Professional Documents
Culture Documents
Toyota Wish Manual
Toyota Wish Manual
This bookW i s h The theory of ..drinking.. handling according to the driver's operation.
Discernment.
Read ahead of the use to use it safely and
comfortably.
・Driving defends traffic rule manners, and distributes the nature to a natural environmental protection.
・Read "HDD navigation system manual" of the separate volume also of the installation
of the HDD navigation system.
・Read "DVD voice navigation system system manual" of the separate volume also of the
installation of the DVD voice navigation system system.
・Toyota..shop..install..equipment..shop..option..handle..the..co
mmodity..attachment..manual..read.・Claim
the catalog about equipment in the shop.
・Ask the charge sales staff an uncertain point. -
Acknowledge the content of this book to be might not corresponding to the car because of the change in the specification etc. of the car.
Composition of this book
This book is composed of the following Chapter 8.
Especially, "It would like you to defend without fail for the
safety drive" in Chapter 1 is important. Read firmly.
Chapter 1: I must would like you to defend without fail for the safety drive.
"It is likely to reach injury and a serious accident and a vehicle fire", "General
attention", and the evasion method consolidate in this chapter and it is described. It is
important, and read.
Chapter 7: Maintenance
It explains the method and the daily check of the maintenance of the car.
2
About the display
Display concerning safety
"There is a possibility that those who drive and other person receive injury", "It is
likely to lead to the breakdown and the damage of the vehicle", and the evasion method have
been described by the following display. These are important, and observe it
reading without fail.
Other displays
"Thing convenient when knowing" and "It would like you to know" have
been described by the following display.
3
View of operation explanation (Chapter 3-8)
It explains a basic pronunciation to explain the operation (Chapter 3-8).
Title - Header Tsmetaitol
It is distinguished We will inform that the presence The content of The title of each
according to the hierarchy. of the installation is different depending the page is guided. chapter is guided.
on the grade etc.
- Describe in this book based on the international unit system (unit of abbreviation SI) along with the enforcement of the new measurement
method, and so far{ } It describes in the inside.
4 - Because this page is a sample, the content of the description is different from an actual car.
About the retrieval method
In this book, to read what the customer wants to learn quickly,
the following devices are done.
5
Illustration contents 8
I must would like you to
Contents defend without fail for the
safety drive. 13
Basic operation Haya understanding
(To the person who takes this car for the first time. )
95
Maintenance 399
さくいん 495
6
Contents
・Opening and shutting 116 of door door the glass etc. ・How for engine to start 218
・Adjustment of seat 154 ・How to use of the gear-shift. 222
・Seat arrangement 170 ・How 240 to drive automatic Driving
Handling
・Wearing of seat belt 196 car・Usage 246 of parking brake pedal・View
・Fixation of child seat 204 248 of meter, display light, and warning light・How device
・Adjustment of steering wheel mirror 212 to use of the switch. 280
The
・Handling of air conditioner 298 ・How to use of the indoor equipment goods.
・Handling of ETC 310 (interior light and clock, etc.) 326 Handling indoor
equipment
How
to attention
・About driving rain on the day 382 ・Economical driving 392 associate . drinking..
・Handling at the cold 383 ・For the environmental protection 395
car
・Tool, spare tire, and Tahonootsts 458 ・When overheating 484 Myriad
・When breaking down 468 ・About pulling 488 Oneの
・When blowing out 470 ・When the accident happens 492 と
・When the battery goes up, 480. き
7
Illustration contents
Instrument panel
Door mirror adjustment/storage switch 2 1 4
Accessories outlet main switch 338
The top and bottom of optical axis adjustment dial 2 8 5
Light switch 280
Direction instruction lever 2 8 4
Reception desk fog lamp switch 283
Meter, display light, and warning light 2 4 8 、 2 5 4 、 2 6 2
The reception desk window shield glass
switch with heat ray 2 9 1
Wiper & washer
switch 286
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
Air conditioner operation part 2 9 8 equipment
Multibox(with cup holder
How
& coin pocket) 334 to attention
Accessories outlet 338 associate . drinking..
Riyauindudefoggar (cloudy
car
removing) switch 290
Mirror heater switch 216
Terminal VTR
Refer to separate volume "HDD navigation system manual".
Fuelriddoorpnar
148
Reception desk seat 1 5 7
SRS side air bag 345
Secandoshet 161
Two point expression seat belt 2 0 2
Riyaarmurest 167
Cup holder & Armurestoboccs 335
Third seat 168
Three point expression seat belt 1 9 9
Luggage box 340
- It includes it in the difference of equipment and the option equipment, etc.
10
Illustration contents
Vehicle externals Contents
Warning
Rear wiper 286
Back door 1 2 4
Antenna 341
Light, retreat light, and Riya direction instruction light and braking Basic
. earliness.. operation
light/emergency blinking light 4 2 2 、 4 4 9
Child protector 121
Reception desk wiper 2 8 6
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
Number-plate light 422、449
car
Bonnet 151
Reception desk fog lamp 4 2 2 、 4 4 9
Headlamp 、 Front position
lightReception desk direction instruction light and emergency blinking light 4 2 2 、 4 4 9 Maintenance
Tire 442、453
Side direction instruction light and emergency blinking light 4 2 2 、 4 4 9
Reception desk door Riyadoa 1 1 6
Myriad
Fuel lid(fueling entrance) 148 Oneの
と
き
Index
- It includes it in the difference of equipment and the option equipment, etc.
11
I must would like you to
defend without fail for the
safety drive. 1
"It is likely to reach injury and a serious accident and a vehicle fire",
"General attention", and the evasion method consolidate in this chapter and it
is described. It is important and read.
Warning
13
f
om
a c
r
YaFso
Execute maintenance.
に
It might lead to a serious vehicle breakdown
if it doesn't execute it and is dangerous.
Warning
1.
1. Asking for maintenance execution
Asking
for
maintenance
execution
漓E x e c u t e m a i n t e n a n c e .
14
f
om
a c
r
YaFso
Defend the following matter before
going out.
に
In the worst case, it reaches an unexpected
accident and serious injury if it doesn't guard or,
Warning
it is likely to lead to the death.
2. Attention at the previous state of going out 2.
Attention
at the
- The catalyst device causes the abnormal combustion by a nonflammable gas in the state of machine shortage, and
it is likely to damage it. -
The water temperature warning light (blue) is enough and turning off machine is enough.
澆C o n f i r m a l l d o o r s h a v e c l o s e d s u r e l y b e f o r e i t
runs.
- It opens suddenly while running if the door is not surely closed the door, might cause an
unexpected accident, and is dangerous. The half door warning light (Refer to P.277) lights
when either of door (Include the backing door) is not surely closed.
15
For safety and a comfortable drive
Attention
at the - View might worsen by the glass's humidity's in the car such as rain it becoming impossible to ventilate
previous enough in the car because air cannot be introduced, going up, and becoming cloudy.
state
of going
out
- If the fixation of the steering wheel is insufficient, it divides as the position of the steering wheel is sudden, might
cause an unexpected accident, and is dangerous while running.
16
For safety and a comfortable drive
2.
Attention
at the
- It narrows in the brake pedal and the gas pedal when there are an empty can etc. , and
previous
the brake cannot be operated, and it might cause an unexpected accident as the gas pedal state
doesn't return and is dangerous. Moreover, it is disturbed the movement of the seat, and cannot of going
out
fix the seat, might cause an unexpected accident, and is dangerous.
澀Do not use the floor mat not suitable for the car.
- The floor mat might cause an unexpected
accident by the return's of the gas pedal
correctly not paving, becoming an obstruction of
the operation of the brake pedal if the floor
mat is paved repeatedly, and worsening and
is dangerous.
Fixed clip
Hole of carpet
17
For safety and a comfortable drive
2.
Attention
at the - It dashes out when time that slammed on the brakes and the car are turning luggage, might
previous cause an unexpected accident by the nature's hitting the crew, damaging luggage, and being
state taken in luggage, and is dangerous. -
of going
out Put luggage in a steady state (For instance, to evenness forward of the luggage room)
to the luggage room. The deck hook installation car must fix luggage if necessary
with the net and the rope, etc. with a deck hook of the luggage room. (Refer to P.337. )
- It ignites at the emergency, might connect with a vehicle fire, and is dangerous.
