover, when the jack improves in [riyasasupenshon] etc. , the vehicle might
4.
be damaged.
Please consult the Toyota shop when it is necessary
Attention
to use jacks other than the jack installed by the car.
Moreover, please hit it to the position where the figure
of
below is set the garage jack when you use the garage jack.
jack
FF car
[Riyasasupenshon] Garage jack set position
improvement
Garage jack set position
The jack
cannot improve.
The front side of vehicle
The jack
cannot improve.
The front side of vehicle
93
an
eat
rh
[OB] a
Please defend the following matter
Reason
about overheating.
Important injury might be received if it
Warning doesn't guard and it is dangerous.
1.
1. Attention of
overheating
Attention
of
[**]Please do not open the hood
overheating
until steam doesn't occur when
it overheats, and steam has
occurred from the bonnet.
- Important injury such as the burns might be received because the high temperature in the engine
room and it is dangerous. Moreover, please note that there is a part that is the high
temperature even when steam has not occurred enough when opening the hood.
- Steam and the hot water spout, important injury such as the burns might be received, and it is dangerous. -
Please wrap the cap by cutting the cloth after getting cold enough the radiator and
the auxiliary tank, and open it slowly when you open the cap.
94
an
eat
rh
[OB] a
Please defend the following matter.
Reason
It might cause an unexpected accident and
serious injury if it doesn't guard and is
dangerous. Warning
OneAt ention
[**]Please note the steering wheel and the brakes operation enough when it is because
pulled as the engine doesn't start. of
- The operating physical force becomes very heavy because neither the power steering nor the brake [goto]
twice power device work if it doesn't engine starts. Please note driving the pulled drinking
car enough.
- The draw hook and the rope are damaged, it hits a surrounding person etc. , important injury
might be given, and it is dangerous.
[**]Please do not turn off the power supply while pulling it.
- It is locked the steering wheel, might cause an unexpected accident, and is dangerous.
95
Overheating and emergency accident
drinking
- There is a possibility that the fuel system has been damaged if the road under the car etc. are confirmed, and the leakage
of the liquid (Excluding the water of the air conditioner) is found. It ignites to the fuel if the engine is
started as it is, it might cause a serious accident, it is not dangerous, and do not start
the engine, please.
In this case, please tell it also at the report of the situation to the Toyota shop.
96
tio n
at ten
r
O the
Other
attention
[**]Please never do an illegal remodeling.
- If the one other than parts that Toyota reported to the Ministry of Land, Infrastructure and Transport are installed, it is
likely to become an illegal remodeling. -
The accident is caused, and it reaches important injury or might lead to the death in the worst case and
is dangerous the drop of height, and causing the breakdown when an unsuitable parts to the performance and the
function of the car as a wide tire is installed are installed, and. -
Please never remodel the steering wheel. It doesn't operate normally, and it swells by
mistake, and it reaches important injury or, in the worst case, it is likely to lead to the death when
inadequately treating because the supplemental restraint system airbag is built into the steering wheel. -
In the following cases, please consult the Toyota shop.
[**]Exchange of tire disc wheel wheel installation nuts.
If the one other than the different species and specification are used, the adverse effect might be caused
for running, and it become an illegal remodeling.
[**]Installations such as electrical equipments and wireless machines and detaching.
The adverse effect is caused for an electronic equipment parts, and it might cause the accident such as breakdowns and
the vehicle fires and is dangerous.
- It might cause the vehicle fire when leaving it while opened and is dangerous. Moreover,
please do not put the combustible one such as wastepapers in the ashtray.
97
Other attention
[**]Please do not put the one other than the cup and the beverage can in the
cup holder.
- What stored when time that slammed on the brakes and colliding dashes out, and it
is likely to injure. Moreover, please close when you do not use it.
Warning
Other
attention
- It works the lens by the sucker, might cause the vehicle fire, and is dangerous.
- It flies the body when time that slammed on the brakes and colliding, and it reaches important
injury or, in the worst case, it is likely to lead to the death.
98
Other attention
- In the worst case, it reaches important injury or, it is likely to lead to the death by placing the attention
hand, the head, and the neck, etc. when closing when the child operates it. -
Please do not place the finger etc. so that an easy closer may work at a half door
and the backing door may close automatically in the easy closer installation car.
Important injury might be received and it is dangerous. -
When the main switch of the power backing door is turned off, an easy closer
operates. -
Please close the backing door pushing from the outside without fail. When the backing door is closed directly
in the backing door grip, the hand and the arm are placed, and important injury might be received and it is
dangerous. -
Please open completely without fail and use the backing door. The backing door drops when using
it while opened half, and it is likely to injure. -
Please do not close the backing door, and do not hang with [bakkudoasute-].
It shifts, and when the hand is placed, and [danpa-sute-] is damaged, it might cause an
unexpected accident and is dangerous.
99
Other attention
[**]In the power backing door installation car, please guard the following. It might
cause [ri] and an unexpected accident that places the finger and the hand, etc. in the backing
door if it doesn't defend and is dangerous.
- Please do not confirm surrounding safety, and do not place the finger etc. enough in the backing door when you
Warning
open and shut automatically. Moreover, please note personal belongings such as bags and neckties
enough. Please do not let the child operate it. -
Other Please turn off the main switch when you exchange tires. The power
backing door moves when it touches the switch etc. playing a trick if it doesn't make it to turning off and by
attention mistake, the finger and the hand, etc. are placed, and it is likely to injure. -
Operation stops, and it changes into the manual operation when the main switch is turned off when being
open and shuting automatically. In this case, please note that the backing door might begin to
move unexpectedly uphill on the slope etc. enough. -
The buzzer might ring, operation stop, and it change into the manual operation when not filling it with the
operation condition of P.191 when being open and shuting automatically. In this case, please note that
the backing door might begin to move unexpectedly uphill on the slope etc. enough. -
Be careful enough when the prevention mechanism operates including scissors. It hits the backing
door, and it is likely to injure. -
Please do not install the accessories articles other than a Toyota pure goods in the power
backing door.
It is not possible to open and shut by the automatic operation when the skiing career etc. are installed in the
backing door and the power backing door might break down. Moreover, the backing door drops after it opens
completely, and important injury might be received. -
The sensor at a right and left edge in the power backing door is a device that detects the obstacle, and prevents
including scissors. It is not likely to be able to detect it according to shape and how to place the placed thing.
Be careful enough when the door opens and shuts. -
Might it be judged the system malfunction due to the decrease in the voltage of the battery when the power supply is
turned on while opening and shutting the engine stop automatically, and the door reverse automatically. It might cause
an unexpected accident, it is not dangerous, and do not turn on the power supply, please while opening and shutting
automatically.
100
Other attention
[**]The lower side of the glass doesn't become hot while operating the reception desk attention
window shield glass with heat ray, and do not touch it, please. (reception desk
window shield glass installation car with heat ray)
- The burn might be done and it is dangerous.
[**]It is not possible to wave because become be hot while be operating the mirror
heater the surface of the door mirror. (mirror heater installation car)
- The burn might be done and it is dangerous.
[**]Please note that detached neither battery nor parts (Especially, the child :) are
swallowed when the batteries of an electronic key are exchanged.
- Important injury might be received when swallowing and it is dangerous.
101
Other attention
attention
- Please confirm all doors have closed completely before it runs.
It opens suddenly while running if the door is not completely closed the door, might cause an
unexpected accident, and is dangerous. -
Please do not let the child operate the door.
[**]In the worst case, it reaches important injury or, it is likely to lead to the death by placing the
hand, the head, and the neck, etc. when closing.
[**]The door might be opened while running, the child throw out outside the car, and it reaches
important injury or, in the worst case, it lead to the death.
- Please guard the following when you open and shut the slide door. It might cause an unexpected
accident as hands and feet and the face, etc. are placed in the door if it doesn't defend and is dangerous.
[**]Please open and shut with the slide door steering wheel.
[**]Please never produce hands and feet and the face, etc. from the window when you open and shut
with the door glass of the slide door opened.
[**]Please confirm safety behind the slide door enough.
[**]Please do not place other people's hands etc.
[**]P l e a s e d o n o t p u t h a n d s a n d f e e t i n t h e s l i d e
door etc.
[**]Please open to the position of opening completely without fail and fix surely when you open the slide door.
(The slide door is fixed by the stopper when opening it completely. )It is likely to
begin to move unexpectedly if the slide door is not surely fixed.
- Please do not place the finger etc. so that the slide door may close automatically
in the easy closer installation car at a half door. Important injury might be received
and it is dangerous.
102
Other attention
[**]In the power slide door installation car, please guard the following. It
might cause [ri] and an unexpected accident that places the finger and the hand, etc. in the
slide door if it doesn't defend and is dangerous.
- When you open and shut automatically, please note that surrounding safety is confirmed, and neither the finger nor the hand, etc.
Warning
are placed between the slide door enough. Moreover, please do not let the child operate it. -
Please never produce hands and feet and the face, etc. from the window when you open and shut with the door
glass lowered automatically. - Other
Please turn off the main switch when you exchange tires of the rear wheel.
The power slide door moves when it touches the slide door steering wheel etc. playing a trick if it doesn't attention
make it to turning off and by mistake, the finger and the hand, etc. are placed, and it is likely to injure. -
Operation stops, and it changes into the manual operation when the main switch is turned off when being
open and shuting automatically. In this case, please note that the power slide door might begin
to move unexpectedly uphill on the slope etc. enough. -
The buzzer might ring, operation stop, and it change into the manual operation when not filling it with the
operation condition of P.180 when being open and shuting automatically. In this case, please note that
the power slide door might begin to move unexpectedly uphill on the slope etc.
enough.
[**]Please do not spill the drink in the switch in the car etc.
- It causes the breakdown, and when the drink splashes to switches etc. that the Instrument panel
and the door, etc. include, it might cause the vehicle fire and is dangerous. Please consult
the Toyota shop promptly when the drink splashes to the switch by any chance.
103
Other attention
Other
[**]Please do not paste the speed limitation label to the following position when
attention you do the blowout repair with a tire blowout emergency repair kit.
- When interfering to driving such as the meter and the door glass,
it might cause an unexpected accident and is dangerous. -
SRS air backing development department SRS air backing such as the
steering wheel pads doesn't operate normally, and it reaches important injury or, in the worst
case, it is likely to lead to the death.
[**]It is not possible to wave with heat ray because become be hot while be operating the
reception desk window shield glass the surface of the lower side of the reception desk
window glass and the driver's seat side reception desk pillar part. (reception desk window
shield glass installation car with heat ray)
- The burn might be done and it is dangerous.
[**]Neither pulling out opening of the ETC card nor those who drive must
operate the ETC unit as much as possible for safety while running when
you use the ETC system. (ETC system installation car)
- The operation under running might cause an unexpected accident as the steering wheel control is mistaken and
is dangerous. Please operate it after stopping the car.
104
Other attention
Warning
Other
attention
105
Other attention
Warning
Other
attention
106
..PM page..107
2
Contents
(To the person who takes this car for the first time. )
. earliness.. Basic
operation
[wakari]
This chapter easily explains a basic driving device of this car and the
fixture for the person who takes a Toyota car the other ..the first purchase
of the car.. for the first time.
Please read each chapter firmly about a detailed handling explanation and notes. Driving
Handling
device
Opening and shutting . . . . . . . . . . . . . . . .
of each part adjustment . . . . . . . . . . . . . . .
of 108 seats wearing . . . . . . . . . . . . of 110 The
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
107
Opening and shutting of each part
Lock
Unlocking
108
Opening and shutting of each part
Contents
A detailed introduction concerning the opening and shutting of each part
Driving
Handling
device
The
Handling indoor
equipment
associate
. drinking..
car
Myriad
One[Notoki]
- The buzzer rings when beginning to operate. -
The intermission buzzer rings while opening and shutting is operating.
Index
109
Adjustment of seat
The back must not separate the back from the drip either.
The pedal should be able to be depressed enough.
Regulating function of driver's seat
Lengthwise position The back is an angle of the drip. The edge is raised and lowered Raising and lowering
in front of the cushion. of the entire seat
Manual seat
Power seat
110
Adjustment of seat
Contents
A detailed introduction concerning the seat
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
The
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
111
Wearing of seat belt
Do not twist.
Method of wearing
1 The belt is drawn out. 2 The plate is inserted in the
buckle.
Anchor
[**]
Bambo basket
Contents
A detailed introduction concerning the seat belt
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
The
Fixation 280 of child seat Handling indoor
equipment
How to remove
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
associate
. drinking..
car
Bambo basket
Button Maintenance
One[Notoki]
Index
113
When you drive
Electronic key
State of power supply Color of operation pilot light State of engine Working of each state
ACC Orange color Stop The electrical equipment such as audio can be used.
114
When you drive
Contents
Driving
Handling
device
The
Handling indoor
equipment
associate
. drinking..
car
Maintenance
Myriad
Please push surely slowly. -
One[Notoki]
When the engine starts, the operation
pilot light is turned off.
Index
115
When you drive
[Shi-kensharushifutomachikku] pilot
light (3.5L car)
[Supo-tsushi-kensharushifutomachikku]
pilot
light (2.4L car)
1 2.4L car
The gear-shift [**][Nishimasu]. -
The [supo-tsushi-kensharushifutomachikku]
pilot light lights.
3.5L car
The gear-shift [**][Nishimasu]. -
The [shi-kensharushifutomachikku] pilot
light lights.
116
When you drive
Contents
A detailed introduction concerning the driving device
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
The
Handling indoor
equipment
associate
. drinking..
car
Bambo basketWhile firmly stepping on the brake pedal Bambo basketWhile firmly stepping on the brake pedal Maintenance
by the right leg by the right leg
[**]The parking brake pedal is depressed with [**]The parking brake pedal is fully
the left leg until "[Kachi]" and the sound depressed with the left leg.
Myriad
are heard, and it separates slowly.
One[Notoki]
Index
117
Warning light
Engine warning light Abnormality of the engine electronically controlled system etc.
[Dei;sucha-jiheddo
(upper and lower irradiation direction self adjustment) An auto
ranpuo-toreberingu]
warning light leveling of [dei;sucha-jiheddoranpu] Abnormality of the system.
Power steering warning
Abnormality of the power steering control system.
light
Oil pressure warning light Abnormality of the oil pressure in the engine.
118
Warning light
Contents
A detailed introduction concerning the warning light
. earliness.. Basic
operation
[wakari]
Index
119
Handling of switches
(stop)
AUTO(automatic operation) INT (intermittent operation)
120
Handling of switches
Contents
A detailed introduction concerning the switch
Wiper
&Washer switch 363
. earliness.. Basic
Instruction lever of operation
[wakari]
356 light switch
directions 359 fog
lamp switch 362
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
Running such as nighttime and rain Signal to another car [na] ・
of
[to] Comfortable
How to apply lamp Turning indicator Left turn theory
equipment
Lighting
Automatic lighting and turning off (headlamp/front position
How and
(Only the [konraito] installation car :. ) light/taillight/number-plate light) to attention
associate
Right turn . drinking..
car
Myriad
Lighting (front position light/taillight/number-plate light)
One[Notoki]
Index
121
Air conditioner
It lowers.
Contents
A detailed introduction concerning the air conditioner
Warning
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
123
..PM page..124
3
Smart entry &
start system . . . 126
A smart entry About &
start system
Handling of driving device
126
Opening and shutting of bonnet
Usage 210 of anti-theft
system (auto
208
alarm)
Adjustment . . . . . . of seat 214
Electronic key 128 Correct driving posture 214
Lock and how to unlock 132 Adjustment 216 of reception desk seat
lock Adjustment 222 of [sekandoshi-to]
and how to unlock door Adjustment of third seat 232
backing door 136 Seat arrangement . . . . . 236
How to switch power supply 139 Index 236
Method 142 of engine start and Space is made in the center part of
stop the vehicle. 241
Energy saving function 147 It makes it to/that stores the
Warning, prevention function, third seat table. 243
and alarm display 148 How to make the maximum
At such time 159 load room mode 257
When an electronic key How to make super-relaxation
doesn't operate normally 161 mode 259
Opening and shutting . . . . . . . How to make flat
. . . . of door door the glass etc. 164 seat mode 262
Opening and shutting of reception desk door 164 Wearing . . . of seat belt 266
Opening and shutting of slide door 170 Correct wearing
Opening and shutting of backing door 183 of seat belt 266
Opening and shutting of the door glass 192 How to wear seat
Opening and shutting of reception belt 269
desk Moon roof How to store
[riyasanshe-do] 197 rear seat belt 277
How to use of the wireless door lock Fixation of child seat . 280
remote control. 200 Fixation 280 with bar &
Opening and shutting of [fuyu;-eruriddo] (fueling [topputeza-anka-] only for child
entrance) 205 seat fixation for ISOFIX
Fixation 286 with seat belt
124
..PM page..125
Adjustment of steering wheel mirror . 290 The top and bottom of optical
Adjustment of steering wheel 290 axis adjustment of headlamp 360 Contents
Adjustment 291 of inner mirror How to use of & washer of
Adjustment of door mirror 292 362 usage wipers switch of the
Supplementary confirmation device 295 fog lamp. 363
How to use of gear-shift . 296 (cloudy remove) [Riyauindou;defogga-] Warning
A smart entry Only because an electronic key is carried, the switch and the engine
of the lock, unlocking, and the power supply in the door are started and & start system
can be stopped.
Lock
Unlocking
Unlocking Lock
126
Smart entry & start system
Contents
Warning
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
Start and stop of engine (Refer to P.142). [to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
127
Electronic key
An electronic key communicates with the vehicle, and it smart enters it & start
system operates.
- Please confirm the influence by the electric wave to an electric equipment manufacturers for the medical treatment etc.
beforehand when an electric equipment for medical treatments other than the implanted cardiac pacemaker and the planting type
defibrillator is used. It might influence the movement of an electric equipment for the medical treatment by the electric wave. -
A smart entry & start system is able not to be operated. Please
consult the Toyota shop in detail.
128
Smart entry & start system
Contents
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
129
Knowledge
About an electronic key
- There are two electronic keys. -
An electronic key is used for another of the lock and unlocking the door and the start and stops, etc. of the engine. -
Please refer to P.200 for the operation of the wireless door lock remote control. -
Please do not lose an electronic key enough. Please consult the Toyota shop
at once to need the exchange of computers to make an electronic key when you lose an
electronic key. -
Because a special processing is needed for making an electronic key, it is not possible to buy it excluding the
Toyota shop. -
A smart entry Please have all electronic keys with which the vehicle is equipped when you take
the vehicle to the Toyota shop due to the breakdown of & start system etc.-
Please refer to P.527 for an anti-theft system. A
130
Smart entry & start system
Contents
Knowledge
Warning
About keeping an electronic key
Please do not keep an electronic key near home appliance. An electronic key mis-operates by the electromagnetic radiation
of home appliance, and it always enters the state of the communication and the battery might be consumed remarkably.
The number of electronic keys that can be used in electrical appliances (Example though it is preferable . earliness.. Basic
to always separate by about 1m or more) main television, personal computer, electromagnetic cooker, desk lamps with the influences, operation
[wakari]
About the number of use of electronic keys
and a cordless phone machine and the same cellular phone vehicles to be charging can be changed. Please consult the Toyota
shop in detail.
Driving
Handling
About the Keenan bar plate
device
Keenan bar It clocked on the Keenan bar in not an electronic key but the plate
so as not to understand the Keenan bar excluding the customer. -
The
Please keep the Keenan bar plate in places other than the vehicle importantly. - Handling indoor
equipment
When an electronic key is lost by any chance, an electronic key to a Toyota pure goods can be made
from the Keenan bar in the Toyota shop. -
Please consult the Toyota shop at once to prevent the theft and the accident, etc. when one electronic
key is lost by any chance. A . good.. Safety
[na] ・
of
A smart entry About the release of & start system [to] Comfortable
theory
smart entry & start system is able not to be operated. Please equipment
consult the Toyota shop in detail.
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
131
Lock and how to unlock door
Lock Unlocking
- When locking
An electronic key is carried, and the lock switch of the reception
desk door steering wheel is pushed with all doors (The backing door
is included) closed. -
Lock switch
All doors (The backing door is included) can be locked. -
The emergency blinking light blinks once, and the buzzer rings
once when locking. -
Please confirm the lock.
- When unlocking it
To carry an electronic key, and to touch the sensor assembly on the other side of
the reception desk door steering wheel, the door handle is gripped. -
All doors (The backing door is included) can be unlocked. -
The emergency blinking light blinks twice, and the buzzer rings two times
when unlocking it.
Sensor assembly
132
Smart entry & start system
Contents
Knowledge Driving
Handling
About the range of operation Auto outdoor transmitter
device
In detection area of auto outdoor transmitter (within about 70cm in surroundings
from each reception desk door)-
It is likely not to operate when it approaches the The
door glass and the door handle too much. Handling indoor
equipment
Detection area
Within about 70cm in surroundings from each reception desk door steering wheel
. good.. Safety
About the operation condition [na] ・
of
- The door is unlocked only when the ID code is automatically collated when entering carrying an electronic key in the [to] Comfortable
detection area of auto outdoor transmitter (reception desk door), and collation is corresponding. It is locked when judged theory
equipment
that the ID code is collated outside the room auto when the lock switch is pushed after it gets off with all
doors closed and there is no electronic key in the car but there is an electronic key outside the car.
How and
[**]The door is locked and it is possible to unlock it only with the door handle that detects an electronic key. to attention
[**]When it approaches time when electronic keys exist in the neighborhood and a high place on ground and the door glass and
associate
the door handle too much even in case of being in the detection area of auto outdoor transmitter (reception desk door), it . drinking..
car
is likely not to operate normally.
[**]If an electronic key is in the detection area of auto outdoor transmitter (reception desk door), it is possible to lock and to
unlock it excluding the person who is carrying an electronic key.
[**]It is likely not to operate easily by how with an electronic key.
[**]There is a place where an electronic key is not operated easily according to the shape of the vehicle. - Maintenance
A smart entry when an electronic key is a dead battery The door is not locked in & start system and the
wireless door lock remote control and it is not possible to unlock it. In this case, please refer to
"An electronic key doesn't operate normally" of P.161.
Myriad
One[Notoki]
Index
133
Knowledge
134
Smart entry & start system
Contents
Knowledge
Warning
About a convenient function
[Irumine-teddoentori-shisutemu]
The door is opened and shut, and it synchronizes with going into in the detection area in the state of unlocking, the lock,
and the power supply and states to carry an electronic key, and a reception desk personal lamp, integral room lamp [riyapa-sonaruranpu] . earliness.. Basic
(When DOO R is located), and the engine switch lighting are lit and turned off. - operation
[wakari]
It lights when an electronic key is carried, and it enters in the detection area outside the detection area of auto outdoor transmitter
(reception desk door), and it will turn it off in about 15 seconds. However, it doesn't operate when go out from in the detection
area outside the detection area, return within about three seconds in the detection area, and confined in the
detection area. - Driving
- It lights when either of door (The backing door is excluded) is opened, and when all doors are closed, it will turn Handling
it off in about 15 seconds. - device
- It lights when the power supply is turned off, and it will turn it off in about 15 seconds. -
- It lights when either of door (The backing door is excluded) is unlocked when the power supply is turned off, and it will
turn it off in about 15 seconds. - The
- In the following cases, it turns it off at once. Handling indoor
・When all doors are closed, and the power supply is made ACC or to turn on. equipment
・When the power supply is made ACC or to turn on, and all doors are closed.
・When all doors are closed, and the reception desk door is locked.
- This function can be changed. Please refer to "User customizing function" of P.617 . good.. Safety
for details. [na] ・
of
[to] Comfortable
Battery rising prevention function theory
The battery rising prevention function works when a reception desk personal lamp (When DOOR is located, the equipment
switch :), [riyapa-sonaruranpu] (When DOO R is located, the switch :), and an integral engine switch lighting
of the room lamp keep lighting for about 20 minutes or more with either of door (The backing door is How and
to attention
excluded) opened and it turns it off automatically.
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
135
Lock and how to unlock backing door
Lock Unlocking
- When locking
An electronic key is carried, and the backing
door lock switch is pushed with all doors
(The backing door is included) closed. -
All doors can be locked. -
The emergency blinking light blinks once, and the
buzzer rings once when locking. -
Please confirm the lock operation was
done.
- When unlocking it
An electronic key is carried, and the backing door
opening switch is pushed. -
All doors can be unlocked. -
The emergency blinking light blinks twice, and the buzzer
rings two times when unlocking it. -
Please refer to "How to open and shut the backing
door" of P.183 for the opening and shutting of the
backing door.
136
Smart entry & start system
Contents
Knowledge Handling
Driving
[**]There is a place where an electronic key is not operated easily according to the shape of the vehicle. -
A smart entry when an electronic key is a dead battery The backing door is not locked in & start system
and the wireless door lock remote control and it is not possible to unlock it. In this case, please
Myriad
refer to "An electronic key doesn't operate normally" of P.161.
One[Notoki]
Index
137
Knowledge
138
Smart entry & start system
State of power supply Color of operation pilot light State of engine Working of each state
OFF Turning off Stop Electrical equipment has stopped. . good.. Safety
[na] ・
of
Electrical equipment of the cigarette writer etc. [to] Comfortable
ACC Orange color Stop theory
can be used. equipment
Bitter orange Stop All electrical equipments can be used. How and
to attention
ON
All electrical equipments can be used. associate
color turning off It is rotating. . drinking..
The state usually while driving. car
Maintenance
Myriad
One[Notoki]
Index
139
The power supply must not leave it like turning on or ACC, etc. at the
length time.
- It causes the battery of the vehicle to go up when the power supply leaves it like turning on or ACC, etc. at the
length time. -
Please do not operate the engine switch, and contact the Toyota shop promptly when
there is caught in the engine switch. -
Please do not touch the engine switch by the hand that attaches oil etc.-
Please do not spill the drinking water etc. in the engine switch. Please contact the Toyota
shop promptly if you feel abnormality by any chance after it spills it. -
When the vehicle is left for a long time under the scorching sun, the surface of the engine switch might
be hot. Please take care not to do the burn. -
Please receive the check in the Toyota shop when the engine switch lighting doesn't light even if the front
position light lights.
Knowledge
Detection area
Vehicle room
Car indoor transmitter
140
Smart entry & start system
Contents
Knowledge
Warning
About an anti-theft system
An anti-theft system might not change the power supply. (Refer to P.527. )
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
141
Method of engine start and stop
142
Smart entry & start system
Contents
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
143
Method of engine stop
Completely stop the vehicle, and the gear-shift[**][Ni] is put and the engine switch is [o].
It does.
The power supply is turned off, and the engine stops. -
The gear-shift [**]The power supply becomes ACC, and the engine stops.
The gear-shift to turn off the power supply [**]Engine Sui after [ni] is put
Please push [cchi].
- Please never start the engine outside the car. It might cause an unexpected
accident, it is dangerous, and get under the wheel, please. -
Please do not touch the engine switch while running. If it keeps pushing the engine switch
by mistake, and the engine stops, it might work neither the brake twice power device nor the power
steering, worsen working of the brake, become very heavy the steering wheel, cause an unexpected
accident, and be dangerous. -
Please start the engine when you move the car a little. It might cause an unexpected
accident when the car is moved by not starting up an engine, and using the slope and is dangerous. -
Please do not let me run absolutely in the vehicle when the operation pilot light of the engine switch blinks
to green when the start operation of the engine is done. It might cause an unexpected accident because the
steering wheel lock has not been released and is dangerous.
When the operation pilot light of the engine switch has blinked to the
orange color, abnormality of the system is thought.
- When the operation pilot light of the engine switch has blinked to the orange color, abnormality of the system
is thought. Please become impossible to start the engine again when the power supply is turned
off once it and contact the Toyota shop promptly. -
Please do not open the door while running until the vehicle stops safely when the vehicle enters the
state of the slide because of the engine stall etc.There is a possibility that the steering wheel lock operates and it
is dangerous. Please contact the Toyota shop promptly after it stops in the place of safety. -
Please do not operate the engine switch, and contact the Toyota shop promptly when
there is caught in the engine switch. -
Please do not touch the engine switch by the hand that attaches oil etc.-
Please do not spill the drinking water etc. in the engine switch. Please contact the Toyota
shop promptly if you feel abnormality by any chance after it spills it. -
When the vehicle is left for a long time under the scorching sun, the surface of the engine switch might
be hot. Please take care not to do the burn. -
Please receive the check in the Toyota shop when the engine switch lighting doesn't light even if the front
position light lights.
144
Smart entry & start system
Contents
Knowledge
Warning
About the range of operation
In detection area of car indoor transmitter (vehicle room)-
When it approaches the door glass too much, the start
of the engine might become possible also outside the car. . earliness.. Basic
operation
[wakari]
Detection area
Vehicle room
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
145
Knowledge
146
Smart entry & start system
The battery of an electronic key and the vehicle might go up so that an electronic key and the
vehicle may communicate regularly when an electronic key has been left for a long time in the detection
Warning
area of auto outdoor transmitter (reception desk door and backing door).
Therefore, it smart enters it to prevent the battery rising of an electronic key
and the vehicle at the next time & start system stops by the automatic operation. -
When there is no response from an electronic key 14 days or more . earliness.. Basic
operation
- A smart entry when there are ten-minute or more electronic key in [wakari]
the detection area of auto outdoor transmitter Please do either of the following
operation to return & start system. -
It approaches the vehicle and the wireless door lock remote control switch of an electronic key Handling
Driving
is pushed. -
device
The lock switch of the reception desk door steering wheel or the backing door is pushed, and the
lock operation is done.
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
147
Warning, prevention function, and alarm display
A smart entry The warning sound is sounded so that & start system may prevent beginning
the movement of the vehicle not anticipated and the vehicle theft, etc. , and attention
is prompted by the alarm display to the multi information display (multi information
display installation car), a smart entry lighting of & start system warning light, and
blinking the operation pilot light of the engine switch.
Please confirm a vehicle and an electronic key when it sounds or the display
of warning lights warning.
Warning sound in car
Sound of warning outside car
When the power supply is ACC, the gear-shift :. [**]When [de] driver's seat door is opened, the power supply.
The warning sound in the car that drinks and warns of [kiri] forgetting rings , saying that "Feep and feep". However, it
doesn't ring when the power supply is turned on.
Moreover, when the steering wheel is not locked when the power supply is turned off,
warning in the car sounds it.
Please turn off the power supply and close the driver's seat door when warning rings.
148
Smart entry & start system
Contents
Driving
Handling
- Half door warning
device
Sound of warning outside car We will inform you that either
Feep(Seriate [funa] for about ten seconds. ) of door is open.
The
The sound of warning outside the car is consecutive for "Feep" and about ten seconds and Handling indoor
equipment
it rings when the lock switch of the reception desk door steering wheel or the backing door
is pushed by using smart entry & start system when the power supply is turned off with either
of door (The backing door is included) open. The warning sound stops in either of the
. good.. Safety
following method. [na] ・
of
- All doors are closed. [to] Comfortable
theory
- The switch of an electronic key is pushed. equipment
Please operate the door lock again after closing all doors when
warning rings. How and
to attention
associate
Knowledge . drinking..
car
About the half door warning
The half door warning operates when it touches the lock switch when the door (The backing door is included) is
opened and shut. Please do not touch the lock switch when you open and shut a door.
Maintenance
Myriad
One[Notoki]
Index
149
- Key shutting prevention function
Sound of warning outside car
Feep(Seriate [funa] for about two seconds. )
The sound of warning outside the car rings for "Feep" and about two seconds even if it tries
to lock pushing the lock switch of the reception desk door steering wheel or the backing door
by closing all doors when the power supply is turned off with an electronic key put in the
car, and using smart entry & start system, and it is not possible to lock.
Please operate [doarokku] again carrying an electronic key in the
car when warning rings.
Knowledge
About the key shutting prevention function
- The key shutting prevention function might not operate when an electronic key is put in the
storage pocket in the storage space on the floor on the Instrument panel (Refer to P.482)(Refer
to P.486) etc.-
The key shutting prevention function might operate when bringing it close to the door glass and the door handle
too much even if an electronic key is outside the car.
150
Smart entry & start system
Contents
Warning light and prevention function of warning sound and alarm display * by one
Smart entry & start system warning light Warning
. earliness.. Basic
operation
[wakari]
Driving
Handling
Multi information one
..display *.. device
The following state or warning sounding and smart entry & start system warning The
lights light when there is no electronic key in the car. - Handling indoor
When it is auto keyless (warning of the key none). - equipment
The power supply is : of the gear-shift excluding turning off. [**]When you open the driver's seat door
(gear-shift position warning)。 -
. good.. Safety
When having judged that the battery of the key has decreased (two-..warning *.. key [na] ・
battery decrease). of
[to] Comfortable
The content of warning being displayed on the multi information display at the theory
equipment
same time in the multi information display installation car (mastering warning)
It blinks. How and
to attention
-2 Smart entry & start system warning light doesn't light to the key battery decrease warning.
associate
. drinking..
- Warning of key none car
We will inform you that there is no electronic key in the car at the following.
When judging that an electronic key is not in the car by collating the ID code in the Myriad
car room pushing the engine switch.
[**]Smart entry & start system Warning light and multi ..alarm display (.. Inn One[Notoki]
The [fome-shondei;supurei] installation car) is the outline. It lights and it displays it for eight seconds.
[**] Warning sound in car "Feep ([funa] once)" rings at the same time, too.
Index
151
- The power supply is : of the gear-shift excluding turning off. [**][Niaru] or the driver's seat door opens and shuts.
When judging that it is done, and it is not in the car by collating the ID code in the car room
an electronic key.
[**] Warning sound in car "Feep ([funa] once)" and "[Pi]
Sound of warni ng outside car and [pi] and [pi]
(three time [funa])" ring at the same time, too.
The warning sound stops in either of the following method.
[**]An electronic key is put in the car. (When judging that the ID code in the car room is collated,
and it is in the car an electronic key. )
[**]The power supply is turned off.
- When the power supply judges that doors other than the driver's seat door are opened and shut excluding
turning off, and it is not in the car by collating the ID code in the car room an electronic key.
[**] Warning sound in car "Feep ([funa] once)" [Pi] Sound ofand
warning outsi[pi]
de car and ..".. [pi]
(three time [funa])"rings at the same time.
The warning sound stops in either of the following method.
[**]An electronic key is put in the car. (When judging that the ID code in the car room is collated,
and it is in the car an electronic key. )
[**]The power supply is turned off.
- The power supply is : of the gear-shift excluding turning off. [**]The driver's seat door is opened and shut.
When judging that an electronic key is not in the car by collating the ID code in the
car room.
[**] Warning sound in car "Feep (seriate [funa])" and Sound"Feep
of warning outside(seriate
car [funa])" are also
consecutive at the same time and it rings.
In [**] multi-information display installation car Please put it in P cooking stove. [Mo]
It is alternately displayed.
The warning sound stops in either of the following method.
[**]An electronic key is put in the car. (When judging that the ID code in the car room is collated,
and it is in the car an electronic key. )
[**]The gear-shift [**][Nishite] and the power supply are turned off.
152
Smart entry & start system
Contents
Knowledge
About the warning sound in the car . good.. Safety
[na] ・
When beginning to run, warning sounds it again when judged that there is no electronic key in the car up to the of
running beginning by collating the ID code in the car room. [to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
153
- Key battery decrease warning
In the multi information display installation
car, the display of the following is displayed on the
multi information display.
We will inform you when judged that the voltage of the battery of an electronic key has decreased
when about 20 minutes or more have passed since the power supply was turned on, and the power supply is turned
off afterwards. -
The alarm display is displayed for about five seconds. (multi information display
installation car)-
" F e eWarning
p (sound
[ f uin car
na] once)" rings.
- Smart entry & start system The warning light doesn't light.
- Please exchange the batteries of an electronic key (battery) if it ..warning..
sounded or warning is displayed. (Refer to P.576. )
154
Smart entry & start system
Contents
. earliness.. Basic
operation
[wakari]
Driving
Handling
- Power supply system abnormality warning device
The operation pilot light of the engine switch blinks to the orange color when abnormality of the power supply
system is detected.
The
Handling indoor
Please receive the check promptly in the Toyota shop when the operation pilot equipment
light blinks.
. good.. Safety
[na] ・
- Steering wheel lock unrelease warning of
[to] Comfortable
theory
The operation pilot light of the engine switch blinks to green for 15 seconds when the steering equipment
wheel lock is not released when the engine start is operated, and the engine doesn't start.
How and
to attention
In the multi information display installation
associate
car, the display of the following is displayed on the . drinking..
car
multi information display.
Knowledge
Maintenance
About the alarm display
- If abnormality is found, the state that smart entry & start system doesn't operate is
displayed. -
The display disappears when the engine is started pushing the engine switch. When the engine doesn't Myriad
start, the steering wheel is pushed, and it steps on the brake pedal, and the engine switch is pushed lightly and right
and left again though the loincloth. One[Notoki]
Index
155
- Steering wheel lock system confirmation warning
The operation pilot light of the engine switch blinks to the orange color when abnormality is detected
in the system of the steering wheel lock.
The operation pilot light blinks, and the check is received ..alarm display.. ..[detatokiha]..
promptly in the Toyota shop.
Knowledge
About the alarm display
If abnormality is found, the state that smart entry & start system doesn't operate is displayed.
156
Smart entry & start system
Contents
Operation table of warning sound, warning light, alarm display, and operation pilot light
- Operation table of warning sound, warning light, and alarm display Warning
Alarm display *
Warning sound in car Sound of warning outside car Situation
Warning light
. earliness.. Basic
Feep and - Forgetting to switch off power supply prevention function (Refer to P.148). operation
[wakari]
feep . . . The power supply is : of the gear-shift with ACC. [**][Notoki]
(intermission [funa]) The driver's seat door was opened.
- Key shutting prevention function (Refer to P.150).
The lock switch was pushed with an electronic key had been left Driving
behind in the car when the power supply was turned off. Handling
. .
Feep([Funa] for two seconds. ) - Forgetting to switch off power supply prevention function (Refer to P.149). device
The power supply is : of the gear-shift excluding turning off. [**][Noto]
It came, and the lock switch was pushed.
- Forgetting to switch off power supply prevention function (Refer to P.148). The
The power supply is : of the gear-shift excluding turning off. [**]以外 Handling indoor
Feep(seriate [funa])
[Notoki] and the driver's seat door were opened. equipment
- Half door warning (Refer to P.149).
When the power supply was turned off, the lock switch was
. Feep.
pushed while either of door was opening and shutting the state or . good.. Safety
the door in a half door. [na] ・
of
Display - Key battery decrease warning (Refer to P.154). [to] Comfortable
. theory
Feep([funa] once) The voltage of the battery of an electronic key has decreased. equipment
157
- Operation table of operation pilot light and alarm display
158
Smart entry & start system
Here, the scene of various "Such time" is assumed, and the example of the operation and the
coping process has been described. A smart entry Please treat and ..&
Warning
start system.. refer.
device
The
associate
. drinking..
car
When parting from the car in the gas station and the shop, etc.
Maintenance
Index
159
When the person who carries another regular electronic key gets on
When the person who carries another regular electronic key has gotten on
When the engine doesn't start when the engine start operation
is done and the operation pilot light of the engine switch
has blinked to green, the steering wheel lock has not been
released by the load of the steering wheel.
The steering wheel is done please do the engine start operation lightly
and right and left though the loincloth.
160
Smart entry & start system
It becomes impossible A smart entry when the communication between an electronic key
and the vehicle is disturbed or the battery of an electronic key cuts to use & start
Warning
system and the wireless door lock remote control.
device
Knob
The
Mechanical key Handling indoor
equipment
How and
to attention
associate
Mechanical key . drinking..
car
Index
161
How to switch power supply
An electronic key in the engine switch. (Toyota mark)The switch of the power supply
becomes possible by holding up the [noaru] side.
Please read "How to switch the power supply" of P.139 also.
1
Electronic key
Engine switch
It steps on the brake pedal.
Knowledge
162
Smart entry & start system
Contents
[wakari]
operation
The
163
Opening and shutting of door door the glass etc.
Opening and shutting of reception desk door
Unlocking
It locks when the right side of the switch is pushed, and when the left side is pushed, it is unlocked. -
The lock and unlocking all doors (The backing door is included) can be done at the same time.
164
Opening and shutting of door door the glass etc.
Contents
Knowledge
Warning
About the operation condition
- It is possible to use it regardless of the state of the power supply. -
When it keeps pushing the switch, it is likely not to operate. Please separate the finger from the
switch, and push again once. . earliness.. Basic
operation
[wakari]
About the security function
The function to stop the unlocking operation with the door lock switch to prevent the vehicle theft etc.
(It is prevented from being unlocked pushing the door lock switch from the space between the window frame and the door glass. )It
Driving
functions automatically when locking in the following way. - Handling
Lock that inserts key in door (Refer to P.161). - device
Lock that uses wireless door lock remote control (Refer to P.200). -
Automatic lock after about 30 seconds when door after it unlocks it by wireless door lock remote control
is not opened (Refer to P.203). - The
Lock by smart function (Refer to P.132). -
Handling indoor
Automatic lock after about 30 seconds when door after it unlocks it by smart function is not opened (Refer to equipment
P.134). -
Lock with lock lever (Refer to P.167).