18
For safety and a comfortable drive
澂N e v e r d o d r i v i n g t h a t
drinks sake.
潼Confirm in the body below the floor level in the engine room, there are no
animals of small size of the cat and the rat, etc.
- It might cause the function trouble by animals of small size' being rolled in the fan
and the belt when the engine starts.
19
f
om
a c
r
YaFso
Defend the following matter when you
に
replenish the fuel.
Important injury might be received if it
Warning doesn't guard and it is dangerous.
3.
3. Attention at fueling
Attention
at
fueling
20
For safety and a comfortable drive
滷G u a r d t h e f o l l o w i n g
at fueling. Warning
3.
21
f
om
a c
r
YaFso
Defend the following matter when
you run.
に
In the worst case, it reaches an unexpected
accident and serious injury if it doesn't guard or,
Warning
it is likely to lead to the death.
4.
4. Attention when running
Attention
when
running
- It might cause an unexpected accident by the steering wheel's working of the brake neither the
brake twice power device nor the power steering's working, worsening, and becoming very heavy
and is dangerous if it doesn't engine starts.
- Driving is mistaken while adjusting it, and it might cause an unexpected accident by the seat's suddenly
moving and is dangerous.
22
For safety and a comfortable drive
Warning
4.
Attention
潺Do not put the foot on the
when
brake pedal, and run with
running
the parking brake put.
- It wears out the brake pad early, and overheats the brake, worsens working of the brake,
might cause an unexpected accident, and is dangerous.
- Working of the brake might worsen by overheating when keeping stepping on the brake pedal
and it is dangerous.
23
For safety and a comfortable drive
Attention
when
running
- The temperature of oil goes up too much, and defective lubrication is caused, and the power
steering device might be damaged. (2.0L car <Z grade > and 4WD car)-
The power steering motor might damage by overheating.
(2.0L car <G grade > and 1.8L car < FF car >)
The power steering control is limited to prevent the motor and the computer overheating and the steering wheel
control becomes heavy when maintaining it with power put on the steering wheel the repetition of the steering
wheel control while being stopping and ..-.. minute and low-speed running.
In this case, refrain from the steering wheel control for a while. It returns to usual weight when
about ten minutes pass without doing the steering wheel control.
(2.0L car <G grade > and 1.8L car < FF car >)
- When the operation to which the limitation of the overheating prevention hangs is frequently repeated, it causes the
breakdown of the system.
(2.0L car <G grade > and 1.8L car < FF car >)
24
For safety and a comfortable drive
- It is prohibited to use the car telephone and cellular phones other than hands-free while those Attention
who drive are driving by the law. -
It turns to the telephone when it calls it and when it has had a telephone call note, when
- A rapid brake, rapid acceleration, and a rapid steering wheel in a slippery road slip the
tire, cannot control the car, might cause an unexpected accident, and are dangerous. -
An engine brake by the improvement shift down of the shift and a rapid change in the engine
rotational speed might cause an unexpected accident by sideslipping by the car and are
dangerous. -
Decelerate beforehand in a frozen place such as on the bridge and shade when it is cold,
and run carefully. -
Run carefully in beginning get off about rain so that the road is slipperier.
25
For safety and a comfortable drive
4.
Attention - It might cause a serious vehicle breakdown to damage the engine by not only the engine stall if
running on the flooded road but also the inhalation of the short of electrical equipment and water.
when Check the following item etc. in the Toyota shop when running on the flooded
running road by any chance, and soaked in water.
蘆Effective condition of brake.
蘆Change in amount of oil and qualities such as engine transmission transfers
(4WD car) and Def. (Because water mixes when becoming cloudy, the exchange
of oil is necessary. )
蘆Lubrication is defective in the propeller shaft (4WD car) and each bear and collaborate each.
潭Do not push the reception desk defroster switch when you operate
the air conditioner when humidity is very high.
- It is cloudy in the surface of the outside of the window glass in the temperatures fluctuate of air and the
window glass, and might disturb view.
26
For safety and a comfortable drive
澂When stacking *
- The drive wheel was not able to run idle on mud,
sands, and the Miyuki road, etc. , and to move being buried Warning
and crowding.
4.
- Confirm surrounding safety enough when you attempt the escape from the Attention
stack. The one is damaged by the power of the escape, and the accident resulting in injury or death might be caused
and it is dangerous. - when
Do not rotate the tire at high speed. The burst (explosion), and the tire might running
cause an unexpected accident by abnormal overheating about driving parts (differential
gear etc.) and is dangerous. -
Note the following might damage a transmission and a differential
gear, etc. when you unavoidably repeat advancement and the retreat for
the escape from the stack.
蘆The gear-shift 綺O r , 緘After it puts it in certain, ..gas pedal.. ..lightly.. ..stepping...
Give to me. Moreover, never step on the gas pedal while operating
the gear-shift.
蘆Race neither excessive revving nor the tire.
蘆Operate the brake after the engine rotation lowers when the tire
runs idle in excess.
蘆Discontinue this operation when you cannot escape even if it goes several times. -
The following method is effective for the stack escape.
蘆Remove the soil and the snow before and behind the tire.
蘆Allot the tree and the stone, etc. under the tire.
- When the rope is pulled to the pulling hook and the suspension parts, etc. putting
it, the pulling hook and the suspension parts might be damaged. Do not forcibly pull,
and request it to the Toyota shop and JAF, etc.
27
For safety and a comfortable drive
Attention - When the brake pad is wet, it worsens working of the brake, and is taken the steering wheel
effective only of one that has not been wet, might cause an unexpected accident, and is dangerous. -
when Confirm the brake works normally lightly stepping on the brake pedal several times
running until effective recovers very noting surrounding safety when effective is bad.
- It flies the body when time that slammed on the brakes and colliding, and the head etc. are strongly
stricken, and it reaches important injury or, in the worst case, it is likely to lead to the death.
28
For safety and a comfortable drive
4.
- In the worst case, it reaches important injury or, it is likely to lead to the death by hitting the one Attention
outside the car etc. , and throwing the head at the window frame at a rapid brake while running when the hand and
the face have been produced. - when
Is not the waist in the opening of the Moon roof or disregard it. The roof dents, and it is thrown out running
from the car at the emergency, and it reaches important injury or, in the worst case, it is likely to
lead to the death.
- In the worst case, it reaches important injury when placed between the door glass and the Moon
roof or, it is likely to lead to the death.
29
For safety and a comfortable drive
濂Do not run with Fta of the glove box and small articles putting
opened.
- It dashes out when slamming on the brakes luggage, might cause an unexpected accident,
and is dangerous.
Warning
4.
- It disturbs driving person's view, and becomes an obstruction of the safe driving while starting
and running, might cause an unexpected accident, and is dangerous when running with the one put.
- The bumper might be damaged, and risk the speed and run carefully
when you run in the following places.
蘆When passing over the place with the difference in the doorway etc. of the parking lot
蘆When you run in the place where the inclination like the slope etc. of the multistory parking garage is sudden
蘆When garrisoning stopping along the place and the shoulder that includes trigs etc.
蘆When you run on the road in the ruggedness and the rut that is
蘆When you pass the hollow (hole) etc.
蘆When it goes into the acclivity and the downward slope from the smooth road, and it goes into the smooth road from the
acclivity and the downward slope
澣Do not pull the driver's seat door lever while running.
- Do not pull the driver's seat door lever while running. In the worst case, it reaches
important injury or, it is likely to lead to the death by the door's opening and being thrown out outside
the car.
30
f
om
a c
r
YaFso
Defend the following matter while running
when abnormally noticing.
に
It might cause an unexpected accident and
serious injury if it doesn't guard and is
Warning
dangerous.
5. While running when 5.
abnormally noticing
While
running
when
abnormally
漓Stop in the place of safety, and
treat it at once when the warning light noticing
- An unexpected accident might be caused, and the engine etc. be damaged when
running while light and blinked. Confirm the content of the warning light, and do appropriate treatment.
(Refer to P.262. )
- Stop in the place of safety at once and contact the Toyota shop when the warning light
becomes the following.
蘆In the state of lighting even if you release the parking brake while the engine is rotating.
In this case, it might cause an unexpected accident as working of the brake worsens, and the slip
distance for brake becomes long and is dangerous. Step on the brake pedal hard when
effective is bad.
蘆The brake warning light : the ABS& brake assistance warning light or in the state of lighting at the
same time as ..the ABS warning light...
In this case, abnormality might not only occur in ABS or the brake assistance
(2.0L car <Z grade > and 4WD car) but also the vehicle becomes unstable in the
brake of strengthening.
31
For safety and a comfortable drive
While
running
when
abnormally
- Firmly have the steering wheel, apply the brakes gradually, and reduce speed. A
rapid brake and a rapid steering wheel might not be able to control the vehicle. -
The blowout and the burst are thought at the following time.
蘆When the steering wheel is taken.
蘆When there is an abnormal vibration.
蘆When the vehicle inclines abnormally.
- Do not run while blowing out. It becomes an unstable running if keeping running
while blowing out, might cause an unexpected accident, and is dangerous. Moreover, the tire
disc wheel and the suspension and the body might be damaged. Exchange
it at once for the spare tire.
32
For safety and a comfortable drive
While
- Under such a condition, the brake liquid and the fuel leak or, it uses it so that there are a
running
transformation of a suspension parts, a tire disc wheels, and the drive and the system parts, etc. and possibilities
of damage and it might cause an unexpected accident and is dangerous. - when
Do not use as it is and consult the Toyota shop when the leakage and damage are abnormally
found.
noticing
- The warning sound generates the warning sound (metallic sound "Key key") by the one by
the brake pad wear indicator while running, and informs those who drive of the brake pad's
having approached the use limit.
Receive the check at once in the Toyota shop when you generate the warning sound.
- It is lost of the brake pad when keeping running with the warning sound generated,
damages the brake parts, and worsens effective, might cause an unexpected accident, and is
dangerous.
33
f
om
a c
r
YaFso
Defend the following matter when you
stop garrisoning.
に
In the worst case, it reaches an unexpected
accident and serious injury if it doesn't guard or,
Warning
it is likely to lead to the death.
6.
6. Attention when stopping garrisoning
Attention
when
stopping
漓The parking brake is put, and stop, and lock the engine
when parting from the car.
garrisoning - When parting from the car, the engine is obligated to stop without fail, and to be
locked by the law. Moreover, the one in the vehicle theft and the car might not be
stolen, and do not put valuables etc. in the car. -
Defend following when parting from the car. It begins to move by uninhabited by the
car if it doesn't defend, might cause an unexpected accident, and is dangerous.
蘆The gear-shift 綟.
蘆Put the parking brake.
蘆Stop the engine.
蘆Lock the door.
- It might connect with a fire when there are combustible one in the rear side of the vehicle and the vicinity of the exhaust
tube and is dangerous. -
Stop the rear end of the vehicle about 30cm or more apart when the rear side of the vehicle includes
wood and plywood, etc.It discolors and it transforms it with the vehicle exhaust emission, and when the space is a
little, it might connect with a fire and is dangerous. -
Neither dry grass nor the wastepaper, etc. must not run on, and pull up a car though are
combustible. When it is to become a high temperature, and near the combustible, it is likely to connect with a fire and the exhaust
tube and the vehicle exhaust emission are dangerous.
34
For safety and a comfortable drive
澆D o n o t r e v w h i l e
stopping. Warning
6.
Attention
- It overheats the exhaust tube, might connect with a vehicle fire, and is dangerous.
when
stopping
garrisoning
- It might connect with a vehicle fire by the gas of the writer and the spray can naturally leaking, and
exploding because it becomes a high temperature very much in the car and is dangerous. -
The room might be made dirty, and Electricity Division goods cause to be short by the can of the
carbonated drink exploding. -
The transformation and the crack of glasses of a plastic lens and a plastic material might be caused
because it becomes a high temperature very much in the car.
潸S t o p t h e e n g i n e w h e n
you take a nap.
- It might connect with a vehicle fire because of an abnormal overheating of the accident by the jack
rabbit start of the car and the engine by unconsciously moving the gear-shift, and depressing the gas
pedal when taking a nap while started up an engine and is dangerous.
The exhaust tube has been damaged, and moreover, the vehicle exhaust emission invades in the car, it becomes
CO intoxication, and it reaches important injury or, in the worst case, it is likely to lead to the death in the
place where ventilation is bad.
35
f
om
a c
r
YaFso
Defend the following matter to prevent
the gas inhalation.
に
In the worst case, it reaches important
injury if it doesn't guard or, it is likely to
Warning
lead to the death.
7.
7. Attention to vehicle exhaust emission
Attention
to
vehicle
exhaust
- It becomes CO intoxication with carbon monoxide (CO) that fills the vehicle exhaust emission, and is included
in the vehicle exhaust emission, and it reaches important injury or, in the worst case, it is likely to lead to
the death in the place enclosed in the garage etc.
- The vehicle exhaust emission invades in the car, it becomes CO intoxication if the snow piles in the circumference
of the car while started up an engine, and it reaches important injury or, in the worst case, it is likely
to lead to the death.
36
For safety and a comfortable drive
7.
Attention
- Moreover, receive maintenance to the damage of the hole such as the corrosion of the exhaust tube, the crack,
to
and the patch person part in the Toyota shop when you notice abnormality etc. of the exhaust sound. The vehicle vehicle
exhaust emission invades in the car, it becomes CO intoxication if it uses it as it is, and it reaches
exhaust
important injury or, in the worst case, it is likely to lead to the death. -
emission
The exhaust tube becomes a high temperature with the vehicle exhaust emission. Do after cooling the exhaust tube enough
when you touch the exhaust tube by the check etc.
- The vehicle exhaust emission invades in the car, it becomes CO intoxication if running while opened,
and it reaches important injury or, in the worst case, it is likely to lead to the death. Confirm the
backing door has closed without fail before it runs.
37
For safety and a comfortable drive
Attention
- Completely open all windows. -
to
vehicle Make the inside and outside nature switch of air-conditioning
exhaust an air introduction, maximize the amount of the wind, and
emission
put fresh air in the car. -
Receive maintenance promptly in the
Toyota shop. It becomes CO intoxication with
the vehicle exhaust emission when leaving it as it
is, and it reaches important injury or, in the worst
case, it is likely to lead to the death.
38
f
om
a c
r
YaFso
Defend the following matter when
you take the child.
に
In the worst case, it reaches an unexpected
accident and serious injury if it doesn't guard or,
Warning
it is likely to lead to the death.
8. Attention when child is 8.
taken
Attention
when
child
- The child might cause an unexpected accident the child's operation is anxious in the passenger's seat, and it
not only becomes an obstruction of driving but also touching the driving device and it is dangerous. -
Use the child protector when you make the child sit on the
rear seat. The door can be prevented the child's mistaking and being opened in the car.
Refer to P.121 for the use of the child protector.
39
For safety and a comfortable drive
滷L e t t h e c h i l d w e a r t h e
Warning seat belt, too.
8.
Attention - Might it be not possible to finish supporting when a rapid brake and colliding when the
child is embraced on the knee, the child throw out, and it reaches important injury or, in the
when worst case, it lead to the death. -
child Wear the seat belt even to the rear seat. (Refer to P.196. )
- Only the direction up which it winds up operates when the seat belt with the child seat
fixation mechanism draws out the belt to the last minute fully with the mechanism used when
the child seat is fixed (lock mode). (Refer to P.209. )-
The belt cannot be drawn out when it operates the child's playing with the seat belt and by mistake,
and the belt coils around the neck by any chance, and it reaches important injury like suffocation
etc. or, in the worst case, it is likely to lead to the death.
Cut the seat belt with scissors etc. when it enters such a state by any chance
by mistake, and the buckle cannot be removed.