. good.. Safety
[na] ・
About a convenient function of
[to] Comfortable
Auto of induction of velocity of car door lock theory
equipment
The velocity of the car is about 20. [**]All doors are automatically locked when becoming/h or more. -
This function can be released. Please consult the Toyota shop in detail.
How and
Impact perception door lock release system to attention
When the vehicle receives the high impact from the front, back, left and right, the lock of all doors is automatically released. -
associate
The time of a weak impact that the supplemental restraint system airbag doesn't operate and it is likely not to operate according . drinking..
car
to the form of the accident.
Maintenance
Myriad
One[Notoki]
Index
165
Knowledge
About the user customizing
The setting of each function of the door lock switch can be changed by the customer's hope.
Please make the power supply a close of all doors from turning off or ACC to turning on, and operate the gear-shift
and the door lock switch according to the modification method of the table below within about ten seconds. -
The setting of each function changes effectively and invalidly whenever operating it according to the modification method of the
table below. (Change effectively invalidly if the setting of a current each function is effective if it is invalid. )-
When the change operation is completed, the lock and the unlocking operation are repeated once.
Modification method
Function Content
Gear-shift position Door lock switch
Induction of velocity of car The velocity of the car is about 20. [**]It becomes/h or more. The lock side of the switch is
[**]Position other than
Auto door lock The door all is locked. separated pushing for about five seconds.
- It drinks and the function is set invalidly in initialization (The factory is shipped).
166
Opening and shutting of door door the glass etc.
Contents
. earliness.. Basic
Lock lever operation
[wakari]
Lock
Unlocking
Driving
Handling
device
Door lever
The
It locks when the lock lever is pushed forward, and it is unlocked when drawing it out backward.
Handling indoor
equipment
- Method of lock outside car
Lock lever
. good.. Safety
[na] ・
Lock of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Door handle
The lock lever is adjusted to the lock side, and the door is closed with the door handle pulled. Myriad
One[Notoki]
Index
167
Knowledge
About a convenient function
The door opens when the driver's seat door pulls the door lever in the car even if the lock lever
is a lock side.
168
Opening and shutting of door door the glass etc.
Contents
Knowledge
Warning
About a convenient function
[Irumine-teddoentori-shisutemu] (Refer to P.480).
The lighting of each part is lit and turned off by the state of the door, the power supply, and the position of the gear-shift.
. earliness.. Basic
operation
About the effect of the lock and unlocking while getting on [wakari]
It locks while getting on, there are the following effects respectively about unlocking, and select it, please.
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
169
Opening and shutting of slide door
Lock lever
Lock
Unlocking
It locks when the lock lever is pushed forward, and it is unlocked when pulling it backward.
The lock lever is adjusted to the lock side, and the door is closed.
Knowledge
About the lock and unlocking
Key cylinder, door lock switch, and smart entry & start systems on the wireless
door lock remote control switch and the driver's seat door lock all doors and can
unlock it. "Method of lock and unlocking with door lock switch" of "Method of lock and unlocking
with mechanical key" of "How to use of wireless door lock remote control" of P.200 and P.161 and P.164Please
refer to "Lock and how to unlock the door" of P.132.
170
Opening and shutting of door door the glass etc.
Contents
It shuts.
Driving
It opens. Handling
device
An inside steering wheel is operated in the direction where it wants to move the slide door. -
The
When the lever is a lock side of the lock (Refer to P.170), the slide door is
Handling indoor
not opened. - equipment
When the lever is a lock side of the protector of child (Refer to P.182),
the slide door is not opened.
. good.. Safety
[na] ・
- Opening and shutting outside car of
[to] Comfortable
theory
Exterior steering wheel equipment
How and
to attention
associate
. drinking..
Opening car
Close
Maintenance
When opening it, the exterior steering wheel is pulled and the slide door is operated
behind the vehicle. Myriad
After the exterior steering wheel is pulled and the stopper is released, the slide door One[Notoki]
is operated forward of the vehicle when closing. -
When the lever is a lock side of the lock (Refer to P.170), the slide door is
not opened. Index
171
Please guard the following when you open and shut the
slide door.
- Please guard the following when you open and shut the slide door. It might cause an unexpected accident
as hands and feet and the face, etc. are placed in the door if it doesn't defend and is dangerous.
[**]Please open and shut with the slide door steering wheel.
[**]Please never produce hands and feet and the face, etc. from the window when you open and shut with the door
glass of the slide door opened.
[**]Please confirm safety behind the slide door enough.
[**]Please do not place other people's hands etc.
[**]Please do not put hands and feet in the slide door etc.
Rail Arm
Pillar part
Rail Arm
[**]Please open to the position of opening completely without fail and fix surely when you open the slide door. (The slide
door is fixed by the stopper when opening it completely. )It is likely to begin to move
unexpectedly if the slide door is not surely fixed.
[**]When the door middle stops the stopper the slide at the position (Refer to P.173), the slide
door is not fixed. Please note that the door might begin to move unexpectedly on the slope
etc. enough. -
Please do not let the child operate the door.
[**]In the worst case, it reaches important injury or, it is likely to lead to the death by placing the hand, the
head, and the neck, etc. when closing.
[**]The door might be opened while running, the child throw out outside the car, and it reaches important
injury or, in the worst case, it lead to the death. -
Please confirm all doors have closed completely before it runs.
It opens suddenly while running if the door is not completely closed the door, might cause an unexpected accident,
and is dangerous.
172
Opening and shutting of door door the glass etc.
Contents
The
Slide door
[Riyasuteppu]
Handling indoor
Roller slide side equipment
Knowledge
. good.. Safety
[na] ・
About the safety feature of
[to] Comfortable
The middle stopper theory
- The slide door opens only on the way when the door glass of the slide door is greatly equipment
open or [fuyu;-eruriddo] (fueling entrance) is open.
(Stop at the middle stopper position. )- How and
to attention
Please shut the door glass and [fuyu;-eruriddo] when you completely open the slide door that stopped
associate
at the middle stopper position, and open the door again after completely closing the slide door . drinking..
once when the door glass is open. car
Myriad
One[Notoki]
Index
173
Slide door easy closer *
If it closes the slide door to the position of a half door, an easy closer works, and
the slide door easy closer installation car becomes all closes automatically.
Knowledge
About a slide door easy closer
If the slide door is closed to the position of a half door, an easy closer works, and it becomes all closes
automatically. It operates regardless of the engine switch. -
The door can be opened by pulling an inside steering wheel and the exterior steering wheel
(Refer to P.171) while an easy closer even is operating. (When the lock lever or the child
protector is a lock side, exclude it. )-
When the door is closed with the slide door steering wheel pulled, an easy closer doesn't
occasionally operate. -
The door can be completely closed without handling an easy closer by hand power.
174 - As for the sign, the presence of the installation is different depending on the grade etc.
Opening and shutting of door door the glass etc.
Contents
. earliness.. Basic
operation
Orange [wakari]
Driving
Handling
device
Main switch
The
It changes into turning on and turning off whenever the main switch is pushed. - Handling indoor
When the main switch is turned off, the power slide door cannot be opened and shut equipment
. good.. Safety
Knowledge [na] ・
of
[to] Comfortable
About the main switch theory
equipment
- When the main switch is turned off, an easy closer operates. (Refer to P.174. )-
It becomes impossible to open and shut the power backing door (Refer to P.188) by the automatic operation at the same time
How and
when the main switch is turned off. to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
- As for the sign, the presence of the installation is different depending on the grade etc. 175
- Automatic opening and shutting with slide door steering wheel
. exterior steering wheel . . inside steering wheel .
Inside steering wheel
It shuts.
It opens.
It opens completely by the automatic operation when opening it to the position in which the buzzer rings by operating the
steering wheel when the power slide door is a close all states.
Moreover, when the steering wheel is operated to the position in which the buzzer rings when the power slide door is a fully
open condition, automatic operation and . of close all [shimasu]. The buzzer rings intermittently while operating of
the close. -
In the exterior steering wheel, it changes into all operation closed (open completely) if the steering wheel
is operated again while opening (all closes) completely is operating. However, about one second begins from all states
closed (open completely) the automatic opening and shutting operation and doesn't change into all operation closed
(open completely) even if the steering wheel is operated again. -
In an inside steering wheel, it changes into the close all operation if the steering wheel is operated again
forward of the vehicle while opening completely is operating. It changes into the close all operation if the steering wheel
is operated again behind the vehicle while all operating of the close. However, about one second begins from all states
closed (open completely) the automatic opening and shutting operation and doesn't change into all operation closed (open completely)
even if the steering wheel is operated again forward of the vehicle (rear side of the vehicle). -
The child protector lever is good at neither a state of the lock (Refer to
P.182) nor automatic [hirasousa] with an inside steering wheel.
176
Opening and shutting of door door the glass etc.
Contents
Switch
Passenger's seat side switch
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
- The buzzer rings at operated open and shut ..unsealing.. [hajime]. (The buzzer rings intermittently while operating How and
of the close. )- to attention
It changes into all operation closed (open completely) if the switch is pushed again while opening (all closes) associate
. drinking..
completely is operating. However, about one second begins from all states closed (open completely) the automatic opening and car
shutting operation and doesn't change into all operation closed (open completely) even if the switch is pushed again.
Myriad
One[Notoki]
Index
177
In the power slide door installation car, please guard the
following. The finger and the hand, etc. are placed in the slide door, and it might
cause an unexpected accident and is dangerous if it doesn't defend.
- When you open and shut automatically, please note that surrounding safety is confirmed, and neither the finger nor the hand, etc. are placed
in the slide door enough. Please note rolling goods of surroundings such as bags and neckties
enough. Moreover, please do not let the child operate it. -
Please never produce hands and feet and the face, etc. from the window when you open and shut with the door glass
opened automatically. -
Please turn off the main switch when you exchange tires of the rear wheel. The power
slide door moves when it touches the slide door steering wheel etc. playing a trick if it doesn't make it to turning off
and by mistake, the finger and the hand, etc. are placed, and it is likely to injure. -
Operation stops, and it changes into the manual operation when the main switch is turned off when being open and shuting
automatically. In this case, please note that the power slide door might begin to move unexpectedly
uphill on the slope etc. enough. -
The buzzer might ring, operation stop, and it change into the manual operation when not filling it with the condition
that P.180 can be operated when being open and shuting automatically. In this case, please note that the power
slide door might begin to move unexpectedly uphill on the slope etc. enough. -
The sensor on the edge is a device in front of the power slide door that detects the obstacle, and prevents including scissors. It
is not likely to be able to detect it according to shape and how to place the placed thing. Be careful enough when
the slide door opens and shuts. -
The door might be judged the system malfunction due to the decrease in the voltage of the battery when the power supply is
turned on while opening and shutting the engine stop automatically, and is reversed or stop automatically. It might cause an
unexpected accident, it is not dangerous, and do not turn on the engine switch, please while opening and shutting
automatically.
178
Opening and shutting of door door the glass etc.
Contents
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
179
Knowledge
About the operation of the power slide door
(It is possible to use it regardless of the state of the power supply. )-
When it meets all the following requirements that can the operation of the main switch by turning on, it is possible to open and shut by the automatic
operation.
. condition that can be operated .
[**]When the power slide door is unlocked. (The close operation is excluded. )
[**]When [fuyu;-eruriddo] is closed (Only the passenger's seat side power slide door :).
[**]At the time of about less than 3 km/h in velocity of the car.
[**]When the power supply is turned on, it is necessary to meet either of the following requirement in addition to the above-mentioned.
・The gear-shift [**][Notoki]
.・When the parking brake hangs.
・When stepping on the brake pedal. -
When it doesn't meet the requirement it is possible to operate (Time when [fuyu;-eruriddo] is open is excluded), the brake is
applied to the slide door for about eight seconds when the door is closed by the manual operation (Open it) and the speed of
the door is controlled. -
When the main switch is turned off, the power slide door can be opened and shut by hand power though doesn't
operate. -
The buzzer rings when the disorder is perceived with the person and the foreign body, etc. while automatic of the power slide door opening
and shutting, and the door moves from the position in the counter direction automatically. However, when the disorder is perceived within the range
from the position of opening completely to this side about 20cm when opening it by the automatic operation, operation is stopped at the position. -
The buzzer rings when the second times or more continuously perceive the disorder to the same direction, and it changes into the manual
operation (The brake is applied to the slide door for about eight seconds and the speed of the door is controlled). Please go on the
door by hand power all close or after it opens it completely once after turning off the main switch when
you operate the door by the automatic operation again. -
The power slide door might not operate when the voltage of the battery has decreased.
180
Opening and shutting of door door the glass etc.
Contents
Knowledge
Warning
About the safety feature
The middle stopper (power slide door installation car)
- When the power slide door is open operated by the automatic operation when the door glass of the power
slide door is greatly open, the power slide door stops at the middle stopper position, and is maintained . earliness.. Basic
at the position. - operation
[wakari]
The door operates when either the power slide door switch, the slide door steering wheel or the
power slide door remote control switch is operated when the power slide door has stopped at the middle
stopper position of the close. -
After the power slide door at the middle stopper position stops, the door is maintained for about 30 minutes.
Driving
Afterwards, the maintenance will be gradually released in eight seconds, and the door is prevented from beginning to move rapidly in the downward Handling
slope etc.The device
About initialization
. good.. Safety
Please initialize the power slide door when blowing the fuse and the battery rising, [na] ・
of
etc. come. (When blowing the fuse and the battery rising, etc. come at the close all time, [to] Comfortable
the power slide door need not initialize it. )The following function doesn't operate if the power theory
equipment
slide door has not been initialized. -
Power slide door
How and
- Scissors prevention mechanism to attention
- Slide door easy closer associate
. drinking..
- Method of initialization car
. set-up steps .
It closes it completely once by hand power by the operation of the exterior steering wheel of the slide door. (Refer to P.171. )
Maintenance
Myriad
One[Notoki]
Index
181
How to use of the child protector.
Child protector lever
Unlocking
Lock
The child protector lever is adjusted to the lock side and the door is closed. -
It becomes impossible to open the slide door with an inside steering wheel in
the car.
Knowledge
About the child protector
The child mistakes and it is possible to lock in an inside steering wheel control in the car regardless of the
position of the lock lever while running so that the slide door should not open so as not to open the door.
182
Opening and shutting of door door the glass etc.
. earliness.. Basic
operation
Backing door opening switch [wakari]
Driving
Handling
device
The backing door opening switch is pushed, and the backing door is lifted. - The
Please lift up to the uppermost part when you open the backing door. - Handling indoor
equipment
Please confirm the backing door doesn't descend naturally.
. good.. Safety
- How to close [na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
The backing door is sold wholesale with the backing door grip, and the bottom of the backing
door is suppressed and locked.
Myriad
One[Notoki]
Index
183
Please never take the person in the luggage room.
- Please never take the person in the luggage room. It flies the body when time that slammed
on the brakes and colliding, and it reaches important injury or, in the worst case, it is likely to lead
to the death. -
Please do not place other people's hands etc. when you close the backing door. Moreover,
please do not let the child operate the backing door.
[**]In the worst case, it reaches important injury or, it is likely to lead to the death by placing the hand, the
head, and the neck, etc. when closing. -
Please close the backing door pushing from the outside without fail. When the backing door is closed directly in the
backing door grip, the hand and the arm, etc. are placed, and important injury might be received and it is dangerous. -
Please confirm the light shake of the backing door before it runs, and the lock surely.
It opens suddenly while running if the backing door is not surely closed the backing door, might cause an
unexpected accident, and is dangerous. -
Please do not run with the backing door opened. It hits the one outside the car etc. by the backing
door if running while opened, might cause an unexpected accident, and is dangerous. Moreover, the vehicle
exhaust emission invades in the car, it becomes CO intoxication, and it reaches important injury or, in the worst case, it
is likely to lead to the death. Please confirm the backing door has closed without fail before
it runs. -
Please open completely without fail and use the backing door. The backing door drops when using it while opened
half, and it is likely to injure. -
Please do not close the backing door, and do not hang with [bakkudoasute-]. It shifts,
and when the hand is placed, and [danpa-sute-] is damaged, it might cause an unexpected accident and
is dangerous.
Striker bar
184
Opening and shutting of door door the glass etc.
Contents
lamp is turned on. It is convenient for the luggage confirmation such as nighttime.
One[Notoki]
Index
185
Knowledge
About the emergency lever
The door lock can be released in the car by operating the emergency lever when the backing
door is not opened outside the car in the place where the battery goes up.
Cover
Emergency lever
Please receive the check ahead of time in the Toyota shop when you break down.
186
Opening and shutting of door door the glass etc.
Contents
. earliness.. Basic
Please do not place the finger etc. so that an easy closer operation
[wakari]
may work at a half door and the backing door may close
automatically in the backing door easy closer installation car.
- Please do not place the finger etc. so that an easy closer may work at a half door and the
Driving
backing door may close automatically. Important injury might be received and it is dangerous. - Handling
When the main switch of the power backing door is turned off, an easy closer
device
operates.
The
In the backing door easy closer installation car, please do
Handling indoor
not put impossible power while an easy closer is operating. equipment
- Please do not put impossible power while an easy closer is operating. When impossible power
is put, it causes the easy closer's breakdown. -
When the open close of the backing door is repeated in short course, an easy closer doesn't occasionally . good.. Safety
operate. In this case, it operates when the door is opened once, and it closes at a certain intervals again when it is a few. [na] ・
of
[to] Comfortable
theory
equipment
Knowledge
How and
About a backing door easy closer to attention
If the backing door is closed to the position of a half door, an easy closer works, and it becomes all closes associate
. drinking..
automatically. It operates regardless of the state of the power supply. - car
When the main switch of the power backing door is turned off, an easy closer
operates. -
The backing door can be opened by pushing the backing door opening switch (Refer
to P.183) while an easy closer even is operating. -
Maintenance
When the door is closed with the backing door opening switch pushed, an easy closer doesn't
occasionally operate. -
The backing door can be completely closed without handling an easy closer by hand power.
Myriad
One[Notoki]
Index
- As for the sign, the presence of the installation is different depending on the grade etc. 187
Method * of automatic opening and shutting of power backing door
- Main switch
Orange
Main switch
It changes into turning on and turning off whenever the main switch is pushed. -
When the main switch is turned off, the power backing door cannot be opened and shut
by the automatic operation.
Knowledge
About the main switch
- It becomes impossible to open and shut the power slide door by the automatic operation at the same time when the main switch
is turned off. -
When the main switch is turned off, an easy closer operates. (Refer to P.187. )
188 - As for the sign, the presence of the installation is different depending on the grade etc.
Opening and shutting of door door the glass etc.
Contents
. earliness.. Basic
operation
[wakari]
device
The backing door closes in the automatic operation when the power backing door close switch is pushed
when the backing door is a fully open condition. -
The buzzer rings when beginning to operate of the close, and the emergency blinking light blinks twice. - The
The buzzer rings intermittently while operating of the close. - Handling indoor
equipment
When the switch is pushed again while operating of the close, the reversing operation is done in the direction of opening completely.
How and
to attention
associate
. drinking..
car
When it keeps pushing the power backing door switch for about one second or more when the backing door is all states closed Maintenance
189
Please guard the following in the power backing door installation car.
The finger and the hand, etc. are placed in the backing door, and it might cause
an unexpected accident and is dangerous if it doesn't defend.
- Please do not confirm surrounding safety, and do not place the finger etc. enough in the backing door when you open and shut
automatically. Moreover, please note personal belongings such as bags and neckties enough. Please do
not let the child operate it. -
Please turn off the main switch when you exchange tires. The power backing door
moves when it touches the switch etc. playing a trick if it doesn't make it to turning off and by mistake, the finger and
the hand, etc. are placed, and it is likely to injure. -
Operation stops, and it changes into the manual operation when the main switch is turned off when being open and shuting
automatically. In this case, please note that the backing door might begin to move unexpectedly
enough. -
The buzzer might ring, operation stop, and it change into the manual operation when not filling it with the operation
condition of P.191 when being open and shuting automatically. In this case, please note that the backing door
might begin to move unexpectedly uphill on the slope etc. enough. -
Be careful enough when the prevention mechanism operates including scissors. It hits the backing door,
and it is likely to injure. -
Please do not install the accessories articles other than a Toyota pure goods in the power backing door.
It is not possible to open and shut by the automatic operation when the skiing career etc. are installed in the backing door
and the power backing door might break down. Moreover, the backing door drops after it opens completely, and
important injury might be received. -
The sensor at a right and left edge in the power backing door is a device that detects the obstacle, and prevents including scissors.
It is not likely to be able to detect it according to shape and how to place the placed thing. Be careful enough when
the door opens and shuts. -
The door might be judged the system malfunction due to the decrease in the voltage of the battery when the power supply is
turned on while opening and shutting the engine stop automatically, and is reversed or stop automatically. It might cause an unexpected
accident, it is not dangerous, and do not turn on the power supply, please while opening and shutting automatically.
190
Opening and shutting of door door the glass etc.
Contents
Knowledge
Warning
About the operation of the power backing door
(It is possible to use it regardless of the state of the power supply. )-
When it meets all the following requirements that can the operation of the main switch by turning on, it is possible to open and shut by the automatic
operation. . earliness.. Basic
. condition that can be operated . operation
[wakari]
[**]When the power backing door is unlocked.
[**]At the time of about less than 5 km/h in velocity of the car.
[**]To open operate when the power supply is turned on, the gear-shift in addition to the above-mentioned :. [**][Tonatteiruko]
It is necessary to be sharpened. - Driving
When the main switch is turned off, the power backing door can be opened and shut by hand power though doesn't Handling
operate. - device
It changes into manual operation if the backing door opening switch is pushed while automatic of the power backing door
opening and shutting. -
The buzzer rings when the disorder is perceived with the person and the foreign body, etc. while automatic of the power backing door opening and The
shutting, and the door moves from the position in the counter direction automatically. - Handling indoor
The buzzer rings when the disorder of the closing direction in the second times or more is continuously perceived and it changes into manual equipment
operation. -
The power backing door might not operate when the voltage of the battery has decreased.
Please initialize the power backing door when blowing the fuse and the battery rising,
etc. come. (When blowing the fuse and the battery rising, etc. come at the close all time, the
power backing door need not initialize it. )The following function doesn't operate if the power backing Maintenance
door has not been initialized. -
Power backing door
- Scissors prevention mechanism
- Backing door easy closer Myriad
191
Opening and shutting of the door glass
All the door glass can be opened and shut with the driver's seat switch.
Switch
Switch
192
Opening and shutting of door door the glass etc.
Contents
seconds however. -
The operation pilot light of each switch lights while power supply OFF latter harvest movement functions.
Myriad
One[Notoki]
Index
193
Knowledge
About initialization
Please initialize the power window when the connection with the battery is refused while opening and
shutting the power window. -
The following function doesn't operate if the power window has not been initialized.
[**]Passenger's seat in driver's seat switch and opening and shutting of the rear seat door glass
[**]Automatic opening and shutting of the door glass
[**]Scissors prevention mechanism
[**]Power supply OFF latter harvest movement function
- The operation pilot light of the switch blinks to the door glass that the power window has not been
initialized.
- Method of initialization
The power window of the each door glass is initialized with each seat switch.
The power window of the passenger's seat and the rear seat door glass cannot be initialized with the driver's
seat switch.
. set-up steps .
1 The power supply is turned on.
2 It keeps pushing the switch below, and the door glass is opened to the half.
When the initialization of the power window is completed, the operation pilot light of the switch divides from blinking
into lighting.
194
Opening and shutting of door door the glass etc.
Contents
Neither the power window nor [riyasanshe-do] (large-scale Moon roof installation car) other
than the driver's seat door glass open and shut when the switch is turned on.
. earliness.. Basic
operation
Window Passenger's seat switch [Riyasanshe-do] [wakari]
Driver's seat switch
Lock switch and rear seat switch (large-scale Moon roof installation car)
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
195
Please produce neither hand nor the face from the window while running.
- Please produce neither hand nor the face from the window while running. In the worst case, it reaches important injury
when it hits the one outside the car etc. or it slams on the brakes or, it is likely to lead to the
death. -
Please place other people's hand, arm or neither head nor necks, etc. when the door glass is
opened and when it closes. In the worst case, it reaches important injury or, it is likely to lead to the
death by being placed between the door glass and being rolled. -
Please do not let the child operate the door glass. In the worst case, it reaches important
injury or, it is likely to lead to the death by the hand, the arm, the head, and the neck's, etc. placing and being rolled
when the opened time and closing.
There is an area where it doesn't perceive including scissors in the part immediately before
the shutting cutting.
- There is an area where it doesn't perceive including scissors in the part immediately before the shutting cutting to close
the door glass surely. Please do not place the finger etc.-
The prevention mechanism doesn't operate the switch in the state that was able to continue strongly including scissors. Please do not
place the finger etc.-
When by any chance the prevention mechanism operates, and the door glass cannot be closed by the automatic operation
including scissors, the switch can be closed when it is possible to continue. -
Please do not move the switch of the driver's seat switch and other doors in the opposite direction at the same time. It causes
the breakdown of the power window. -
After opening completely the door glass closed, all do not keep pushing the switch in be the same direction. It causes
the breakdown of the power window.
196
Opening and shutting of door door the glass etc.
Warning
Tilt improvement/how to
down reception desk Moon roof
. earliness.. Basic
Button Steering wheel operation
[wakari]
Driving
Handling
device
The
- When the tilt improves Handling indoor
The steering wheel is pushed up up while pushing the button. equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
- As for the sign, the presence of the installation is different depending on the grade etc. 197
Electric how to open and shut [riyasanshe-do]
Front seat switch Rear seat switch
OPEN side
Switch
OPEN side
CLOSE side
Switch CLOSE side
- When opening it
When the OPEN side of the switch is pushed, it opens by the automatic operation. -
When operation is stopped on the way, the switch is pushed again. -
It is possible to open it a little by pushing the switch, and separating the hand at once.
- When closing
When the CLOSE side of the switch is pushed, automatic operation and . of close all [shimasu]. -
When operation is stopped on the way, the switch is pushed again. -
It is possible to close a little by pushing the switch, and separating the hand at once.
Please produce neither hand nor the face from the reception desk Moon roof
while running.
- Please do not put out the hand etc. from the reception desk Moon roof while running. In the worst case, it
reaches important injury when it hits the one outside the car etc. or it slams on the brakes or, it is
likely to lead to the death. -
Please do not place other people's hands etc. when you close the reception desk
Moon roof. It is placed between the Moon roof, and important injury might be received and it is dangerous. -
Please do not let the child operate the reception desk Moon roof and [riyasanshe-do]. Important
injury might be received by placing the hand etc. when closing and it is dangerous.
198
Opening and shutting of door door the glass etc.
Contents
Knowledge device
The prevention mechanism might operate including scissors when time when the foreign body was placed and the same impact and the load associate
. drinking..
join the shade according to the environment and the running condition. car
Maintenance
Myriad
One[Notoki]
Index
199
How to use of the wireless door lock remote control.
Lock
Unlocking
Lock Unlocking
LED
When the switch is pushed, all doors (The backing door is included) are locked.
When the switch is pushed, all doors (The backing door is included) are unlocked. -
The emergency blinking light blinks once, and the buzzer rings once when locking. -
- The emergency blinking light blinks twice, and the buzzer rings two times when unlocking it. -
- LED of the key lights when the switch is pushed. -
Please push the switch surely slowly. -
Please confirm the lock operation was done without fail when you do the lock operation.
- This function can be changed. Please refer to "User customizing function" of P.617 for
details.
200
Opening and shutting of door door the glass etc.
Contents
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
Index
- As for the sign, the presence of the installation is different depending on the grade etc. 201
How to open and shut power backing door
Power backing door installation car
LED
When it keeps pushing the backing door switch for about one second or more when the power backing door is all states closed
(open completely), it opens completely by the automatic operation (all closes). -
..opening and shutting operation.. ..unsealing.. buzzer in [hajime] rings, and the emergency blinking light blinks twice. -
The buzzer rings intermittently while opening and shutting is operating. -
It changes into all operation closed (open completely) if the switch is pushed again while opening (all closes)
completely is operating. However, about one second begins from all states closed (open completely) the automatic opening and
shutting operation and doesn't change into all operation closed (open completely) even if the switch is pushed again. -
Please push the switch surely slowly. -
LED lights when the switch is pushed.
Remote control is electronic parts. It causes the breakdown when the high
impact etc. are given, and note the following points, please.
- Please do not put it on the place that becomes a high temperature such as on dashboards. -
Please do not resolve it. -
Please do not drop, and do not give the high impact. -
Please do not wet it to water.
202
Opening and shutting of door door the glass etc.
Contents
Knowledge
Warning
About the operation condition
- The distance that can be operated according to surrounding circumstances might change into remote control. Please approach
from the car to about 1m to operate surely and operate it. -
The electric wave to the receiver is interrupted when remote control is operated from the rear side of the vehicle when the following . earliness.. Basic
one is pasted to the backing door glass and it applies it, the reception sensitivity decreases, and the distance that can be operated operation
[wakari]
might shorten.
[**]Window film that contains metal.
[**]Other metallic things. (antennas etc. other than Toyota pure goods)-
As for the remote control switch, the power supply doesn't operate excluding turning off. -
Driving
The switch doesn't operate when either of door (The backing door is included) is open. Handling
- SwitchEven if it keeps pushing the switch, neither the lock nor unlocking the door are repeated. Please device
push the switch again. -
When the door is not opened within about 30 seconds after the unlocking operation is done pushing the switch,
it is locked automatically. (The emergency blinking light blinks once. )- The
- Neither the power slide door remote control switch nor the power backing door remote control switch Handling indoor
equipment
operate when the main switch in the driver's seat is turning off. -
Even if it keeps pushing the switch for about one second or more when the opening and shutting operation is not done well pushing
the power slide door remote control switch and the power backing door remote control switch, the opening and shutting operation
is not repeated. Please push the switch again. . good.. Safety
[na] ・
of
[to] Comfortable
About a convenient function theory
equipment
[Irumine-teddoentori-shisutemu] (Refer to P.480).
The lighting of each part is lit and turned off by the state of the door, the power supply, and the position of the gear-shift. How and
to attention
- This function can be changed. Please refer to "User customizing function" of P.617 for associate
. drinking..
details. car
Maintenance
Myriad
One[Notoki]
Index
203
Knowledge
About the battery exchange
The consumption of the battery is thought when L ED darkens or it doesn't light when it doesn't operate even
if remote control is operated, and the distance that can be remarkably operated shortens. Please change
a battery.
If a precise driver on the market is used, the customer can exchange the exchanges of the batteries. Please
refer to "Battery exchanges of keys" of P.576. (The Toyota shop can exchange it. )
204
Opening and shutting of door door the glass etc.
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
When [fuyu;-eruriddoo-puna-] ( ) in lower right of driver's seat [inpane] is pulled, the opening.
It comes.
The
When closing, [fuyu;-eruriddo] is closed to the place where "[Kachi]" and the sound are heard
Handling indoor
with the hand. equipment
How and
It opens it. to attention
associate
. drinking..
car
Switch
Myriad
One[Notoki]
Index
205
Location of fuel cap
The fuel cap is put in the suspender
while refueling.
Suspender
206
Opening and shutting of door door the glass etc.
Contents
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
207
Opening and shutting of bonnet
How to open it
1 The bonnet opener is pulled.
The bonnet comes to the surface a little
when the bonnet opener under the right of the
driver's seat Instrument panel is pulled.
Bonnet opener
Bonnet hook
2 The bonnet hook is removed.
The hand is put in the space of the
bonnet, the lever is pushed up, the bonnet
hook is removed, and the bonnet is lifted.
Lever
3 [Bonnettosute-] is inserted.
[Bonnettosute-] is inserted in the [sute-]
hole and the bonnet is supported.
[Sute-] hole
[Bonnettosute-]
208
Opening and shutting of door door the glass etc.
Contents
How to close
1
Warning
[Bonnettosute-] is removed.
[Bonnettosute-] is removed and fixed.
. earliness.. Basic
The bonnet is quietly dropped from the position of about 20-25cm and it closes.
It is confirmed to shake the forward end to the bonnet up and down, and to be device
locked surely.
The
Handling indoor
It opens when running without locking the bonnet, might cause an unexpected equipment
accident, and is dangerous.
. good.. Safety
[na] ・
of
Please do not place the hand etc. when the bonnet is [to] Comfortable
theory
dropped and it closes. equipment
- Please do not place the hand etc. when the bonnet is dropped and it closes. -
Please do not push strongly by putting weight when closing the bonnet. The How and
to attention
bonnet might dent. -
associate
Please insert it in the [sute-] hole with the resin part . drinking..
of [bonnettosute-] when opening the hood after it runs for a car
long time. Because [sute-] is hot when having it excluding
the resin part, the burn might be done.
Maintenance
Resin part
Myriad
One[Notoki]
Index
209
How to use * of an anti-theft system (auto alarm)
Please lock by the wireless door lock remote control & start
system of [su] mart entry the peel ..the lock and unlocking the
door...
- We will recommend the lock and unlocking the door to be done by smart entry & start system
(Refer to P.132) and the wireless door lock remote control (Refer to P.200).
In the lock with the key (mechanical key), an auto alarm doesn't enter the state that can be operated. -
Warning an auto alarm operates when the door is unlocked with a key (mechanical
key) after the door is locked by smart entry & start system and remote control of a
wireless door lock.
To stop warning an auto alarm, it stops by turning on unlocking or the power
supply in a smart entry & start system and door by the wireless door lock remote
control.
Knowledge
About the warning operation
The horn is sounded for about 30 seconds, the emergency blinking light is blinked, and it informs surroundings of abnormality. Moreover,
it locks compulsorily when either of door is unlocked while warning and the invasion in the car is prevented.
It enters the state that the system can operate again by about 30 seconds after the warning operation is done.
210 - As for the sign, the presence of the installation is different depending on the grade etc.
Opening and shutting of door door the glass etc.
Contents
Please do not put it into the state that the system can operate in the state that the The
state and the door glass that the person is on a roll open. Handling indoor
equipment
- An auto alarm operates in the state that the person is on a roll in the car and the state that the door
glass opens. Please do not put it into the state that the system can operate in the state that the state and the door glass that the
person is on a roll open to prevent unexpected operation of warning. -
An auto alarm might be warned, a compulsory lock operate, and release the state that . good.. Safety
[na] ・
the system can operate by a wireless door lock etc. , please when the battery charging of
and you exchange it by the battery rising after setting an auto alarm. Please do not [to] Comfortable
theory
leave the key in the car for the shutting prevention of the key. equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
211
Knowledge
About the state that the system can operate
- 1 It doesn't enter the state that the system can operate when either the following is done drinking within about 30 seconds
(state of the system standby the pilot light's lighting) after the operation. (The stand-by state is released. )
[**]When you open either of door or the bonnet.
[**]When you unlock either of door.
[**]When you reconnect the battery.
[**]When you push the engine switch. -
When either the following is done while the pilot light is blinking, the state that the system can operate is released.
[**]When you unlock the door with a smart entry & start system, wireless door lock
remote control, and mechanical key.
[**]When you turn on the power supply by using smart entry & start system
212
Opening and shutting of door door the glass etc.
Contents
Warning
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate . drinking..
car
Maintenance
Myriad
One[Notoki]
Index
213
Adjustment of seat
Correct driving posture
The seat is adjusted noting the following matter to take correct driving posture.
- Please do not adjust the driver's seat seat while running. The seat moves suddenly while adjusting it,
driving is mistaken, it might cause an unexpected accident, and it is dangerous. -
Please shake the seat before ..lightening.., and confirm fixation surely after
adjusting the seat. Important injury that moves if not fixed the seat, causes an unexpected accident,
and is related to the life might be received and it is dangerous. -
Please do not put the one under the seat. The one narrows, the seat is not fixed, it might cause
an unexpected accident, and it is dangerous. Moreover, it causes the breakdown of the lock mechanism. -
Please do not put the cushion (square cushion) of the back etc. between the drip and the back. Important injury that
is not demonstrated the effect of the seat belt and the headrest enough when cannot not only take correct driving posture
but also colliding, and is related to the life might be received and it is dangerous. -
Please do not pile luggage to the passenger's seat and the rear seat. It dashes out when time that slammed
on the brakes and the car are turning luggage, might cause an unexpected accident by the nature's
hitting the crew, damaging luggage, and being taken in luggage, and is dangerous. -
Please do not move while running ..get on to places other than the seat and in the car... It flies the body by
inertia force when time that slammed on the brakes and colliding, and the head etc. are strongly stricken, the important
injury related to the life might be received, and it is dangerous.
214
Adjustment of seat
Contents
Please note the situation of the circumference such as those who multiply this and
. good.. Safety
luggage when you adjust the seat. [na] ・
of
- Please do not hit it to the seat on the seat and side before and behind those who multiply this and [to] Comfortable
luggage when you adjust the seat. Those who multiply this might be injured, luggage be destroyed, and theory
equipment
the seat be damaged. -
Please do not bring the hand close near the seat under and the moving part when you adjust How and
the seat. The finger and the hand are placed, and it is likely to injure. - to attention
Please note that it is likely to injure at the seat rail seat frame (foundation part in associate
. drinking..
the seat) etc. in the place where time when the room is cleaned and what dropped under the car
seat is picked up when the hand is put under the seat enough. -
After of the movement of a top and bottom of the reclining position and the seat of the drip position to the terminal, do not keep
pushing the switch of the lengthwise position and the back of the seat in be the same direction in the power seat installation car. It
causes the breakdown of the power seat. - Maintenance
Please do not pave the mat etc. on the seat rail.
When the seat is moved, the rubber part in the seat rail might be damaged.
Myriad
One[Notoki]
Index
215
Adjustment of reception desk seat
Forward
Slide lever
Switch
It operates while the switch is being operated The seat is moved back and forth with the
back and forth. slide lever pulled and it adjusts it.
- Reclining adjustment
Power seat Manual seat
It knocks it down.
It causes it.
Switch
Reclining lever
It operates while the switch is being operated The back also moves the drip back and forth
back and forth. with the reclining lever pulled and it adjusts
it.
216
Adjustment of seat
Contents
Driving
Handling
It falls. device
It falls.
The height of the edge is adjusted by the vertical The steering wheel is spent and the height of the The
operation in front of the switch in front of the seat cushion. edge is adjusted in front of the seat cushion. Handling indoor
equipment
. good.. Safety
[na] ・
of
It goes up. [to] Comfortable
It goes up. theory
equipment
How and
to attention
associate
. drinking..
It falls. car
It falls. Lever
Switch
The height of the entire seat is adjusted by the Whenever the lever is moved below on, the
vertical operation on the part of switch [ushiro]. height of the entire seat is adjusted. Maintenance
Myriad
One[Notoki]
Index
217
Please do not position it while about running.
It moves suddenly greatly when slamming on the brakes the seat, is thrown out, and
might receive important injury that causes an unexpected accident, and is related to
the life and is dangerous.
Please do not place the foot between the reception desk seat
and [ottoman] when you position the back and forth.
- Please note that the crew of [sekandoshi-to] doesn't place its foot between the reception desk seat and
[ottoman] enough when you use [ottoman] (Refer to P.229) with [sekandoshi-to] when positioning it with seven
person getting on car before and behind the reception desk seat. -
Please the back also must operate the hand in the drip when the back of the manual seat also returns the drip
and operate the reclining lever along can.
When the back doesn't suppress the drip and either the lever is operated, the back returns suddenly the drip, and might
be injured, too.
218
Adjustment of seat
Contents
. earliness.. Basic
operation
[wakari]
Button
Driving
Handling
- Please do not run with the headrest removed. A big impact joins the neck when colliding,
the important injury related to the life might be received, and it is dangerous. Please adjust height . good.. Safety
[na] ・
so that the center of the headrest may become behind the ear. - of
The headrest of the reception desk seat is only for the reception desk seat. Please confirm hearing "[Kachi]" [to] Comfortable
theory
and the sound and fixation when you install it. The important injury related to the life when it equipment
is not possible to fix when the headrest is installed by mistake, and it collides might be received and
it is dangerous. How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
219
How to use of the armrest.
220
Adjustment of seat
Contents
Warning
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate . drinking..
car
Maintenance
Myriad
One[Notoki]
Index
221
Adjustment of [sekandoshi-to]
Slide lever
The seat is moved back and forth with the slide lever pulled and it adjusts it. It is
confirmed to shake the seat lightly after it adjusts it and to be fixed surely.
The right and left slide lever is pulled, the seat is moved to right and left full, and it
adjusts it. It is confirmed to shake the seat lightly after it adjusts it and to be fixed surely.
222
Adjustment of seat
Contents
- Reclining adjustment
Getting on of seven people Getting on of eight people Warning
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
Reclining lever
Reclining lever
The
The back also moves the drip back and forth with the reclining lever pulled and it adjusts it. Handling indoor
equipment
It is confirmed to shake the seat lightly after it adjusts it and to be fixed surely.