40
For safety and a comfortable drive
- In the worst case, it reaches important injury by placing the hand, the head, and the neck, etc. when Attention
closing when the child operates it or, it is likely to lead to the death. -
The door might be opened while running, the child throw out outside the car, and it reaches when
important injury or, in the worst case, it lead to the death. - child
The child must not operate it with a child protector (Refer to
P.121) and a window lock switch (Refer to P.132) by mistake. Moreover, is
taken
operate it noting that other people's neither hand, head nor necks, etc. are placed when
you close the door glass.
- In the car under hot weather, it becomes heatstroke and dehydration if it becomes a high temperature very much,
and the child is left, and it reaches important injury or, in the worst case, it is likely to lead to the death. -
41
f
sa
he
u tt
o
Ab
Defend the following matter about
the seat.
In the worst case, it reaches an unexpected
accident and serious injury if it doesn't guard or,
Warning
it is likely to lead to the death.
1.
1. Attention of seat
Attention
of
- The driving operation is mistaken if correct driving posture is not taken and it not only causes an
unexpected accident but also the effects such as seat belts and SRS air bag headrests are not demonstrated, and
it reaches important injury or, in the worst case, it is likely to lead to the death.
Refer to P.155 for correct driving posture.
滷S h a k e t h e s e a t b e f o r e
..lightening.., and confirm
fixation surely after adjusting
the seat.
- Important injury that moves if not fixed the seat, causes an unexpected accident, and is related
to the life might be received and it is dangerous.
42
About the safety equipment
Warning
1.
Attention
潺The back must not run knocking down the drip
more than the necessity either. of
seat
- The waist belt shifts from the hipbone when collide or bumped from behind when the back also knocks
down the drip more than the necessity, the body receives slipping and strong pressure under the seat belt,
and it reaches important injury or, in the worst case, it is likely to lead to the death.
- Important injury that is not demonstrated the effect of the seat belt and the headrest enough when cannot
not only take correct driving posture but also colliding and is related to the life might be received and it
is dangerous.
43
About the safety equipment
澁D o n o t r u n w i t h t h e
Warning headrest removed.
1.
Attention - Do not run similarly in the headrest of the Secandoshet third seat
while lowered. A big impact joins the neck when colliding, the important injury related to
the life might be received, and it is dangerous. The headrest of the reception desk seat
of
must adjust height so that the center of the headrest may become behind the ear, and put the
seat
headrest of the Secandoshet third seat into the raised state.
潯Guard the following about the getting on going down to the third
seat.
- Let me be sure to fix Secandoshet after it gets on the third seat and it descends.
The important injury related to the life by the movement of the seat when time that slammed on the brakes
and colliding if it is not made to fix, and the hit to the crew, etc. might be received and it is dangerous. -
Remove Secandoshetobelt from the clip when you get on Secandoshet
after it gets on the third seat and
it descends. Important injury that doesn't
demonstrate the effect with an enough seat belt
when colliding when the seat belt is installed with
the seat belt placed between the clip, and is
related to the life might be received and it is
dangerous.
Clip
44
About the safety equipment
Do not do the operation that is arranged the seat, and returned while running. The
important injury related to the life might be received when it applied the brakes and when it 1.
45
About the safety equipment
Attention
- Guard the following about the Big cabin mode and the super-long
space mode.
of - The back knocked down must not run taking the person after the drip either. The important injury related
seat to the life when time that slammed on the brakes and colliding might be received and it is
dangerous. -
Confirm the light shake of the seat and fixation surely when it makes
to the Big cabin mode and the super-long space mode, and it returns
it. Important injury that moves while running if not fixed the seat, causes an unexpected accident,
and is related to the life might be received and it is dangerous.
46
f
sa
h e
u tt
o
Ab
Defend the following matter about the
seat only for the child.
In the worst case, it reaches an unexpected
accident and serious injury if it doesn't guard or,
Warning
it is likely to lead to the death.
2. Attention of seat only 2.
for child
Attention
漓Let a small child who cannot correctly wear the seat belt of the car sit of
on the seat only for the child appropriate for the body. seat
- A complete safety protection support (baby seat) is necessary for the baby including the head and the neck. The only
head because extremely heavily compared with other parts baby's neck is not steady. for
The baby must let me sit on an appropriate baby seat. - child
Infant's figure is different from the adult who is the design object of the seat belt.
Infant's pelvis is small, and it hangs to not only the position where the pelvis is low but also
the abdomen in a usual seat belt. In the worst case, strong pressure is received to the abdomen with
the seat belt when colliding, it reaches important injury or, it is likely to lead to the death.
The infant must let me sit on the seat only for an appropriate child.
47
About the safety equipment
- Install the seat only for the child in the rear seat.
- Do not forcibly install the seat only for the
child, and install it in passenger's seat side
Secandoshet when you cannot secure the enough
space safely installed by the position of the
driver's seat in driver's seat side Secandoshet.
48
About the safety equipment
- Never install the seat only for the child in the passenger's seat for.
- The high impact joins the back of the seat
only for the child when passenger's seat S RS
air bag swells when installing it for and it
is dangerous.
Warning
2.
Attention
- When the seat (child seat baby seat) only for the child who fixes with
bar & Topptezarancar only for the child seat fixation for ISOFIX is
installed, confirm there is neither foreign body around bar & Topptezarancar
only for the child seat fixation for ISOFIX is a god not all-in of the seat
belt etc.
- It flies when the child seat baby seat is not fixed when the foreign body and the seat belt,
etc. are bitten and it crowds, and it collides, and it reaches important injury or, in the worst
case, it is likely to lead to the death.
- Tension it until Tezarbelt picks up the slack without fail when you
install the child seat baby seat.
- The important injury related to the life when colliding might be received if Tezarbelt
doesn't correctly put it and it is dangerous.
Tezarbelt Tezarbelt
49
About the safety equipment
2.
Attention
of
seat
only
for
- Do not lower the headrest after the headrest is improved and it
child fixes to Topptezarancar when you install the child seat baby seat
with the headrest raised.
- In the worst case, the child seat baby seat moves when Tezarbelt's hitting the
headrest if the headrest is lowered, slackening, and colliding, it reaches important
injury or, it is likely to lead to the death.
Tezarbelt
Headrest
Tezarbelt
Headrest
- It might cause an unexpected accident by hitting the crew and the one, etc. when having
applied the brakes when indoors leaving it while detached from the seat and is dangerous.
50
f
sa
he
u tt
o
Ab
Defend the following matter about
the seat belt.
In the worst case, it reaches important
injury if it doesn't guard or, it is likely to
Warning
lead to the death.
3. Attention of seat 3.
belt
Attention
of
The high impact is received when the seat belt is not worn, the body is not maintained in
the seat when time that slammed on the brakes and colliding if it doesn't correctly wear it,
the body is thrown or the SRS air bag swells and it is dangerous. Moreover, it reaches important
injury by being thrown out outside the car or, in the worst case, it is likely to lead to the death.
- The back also must adjust the drip, set up the upper part of the
body, and sit ..waist.. deeply disregarding it.
Shoulder belt
- Put it enough on the shoulder.
(Do not hang to the neck, and shift from the shoulder. )
- Wearing the seat belt is obligated
by the law. Those who drive must run
after all crew confirm whether to have worn
the seat belt correctly according to the
following use.
Waist belt
- The hipbone must stick to
a low position as much as possible.
without fail
- Do not twist.
51
About the safety equipment
- Set up the upper part of the body, and wear the seat belt to the seat deeply in the waist or the state of the digit.
- Refer to P.155 for the good posture.
- Do not wear the shoulder belt of the seat belt by hanging to the neck and passing
Warning the armpit.
- Wear the shoulder belt of the seat belt to
3. take enough to the shoulder without fail. -
Strong pressure is received to the abdomen etc. when colliding
Attention when the position in which the belt is passed is wrong and it
is dangerous.
of
seat
belt - Adjust the adjustable seat belt anchor surely. (Refer to P.200. )
- Adjust it at the position where it is high only for the seat belt to finish not hitting the neck and
to take enough to the center of the shoulder. -
Confirm fixation surely after it adjusts it.
- The waist belt of the seat belt must make it stick to a low position as much as possible
and wear the hipbone.
- Strong pressure is received to the abdomen etc. when
colliding when the waist belt of the seat belt shifts
from the hipbone and it is dangerous.