. good.. Safety
Please do not position before and after, and do not position the right and left while running. [na] ・
of
[to] Comfortable
theory
- Please do not position before and after, and do not position the right and left while running. equipment
It moves suddenly greatly when slamming on the brakes the seat, is thrown out, and might receive important
injury that causes an unexpected accident and is related to the life and is dangerous. - How and
Please do not let me do the slide the in front of ..[sekandoshi-to].. the [ushiro] the to attention
reception desk seat when you do the slide with sitting on [sekandoshi-to]. It also places the foot associate
. drinking..
etc. also by the back of the reception desk seat between cushion [ottoman] of the drip and [sekandoshi-to], might car
injure, and is dangerous. Especially, the seat might begin to move naturally when the slide is operated
with the child from whom the foot did not reach the floor face pulled the slide lever.
Maintenance
Myriad
One[Notoki]
Index
223
Please ..drip.. operate the hand along can the back when the back
also returns the drip.
- Please the back also must operate the hand in the drip when the back also returns the drip and operate the reclining
lever along can. When the back doesn't suppress the drip and either the lever is operated, the back returns suddenly the
drip, and might be injured, too. -
Please let me do the slide to the full left side whether the full right side without fail about a right and left positioning. The
side position cannot be fixed at the middle position.
Knowledge
About the slide stopper
There is a slide stopper (2) in the slide rail behind [sekandoshi-to] in seven person getting
on car. This is used to prevent the crew in the third seat from placing its foot between the rear end of
[sekandoshi-to] and the cushion of the third seat when the slide was done backward as for [sekandoshi-to].
Please put it into the installed state when the person has gotten on the third seat.
Slide stopper
224
Adjustment of seat
Contents
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
Button Button
The
- Central seat * Handling indoor
equipment
Only getting on of eight people
Button
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Myriad
One[Notoki]
Index
- As for the sign, the presence of the installation is different depending on the grade etc. 225
Please do not run with the headrest removed.
- Please do not run with the headrest removed. A big impact joins the neck when colliding,
the important injury related to the life might be received, and it is dangerous. Please adjust height
so that the center of the headrest may become behind the ear. -
The headrest of [sekandoshi-to] is only for [sekandoshi-to]. Please confirm hearing "[Kachi]"
and the sound and fixation when you install it. The important injury related to the life when it
is not possible to fix when the headrest is installed by mistake, and it collides might be received and
it is dangerous.
Knowledge
About the central seat headrest
A top and bottom of central seat headrest positioning becomes only two stages where the improved time and it
depresses it. Please use the central seat headrest while improved.
226
Adjustment of seat
Contents
Driving
2
Handling
The armrest is lowered to the under. device
The
Handling indoor
equipment
Myriad
One[Notoki]
Index
227
Getting on and off to third seat
- When you get on and off
Getting on of seven people Moving up pedal Getting on of eight people
Moving up pedal
The drip falls forward, and the seat can be moved in the back forward when the
reclining lever is improved or it steps on the moving up pedal on the part of seat
[ushiro]. -
Please depress the moving up pedal of eight person getting on car more strongly than
usually when you put [sekandoshi-to] into the state of the chip improvement (Refer to P.231).
- After it gets on and off
- The back also causes the drip until the sound "[Kachi]" is heard, and the lengthwise position is adjusted.
- It is confirmed to shake the seat lightly after it adjusts it and to be fixed surely.
Please let me be sure to fix [sekandoshi-to] to the third seat after it gets
on and off. The important injury related to the life by the movement of the seat when time
that slammed on the brakes and colliding, except for no fixation, and the hit to the crew, etc.
might be received and it is dangerous.
228
Adjustment of seat
Contents
Please the back also must operate the hand in the drip when the back also
returns the drip and operate the reclining lever along can. Warning
- Please the back also must operate the hand in the drip when the back also returns the drip and operate the reclining
lever along can. When the back doesn't suppress the drip and either the lever is operated, the back returns suddenly the
drip, and might be injured, too. -
[Sekandoshi-to] doesn't move forward even if the moving up pedal of eight person getting on car steps on the moving . earliness.. Basic
operation
up pedal when [sekandoshi-to] is put into the state of the chip improvement (Refer to P.231) by the same power as the [wakari]
time not put into the state of the chip improvement. Please depress the moving up pedal more strongly than usually
when putting it into the state of the chip improvement. -
Please operate it in seven person getting on car after storing the armrest when you move
Driving
the seat forward with the moving up pedal reclining lever. The armrest might hit the seat Handling
cushion when the seat is moved forward without storing the armrest, and the after
device
of the armrest remain in the seat cushion.
The
Handling indoor
equipment
How to use * of [ottoman] (foot Wrest)
. good.. Safety
Easy posture can be taken by stretching one's [na] ・
of
legs. [to] Comfortable
theory
It is stored under the seat cushion. equipment
How and
to attention
associate
. drinking..
car
[Ottoman]
Maintenance
Myriad
One[Notoki]
Index
- As for the sign, the presence of the installation is different depending on the grade etc. 229
- Those who take it out
Lever
- Method of storage
The lengthwise position of [ottoman] is stored in [ushiro]
most, and [modoshi] and it pulls a lever and [ottoman]
is stored under the seat.
Lever
230
Adjustment of seat
Contents
Driving
Handling
Please store the lengthwise position of [ottoman] in [ushiro]
most after [modoshi] when you store [ottoman]. device
- Please store the lengthwise position of [ottoman] in [ushiro] most after [modoshi] when you
store [ottoman]. [Ottoman] damages the lengthwise positions in [ushiro] most when storing it in [modosazu] The
and hit [ottoman] might be damaged to the floor face. -
Handling indoor
Please note one's feet enough so that the foot is not placed when you adjust the reception desk equipment
seat.
. good.. Safety
[na] ・
of
How of chip to improve seat cushion [to] Comfortable
theory
Only getting on of eight people equipment
How and
to attention
associate
. drinking..
car
Maintenance
One[Notoki]
The chip improvement lever is pulled, and the cushion is lifted. It is confirmed
to shake the cushion lightly after it lifts and to be fixed surely.
Index
231
Adjustment of third seat
Reclining lever
The back moves the drip back and forth along can by the back while pulling the reclining lever
forward and adjusts the hand to the drip.
It is confirmed also for the back to shake the drip lightly after it adjusts it and to be fixed surely.
Switch
232
Adjustment of seat
Contents
Please note the following respect when you adjust the third
seat. Warning
- Please the back also must operate the hand in the drip when the back also returns the drip and operate the reclining
lever along can. When the back doesn't suppress the drip and either the lever is operated, the back returns suddenly the
drip, and might be injured, too. -
Please note that the back doesn't hit the drip to the backing door either when you adjust . earliness.. Basic
operation
reclining. The backing door etc. might be damaged. [wakari]
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
233
Method of headrest adjustment
- Right and left seat
Button
- Central seat *
Button
234 - As for the sign, the presence of the installation is different depending on the grade etc.
Adjustment of seat
Contents
Knowledge Handling
Driving
A top and bottom of the headrest of the third seat positioning becomes only two stages where the improved
time and it depresses it. Please use the headrest while improved.
The
Handling indoor
equipment
How and
to attention
associate
. drinking..
car
It is possible to use it as an armrest by the back of a central seat hanging down, too and pulling the part forward. Maintenance
Myriad
One[Notoki]
Index
- As for the sign, the presence of the installation is different depending on the grade etc. 235
Seat arrangement
I n d e x
236
Seat arrangement
Contents
Driving
Handling
device
The
Handling indoor
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
237
257 of the maximum load room modes ..how . . . to make it..
238
Seat arrangement
Contents
Driving
Handling
device
The
Handling indoor
equipment
- State of reception desk seat [sekandoshi-tofuratto] and state of third seat storage
. good.. Safety
Getting on of seven people Getting on of eight people [na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
239
Before arranging the seat
Park the vehicle to a safe, smooth place, and the gear-shift[**][Ni] putting and parking
The brake is surely applied.
240
Seat arrangement
Warning
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
The
Space can be made in the center part of the vehicle by improving the cushion
Handling indoor
of [sekandoshi-to] in the chip, and doing the slide back and forth. equipment
When you make space in the center part of the vehicle . good.. Safety
[na] ・
of
1 The seat belt is stored. [to] Comfortable
theory
equipment
Two point in central seat expression seat belt
installation car stores the seat belt in the storage pocket. How and
(Refer to P.277. ) to attention
associate
. drinking..
car
One[Notoki]
Reclining lever
Index
241
3 The seat cushion is lifted.
The chip improvement lever is pulled, and
the cushion is lifted.
Please do not run taking the person in space in the center part of the vehicle made from the
seat arrangement. The important injury related to the life might be received when time
that slammed on the brakes and colliding and it is dangerous.
Foundation part
242
Seat arrangement
. earliness.. Basic
operation
[wakari]
Driving
Handling
The third seat can be stored in the luggage room by hand power. Moreover, device
1
Handling indoor
The backing door is opened. equipment
Please open the backing door without fail, and go from the rear
side of the vehicle in the operation of the seat.
. good.. Safety
[na] ・
2 The deck hook is stored. (Refer to
of
[to] Comfortable
theory
P.492. ) equipment
How and
to attention
243
6 The armrest is returned.
The central arm Wrest installation car
returns the armrest. (Refer to P.235. )
Steering wheel A
244
Seat arrangement
Contents
The
Handling indoor
equipment
5 The deck board is installed.
(Refer to P.495. )
. good.. Safety
[na] ・
Before it returns it of
[to] Comfortable
theory
Please open the backing door without fail, and go from the rear How and
to attention
side of the vehicle in the operation of the seat.
associate
P.495. )
245
When you return it
Steering wheel B
1 The entire seat is improved while pulling
steering wheel B.
Once, it stops it at the position in which the rear end of
the seat hits the rear end of the seat storage part.
Steering wheel A
4 The deck board is installed.
(Refer to P.495. )
Please do not depress the seat according to procedure 2 when it returns it based on the
seat while being pushing the seat out forward. When the seat is depressed on the way, the
floor face might be damaged by the leg of the seat. Please depress it after
confirming the seat returned to former position when you lock the seat.
246
Seat arrangement
Contents
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
The
The third seat can be stored by the automatic operation in the luggage room. Moreover, Handling indoor
equipment
it is possible to use it by putting it into the state of the table.
Maintenance
[Chakusuwa] switch
247
Before operating the electric storage seat
1 The gear-shift when the power supply is turned
off or is turned on[**][Nishimasu].
If it doesn't meet this requirement, the seat doesn't
do the storage operation.
(The case where it returns it with the reclining
switch based on the table is excluded. )
Belt suspender
2 The backing door is opened.
Please open the backing door without fail, and go from the rear
side of the vehicle in the operation of the seat.
248
Seat arrangement
Contents
device
The
Handling indoor
equipment
. good.. Safety
Knowledge [na] ・
of
[to] Comfortable
About electric storage of the third seat theory
equipment
- The storage operation is interrupted when the following are when the storage of the third seat is operating, the operation pilot
light lights, and the buzzer informs you that the ringing storage operation was interrupted for about ten seconds. (In the
How and
multi information display installation car, it is displayed at the same time that the buzzer to attention
rings on the multi information display with "3rd SEAT". )
associate
[**]The hand is separated from the storage switch. . drinking..
car
[**]Side where storage operation is doneThe table switch or the reclining switch is pushed.
[**]The gear-shift when the power supply is turned on[**][Kara][**]It makes it.
When the above-mentioned interruption condition is canceled, and operation is restarted, the operation pilot light is turned off. -
The operation pilot light blinks, the buzzer is interrupted when the movement of the seat is forcibly stopped while the storage of the third
seat is operating or the seat breaks down, and the ringing storage operation is interrupted for about ten seconds. (In the multi information Maintenance
display installation car, it is displayed at the same time that the buzzer rings on
the multi information display with "3rd SEAT". )When operation is restarted, the operation pilot light
is turned off.
Myriad
One[Notoki]
Index
249
When you return it
Belt suspender
[Chakusuwa] switch
2 It keeps pushing the [chakusuwa] switch on the
operated side.
The buzzer rings two times, and the entire seat
begins to return forward. -
Not turned off the power supply
or the gear-shift [**][Nishiteinaito]
We will inform you that we blink while being
pushing the coming [ha] and switch the operation pilot
light, and cannot operate the return.
3 The seat is fixed to the floor face and the drip begins
to return backward in the back.
The buzzer rings two times, and the drip begins to
return in the back. -
Even if the back also separates the hand from
the [chakusuwa] switch after the drip begins to return,
operation is continued.
250
Seat arrangement
Contents
Knowledge
Warning
About an electric return of the third seat
- The return operation is interrupted when the following are when the return of the third seat is operating, the operation pilot
light lights, and the buzzer informs you that the ringing return operation was interrupted for about ten seconds. (In the
multi information display installation car, it is displayed at the same time that the buzzer . earliness.. Basic
rings on the multi information display with "3rd SEAT". ) operation
[wakari]
[**]The hand is separated from the [chakusuwa] switch (Even if the back also separates the hand from the switch after the drip
begins to return backward, operation is not interrupted).
[**]Side where return operation is doneThe table switch or the reclining switch is pushed.
[**]The gear-shift when the engine switch is turned on [**][Kara][**]It makes it.
Driving
When the above-mentioned interruption condition is canceled, and operation is restarted, the operation pilot light is turned off. - Handling
The operation pilot light blinks, the buzzer is interrupted when the movement of the seat is forcibly stopped while the return of the third device
seat is operating or the seat breaks down, and the ringing return operation is interrupted for about ten seconds. (In the multi information
display installation car, it is displayed at the same time that the buzzer rings on
the multi information display with "3rd SEAT". )When operation is restarted, the operation pilot light The
is turned off.
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
251
When making it to the table by the automatic operation
Table switch
2 When the table switch on the side made a table
is pushed, the drip is moved up as for the back.
252
Seat arrangement
Contents
2
Table switch
The table switch or the reclining
switch on the returned side The drip Driving
Handling
returns in the back when (Refer to P.247)
device
is pushed.
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
3 Operation ends as for the back if the drip returns How and
to attention
to the position like the right angle.
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
253
Knowledge
About the table operation and the return operation of the third seat
- The table operation and the return operation are interrupted when other third seat switches are pushed when the third seat
is operated the table and the return is operating, the operation pilot light lights, and the buzzer informs you that the ringing
table operation and the return operation were interrupted for about ten seconds.
When the table operation and the return operation are restarted, the operation pilot light is turned off. -
The operation pilot light blinks, the buzzer is interrupted when the movement of the seat is forcibly stopped while the third seat is
operated the table and the return is operating or the seat breaks down, and the ringing table operation and the return operation are interrupted
for about ten seconds. When operation is restarted, the operation pilot light is turned off.
254
Seat arrangement
Contents
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
Please do not store the seat with luggage etc. put to attention
on the seat cushion. associate
. drinking..
- Please do not store the seat with luggage etc. put on the seat cushion. When car
luggage is stored while put, the seat might be damaged. -
Please confirm there is no thing in the seat storage part when you store the seat. When the seat
is stored with there a thing, the seat might be damaged. -
Please confirm there is no thing on the floor face when you return the seat. The seat fixation part etc. Maintenance
might be damaged when returning it based on the seat with there a thing. -
Because the spare tire is installed in the third seat storage, the person who installed
the spare tire of the shop installation option with 4WD car cannot store the third seat. When
the third seat is forcibly stored, the third seat might be damaged. Myriad
One[Notoki]
Index
255
Knowledge
About the storage of the third seat of the car with the wheelchair fixation belt
Please the following preparation must not be done before storing the third seat, the wheelchair fixation belt must not place
between the third seat, and do not crowd. -
The wheelchair fixation belt on the luggage room side hangs the hook on the ring in the root of
the belt. -
The back hangs down, too and the length of the belt on the this side side and the interior side is adjusted to the same, the back is pasted to
the drip with Velcro repeatedly, and it puts on the wheelchair fixation belt on the side.
Velcro
Ring
Hook
256
Seat arrangement
. earliness.. Basic
operation
[wakari]
Driving
The load room can be widened to its maximum by the combination of [sekandoshi-to] Handling
and the third seat. device
1 The long slide console installation car does the long slide console
in the slide forward.
. good.. Safety
Refer to P.488. [na] ・
of
[to] Comfortable
associate
3
. drinking..
car
The third seat is stored.
Refer to P.243.
Maintenance
Myriad
One[Notoki]
Index
257
Getting on of eight people
1 The cushion of [sekandoshi-to] is improved in the chip and space is made in the center
part of the vehicle.
Refer to P.241.
Please do not run taking the person in the luggage space. The
important injury related to the life when time that slammed on the
brakes and colliding might be received and it is dangerous.
- Please do not run taking the person in the luggage space. The important injury related to the life
might be received when time that slammed on the brakes and colliding and it is dangerous. -
The seat belt must confirm the back doesn't narrow in the drip either. The important injury that
the seat belt is not demonstrated the effect with an enough seat belt when colliding when the back narrows in the
drip and the seat cushion, too, and related to the life might be received and it is dangerous. -
Please confirm the light shake of the seat, the lift of the seat cushion in addition,
and fixation surely when you return it based on the seat. Important injury that moves while running
if not fixed the seat, causes an unexpected accident, and is related to the life might be received and it
is dangerous. -
Please do not do the operation that makes the luggage space while running, and returns it. The
important injury related to the life might be received when it applied the brakes and when it collides and
it is dangerous.
Please do not pave the mat etc. on the seat rail. When the seat
is moved, the rubber part in the seat rail might be damaged.
258
Seat arrangement
Warning
. earliness.. Basic
operation
[wakari]
Driving
Handling
Myriad
One[Notoki]
Index
259
4 The slide stopper is removed.
The slide stopper (2) is removed
from the seat rail behind
[sekandoshi-to].
Slide stopper
6 [Ottoman] is caused.
Refer to P.230.
260
Seat arrangement
Contents
Please obtain the insertion of the tab of the slide stopper for the hole
(three places) in the seat rail when you install the slide stopper.
Slide stopper . earliness.. Basic
operation
[wakari]
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
Knowledge [to] Comfortable
theory
equipment
About the slide stopper
- Please keep the removed slide stopper importantly so as not to lose. We will recommend How and
to attention
putting it in the tool bag. (Please see P.622 about the tool bag. )-
The arrow is displayed in the knob of the slide stopper. The arrow is an arrow that associate
. drinking..
becomes a standard when the slide stopper is installed when the floor mat of the shop installation car
option is installed. Please install the arrow of the knob of the slide stopper on the arrow displayed
in the floor mat of the shop installation option and install the slide stopper additionally.
Maintenance
Floor mat side arrow
Knob
Myriad
One[Notoki]
Index
261
How to make flat seat mode
- State of reception desk seat [sekandoshi-tofuratto] and state of third seat storage
262
Seat arrangement
Contents
1 The long slide console installation car stores the long slide console with seven
person getting on car and the table is stored in the central table installation . earliness.. Basic
operation
car that does the slide forward (Refer to P.488). (Refer to P.476. ) [wakari]
Refer to P.222.
device
3 In seven person getting on car, the side position of [sekandoshi-to] is done in the slide at the The
center. Handling indoor
equipment
Refer to P.222.
5 The back of [sekandoshi-to] also knocks down the drip to the full rear side. How and
to attention
Refer to P.223. associate
. drinking..
car
6 The back of the third seat also knocks down the drip to the full rear side.
Maintenance
Refer to P.232.
- Please lower the headrest of the third seat to the under.
Back [motare] is hit in [ushiro] if it doesn't lower and when reclining
is done, the headrest hits the backing door. Myriad
One[Notoki]
Index
263
- State of reception desk seat [sekandoshi-tofuratto] and state of third seat storage
4 The back of the reception desk seat also knocks down the drip to the full rear side.
Refer to P.216.
5 The long slide console installation car stores the long slide console with seven
person getting on car and the table is stored in the central table installation
car that does the slide forward (Refer to P.488). (Refer to P.476. )
6 The side position of [sekandoshi-to] is done in the slide at the center in seven person getting
on car.
Refer to P.222.
7 The seat cushion of [sekandoshi-to] moves it to the position in which the back of the
reception desk seat also hits the drip. (Refer to P.222. )
The cushion of [sekandoshi-to] and the back of the reception desk seat also adjust
the reclining position of the reception desk seat so that the drip may become flat.
8 The back of [sekandoshi-to] also knocks down the drip to the full rear side.
Refer to P.223.
264
Seat arrangement
Contents
Knowledge
About the side lift up seat installation car
Maintenance
The side lift up seat cannot be made flat.
Myriad
One[Notoki]
Index
265
Wearing of seat belt
Correct wearing of seat belt
The seat belt might reduce the effect by half, and be dangerous if it doesn't correctly
wear it. Please those who drive must wear without fail according to the following use before it runs, and let
me wear it to those who multiply this.
The back also must adjust the drip, set up the upper
Shoulder department belt part of the body, sit deeply, and sit.
Put it enough on the shoulder. (Do not hang
to the neck, and shift from the shoulder. )
Do not twist.
Waist belt
The hipbone must make them stick to
a low position as much as possible.
266
Wearing of seat belt
Contents
Maintenance
Myriad
One[Notoki]
Index
267
Please wear the seat belt. Moreover, please
guard the following when you wear it.
- The seat belt hits the neck and the jaw, and the child seat junior seat is used
for a small child who doesn't hang to the hipbone. Strong pressure is received when colliding
when not using it, and it reaches important injury or, in the worst case, it is likely to lead to the
death. Moreover, a small child of one sitting who cannot do must use the baby seat.
Please consult the Toyota shop about the seat only for the child.
Standard of selection of seat only for child (For a Toyota pure goods).
Child seat baby seat fixed with bar The above-mentioned is excluded.
& [topputeza-anka-] only for child
seat fixation of this car Weight Height Reference age
Baby Less 105 Newborn baby
Weight Height Reference age seat than 10kg ..75cm Nine months of
Baby ..less ..less Nine months Child 9. or -12 months- four
seat than 9kg.. than of newborn baby - seat 18kg less.. 75- years old
Child nine-18 70cm.. 70-100 nine months- Four junior 15. cm 100- four years old-
seat .... kg .... cm years old seat 32kg 135cm Ten years old
- The foreign body must not enter the buckle of the seat belt. In the worst case, the effect
with an enough seat belt is not demonstrated when the plate might not completely fit in the buckle when the
foreign body enters, and it collides, it reaches important injury or, it is likely to lead to the death. -
Please it becomes loose, it is possible to be worn out, and exchange the seat belt that doesn't operate normally
at once for the new article of pure Toyota. Moreover, please receive the high impact due to the accident, and exchange the
seat belt that attaches the wound at once without using it for the new article. In the worst case, it doesn't work
normally when colliding when using it as it is, the effect with an enough seat belt is not demonstrated, it reaches
important injury or, it is likely to lead to the death. -
Please remodel, resolve or neither installation nor detach the seat belt. The effect with
an enough seat belt is not demonstrated when colliding, and it reaches important injury or, in the worst
case, it is likely to lead to the death. Please consult the Toyota shop about the installation,
detaching, and the exchange of seat belts. -
Please do not use organic solvents such as benzine and gasoline to clean the seat belt. Moreover,
please do not bleach, and do not dye the belt. Important injury that doesn't demonstrate the effect
with an enough seat belt when the performance of the seat belt falls, and it collides, and is related to the life might
be received and it is dangerous. Please do not use the seat belt until drying by using the soapless soap
or lukewarm water when you clean it.
268
Wearing of seat belt
associate
. drinking..
Buckle car
One[Notoki]
Index
269
4 The shoulder department belt is worn.
The shoulder department belt makes it hang enough to the
shoulder without fail.
At this time, the belt doesn't hit the
neck, and it doesn't shift from the shoulder.
Button
270
Wearing of seat belt
Contents
Please guard the following when you adjust the seat belt anchorage. The
effect with an enough seat belt is not demonstrated when colliding if it doesn't defend, and Warning
it reaches important injury or, in the worst case, it is likely to lead to the death. -
Please adjust it at the position where it is high only for the seat belt to finish not hitting
the neck and to take enough to the center of the shoulder. -
Please confirm fixation surely after it adjusts it. . earliness.. Basic
operation
[wakari]
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
271
How to detach expression seat belt of length adjustment type two points
[Sekandoshi-to] central seat of side air bag non-installation car
Third seat central seat of side air bag non-installation car
Plate * Buckle
Button
272
Wearing of seat belt
Contents
- Method of detaching
Plate A
2 Plate A is inserted in buckle A until
The
Handling indoor
"[Kachi]" and the sound are heard. equipment
. good.. Safety
[na] ・
Buckle A of
[to] Comfortable
theory
equipment
How and
to attention
Plate B 3 Plate B is inserted in buckle B until associate
. drinking..
"[Kachi]" and the sound are heard. car
Maintenance
Buckle B
Myriad
One[Notoki]
Index
273
4 The waist belt is made to stick.
The waist belt makes the hipbone hang to a low position
as much as possible without fail, pulls the shoulder
department belt, and makes them stick to the waist.
Shoulder department belt
Waist belt
Button
Buckle B
274
Wearing of seat belt
Contents
Driving
Handling
Buckle A
Button device
Mechanical key
2
The
Hole part A It winds up up the seat belt, and the plate Handling indoor
equipment
Hole part B is inserted and it stores it.
The tip of plate A is stored after the tip
of plate B is inserted in hole part B of the
. good.. Safety
holder and the insertion plate is stored in [na] ・
hole part A of the holder. of
[to] Comfortable
theory
equipment
associate
Plate A . drinking..
car
Maintenance
Myriad
One[Notoki]
Index
275
Please store the seat belt apart when you store
the third seat.
- Please store the seat belt apart when you store the third seat. The effect with an
enough seat belt is not demonstrated when the seat belt is placed the back between the drip etc. , might be damaged, and
uses it when the storage operation of the third seat is done without doing the separation storage with damaged, and
it reaches important injury or, in the worst case, it is likely to lead to the death. -
Please unite plate A and buckle A when you use
the separation storage type seat belt. The effect Plate A
with an enough seat belt is not demonstrated when using it while not
united, and it reaches important injury or, in the worst case, it
is likely to lead to the death. Buckle A
Knowledge
About uniting [sekandoshi-to]/third seat central seat seat belt
The seat belt for a central seat must unite with the one that there is a stamp of "CENTER" in the
buckle. It is not possible to unite with the belt for a right and left seat.
-1
Stamp of "CENTER" -2
(buckle side)
- 1 The shape of the plate is different according to the [sekandoshi-to] third seat and the seat belt two-expression three point point
expression seat belt. -
2 In two point expression seat belt, there is a stamp of "CENTER" also on the plate side. (It is not in three point
expression. )
276
Wearing of seat belt
Storage of [sekandoshi-toberuto]
Getting on of eight people (two point in central seat expression seat belt installation car) Warning
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
The
Buckle for central seat
Handling indoor
Buckle for left seat equipment
Getting on of eight people (three point in central seat expression seat belt installation car) . good.. Safety
[na] ・
of
Buckle for right seat It stores it as shown in a left chart. [to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
One[Notoki]
Index
277
Storage of third seat belt
Central seat separation storage type seat belt installation car
Separation storage type seat belt
It stores it as shown in a left chart. -
Please refer to "How to use of the separation
storage type seat belt" of P.273 for the separation
and how to store the central seat separation
storage type seat belt.
278
Wearing of seat belt
Contents
The central seat separation storage type seat belt installation car is excluded.
It stores it as shown in the figure below. Warning
- Manual storage type third seat - Electric storage type third seat
Buckle for right seat
Buckle for right seat
Seat belt for central seat . earliness.. Basic
Seat belt for central seat
operation
[wakari]
Driving
Handling
device
Maintenance
Plate
Myriad
One[Notoki]
Index
279
Fixation of child seat
Fixation with bar & [topputeza-anka-] only for child seat fixation for ISOFIX
[Sekandoshi-to] right and left seat (The side lift up seat is excluded).
The bar only for the child seat fixation for ISO *FIX In &
[topputeza-anka-], bar only for the child seat fixation for ISO FIX Only
the child seat baby seat for & [topputeza-anka-] can be installed.
- It means "International Organization for Standardization" by abbreviating International Organization for Standardization.
Tag
Tag
Bar only for fixation
There are a seat cushion and a back for the drip, too. -
..tag (.. surface where bar only for fixation shows equipment 「 L A T C H 」 ・The back
「ISOFIX」 ) is seated to the seat.
280
Wearing of seat belt
Contents
Mark Mark
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
[Topputeza-anka-]
[Topputeza-anka-] The
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
281
When you install it
1 The lengthwise position of [sekandoshi-to] is adjusted most to [ushiro].
Refer to P.222.
2 The headrest of [sekandoshi-to] is improved to the place where "[Kachi]" and the
sound are heard. (Refer to P.225. )
Please confirm the headrest is fixed. 。
Central pillar
3 Please the lengthwise position and adjust reclining
of the seat so that the front side of the
Part A headrest of the reception desk seat may become before
the front side (part A) of central pillar.
Reception desk seat
Refer to P.216.
Central pillar
4 The position of the bar only for fixation and [topputeza-anka-] is confirmed.
Refer to P.280,281.
282
Fixation of child seat
Contents
5 The seat (child seat and baby seat) only for the child is installed
Warning
in [sekandoshi-to].
The installation metal fittings of the seat only for the suited child are installed in the bar only
for fixation. Next, [teza-beruto] is installed in [topputeza-anka-].
*Please read the manual of the attachment each commodity the installation method and how . earliness.. Basic
to detach it. operation
[wakari]
- Please install it after the back of the seat also adjusts the angle of the
drip for the back of the seat to do the space between seats only for the drip, the
seat cushion, and the child. -
Driving
It passes between headrests as shown in the figure below so that [teza-beruto] Handling
should not twist, and [teza-fukku] is multiplied by vehicle side [topputeza-anka-]. - device
Part A is strongly pulled until [teza-beruto] picks up the slack, and the seat
only for the child is fixed.
The
Child of less than 9kg(For Child of 9kg-18kg (four-years Handling indoor
newborn baby - about nine months). old of nine months- time) equipment
[Topputeza-anka-] [Topputeza-anka-]
[Teza-fukku] [Teza-fukku]
[Teza-beruto]
[Teza-beruto]
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
[Teza-beruto]
[Teza-beruto] Maintenance
Part A Myriad
Part A
One[Notoki]
- The illustration is the one for the explanation, and it is different from the shape of the seat only for an actual child. Index
283
6 It is confirmed to be fixed surely.
It is confirmed to shake the seat only for the child who installed it lightly,
and to be installed surely.
- Please pass [teza-beruto] under the headrest. The serious trouble related to the
life when the seat only for the child is not firmly fixed when putting it on the headrest, and it collides
might be received and it is dangerous.
284
Wearing of seat belt
Contents
Please store in the luggage room or remove from the vehicle and keep it when you do not
use the seat only for the child for a long term. The seat might discolor, and the Warning
type collapse when it is left to install it in the seat.
Knowledge
. earliness.. Basic
operation
About bar & [topputeza-anka-] only for the child seat fixation for ISO FIX [wakari]
Only the seat (Toyota pure child seat baby seat for bar & [topputeza-anka-] only for the child
seat fixation for ISOFIX) only for the child who suits the security standard of the road
transportation vehicle of the [esutei;ma] specification can be installed in bar & [topputeza-anka-] only
for the child seat fixation for this ISOFIX. Please consult the Toyota shop in detail. Driving
Handling
device
About the side lift up seat installation car
In the side lift up seat, there are neither a bar only for fixation nor [topputeza-anka-]. Please The
fix with the child seat fixation mechanism addition seat belt. (Refer to next page. )
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
285
Fixation with seat belt
- The illustration is the one for the explanation, and it is different from the shape of the seat only for an actual child.
286
Fixation of child seat
Contents
. earliness.. Basic
operation
Release of child seat fixation mechanism [wakari]
When it unbuckles, and it winds up up the belt fully, the child seat
fixation mechanism is released.
Driving
Handling
Please often read the manual of the attachment and obtain the
device
installation of the seat only for the child for the commodity correctly.
- In the worst case, it reaches important injury by flying when time that slammed on the
brakes and colliding if not correctly installed or, it is likely to lead to the death. - The
It might cause an unexpected accident by hitting the crew and the one, etc. when having applied the Handling indoor
equipment
brakes when indoors leaving it with the seat only for the child detached and is dangerous. -
Please do not let the child play with the child seat fixation mechanism addition seat belt. It becomes
impossible to draw out the belt when it operates the child's playing with the seat belt and by mistake, and the belt
coils around the neck by any chance and it reaches important injury like suffocation etc. or, in the worst case, it . good.. Safety
[na] ・
is likely to lead to the death. Please cut the seat belt with scissors etc. when it enters such a of
state by any chance by mistake, and the buckle cannot be removed. [to] Comfortable
theory
equipment
How and
to attention
Please store in the luggage room or remove from the vehicle and keep it when you do not
use the seat only for the child for a long term. The seat might discolor, and the associate
. drinking..
type collapse when it is left to install it in the seat. car
Maintenance
Myriad
One[Notoki]
Index
287
Knowledge
About the seat belt with the child seat fixation mechanism
- The seat belt with the child seat fixation mechanism is built into the seat belt of
[sekandoshi-to]. When the child seat baby seat is installed, it is convenient because the belt can be
prevented from moving in the direction of drawing out. -
The child seat fixation mechanism might operate when big movement of the upper part of the
body is done with the seat belt worn. In that case, please wear the seat belt again after
releasing the child seat fixation mechanism of unbuckling once, and winding up up the
belt fully.
Please fix the seat only for the child who suits the security standard of the road transportation
vehicle with bar & [topputeza-anka-] only for the child seat fixation in fixation by bar
& [topputeza-anka-] only for the child seat fixation of this car, and give to me in the seat
belt of this car in the melting pot.
(Please refer to "Fixation with bar & [topputeza-anka-] only for
fixation" of P.280 for bar & [topputeza-anka-] only for the child
seat fixation. )
288
Fixation of child seat
Contents
Warning
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
289
Adjustment of steering wheel mirror
Adjustment of steering wheel
Lever
When it presses a lever down, the steering wheel is moved up and down and back and forth, it makes to an appropriate
position, and the lever is improved, it is fixed.
- Please do not adjust the handle position while running. It mistakes driving while adjusting it, might cause
an unexpected accident, and is dangerous. -
Please confirm fixation surely after adjusting the handle position. It divides
as the position of the steering wheel is sudden if fixation is insufficient, might cause an unexpected accident, and is dangerous.
Knowledge
About the operation sound of the power steering
When the steering wheel control is done, it is likely to hear of the sound "Vienna". This is not
abnormal because of the sound when the power steering operates.
290
Adjustment of steering wheel mirror
. earliness.. Basic
operation
[wakari]
Driving
Handling
It vertically adjusts it with the main body of the inner mirror.
device
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
Lever
How and
to attention
It uses it with the lever under the mirror pushed forward usually. associate
. drinking..
When the headlamp of the following car is dazzled, the lever is pulled forward. car
Please do not adjust the inner mirror while running. It mistakes driving,
might cause an unexpected accident, and is dangerous. Maintenance
Myriad
One[Notoki]
Index
291
Adjustment of door mirror
Method of storage
Storage switch
State of switch State of mirror
ON
(storage)
OFF
(return)
It changes into turning on (storage) and turning off (return) whenever the storage switch is
pushed. When the power supply is turned off, can it store and it be returned with the hand.
292
Adjustment of steering wheel mirror
Contents
Please do not touch it when the door mirror moves. The hand
Driving
is placed, and might it injure, and it cause the breakdown of the door mirror etc. Handling
device
Knowledge
The
About the operation condition Handling indoor
equipment
- When the power supply is ACC or is turned on, it is possible to use it. -
The storage operation stops when the power supply is turned off while the door mirror storage is operating. -
In the following cases, the mirror returns to the state of the storage switch even if the door mirror is stored and returned
with the hand. . good.. Safety
[na] ・
[**]When you make the power supply ACC or turn on after it operates it by hand power. - of
When the storage switch knocks it down forward on the hand while turned off (return) the door mirror, the [to] Comfortable
theory
mirror doesn't return even of ACC or turning on the power supply. Please turn off the storage switch again equipment
once after making the storage switch turn on (storage) and return it.
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
293
How to use of the mirror heater.
Cold-weather model car
Operation pilot light
Switch
The surface of the door mirror doesn't become hot while operating, and do not touch it, please.
The burn might be done and it is dangerous.
It causes the battery rising when continuously using it for a long time.
Knowledge
About the mirror heater
- The specular of the door mirror is warmed, and frost, dew, and the drop, etc. are removed. -
[Riyauindou;defogga-] (Refer to P.369) operates simultaneously with the mirror heater.
294
Adjustment of steering wheel mirror
Door mirror
Warning
. earliness.. Basic
operation
[wakari]
Driving
Supplementary confirmation device Handling
device
The supplementary confirmation device is under the passenger's seat side door mirror.
Please wipe off when dirt adheres to the supplementary confirmation
The
device.
Handling indoor
- Please wipe dirt off by using a soft cloth etc. when dirt etc. adhere to the specular part of the equipment
supplementary confirmation device. It is likely to become an obstruction of view if leaving just
as it is. -
Please immediately before the vehicle and confirm directly or do the left part and the confirmation of the rear side enough soon using . good.. Safety
the door mirror etc. together with the inner mirror. [na] ・
of
[to] Comfortable
theory
Knowledge equipment
Maintenance
Myriad
One[Notoki]
- The range that can be confirmed is different according to the height and the seat position.
Index
295
How to use of the gear-shift.
How to use of the gear-shift of Super CVT i installation car.
2.4L car
Working of gear-shift
Retreat
R The gear is fixed to the retreat.
The buzzer rings. [**]It informs those
(reverse) who drive of [niarukoto].
296
How to use of the gear-shift.
Contents
Handling of gear-shift
- Operation of gear-shift Warning
[**]と [**]The operation of ..drinking.. [kan] is [fu] as for the brake pedal.
Please go after completely stopping the car of seeing.
. earliness.. Basic
operation
With stepping on the brake pedal、Change [wakari]
P P
The lever is moved along the gate.
R R
The gear-shift along the gate [Sonoma]
Driving
N N [Ma]It moves it. Handling
D M D M device
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
297
How to use of doing sports the sequential shift mode.
- How to doing sports sequential shift mode to switch
Shift position
pilot light
[Supo-tsushi-kensharushifutomachikku]
pilot light
The gear-shift [**]It becomes [nisuruto] and doing sports a sequential shift mode.
The changing the speed steps can be switched by + side or operating the
gear-shift on the side. -
The [supo-tsushi-kensharushifutomachikku] pilot light lights when changing
to doing sports the sequential shift mode. (Refer to P.322. )-
The gear-shift [**][Nisuruto] and doing sports the sequential shift mode are made
clear, and it returns to a usual control.
Shift up
When the shift improvement is done, the
gear-shift is moved to + side.
When the down of the shift is done, the gear-shift
is moved to the side. -
It changes the speed by one step whenever the
gear-shift is operated.
Shift down
- The changing the speed steps that have been selected between
1-7 are displayed in the shift position pilot light.
(Refer to P.322. )
298
How to use of the gear-shift.
Contents
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
The
Handling indoor
The changing the speed steps are fixed to one. equipment
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
299
Knowledge
About the warning buzzer
There is a limitation in the shifting operation to secure the driving performance for safety, and it is likely not to
be shifted to hoped the changing the speed steps. The warning buzzer rings when the down of the shift by the shifting
operation is not done.
300
How to use of the gear-shift.
Contents
Warning
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
301
How to use of the gear-shift of the Super ECT installation car.
3.5L car
Working of gear-shift
Retreat
R The gear is fixed to the retreat.
The buzzer rings. [**]It informs those
(reverse) who drive of [niarukoto].
302
How to use of the gear-shift.
Contents
Handling of gear-shift
- Operation of gear-shift Warning
[**]と [**]The operation of ..drinking.. [kan] is [fu] as for the brake pedal.
Please go after completely stopping the car of seeing.
. earliness.. Basic
operation
With stepping on the brake pedal、Change [wakari]
P P The lever is moved along the gate.
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
303
How to use of the sequential shift mode.
- How to sequential shift mode to switch
Shift position
pilot light
Sequentially
[Shifutomachikku] pilot light
The gear-shift [**]It becomes [nisuruto] and a sequential shift mode, and it is Chen.
The shift cooking stove can be switched by + side or operating
[jireba-] on the side. -
The [shi-kensharushifutomachikku] pilot light lights when changing to the
sequential shift mode. (Refer to P.322. )-
The gear-shift [**][Nisuruto] and the sequential shift mode are made clear, and
it returns to a usual control.
Shift up
When the shift improvement is done, the
gear-shift is moved to + side.
When the down of the shift is done, the gear-shift
is moved to the side. -
It changes the speed by one step whenever the
gear-shift is operated.
Shift down
304
How to use of the gear-shift.
Contents
It divides into the gear from 1 velocity to 6 velocities automatic according to the speed and the
running condition.
. earliness.. Basic
operation
[wakari]
It divides into the gear from 1 velocity to 5 velocities automatic according to the speed and the
running condition.
Driving
Handling
It divides from one velocity into the gear of four-speed automatic according to the speed and the device
running condition.
The
It divides into the gear from 1 velocity to 3 velocities automatic according to the speed and the
Handling indoor
running condition. - equipment
A light engine brake is obtained in the downward slope. -
A smooth running that the changing the speed frequency is a little can be done in the acclivity.
. good.. Safety
It divides into the gear at one velocity or two velocities automatic according to the speed and [na] ・
the running condition. - of
[to] Comfortable
When the engine brake is necessary, it uses it. theory
equipment
How and
The gear is fixed at one velocity. - to attention
When a strong engine brake is necessary, it uses it. associate
. drinking..
car
Knowledge
The gear-shift [**][Kara][**]About the shift position display of ..decrease.. [kiri] when it substitutes it Maintenance
According to the velocity of the carShinto flute、 O r , [**]However, it is displayed.
However, [**]When you run below [de] four-speed [**][Nisuru] and the shift cooking stove at that time display it.
[Remasu].
Myriad
One[Notoki]
Index
305
Knowledge
About the warning buzzer
There is a limitation in the shifting operation to secure the driving performance for safety, and it is likely not to
be shifted to hoped the changing the speed steps. The warning buzzer rings when the down of the shift by the shifting
operation is not done.
306
How to use of the gear-shift.
Contents
Warning
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate . drinking..
car
Maintenance
Myriad
One[Notoki]
Index
307
How to drive automatic car
Method of start
Brake pedal
Parking
Brake pedal
2 The parking brake is released with the
left leg.
Refer to P.314.
Brake pedal
3 It slowly steps on the gas pedal by the right
leg after the brake pedal is gradually loosened
and it starts.
Gas pedal
308
How to drive automatic car
Contents
3 The parking brake is released with the left leg after the feeling where the car begins to move Driving
Handling
is confirmed, and it starts.
device
The
Please operate the gear-shift with stepping on the Handling indoor
brake pedal firmly. equipment
- Please operate the gear-shift when you start with stepping on the brake pedal
firmly. Especially, please step on more unfaltering and the brake pedal so that the creep phenomenon may strengthen
when immediately after the engine start and the air conditioner operates. - . good.. Safety
[na] ・
It is not necessary to make a mistake in stepping confirming the position of the brake pedal and the gas of
pedal without fail when you drive. The car starts rapidly when the gas pedal is mistaken for the brake pedal and [to] Comfortable
theory
it steps, it causes an unexpected accident, and it reaches important injury or, in the worst case, it is likely to equipment
lead to the death. -
Please never do the gear-shift operation by having depressed the gas pedal. How and
to attention
It starts rapidly by the car, might cause an unexpected accident, and is dangerous.
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
309
Method of running
Usual running
The gear-shift [**]It runs with [ni] put. -
It accelerates and it decelerates only by operating the accelerator and the brake.
To accelerate rapidly
The gas pedal is fully depressed. It ..kicking down doing.. accelerates rapidly.
- Downward slope
Working of the brake might worsen when the service brake is used too
much.
The gear-shift [**]When the speed goes out too much by [nomama]
2.4L car
The gear-shift [**]The engine brake is used together in the changing the speed steps corresponding to [nishite] and the slope.
It does.
3.5L car
The gear-shift [**]It runs [nishite], three velocities, two velocities or one velocity.
- A light engine brake is obtained by making the gear-shift
four-speed.
310
How to drive automatic car
Contents
The
The gear-shift [**]It might cause the breakdown of the transmission Handling indoor
equipment
when running to [nishitama].
. good.. Safety
Knowledge [na] ・
of
[to] Comfortable
About the engine brake of the radar cruise control cruise control installation car theory
equipment
The gear-shift in 3.5L car when you use the radar cruise control
cruise control [**]・ [**]、In 2.4L car [**]・ [**]The [nishitemo] cruise control releases it. How and
The engine brake doesn't work because no [re]. It steps on the setting speed with the cruise to attention
control switch when the deceleration is necessary and it steps on frog (P.398,413) or the brake pedal. associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
311
Method of stop and parking
Method of stop
1 It pulls up a car. The gear-shift [**]The brake pedal by [nomama] and the right leg
It steps firmly.
The air conditioner operates intermittently by the temperature change. The idol improves
automatically, the creep phenomenon strengthens while operating, and note that the car
doesn't begin to move especially, please.
3 The gear-shift when stopping for a long time [**]O r , [**][Ni] is put.
312
How to drive automatic car
Contents
Method of parking
1
Warning
The car is completely stopped.
. good.. Safety
[na] ・
The gear-shift while running [**]Please do not put [ni]. of
[to] Comfortable
theory
- The gear-shift while running [**]Please do not put [ni]. Automatic transmission equipment
It drinks, is locked [uchi] mechanically, might cause an unexpected accident, and is dangerous. -
How and
Please do not rev while stopping. The gear-shift [**]・ [**]It is, and the car is a rapid departure. to attention
It might connect and is dangerous in the accident of ..advancement.. [shi] not trowed.
associate
. drinking..
car
Please stop the engine without fail and lock the door when
parting from the car.
- When it is left to start up an engine, the gear-shift : by any chance. [**]Japanese chestnut at a certain time. Maintenance
The car in the [pu] phenomenon begins to be likely to move automatically, and when depressing it, to start
the gas pedal rapidly by mistake. -
Step on the gas pedal and the brake pedal at the same time, and the gear-shift in the acclivity[**][Nomama]
Myriad
Please do not stop the accelerator though it is deep. An automatic transmission overheats,
and it causes the breakdown.
One[Notoki]
Index
313
How to use of the parking brake pedal.
Handling of parking brake pedal
Brake pedal
The parking brake pedal is fully depressed with the left leg while firmly stepping
on the brake pedal by the right leg. -
The brake warning light lights when the engine switch is turned on.
Brake pedal
The parking brake pedal is depressed with the left leg while firmly stepping on the brake pedal
by the right leg until "[Kachi]" and the sound are heard, and it separates slowly.
- The brake warning light is turned off.
314
How to use of the parking brake pedal.
Contents
Please do not run with the parking brake put. The brake parts
are worn out early, and the brake overheats and effective might worsen. Warning
Knowledge
. earliness.. Basic
operation
When putting it again [wakari]
It steps again to put after the parking brake is put again after it releases it
once.
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
315
View of meter, pilot light, and warning light
Meter
Knowledge
About the meter
When the power supply is turned on, the indicator in the meter is not abnormal though are for a short time
about 0 scale slight movement [suru] situation.
316
View of meter, pilot light, and warning light
Contents
Fuel gauge
When the power supply is turned on, the amount of the fuel remainder is shown. Warning
It is. device
The
Speed meter Handling indoor
equipment
The transport speed of the vehicle is shown.
Index
317
Odometer/trip meter
When the power supply is turned on, the following display is done.
- Odometer
A total distance where it runs is shown by the unit of km.
- Trip meter
Two kinds of section distances (trip A and trip B) are shown by the unit of km.
318
View of meter, pilot light, and warning light
Contents
Knowledge
Driving
About the operation condition Handling
When the power supply is turned on, it is possible to use it. device
when surroundings are bright (daytime etc.), no do decrease in lights of meter lighting. Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
319
Pilot light
- 3.5L car [**][De] of ..drinking.. display [shi-kensharushifutomachikku] pilot light (Refer to P.322).
The pilot light in all grades is published in figure. The pilot light set
to an actual car is different depending on the grade etc.
320
View of meter, pilot light, and warning light
Contents
Driving
Handling
[shi-kensharushifutomachikku]
AFS OFF pilot light device
pilot light direction
The
instruction pilot light LKA pilot light Handling indoor
equipment
associate
Reception desk fog lamp . drinking..
pilot light car
Maintenance
Myriad
One[Notoki]
Index
321
Shift position pilot light
The shift position that has been selected is displayed as follows. -
2.4L car: [********] ( Bambo basket. [**]- 1 )
- 3.5L car: [********] ( Bambo basket. [**]- 2 )
- 1 The shift position [**][Notoki] is displayed.
- 2 The shift position [**][Notoki] is displayed.
[Supo-tsushi-kensharushifutomachikku]
pilot light
2.4L car
The gear-shift [**]It lights when changing to [nishite] sports
sequential shift mode. (Refer to P.298. )
Knowledge
When blinking quickens abnormally
The lamp cutting of the turning indicator is thought. Please confirm whether all the turning
indicators blink.
322
View of meter, pilot light, and warning light
Contents
. earliness.. Basic
Light of width of car pilot light operation
[wakari]
When the front position light and the taillight are lit, it lights. (Refer to P.356. )
Driving
Handling
. good.. Safety
Security pilot light [na] ・
of
[to] Comfortable
When an anti-theft system becomes an operating state, it blinks. (Refer to theory
equipment
P.527. )
How and
to attention
associate
. drinking..
car
Cruise control pilot light
CRUISE
Radar cruise control and cruise control installation car
When the system is turned on pushing the cruise control Maintenance
main switch, it lights.
Afterwards, when abnormality is found in the system, it blinks. (Refer to
P.387,416. ) Myriad
One[Notoki]
Index
323
AFS OFF pilot light
Intelligent AFS installation car
When intelligent AFS is put into the operation halt condition
pushing the AFS OFF switch, it lights. (Refer to P.376. )
When abnormality is found in [o-tore] [be] ring system of
intelligent AFS or [dei;sucha-jiheddoranpu], it blinks. (Refer
to P.537 for [dei;sucha-jiheddoranpu]. )
When the AFS OFF pilot light has blinked, there is usually
no obstacle in running because the headlamp lights though not
operated by an intelligent AFS or [o-tore] [be] ring system.
Knowledge
About the pilot light
The power supply is lit when turning on or the engine is started, and after a few seconds, it turns it off.
324
View of meter, pilot light, and warning light
Contents
Driving
Handling
Knowledge device
Maintenance
Myriad
One[Notoki]
Index
325
Slipping pilot light
S-VSC installation car
It blinks at the next time the engine's rotating. -
When the TRC system operates. (TRC system)
. Refer to P.532. -
When the vehicle seems to sideslip and becomes it. (S-VSC system)
. Refer to P.534.
Knowledge
About the pilot light
It lights when the power supply is turned on, and after a few seconds, it turns it off.
Knowledge
About operation
It is likely to warn only by blinking the slipping pilot light according to the operation condition.
326
View of meter, pilot light, and warning light
Contents
Warning
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate . drinking..
car
Maintenance
Myriad
One[Notoki]
Index
327
Warning light
- In meter
The warning light in all grades is published in figure. The warning light
set to an actual car is different depending on the grade etc.
328
View of meter, pilot light, and warning light
Contents
- Center of [inpane]
Warning
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
329
. warning light table .
Warning light Warning light name Warning light Warning light name
ABS& brake assistance
warning light ABS [Purikurasshu]
ABS
Safety system warning light
warning light
330
View of meter, pilot light, and warning light
Contents
Abnormality of the system is thought, and receive the check promptly in the Toyota
shop in the state of the following warning light's lighting, please. Warning
Knowledge
About the warning light Myriad
It lights when the power supply is turned on, and after a few seconds, it turns it off.
One[Notoki]
Index
331
Abnormality of the system is thought, and receive the check promptly in the Toyota
shop in the state of the following warning light's lighting, please.
Knowledge
About the warning light
It lights when the power supply is turned on, and after a few seconds, it turns it off.
332
View of meter, pilot light, and warning light
Contents
Abnormality of the system is thought, and receive the check promptly in the Toyota
shop in the state of the following warning light's lighting, please. Warning
once in the Toyota shop, please when the warning light becomes the
following. When colliding, the seat belt with the supplemental restraint
The
system airbag or the pretensioner normally doesn't operate,
Handling indoor
and be likely to be injured. - equipment
In the state of not lighting the power supply of turning on or
nor lighting. -
When lighting while running.
. good.. Safety
[na] ・
of
[to] Comfortable
Knowledge theory
equipment
About the warning light
How and
It lights when the power supply is turned on, and after a few seconds, it turns it off. to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
333
Abnormality of the system is thought, and receive the check promptly in the Toyota
shop in the state of the following warning light's lighting, please.
Knowledge
About the warning light
It lights when the power supply is turned on, and after a few seconds, it turns it off.
334
View of meter, pilot light, and warning light
Contents
Abnormality of the system is thought, and receive the check promptly in the Toyota
shop in the state of the following warning light's lighting, please. Warning
device
Abnormality of the system is thought, and receive the check in the Toyota shop, please
when the warning light becomes the following. -
In the state of not lighting the power supply of turning on or nor lighting. -
The
When lighting while running.
Handling indoor
It is not abnormal if it turns it off afterwards even if it lights while running. However, equipment
please receive the check in the Toyota shop when the same phenomenon is generated again.
. good.. Safety
Knowledge [na] ・
of
About the warning light [to] Comfortable
theory
It lights when the power supply is turned on, and after a few seconds, it turns it off. equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
335
Abnormality of the system is thought, and receive the check promptly in the Toyota
shop in the state of the following warning light's lighting, please.
Please receive the check at once in the Toyota shop when you light
while the engine is rotating.
Knowledge
About the warning light
It lights when the power supply is turned on, and it turns it off when starting up an engine.
336
View of meter, pilot light, and warning light
Contents
Abnormality of the system is thought, and receive the check promptly in the Toyota
shop in the state of the following warning light's lighting, please. Warning
[Dei;sucha-jiheddoranpuo-toreberingu]
warning light . earliness.. Basic
operation
[wakari]
[Dei;sucha-jiheddoranpu] installation car
(The intelligent AFS installation car is excluded).
When abnormality is found in auto leveling (upper and lower irradiation direction
Driving
self adjustment) system of [dei;sucha-jiheddoranpu], it lights. (Refer to Handling
P.537. ) device
The
Please stop in the place of safety at once, and stop the engine
Handling indoor
once when the warning light lights while running. It is possible equipment
to use it as it is if it turns it off after the warning light lights for a few seconds
when the power supply is turned on. Please receive the check at once in
the Toyota shop when it doesn't turn off, and you light again. . good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
Knowledge
How and
About the warning light to attention
It lights when the power supply is turned on, and after a few seconds, it turns it off. associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
337
Abnormality of the system is thought, and receive the check promptly in the Toyota
shop in the state of the following warning light's lighting, please.
Please receive the check at once in the Toyota shop in the state of
the warning light's lighting. In this case, the steering wheel
control power might be heavy, and operate it, please with
the steering wheel firmly.
Knowledge
About the warning light
It lights when the power supply is turned on, and after a few seconds, it turns it off.
338
View of meter, pilot light, and warning light
Contents
Please stop in the place of safety at once, and contact the Toyota shop in the state
of the following warning light's lighting. Warning
device
Index
339
Abnormality of the system is thought, and receive the check promptly in the Toyota
shop in the state of the following warning light's lighting, please.
Please receive the check at once in the Toyota shop when you light
while the engine is rotating.
Knowledge
About the warning light
It lights when the power supply is turned on, and after a few seconds, it turns it off.
340
View of meter, pilot light, and warning light
Contents
Please stop in the place of safety at once, and contact the Toyota shop in the state
of the following warning light's lighting. Warning
device
Knowledge
About the warning light The
It lights when the power supply is turned on, and it turns it off when starting up an engine. Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
341
Please stop in the place of safety at once, and contact the Toyota shop in the state
of the following warning light's lighting.
Knowledge
About the warning light
It lights when the power supply is turned on, and it turns it off when starting up an engine.
342
View of meter, pilot light, and warning light
Contents
device
The
Handling indoor
equipment
Half door warning light
It lights when either of door (The backing door is included)
is not surely closed. - . good.. Safety
[na] ・
The content of warning is displayed on the multi information of
[to] Comfortable
display at the same time in the multi information display theory
installation car. equipment
How and
Please do not run with the warning light lights. It opens to attention
suddenly while running because the door is not surely closed the door, might associate
cause an unexpected accident, and is dangerous. . drinking..
car
Maintenance
Myriad
One[Notoki]
Index
343
Please deal promptly when the following warning light lights.
344
View of meter, pilot light, and warning light
Contents
Knowledge
About the warning light Maintenance
- The sensor is detected when weight more than constancy certain is put on the passenger's
seat seat seat side (half [ushiro]). Therefore, might it detect when luggage etc.
are put, and the warning light blink. -
Weight might be distributed when the cushion (square cushion) etc. are paved on the Myriad
passenger's seat seat seat side, and the sensor not detect the crew.
One[Notoki]
Index
345
Multi information display *
It is necessary to be able to do on the multi information display.
346 - As for the sign, the presence of the installation is different depending on the grade etc.
Multi information display
Warning
Driving
Handling
device
Whenever the DISP switch is pushed, the display of "Cruise
information display" can be switched. (Refer to next page. )
Moreover, it is possible to switch also to the display of "Radar cruise The
control" by turning on the main switch of the radar cruise control and the Handling indoor
equipment
lane keeping assistance. (radar cruise control installation car and lane keeping
assistance installation car)
. good.. Safety
[na] ・
of
[to] Comfortable
Knowledge theory
equipment
About the display of the display
In the following cases, the display of the display changes automatically. - How and
to attention
It changes into the alarm display even if the item of "Cruise information display" is
displayed when the warned item is generated. - associate
. drinking..
It changes into each display even if the item of "Cruise information display" is car
displayed when there is a change in each display when the main switch of the radar
cruise control and the lane keeping assistance is turned on.
(radar cruise control installation car and lane keeping assistance installation car)
Maintenance
Myriad
One[Notoki]
Index
347
Cruise information display
The distance that can cruise according to a present amount of the fuel remainder and fuel cost is calculated and displayed.
Please the fuel gauge must approach E even in case of the numerical value to which it can run still enough in
the distance that can cruise or replenish the fuel ahead of time when the low fuel warning light lights.
Knowledge
About the distance display that can cruise
- When the new car is received, the numerical value displayed as a distance that can cruise might not display a
correct numerical value. -
The distance that can be the displayed flying might increase and decrease by the operating method and the road situation
because it calculates based on past fuel cost. -
When the fuel gauge abnormally detects it, the display might become " km" for a while.
- When the battery terminal is detached, the studied fuel cost is reset.
348
Multi information display
Contents
The average fuel cost after the engine is started is updated every about ten seconds and displayed. -
To measure the numerical value from present, it keeps pushing the DISP switch for about . earliness.. Basic
operation
one second or more. [wakari]
device
Fuel cost is displayed in the bar graph momentarily in every about 0.5 seconds after the engine
starts, and running begins.
The
How and
Velocity of average car (00.0 km/h) to attention
associate
. drinking..
car
The velocity of the average car after the engine starts, and running begins is updated every about ten
seconds and displayed. -
To measure the numerical value from present, it keeps pushing the DISP switch for about Maintenance
one second or more.
Myriad
One[Notoki]
Index
349
Alarm display
When either of door (The backing door is included) is open, the open door is displayed with
the character and the picture.
Please ..alarm display.. ..[detamama].. do not run. It opens while running because the
door is not surely closed the door, might cause an unexpected accident, and is dangerous.
Please run after surely closing [detatokiha], pulling up a car, and the door of the alarm
display.
350
Multi information display
Contents
When the switch of the power supply is repeated twice pushing the engine switch without stepping on the
brake, the content of warning is displayed for a few seconds. However, the mastering warning . earliness.. Basic
blinks or doesn't light. operation
[wakari]
device
When the velocity of the car becomes about 5 km/h or more with the parking brake
hung, the sound "Porn" rings, the mastering warning lights, and the content of warning
is displayed. The
Handling indoor
Please run after releasing [detatokiha], pulling up a car, and the parking brake equipment
. good.. Safety
[na] ・
of
Engine oil oil pressure warning display [to] Comfortable
theory
equipment
How and
to attention
The sound "Porn" rings when abnormality is found in the pressure of oil to which the inside of
associate
the engine is lubbed while the engine is rotating, the mastering warning lights, and the content . drinking..
of warning is displayed. car
Please stop in ..alarm display.. [detatokiha] and the place of safety at once, stop the
engine, and check the amount of the engine oil. (Refer to P.600. )Please contact the
Maintenance
Toyota shop when it is displayed even if the time displayed though the number of engine
oil has not decreased and the engine oil is replenished.
Myriad
One[Notoki]
Index
351
VSC alarm display
Abnormality of [detatokiha] and ..alarm display.. system is thought, and receive the
check in the Toyota shop, please.
4WD car
The sound "Porn" rings when abnormality is found in 4WD system, the mastering
warning lights, and the content of warning is displayed.
Abnormality of [detatokiha] and ..alarm display.. system is thought, and receive the
check in the Toyota shop, please.
352
Multi information display
Contents
Pre-crash
safety warning display Warning
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
Pre-crash safety installation car
About the alarm display of pre-crash safety (PCS) systemPlease The
refer to P.544. Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
353
Radar cruise
control warning display
Please receive the check in the Toyota shop ..alarm display.. [detemo] and the obstacle in
running though it is not.
354
Multi information display
Contents
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
[na] ・
Please see P.151 about the alarm display of smart entry & of
start system. [to] Comfortable
theory
equipment
How and
Lane keeping to attention
associate
assistance warning display . drinking..
car
Maintenance
One[Notoki]
Index
355
How to use of the switch.
How to use of the light switch.
Switch
When the switch is spent in AUTO, the headlamp and the front position light, etc. are lit and turned off by the automatic
operation in proportion to surrounding brightness. -
When the engine is stopped, and the driver's seat door is opened, it automatically turns it off. When the
engine switch is turned on, it lights again.
Knowledge
About the operation condition
When the power supply is turned on, it is possible to use it.
About [konraitosensa-]
- Sensitivity can be adjusted and consult the Toyota shop, please when feeling that lighting and turning off the
lamp when it uses it by the automatic operation are early or are slow. -
The sensor might not operate normally
when the one is put on the sensor of Sensor
[konraito] or the glass cleaner etc. are
sprayed.
356 - As for the sign, the presence of the installation is different depending on the grade etc.
How to use of the switch.
Contents
Index
357
When you want to shine on forward far
Upward
Downward
lever
358
How to use of the switch.
Warning
The right
. earliness.. Basic
Lever operation
[wakari]
- The direction instruction pilot light that blinks under on when operating it a turning indicator
that is left or right, and exists in the meter also blinks the lever. Driving
Handling
The lever returns automatically when the steering wheel is returned. Please return it with the
device
hand when it doesn't return. -
Each turning indicator while it is suppressing it and the direction instruction pilot
light blink to the under, and it turns it off when the hand is separated at the lane change. The
Handling indoor
equipment
Knowledge
About the operation condition
. good.. Safety
When the power supply is turned on, it is possible to use it. [na] ・
of
[to] Comfortable
theory
When blinking quickens abnormally equipment
The lamp cutting of the turning indicator is thought. Please confirm whether all the turning indicators blink.
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
359
The top and bottom of optical axis adjustment of headlamp
Dial
Knowledge
About the top and bottom of optical axis adjustment
- The dial is spent when the front side of the vehicle face upes by putting luggage and the person, and the
range that the headlamp shines on is different from always (It is more upward than usual) and an optical axis of
the headlamp is made downward. Please return the dial to the position of 0(0) after selling luggage
and the person wholesale. -
Please go after adjusting the dial to the position of 0(0)(most upward position) when you adjust an optical
axis by the car inspection etc.-
Please adjust the table of next page according to the number of crew and the loading situation of the luggage room and adjust the dial
position to the standard.
360
How to use of the switch.
Contents
Knowledge
Warning
About the standard at the dial position
When it gets on 7 or 8 people and luggage room is fully loaded 2.5 device
When only driver's seat gets on and luggage room is fully loaded 3.5
The
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
361
How to use of the fog lamp.
Lighting
turning off
The switch It drinks, it ..location.. lights with [mawasu], and it turns it off when spending in turning off. -
The reception desk fog lamp pilot light (Refer to P.323) in the meter
lights when the reception desk fog lamp lights.
Knowledge
About the reception desk fog lamp
It uses it as assistance of the headlamp when view is bad because of rain and the fog, etc.
362
How to use of the switch.
Driving
Handling
[**]Low-speed operation
[**]High-speed operation
Please turn off the lever when you need not use the Maintenance
wiper.
Myriad
One[Notoki]
Index
363
Adjustment type wiper installation car of intermittent time
Temporary operation
(MIST)
Intermittent time"Length"
Stop
(OFF) Switch
Lever Intermittent
operation (INT)
low speed Intermittent time"Short"
operation (LO)
High-speed
operation (HI)
- [Riya]
Low-speed operation (HI)
Intermittent operation
Switch
364
How to use of the switch.
Contents
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
365
Knowledge
About the operation condition
When the power supply is turned on, it is possible to use it.
366
How to use of the switch.
Contents
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
The washer fluid is jetted while the lever is being pulled forward. -
The wiper operates several times after jetting the washer liquid.
The
Handling indoor
- [Riya] equipment
. good.. Safety
[na] ・
Washer liquid jet of
[to] Comfortable
theory
equipment
Low-speed operation (HI)
How and
to attention
associate
Switch . drinking..
Stop (OFF) car
Maintenance
- When jetting it, the washer fluid is spent from low-speed operation (H I) of the switch
in the side while low-speed operating ..on...
- Washer while switch is being spent from stop (OFF) in lower side
Myriad
The liquid is jetted.
[**]The wiper operates several times after jetting the washer liquid. One[Notoki]
Index
367
Please do not use the washer fluid at the cold. The low
visibility might be caused.
- Please do not use the washer fluid at the cold until the window glass gets warm. The
washer fluid is the window glass and the frozen low visibility might be caused. -
Please operate the wiper after jetting the washer fluid. When the wiper is
operated when the glass is dry, the glass might be damaged. -
The pump might break down when it keeps operating the washer switch when the washer
fluid doesn't come out. Please check blocking the washer liquid measure and the nozzle. Moreover,
please consult the Toyota shop when the nozzle is blocked and the jet is bad.
Knowledge
About the operation condition
When the power supply is turned on, it is possible to use it.
368
How to use of the switch.
Warning
. earliness.. Basic
operation
[wakari]
Switch Driving
Handling
device
It operates for about 15 minutes when the switch is pushed, and it stops when pushing again while operating. -
The operation pilot light lights while operating.
The
Handling indoor
It causes the battery rising when continuously using it for a long time. equipment
. good.. Safety
Knowledge [na] ・
of
[to] Comfortable
About [riyauindou;defogga-] theory
equipment
- The backing door glass is warmed in heat ray and cloudy weather is taken. -
The cold-weather model car operates the mirror heater (Refer to P.294) at the same time. How and
to attention
Maintenance
Myriad
One[Notoki]
Index
369
How to use * of the reception desk seat heater
- Next, please be too hot and note that the low temperature burn (erythema and blister) might
be caused enough while using the heater when it is used to correspond.
[**]Baby and child, elderly person, sick person, and physically handicapped person.
[**]Person to whom skin is weak.
[**]Person with intense tiredness.
[**]Person who used medicine (sleeping medicine and cold [kusuri], etc.) that invites drinking too much and can sleep peel. -
Please do not use it with the good one of the heat-retaining property such as blankets and cushions put.
It overheats abnormally the seat, might lead to the breakdown of the low temperature burn and the seat, and is dangerous.
370 - As for the sign, the presence of the installation is different depending on the grade etc.
How to use of the switch.
Contents
Please do not put the heavy load with the ruggedness on the seat, and
do not thrust the sharp one such as needles and nails. Warning
- Please do not put the heavy load with the ruggedness on the seat, and do not thrust the sharp one such
as needles and nails. It causes the breakdown. -
Please do not use organic solvents such as benzine and gasoline to clean the seat. The surface
of the heater and the seat might be damaged. . earliness.. Basic
operation
[wakari]
Knowledge
Driving
About the operation condition Handling
When the power supply is turned on, it is possible to use it. device
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
371
How to use of the reception desk
window shield glass switch with heat ray.
Switch
It operates for about 15 minutes when the switch is pushed, and it stops when pushing again while operating. -
The operation pilot light lights while operating.
It causes the battery rising when continuously using it for a long time.
Knowledge
About the reception desk window shield glass with heat ray
The surface under the reception desk window glass is heated and the glass and the wiper blade are prevented being
frozen.
372
How to use of the switch.
Switch
Warning
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
When all the turning indicators blink, and push again while blinking when the switch is pushed,
it turns it off. -
The direction instruction pilot light in the meter blinks while blinking, too. The
Handling indoor
equipment
Please do not use it for a long time when the engine has stopped to prevent
the battery from going up.
. good.. Safety
[na] ・
of
[to] Comfortable
Knowledge theory
equipment
About the emergency blinking light
How and
It uses it to inform another car when the road is unavoidably parked due to the breakdown etc. to attention
associate
. drinking..
About the operation condition car
Maintenance
Myriad
One[Notoki]
Index
373
How to use of 4WD auto mode switch.
4WD car
Switch
Knowledge
About the mode
4WD auto mode
When cornering, climbing up the slope, and starting, driving performance (torque) distribution to the rear wheel is automatically controlled
from running according to various states of running such as roads slippery because of acceleration, the snow, and rain, etc. usually. -
When the idling of the wheel continues for a long time by the escape circle and the stack, etc. , 4 for the drive
and the system protection The WD system is a halt condition (FF mode fixation).
FF mode
FF is running. The fuel cost performance is improved by changing to the FF mode.
374
How to use of the switch.
Three spoke steering wheel installation car Four spoke steering wheel installation car
Warning
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
Steering wheel The horn (horn) rings when the part around the mark is pushed.
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
375
AFS* How to use of the turning off switch.
Switch
The operation of intelligent AFS stops when the AFS OFF switch is pushed, and it returns to the
state that can be operated when pushing again while operation is stopping. -
The AFS OFF pilot light (Refer to P.324) in the meter lights while
stopping.
Please do not use intelligent AFS in the road that includes [yukikabe] etc.There
is a possibility of the reflection of the headlamp to snowy slopes etc. and becoming an obstruction
of driving.
Knowledge
About the operation condition
- When the headlamp (downward) lights by turning on, the power supply can be used.
- Operation stops when the velocity of the car is 10 km/h or more, it becomes an operation beginning, and the velocity of the car becomes less than 5 km/h. -
When the left turns, a left headlamp moves, and 10. or less and a right headlamp move and the illumination axis
moves up to 5. or less left. -
When turning right, a right headlamp moves, and 15. or less and a left headlamp move and the illumination axis
moves right up to 7.5. or less. -
Intelligent AFS doesn't operate when the AFS OFF pilot light has blinked
(Refer to P.324).
376
How to use of the switch.
Auxiliary equipment. as perceive a rough interval of the vehicle and the obstacle by the supersonic
sensor when driving at the low speeds of the garage putting and parallel parking, etc. (about 10 km/h or
Warning
less), and inform those who drive with the pilot light and the buzzerPlease
read "HDD navigation system manual" of the separate volume if you take
the voice guide clearance sonar installation car. . earliness.. Basic
operation
[wakari]
When using it
- Main switch Driving
Handling
Operation pilot light
device
It changes into turning on and turning off whenever the main switch is pushed. -
How and
The operation pilot light lights when the main switch is turned on, and the buzzer rings. - to attention
The operation pilot light lights when the power supply is turned on when the main switch associate
. drinking..
is turned on, and the buzzer rings. car
Maintenance
Myriad
One[Notoki]
Index
- As for the sign, the presence of the installation is different depending on the grade etc. 377
- Operation pilot light
Operation pilot light
Knowledge
About the operation condition
- When the power supply is turned on, it is possible to use it. -
The main switch operates by turning on as for clearance sonar & backing sonar at the following
condition.
[**]The gear-shift : the backing sonar and [riyakuriaransusona-]. [**][Notoki] .
[**]The gear-shift : the reception desk clearance sonar. [**]It is, and the velocity of the car is about 10 km/h [**].
Nipponia nippon below. However, the gear-shift ..(.. :. [**][Notoki] operates regardless of the velocity of the car. )
378
How to use of the switch.
Contents
The
Clearance sonar pilot Handling indoor
Blinking Fast blinking Lighting
light equipment
Position of car
and obstacle
Maintenance
Backing sonar
Blinking Fast blinking Faster blinking Lighting
pilot light Myriad
[Pipipipi] One[Notoki]
[Pippippi] [Pipipipi]
buzzer sound (faster discontinuous
(discontinuous sounds) (fast discontinuous sounds) Feep(continuous sound)
sounds)
Index
379
How of buzzer when obstacle is perceived in two or
more places at the same time to ring
The buzzer sound changes as follows when the obstacle is perceived in two or more places at the
same time. -
The clearance sonar already and the buzzer sound is [pipipi] . . [pipi] (Seven times of
discontinuous sounds) feep within about 25cm when the obstacle is newly perceived by other parts
while perceived with the backing sonar within about 35cm as for the obstacle It keeps ringing
dividing into (continuous sound), and about 1.5 cycles of the second repeatedly. -
Other parts keep ringing dividing into [pipipi] (Three times of discontinuous sounds)
feep (continuous sound) the buzzer sound when the obstacle is perceived with the backing
sonar within about 35cm, and about 0.5 cycles of the second repeatedly by the clearance
sonar within about 25cm while perceived with the backing sonar within about 25cm in the clearance
..obstacle.. sonar already within about 35cm, too.
The figure below is an example when two or more obstacles are perceived the left side front and behind the vehicle of the vehicle.
Blinking
35cm or more
Lighting
Within 35cm
380
How to use of the switch.
Contents
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
Clearance sonar
. good.. Safety
backing sonar [na] ・
of
[to] Comfortable
theory
The range that can be perceived is limited within the range in the above figure, and drive slowly, please equipment
Index
381
In the following cases, the device might not operate normally. Please
drive carefully.
- In the following cases, it might not operate normally the device, might cause an unexpected accident, and is
dangerous. Please drive carefully.
[**]When ice, the snow, and mud, etc. adhered to the sensor (Return normally if it removes).
[**]When the sensor assembly froze (Return normally if it melts).
[**]When you close the sensor with the hand.
[**]When the vehicle posture inclines greatly.
[**]At the hot weather under and the cold.
[**]At irregularity road, slope, gravel walk, and grassy place running etc.
[**]When the one to generate the supersonic wave such as clearance sonar & backing sonars of the airbrake sound of the
engine sound of another car horn and the motorcycle and large-sized cars and another cars approaches.
[**]When downpour and the spray hang.
[**]When you apply an antenna for fender Paul and the wireless machine on the market to the car.
[**]When you advance toward a tall curb and the curb of the right angle.
[**]The detection distance might become short according to the object of the sign etc.
[**]The vicinity of the right under of the bumper is not perceived. No neither object that is lower than the sensor nor a thin paling,
etc. might be suddenly perceived when approaching even if it perceives it once.
[**]When the obstacle approaches the sensor too much, it is likely not to operate. -
The following one might not perceive, might cause an unexpected accident, and is dangerous.
Please drive carefully.
[**]The thin one such as wires and ropes.
[**]The one to absorb sound waves such as cotton and snows easily.
[**]The one with acute angle shape.
[**]It is tall and the one that the part projects.
[**]The short one.
382
How to use of the switch.
Contents
Knowledge
About the volume of the buzzer . good.. Safety
[na] ・
I might not hear the buzzer easily by the volume of audio and the amount etc. of the wind of the air conditioner. of
In that case, the volume of the buzzer can be adjusted, and consult the Toyota shop in detail, [to] Comfortable
theory
please. equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
383
Radar cruise control (with brake control)*
How to use of the radar cruise control (with brake control).
Please use it in the expressway and the motorway, etc. where the distance between two cars with the proceeding vehicle
is secured easily.
384 - As for the sign, the presence of the installation is different depending on the grade etc.
Radar cruise control (with brake control)
Contents
. earliness.. Basic
operation
[wakari]
[**]
[**]
Driving
Handling
device
Control switch
[**]
Main switch
④ The
Handling indoor
equipment
Direction of operation Switch indicator Function
. ON-OFF
-
① - MODE from the control mode between cars to fixed velocity control mode . good.. Safety
[na] ・
② - CANCEL ・Temporary release of control of
[to] Comfortable
theory
・It returns it in the state of the control at former velocity of the set car.
③ - + RES
・The velocity of the set car is raised.
equipment
How and
・Beginning of control
④ - - SET
・The velocity of the set car is lowered.
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
385
- Distance between two cars switch switch
"Length" the distance between the control cars of the control
mode between cars It is possible .... to switch to three stages"
and "Short".
Please make the main switch O FF when you do not use the
radar cruise control. The radar cruise control is operated by mistake, and
it might cause an unexpected accident and is dangerous.
386
Radar cruise control (with brake control)
Contents
It warns, it sounds, the mastering warning in the meter lights, and the cruise
control pilot light blinks , saying that "Porn" when judged that the radar Warning
cruise control cannot be used due to abnormality etc. of bad weather (control
mode between cars) and the system (all modes). At this time, the content of
warning is displayed on the multi information display.
At this time, the control is automatically released. . earliness.. Basic
Please see P.409 in detail. operation
[wakari]
Mastering warning (lighting)
Driving
Handling
device
. good.. Safety
[na] ・
How to switch control mode and the fixed velocity control mode between cars of
[to] Comfortable
theory
- When using it in the control mode between cars equipment
How and
to attention
Main switch
associate
. drinking..
car
If the main switch is pushed, it becomes the control mode between cars. - Maintenance
The radar cruise control pilot light in the meter lights. At the
same time, the radar cruise control standby state pilot light lights, and it enters the state
of the set standby of the control mode between cars. Myriad
Under such a condition, it uses it when using it in the control mode between cars.
One[Notoki]
Index
387
- When using it in the fixed velocity control mode
388
Radar cruise control (with brake control)
Contents
Knowledge
Warning
About the operation condition
When the power supply is turned on, it is possible to switch to the control mode between cars and the fixed velocity control mode.
associate
. drinking..
car
Index
389
Control mode between cars
- The distance between two cars shortens by the change in proportion to the velocity of the car, and lowering of the velocity of the car.
390
Radar cruise control (with brake control)
Contents
Sharp incline
The set speed might be exceeded because the engine brake doesn't work enough when there
is no proceeding vehicle. Maintenance
Moreover, the engine brake doesn't work enough even when there is a proceeding vehicle and the follow
control is done, and the decelerating timing might be delayed.
At a traffic situation in which acceleration and the deceleration are frequently repeated
Myriad
It is not likely to be able to run the speed suitable for a traffic situation.
One[Notoki]
Index
391
Be not overconfident in the radar cruise control.
It might cause an unexpected accident and is dangerous.
Road where sudden acclivity and downward slope are repeated
The proceeding vehicle cannot be detected, and it is likely to approach the proceeding vehicle too much.
When it goes into the interchange coverage parking area etc. while
It using
does. the radar cruise control in the expressway etc. (Go out of
the main line)
When the follow running is done to a car that is slower than the velocity of the set car by the
radar cruise control on the main line, the proceeding vehicle is gone because the car leaves the
main line, and it is likely to accelerate up to the velocity of the set car. -
It might cause an unexpected accident because neither the control of the radar cruise control nor the approach
warning are done and is dangerous for a vehicle that is more extremely slower than the vehicle and the velocity of
the car under the stop. Please note the stop in the tail of the toll gate and congestion and vehicles, etc. where the velocity of the car
is extremely slow enough. -
It cannot keep the distance between two cars appropriate because the detection of the proceeding vehicle
that interrupts closely cannot be delayed because the detection area of the radar sensor is narrow in the short
distance, and the two-wheeled vehicle that runs on the edge of the lane be detected, might cause an unexpected
accident, and is dangerous. - Two-wheeled vehicle
Because this system controls the reflection electric wave on the rear end side of the proceeding vehicle
chiefly detecting it, it cannot in the following cases keep the distance between two cars appropriate because
the proceeding vehicle cannot be detected accurately, might cause an unexpected accident, and is dangerous.
[**]When the proceeding vehicle and the vehicle in another lane reel, raise water and the snow etc. of the road,
and it runs.
[**]The proceeding vehicle : when the vehicle rear end area is extremely little like the trailer etc. of an empty load.
392
Radar cruise control (with brake control)
Contents
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
393
Method of set
1 It makes it to turning on pushing the main switch.
The cruise control pilot light in
the meter lights. At the same time, "RADAR
READY" is displayed on the multi information
display, and it enters the state
Main switch
of the set standby of the control mode between
cars.
394
Radar cruise control (with brake control)
Contents
Knowledge
Warning
About the set condition
- The velocity of the set car can be set between about 45 km/h and 100 km/h. However, the velocity of the set car
becomes about 100 km/h when the velocity of the set upper bound car is exceeded when setting it and it runs. -
It is not possible to set it at the next time. . earliness.. Basic
[**]The gear-shift [**]O r , [**] ( [**]、 Shinto flute、 [**][Noizureka]) When is besides. operation
[wakari]
[**]When the wiper is high-speed and operated.
In the situation in which accurate detection with the radar sensor cannot be done by bad
weather etc. , the system might not operate. Please refer to "Alarm display" of P.409 for
details.
Driving
Handling
device
When you stop the engine
The main switch is automatically turned off.
The
Handling indoor
About the distance setting between cars equipment
Whenever starting up an engine, the distance setting between cars becomes "Length". " To switch to "Short", the
distance between two cars switch switch is operated during "Please refer to "How to change the
distance setting between cars" of P.399 for details.