52
About the safety equipment
滷The be getting pregnant woman also must wear the seat belt correctly.
However, confirm notes to the doctor. -
Wear wearing the seat belt under the pregnancy under the swelling of the stomach so that the
waist belt may hang to the position where the hipbone as possible is as low though it is
basically similar to the time usually worn. Warning
Moreover, surely avoid the swelling of the stomach through the shoulder and wear the shoulder
belt to hang to the chest. - 3.
In the worst case, not only the mother's body but even also the embryo reaches important injury or,
it is likely to lead to the death by the belt's digging into to the swelling of the stomach when Attention
time that slammed on the brakes and colliding if the belt has not been correctly worn.
of
Shoulder belt
- Avoid the swelling of the stomach seat
and wear it to hang to the chest.
belt
Waist belt
- Wear the hipbone under the swelling
of the stomach to hang to a low
position as much as possible.
53
About the safety equipment
Attention In the worst case, correct driving posture is not demonstrated the effect with
an enough seat belt when colliding when the seat belt twists, is loose or it
doesn't lock surely, reaches important injury or, might lead to the death. -
of
The impact power cannot be distributed enough when colliding when twisting and it is
seat dangerous. -
belt
Unpick it to install it correctly when the belt has twisted. Consult
the Toyota shop when the twist doesn't get loose well.
- Do not use it applying slack to the seat belt with the clothespin and the clip,
etc.
- The amount of the movement until the body is restrained
with the belt when colliding when the shoulder
belt is too loose grows, the belt presses the chest etc.
, and it is dangerous. Moreover, the high impact is
received when the head is thrown at the steering wheel
or the SRS air bag swells and it is dangerous.
- When inserting it in the buckle of the plate, the plate and the buckle hear, "Catitsu" and the sound are
heard, and it is confirmed that it is surely ..the god combination...
- The seat belt comes off when the plate might
not completely fit in the buckle when the
foreign body enters, and it collides and it is
dangerous.
54
About the safety equipment
In the worst case, the effect with an enough seat belt is not demonstrated when colliding Attention
when the damaged seat belt is used as it is, it reaches important injury or, it is likely to lead
to the death. -
of
Place neither seat belt nor the plate between the seat and the door. It might
be damaged when narrowing, and dangerous when using it as it is. seat
belt
- It becomes loose, it is possible to be worn out, and exchange seat belts that do not
operate normally at once. Moreover, do not receive the high impact due to the accident, and
do not use a damaged seat belt. When colliding, an original function cannot be demonstrated
enough.
- There is a possibility that the belt cuts
when colliding when using it as it is. Moreover,
it doesn't work normally, the effect with an enough seat belt is
not demonstrated, and it is dangerous. -
Exchange it at once for the new article
of pure Toyota when the seat belt doesn't
function normally.
55
About the safety equipment
Warning - Remodel, resolve or neither installation nor detach the seat belt with
the pretensioner.
3. - It is likely not to operate normally
when the seat belt with the pretensioner
Attention is inadequately handled, and
repair in the Toyota shop.
of
seat
belt
- Do not use organic solvents such as benzine and gasoline to clean the seat
belt. Moreover, do not bleach, and do not dye the belt. Strength decreases.
- The effect with an enough seat belt is not demonstrated
when the performance of the seat belt decreases, and
it collides and it is dangerous. -
Do not use the seat belt until drying by
using the soapless soap or lukewarm water
when you clean it.
56
f
sa
h e
u tt
o
Ab
Defend the following matter about
the SRS air bag.
In the worst case, it reaches important
injury if it doesn't guard or, it is likely to
Warning
lead to the death.
4. Attention of 4.
SRS air bag
Attention
漓The SRS air bag is a device that assists the seat belt, and no one
to take the place of the seat belt. of
S
R
In the worst case, the effect of the SRS air bag might not be able not only to be
demonstrated enough when colliding if it sits on the seat by the good posture, and the seat belt S
air
is not worn correctly but also it reaches important injury by a strong impact when the SR S
bag
air bag swells or, lead to the death.
Refer to P.196 for a correct wearing the seat belt.
- Adjust the seat at a correct position, and sit on the seat by correct posture that the back also applied
the back to the drip.
- The high impact is received when the SRS air bag swells when it gets on the development department of the
SRS air bag by the cover guess worth and posture that approaches too much and it is dangerous.
57
About the safety equipment
- Do not run with the one put as the one is held on the knee between the
crew and the SRS air bag.
- It flies the one when the SRS air bag swelled
and it strikes the face, and normal operation
of the SRS air bag is disturbed and it is
Warning
dangerous.
4.
Attention
of
S - Start not leaning against the door, and do not approach the reception desk center
R rear pillar and the roof side part. (SRS side air bag &SRS curtain shield air
S bag installation car)
air
- The high impact is received to the head etc. when
bag
the SRS air bag swells and it is dangerous.
Especially, be careful when the child
is taken.
- Do not run in the state that makes the child stand in front of passenger's seat
SRS air bag, and holds on the knee.
- The high impact is received when the SRS air
bag swells and it is dangerous.
58
About the safety equipment
- Consult the Toyota shop in the SRS side air bag installation car when detaching, the installation, S
air
the resolution, and the repair of repapering and the reception desk seat of the epidermal of the
reception desk seat are necessary. Moreover, do not remodel the reception desk seat. bag
59
About the safety equipment
4.
Attention
60
About the safety equipment
澆Guard the following when you install the car articles etc.
The SRS air bag might not operate normally, and it swells by mistake, it reaches important
injury or, in the worst case, it lead to the death if it doesn't defend. -
Do not cover the development department of the
SRS air bag with the cover and the sticker, etc. Warning
Attention
Sticker of
S
R
- Do not put the one of the aromatic substance
S
etc. on the Instrument panel and the air
dashboard, and do not lean the umbrella etc.It
bag
flies passenger's seat SRS air bag when
normally it doesn't operate or the SRS
air bag swells and it is dangerous.
61
About the safety equipment
- In the SRS curtain shield air bag installation SRS air bag development department
car, install accessories or neither
hands-free mike nor the suspender, etc.
around the SRS air bag development department such
as the reception desk window glass, the
Warning
reception desk door glass, the reception desk
center rear pillar, the roof side part, assist
4.
grip, and ceilings. It flies when the
SRS curtain shield air bag swells
Attention
and is dangerous.
of
S
R - The electric wave etc. of the wireless machine might negatively affect the computer
S that operates the SRS air bag, mis-operate the SRS air bag, and are dangerous. Consult
air
the Toyota shop when you install the wireless machine etc.
bag
62
About the safety equipment
- Important injury such as the burns might be received because complete parts are very hot and
it is dangerous.
63
f
sa
h e
u tt
o
Ab
Defend the following matter about
the ABS brake assistance.
It might lead to the important injury related
to an unexpected accident and the life if it doesn't
Warning
guard and is dangerous.
5.
5. Attention of
A
ABS brake assistance
B
S ・
64
f
sa
h e
utt
o
Ab
Defend the following matter
about TRC. VSC.
It might lead to the important injury related
to an unexpected accident and the life if it doesn't
Warning
guard and is dangerous.
6. Attention 6.
of TRC. VSC T
R
C ・
unexpected accident and is dangerous also in the state that TRC operates. Drive especially carefully when it
always bears in mind, and the slipping display light (Refer to P.258) blinks to the safe driving. of
V
S
C
65
iv
dr
h e
u tt
o
Ab
Defend the following matter about
the automatic car.
In the worst case, it reaches an unexpected
accident and serious injury if it doesn't guard or,
Warning
it is likely to lead to the death.
1.
1. Attention of
automatic car
Attention
- Down of kick
It can be rapidly accelerated by engine revolutions' automatically changing into a low-speed
gear if the gas pedal is fully depressed while running, and rising. This is called a down
of the kick.
- The car starts rapidly when the gas pedal is mistaken for the brake pedal and it steps, it causes an
unexpected accident, and it reaches important injury or, in the worst case, it is likely to lead to the
death. -
When retreating, it becomes difficult to operate
the pedal because it becomes posture in which the body
is twisted. Note that it can ensure the
pedal operation. -
Can take be correct driving posture
when move the car a little, and step on
the brake pedal and the gas pedal
surely.