. good.. Safety
[na] ・
of
About the lane keeping assistance [to] Comfortable
theory
The state of the lane keeping assistance might be displayed. Please refer to "Lane equipment
keeping assistance" of P.417 for details.
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
395
Operation under control
A fixed velocity runs at the set velocity of the car even if not stepping on the gas pedal.
Knowledge
To accelerate up to the velocity of the set car quickly
Please the control switch is raised, and the hand is separated or accelerate stepping on the gas pedal though it
accelerates automatically up to the velocity of the set car when the proceeding vehicle is gone when you want to accelerate quickly.
396
Radar cruise control (with brake control)
Contents
device
Knowledge
About the acceleration and deceleration
The
The interruption of the sudden deceleration and another car etc. , seeming the approaches of accelerate necessary in the lane change etc. Handling indoor
, and proceeding vehicles to the proceeding vehicle, and it must accelerate with the gas pedal, and it decelerate with the brake pedal though equipment
automatically accelerates and decelerates according to the velocity of the car of the proceeding vehicle while following running.
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
397
How to change velocity of set car
"Method of set" of P.394 2 、 3 Drinking, and the method of the frog, the following control
switch, and there is a method of the frog according to the procedure.
When it controls between cars (follow running), it doesn't accelerate even if the control switch is raised
because it is controlled at the velocity of the car matched to the proceeding vehicle and the velocity of the set car
is raised. However, after the proceeding vehicle is gone, it will keep accelerating because
the velocity of the set car goes up at this time. Please confirm the velocity of the
set car by displaying the velocity of the set car on the multi information display.
398
Radar cruise control (with brake control)
Contents
Driving
Handling
device
The
Distance between two cars switch switch
Handling indoor
equipment
. distance between two cars "Length" . Distance between two cars . " during ". . distance between two cars "Short" .
. good.. Safety
[na] ・
of
[to] Comfortable
" It changes during "Length" . "in order of . "Short" . "Length" whenever the theory
equipment
distance between two cars switch switch is pushed when the distance mark between set cars
is displayed on the multi information display. How and
to attention
Knowledge associate
. drinking..
car
About the distance between two cars
- Please select the distance between two cars according to a traffic situation.
When running at the velocity of the car 80 km/h, the standard of the distance between the control cars in each distance between two cars setting
is as follows. Maintenance
[**]"Length" . About 50m
[**]" during ". About 40m
[**]"Short" . About 30mIt
shortens more than the above-mentioned distance between two cars by lowering of the velocity of the car. - Myriad
In a long downward slope etc. , the distance between the control cars might become short from the set distance between two cars. -
When the engine is stopped, the distance between two cars is reset in "Length". (Whenever starting up an engine, One[Notoki]
initialization becomes "Length". )-
Only when the control mode between cars has been selected, the distance between two cars can be switched.
Index
399
Method of release
The control is released when stepping on the brake pedal.
- When you temporarily interrupt use
400
Radar cruise control (with brake control)
Contents
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
401
When you return it in former state of the control
If "RADAR READY" is displayed on the multi information display after the
control is released, it is possible to return it in the state of the control at
former velocity of the set car.
The control switch is raised at the time of about 40 km/h or
more in velocity of the car, and the hand is separated. -
The multi information display
becomes a set state display again.
Approach warning
When approaching the proceeding vehicle by the interrupt etc. of it is the deceleration combination
about the proceeding vehicle large and another car when being following running with an enough deceleration
cannot done, attention is prompted to those who drive with the warning buzzer and the multi information
display.
In this case, please decelerate by stepping on the brake, and secure an appropriate distance
between two cars. -
The warning buzzer rings , saying that "[Pipipipi]".
- The screen on the multi information display repeats reversing light and
shade.
402
Radar cruise control (with brake control)
Contents
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
403
Handling of the front of radar sensor
Cover
The front side of sensor
- Please always clean the side before and after the front side of the radar sensor
and the cover. Moreover, please do not damage it by using a soft
cloth etc. when you clean it. -
Please add neither high impact nor power to the radar sensor and the circumference part.
Moreover, please do not resolve it. It causes the breakdown and the mis-operation. -
Please install neither sticker nor the accessories articles, etc. in the circumference
of the radar sensor and the cover.
Especially, please do not paste in front of the cover even if the sticker is transparent and do not
apply it. It causes the mis-operation. -
Please do not remodel, do not paint, and do not exchange the covers. It causes the breakdown and
the mis-operation.
The device might not operate normally due to the breakdown of the
sensor etc. when the bumper is thrown. Please receive the check ahead of time in
the Toyota shop.
404
Radar cruise control (with brake control)
The gear-shift [**]O r , [**](either six cooking stoves, five cooking stoves or four cooking stoves)It
is possible to run the set constant speed (about 45 km/h-100 km/h) even if
Warning
stepping on neither [notoki] nor the gas pedal.
Please note the distance between two cars with the proceeding vehicle enough. . earliness.. Basic
operation
[wakari]
- In the fixed velocity control mode, it doesn't operate because it doesn't judge the distance between two cars of presence and the proceeding
vehicle of the proceeding vehicle in the control mode between cars the approach warning, be likely to cause an unexpected accident, and is dangerous.
Please note the distance between two cars with the proceeding vehicle enough. -
Please do not use the radar cruise control (fixed velocity control mode) at the following Driving
situations. It might cause an unexpected accident when using it and is dangerous. Handling
Road where a lot of traffic exists and road in dogleg that is device
It is not likely to be able to run the speed that exists in the situation of the road.
Slippery road on frozen road and snowfall road, etc. The
The tire runs idle, and the control of the car might be lost. Handling indoor
Sharp incline equipment
Because the engine brake doesn't work enough in the sharp incline, the set speed
might be exceeded.
. good.. Safety
[na] ・
of
[to] Comfortable
theory
Method of set equipment
associate
The cruise control pilot light in . drinking..
car
the meter lights. At the same time,
"RADAR READY" is displayed on
the multi information display.
Maintenance
2 It keeps pushing the control switch forward for
about one second or more.
It changes into the fixed velocity control mode. Myriad
One[Notoki]
405
4 The control switch is lowered, and the hand
is separated.
"Fixed velocity" and the velocity of the set
car are displayed on the multi information display
and it becomes a set state display.
Knowledge
About the set condition
The velocity of the set car can be set between about 45 km/h and 100 km/h. However, the velocity of the set upper bound
car is memorized as a velocity of the set car when the velocity of the set upper bound car (about 100 km/h) is exceeded when the velocity
of the set car is set and it runs.
When you turn off the power supply and the main switch
The system is turned off, and the fixed velocity control mode is canceled.
406
Radar cruise control (with brake control)
Contents
Index
407
Automatic release of control
In the following cases, the constant speed running is automatically released. -
When stepping on the brake pedal. -
When the velocity of the car decreases more than the set speed at about 16 km/h or more. -
When the velocity of the car becomes about 40 km/h or less. -
When it keeps lowering the control switch and the velocity of the car becomes about 45 km/h
or less. -
When the slipping pilot light blinks by operating S-VSC and the S-VSC operation
warning buzzer rings, the S-VSC installation car :. (Please refer to P.534
for the operation of S-VSC. )。
Knowledge
When it seems to sideslip and it becomes it
The control might be released before it warns with the slipping pilot light and the S-VSC warning buzzer in the place where
the S-VSC installation car seems to sideslip according to the operation condition and becomes it.
408
Radar cruise control (with brake control)
The warning sound is released, and in the following cases, it rings, the mastering warning lights, and
the control is released automatically , saying that "Porn". Moreover, the cruise control pilot light
Warning
blinks at the same time, and the content of warning is displayed on the multi information
display.
Driving
Handling
When the front of the radar sensor is dirty in the control mode between cars and the measurement of the distance between
device
two cars becomes difficult, it is displayed. -
In this case, please set it again after cleaning the front of the radar
sensor with a soft cloth etc.- The
It enters the state of the set standby when dirt can be naturally taken. Handling indoor
equipment
If the velocity of the car raises the control switch at about 40 km/h or more in the control
mode between cars at this time and the person is separated, it returns to the state of the control at former
velocity of the set car, and the multi information display becomes a set state display again.
. good.. Safety
[na] ・
of
[to] Comfortable
- "The bad weather cruise cannot be done. " theory
equipment
How and
to attention
associate
. drinking..
car
It is judged that the measurement of the distance between two cars is difficult from the control mode between cars at the following,
and is displayed. -
When you operate the wiper at high speed. -
Maintenance
When the difficulty and the system judge it, the measurement : because of bad weather.
It enters the state of the set standby when the situation when the control is released is improved.
At this time, if the velocity of the car raises the control switch at about 40 km/h or more, Myriad
and the hand is separated, it returns to the state of the control at former velocity of the set car, and One[Notoki]
the multi information display becomes a set state display again.
Index
409
- "Cruise system check"
When abnormality of the system occurs while the set's being standing by or controlling
the radar cruise control, it is displayed.
However, there is no obstacle in a usual running.
In this case, please set it again after stopping in the place of safety, and stopping
the engine once.
In the following cases, please receive the check in the Toyota shop.
In the following cases, abnormality of the system is thought. Please receive the check in the Toyota shop though there
is no obstacle in a usual running. -
"Radar dirt cleaning necessity"However, when it is not possible to set even if the radar sensor is cleaned after it
is displayed or the alarm display doesn't disappear. -
"The bad weather cruise cannot be done. "However, it is not possible to set even if the weather recovers after it is displayed and
When it peels off and the warning display doesn't disappear. -
"Cruise system check" However, when it is not possible to set even if it stops after it is displayed and it
starts up an engine again or the alarm display doesn't disappear.
Knowledge
About the multi information display
The alarm display on the multi information display is turned off, and changes into other
screens if the main switch is turned off when the alarm display lights.
410
Cruise control *
How to use of the cruise control. Contents
The position of the gear-shift : in 3.5L car. [**]O r , [**] ( [**]、 Shinto flute、 [**][Noizureka])
In [notoki] and 2.4L car[**]O r , [**] ( [**]、 [**]、 Shinto flute[Noizureka]) [Akuse]
Warning
It is possible to run with 100km/ h about 45 km/h-) constantly even if [ru] doesn't
pedal ..the set.. ..speed (...
[**] Driving
Handling
device
The
Control switch
[**]
Main switch Handling indoor
[**] equipment
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
- As for the sign, the presence of the installation is different depending on the grade etc. 411
Method of set (constant speed running)
Control switch
1 The main switch is pushed.
The cruise control pilot light in
the meter lights.
Main switch
Control switch
2 It accelerates up to the hope speed or it decelerates.
412
Cruise control
Contents
device
To return it in former state of the fixed velocity
running, the control switch is raised, and the hand is
The
separated.
Handling indoor
equipment
. good.. Safety
[na] ・
How to change velocity of set car of
[to] Comfortable
theory
"Method of set" of last page 2 、 3 There are a method of drinking and substitution according to equipment
the procedure and methods of substitution with the following control switch.
How and
1
to attention
The control switch is operated. associate
. drinking..
- The velocity of the set car goes up if it keeps car
The velocity of the set car goes up. raising it. -
The velocity of the set car falls when keeping
lowering.
Maintenance
The velocity of the set car falls. control switch below lightly on, the setting
speed can be fine-tuned (about 1.5 km/h).
Index
413
Method of release
414
Cruise control
Contents
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
415
Please set it again after turning off the main switch once when the pilot light
blinks in the constant speed running.
Abnormality of the system is thought when released soon even if it is not possible to set or it
sets it even if the above-mentioned operation is done. Please receive the check in the Toyota
shop though there is no obstacle in running.
Knowledge
About automatic release of the constant speed running
In the following cases, the constant speed running is automatically released. -
When stepping on the brake pedal. (In this case, return to former state of the fixed velocity running when the
control switch is raised, and the hand is separated
. When the velocity of the car decreases more than the speed at which * is set
at about 16 km/h or more . When the velocity of * car
becomes about 40 km/h or less . When it keeps lowering * control switch and the velocity of the
car becomes about 40 km/h or less. (When the slipping pilot light blinks by operating S-VSC, and the S-VSC operation warning
buzzer rings . * When the vehicle seems to sideslip and becomes it by the S-VSC installation car . The control might
be released before it warns with the slipping pilot light and the S-VSC operation warning buzzer when it seems to
sideslip according to the operation condition and it becomes it. )
416
Lane keeping assistance *
About the lane keeping assistance Contents
is recognized by using the image of the camera for white line recognition in running, and system of the
motorway that supports running in the lane. Two functions of the lane deviating warning function and the lane
maintenance support function are provided, and the driving support that cooperates with the radar cruise function is done, . earliness.. Basic
operation
and the driving person's load when high-speed running is reduced. [wakari]
and the electric power steering system when the system judges that the lane keeping assistance is
turning on to lane deviating warning function *, the velocity of the car is 50 km/h or more, and there is The
a possibility of deviating from the lane while running through the steering wheel. Handling indoor
equipment
- The lane deviating warning in the lane maintenance support function becomes only a display with the buzzer sound
and the multi information display.
. good.. Safety
- Lane maintenance support function [na] ・
of
A small steering force is given to the steering wheel so that the lane maintenance support function may [to] Comfortable
theory
be added when the velocity of the car is 65 km/h or more, the radar cruise control (control mode between cars) is set, equipment
and it becomes it while controlling running, and the vehicle may run in the vicinity of the center of the lane
How and
and it assists in driving person's steering wheel control. to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
- As for the sign, the presence of the installation is different depending on the grade etc. 417
[Namae] and function of each part
LKA switch
LKA pilot light
Equipment Function
LKA (lane keeping assistance)
ON. OFF of system
switch
LKA (lane keeping assistance) pilot Turning off: System OFF/point light: System ON/blinking:
light System malfunction
Multi information
The state of LKA at system ON is displayed.
display
Please see P.427 about the camera for white line recognition.
418
Lane keeping assistance
Driving
LKA switch Handling
device
When the system is turned on, it operates as it is white (yellow) and the lane deviating warning function and the lane
maintenance support function are automatic according to the condition of the set situation etc. of the cognitive state, the
velocity of the car, and the radar cruise control (control mode between cars) in the line. The
(Please see P.384 about the usage of the radar cruise control. ) Handling indoor
equipment
State of radar cruise Lane deviating warning function Lane maintenance support function . good.. Safety
LKA switch The velocity of the car operates at The velocity of the car operates at [na] ・
control system 50-about 120 km/h. 65-about 100 km/h. of
[to] Comfortable
Fixed velocity theory
- . equipment
control mode ..no use..
Knowledge
Maintenance
About the velocity of the operation car
When each function begins operating, the velocity of the operation car enhances at the upper bound lower bound and 5 km/h and maintains operation. I
might feel the response of time when the lane deviating warning operated and the lane maintenance support function because it differs
One[Notoki]
depending on the running condition and the road condition while running in the road and the curve that inclines right and left when there
is a crosswind.
Index
419
Be not overconfident in the lane keeping assistance.
- Be not overconfident in the lane keeping assistance. No one to assist forward as the parting with driving
and the driving without keeping one's eyes on the road ahead, etc. carelessly with the system that warns the lane deviating, and supports
running in the lane. Please do the steering wheel control always voluntarily, correct the course, and ..safe driving.. bear it in mind. -
In the following cases, the lane keeping assistance might not function correctly, and the
LKA switch is pushed, the system is turned off, and run, please.
[**]When ..white (yellow).. line doesn't get hoarse or it is not easy to see it by becoming dirty.
[**]When you do not see ..white (yellow).. line easily by rain, the snow, the fog, and the backlight, etc.
[**]When time when the lens of the headlamp is dirty and the irradiation is weak and an optical axis shift.
[**]When ..white (yellow).. line becomes interrupted like the examination of tickets place and this side of the toll gate, etc.
[**]When the change in rapid brightness is consecutive.
[**]When ..white (yellow).. line and a confusing line look like the rut etc. where the erasing remainder line, the shadow, the remaining snow, and rain
of the road repair collect.
[**]When you run in lanes other than the main line (cruising lane and overtaking lane) in the expressway etc.
[**]When you run in the lane of the lane restriction and the temporary housing by construction.
[**]When the width of the lane is extremely narrow and when it is wide.
[**]When the distance between two cars with the preceding vehicle shortens extremely.
[**]When the vehicle has inclined remarkably in heavy loading of luggage and a defective adjustment of the tire inflation pressure, etc.
[**]When you run on an undulate road and the robbed road.
[**]When you run rain and the snowfall and to freeze on a slippery road road.
420
Lane keeping assistance
Contents
- When the system judges that it deviates from the lane under running, the lane deviating warning function doesn't automatically device
prevent the lane deviating by the function to press the course correction by driving person's steering wheel control
according to warning. Please correct the course by an always own steering wheel control, and ..safe driving.. bear it in mind. -
The lane deviating warning might not be operated and operate early according to the running condition and the The
road condition. Please always confirm the course, and ..safe driving.. bear it in mind. Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
421
Lane maintenance support function
The lane keeping assistance is turning on, and the white of the lane the camera's for white line recognition running.
(yellow)The lane maintenance support function in addition to the lane deviating warning function
operates when the velocity of the car is set at 65-about 100 km/h by the radar cruise control
(control mode between cars) when the line is recognized. The lane maintenance support function is a
function to support driving by assisting a part of driving person's to run in the vicinity of the
center of the lane steering wheel control power by an electric power steering.
The lane maintenance support function is not the one (the assistance of driving person's steering wheel control
power, and running at the center of the lane automatically by the function to support driving). Please correct
the course by an always own steering wheel control, and ..safe driving.. bear it in mind.
Knowledge
About parting with driving warning
The display of "[Pipi]", the buzzer sounding, and the multi information display
blinks when the system judges the steering wheel control not to be done in the lane maintenance
support function longer than the fixed time (About five seconds in the curve road
of about 15 seconds in the straight pathway) and it warns. At this time, the lane maintenance
support function is temporarily released.
- Warning might operate when driving to affix the hand to the steering
Blinking wheel lightly continues.
- In a road not smooth, time until warning operates might
become long.
422
Lane keeping assistance
Contents
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
423
Multi information display
When LKA is turned on, the state of the lane keeping assistance is displayed by the lane
display and the steering wheel display. The state of the lane maintenance support function is shown by the lane deviating
warning function and the steering wheel display in the lane display.
Lane display
The lane maintenance support function is provided in the state that can be begun.
[**]When the LKA switch is turned on or the radar cruise control is set
Steering
at 65 km/h or more, the lane maintenance support function is begun.
wheel
Knowledge
About the display
- When the velocity of the car has exceeded less than 50 km/h or about 120 km/h, the state of
the lane keeping assistance is not displayed on the multi information display. -
Please see P.386 about the display of the radar cruise control.
424
Lane keeping assistance
Contents
- Display example
At the lane deviating warning function Warning
The cognitive state etc. of ..white (yellow).. line are displayed by the lane display.
Display Content
At the velocity of the operation condition foreign-made car . earliness.. Basic
operation
When the velocity of the car is less than 50 km/h or about 120 [wakari]
km/h or more
When lane deviating warning function interrupts
- When you cannot recognize ..white (yellow).. line at 50-about 120 km/h Driving
Handling
the velocity of the car
- When you have temporarily released the lane deviating warning device
425
Lane deviating warning
The steering force is added for a short time, and a virtual warning does and draws attention to those
who drive by the electric power steering system through the steering wheel , saying that "[Pipipipipi]"
ringing, and blinking of the display with the multi information display, and drawing of the
buzzer sound the lane deviating warning when the system judges that it deviates from the lane the car's
running.
- At the lane deviating warning function - At the lane maintenance support function
Blinking Blinking
Knowledge
About warning
- The car position after about one second is presumed by the operation. The lane deviating warning might not operate
when the vehicle runs almost in parallel even if approaching ..white (yellow).. line. -
When the lane deviating warning operates in the lane maintenance support function, a virtual warning by the
electric power steering system is not done.
426
Lane keeping assistance
Contents
desk window glass). Please guard the following for operation with a correct lane
keeping assistance.
Camera for white line recognition . earliness.. Basic
operation
[wakari]
Driving
Handling
device
The
Handling indoor
equipment
One[Notoki]
Index
427
Alarm display (display when operation is limited and system display when it is abnormal)
When the following display is done by the multi information display, the
lane keeping assistance cannot be used.
"Pons" and the buzzer sound and are displayed "LKA cannot be done while confirming
the condition" when the lane keeping assistance or the electric power steering
system is the following state.
- The camera for white line recognition extremely is a high temperature or a low temperature, and when
the use of the lane keeping assistance is temporarily limited for the system protection, :.
- The electric power steering system must be doing the operation limitation, and when you
temporarily limit the use of the lane keeping assistance.
In this case, please turn off the system pushing the LKA switch, and make it
after a while to turning on again. If the release of the constraints that must be observed is confirmed by this
operation, it becomes a usual operating state.
It sounds, "LKA system check" is displayed, and the LKA pilot light blinks
to "Pons" and the buzzer when abnormality of the lane keeping assistance
system is detected.
In this case, please set it again after turning off the system pushing the LKA
switch, stopping in the place of safety, and stopping the engine once. If the normality
of the system is confirmed by this operation, it becomes a usual operating state. Please turn
off the system and receive the check in the Toyota shop when "LKA system
check" is displayed again. There is no obstacle in a usual running.
428
Lane keeping assistance
Contents
Warning
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
429
430
..PM page..431
4
Contents
Warning
Myriad
One[Notoki]
Index
431
Handling of air conditioner
How to use of the reception desk air conditioner.
Display part
Temperature adjustment
switch (driver side)
Airconditioning switch
Temperature adjustment
switch (passenger side) Turning off switch
If the AUTO switch is pushed, the fan operates, the balloon entrance and the amount of the style are adjusted
automatically, an air introduction and a shy circulation change automatically, and it becomes a preset temperature.
The AUTO switch is pushed. - It adjusts it with the temperature adjustment switch.
The operation pilot light of the switch When you lower the side when you raise it
lights while operating. [Ha] The side is pushed.
(0.5. can be adjusted. )-
The preset temperature can be
adjusted between 18. -32. .
[**]LO in case of maximum air-conditioning.
[**]It becomes a display of
HI if it maximum heats it. -
The preset temperature is displayed in the
display part.
432
Handling of air conditioner
Contents
Driving
Handling
It changes into a synchronization mode The driver's seat can be set to the indoor device
and an independent mode whenever the DUAL temperature for which it hopes because the driver's seat
switch is pushed. side switch and the passenger's seat push the
The
The operation pilot light passenger's seat side switch at an independent mode.
- When turning it off, the synchronization mode. Handling indoor
When lowering . side of the switch, equipment
- When lighting, it becomes an . side of the switch is pushed when
independent mode. raising it. (0.5. can be adjusted. )-
Respectively, an independent temperature can . good.. Safety
Display Mode [na] ・
be adjusted with the driver's seat in the of
[to] Comfortable
passenger's seat. theory
Synchronization mode
equipment
The driver's seat and the preset
temperature of the passenger's seat are made How and
the same by the driver's seat side to attention
Independent mode
Maintenance
The frog can independently do
the preset temperature of the
driver's seat and the passenger's seat.
Lighting Myriad
One[Notoki]
Index
433
The air conditioner is turned on. The fan is stopped.
The air conditioner (air-conditioning and The turning off switch is pushed. -
dehumidification function) changes into turning on and The fan can be
turning off whenever the airconditioning switch is stopped.
pushed while the fan is operating. -
The operation pilot light of the switch
lights while operating. -
When the outside temperature falls up to about
0. , the air conditioner doesn't operate.
434
Handling of air conditioner
Contents
Knowledge
Driving
When the temperature in the car is high Handling
Please operate the air conditioner after opening the window and letting heat go when the temperature in the car is high device
after parking.
The
About a convenient function
Handling indoor
equipment
When the AUTO switch has been turned on, the following functions are provided. -
The balloon entrance : again. The fan is stopped at a while until the warm air can be prepared
when it is [notoki] and winter, etc. cold. -
The balloon entrance : again. The fan between a few seconds is stopped until the cold wind can be prepared when it . good.. Safety
is [notoki] and the summer time, etc. hot. [na] ・
of
[to] Comfortable
theory
About the AUTO switch equipment
When the AUTO switch is turned on, the MODE switch (Refer to P.436) and the fan motor How and
switch If (Refer to P.436) is operated, the AUTO switch is turned off. to attention
associate
. drinking..
About the temperature adjustment car
- When the preset temperature is different in the driver's seat and the passenger's seat, it becomes it at the preset temperature on the driver side in the return
from an independent mode to the synchronization mode. -
It automatically changes into an independent mode if the passenger's seat side temperature adjustment switch is operated at the
Maintenance
synchronization mode.
Myriad
One[Notoki]
Index
435
To put it into the state of the favorite
Fan motor switch Display part Outside temperature degree display switch
MODE switch
Inside and outside nature switch switch
The frog of the amount of the wind. The frog of the balloon entrance.
The amount of the wind is switched to seven stages The balloon entrance is switched with
with the fan motor switch. the MODE switch. (Refer to next page. )-
When weakening it > side, < side is pushed The balloon entrance changes
when the amount of the wind is made strong. - whenever the switch is pushed. -
The amount of the wind that has been selected is The balloon entrance that has been selected
displayed in the display part. - is displayed in the display part.
The fan operates when the
switch is pushed when the fan
has stopped.
436
Handling of air conditioner
Contents
Driving
Handling
device
Display of display part
When you ventilate it to
The
one's upper-body and one's feet Handling indoor
equipment
. good.. Safety
* * * [na] ・
*
of
Display of display part * [to] Comfortable
theory
When you ventilate it equipment
associate
. drinking..
car
*Only when AUTO operates, it is ventilated.
Maintenance
Display of display part
When you take ventilation
to one's feet and the cloudy
Myriad
weather of the glass
One[Notoki]
Index
437
An air introduction and a shy
The cloudy weather of the glass is taken.
circulation are switched.
It changes into an air introduction and a shy The reception desk defroster switch is pushed,
circulation whenever the inside and outside nature and the inside and outside nature switch switch
switch switch is pushed. - is made an air introduction. -
The operation pilot light on the selected The fan operates automatically
side lights. when the switch is pushed while the
fan is stopping. -
Display Mode If the switch is pushed, the air
conditioner is automatically turned on. -
Air introduction The operation pilot light of the switch
Air has been lights while operating.
introduced. Please use
it at this position
< balloon entrance >
usually.
Shy circulation
Air is
intercepted. Please use it
when you want to improve the effect
of air-conditioning when the outside
temperature degree is high in time
when air like the tunnel and
congestion, etc. is dirty and wanting
air-conditioned early.
438
Handling of air conditioner
Contents
. earliness.. Basic
operation
[wakari]
The
Please do not push the reception desk defroster switch when you operate the
Handling indoor
air conditioner when humidity is very high. The surface of the outside of the window equipment
might disturb cloudy view by the temperatures fluctuate of air and the window.
. good.. Safety
Please do not operate it to prevent the battery rising while the engine is stopping. [na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
439
Knowledge
440
Handling of air conditioner
Contents
Knowledge
Warning
About the outside temperature degree display
- When the power supply is turned on, it is possible to display it. -
It might be different from the measured outside temperature degree according to other measurement devices. -
In the following cases, a correct outside temperature degree might not be displayed. . earliness.. Basic
operation
[**]At the time of 30. or less or about 50. or more in outside temperature degree. [wakari]
[**]When the time that has stopped and it low-speed runs (about 20 km/h or less).
[**]When the degree changes rapidly the outside temperature (vicinity etc. of the gateway of the tunnel). -
The outside temperature degree display might change by the state of the vehicle (velocity of the car and wind, etc.) even if
an actual outside temperature degree has not changed. Driving
Handling
device
About the operation sound of the motor
- This is normal operation, and is not abnormal though might blink when the engine switch is
turned on after the battery terminal is detached the pilot light of the reception desk defroster The
switch, and hear the operation sound of the motor. - Handling indoor
equipment
This is normal operation, and not a breakdown though the operation sound of the motor might be heard after a few seconds in
the place where the power supply is made from turning on to turning off.
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
441
How to use of the pollen removal switch.
A beautiful wind that passed the filter is ventilated from the center, the left side, and the right balloon entrance
to the surrounding of the face, [no] car and the door ..lowering.. glass are opened, and the entered pollen is removed to the
car room to running etc. at the early stage.
It changes into the pollen removal mode if the switch is pushed, and it usually returns to the control
when pushing again. -
The operation pilot light of the switch lights at the pollen removal mode. -
It usually automatically returns to the control when pollen in the car room is removed.
(Will usually return to the control in about one minute when the outside temperature is low about three minutes later usually. )
[**]When using it with the fan doesn't operate, it becomes AUTO
control.
Knowledge
About the operation condition
When the power supply is turned on, it is possible to use it.
442
Handling of air conditioner
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
How to open and shut how to change it and balloon entrance of wind The
Handling indoor
equipment
Central balloon entrance Right and left balloon entrance
. good.. Safety
Opening [na] ・
of
[to] Comfortable
Dial theory
equipment
How and
to attention
Knob Close
associate
. drinking..
car
- The wind can be adjusted by moving the knob at the balloon entrance. -
The balloon entrance can be opened and shut by spending the dial at the right and left balloon entrance.
Maintenance
Knowledge
About the balloon entrance
Myriad
At air-conditioning, this is the one that occurs when the air saturated with moisture is suddenly cooled and is
not unusually abnormal though might seem to have spouted from the balloon entrance the fog. One[Notoki]
Index
443
Tapir
Plasma cluster How of [tsuka] for being * drinking
Ventilation from the balloon entrance of the air conditioner (driver's seat side balloon entrance) contains
the plasma cluster ion, and the air quality in the car is straightened.
To operate
The plasma cluster operates automatically when the fan operates. -
A clean mode and the ion control mode change automatically every
about 15 minutes. -
The mode is displayed in the air conditioner display part.
To stop operating
444 - As for the sign, the presence of the installation is different depending on the grade etc.
Handling of air conditioner
Contents
This is not generated when the electron collides with the electrode when the plasma cluster ion is
How and
generated, and no breakdown though a slight operation sound might be generated when the plasma cluster to attention
ion generator operates. -
associate
. drinking..
About plasma cluster ion/negative air ion car
The plasma cluster ion is called, "Except bacterium ion", and controls the activity of the mold that
floats in the car. -
Generally, the negative air ion exists a lot in air the mountain stream, the forest part, and the waterfall, etc.
peripheral, and is assumed to give the person the relief. - Maintenance
I might feel static electricity in the vicinity of the balloon entrance because it operates by a very high voltage.
Myriad
One[Notoki]
Index
445
How to use of [riyaeakon].
REAR switch
Please refer to "Adjustment of the [riya] balloon entrance" of P.454 for the balloon
entrance of [riyaeakon].
446
Handling of air conditioner
Contents
To switch the operation mode from the front seat operation part Warning
. earliness.. Basic
operation
[wakari]
Whenever the REAR switch in the front seat operation part is pushed, the operation mode
can be switched to the reception desk air conditioner mode or [riyaeakonmo-do]. Driving
Handling
device
Maintenance
Knowledge
About the front seat display part
It returns to the reception desk air conditioner mode if it doesn't operate it for about six seconds in making Myriad
it to [riyaeakonmo-do] pushing the REAR switch.
One[Notoki]
Index
447
How to use usually.
Front seat operation part Front seat display part AUTO switch
AUTO switch
Temperature adjustment switch
448
Handling of air conditioner
Contents
. seat switch . . rear seat switch . . seat switch . . rear seat switch .
. earliness.. Basic
operation
[wakari]
It adjusts it with the temperature adjustment switch. The turning off switch is pushed. - Driving
Handling
When lowering the upper part, the lower side Operation can be
is pushed when raising it. stopped. device
associate
Knowledge . drinking..
car
About the operation condition of the air conditioner
Air-conditioning and the dehumidification function do not operate, and are ventilated when the reception desk air conditioner has stopped.
Maintenance
Myriad
One[Notoki]
Index
449
To put it into the state of the favorite
It is possible to use it by each setting by pushing each switch.
MODE switch
The frog of the amount of the wind. The frog of the balloon entrance.
. seat switch . . rear seat switch . . seat switch . . rear seat switch .
The amount of the wind is set with the fan motor switch. The balloon entrance is selected with
The amount of the wind can be switched to the MODE switch.
seven stages. The balloon entrance changes whenever
When the amount of the wind is made strong, the improvement side. the switch is pushed.
When weakening it, the down side is pushed. - (Refer to next page. )
The amount of the wind is displayed in the display part.
450
Handling of air conditioner
Contents
Driving
Handling
device
The
How and
to attention
associate
. drinking..
When you ventilate it car
to one's feet
Maintenance
Myriad
One[Notoki]
Index
451
How to use of [riyaku-ra-].
REAR switch
Please refer to "Adjustment of the [riya] balloon entrance" of P.454 for the balloon
entrance of [riyaku-ra-].
452
Handling of air conditioner
Contents
[Riyaku-ra-] is
The frog of the amount of the wind.
turned on.
. earliness.. Basic
operation
[wakari]
Driving
Handling
The REAR switch in the front seat operation part It adjusts it with fan adjustment lever in the
device
is pushed while the reception desk air conditioner rear seat operation part. -
is operating. - The amount of the wind can be switched
It is displayed in the front seat display to four stages. The
part while operating as "RE AR". - Handling indoor
equipment
To stop the operation of
[riyaku-ra-], the REAR switch
is pushed again.
. good.. Safety
[na] ・
of
[to] Comfortable
theory
Please do not operate it to prevent the battery rising while the engine is stopping. equipment
How and
to attention
Knowledge
associate
. drinking..
About the operation condition of the air conditioner car
Air-conditioning and the dehumidification function do not operate, and are ventilated when the reception desk air conditioner has stopped.
Myriad
One[Notoki]
Index
453
Adjustment of [riya] balloon entrance
[Riyaeakon] and [riyaku-ra-] balloon entrance
The wind can be adjusted by moving the knob at the balloon entrance.
Knowledge
About the balloon entrance
At air-conditioning, this is the one that occurs when the air saturated with moisture is suddenly cooled and is
not unusually abnormal though might seem to have spouted from the balloon entrance the fog.
454
Handling of air conditioner
Contents
Warning
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate . drinking..
car
Maintenance
Myriad
One[Notoki]
Index
455
Handling of ETC -
The ETC(Electronic Toll Collection) system is a system that adjusts the charge
by the automatic operation to pass the tollway smoothly.
The wireless is communicated between ETC units of a road side wireless device and the vehicle, and the charge
is pulled down from the bank account that the customer registered later.
[**]
[**]/[**]
[**]
[**]
456 - As for the sign, the presence of the installation is different depending on the grade etc.
Handling of ETC
Please note the following points when you use the ETC system.
Neither pulling out opening of the ETC card nor those who drive must operate the ETC Warning
unit as much as possible for safety while running.
The operation under running might cause an unexpected accident as the steering wheel control is
mistaken and is dangerous. Please operate it after stopping the car.
. earliness.. Basic
operation
[wakari]
Please note cutting of the expiration date of the ETC card. Driving
Handling
Please note cutting of the expiration date of the ETC card. The opening and shutting bar doesn't open device
when the ETC card is expired. Please confirm the expiration date described in ETC card on
hand beforehand.
The
Handling indoor
equipment
After inserting the ETC card
Please confirm the insertion of the ETC card surely, and
the normal operation. . good.. Safety
[na] ・
- Please confirm the insertion of the ETC card in the ETC unit surely of
[to] Comfortable
beforehand, and the ETC unit operate normally when you use ETC. - theory
The insertion of the ETC card in this side of the toll gate might cause the error by the time the equipment
ETC unit attests the ETC card because it borrows for a few seconds.
How and
to attention
associate
. drinking..
When passing over the toll gate car
Going into of the ETC lane must go into it at a safe enough speed at the
distance between two cars and about 20 km/h or less.
Maintenance
- Going into of the ETC lane must go into it at a safe enough speed at the distance between two cars and about 20
km/h or less. -
Please it is likely not to open in the opening and shutting bar set up in the ETC lane when
the communication between the communication or the ETC unit and the ETC card between the ETC Myriad
unit and the antenna is not normally done. -
Please pass after confirming it decelerates enough to stop safely in this side of the opening and shutting bar after the One[Notoki]
distance between two cars with the preceding vehicle is maintained, and the opening and shutting bar opened when you pass in
the ETC lane.
Index
457
How to use of ETC.
In this book, it explains only the operation of the ETC unit of the manufacturer
option. As for the installation of this ETC unit together with the HDD navigation system, a
present setting change etc. of the display and ETC of the state, the ETC registered information
of the ETC system, and the use history can be done on the screen of the HDD navigation
system. Please see "HDD navigation system manual" of the separate volume in
detail.
About the ETC unit
The ETC unit is in the driver's
seat upper box.
ETC unit
Please do not put the foreign body etc. in the ETC unit.
- Please do not put the foreign body etc. in the ETC unit. The ETC unit might
break down. -
Please do not strike close to home to the ETC unit. The ETC unit might break down, and
be damaged. -
Please do not touch the ETC unit by a wet hand, and put water (liquid etc.). Water
enters in the ET C unit, and it is likely to break down and to damage it. -
Please wipe dirt off with a soft, dry cloth when becoming dirty. Please never use
wax, thinner, and alcohol, etc.The ETC unit might be transformed and
break down. -
The opening and shutting bar at the gate might not open when two or more ETC units are installed
in one vehicle.
458
Handling of ETC
Contents
Knowledge
Warning
About the operation condition
When the power supply is ACC or is turned on, it is possible to use it.
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
459
Name of each part
- About the ETC unit
Use history confirmation switch
Speaker
Green lamp
Bitter orange lamp
ETC card
Knowledge
About the ETC card
- It is necessary to apply to the ETC card by the customer oneself. Please consult the Toyota
shop in detail. -
Please note the theft and the loss of the ETC card. Please contact the ETC card issuer at once
when the theft and it is lost by any chance.
460
Handling of ETC
Contents
When using it
- Operation when getting on Warning
- Some errors occur when the bitter orange lamp blinks. One[Notoki]
Please see "Union error code list" (Refer to P.469) in detail.
Index
461
- Operation when getting off
ETC card
2 The ETC card is pulled out from the
ETC unit.
Please do not pull out the ETC card while a green lamp is blinking.
- Please do not pull out the ETC card while a green lamp is blinking. Data in the ETC card
might be damaged. -
Please do not use it excluding the ETC card regularly issued. -
Please insert the ETC card firmly in a correct direction of insertion. -
The bitter orange lamp blinks when the error occurs on the ETC unit and the ETC card.
Please correspond according to the situation as follows.
[**]Union error code (01-07) must follow treatment described in .."Union error
code list. " and (Refer to P.469) when the voice is output...
[**]Please stop the engine once, and start again when the error occurs when the
engine starts. Still, please receive the check in the Toyota shop when the error continues.
[**]Please pull out the ETC card once, confirm the direction of insertion, and insert it again
when the error occurs when the ETC card is inserted. Still, please receive the check in the Toyota
shop when the error continues. -
Please do not part from the car leaving the ETC card.
The ETC card might be transformed by the rise in heat in the car, and data in the
ETC card be damaged.
462
Handling of ETC
Contents
- When you can normally do the adjustment processing at the ETC gate
The
When abnormality is found in the operation of ETC Handling indoor
- When you insert a card different from the equipment
Bitter orange lamp: Blinking
ETC card
- When the inserted ETC card is correct and it is not
recognized . good.. Safety
- When abnormality is found in the ETC system [na] ・
of
- When it was not possible to communicate normally at the ETC gate [to] Comfortable
- When you cannot do the adjustment processing at the ETC gate theory
equipment
- When abnormality is found in the antenna of ETC
How and
Bitter orange lamp: Lighting to attention
Maintenance
Myriad
One[Notoki]
Index
463
Knowledge
About the handling of the ETC card
- Please do not part from the car leaving the ETC card. The ETC card might encounter
the theft. -
Please close the driver's seat upper box to prevent the theft when you have
inserted the ETC card. -
Please contact the ETC card issuer promptly when you lose the ETC
card.
464
Handling of ETC
Contents
- The ETC gate (entrance) and examination of tickets place and previous notice antenna/ETC card . earliness.. Basic
uninsertion information antenna are passed. operation
[wakari]
Previous notice antenna/ETC - Only "[Pi]" and the sound are heard and a
card uninsertion information antenna green lamp remains lighting when the communication
ETC gate (entrance) and examination of tickets place is normally done. - Driving
Handling
The bitter orange lamp blinks if the
device
communication is not normally done.
Vehicle Vehicle
"Error 00* that cannot
use [pi-] ETC" The voice outputs it solving. The
Traveling direction
[Remasu]. Handling indoor
In this case, please tell the toll gate equipment
How and
to attention
Please do not pull out the ETC card in the ETC gate and the vicinity of the examination
associate
of tickets place and the previous notice antenna. . drinking..
car
Please do not pull out the ETC card in the ETC gate and the vicinity of the examination of tickets place and the previous notice antenna. Data
in the ET C card might be damaged.
Knowledge Maintenance
465
- The ETC gate (for exit/adjustment) is passed.
Please decelerate enough when the ETC gate goes into it.
- Please decelerate enough when the ETC gate goes into it. -
Please run according to the guide displayed in the vicinity of the ETC gate when you pass the
ETC gate. -
Please follow the toll gate clerk in charge's instruction when the opening and shutting bar at the ETC gate doesn't open. -
Additionally, please follow use that the road entrepreneur issues. -
Please do not pull out the ETC card in the ETC gate and the vicinity of the examination of tickets place and the previous notice antenna.
Data in the E TC card might be damaged. -
When neither the ETC gate (entrance and exit) nor the examination of tickets places are normally communicated,
the bitter orange lamp blinks and the voice is output to union error code (01-07). Please follow
treatment described in "Union error code list" (Refer to P.469).
Knowledge
About the voice guide of the toll fee
The toll fee guided by the voice might be actually different according to the discount etc.
466
Handling of ETC
Contents
Knowledge
Warning
When you pass the ETC gate
- Please pass over the ETC gate (for exit/adjustment) or the examination of tickets place with the
ETC card used at the ETC gate (entrance). -
It is set up forward, and the previous notice antenna communicates with the ETC unit, and is an antenna . earliness.. Basic
of the toll gate to notify those who drive beforehand whether the ETC gate can be used through the operation
[wakari]
ETC unit. The previous notice antenna might not be being set up by the system on the road side in
the case to be set up. -
When it is set up forward, and it communicates with the ETC unit, and the ETC card of the toll gate
has not been inserted correctly, the ETC card uninsertion information antenna is an antenna to notify
Driving
those who drive beforehand through the ETC unit. The ETC card uninsertion information antenna might Handling
not be being set up by the system on the road side in the case to be set up. device
Please do not confirm the use history in the ETC gate and the vicinity of the examination Maintenance
of tickets place and the previous notice antenna.
Please do not confirm the use history in the vicinity of the ETC gate. It becomes impossible to communicate
with a road side wireless device. Myriad
One[Notoki]
Index
467
Knowledge
About the use history
- Because the use history is recorded on the ETC card, the maximum record number is different according to
the ETC card used. -
When the maximum record number of use histories is exceeded, the oldest use history is deleted. -
When there is no use history"There is no use history. " It is guided.
- When information on the use day is not correct"The use date is uncertain. "It is guided.
- When information on the toll fee is not correct "The charge is uncertain. "It is guided.
The volume
Volume adjustment switch
- When enlarging it, the side of the switch.
- When reducing it, the side of the switch.
[Wo] is pushed. -
Knowledge
About the volume adjustment
When you set the voice guide to discontinuance (volume 0)
- "The voice guide is discontinued. "The voice is output. -
When the error occurs, the voice is output by volume 1. -
The notification that the ETC unit unsets up is
not output.
468
Handling of ETC
Myriad
One[Notoki]
Index
469
Code Abnormal state Assumed factor Treatment
Knowledge
About the union error code
- When communicating with the ETC card uninsertion information antenna etc. "Error 07" With notification [sareruko]
No breakdown of the ETC unit though there is a fault. -
A wireless communication of the ETC unit is used, and the parking management system is operated. When you
do a communication different from the charge payment of the tollway
"Error 01" Or, "Error 07" With the notification
No breakdown of the ETC unit though it is likely to be done.
470
Handling of ETC
Contents
Use history confirmation switch 1 The ETC card is pulled out. . earliness.. Basic
operation
[wakari]
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
471
How to use of the indoor fixture.
Sun visor Cigarette writer
Cigarette writer
Sun visor
Knowledge
About the operation condition
When the power supply is ACC or is turned on, it is possible
to use it.
472
How to use of the indoor fixture.
Ashtray Contents
Protector
[Sekandoshi-to] . earliness.. Basic
Cap operation
- Bottle holder of slide door [wakari]
(Refer to P.491. )
Driving
Handling
device
- When using it, the cap is
opened pushing. -
When detaching it, the The
protector is detached while suppressed. Handling indoor
equipment
Third seat
- [Riya] - Bottle holder of quarter trim
. good.. Safety
(Refer to P.491. ) [na] ・
Cap
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
When using it, the cap is caused
and opened.
Maintenance
473
Clock
M button
:00 buttons
H button
Knowledge
About the display of the clock
- The power supply is displayed and time of turning on is displayed. -
In the following cases, operation begins for 0 seconds though there is no second display.
[**]When you separate the hand from M button after the amount is adjusted pushing M button
[**]:When you push 00 buttons
474
How to use of the indoor fixture.
Cap
Warning
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
associate
. drinking..
car
Knowledge
About the accessories socket
- When the power supply is ACC or is turned on, it is possible to use it. - Maintenance
Please use an electric product of 10A or less in maximum current (maximum power consumption 120W) for
the electric product used with DC12V. -
The vehicle fuse might cut if an electric product that exceeds regulated capacity is used.
Myriad
One[Notoki]
Index
475
Central table
Cup holder
476
How to use of the indoor fixture.
. earliness.. Basic
operation
[wakari]
Room lamp switch
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
477
[Riyapa-sonaruranpu]
[Sekandoshi-to] and the upper part of third seat
Switch
- It lights when the switch is pushed, and it turns it off when pushing again. -
The room lamp switch of a reception desk personal lamp on earth lights to
the room lamp when the slide door is opened when D OOR is located.
Please refer to "[Irumine-teddoentori-shisutemu]" of P.480 for
detailed operation.
OFF
Switch
ON
It lights when the backing door is opened when the switch is turned on, and it turns it
off when closing.
478
How to use of the indoor fixture.
Contents
[Doaka-teshiranpu] *
Reception desk door Warning
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
Lamp
It turns it off when lighting when the reception desk door is opened, and closing. The
Handling indoor
equipment
Reception desk floor circumference lighting
. good.. Safety
[na] ・
Lighting of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Please do not light it for a long time to prevent the battery rising while the engine
is stopping.
Myriad
Knowledge
One[Notoki]
About the operation condition
It is possible to use it regardless of the state of the power supply.
Index
- As for the sign, the presence of the installation is different depending on the grade etc. 479
[Irumine-teddoentori-shisutemu]
About [irumine-teddoentori-shisutemu]
The system that lights and turns off the lighting of each part by the position of the state of the opening and shutting
of the lock, unlocking the door lock, and the door and power supplies and gear-shifts.
480 - As for the sign, the presence of the installation is different depending on the grade etc.
How to use of the indoor fixture.
Contents
Method of operation
The following operation is an example when only one condition consists. Actually, it might be Warning
different from the following operation according to consisting of some conditions at the same time.
smart When you Lighting . turning off Lighting . turning off device
key lock either
(The backing door is excluded. ) Turning off . of the state remains. Turning off . of the state remains.
When you The
open either Turning off . lighting Turning off . lighting Handling indoor
(The backing door is excluded. ) equipment
Door When you
close everything It will turn it off in about 15 seconds. It will turn it off in about 15 seconds.
(The backing door is excluded. ) . good.. Safety
[na] ・
Lighting . turning off Turning off turning off . of the of
OFF. ACC [to] Comfortable
Turning off . of the state remains. state will remain in about 15 seconds. theory
equipment
engine is rotating .. 15-turning off second like the state. It will turn it off in about 15 seconds.
Maintenance
Position
of [**][Kara][**]以外 Myriad
Like the state It lights with lighting . do decrease in lights.
[Nishitatoki]
gear-shift One[Notoki]
Index
481
Storage space
Button
Glove box
It pulls a lever and it opens it. -
When closing, it closes surely until
"[Kachi]" and the sound are heard.
Lever
482
How to use of the indoor fixture.
Contents
. earliness.. Basic
operation
[wakari]
device
Driver's seat under box
The switch is pulled and opened. - The
When closing, it closes surely. Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
Switch equipment
How and
to attention
Please do not run with the cap of the storage box opened.
associate
. drinking..
- Please do not run with the cap of the storage box opened. car
It dashes out when slamming on the brakes luggage, might cause an unexpected accident, and is
dangerous. -
Please do not open and shut the cap to the driver's seat upper box while running. Especially, please
neither putting the hand in the steering wheel nor open the cap. It interferes to the steering wheel Maintenance
control, might cause an unexpected accident, and is dangerous.
Myriad
One[Notoki]
Index
- As for the sign, the presence of the installation is different depending on the grade etc. 483
Triangular emergency sign storage space
The spare tire installation car of the shop installation option is excluded.
Storage space
Hole part A
2
Part A
The strap for fixation is inserted in the hole.
Part A of the strap for fixation is inserted
in hole part A. -
The strap for fixation is in
the tool bag. -
Part A It is not necessary to make a mistake in
the hole that inserts part A.
484
How to use of the indoor fixture.
Contents
Please confirm the triangular emergency sign is surely fixed when you store the triangular
emergency sign in the triangular emergency sign storage space. It dashes out when slamming on The
the brakes if not fixed surely the triangular emergency sign, might cause an
Handling indoor
unexpected accident, and is dangerous. equipment
Knowledge
. good.. Safety
[na] ・
About storage of
[to] Comfortable
It is not likely to be able to store it according to the size and the shape of the case with the triangular emergency sign. theory
equipment
Maintenance
Myriad
One[Notoki]
Index
485
..PM page..486
Storage pocket
Please put neither one that rolls easily in the storage pocket nor the one from
concave with height.
It dashes out what put when the sudden braking and rapidly turning, might cause
an unexpected accident, and is dangerous.
486
..PM page..487
Small putting
Warning
Lever
. earliness.. Basic
operation
[wakari]
Driving
Handling
Small putting device
. good.. Safety
[na] ・
Table of
[to] Comfortable
theory
equipment
Top board
How and
to attention
associate
. drinking..
car
Maintenance
One[Notoki]
Index
- As for the sign, the presence of the installation is different depending on the grade etc. 487
..PM page..488
The long slide console when you do the slide back and forth
Lever
488
..PM page..489
Contents
Please do not run with the cap of small articles putting opened.
Warning
- Please do not run with the cap of small articles putting opened. It dashes out when slamming on the
brakes luggage, might cause an unexpected accident, and is dangerous. -
Please do not put the one other than the cup and the beverage can in the cup holder. It dashes out when
time that slammed on the brakes and colliding stored what, might injure, and is dangerous. Moreover, . earliness.. Basic
operation
please close the cap when you do not use it. - [wakari]
Please do not use the table while running. The thing dashes out when slamming on the
brakes when running with the thing put on the table, and it might cause an unexpected accident.
Driving
Handling
device
Please do not spill the juice etc. of the cup and the beverage can of the
cup holder (Refer to P.490) in the console when you operate the slide
of the long slide console. The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
489
..PM page..490
Cup holder
Cap
When the cap is pushed, it opens. - The cup holder is drawn out in the direction
It is possible to adjust it by of figure. -
matching the width of the holder to the It is possible to adjust it by
size such as cups. - matching the width of the holder to the
Please store it when you do size such as cups. -
not use it. Please store it when you do
not use it.
It is in the armrest. -
Please store the armrest when
you do not use it. -
The cup holder for [sekandoshi-to] of
seven person getting on car is in a central
table. (Refer to P.476. )
Please do not put the one other than the cup and the beverage can in the cup
holder for what stored when time that slammed on the brakes and colliding to
dash out, and might injure. Moreover, please store it when you do not
use the cup holder.
Please ..hand.. do not attach to the cup holder to defend the cup
holder from damage.
490
..PM page..491
. earliness.. Basic
operation
[wakari]
Driving
Handling
It is on the reception desk door (both sides). It is on the slide door (both sides).
device
- Third seat
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
associate
Please do not store the glass etc. the paper cup and made of the glass that includes . drinking..
car
the juices etc. when time where it runs and you open and shut a door. The juice
etc. might spill, and glassware crack.
Knowledge Maintenance
Index
491
..PM page..492
Hook
492
..PM page..493
Warning
. earliness.. Basic
operation
Coat hook [wakari]
device
Please put a suspender or neither heavy one nor sharpened what on the
coat hook. Please give directly to the coat hook without using the suspender
The
when you wear clothes.
Handling indoor
It flies when the SRS curtain shield air bag develops, might cause equipment
an unexpected accident, and is dangerous.
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
493
..PM page..494
Deck board
Deck board
Knob
494
..PM page..495
Contents
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
The
Please do not run with the deck board opened. It dashes out when slamming Handling indoor
on the brakes luggage, might cause an unexpected accident, and is dangerous. equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
495
..PM page..496
Accessories outlet *
Main switch
Cap
496 - As for the sign, the presence of the installation is different depending on the grade etc.
..PM page..497
Contents
- Please remove the plug of an electric product from the outlet, and close the cap when you
do not use the accessories outlet. It enters the outlet the foreign body or the drinking water
etc. splash, and might it break down, and it be short. - . earliness.. Basic
The battery might go up when using it for a long time with the engine stopped. Moreover, operation
[wakari]
the battery might go up when using it for a long time while idling even if
it engines starts. -
Please do not connect the AC adaptor directly with the accessories outlet. The cap might
be damaged, and the AC adaptor drop out. Driving
Handling
device
Knowledge
About the operation condition The
When the power supply is turned on, it is possible to use it. Handling indoor
equipment
Myriad
One[Notoki]
Index
497
..PM page..498
498
..PM page..499
Contents
Warning
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
499
..PM page..500
500
..PM page..501
5
Contents
Index
501
-
SRS Air bag
What is the supplemental restraint system airbag?
Wearing a good posture and a correct seat belt is the absolute requirements for the supplemental restraint
system airbag to demonstrate the effect of the supplemental restraint system airbag by the one to assist the seat
belt to the last with the auxiliary equipment of the crew protection.
Moreover, the effect might not only be demonstrated when an effective supplemental restraint
system airbag also does wrong handling if it correctly handles it but also the danger of injury or the
death is rather given to the crew.
502
Supplemental restraint system airbag
Contents
The SRS side air bag and the SRS curtain shield air bag on the side where the impact was
received swell when the SRS side air bag and the SRS curtain shield air bag receive the high
impact for the grievous harm to reach the crew in a reception desk seat, [sekandoshi-to], . earliness.. Basic
operation
and a third seat right and left seat from the side to the vehicle guest room. The SRS [wakari]
side air bag along with working to which the seat belt restrains the body works to distribute
and to ease the impact power that the reception desk seat and the [sekandoshi-to] right and
left seat crew chiefly act on the head as for the SRS curtain shield air bag in the upper Driving
Handling
part of the body such as reception desk seat crew's chests.
device
Driver's seat SRS [ni-eabaggu] improves driving person's protection effect by distributing the impact
that acts on the knee etc. aiming at, and unifying making of driving person's behavior and an aptitude
the decrease of injury, and easing it. The
The SRS side air bag and the SRS curtain shield air bag swell even Handling indoor
if there is no crew. equipment
How and
to attention
associate
. drinking..
car
Myriad
One[Notoki]
Index
- As for the sign, the presence of the installation is different depending on the grade etc. 503
Mechanism of operation of supplemental restraint system airbag
It becomes impossible for the sensor to perceive the impact normally when the grill guard etc. are installed
forward of the vehicle and normal operation of the supplemental restraint system airbag might be ruined.
504 - As for the sign, the presence of the installation is different depending on the grade etc.
Supplemental restraint system airbag
It operates when there is a high impact to which the crew who has correctly worn the
seat belt might receive important injury, and it is not easy to operate by the impact
Warning
with a little fear to receive important injury.
When operating
When the high impact for the grievous harm to reach from the
. earliness.. Basic
direction the crew is received within about 30. in a vehicle operation
[wakari]
forward right and left, it operates.
The SRS side air bag and the SRS curtain shield
air bag operate when the high impact for the Driving
Handling
major obstacle to reach from the direction of the
device
vehicle side the crew is received.
The
Handling indoor
equipment
One[Notoki]
Index
- As for the sign, the presence of the installation is different depending on the grade etc. 505
Because the impact by the collision is loosened in the following cases, it is likely not
to operate.
- When the under of the carrier of the track etc. slip
and it collides.
- When you receive the impact from the person before the diagonal.
The operating velocity of the car rises because the impact by the collision is loosened
when colliding what is transformed or it moves.
506
Supplemental restraint system airbag
Contents
- SRS side air bag and SRS curtain shield air bag
When the impact that the following bodies receive is weak, it is likely not to operate.
Warning
. earliness.. Basic
operation
[wakari]
Driving
Handling
- When you receive the impact to sides other than the guest room.
device
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
507
When you do not demonstrate an original effect
An original effect is not demonstrated though it is likely to operate in the following cases.
- When you receive the impact from the side and the rear side.
(driver's seat and passenger's seat supplemental restraint system airbag)
- When it falls in the deep hole and the ditch or it gets it over.
508
Supplemental restraint system airbag
Contents
How and
to attention
associate
. drinking..
car
[**]Please start not leaning against the door, and do not approach the reception desk pillar, the rear pillar,
the roof side part, and the ceiling. The high impact is received to the head etc. when the SRS side
air bag and the SRS curtain shield air bag swell, the important injury related to the life Maintenance
might be received, and it is dangerous. Especially, be careful when the child is taken.
Myriad
One[Notoki]
Index
509
Please guard the following items to demonstrate the effect of the
supplemental restraint system airbag enough.
[**]Please do not run with the one put with the crew as the one is held on the knee between supplemental
restraint system airbags. Normal operation of the supplemental restraint system airbag is disturbed, and the important
injury related to the life might be received and it is dangerous the flight of the one when the supplemental restraint system
airbag swelled and striking to the face, and. -
Please guard the following when you take the child. In the worst case, it reaches the
important injury related to the life in a strong impact when the supplemental restraint system airbag swells if it doesn't
defend or, it is likely to lead to the death.
[**]The child must make it sit on the rear seat, and let me wear the seat belt.
[**]Please install the seat only for the child in the rear seat and use it for a small child who
cannot correctly wear the seat belt.
[**]Please never install the seat only for the child in the passenger's seat for [ushiro]. The high impact
joins the back of the seat only for the child when passenger's seat SR S air bag swells and it is dangerous.
Please ..adjustment position.. install [ushironishite] most before and behind the seat when it unavoidably keeps
positive and the seat only for the child is installed in the passenger's seat.
[**]Please do not run in the state that makes the child stand in front of the passenger's seat supplemental restraint
system airbag, and holds on the knee.
510
Supplemental restraint system airbag
Contents
Driving
Handling
device
The
Handling indoor
equipment
[**]Please consult the Toyota shop about the SRS side air bag installation car when detaching, the installation, the
resolution, and the repair, etc. of repapering and the reception desk seat of the epidermal of the reception desk
seat are necessary. Moreover, please do not remodel the reception desk seat.
. good.. Safety
[**]The SRS curtain shield air bag installation car must not resolve and repair the detaching surrounding [na] ・
of
of the reception desk center rear pillar, the roof side part, and the ceiling of the SRS of the installation [to] Comfortable
etc. curtain shield air bag development department. theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
[**]Please do not remodel the suspension. When height changes or the hardness of the suspension changes,
it causes the mis-operation of the supplemental restraint system airbag.
[**]Please do not repair the front of the vehicle or the vehicle guest room. The impact transmitted to the SR S
air bag sensor changes if an improper repair is done, and the supplemental restraint system airbag doesn't operate Myriad
normally.
One[Notoki]
Index
511
Please guard the following items to demonstrate the effect of the
supplemental restraint system airbag enough.
- Please guard the following when you install the car articles etc.The supplemental restraint
system airbag might not operate normally, and it reaches important injury by swelling by mistake or, in the
worst case, it lead to the death if it doesn't defend.
[**]Please do not cover the middle paragraph of the supplemental restraint system airbag with the cover and the sticker, etc.
Sticker
Sticker
[**]Please do not put the one of the aromatic substance etc. on the Instrument panel, and do not lean the
umbrella etc.It flies when the passenger's seat supplemental restraint system airbag doesn't operate normally or
it swells and is dangerous.
[**]Please do not install accessories etc. around the SRS [ni-eabaggu] development department
under the Instrument panel. It flies when SRS [ni-eabaggu] swells and is dangerous.
SRS [ni-eabaggu]
512
Supplemental restraint system airbag
Contents
Driving
Handling
device
SRS side air bag development department
The
[**]The SRS side air bag installation car must not install the car articles such as the cup holders in the
Handling indoor
reception desk door and the circumference. It flies when the SRS side air bag swells and equipment
is dangerous.
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
[**]The SRS curtain shield air bag installation car must not install accessories hands-free to attention
mike suspenders etc. around the SRS curtain shield air bag development department such associate
as the reception desk window glass, the side door glass, the reception desk center rear . drinking..
car
pillar, the roof side part, assist grip, and ceilings. It flies when the SRS curtain
shield air bag swells and is dangerous.
SRS curtain shield air bag
development department
Maintenance
Myriad
One[Notoki]
Index
513
Please guard the following items to demonstrate the effect of the
supplemental restraint system airbag enough.
[**]The electric wave etc. of the wireless machine might negatively affect the computer that operates the
supplemental restraint system airbag, and consult the Toyota shop, please when you install the wireless
machine etc.
[**]Please consult the Toyota shop when you install the grill guard and the winch, etc. in the front of the
vehicle. The impact transmitted to the supplemental restraint system airbag sensor changes if the front of the vehicle is
remodeled, and it causes the mis-operation of the S RS air bag. -
The supplemental restraint system airbag development department such as the upper part of the steering wheel pad
Instrument panel must not be overpowered as the strong beating etc.The supplemental restraint system airbag doesn't operate
normally, and it reaches important injury or, in the worst case, it is likely to lead to the death. -
It is not necessary to touch the supplemental restraint system airbag composition parts immediately after the supplemental restraint system airbag's having swollen.
Important injury such as the burns might be received because complete parts are very hot and it is
dangerous.
There is even when the supplemental restraint system airbag operates normally
in the following cases.
- Because the supplemental restraint system airbag swells at a very fast speed, the bruise file wound etc. might be
received by contact with the supplemental restraint system airbag.
- No fire though the gas like white smoke is generated with the operation sound if the supplemental restraint
system airbag operates. If this gas is breathed in, the person who has details for the respiratory system such as asthma
to suffer occasionally becomes painful breath.
In this case, please confirm it is safe even if the crew goes out outside the car, and go out outside the car. Please
open the window and the door and put fresh air when it is not possible to go out outside the car.
Moreover, please flush it in water as soon as possible when traces (Cass etc.) when the supplemental restraint
system airbag operates adhere to eyes and the skins. The person to whom the skin is weak occasionally stimulates his
skin unusually.
514
Supplemental restraint system airbag
Contents
There is even when the supplemental restraint system airbag operates normally
in the following cases. Warning
- Because the passenger's seat supplemental restraint system airbag swells when colliding, the reception
desk window glass of the vehicle might be damaged. -
The supplemental restraint system airbag that operates once doesn't operate again in the collision since the second times. Please exchange
it in the Toyota shop. The supplemental restraint system airbag doesn't operate in the second collision if the . earliness.. Basic
operation
supplemental restraint system airbag operates by the first collision when colliding similarly continuously. - [wakari]
Please consult the Toyota shop when you abandon the car and the supplemental restraint system airbag. The supplemental
restraint system airbag operates unexpectedly, and it is likely to injure. -
Please do not use as it is and exchange it in the Toyota shop when the pad, the reception desk pillar,
Driving
the rear pillar, and the roof side part where the supplemental restraint system airbag is stored have been Handling
damaged or there is a crack. When colliding, the supplemental restraint system airbag normally doesn't operate,
device
and be likely to be injured.
Roof side part
Reception desk pillar
Pad Rear pillar
The
Handling indoor
equipment
. good.. Safety
[na] ・
Pad of
[to] Comfortable
- When the engine stops and the supplemental restraint system airbag operates, the fuel pump control operates, the fuel theory
equipment
delivery is stopped, and the fuel leakage is pressed to the minimum. After it is confirmed enough that there is no fuel leakage,
the power supply is turned off once when the stop of the fuel delivery is released. How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
515
Seat belt relation
Working of seat belt
Pretensioner
&Seat belt with force limiter
Reception desk seat belt
- The pretensioner mechanism winds up up the seat belt instantaneously when the high impact for the
grievous harm to reach the crew in the front seat is received forward of the vehicle, and secures an
appropriate effect of the crew restraint. -
The force limiter mechanism eases the impact to the chest by maintaining the load
of the seat belt to a regulated value.
. It instantaneously winds up to the first stage of the collision up the seat belt . . The seat belt is drawn out while maintaining the specified load
when colliding .
[Purikurasshushi-toberuto]
Please refer to P.538,541 for [purikurasshushi-toberuto].
516
Seat belt relation
Contents
The
The seat belt with the pretensioner cannot be used again. Handling indoor
equipment
- The seat belt with the pretensioner cannot be used again when operating once. Please become
impossible to draw out and to wind up up the seat belt when operating it and exchange it
in the Toyota shop. The pretensioner doesn't operate in the second collision if the pretensioner . good.. Safety
operates by the first collision when colliding similarly continuously. - [na] ・
of
No fire though the gas like white smoke is generated with the operation sound if the seat [to] Comfortable
belt with the pretensioner operates. Moreover, there is not an influence on the human body either. - theory
equipment
Please consult the Toyota shop when you abandon the seat belt with the car and the
pretensioner. The seat belt with the pretensioner operates unexpectedly, and it is likely to How and
injure. to attention
associate
. drinking..
car
Knowledge
About the operation condition of the seat belt with the pretensioner
The seat belt with the pretensioner operates when the high impact is received forward of the vehicle. It Maintenance
is likely not to operate when the following impacts are weak. -
To the concrete wall at the head-on collision at the speed at about 25 km/h or less.
An original effect is not demonstrated though it is likely to operate in the following cases. -
When you receive the impact from the side and the rear side. - Myriad
When the vehicle turns sideways, and is overthrown.
One[Notoki]
Index
517
- 1
EBD Applying ABS- 2 、Brake assistance
What are ABS and the brake assistance?
Working of ABS
ABS controls slipping by preventing the tire that happens when time that
slammed on the brakes and applying the brakes on a slippery road being locked
(The rotation must stop).
ABS
ABS none
Breaking beginning
- 1 It means "Electronic braking power distribution control" by abbreviating Electronic Brake force Distribution. -
2 Abbreviation of Antilock Brake System (antilock braking system).
518
EBD assistant ABS and brake assistance
Contents
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
[na] ・
Moreover, ABS and the brake assistance (S-VSC installation car) detect the of
lock of the tire with the sensor installed in the wheel. The state of the tire [to] Comfortable
theory
greatly influences the system, and do close attention to the state of the tire, please. equipment
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
519
When ABS and the brake assistance operate
About driving
- It is necessary to keep stepping on the brake
pedal hard as soon as possible at a rapid
brake so that ABS and the brake assistance may
demonstrate the effect.
It steps to one's heart's content. It keeps stepping. It doesn't loosen, and the pumping is done.
About operation
It is not abnormal though the following phenomena might be generated
if ABS operates. -
The brake pedal might move, feel the vibration in the body and the steering wheel little
by little with the operation sound of ABS, and after the vehicle stops, it hear of the motor
sound. -
The brake pedal might enter the interior a little when the operation
of ABS ends.
520
EBD assistant ABS and brake assistance
An appropriate braking effort corresponding to the state of running of the vehicle is distributed to the back and forth circle by
applying the control technology of ABS. As a result, the brake force distribution of four wheels is appropriately done according
Warning
to the variation of load by loading and the deceleration, and a high brake performance is secured. In addition, the
braking effort of a right and left circle is controlled when braking while turning and roadholding is
secured.
. earliness.. Basic
Be overconfident in neither EBD assistant ABS nor the brake operation
[wakari]
assistance.
- Be overconfident in neither EBD assistant ABS nor the brake assistance.
There are limits in the control of slipping and how of the steering wheel to work, and an impossible driving might cause an
unexpected accident and is dangerous also in the state that EBD assistant ABS operated. Neither EBD assistant ABS nor the brake assistance Driving
Handling
are overconfident, the speed is suppressed, the distance between two cars is taken enough, and ..safe driving.. bear it in mind, please.
[**]When the grip limit of the tire is exceeded or hydroplaning * happens, EBD assistant device
The vehicle and the distance between two cars, etc. are very noted and ..safe driving.. bear it in mind, please.
How and
to attention
Knowledge associate
. drinking..
About the operation condition car
- It comes to be able to operate EBD assistant ABS and the brake assistance (S-VSC installation car) by the
velocity of the car exceeding about 10 km/h. Moreover, when the velocity of the car falls up to about 5 km/h, operation is stopped. -
It becomes easy for EBD assistant ABS to operate because he or she is slippery if stepping on the brake on a seam and an
Maintenance
under construction iron plate of a manhole cap and the bridge etc. on the day of rain.
521
Active torque control 4WD
What is active torque control 4WD?
4WD car
4WD that automatically usually controls, demonstrates steady manoeuverability and roadholding from running
from the state of the FF running to the state of directly connected 4WD running according to various states
of running such as roads slippery because of acceleration, the snow, and rain, etc. when cornering,
climbing up the slope, and starting, and achieved an excellent fuel cost performance by the computer. -
When 4WD auto mode switch is turned on, it controls. Please
refer to "How to use of 4WD auto mode switch" of P.374 for
the switch.
The attention when active torque control 4WD is handled has been
described to "Attention of 4W D car" of P.70. ..safe driving.. bear it in mind
because it often reads, and correct handling is understood.
4WD running
When 4WD auto mode switch is turned on, it operates.
Drive
Drive
Drive
522
Active torque control 4WD
Contents
FF running
4WD auto mode switch is in the state of turning off. A Warning
. earliness.. Basic
operation
About the tire [wakari]
Active torque control 4WD greatly influences the performance of the car the state
of the tire, and do close attention to the state of the tire, please. In detailPlease
Driving
read "Attention of the tire" of P.83 well. Handling
device
Myriad
One[Notoki]
Index
523
Mirror glass relation
[Reinkuriaringumira-]
What is [reinkuriaringumira-]?
The rear side is made easy to see by being coated [oyamizumaku] to the specular of the door mirror, and
expanding the drop of water that adheres to the specular such as rain like the film (effect of the hydrophilicity).
- The illustration is different in the one shown in the image from the actual one.
- The water film is obtained when the mirror heater is operated in the mirror heater installation
car and fine and clearer view are obtained. About the operation of the mirror heaterPlease
refer to P.294. -
Usual maintenance is enough only by doing it is washing in clear water. -
The effect of the parents water decreases to a small amount of drops of water such as the fine rain and drizzle. -
In the following cases, it recovers gradually though the effect of the hydrophilicity is temporarily lost. Please
flush it with bags of water after it washes it with the car shampoo and the glass cleaner, etc.
when you want to recover the effect of the hydrophilicity at once. (There is the one that
in the car shampoo and the glass cleaner, there is a silicone compound,
too and read the ingredients label well, please. )
[**]When you wipe the dirt of the mirror off.
[**]When the mirror becomes cloudy.
[**]When you wash wax with the automatic car-washing machine.
[**]A long term, when parking to the place where the day such as the basement car parks is not hit.
524
Mirror glass relation
Contents
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
525
The glass with water-repellent function
The glass
- The illustration is different in the one shown in the image from the actual one.
There is a limit for the continuation period when the drop of water is shed. Please defend
the following notes to make them last long.
- Please clean it as ahead of time as possible with a soft, damp cloth etc. when the glass with a water-repellent
function is dirty. -
Please open and shut the reception desk door glass after removing dirt when the dirt such as the
mud of the glass is awful. -
Please use neither glass cleaner nor wax that the compound (polish powder) enters when you clean
the glass with a water-repellent function. Moreover, please wipe off with the moist cloth when
white overcast when the glass cleaner is used. -
Please wash a car after washing off the dirt such as the glass surface sludges with a water-repellent function when you use the
automatic car-washing machine. -
Please do not do the frost removing etc. by the metallic one. -
The glass with a water-repellent function is an articles of consumption. When shedding the drop of water worsens, it is necessary to repair.
Moreover, the coating can be removed. Please look to the Toyota shop in
detail.
526
Anti-theft system
What is an anti-theft system? Contents
The signal transmitter is built into an electronic key for anti-theft of the vehicle, and
the system that was not able to start the engine excluding the electronic key registered
Warning
beforehand. -
The signal registered in an electronic key is different in each car. -
The system operates when the power supply is turned off, and the security
pilot light (Refer to P.323) blinks. - . earliness.. Basic
operation
The system is released when the registered electronic key is carried, and the engine switch [wakari]
Driving
Electronic keys are electronic parts with built-in signal transmitter. Please guard the following Handling
to prevent the breakdown. -
device
Please do not torture an electronic key, and do not give the high impact. -
Please do not put it on the place that becomes a high temperature such as on dashboards. -
Please do not apply the key ring etc. that wear magnetism. - The
Please do not wash an electronic key in the ultrasonic washing machine etc.
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
527
Super ECT
6 What is Super ECT?
3.5L car
6 Super ECT is controlling and automatic a transmission to unite
the fuel cost performance to a comfortable running by Flex Lock-Up system
and AI SHIFT, etc.
AI * SHIFT working
The system that achieved a comfortable, safe running by presuming driving person's
intention and road situation to AI SHIFT from the following systems, and switching to the best
running pattern automatically. -
The gear-shift [**]It operates automatically [niareba].
528
Super ECT
Contents
Driving
Handling
device
The
Handling indoor
equipment
Six velocities Four-speed Five velocities Three velocities Five velocities Four-speed Five velocities (brakes operation) Six velocities . good.. Safety
There is no control. [na] ・
of
Six velocities Four-speed Three velocities Four-speed Three velocities Four-speed Five velocities six velocities [to] Comfortable
[Noboorosaka] changing the speed control theory
equipment
How and
to attention
Abnormality of the automatic transmission electronically controlled system is
thought, and receive the check in the Toyota shop, please while running when the engine associate
. drinking..
warning light (Refer to P.336) lights. car
Maintenance
Myriad
One[Notoki]
Index
529
Super CVT. i
What is Super CVT i?
2.4L car
Super CVT i is an electronically controlled gearless transmission to make them unite a smooth, comfortable
running to the fuel cost performance by an integrated control etc. of the no steps changing the speed system, the
Lock-Up system, and the [noboorosaka] changing the speed control system.
530
Super CVT. i
Contents
The shift up is limited when judged climbing up the slope when doing, and
a smooth running is achieved.
Moreover, the down of the shift is automatically done when stepping on the brake when judged . earliness.. Basic
operation
that [orosaka] is done at [orosaka] and the engine brake hangs. [wakari]
Driving
Climbing up the slope corner Handling
device
The
Handling indoor
Shift Shift Shift equipment
Usually down up down Shift improvement Usually
There is no control.
Shift
Usually Shift improvement limitation shift improvement down Usually
[Noboorosaka] changing the speed control . good.. Safety
[na] ・
Brake ON of
[to] Comfortable
theory
equipment
Abnormality of the automatic transmission electronically controlled system is
thought, and receive the check in the Toyota shop, please while running when the engine How and
to attention
warning light (Refer to P.336) lights.
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
531
TRC ・S-VSC -
What is TRC *?
Working of TRC
The device that tries to suppress the wheel spin of the drive wheel caused by an excessive driving performance
when starting and accelerating in a slippery road, and to secure the direction stability and the driving performance
of the vehicle. -
The computer perceives slipping by information from the sensor of the velocity of
the wheel when the wheel begins to slip, the output is lowered to the engine momentarily,
and it applies the brakes if necessary. As a result, an excessive driving performance is
suppressed, and slipping is prevented.
[**]Slipping pilot light (P.326) blinks when TRC operates. At
this time, this is due to the brake control, and it is not abnormal though the
vibration of the vehicle might be felt.
Mechanism of TRC
The computer judges that slipping of the tire slips when signals from the
sensor installed in four wheels are compared, and only either of signal is
more than other wheels. As a result, to suppress the driving performance of the slipping
tire, slipping is controlled by applying the brakes, and suppressing the output
of the engine to temporary.
532 - As for the sign, the presence of the installation is different depending on the grade etc.
TRC・S-VSC
Contents
on the signal from the sensor that is attached to the wheel even by one wheel in four wheels,
and TRC is judged the computer is slipping. -
The state of the tire greatly influences the system, and do close attention to . earliness.. Basic
operation
the state of the tire, please. Please read "Attention of the tire" of [wakari]
P.83 well in detail.
Driving
Be not overconfident in TRC. There is a limit in securing the direction stability Handling
of the vehicle, and an impossible driving might cause an unexpected accident and is dangerous also in
device
the state that TRC operates. Please drive especially carefully when it always bears in mind, and
the slipping pilot light (Refer to P.326) blinks to the safe driving.
The
Handling indoor
equipment
Knowledge
About the operation condition
- It enters the state that TRC can be operated if the power supply is turned on usually. - . good.. Safety
[na] ・
TRC doesn't operate when the VSC warning light (Refer to P.334) lights. of
[to] Comfortable
theory
equipment
About the operation check
It is likely to hear of the sound "..ticking.. ton" from the engine room immediately after the start the How and
to attention
engine start and after it starts. This is a sound in which the operation of the system is checked, and it is not
abnormal. associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
533
What is S-VSC *?
S-VSC is a system that tries to control the output of the brake and the engine
etc. automatically to ABS& brake assistance, TRC. EFI active torque control 4WD
(4WD car), electric power steering, etc. and cooperation control, and to control
the sideslip on a rapid steering wheel control and a slippery road etc. when
turning, and to secure the stability of the vehicle. -
The slipping pilot light (Refer to P.326) blinks when S-VSC operates. -
The state of the tire greatly influences the system, and do close attention to
the state of the tire, please. Please read "Attention of the tire" of
P.83 well in detail.
Knowledge
About the operation condition
- It comes to be able to operate S-VSC by the velocity of the car exceeding about 15 km/h. -
S-VSC doesn't operate when VSC warning light (P.334) lights.
534
Electronically controlled throttle (ETCS i- )
What is an electronically controlled throttle? Contents
An electronically controlled throttle is a device that controls the engine power to open times of the
accelerator best in each operating condition, and secures operativeness with an excellent vehicle.
Warning
It extends to various operating ranges by an integrated control with the engine electronically controlled
system etc. , and an excellent accelerator control and an excellent vehicle stability have been achieved.
Abnormality of the electronic control system is thought when the rise of the engine rotational speed . earliness.. Basic
operation
is slow even if the engine warning light (Refer to P.336) lights and it steps on the gas pedal. [wakari]
At this time, it is possible to run in low speed. Please receive the check at once in
the Toyota shop.
It never returns normally until the engine is stopped even when abnormality of the
electronic control system cancels it while low-speed running by any chance of this. Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
535
-.
NAVI・AI SHIFT*
What is NAVI. AI*-SHIFT?
The gear-shift [**]、It operates at the time of about 15-100 km/h in velocity of the car.
The changing the speed ratio of an automatic transmission of driving person's road shape information
on the navigation (corner and intersection), road inclination information, and accelerator and brakes
operation is automatically switched based on information while operating.
Running usually
Shift down
The foot is released from the gas pedal.
Brakes operation
The foot is released from the gas pedal.
Running usually
It ..changing the speed ratio.. changes appropriately
at a no stage according to the level of the curve
shape and the inclination. It comes off the curve, and the
(shift down) shift up gradually.
Knowledge
About the operation condition
NAVI. AI-SHIFT doesn't operate at the following. -
When you make NAVI. AI-SHIFT" no "-
The gear-shift [**]Other than. Nipponia nippon.
- When switching to doing sports the sequential shift mode. -
At the time of about 15 km/h or less or about 100 km/h or more in velocity of the car. -
When the car position mark is not on a roll on the road in the map of the GPS voice navigation system. -
At running of not destination guide by GPS voice navigation system but intersection. However, NAVI
. AI-SHIFT might operate by the road situation etc. when the intersection running.
536 - As for the sign, the presence of the installation is different depending on the grade etc.
[Dei;sucha-jiheddoranpu] -
It emits light by using the gas and the metal iodide, and [dei;sucha-jiheddoranpu] is light that is
whiter than a usual lamp and a lamp of the valve jurisdiction with the light distribution with the extension
Warning
it expands.
Driving
Handling
Knowledge
device
About auto leveling (upper and lower irradiation direction self adjustment) system
- The device that automatically adjusts an optical axis of the headlamp corresponding to the change in the vehicle posture by the loading situation etc.
The
of the addition and subtraction velocity (Only the AFS installation car :) and luggage. -
This is not abnormal in the phenomenon when normal operation of the system is checked though Handling indoor
equipment
an optical axis of the headlamp might move in the AFS installation car when the headlamp is
lit only after the engine is started.
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
- As for the sign, the presence of the installation is different depending on the grade etc. 537
Pre-crash safety system *
What is the pre-crash safety system?
About [purikurasshushi-toberuto]
The effects of the protection instruments such as the pretensioner seat belts with
& force limiter and air bags are improved by rolling the reception desk seat belt when
it is judged that driver's brakes operation is urgent from the depressing speed and
the amount of driver's brake, and judges the sideslip of the vehicle, and restraining
the crew earlier.
Knowledge
About the operation condition
[Purikurasshushi-toberuto] operates at the following conditions. -
When the power supply is turned on. -
At the time of about 15 km/h or more in speed of the car. -
When you have worn the seat belt.
538 - As for the sign, the presence of the installation is different depending on the grade etc.