66
About the driving device
- The brake operation by the left leg might cause an unexpected accident as the reaction in the emergency Attention
is delayed and is dangerous.
of
automatic
潺Starting up an engine must start up an engine with stepping
on the brake pedal firmly. car
- As for the gear-shift, the wheel is fixed because of safety. 綟It puts, and the brake pedal is ..paving...
The debt stepping engine must start.
67
About the driving device
1.
Attention - 緜It might cause an unexpected accident because neither nor the engine brake work
completely and is dangerous. -
緜The lubrication of oil in an automatic transmission worsens when running
of
at Chou time, and it is likely to break down.
automatic
潛D o n o t r e v w h i l e
stopping.
- 綟・ 緜It is, and the car starts rapidly, and it might cause an unexpected accident and is dangerous.
68
About the driving device
1.
潭The gear-shift in 1.8L car (FF car) on the slope etc. 綺・ 絲. Attention
In 1.8L car (4WD car) 綺・ 笳・ 笆・ 綢. 2 . 0 L ( G g r a d e )
Then,綺・ 絲・ Silk gauze、 I n 2 . 0 L c a r ( Z g r a d e ) 綺・ 綯..putting... of
Neither reeling nor never retreat with.
- To similar緘N e v e r a d v a n c e b y i n e r t i a w i t h p u t . I t s t a l l s , automatic
it might cause a breakdown and an unexpected accident by the steering wheel's working of the
brake worsening, and becoming heavy, and it is dangerous. car
69
iv
dr
h e
u tt
o
Ab
Defend the following matter
about 4WD car.
In the worst case, it reaches an unexpected
accident and serious injury if it doesn't guard or,
Warning
it is likely to lead to the death.
2. 4
2. Attention of 4WD car
Attention
of
W
D
- 4WD of this car (active torque control 4WD) is only for the on-road.
Be not, and do not drive putting for running in the off-road and the rally running, etc.
because 4WD of securing roadholding in a general road ..impossibility...
滷R u n c a r e f u l l y o n a
slippery road.
- No versatile car even if it is called 4WD car. Do carefully as well as a general car, and always bear
the safe driving in mind about the operation of the accelerator, the steering wheel, and the brake.
70
About the driving device
car
- It might cause a serious vehicle breakdown to damage the engine by not only the engine stall if the underwater
running of the cross a river etc. is done but also the inhalation of the short of electrical equipment
and water. -
Check the following item etc. in the Toyota shop when soaked in water
by any chance.
蘆Effective condition of brake.
蘆Change in amount of oil and quality such as engine transmission
transfer Def. (Because water mixes when becoming cloudy, the exchange of oil is
necessary. )
蘆Lubrication is defective in the propeller shaft, each bear, and collaborate each.
71
About the driving device
Normal
Attention
Studless tire
. coexistence use example .
of
W - Install all tires of the same size, the same manufacturer, the same brand, and the
D
same tread pattern (ditch pattern) in the tire by a specified size. Moreover, do not install
car
the tire with a remarkable wear-out difference mixing it. -
It might connect with a vehicle fire in the worst case by oil leaking and burning by the temperature of
oil generating an always abnormal rotation difference by the tire in the front, back, left and right if the
tire is existing together used, applying impossible power to the drive and the system parts (differential
gear), and rising and is dangerous.
- The drive and the system parts are negatively affected in the following cases as well as the coexistence use for the
tire, and execute the check of the air pressure in the tires.
蘆When the difference of the air pressure of four wheels is remarkable.
蘆When the air pressure shifts from a specified value. -
Rotate the tire around the wear-out of the tire to keep even, and to extend longevity
to four wheels. (Refer to P.409. )-
Do not install the disc wheels other than specification when you exchange the
disc wheels. (Refer to P.453. )
72
i
ma
t
ou
Ab Defend the following matter when it checks and
you maintain it.
It might cause an unexpected accident and
serious injury if it doesn't guard and is
dangerous.
Warning
Read "Maintenance note" about
1. Attention when checking and maintaining it details of maintenance.
1.
Check
・
Attention
when
漓S t o p t h e e n g i n e w h e n maintaining
you check the engine it
- It might cause an unexpected accident by the hand and clothes and tool being rolled when it
touches the rotation parts such as belts and fans while the engine is rotating or it approaches and
is dangerous. Moreover, note that the cooler fan might begin to turn suddenly when the
temperature of cooling water is high even if the engine has stopped. Do not bring the fire
close to the battery and the fuel piping. It explodes, important injury might be received,
and it is dangerous.
滷It is not necessary to touch the high temperature part such as the engine, the exhaust tubes, and
radiators immediately after the engine stop.
- The burn might be done. Note that oil and other liquids
might be high temperatures.
- It might lead to the breakdown and a vehicle fire by the short-circuit of electrical equipment when water
is sprinkled in the engine room and is dangerous.
73
About maintenance
1.
Check
・ - It causes the car breakdown, and when water splashes to electric parts etc. that the audio and
Attention floor carpet under includes, it might connect with a vehicle fire and is dangerous.
when
maintaining
it
潸Note that water doesn't splash directly to the brake when you
wash a car.
- Working of the brake might not be able to worsen, and it rusts, it might cause
clinging of the brake, and to run by freezing when water enters in the brake device.
澁Do not use fuses other than regulated capacity when you
exchange fuses.
- It overheats, damages wiring by a fire, might connect with a fire, and is dangerous.
澀Do not replenish the washer liquid when time when the engine
is hot and the engine start.
- It might break out when hanging to the engine etc. because an alcoholic element is contained
in the washer liquid and is dangerous.
潯Confirm neither the tool nor the cloth are left behind in the
engine room after checking the engine room.
- If the tool and the cloth, etc. used for the check and the cleaning are left behind in the engine room,
it might connect with a vehicle fire because it causes the breakdown, and it becomes a high temperature moreover
in the engine room and is dangerous.
74
i
ma
t
ou
Ab
Defend the following matter about
the tire.
In the worst case, it reaches an unexpected
accident and serious injury if it doesn't guard or,
Warning
it is likely to lead to the death.
2. Attention of tire 2.
Attention
漓C h e c k t h e t i r e a s a d a i l y c h e c k .
- The check of the tire is obligated by the law. - of
- Adjust the specified air pressure after confirming correct air pressure with the table or P.453 of
"Tire inflation pressure" pasted to the body side where the driver's seat door was opened.
The stability of the vehicle not only is ruined when it is lower than the specified air pressure but also the
tire does Catayomamets. The tire is a burst (explosion), might cause an unexpected accident
by standing wave phenomenon * when high-speed running, and it is dangerous. Include the
spare tire by the daily check, and check that the tire inflation pressure is specified
air always pressure.
- When running at high speed, the tire is a wave phenomenon.
- The management of the air pressure of a super-flat tire (17-inch wheel installation car) is especially important
compared with a usual tire. Check the air pressure regularly especially to become proper because a
super-flat tire is a tire to which it gives priority to the driving performance. Check the air pressure once
every two weeks (Once a month even if it is the lowest) before the drive of the long distance.
75
About maintenance
- The drive and the system parts are negatively affected in the following cases as well as the coexistence use for the
tire and execute the check of the air pressure in the tires.
蘆When the difference of the air pressure of four wheels is remarkable.
蘆When the air pressure shifts from a specified value. -
Rotate the tire around the wear-out of the tire to keep even, and to extend longevity
to four wheels. (Refer to P.409. )-
Do not install the disc wheels other than specification when you exchange the
disc wheels. (Refer to P.453. )-
An accurate speed of the vehicle might not be able to be detected by the performance of the car (stability and
slip distance for brake etc. of fuel cost and the vehicle) is not able not only to be demonstrated enough when tires
other than specification and four-wheel stern tires the not same are installed but also generating the rotation difference
in the tire in the front, back, left and right, and the following system might not operate normally.