Pre-crash safety system
Contents
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
associate
Be not overconfident in pre-crash safety. . drinking..
car
Myriad
One[Notoki]
Index
539
Radar system
The system that forecasts the situation in which the collision is not avoided with
[purikurasshusensa-], and reduces the damage of the collision by the braking assistance ([purikurasshub
ure-kiashisuto]) according to depressing the brake control ([purikurasshubure-ki]) rolling
([purikurasshushi-toberuto]) at the early stage of the seat belt and before it collides and the brake.
About [purikurasshusensa-]
The possibility of the collision is judged from the position, the velocity of the car, and the course of the object detecting the
vehicle and the obstacle that exists on the course in the millimeterwave radar beforehand.
Cover
Sensor
Knowledge
About [purikurasshusensa-]
- The millimeterwave radar has been installed before the par of the reception desk bread in the cover of the edge. -
The millimeterwave radar cannot detect plastic of pie Ron etc.Moreover, the person, the
animal, the bicycle, the motorcycle, and the tree, etc. might not be able to be detected as a collision thing. -
Please refer to "Handling of the front of the radar sensor" (Refer to P.404) for the
handling of the sensor.
Lane keeping assistance installation car
Please refer to "Camera for white line recognition" (Refer to P.427) for the white line recognition
camera.
540
Pre-crash safety system
Contents
About [purikurasshushi-toberuto]
The damage of the collision is reduced by involving the reception desk seat belt before the Warning
collision, and restraining the crew earlier in the judgment that the collision thing is detected by
[purikurasshusensa-], and the collision is not avoided.
Moreover, when slamming on the brakes, it operates. . earliness.. Basic
operation
[wakari]
Knowledge
About the operation condition
[Purikurasshushi-toberuto] operates at the following conditions. - Driving
Handling
When the power supply is turned on. -
At the time of about 5 km/h or more in speed of the car. - device
At the time of about 30-40 km/h or more in approach speeds such as oncoming cars and obstacles seen from the car. -
When you have worn the seat belt.
The
Handling indoor
equipment
Please stop in the place of safety promptly when locking with the
seat belt drawn in by operating [purikurasshushi-toberuto], remove the
. good.. Safety
seat belt, and install it again. Moreover, when the seat belt can [na] ・
be loosened, the lock can be released by a little winding up. of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
541
About [purikurasshubure-ki]
"Brake" is displayed on the multi information display that exists in the meter at the
same time as lighting and the buzzer of the mastering warning ringing when judged that the
collision thing is detected by [purikurasshusensa-], and the possibility of the collision is
high, and it informs those who drive of the impact hazard. In addition, when judged that the
collision is not avoided, it applies the brakes, and the collision speed is decreased.
[Purikurasshu]
Brake OFF switch
The function of [purikurasshubure-ki] stops when the switch is pushed, and it returns to the state that can
be operated when pushing again while the function is stopping. -
We will inform you that we blink when the function of [purikurasshubure-ki] is
stopped the pre-crash safety system warning light (Refer to P.340) and have
stopped the operation of [purikurasshubure-ki]. -
The function of [purikurasshubure-ki] stops after operation ends when operation
is stopped pushing the switch while [purikurasshubure-ki] is operating.
Knowledge
About the operation condition
[Purikurasshubure-ki] operates at the following conditions. -
When the power supply is turned on. -
When [purikurasshubure-ki] OFF switch is not pushed. -
At the time of about 15 km/h or more in speed of the car. -
At the time of about 15 km/h or more in approach speeds such as proceeding vehicles and obstacles seen from the car.
542
Pre-crash safety system
Contents
About [purikurasshubure-kiashisuto]
When those who drive step on the brake pedal while judged that the collision thing is detected Warning
by [purikurasshusensa-], and the possibility of the collision is high, the braking effort is
assisted according to depressing.
. earliness.. Basic
Knowledge operation
[wakari]
About the operation condition
[Purikurasshubure-kiashisuto] operates at the following conditions. -
When the power supply is turned on. - Driving
At the time of about 30 km/h or more in speed of the car. - Handling
At the time of about 30-40 km/h or more in approach speeds such as proceeding vehicles and obstacles seen from the car. - device
When those who drive step on the brake pedal.
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
543
About the display of the multi
information display
- "Brake"
It is displayed that abnormality is found in the pre-crash safety system. The sound
"Porn" rings and the mastering warning lights. When the alarm
display has gone out, the following system might not operate.
- [purikurasshushi-toberuto]
* [purikurasshubure-kiashisuto] The
pre-crash safety system
warning light (Refer to P.340) lights to * simultaneous [purikurasshubure-ki].
544
Pre-crash safety system
Contents
device
The following operation might be done even if there is no possibility of the collision for the case
How and
that operates excluding the collision thing. - to attention
[Purikurasshushi-toberuto] operates, and the seat belt is pulled.
associate
[**]Please stop the car to the place of safety, remove the seat belt, and . drinking..
car
install it again when locking with it wound up up the seat belt. -
[Purikurasshubure-kiashisuto] operates and the brake works well than
usually. -
[Purikurasshubure-ki] operates and the brake is applied.
Maintenance
Myriad
One[Notoki]
Index
545
-- Intelligent AFS
Intelligent AFS
What is intelligent AFS?
Intelligent AFS (adaptive reception desk lighting system) is a device that secures
the best light distribution according to various states of running.
The visibility in the intersection and the curve can be improved by moving the lamp in the direction of the turn
according to the velocity of the car and the amount of the operation of the steering wheel when the headlamp
(downward) lights.
Light distribution with intelligent
AFS (practice part)
Please do not use intelligent AFS on the road that includes [yukikabe] etc.There
is a possibility of the reflection of the headlamp to snowy slopes etc. and becoming an obstruction
of driving.
Knowledge
About the operation condition
- Operation stops when the velocity of the car is 10 km/h or more, it becomes an operation beginning, and the velocity of the car becomes less than 5 km/h. -
When the left turns, a left headlamp moves, and 10. or less and a right headlamp move and the illumination axis
moves up to 5. or less left. -
When turning right, a right headlamp moves, and 15. or less and a left headlamp move and the illumination axis
moves right up to 7.5. or less. -
Intelligent AFS doesn't operate when the AFS OFF pilot light has blinked
(Refer to P.324).
546 - As for the sign, the presence of the installation is different depending on the grade etc.
Mirror glass relation
Contents
Warning
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
547
548
..PM page..549
6
Contents
car to associate
. earliness.. Basic
operation
[wakari]
. . . . . . . . . . . of driving on the day of rain 550.
Driving on day of rain 550
Handling . . . . . . . . . . . . . at the cold 551
Driving
Preparation and check before winter 551 Handling
Before it drives 553 device
When you run 555
When parking 558
The
Economical driving . . . . . . . . . . . . . . . 560
Handling indoor
To do an environment friendly, economical driving 560 equipment
. . . . . . . . . . . . . for the environmental protection 563.
Used parts and the abolition oil are 563 that does proper processing.
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
549
About driving on the day of rain
Driving on day of rain
- The sudden braking, the rapid acceleration, and the abrupt steering in a slippery road become impossible for the tire to
slip, and to control the vehicle it, might cause an unexpected accident, and are dangerous. -
An engine brake by the improvement shift down of the shift and a rapid change in the engine rotational
speed might cause an unexpected accident by sideslipping by the car and are dangerous. -
Please confirm the brake works normally lightly stepping on the brake pedal after it runs
of the puddle. When the brake pad is wet, it worsens working of the brake, and is taken the steering wheel
effective only of one that has not been wet, might cause an unexpected accident, and is dangerous.
It might cause a serious car trouble to damage the engine by not only the engine stall
if running on the water-covered road but also the inhalation of the short of electrical
equipment and water. Please check the following item etc. in the Toyota shop when running
on the water-covered road by any chance, and soaked in water. -
Effective condition of brake. -
Change in amount of oil and qualities such as engine transmission
transfers (4WD car) and differential. (Because water mixes when
becoming cloudy, the exchange of oil is necessary. )-
Lubrication is defective in the propeller shaft (4WD car) and each bear and
collaborate each.
550
About driving on the day of rain
Handling at the cold
Preparation and check before winter Contents
. earliness.. Basic
operation
The density of the washer fluid is adjusted. [wakari]
It dilutes referring to the frozen temperature displayed in the bought washer liquid container
to prevent the washer fluid being frozen and it replenishes it.
Driving
Handling
device
The density of cooling water is adjusted.
Please adjust the density of cooling water to prevent cooling water being frozen. The
Handling indoor
Use region Dilution ratio Frozen guarantee temperature equipment
How and
to attention
associate
. drinking..
Liquid measure and the specific gravity of the battery are checked. car
The performance of the battery might decrease when the temperature falls, and it interfere
to the engine start. Liquid measure and the specific gravity of the battery are checked, and please replenish of
the liquid and charge it if necessary. Maintenance
Myriad
One[Notoki]
Index
551
The tire and the tire chain for winter are prepared.
- Please refer to "Attention of the tire" of P.83 when
fixing a new tire. -
Please prepare the tire chain suitable for the size of the tire. -
Please use a Toyota pure goods of the [esutei;ma] specification. Please consult
the Toyota shop in detail. -
18-inch tire installation car cannot install the tire
chain. Please consult the Toyota shop in detail.
552
Handling at the cold
The snow and the frost that attaches to the glass . earliness.. Basic
operation
[wakari]
Please drop the snow and frost in the inside and outside of the glass and secure view.
It is possible to drop without damaging the glass when the defroster is used.
Driving
Please do not divide beating to remove the ice that attaches to the reception Handling
desk window glass. The inside of the windshield (inside of the car) might
crack. device
553
When the door freezes
Please melt ice sprinkling the hot water. Please wipe moisture off enough
at once. When forcibly opening it, rubber in the door circumference might peel
off, and it damage it.
When pedals are operated, it slips, indoor dampness might increase, the
glass become cloudy, and it freeze.
554
Handling at the cold
vehicle and might cause the accident. Please start slowly, take the distance between two cars enough
at a restrained speed, and run.
Please decelerate beforehand in a frozen place such as on the bridge and shade, and . earliness.. Basic
operation
run carefully. [wakari]
An engine brake by the improvement shift down of the shift and a rapid change in
the engine rotational speed might cause an unexpected accident by sideslipping by the
Driving
car and are dangerous. Handling
device
The
The ice that attaches to the other side of the fender Handling indoor
equipment
It influences the steering wheel control, and remove, please before sometimes confirming,
and growing the lump of ice.
. good.. Safety
[na] ・
of
The ice that attaches to the brake equipment [to] Comfortable
theory
equipment
Working of the brake might become bad. Please confirm the effective condition
of the brake stepping on the brake pedal sometimes lightly. How and
to attention
associate
. drinking..
car
The slipping stop : ahead of time.
Please install the tire for the tire chain or winter ahead of time on the frozen road at
the snowfall. Please refer to "Attention of the tire" of P.83 when Maintenance
fixing a new tire.
Please run by the correct air pressure suitable for the tire when the tire for winter is installed.
Myriad
Moreover, please avoid the high speed operation for safety when you install the tire for winter.
One[Notoki]
Index
555
Tire chain
18-inch tire installation car
18-inch tire installation car cannot install the tire chain.
Please consult the Toyota shop in detail.
. procedure .
556
Handling at the cold
Contents
device
Please note that neither the wheel nor the hubcap How and
to attention
are damaged when you install the tire chain.
associate
- The hubcap installation car must install the tire chain after removing . drinking..
the hubcap. When the tire chain is installed with the hubcap applied, car
One[Notoki]
Index
557
When parking
The vehicle exhaust emission invades in the car, it becomes CO intoxication if the snow piles in the
circumference of the car while started up an engine, and it reaches important injury or, in the worst
case, it is likely to lead to the death.
558
Handling at the cold
Contents
the part where the wind drives more than the imagination to prevent the battery performance decrease.
. earliness.. Basic
operation
The wiper arm is setting it up. [wakari]
The wiper due to the cold is ..glass.. frozen at the snow. Please set up
and park the wiper arm. Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
559
Economical driving
To do an environment friendly, economical driving
560
Economical driving
Contents
of fuel well. It becomes low fuel cost a little depressing the gas pedal and the stepping return.
in case of a constant running
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
561
Knowledge
, saying that "10.15 modes"
"10.15 modes" fuel cost described in the vehicle catalog is fuel cost measured according to
specific conditions.
This mode is the one (the reproduction of running on a road actual on the chassis dynamometer by the one that
running in the city was reproduced as shown in Figure 1, and running after the machine of [njin] [**] in the pattern
like Figure 2).
40
A typical though "10.15 modes" is the one that running in the city was reproduced to the last a
running pattern. Therefore, often differ from an actual running, and, for
instance,
- The average of the transport speed is lower than "10.15 modes".
- The stop ratio (ratio to which the car stops while driving) is high.
- Sudden acceleration was done.
It comes to get bad mileage by the difference of the condition.
- The numerical value is calculated based on fuel cost 11.7km/L of the passenger car of 2.0L class (automatic
car)(10.15 modes). (Please read the vehicle catalog about the fuel cost of each vehicle model. )-
The amount of the CO2 exhaust is calculated by two exhaust of CO for each gasoline 1L coefficient 0.64.
562
For the environmental protection
For the environmental protection
Used parts and the abolition oil do proper processing. Contents
- Because lead and sulfuric acid are used as for the battery, appropriate processing is
obligated by the law as a specific, industrial waste.
Warning
Please request disposal in the shop that bought it when you exchange the batteries. -
If the individual burns, the tire generates a poisonous gas such as sulfurous
acid gass.
Please request disposal from the shop that bought it. - . earliness.. Basic
operation
It infiltrates under the soil, and when the engine oil is left, it floats on water, and the [wakari]
Fluorocarbon (regulated chlorofluorocarbons gas CFC12) for the air conditioner refrigerative advances the
depletion of the ozone layer when discharged into the atmosphere. The
Toyota completes all car switch ..hydrochlorofluorocarbon gas (HFC134a) that Handling indoor
doesn't rip up the ozone.. (completion for 93 years). equipment
Still, hydrochlorofluorocarbon gas (HFC134a) has working that makes the earth
clement.
Please fill the gas after doing the gas not only is filled when working of the air . good.. Safety
[na] ・
conditioner is bad but also unifying the check of the gas leak, and repairing the leakage part. of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
563
564
..PM page..565
7
Contents
Warning
Maintenance
. earliness.. Basic
operation
[wakari]
Maintenance . . . . . . . . . . . . . . . . of car 566
The usual maintenance 566
Maintenance of exterior 568
Driving
Maintenance of interior 570 Handling
Maintenance of air conditioner 572 device
Check of tire 575
Battery exchanges of keys 576
The
Check and exchange of fuses 578
Handling indoor
Lamp (valve) exchanges of exteriors 588 equipment
Daily check . . . . . . . . . . . . . . . . . 594
About the daily check 594
Check of engine room 595 . good.. Safety
[na] ・
Check of circumference of car 603 of
[to] Comfortable
Check that gets under the wheel 607 theory
Check where it runs 609 equipment
Myriad
One[Notoki]
Index
565
Maintenance of car
The usual maintenance
About painting
- The stepping-stone wound and the scratch cause corrosion, and repair with the Toyota
pure touch-up paint etc. ahead of time, please when finding it. -
Benzine..gasoline..organic..solvent..adhere..painting..damage..at
once..wipe off..wash a car.
566
Maintenance of car
Contents
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
It causes deterioration in painting and the corrosion of the body and parts, etc. to be brought forward. -
The
When you do running of the coast zone. -
Handling indoor
When you run on the road where the antifreezing agent was scattered. - equipment
When coal tar, pollen, sap, and bird's excrement and insects' corpses etc. adhere. -
When you run in the place where a lot of descents such as smoke, lamp soot, dust, iron filings, and
chemicals exist. - . good.. Safety
[na] ・
When remarkably becoming dirty with dust and mud, etc. of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
567
Maintenance of exterior
568
Maintenance of car
Contents
- Please do not sprinkle water etc. on electric parts in the engine room. It is short-circuited of a failed start
and electric parts of the engine, might cause the breakdown and the vehicle fire, and is dangerous. - Driving
Please note that water doesn't splash directly to the brake when you wash a car at the cold. Handling
It becomes impossible Working of the brake worsens, and might cause clinging of the brake, device
and to run by freezing when water enters in the brake device. -
Please confirm the brake works normally lightly stepping on the brake pedal after washing a car.
When the brake pad is wet, it worsens working of the brake, and is taken the steering wheel effective The
only of one that has not been wet, might cause an unexpected accident, and is dangerous. Handling indoor
equipment
Maintenance
Myriad
One[Notoki]
Index
569
Maintenance of interior
- Please do not sprinkle water in the car when you clean the car. It causes the car breakdown, and when
water splashes to electric parts etc. that the audio and floor carpet under includes, it might cause the
vehicle fire and is dangerous. -
Please do not use organic solvents such as benzine and gasoline to clean the seat belt. Moreover,
please do not bleach, and do not dye the belt. Important injury that decreases the performance of the
seat belt, doesn't demonstrate an enough effect at the collision etc. , and is related to the life might be received and it is
dangerous. Please do not use the seat belt until drying by using the soapless soap or lukewarm water
when you clean it.
- Please do not use an organic solvent, an acid such as the benzine gasoline or an alkaline
solvent when you maintain the interior. Discoloration and doing cause seeing. Moreover, these elements
might be included in various cleaners, and use it, please after it often confirms
it. -
Please note no allowance of the interior goods (air conditioner and audio, etc.) aromatic
substance's (liquid, solid, and gel plate type, etc.) direct touch, and spilling. It might cause discoloration
and seeing and the painting peeling off of doing according to the included element. -
Please do not use the glass cleaner etc. when you clean the inside of the backing door
glass. Heat ray is disconnected, and it is likely not to operate. Please wipe the cleaning lightly with
the cloth to contain water or lukewarm water along heat ray. -
Please do not use the glass cleaner that the compound enters when you clean the inside
of the glass. Please wipe the cleaning lightly with the cloth to contain water or lukewarm water.
570
Maintenance of car
Contents
Sand and the dust, etc. that attach to the surface of the seat damage the protection film on the surface of leather, and
cause the wear-out at the early stage. Please absorb sand and dust, etc. with the cleaner etc.
. earliness.. Basic
operation
- Please defend leathering from direct sunshine by using the San shade [wakari]
(sunshade).
When leather is exposed under hot weather for a long term, it causes fading and stiffening. Please
cover the body, and defend leathering from direct sunshine by using the San shade
Driving
(sunshade) when you leave the car under hot weather long-term. Handling
device
- Please remove the dirt that attaches to the surface of the seat by the following method.
3
How and
It is dried because of shade. to attention
Moisture on the surface of the seat is wiped off with a cloth that dries and is soft, and it associate
. drinking..
is dried because of airy shade. car
When excessive moisture in the surface of the seat remains, the wind combination of leather causes ..saying.. decrease
(stiffening and shrinkage).
Maintenance
Knowledge
About the genuine leather seat Myriad
- The natural material selected carefully is used. We will recommend maintaining it regularly about twice
a year to keep the externals quality to be long. - One[Notoki]
Not uniform and an oxhide leather original wound of [shibo] (ruggedness of the leather surface skin) might be understood for
a natural material.
Index
- As for the sign, the presence of the installation is different depending on the grade etc. 571
Maintenance of air conditioner
Upper tab
Pin
Lower tab
[Danpa-sute-]
572
Maintenance of car
Contents
Knob
3 The cap of the filter case is removed.
Warning
It pulls forward while picking up the knob at
the left of the cap, and it detaches it.
. earliness.. Basic
operation
[wakari]
Cap
Driving
Handling
device
Mark
How and
to attention
associate
. drinking..
car
Index
573
6
Upper tab
The glove box is installed.
An upper tab is fixed by one pushing the
glove box side internally after the pin
is installed in [danpa-sute-] of the set of
the cutting lack of the tab under the
glove box to respect of the shaft and setting,
and the glove box is closed.
Lower tab
Pin Shaft
[Danpa-sute-]
Knowledge
About the exchange of air filters
- The air filter is installed in the air conditioner. To use it comfortably, we will recommend
a regular cleaning and the exchange. -
Air filters can be exchanged without the tool. -
Please consult the Toyota shop about the air filter of the air filter for the cleaning and the exchange.
Standard of cleaning: Each 15,000km. 7,500km. .
Standard of exchange: Each 30,000km. 15,000km. .
. . : for the multi [jin] district (district where a lot of traffic and dust such as big cities and the cold districts exist).
574
Maintenance of car
device
The
Handling indoor
equipment
Rear wheel
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
Please check the tire as a daily check.
How and
- Please check the tire as a daily check. (Refer to P.83 "Attention of the to attention
tire". )- associate
. drinking..
Please consult the Toyota shop when you exchange the tire disc wheel wheel car
installation nuts. (Refer to P.97 "Other attention". )
Maintenance
Myriad
One[Notoki]
Index
575
Battery exchanges of keys
Key cover
1 A mechanical key is taken out.
A mechanical key is drawn out while pushing
the side with the key mark of the knob.
Knob
Mechanical key
Cutting lack
2 The key cover is removed.
The point of a minus driver on the market is
inserted in the cutting lack of an electronic key, and
the cover is removed while twisting it. -
Please wrap the vinyl tape etc.
around driver's point for the damaged
prevention.
576
Maintenance of car
Contents
. earliness.. Basic
Driving
Handling
device
Mechanical key
7 The operation confirmation is done.
It is confirmed that LED of the main The
body lights when either of switch is Handling indoor
pushed. equipment
Please note that detached neither battery nor parts (Especially, the child
:) are swallowed. Important injury might be received when swallowing and it is dangerous. . good.. Safety
[na] ・
of
Please note the handling of the battery and detached [to] Comfortable
theory
parts. equipment
- Please do not lose parts such as the screws when you exchange the batteries. -
How and
With the battery pole Please make to the correct direction without fail and install the pole. - to attention
Please bend the electrode in the battery insertion part, and note that neither garbage nor oil, etc. associate
adhere in the module. - . drinking..
car
Please do not take out internal parts of the base etc.
Knowledge
Maintenance
About the battery
Use battery . . lithem battery CR1632
Please buy the battery in the Toyota shop, the clock shop, and the camera shop, etc.The
Myriad
About the battery exchange
One[Notoki]
battery exchange recommends the exchange in the Toyota shop though can exchange by the customer
oneself because there is fear of damage etc. when exchanging it.
Index
577
Check and exchange of fuses
The ball cutting of blowing the fuse and the lamp is thought when the lamp doesn't go on and when
the device of the electrical system doesn't work.
Please check the fuse and exchange it according to the following procedure. -
Please consult the Toyota shop about the fuse.
Tab
Fuse box B
Fuse box A
578
Maintenance of car
Contents
. earliness.. Basic
Knob operation
[wakari]
Driving
Handling
device
Cover
The
Cover [**]
Knob - The indoor passenger's seat side fuse box Handling indoor
equipment
It is under the passenger's seat side seat
Instrument panel. -
It covers pushing the tab three places. [**][Wohazushi] and -
. good.. Safety
[Bu] is pulled and it covers. [**][Wohazushimasu]. [na] ・
of
- The fuse label is covered. [**][Ni] is displayed and [a]. [to] Comfortable
theory
[Rimasu]. equipment
How and
to attention
associate
Cover [**] . drinking..
car
Maintenance
Tab
Myriad
One[Notoki]
Index
579
3 The fuse is checked.
The fuse that should be checked is confirmed from the situation of the breakdown with
the fuse label, the fuse is pulled out, and whether the fuse cuts is checked. -
..fuse.. feretory is in fuse box B in the
engine room. (Refer to P.578. )-
The fuse has the one that not is depending on the specification of the car either. -
Please consult the Toyota shop about the fuse.
Please do not use fuses other than regulated capacity. It overheats, damages wiring
by a fire, might connect with a fire, and is dangerous.
580
Maintenance of car
Contents
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
The
Handling indoor
equipment
associate
Shinto flute ECU-B3 7.5A smart entry & start power . drinking..
car
[**] ECU-B2 7.5A window (driver's seat switch)
*There is a fuse without the setting depending on the specification of the car either. Index
581
- Fuse box B in engine room
582
Maintenance of car
Contents
[**] ST 5A starter
The
[**] ETC-S 10A Electronically controlled throttle
Handling indoor
equipment
Basket AM2 NO.2 10A Engine switch
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
*There is a fuse without the setting depending on the specification of the car either. Index
583
- The indoor driver's seat side fuse box
584
Maintenance of car
Contents
associate
[**] OBD 7.5A Diamond gnosis connector power . drinking..
car
Straw mat PSD RH 30A slide door (driver side) power
Myriad
One[Notoki]
*There is a fuse without the setting depending on the specification of the car either. Index
585
- The indoor passenger's seat side fuse box
586
Maintenance of car
Contents
associate
[**] S/R 20A (passenger side) electric . drinking..
car
Straw mat PSD LH 30A power window (passenger side) power
Myriad
One[Notoki]
*There is a fuse without the setting depending on the specification of the car either. Index
587
Lamp (valve) exchanges of exteriors
In the exterior of this car, there is a lamp (valve) shown in the figure below. -
Please read a pertinent page about the exchange of lamps that describe the number of pages.
- - Please consult the Toyota shop about the exchange of lamps that describe the sign.
Number-plate light
*High-mount stoplamp * taillight
* retreat
light 593
Braking light/taillight
*[Riya] turning indicator and emergency blinking light *
[Aerasu]
588
Maintenance of car
Contents
Driving
Handling
Please handle the lamp very carefully.
device
- Please drop because pressure in the glass is high, throw the thing or damage and
the glass might scatter damaging it, and handle the tungsten halogen lamp very
The
carefully. Moreover, please wear beautiful gloves without touching by bare-handed. -
Handling indoor
Please use lamps of the same number of W. (Refer to P.611. )- equipment
Please install the lamp and the lamp fastening device surely. It breaks down by the temporary halt etc.
when the installation is imperfect and it is likely to connect as it is inside of the lens and is cloudy. -
Please work noting that the tool, the lamp or neither lamp fastening device nor the socket, etc.
. good.. Safety
are lost when you exchange lamps. [na] ・
of
[to] Comfortable
theory
equipment
Knowledge
How and
to attention
About the cloudy weather of the lamp
associate
The inside of the lens might become cloudy lamped of the headlamp etc. by use conditions of the rain running . drinking..
and the carwash, etc.This is a similar phenomenon to becoming cloudy the pane in the one by the temperatures fluctuate of the inside car
of the lamp and air such as rain, and doesn't have the problem on the function. However, please receive the check in the
Toyota shop when water has collected in time when a big drop of water is attached in the lens and the lamp.
Myriad
One[Notoki]
Index
589
Headlamp (high beam)
- Those who detach it
Cap
1 It opens the hood, and the cap of the washer liquid
injection port is opened, and the washer liquid
injection port is removed from the fastening device on the
driver side.
Socket
Lamp
Tab
- Those who install it
It ..reverse-drinking.. is installed to detach it in order
of [shu].
590
Maintenance of car
Contents
Bolt
Clip
The
Handling indoor
[Aerasu] equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Bolt
Clip
Maintenance
Myriad
One[Notoki]
591
[Aerasu] is excluded.
2 The socket is spent in the direction of the
arrow, it pulls out, the tab is pushed, and the lamp
is detached from the socket.
Lamp
Tab
Socket
[Aerasu]
Socket
Lamp
592
Maintenance of car
Contents
Retreat light
Warning
- Those who detach it
2
Handling indoor
equipment
Socket The lamp is detached.
The socket is spent in the direction of the arrow,
it takes out, and the lamp is extracted from the . good.. Safety
socket. [na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Lamp
One[Notoki]
593
Daily check
About the daily check
594
Daily check
Warning
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
Battery theory
equipment
Engine oil level gauge
How and
Washer liquid injection port to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
595
Car equipped with 2AZ-FE engine (2.4L gasoline)
[Bure-kifuru-doriza-ba-tanku]
Battery
Engine oil level gauge
Washer liquid injection port
Please confirm neither the tool nor the cloth, etc. are left behind in the engine
room check and after it exchanges it. It causes the breakdown, and it might cause the
vehicle fire because it becomes a high temperature and is dangerous in the engine room if it
leaves it behind by any chance.
596
Daily check
Contents
. earliness.. Basic
MAX (upper bound) operation
[wakari]
Driving
Handling
device
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
597
Liquid measure of battery
The battery liquid side checks whether each [ekisou] is between UPPER LEVEL
of the battery (upper bound) and LOWER LEVEL (lower bound) by shaking the vehicle.
Please check regularly might connect with the damage of the battery rising
and the battery when the battery liquid is insufficient.
Knowledge
About the battery
As for the display of UPPER LEVEL. LOWER LEVEL, the design and the displayed place are different
according to the installed battery.
598
Daily check
Contents
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
LOW (lower bound)
The
Handling indoor
equipment
Please check regularly so that there is fear of the corrosion of the radiator and the engine
damage because of overheating when the amount of cooling water is insufficient. Moreover,
please use the super-long life coolant (anti-freeze) in an appropriate . good.. Safety
density to freeze at the cold when using it with the glass, and to damage [na] ・
of
the radiator etc. [to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
599
Amount of engine oil
It is checked whether the amount of the engine oil is between the upper bound and the lower bound of the
oil level gauge.
Car equipped with 2GR FE engine
Please guard the following when the engine oil is checked and
exchanged by you. It might cause important injury and the burn
if it doesn't defend.
- Please stop the engine.
[**]It might cause an unexpected accident by the hand and clothes and tool touching the rotation parts such as
belts and fans while the engine is rotating and arriving at the vicinity and being rolled then and is dangerous. -
Please check and exchange it when the temperature of the engine oil is low. -
The engine oil is a high temperature, and the burn might be done and it is dangerous when the temperature of
cooling water is high even if the engine stalls.
- Please regularly check and exchange it for the rotation part to become defective lubrication due to oil shortage
and deterioration if a regular check is neglected, to cause burning etc. , and to damage the engine.
[**]The engine oil has lubrication in the engine and working cooled.
Usually..drive..piston..breathe in..?..exhaust..valve..lub..oil..partially..combustion
chamber..burn..oil..amount..run..decrease.Moreover, the decreasing amount is different depending
on the running condition etc.-
Please do not put it too much when you replenish oil. -
Please apply and check the cloth etc. so that oil should not adhere to the alternator
etc. when you check the engine oil. Please wipe off completely when oil adheres by any
chance.
600
Daily check
Contents
Driving
Handling
device
The
Level gauge Handling indoor
equipment
LOW (lower bound)
. good.. Safety
[na] ・
Knowledge of
[to] Comfortable
theory
About the replenishment of the washer fluid of [riyawaipa-] equipment
The washer tank for [riyawaipa-] is using combinedly for the reception desk wiper.
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
601
- To replenish the washer fluid
Cap
Please do not replenish the washer fluid when time when the engine is
hot and the engine start. It might break out when hanging to the engine etc.
because an alcoholic element is included in the washer fluid and is dangerous.
Please do not put soapy water etc. instead of the washer fluid. Painting
might become seeing.
602
Daily check
Please read "Attention of the tire" of P.83 also about the check
of the tire.
Warning
Driving
Handling
device
Please adjust when the air pressure is not proper to the specified air pressure.
The stability of the vehicle not only is ruined when it is lower than the specified air pressure but also the . good.. Safety
[na] ・
tire does [katayomametsu]. The tire is a burst (explosion), might cause an unexpected of
[to] Comfortable
accident by standing wave phenomenon * when high-speed running, and it is theory
dangerous. Please include the spare tire by the daily check, and check that the tire inflation equipment
pressure is specified air always pressure.
- When running at high speed, the tire is a wave [utsu] phenomenon. How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
603
Knowledge
About the specified air pressure
Please confirm the specified air pressure by the table or the maintenance data (Refer to P.615) of "Tire inflation
pressure" pasted to the body side where the driver's seat door was opened. -
Please check the spare tire. -
It serves as a reference if the bend by the specified air pressure is confirmed to watching check of the
tire.
604
Daily check
Contents
the nail, the stone, and other foreign bodies stick, and it is whether bitten and crowded are checked.
. earliness.. Basic
Please do not install an abnormal tire that there are a wound and a crack operation
[wakari]
in the side wall of a tire etc.
- When the tire in which abnormality is found is installed, I might feel a vibration that is taken the steering wheel
when running, and is abnormal.
The damage such as bursts (explosion) that cannot be repaired is given to the tire, and moreover, the tire Driving
Handling
might cause an unexpected accident as the sideslip etc. and it is dangerous.
Please promptly receive the check in the Toyota shop, and exchange it for a normal tire while running when device
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
605
Depth and abnormal wear-out of ditch of tire
Mark that shows slip sign Mark that shows slip sign
Slip sign Slip sign
. example: State that slip sign has not gone out . *1 . example: State that slip sign has gone out . *1
Whether the slip sign (wear-out limit display) displayed in the tire
tread appears is checked. Moreover, it is checked whether there is [katayomametsu] of extreme [henbe]
[rinado].
- 1 The purpose of the illustration of the example is to explain, and it is actually different.
Please do not use the tire that exceeds the wear limit. Tire..ditch..dept
h..few..tire..slip sign..wear limit..display..go out..tire..as
it is..use..slip distance for brake..long..become..rain
..day..hydroplaning..steering wheel..operation..tire..burst.
.explosion..unexpected..accident..connect..dangerous.Please
exchange it promptly for a normal tire when slip sign appears.
- 2 Phenomenon of steering wheel and brake's tire's water's entering between tire and road when
running at high speed on road where water collects, floating from road, and not working.
Knowledge
About the cloudy weather of the lamp
The inside of the lens might become cloudy lamped of the headlamp etc. by use conditions of the rain running
and the carwash, etc.This is a similar phenomenon to becoming cloudy the pane in the one by the temperatures fluctuate of the inside
of the lamp and air such as rain, and doesn't have the problem on the function. However, please receive the check in the
Toyota shop when water has collected in time when a big drop of water is attached in the lens and the lamp.
606
Daily check
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
Whether goodness is checked by being the taking tool combination. whether there is allophone when the engine Handling indoor
equipment
startsMoreover, it is checked whether there is allophone with the rotation ..state of idling..
a little raised.
. good.. Safety
[na] ・
of
It steps on the brake pedal. [to] Comfortable
theory
equipment
The engine is started, the brake pedal is depressed fully, and the space with the
alcove slab is checked. Whether abnormality is also found in the feeling of the pedal is checked. How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
607
State of jet of window washer
The engine is started, the window washer is operated, and the jet is
checked.
608
Daily check
usually.
. earliness.. Basic
It is a use limit of the brake pad to generate the warning sound ("Key key" sound) from operation
[wakari]
the vicinity of the brake continuously while running. Please receive the check at once
in the Toyota shop. It is lost of the brake pad when keeping running with the
warning sound generated, damages the brake parts, and worsens effective, might cause
an unexpected accident, and is dangerous. Driving
Handling
device
. good.. Safety
[na] ・
Check of abnormal part until the day before of
[to] Comfortable
theory
It is checked whether there is obstacle in operation for the part in which abnormality was found when using it until equipment
the day before.
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
609
Maintenance data
Maintenance data
Play
1. 6
mm(state without negative pressure)
V
[Oruta-ne-ta-]
& P/S& Flexible volume Non-adjustment type
belt
A/C belt
- The notch is moderation (sound "[Kachi]") when the parking brake is put.
610
Maintenance data
Contents
Wattage of lamp
Warning
I t e m Maintenance data
Headlamp
Halogen headlamp installation car
. earliness.. Basic
[**]60W of high beam . . . . . . . . . operation
. . . (Valve type: HB3) [wakari]
Index
- As for the sign, the presence of the installation is different depending on the grade etc. 611
Amount and kind of cooling water and oils and fats
CapacityL ]
Item Designated stock
(reference value)
[Riya] air-conditioned
10.6
car
2GR-FE Toyota is pure.
[Riya] air-conditioned
8.7 Super-long life
cars except coolant
Cooling water
[riya] air-conditioned - Frozen guarantee
8.2
car
2AZ-FE temperature density 50%-35.
[Riya] air-conditioned
6.3
car is excluded.
Auto Pure auto Froude
(FF 2GR-FE 6.5
WS of Toyota
car)
612
Maintenance data
Contents
[**]S L 5 W . 2 0
(API SL,EC
The
SAE 5W -20)
Handling indoor
[**]S L 1 0 W 3 0 equipment
(API SL,EC
SAE 10W -30)
Engine Toyota pure motor oil . good.. Safety
[na] ・
[**]S M 0 W . of
[to] Comfortable
oil 20(API SM,EC/ILSAC theory
equipment
GF-4,SAE 0W -20)
[**]S M 5 W .
How and
30(API SM,EC/ILSAC to attention
GF-4,SAE 5W -30) associate
[**]S M 1 0 W . . drinking..
2AZ-FE 4.1 4.3 car
30(API SM,EC/ILSAC
GF-4,SAE 10W -30)
[**]S L 5 W . 2 0
(API SL,EC Maintenance
SAE 5W -20)
[**]S L 1 0 W . 3 0
(API SL,EC
Myriad
SAE 10W -30)
One[Notoki]
Index
613
- Specified engine oil
We will recommend API standard SM/EC, SL/EC or the ILSAC standard passing
oil. ILSAC CERTIFICATION ([irusakkusa-tei;fike-shon]) mark is
attached to the can of the ILSAC standard passing oil.
- Please use the one of the viscosity that is appropriate for the outside temperature based on the following table.
Outside temperature
( .)
- 0W20 is the most excellent oil in the conserve fuel cost. (Only the car equipped with 2AZ FE engine can be used. )
Capacity L
Washer tank 2.5
(reference value)
614
Maintenance data
Contents
The
225/50R18 95V 18. 7J 51mm
Handling indoor
equipment
Spare
tire for T145 90D16 116M 16. 4T 20mm
emergency
. good.. Safety
[na] ・
of
Air pressure when tire is cold [to] Comfortable
Tyre type
[kPa{kg/cm 2
}] theory
equipment
Maintenance
Myriad
One[Notoki]
Index
615
Vehicle specification
Name Model Engine Drive system Grade
[Aerasu]
2GR-FE
GSR50W
(3.5L gasoline)
G
FF
(front-wheel drive)
2AZ-FE
ACR50W X[Aerasu]
(2.4L gasoline)
[Esutei;ma]
G[Aerasu]
2GR-FE
GSR55W
(3.5L gasoline)
G
4WD
(four-wheel drive)
2AZ-FE
ACR55W X[Aerasu]
(2.4L gasoline)
616
Maintenance data
User customizing function
User customizing function Contents
The following functions can be changed. Please consult the Toyota shop
in detail.
Warning
. good.. Safety
turning off operation reception desk door and [na] ・
The decrease in lights. No/do decrease in lights.
slide door indirect lightings of
[to] Comfortable
theory
Adjustment of time until sensitivity Level 3 /level 1-5 equipment
[Konraito]
adjustment [konraitoshisutemu] of [konraitosensa-] How and
(Refer to P.356. ) to attention
lights front position light, taillight, Standard/is long.
and number-plate light associate
. drinking..
The power supply : the gear-shift car
when all doors are closed in
It doesn't lock. /is locked.
(Refer to P.166) A turning on. [**] [Kara][**]It makes it.
All doors are locked.
self-locking function
The velocity of the car is about 20. [**]It becomes/h or more. Maintenance
It locks. /is not locked.
The door all is locked.
An auto unlock The power supply : the gear-shift in turning on.
function. [**]以外から [**]All [nisuruto], It unlocks it. /is not unlocked. Myriad
(Refer to P.166. ) doors are unlocked.
One[Notoki]
Index
617
Initialization item
Initialization item
The following items ..battery.. are reconnected, and after it maintains it, the
system should be correct and it initialize it to make them work. Please read the
reference page, and initialize it.
618 - As for the sign, the presence of the installation is different depending on the grade etc.
Initialization item
Contents
Warning
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
619
620
..PM page..621
8
Contents
Warning
At the emergency
. earliness.. Basic
operation
[wakari]
Tool, spare tire, and departure flame cylinder . . . . . . . . 622
Storage place of jack, tool, and spare tire 622
How to take out tool and jack 624
Driving
How to detach spare tire 626 Handling
How to use of the departure flame cylinder. 630 device
When breaking down, . . . . . . . . . . . . . . 632.
When breaking down on the road 632
The
When it becomes impossible to move 633
Handling indoor
When blowing out, . . . . . . . . . . . . . 634. equipment
Exchange of tires 634
Tire blowout emergency repair kit . . . . . . . . 644
About the tire blowout emergency repair kit 644 . good.. Safety
[na] ・
Before repairing the emergency 648 of
[to] Comfortable
Method of emergency repair 650 theory
equipment
When the battery goes up, . . . . . . . . 658.
What is the battery rising? 658 How and
to attention
When overheating, . . . . . . . . . 662.
associate
What is overheating? 662 . drinking..
car
. . . . . . . . . . . . . . of pulling 666.
Method of pulling 666
When the accident happens, . . . . . . . . . . . . 670.