蘆A B S
蘆Brake assistance(2.0L car <Z grade > and 4WD car)
蘆T R C
蘆V S C
蘆Backing guide monitor
蘆Window shade corner monitor
蘆GPS voice navigation system
76
About maintenance
潺Do not use the tire that exceeds the wear-out limit.
- If the tire of which the tire and slip sign Mark that shows position of slip sign
(wear-out limit display) with a little depth of Slip sign
the ditch of the tire have gone out is used as
it is, the slip distance for brake cannot become Warning
long, the steering wheel be operated by hydroplaning
* and 1 on the day of rain, and the tire 2.
is a burst (explosion), might cause an unexpected
accident, and it is dangerous. Exchange it Attention
promptly for a normal tire when you exceed
the wear-out limit.
of
- 1 Phenomenon of steering wheel and brake's tire's
water's entering between tire and road when running . example: State that slip sign has not gone out . *2 tire
at high speed on road where water collects, floating
from road, and not working. - Slip sign
2 The illustration is an example for the explanation, and
it actually differs.
潸Do not install an abnormal tire that there are a wound and a crack in the
side wall of a tire etc.
- When the tire in which abnormality is found is installed, I might feel a vibration that is taken the
steering wheel when running, and is abnormal.
The damage such as bursts (explosion) that cannot be repaired is given to the tire, and moreover,
the tire might cause an unexpected accident as the sideslip etc. and it is dangerous.
Promptly receive the check in the Toyota shop, and exchange it for a normal tire while running
when you feel an abnormal vibration. -
It might not be able not only to demonstrate the performance of the car (stability and slip distance for brake etc. of
fuel cost and the vehicle) enough when the tire in which abnormality is found is installed but also cause an unexpected accident
and be dangerous. Moreover, it might cause the breakdown as parts are negatively affected.
77
About maintenance
澁Install the same kind of tire without fail when you install the tire for winter by the
same specified size as a standard tire, and run by the specified air pressure.
- When the tire for winter is installed, it is similar to a standard tire. Moreover, avoid the high speed operation for
safety when you install the tire for winter.
Warning
2. 澀Refrain from the speed and drive carefully when you install the tire chain.
- Run below the speed limit of about 30 km/h or the chain manufacturer recommendation
Attention when you install the tire chain. -
When the tire chain is installed and you run, do not operate the brake by which the projection
of and the hole are got over, and locked by a rapid steering wheel and the wheel. It does unexpected
tire movement by the vehicle, might cause the accident, and is dangerous.
Moreover, the slip distance for brake might become long when ABS operates, and
drive carefully.
潯C o n f i r m t h e w h e e l
installation nut has shut
surely when you exchange
tires.
- The wheel installation bolt and the brake parts are damaged, and it might cause an
unexpected accident as the disc wheel comes off and is dangerous if not surely shutting.
Tighten the nut in the reference value with the torque wrench in the Toyota shop as soon as possible
after exchanging tires.
Tightening torque: About 105N. m{1050kgf・cm} -
No oil and grease it to the nut and the bolt that installs the tire.
The bolt might be damaged, and the disc wheel be damaged when tightening more
than the necessity. Moreover, it might cause an unexpected accident as the tire comes off while
the nut's loosening and running and is dangerous.
78
About maintenance
潛Receive the check in the Toyota shop etc. when abnormalities such as collapsing
and the cracks are found in the bolt hole of the thread part and the disc
wheel of the disc wheel installation bolt and the nut.
- It might cause an unexpected accident as it doesn't shut enough even if the nut is tightened when
Warning
abnormalities such as collapsing and the cracks are found, and the disc wheel comes off and is dangerous.
2.
潭Damage from a usual tire to the tire disc wheel by the impact
from the road is large, and note the following points about a
super-flat tire (17-inch wheel installation car).
- Always use it by proper air pressure. It becomes easy to suffer in addition when
the tire inflation pressure is low, and do a regular check of the air pressure. -
Avoid running of a difference and a ruggedness road as much as possible. Run as slowly as possible
carefully when you run unavoidably.
澂Note that the tire doesn't hit the curb etc. of the pavement.
- The tire disc wheel might be damaged.
79
About maintenance
潘Do not touch the disc wheel and the brake circumference, etc. immediately
after running.
- The disc wheel and the brake circumference immediately after running are high temperatures. When the
hand and the foot, etc. touch by the tire exchange etc. , the burn might be done.
80
i
ma
t
ou
Ab
Defend the following matter about
the battery.
Important injury might be received if it
doesn't guard and it is dangerous. Warning
3. Attention of 3.
battery
Attention
it like LOWER LEVEL or less that each Ekisou is displayed on the battery side (lower bound), heat is
battery
generated and might the explosion is dangerous. The check method"Maintenance note" Refer to.
Replenish it when liquid measure is a little.
- Important injury such as losing sight might be received when the battery liquid that contains diluted sulphuric acid
that it is poisonous and the causticity is high might spout from the battery, and it adheres to eyes and the skins and it
is dangerous while charging it. Take off clothes at once, wash the part of the body that adheres the liquid with
bags of water, and receive the doctor's examination when adhering by any chance.
81
About maintenance
Warning
3.
- It surely installs or doesn't tighten, and might connect with a vehicle fire by
clamping coming off while running and shorting and be dangerous.
82
i
ma
t
ou
Ab
Defend the following matter about
the jack improvement.
In the worst case, it reaches an unexpected
accident and serious injury if it doesn't guard or,
Warning
it is likely to lead to the death.
4. Attention of 4.
jack improvement
Attention
- The body becomes the a celluloid board laid under written paper of the car if the jack comes off by any chance, and it reaches
important injury or, in the worst case, it is likely to lead to the death. -
Do not use the jack of the Clmano tool excluding the tire exchange and the tire chain
detaching.
83
About maintenance
澆When the jack improves, the body is damaged, and the jack comes off, important
injury might be received, and it is dangerous if the following respect
is not noted.
- The jack must not improve with the person taken. -
Warning
On the jack and do not place the one below when the jack improves. -
Confirm the jack surely hangs to the position (Refer to P.472)
4.
where the body is set the jack when the jack improves. -
Lift only necessary height for the tire exchange to the body. -
Attention
The jack's having improved must not start up an engine. -
of Confirm surroundings, and work while noting it enough when you sell the body that improves
the jack wholesale.
jack
improvement
84
About maintenance
FF car
improvement
The jack
cannot improve.
The front side of vehicle
狠
Badger
4WD car
85
an
eat
rh
O Ba
Defend the following matter
Reason
about overheating.
Important injury might be received if it
Warning doesn't guard and it is dangerous.
1.
1. Attention of
overheating
Attention
of
漓Do not open the hood until
overheating
steam doesn't occur when it
overheats, and steam has
occurred from the bonnet.
- Important injury such as the burns might be received because the high temperature in the engine
room and it is dangerous. Moreover, note that there is a part that is the high temperature
even when steam has not occurred enough when opening the hood.
- Steam and the hot water spout, important injury such as the burns might be received, and it is dangerous. -
The cloth cutting etc. , wrapping of the cap valve after it gets cold, and open it
slowly as the radiator the auxiliary tank is enough when you open the cap valve.
86
an
eat
rh
O Ba
Defend the following matter.
Reason
It might cause an unexpected accident and
serious injury if it doesn't guard and is
dangerous. Warning
OneAt ention
漓Note the steering wheel and the brake operation enough when it is because
pulled as the engine doesn't start. of
- The operation power becomes very heavy because neither the power steering nor the brake twice Cot
drinking
power device work if it doesn't engine starts. Note driving the pulled
car enough.
- The pulling hook and the rope are damaged, it hits a surrounding person etc. , important injury
might be given, and it is dangerous.
澆Do not pull out the key from the engine switch while pulling it,
and do not make the engine switch LOCK.
- It becomes impossible to do the steering wheel control it, is locked the steering wheel when the key has come
off, might cause an unexpected accident, and is dangerous. Moreover, the key might come off
when the engine switch is LOCK.
87
Overheating and emergency accident
- There is a possibility that the fuel system has been damaged if the road under the car etc. are confirmed, and the leakage
of the liquid (Excluding the water of the air conditioner) is found. It ignites to the fuel if the engine is
started as it is, it might cause a serious accident, it is not dangerous, and do not
start the engine.