Please do the following treatment without panicking. 670 Maintenance
Myriad
One[Notoki]
Index
621
Tool, spare tire, and departure flame cylinder
Storage place of jack, tool, and spare tire
Jack
Tool bag
Tire blowout emergency repair kit
(Refer to P.644. )
- The jack and the tool bag are stored in the cover on the luggage room passenger's
seat side.
[**]The tool bag is as follows.
Wheel nut wrench Jack steering wheel Draw hook Dirt prevention seat *1
(Refer to P.666. )
- As for 4WD car, the blowout repair kit is stored besides the jack and the
tool bag. Please read P.644 about the tire blowout emergency repair kit. -
I will confirm no embarrassment at the emergency the usage etc. of the kind and the departure
flame cylinder of the jack and the tool beforehand.
622
Tool, spare tire, and departure flame cylinder
Contents
. earliness.. Basic
operation
[wakari]
Driving
Handling
Spare tire (Refer to P.626). device
The spare tire is stored in the below the floor level on the driver side.
The
Handling indoor
Knowledge equipment
How and
to attention
associate
. drinking..
car
Maintenance
[Supeataia] of shop installation option
Myriad
One[Notoki]
Index
623
How to take out tool and jack
Cover
Hook
2 The tool bag is taken out.
The hook is removed, and the tool bag is
taken out.
Tool bag
624
Tool, spare tire, and departure flame cylinder
Contents
Driving
Handling
device
Bracket
The
Please store it surely after using the tool and the Handling indoor
equipment
jack.
- Please store it in the decided place surely after using the tool and the jack. It might
cause an unexpected accident when indoors leaving it and is dangerous. -
. good.. Safety
The jack installed by the car is only for customer's car. Please do not use for other cars, [na] ・
of
and do not use the jack of other cars for customer's car. It might cause an unexpected accident when the [to] Comfortable
handling of the jack is mistaken and is dangerous. theory
equipment
How and
to attention
Please do not use the jack installed by the car excluding the tire exchange and
associate
the tire chain detaching. . drinking..
car
Maintenance
Myriad
One[Notoki]
Index
625
How to detach spare tire
When detaching it
1 Driver's seat side [sekandoshi-to] is moved
to the rear side.
The loincloth and it ..wheel nut wrench.. becomes
it when moving forward the reception desk seat
(driver's seat) ..becoming empty...
Attachment
4 The spare tire is detached.
The attachment is removed from the
wheel hole, and the spare tire is detached.
- The spare tire of the shop installation option is stored in the luggage room. Please see the manual of the
attachment about how to detach the spare tire.
626
Tool, spare tire, and departure flame cylinder
Contents
. good.. Safety
Please confirm the tire is surely fixed. [na] ・
of
[to] Comfortable
- Please confirm the tire is surely fixed after storing the spare tire. theory
The tire shakes if not fixed, and it is likely to shift while running. - equipment
Please do not use the impact wrench when you detach the spare tire. When the
How and
impact wrench is used, the storage tool might be damaged. - to attention
Please roll up the attachment until sticking to the body even when you do not store the tire
associate
in the storage tool after taking out the spare tire. It hits the body in case of the state that . drinking..
hangs by the attachment and fell, and the body might be damaged. - car
Please do not check the spare tire, and do not install the spare tire in which abnormality is found. Please
adjust the specified air pressure after confirming correct air pressure with the table or P.615 of "Tire inflation
pressure" pasted to the body side where the driver's seat door was opened. -
Maintenance
Please detach it before the jack improves when you detach the spare tire from the storage
tool.
Myriad
One[Notoki]
Index
627
Knowledge
About the storage of a standard tire
A standard tire cannot be stored in the storage tool. Please put the removed standard tire in the
luggage room in coming to the dirt prevention seat that exists in the tool bag.
About the prevention of tightening too much mechanism of the operation bolt
The structure that hears the sound "[Kachi]" when the operation bolt is tightened by the power of
tightening torque about 37N. m{370kgf. cm} or more when the tire is stored, and doesn't shut any more. This is the one
by working of the prevention of tightening too much mechanism of the operation bolt, and it is not abnormal.
- Please check the air pressure of the temporal spare tire. It might cause an unexpected accident because the difference
of the diameter of the tire grows further if running in the state where the air pressure is insufficient and is dangerous.
Air pressure (gage pressure) when tire is cold: 4.2kg ..420kPa {../ [**]} -
The temporal spare tire installed by the car is only for customer's car. Please do not combine with other
tires and the disc wheels, do not use for other cars, and use the temporal spare tire of other
cars for customer's car. It goes out to run the adverse effect, might cause an unexpected accident, and is
dangerous.
628
Tool, spare tire, and departure flame cylinder
Contents
tire is installed and an umbo etc. are got over. Height changes when the temporal spare tire is installed into the
standard tire installation. The car might be thrown when driving in the same sense. -
Please do not install the tire chain in the temporal spare tire. The tire chain might hit the
Driving
body side, and the adverse effect be caused for running. Please install the tire chain after without using the Handling
temporal spare tire for the front wheel, using for the rear wheel, and applying the removed rear wheel to the front wheel when the front device
wheel blows out on the snow road and the frozen road. -
When the temporal spare tire is installed, an accurate speed of the vehicle might not be able to be
detected, and the following system might not operate normally. The
[**]A B S Handling indoor
[**]Brake assistance equipment
[**]T R C ・ S - V S C
[**]Radar cruise control
[**]Cruise control . good.. Safety
[**]Backing guide monitor [na] ・
of
[**]Window shade corner monitor [to] Comfortable
theory
[**]GPS voice navigation system equipment
[**]P r e - c r a s h s a f e t y
[**]Lane keeping assistance How and
to attention
[**]N A V I . A I .
SHIFTMoreover, the following system might not be able not only to demonstrate the performance enough but also negatively associate
. drinking..
affect the drive and the system parts. car
[**]Active torque control 4WD
Maintenance
Myriad
One[Notoki]
Index
629
How to use of the departure flame cylinder.
Storage place
It is applied it in preparation for one's passenger's seat feet.
2 It ignites.
Print medicine It ignites when rubbing with the print medicine of
the head of the cap.
630
Tool, spare tire, and departure flame cylinder
Contents
Driving
Handling
Please do not use the departure flame cylinder in the tunnel etc.View is deteriorated with
device
smoke, and use the emergency blinking light in the tunnel etc. , please.
The
Handling indoor
Knowledge equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
631
When breaking down
When breaking down on the road
When the emergency is required, it signals with the departure flame cylinder.
Refer to P.630 "How to use of the departure flame cylinder".
632
When breaking down
Driving
Handling
device
The
When it becomes impossible to move on the road Handling indoor
equipment
The gear-shift [**][Yasu] in the person in [nishite] and the vicinity.
Please have pushing to the place it is.
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Myriad
One[Notoki]
Index
633
When blowing out
Exchange of tires
Please read "Attention of the tire" of P.83 also about the exchange
of tires.
634
When blowing out
Contents
Maintenance
4 The nut is loosened.
It loosens it by a little circumference in the
order of figure in the nut to the left by the Myriad
loincloth and the hand with a wheel nut wrench.
One[Notoki]
Index
635
5 The jack is raised.
The part of A of the jack is spent in the right by the
hand and it raises it to the position where the body is
set the jack.
Cutting lack
6 The jack is put on the jack set position
(During the cutting lack).
The jack is put on a jack set
position near the changed tire.
It is confirmed that the jack surely hangs
to the position where the body is set the
jack.
636
When blowing out
Contents
Driving
device
The nut is spent in the left by the hand, and
it detaches it.
The
Handling indoor
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
637
11 Exchanged tires are installed.
- Please install it after wiping the seat
Instal ation
Seat of the disc wheel and dirt in installation
respect respect on the other side of the wheel
off when you install the tire.
638
When blowing out
Contents
- Frog Nipponia nippon in the steel wheel (The temporal spare tire is included) from the steel
wheel. Driving
Bolt It tightens temporarily until the taper part Handling
Taper part
of the nut lightly hits the seat of the wheel device
hole.
The
Nut
Handling indoor
equipment
Seat
. good.. Safety
- Frog Nipponia nippon in the temporal spare tire from the aluminum foil. [na] ・
of
Bolt It tightens temporarily until the taper part [to] Comfortable
theory
of the nut lightly hits the seat of the wheel equipment
hole.
How and
to attention
Nut associate
. drinking..
Taper part car
Seat
- Frog Nipponia nippon in the aluminum foil from the aluminum foil.
Maintenance
Bolt Washer
It tightens temporarily until the washer of the
nut hits the wheel.
Myriad
Nut One[Notoki]
Wheel
Index
639
13 The body is sold wholesale.
The jack steering wheel is spent in the left and the
body is sold wholesale.
Valve
15 The hubcap is installed.
When the hubcap is installed with the
hubcap installation car, the cutting
lack is matched to the valve of the tire
(air entrance), and the hubcap is installed
surely. -
The hubcap cannot be installed
Cutting lack in the temporal spare tire.
640
When blowing out
Contents
Please install the tire of the same size, the same manufacturer, the same brand, and the same tread pattern
(ditch pattern) by four wheels and specified sizes when you exchange it for the new article.
Index
641
A special tool is needed, and when using it by mistake because the special
attention is needed for handling, the vehicle is damaged, and when the jack improves
with jacks other than the jack installed by the car, it might cause an unexpected
accident and is dangerous. Moreover, when the jack improves in [riyasasupenshon]
etc. , the vehicle might be damaged.
Please consult the Toyota shop when it is
necessary to use jacks other than the jack installed
by the car. Moreover, please hit it to the
position where the figure below is set the garage jack
Garage jack
when you use the garage jack.
FF car
[Riyasasupenshon]
Garage jack set position Garage jack set position
The jack
cannot improve.
The front side of vehicle
4WD car
[Riyasasupenshon]
Garage jack set position Garage jack set position
The jack
cannot improve.
The front side of vehicle
642
When blowing out
Contents
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
643
Tire blowout emergency repair kit
About the tire blowout emergency repair kit
The tire blowout emergency repair kit is stored at the left of the luggage room.
Hook
644
Tire blowout emergency repair kit
Contents
when having blowed out to repair the emergency as for the blowout. -
The emergency repair of a slight blowout of extent where [kugi] and the screw, etc. stick in the tread
part of the tire (earth part) can be done. (Refer to P.648. )- . earliness.. Basic
operation
One tire of one repair medicine of the tire blowout emergency repair [wakari]
kit can emergency repair.
We will recommend the tire to repair the emergency with the tire blowout emergency Driving
Handling
repair kit to be exchanged for a new tire. Please consult the Toyota shop about the
repair and the re-use. device
The repair medicine of the tire blowout emergency repair kit is for The
drinking [shina]. Handling indoor
equipment
- The repair medicine of the tire blowout emergency repair kit is for drinking [shina]. It is harmful to for drinking
healthy [suruto]. Please drink water as a lot as possible, and receive the doctor's examination at once by mistake in
case of for drinking [shita]. -
Please wash it with bags of water at once when the repair medicine of the tire blowout emergency repair kit catches . good.. Safety
[na] ・
one's eye or it attaches to the skin. Still, please receive the doctor's examination when you feel abnormality. - of
[to] Comfortable
Please keep the tire blowout emergency repair kit in the place that doesn't reach child's like a specified theory
storage place (Refer to last page) etc. hands. - equipment
Please work after it parks to a safe place where smoothness and traffic are not hindered when
How and
you repair the emergency of the blowout. - to attention
Please note that it is likely to become a bristletail when the repair medicine of the tire blowout emergency
associate
repair kit adheres to clothes etc. . drinking..
car
Knowledge
About the blowout and the burst
Maintenance
The blowout and the burst are thought when it is the following. -
When the steering wheel is taken. -
When there is an abnormal vibration. -
When the vehicle inclines abnormally. Myriad
If the adhering repair medicine is wiped off, the wheel can be used again. However, please change the valve
for the new one. Please wipe the spilling repair medicine off with the cloth etc.
Index
645
Content of tire blowout emergency repair kit
- Repair medicine - Compressor
646
Tire blowout emergency repair kit
Contents
Knowledge
Warning
About the repair medicine
Expiration date
- From manufacturing to 4 years. (The expiration date is displayed in the container. )-
It is necessary to exchange it before the expiration date cuts. Please consult the Toyota shop when you . earliness.. Basic
exchange it. operation
[wakari]
System requirements temperature . . . . -30. . +60.
(It is not possible to use it, except when the outside temperature is a system requirements temperature. )
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
647
Before repairing the emergency
The damage of the tire is confirmed before the repair medicine of the tire blowout emergency
repair kit is used.
Knowledge
About [kugi] and the screw that sticks in the tire
Please repair the emergency removing neither [kugi] nor the screw,
etc. that stick in the tire. The emergency repair might become
impossible in the repair medicine of the tire blowout emergency
repair kit if it pulls it out.
648
Tire blowout emergency repair kit
Contents
Driving
Handling
device
- Blowout due to crack and damage of side wall
The
Handling indoor
equipment
. good.. Safety
- When shifting, the tire and the wheel [na] ・
obviously :. of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
- Cut and stab of 4mm or more in tread car
Maintenance
Index
649
Method of emergency repair
Core turning
3 The projection part of the core turning is pushed,
appropriated, and it deflates.
The projection part that is attached to core turning
[noushiro] is pushed, appropriated to the valve, and the air
Projection part
of the tire is pulled out completely.
Valve
Valve core
650
Tire blowout emergency repair kit
Contents
. earliness.. Basic
operation
[wakari]
Repair medicine
Injection hose
injection hose screws in.
device
The aluminum seal of the container tears while
screwing in.
The
Repair medicine Handling indoor
equipment
How and
to attention
Injection hose associate
. drinking..
car
Injection hose
Myriad
Thread part
One[Notoki]
Index
651
9 All the repair medicines are injected in the tire.
The container and the injection hose are done above the valve,
inclined as shown in a left chart, the container is pushed by the
hand, and it begins to squeeze an inside repair medicine. -
An empty container of the repair medicine is
used to collect a used repair medicine when tires
are exchanged, and have it to the Toyota shop,
please. -
It is necessary to equip the vehicle
with a new repair medicine again, and consult
the Toyota shop, please when you use
the repair medicine.
652
Tire blowout emergency repair kit
Contents
Hose
12 The hose of the compressor screws in
in the valve of the tire. Warning
Compressor
. earliness.. Basic
operation
[wakari]
Driving
Handling
Power plug
13 The power plug is inserted in the
device
accessories socket.
The
The power plug of the compressor is inserted
Handling indoor
in the accessories socket of the vehicle. - equipment
The accessories socket is in
the luggage room.
. good.. Safety
[na] ・
of
Accessories socket [to] Comfortable
theory
equipment
14 The power supply in the vehicle is made ACC.
How and
(Refer to P.139. ) to attention
associate
. drinking..
car
Maintenance
653
16 The switch of the compressor is turned on,
and it pumps air in to the tire until becoming
specified air pressure.
The switch is turned off when confirming with the
pressure gauge that is attached to the compressor, and
becoming specified air pressure. -
Switch
There is a possibility of received damage
Pressure gauge with an awful tire when not becoming specified
air pressure within five minutes. In this case,
the emergency cannot repair with the tire
blowout emergency repair kit. Please
contact the Toyota shop.
654
Tire blowout emergency repair kit
Contents
Driving
Handling
device
The
Pressure gauge
22 The air pressure in the tires is confirmed with the Handling indoor
equipment
pressure gauge of the compressor.
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
130kPa { 1.3kg/cm2 } When is above
associate
Please put it again in the specified air . drinking..
car
pressure with the compressor again.
Maintenance
Index
655
Speed limitation label
23 The tire and the valve are exchanged in
the Toyota shop.
Please go to the Toyota shop by pasting to the
place where the speed limitation label is seen easily
from the driver's seat, applying, avoiding the sudden
braking and the abrupt steering, and driving carefully
at 80 km/h or less, and exchange the tire and the
valve promptly.
Please do not paste the speed limitation label to the supplemental restraint system airbag development
department in the pad part etc. of the steering wheel. The supplemental restraint system airbag
doesn't operate normally, and it reaches important injury or, in the worst case, it is likely to
lead to the death.
Moreover, please do not paste it to the place in which it interferes to driving such as the
meter and the door glass. It might cause an unexpected accident and is dangerous.
Please guard the following items when you repair the emergency.
- The repair medicine might spout when the container of the repair medicine is shaken with the injection hose screwed in
in the repair medicine. -
Please note that the valve core dashes out when the core turning is often naturally spent
when air remains in the tire. -
The repair medicine might spout when the repair medicine is injected when the insertion of the injection hose is loose
when the repair medicine is injected. -
Please spend by the hand when the valve core screws in by the core turning. When the tool etc. are
used, the core turning might be damaged. -
Please firmly connect the hose with the valve with the tire put up to the vehicle
and work when you use the compressor. -
The battery might go up according to the state of the battery when the power supply is made
ACC and the compressor is used. -
The compressor might not become hot, and do not touch the inside of the compressor,
please when you use the compressor.
656
Tire blowout emergency repair kit
Contents
Please guard the following items when you repair the emergency.
Warning
- Please do not drive the compressor continuously for ten minutes or more. The motor overheats and it is
likely to damage it. Again, please do after getting cold the compressor when you use it. -
Water must not splash to the compressor at the rainfall etc.-
Please do not use the compressor for the place where a lot of soil dust such as sands exists putting it directly. - . earliness.. Basic
operation
Please do not take apart and remodel the compressor. Moreover, please do not strike close to home. - [wakari]
Please do not oil oil etc. because the compressor is an unpaid oil type. -
Please run carefully when you run with the tire that did the emergency repair. Please take care
especially when it goes round a curve.
Driving
Handling
device
Knowledge The
Handling indoor
About the compressor equipment
- The compressor is for the air filling of the passenger car type.
- It is not abnormal though a big operation sound is heard when the switch of the compressor is
turned on. - . good.. Safety
The power supply of the compressor is 12V exclusive use for the car. Please do not connect 24V and other power [na] ・
of
supplies. [to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
657
When the battery goes up
What is the battery rising?
Method of treatment
It is not possible to start by the jump-start.
Please request the rescue car, connect the booster cable, and start the
engine. The battery of the rescue car must use 12V.
658
When the battery goes up
Contents
Earth point
. earliness.. Basic
Car equipped with 2GR FE engine operation
[wakari]
Car (battery rising car)
Driving
Handling
device
The
Handling indoor
equipment
associate
. drinking..
car
Maintenance
Myriad
Index
659
To prevent the battery rising
- Please do not light a lamp with the engine stopped, and do not use
the audio air conditioner etc.-
Please turn off the power supply of needless electrical equipment when stopping for a long time due to
congestion etc. while the engine is rotating.
- Please guard the following. It ignites, it explodes to the combustible gas generated from the battery
if it doesn't defend, important injury such as the burns might be received, and it is dangerous.
[****]Connected [ha] car battery drinking Please do not tie to the terminal. Direct [tsuna] in the battery.
[Guto] and the spark are generated.
[**]When you connect the booster cable Please never touch the terminal.
The spark is generated if it touches it.
[**]Please do not bring the fire close to the battery. -
Please do not approach the battery while charging it. Important injury might be received when the battery liquid
that is contained diluted sulphuric acid might spout, and it adheres to eyes and the skins and it is dangerous. Please
wash with bags of water at once, and receive the doctor's examination when you adhere by any chance. -
The booster cable is connected, and please do not touch the fan and the belt, etc. , and
do not approach when detaching it. It might cause an unexpected accident by the hand and clothes',
etc. being rolled and is dangerous. -
Please tighten the nut of clamping surely when you exchange the batteries. It might
cause the vehicle fire by clamping coming off while running if it doesn't tighten surely, and
shorting and is dangerous.
- The battery of another car (rescue car) should be 12V. Please go after
confirming the battery for 12V. -
Please receive the check in the Toyota shop when it is easy to go up in the battery.
660
When the battery goes up
Contents
Warning
. earliness.. Basic
operation
[wakari]
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
661
When overheating
What is overheating?
Method of treatment
1 It pulls up a car.
When the car is stopped to the place of safety, and the air conditioner is used, it makes it to
turning off.
662
When overheating
Contents
Driving
Handling
. good.. Safety
[na] ・
of
[to] Comfortable
[Riza-ba-tanku] 5 The circulating water flow etc. are confirmed.
theory
equipment
Whether neither the confirmation nor the radiator
How and
core part (heat radiation part) of the circulating to attention
water flow of [riza-ba-tanku] are remarkably dirty associate
nor garbage etc. do not adhere after getting cold . drinking..
car
enough the engine are confirmed.
Maintenance
Core part
Myriad
One[Notoki]
Index
663
6 Cooling water is replenished.
When the circulating water flow is insufficient, cooling water is replenished with the
radiator and [riza-ba-tanku]. -
Water is replenished in the emergency when there is no cooling water.
664
When overheating
Contents
To prevent overheating
Please always check whether there are water leakages in the amount and the ground of cooling water. Warning
. earliness.. Basic
Please take care not to do the burn enough. operation
[wakari]
- Please do not open the hood until steam doesn't occur when steam has occurred from
the bonnet. Important injury such as the burns might be received because the high temperature in the engine
room and it is dangerous. Moreover, there is a part that is the high temperature even when steam has not occurred.
Driving
Be careful enough when it opens the hood. - Handling
Please do not open the radiator cap when the radiator and the auxiliary tank are hot. Steam device
and the hot water spout, important injury such as the burns might be received, and it is dangerous. Please wrap
the cap by cutting the cloth after getting cold enough the radiator and the auxiliary tank and
open it slowly when you open the cap. - The
Please do not touch the fan and the belt, etc. , and do not approach when the Handling indoor
engine turns. It might cause an unexpected accident by the hand and clothes', etc. being rolled. equipment
Please do not put cooling water in when the engine is hot. When suddenly cold . good.. Safety
[na] ・
cooling water is put in, the engine might be damaged. Please put cooling of
[to] Comfortable
water in slowly after getting cold enough the engine. theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
665
About pulling
Method of pulling
The pulling hook of the reception desk aims to be pulled, and is not
the one to pull another car.
Please request it from the Toyota shop or JAF, etc. as much as possible
when you pull it. Especially, the breakdown of driving system is thought, and, first, contact the
Toyota shop in the following cases, please before it pulls it. -
The car doesn't move though the engine turns. -
An abnormal sound is heard.
When pulling it
1 The draw hook and the wheel nut wrench are taken out.
(Refer to P.622. )
Cap
666
About pulling
Contents
Driving
Handling
device
Draw hook
The
Handling indoor
equipment
4 It ropes it.
The body is not damaged, and the draw hook is roped. . good.. Safety
[na] ・
Please pull it in the direction of advancement roping the draw hook. of
In the traction rope, please apply the cloth that it is white more than 0.3-meter [to] Comfortable
theory
square (0.3m. 0.3m) to the center of the rope. equipment
How and
to attention
associate
. drinking..
Within about car
5m about 25m
As much as possible
on the same side
Maintenance
White cloth
Direction of pulling
Myriad
One[Notoki]
Index
667
5 It starts up an engine.
The engine must start as much as possible. When not engining starts,
the power supply is made ACC or to turn on.
6 It starts.
The gear-shift [**][Nishite] and the parking brake are released.
Please remove the draw hook, and obtain the cap of the bumper surely
when pulling ends. -
The removed pulling hook is stored in the tool bag.
When you pull another car (disabled car) with the rope
The installation hole of the pulling hook on the [riya] side is at both ends of [riyabanpa-]. Please
read "Pull it" of P.666 about how to install the draw
hook. -
The draw hook is used to pull another car (disabled car) that breaks down on a
general road with the rope unavoidably. -
A car that is heavier than the car cannot be pulled. When a car that is heavier than the
car is pulled, driving system might be negatively affected, and the draw hook and
the body be damaged.
668
About pulling
Contents
device
Please pull it with the tow car when it descends Nagasaka road.
- Please pull it with the tow car when it descends Nagasaka road. The brake overheats if it doesn't
The
pull it with the tow car and effective might worsen. -
Handling indoor
Please pull by four-wheel earth for 4WD car or transport it with four wheels while lifted. equipment
Please never do pulling that lifts only the front wheel or the rear wheel. Driving device
might cause burning, and the car dash out from Trekkers (truck).
Moreover, please lift and transport four wheels when it seems that the drive and the system parts broke down.
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
- Please pull the pulling distance to the pulling speed at about 30 km/h or less within about 80km in the direction . drinking..
car
of advancement. Please influence the transmission harmfully when pulling by exceed this speed and the
distance or pulling it in the direction of the junior, it is likely to damage, and lift and transport
it with four wheels by vehicle loading car etc. when you exceed this. -
Please do not rope the suspension arm etc. when pulling it to another
Maintenance
car for the stack escape. The suspension arm etc. might be damaged. -
Please do not use the wire rope. The bumper might be damaged. -
Please do not forcibly pull, and request it from the Toyota shop and JAF, etc. when stack * and
doing. When the rope is pulled to the draw hook and the suspension parts, etc. putting it, Myriad
the draw hook and the suspension parts might be damaged.
- It becomes impossible for the drive wheel to run idle on mud, sands, and the Miyuki road, etc. , and to move being buried and crowding. One[Notoki]
Index
669
When the accident happens
Please do the following treatment without panicking.
670
..PM page..671
Contents
Warning
. earliness.. Basic
operation
It is of sparing [wakari]
The
Handling indoor
equipment
. good.. Safety
[na] ・
of
[to] Comfortable
theory
equipment
How and
to attention
associate
. drinking..
car
Maintenance
Myriad
One[Notoki]
Index
671
..PM page..672
It is of sparing
It doesn't regret by 50 tuning forks.
Please the time to be examined from the symptom and see the item of the coloring character about
the treatment at the emergency.
[A] Food
Armrest . . . . . and Air conditioner
220,227, . . . . . . . . C l e a n . . a i r
. . . . 518 516 seat belt filter..exchange..reception desk..air
. . . . . . with ELR mechanism conditioner..usage..usa
521 working . . . ge..usage..plasma..cluster..How
. . . . . . . . . of ETC to use..air
. . . . . . . . . . conditioner..gas..refrigerative..check.
. . . . . 456 EBD 8-11 Brake..assistance
..brake..assistance..warning
[I] light..warning
light..brake..assistance..a
280 illustration contents .
ttention..supplemental
. . . . . . . . . . of bar
restraint system airbag..supplemental
& [topputeza-anka-] . . .
restraint system
. . . only
airbag..warning
for child seat fixation
light..supplemental restraint
for ISOFIX
system airbag..attention..cu
[irumine-teddoentori-shisutemu] .
rtain..shield..air bag..side
Washer liquid of intelligent
air bag..viscosity..eng
AFS . . . . . . . 546 AFS
ine..oil..attention..warning
OFF switch . . . . . . of
light..cooling water..tank
291 of mirror . . . . . .
capacity..density..winter..ahe
[U] ad..preparation..check..engine..oil.
. . . . . 480
inner 376 windows, 142 of 139 engines
Replenishment..tank..capacity..c ..how . . . . .
heck..method..jet..method. . . . . . to put
.winter..ahead..preparatio it.. 336 engine
n..check..window..defogge switch . . . . . . .
r..cloudy..remove..switch..How . . . of 317 engine
to use..window..lo warning light .
ck..switch..warning..lamp..warning . . . . . . . . . .
light..move..driver's
seat..supplemental restraint
system airbag..driver's
seat..driver's seat..seat
belt..wear..warning light.
672
..PM page..673
It is of sparing
Contents
Engine room
From the engine room [Ki]
When it becomes impossible to start by Warning
578 engine stalls in the room opener . . KeyKeenan..bar..plat
. . . . . . . . . . 662 check . . . . . . e..electron..key..me
. . . . . . 595,596 bonnet 208 engines from chanical..key..key.
which smoke (steam) has risen in fuse box . . .shut..prevention..f . earliness.. Basic
operation
unction..key..warn..k [wakari]
[O] ey..battery..decreas
e..warn..k
. 633 oil.
eyless..entry..wireless..door
(maintenance data). . . How to use
Driving
of 612-614 temporal spare tire . . . . . . Handling
lock..key..key..metal
. . . . . . 197 [ottoman] (foot Wrest) on 628
..sound..tire..hear device
large-scale Moon roof . . . . . . . . . . .
..brake..pad..wear..i
When 94 attention . . . . overheating of 612
ndicator..standard..
amount . . . . . . . The
. . . . . of 66 automatic transaxle of
attention . . . Froude Froude overheating [Ku] Handling indoor
equipment
overheating of 308 automatic car of method . . . value..maintenance..
. . . . . . . . of 210 automatic car of alarm data..kick..down..ai
. . . . . . . r..pressure..
. good.. Safety
. . . . 229 auto driving is done, opener . tire..section..mile [na] ・
. . . . . . . . . . . 662 [o-puna-fuyu;-eruriddoo-puna-] ometer..trip..meter..cloudy. of
[to] Comfortable
theory
. . . . 205 bonnet 208 [o]. 15 attention Take..horn..horn..clearance..so equipment
. . . . . . . . . . . odometers (multiplication nar..back..sonar..cr
mileometer) in the previous state when the eep..phenomenon..clean..air How and
to attention
child is taken 38 attention . . . . . . going
associate
out How to use . . . . . . use gasoline of filter..exchange..cruise..control . drinking..
..car..turn..check.. car
[Ka]
492 hook . . . . . . . . . . . . gasoline of [Ke]
568 maintenance . . . . . . . . . . . . shopping grade..name..glove
Maintenance
(fuel)/removal switch of 490 holder . . . box..horn..horn..meter
. . . . . . . . pollen ..meter..warning
of 614 tank capacity . . . . . cups of light..warning
degree display . . . . . . . . . . . . . . . light..light..blink..warn..di
Myriad
. . 318 outside temperature 439 exterior about splay..economical..d
442 environments rive..make-up..for.. One[Notoki]
To do an environment friendly, economical driving vanity..mirror..pull.
. 552 for 551 handling . . . . . . . . . . cold
ground of . . . . . . . . . 563 cold for 560
environmental protections ..wiper blade . . . . . . ... Index
673
..PM page..674
Seat belt . . . . . . . . . . . .
[Ko] 266 adjustable
Top and bottom of axis adjustment dial . . . . . . . Method of 286 345 non-wearing 50 attention
. 622 light 360 retreat of tool . . . . . . . . . . . . . . . . . . seat belts per 516 working .
. . . light . . . . . . . seat belt of 270 seat belt
593 of lamps (valve) ..exchange . . . . anchorage . . . . . . seat belts warning light
. . . .. 611 court number . . . . . . . . . . . . . . child seat fixed mechanism .
. of W (watt) hook . . . . . . . . . . . . . . . . . wearing
. . . . . . . . . . at 493 breakdowns356 ..46 Expression..seat
[konraito] . . . . . . . . . . . . . .. attention belt..expression..seat
. . . . . of seat only for 632 children belt..separation..storage..seat
belt..cigarette..writer..pilot
[Sa] light..sequentially..shift..m
ode..accident..occur..ro
Third seat om..fixture..How to
232 method . . . . of 234 raising and use..room..light..reception
lowering . . . . . . reclining adjustment of desk..floor..circumfer
the headrest service ence..lighting..luggag
data (maintenance data) storage space e..room..lamp..room..lamp..on
. . . . . . . . . . . . . 610 triangular earth..reception
emergency sign 484 sun visor . . . . . . . . . .
. . 472 sunroofs (large-scale Moon roof) 257 desk..personal..lamp..shift..position..pilot
674
..PM page..675
It is of sparing
Contents
It does. [Se]
S u p e r [Sekandoshi-to] Warning
C V T 227 ..armrest . . . . . . . . . . . ..
. . . . How to use of [ottoman] (foot Wrest). . 229
i . 225 raising and lowering . . . . . .
. . multiplication mileometer of 222 method . . . . . earliness.. Basic
operation
. . . . . . . headrests of 228 getting on and off [wakari]
. . . . . . . seat adjustment to the third seat
. 5 3 0 (odometer) About table . . . . . . . . . . number
Change the . . . . . . . . . . 611 center 476 running of
speed..control..system..work..steps..change 356W of switch . . . . . . Driving
Handling
t h e . . . . of 590 exchange . . . . . . . lights
speed..system..work..Lock-Up..system..w (watt) of [tehi] (headlamp) lamp (valve) device
ork..snow..tire..winter..f before 566 pilot light . . . . . . . . . . . .
or..tire..speed..meter..spare . . 318 security 323 carwashes . . . . . . . .
The
t i r e . . p i l o t
light..sports..sequentiall [So] Handling indoor
equipment
y..shift..mode..smart..en
........
try..start..system..warn..sound..warning
When it becomes impossible . . . . . . 30 running
when abnormally noticing while running of 609
light..light..operation..pilot . good.. Safety
check . . . . . . . . . . running in running [na] ・
light..orange of
doing noting . . . . . . . . . 22
color..blink. When [to] Comfortable
(About pulling. ) . . . . . . . 666 theory
blinking to green 156 equipment
speedometers (speed meter) . . . . . 317
operation pilot light,
it smart enters it How and
155 . . . . . . . . . . [Ta] to attention
. . . When & start associate
Tire . drinking..
system doesn't operate,
F o r car
smart enter it 159 .
[ c h a k u ]
. . 170 of 611 slide
( s e a t
doors ..opening and shutting
b e l t )
. . . . . . . . .
Maintenance
... lamp (front position
..correcting
light) light switch
. . . . . . . . . . of
2 1 4 . .
78 small of attention Myriad
. . s a y i n g . .
. . . . . . . of &
.
start system number . . One[Notoki]
. . .
. . . . . . . . of W(watt)
. . .
. . .
. 2 6 6 . Index
675
..PM page..676
adjustment..system..ring..warning [Na]
light..watt..number..
differential..oil. Inside and outside nature switch (air conditioner)
612 maintenance of amount . . . . . . . . . . . . . . maintenance . . . . . . . . . . . . of
. . . . of oil (maintenance of car) 494 dual 502 interior of 438570 Check . . . . . . . . . . . . .
of 492 deck board . . . . .
. . . . . . . of 356 deck hook . . . . . . . [Ni]
. . . . . of light switch . . . . . . . . . . of . ..eternal..594 on NAVI. AI SHIFT. . . . . . . 536
. . . . . . . . of 566 taillights (taillight)
..supplemental restraint system airbag . . . . . . ..
676
..PM page..677
It is of sparing
Contents
Power window
Sleep 188 number on backing warning light . .
Reception desk window with heat ray . . . . . . . . 195 power 175 power steering Warning
372 shield glass switch . . . . . . on slide door . . . . . . . . . 338 power
fuels door . . . . . . . . . . light where 192 switch
343 fueling remainder amount warning light . . . . . . . . . . . . . . power window
. . . . . . . . . of 614 tank capacity . . . . . doesn't move . earliness.. Basic
operation
. . . . . . . fuel gauge . . . . . . . . . . . . 343 warning light . . . . . . . . . . . . [wakari]
. . 317 fuels entrance ([fuyu;-eruriddo]) . . 20 steering wheels of 611 number . . . . . . . . . .
at 205 fueling ..attention . . . . . . . . . . .. half doors of 356W of light switch . . . . . . .
. . . (watt)
[Ha] Position..adjustment..steering
Handling
Driving
wheel..heavy..become..blow
323 590 exchange . . . . . . . out..shop..install device
headlamp upward pilot light . . . . . ation..option..spare
of 473 high beams (headlamp)35 ashtray
The
. . . . . . . . . . . . . . . . of Lamplight
attention . . . . . . . . Handling indoor
tire..feep..long..sound.. equipment
. to 610 314 parking brake pedal
light..cancel..warn..buzze
. . . . . . check standard value .
r..long..sound..repeat.
. . . . . . . . . . . vehicle exhaust
.reverse..retreat.
emissions manner of operations . . good.. Safety
.buzzer..emergency..blink..light. [na] ・
. . . . . . . . . . . . of
of
358 lamps (valve) 373 lamp (emergency [to] Comfortable
611 number . . . . . . . . . . taillights theory
blinking light)611 hazard switch equipment
of 373W of switch . . . . . . . . . . . . .
. . . . . . . . . . . . . of number
(watt)
. . . . . . . . . . of W (watt) How and
356 light switch . . . . . . . . . . fuse
Number . . . . . . . . . . of to attention
. . . . . . . . . . . . . . 578 pilot lights
W (watt), and prevention mechanism associate
(meter) . . . . . . . . . avoiding (sun visor) . drinking..
. . . . . . . and 193 ..including
for 320 days . . . . . . . 472 516 610 force car
611 pairs of scissors.. How to
use..backup..lamp..retreat..light..lamp..v
alve..exchan [Fu]
ge..watt..number..back..door..opening limiter mechanism
Maintenance
and shutting..water-repellent..fu . . . . . . . of V belt check standard
nction..glass..battery..check..method..battery..go value . . . . . . . . . . . . hooks (pulling)
up..battery..attentio 205 fuel . . . . . . . . . . opening and shutting
n..winter..ahead..preparation..che . . . . . . of 622 fuel cap meter (fuel
Myriad
ck..pad..wear..indicator..brake..pa gauge) 552 for 551 winter ..tire . . . . . . . .
d..wear..indicator..vanity..make-up..f . . . . . .. . . . . preparation and check One[Notoki]
or..mirror..valve..lamp..watt..number. . . . . . . . . . before 205 winter of opening
and shutting . . . . . . . . . . . . . . .
. . of 317 [fuyu;-eruriddo] (fueling entrance)
Index
677
..PM page..678
[He] [Mu]
292 assistance
desk..Moon..roof..opening and
device . . . . . . . . . . . of 291 door
shutting..separation..storage..seat belt..How
mirror . . . . . . . . . . . . of adjusting
to use..headlamp..upward..pilot
light..light..axis..upper and
lower..adjustment..lamp..valve. [Me]
inner mirror . . . . . . . . . . of attention
. . . . . . . . at accident of 3,460,001
..display . . . . . . . . . . . .. of 95 mirrors
678
..PM page..679
It is of sparing
Contents
[Yu] [Re]
Oil pressure..warning Cooling water Warning
light..user..customize..function..act . . . . . when overheating 662 check
method . . . . . . . . . . . . . 599 density
[Yo] and capacity . . . . . . . . . . . .
preparation and checks . . . . . . . . . earliness.. Basic
ive.. operation
before 612 winter 595 ..position . . . [wakari]
torque..control..auto..mode..
. .. 551 [riza-ba-tanku], 596 [reinkuriaringumira-]
switch..car..attention..l
. . . . .
icense..plate..lamp..number-plate
. 524 radar cruise control (with brake
light..light..switch..wa
control) 530 417 Lock-Up system . . . . . . Driving
Handling
[Ra] Furnace device
tt..number..light..cancel..
. . of keeping assistance . . . . . . of
warn..buzzer..light..switch..
. . of 384 lanes low beams The
luggage..room..lamp..watt..nu
(headlamp) number . . . . . . . . . . of
mber..radiator..overheat..tank..cap..position. Handling indoor
W (watt) . . . . . . . . when breaking down equipment
How to use .
on 611 roads566 200 363& washer . . . . .
. . . . . . . 198 opening and
shutting . . . . . . .
[riyauindou;defogga-] [Wa] . good.. Safety
. . . . . 369 . . of 487 wipers of 632 long slide console [na] ・
of
[riyadei;farensharuoiru] of 452 . . . . . . wireless door lock . . . . [to] Comfortable
theory
[riyasanshe-do] of 446 [riyaku-ra-] . . . . wax . . . . . . . . . . . . . . W equipment
of buzzer . . . . 357 reverse (watt)611 ..number . . . . . . . . . . . ..
How and
[Ri] to attention
associate
(retreat)596 glasses of . drinking..
cooling water 612 lamp in density car
and capacity . . . . . . . .
. 296,302 [riyaeakon] of auto
cutting system . . . . . How
to use . . . . . . . . Maintenance
478 ..612 [riyapa-sonaruranpu] . . . . . .
. . of amount . . . . . . . . . . . . . of oil..
611 room mirror of number . . . . . . .
Myriad
[Ru]
One[Notoki]
. . . of W (watt)(inner mirror) 477 integral
reception desk personal
lamp . . . . . of lamp of . . . of 291 rooms
W (watt)611 ..number . . . . . . . . . . .. Index
679
..PM page..680
Supplemental restraint
system airbag/pretensioner Charge warning light P.341
warning light P.333
4WD 4WD warning light P.335 Low fuel warning light P.343
680
[Esutei;ma] [Te]. 1 3
- Please acknowledge the content of this book to be might not corresponding to the vehicle because of the change in the specification etc. of the vehicle. -
- SixOne in January,
in November,of print of NAB-2006
print NAB-2004 * issue* January
issue 16, -2006 first edition
This "Manual"
27 in 4 chome 10 at Nagoya City Nakamura Ward name station The soybean oil ink is used.
The seventh floor in the second Toyota building west pavilion Bookbinding that considers recycling
of printed matter of use 100% of used paper
Used paper mixing rate 100%
About "Protection of individual information policy"It Paragraph 01120023 of recognition number Recycled paper is used.
publishes with http://www.toyota.co.jp. M 28659
- This manual is bound a book considering recycling.
When becoming unnecessary, let's send it to the collection and recycling. 01999. 28659