In this case, tell it also at the report of the situation to the Toyota shop.
88
tio n
at ten
r
O the
Other
attention
漓Never do an illegal remodeling.
- If the one other than parts that Toyota reported to the Ministry of Land, Infrastructure and Transport are installed, it is
likely to become an illegal remodeling. -
Height is dropped, it causes the breakdown when an unsuitable parts to the performance and the function
of the car as a wide tire is installed are installed, and the accident is caused, important injury might be
received, and it is dangerous. -
Never remodel the steering wheel. It doesn't operate normally, and it swells
by mistake, and it reaches important injury or, in the worst case, it is likely to lead to the
death when inadequately treating because the SRS air bag is built into the steering wheel. -
In the following cases, consult the Toyota shop.
蘆Exchange of tire disc wheel wheel installation nuts.
If the one other than the different species and specification are used, the adverse effect might be caused
for running, and it become an illegal remodeling.
蘆Installations such as electrical equipments and wireless machines and detaching.
The adverse effect is caused for an electronic equipment parts, and it might cause the accident like the breakdown and
a vehicle fire, etc. and is dangerous.
- It might connect with a vehicle fire when leaving it while opened and is dangerous. Moreover, do
not put the combustible one such as wastepapers in the ashtray.
89
Other attention
澆Do not put the one other than the cup and the beverage can in the
cup holder.
- What stored when time that slammed on the brakes and colliding dashes out, and it
is likely to injure. Moreover, close when you do not use it.
Warning
Other
attention
- It works the lens by the sucker, might connect with a vehicle fire, and is dangerous.
- It flies the body when time that slammed on the brakes and colliding, and it reaches important
injury or, in the worst case, it is likely to lead to the death.
90
Other attention
- In the worst case, it reaches important injury or, it is likely to lead to the death by placing the attention
hand, the head, and the neck, etc. when closing when the child operates it. -
Close the backing door pushing from the outside without fail. When the backing door is closed directly
in the backing door grip, the hand and the arm are placed, and important injury might be received and it is
dangerous. -
Do not close the backing door, and do not hang with Baccdoadamparsta.
It might cause an unexpected accident by placing the hand, and shifting when
Damparsta is damaged and is dangerous.
潛The surface of the door mirror doesn't become hot while the mirror heater of the
mirror heater installation car is operating, and do not touch it.
- The burn might be done and it is dangerous.
91
Other attention
濳The lower side of the glass doesn't become hot while operating the reception
desk window shield glass with heat ray, and do not touch it. (reception desk
window shield glass installation car with heat ray)
- The burn might be done and it is dangerous.
Warning
潭Note that detached neither battery nor parts (Especially, the child :)
Other
are swallowed when the batteries of the wireless door lock remote control
attention smart key are exchanged.
- Important injury might be received when swallowing and it is dangerous.
澂The electric wave might exert the influence on the equipment for the medical treatment
of the heart pacer etc. , and confirm the person who takes the smart door lock installation
car to an electric equipment manufacturers for the medical treatment etc. beforehand.
92
Other attention
Other
attention
93
Other attention
Other
attention
94
2
Contents
(To the person who takes this car for the first time. )
Basic
. earliness.. operation
This chapter easily explains a basic driving device of this car and the
equipment goods for the person who takes a Toyota car the other ..the first
purchase of the car.. for the first time.
Read each chapter firmly about a detailed handling explanation and notes. Driving
Handling
device
Opening and shutting . . . . . . . . . . . . . . . . .
of each part adjustment . . . . . . . . . . . . . . . .
of 96 seats wearing of 98 seat belts . . . . . . . . . . . . The
How
to attention
. drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
95
Opening and shutting of each part
Lock
Unlocking
With the key With the remote control switch In a smart door lock
(smart door lock installation car)
Lock Lock unlocking
Unlocking
Lock Unlocking
Unlocking Lock
Lock Unlocking Lock Unlocking
96
Opening and shutting of each part
Contents
A detailed introduction concerning the opening and shutting of each part
Basic
. earliness.. operation
Opening and shutting 151 of bonnet
Driving
Handling
device
The
Handling indoor
equipment
associate . drinking..
car
Maintenance
It closes.
Open. Myriad
Oneの
と
き
Index
97
Adjustment of seat
The back must not separate the back from the drip either.
The pedal should be able to be depressed enough.
98
Adjustment of seat
Contents
A detailed introduction concerning the seat
Basic
. earliness.. operation
Driving
Handling
device
The
Handling indoor
Adjustment 168 of third seat equipment
. good.. Safety
of ・
To
theory Comfortable
Regulating function (the 2) headrest and
equipment
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
99
Wearing of seat belt
Do not twist.
Method of wearing
1 Draw out the belt. 2 Insert the plate in the
buckle.
100
Wearing of seat belt
Contents
A detailed introduction concerning the seat belt
Basic
. earliness.. operation
Driving
Handling
device
The
..fixation.. 204 of child seats Handling indoor
equipment
笆 How
to attention
associate . drinking..
car
Bambo basket
Button Maintenance
Adjust the height of the belt Bambo basketPush the button of the buckle.
with the anchor. 笆It is necessary to wind up up the belt. Myriad
Oneの
と
き
Index
101
When you drive
START
Position in which engine is started.
(start)
- Confirm the
parking brake
hangs.
102
When you drive
Contents
笆 Basic
. earliness.. operation
Bambo basket
笆 Driving
Handling
device
The
Bambo basketP ush the key from ACC. Bambo basketWhile moving the steering wheel
Handling indoor
笆Pull out the loincloth to LOCK. 笆Spend the key. equipment
How
to attention
associate . drinking..
car
Maintenance
と
き
Index
103
When you drive
104
When you drive
Contents
A detailed introduction concerning the driving device
Gear-shift- Warning
Super ECT installation car 222-
Super CVT i installation car 230
Basic
. earliness.. operation
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
Parking brake pedal 246 Engine switch 218 of ・
To
theory Comfortable
and
How to use of the parking brake. equipment
associate . drinking..
笆 笆 car
Bambo basket Bambo basket
Maintenance
Bambo basketWhile firmly stepping on the brake pedal Bambo basketWhile firmly stepping on the brake pedal
by the right leg by the right leg Myriad
Oneの
笆Depress the parking brake pedal with 笆Depress the parking brake pedal
と
the left leg until "Catitsu" and the sound with the left leg fully. き
are heard, and separate slowly.
Index
105
Warning light
Passenger's seat seat The crew in the passenger's seat has not worn the
belt non-wearing warning seat belt. -
106
Warning light
Contents
A detailed introduction concerning the warning light
Basic
. earliness.. operation
Driving
Handling
In the state of the warning light's lighting or blinking device
Warning light of water Abnormality of the engine electronically controlled system associate . drinking..
car
Maintenance
Myriad
4WD warning light charge warning Abnormality of 4WD system. Oneの
と
き
Abnormality of the temperature of the engine cooling water.
light 4WD warning light
(Light in blue in red at the high temperature at the low temperature of blinking. )
Index
107
Handling of switches
Intermittent
108
Handling of switches
Contents
A detailed introduction concerning the switch
Warning
Emergency blinking light switch 292
Wiper
&Washer switch Basic
. earliness.. operation
Fog lamp switch 283 of
284 instruction lever of
280 light switch directions
reception desks Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
Signal to another car
How
to attention
Direction instruction light Emergency blinking light associate . drinking..
Left turn car
Maintenance
Myriad
Oneの
Right turn
と
き
Index
109
Air conditioner
Lower.
Raise it.
110
Air conditioner
Contents
A detailed introduction concerning the air conditioner
Warning
Basic
. earliness.. operation
Driving
Handling
device
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
111
Air conditioner
112
Air conditioner
Contents
Warning
Basic
. earliness.. operation
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
. drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
113
3 Handling of driving device
116 such as door door the glass ..opening Seat 170 ..arrangement . . . . . ..
and shutting . . . . . . . . . . . .. Index 170
Opening and shutting of reception desk Method of 172 how to
door Riyadoa 116 make Secandoshetodablforlding
Opening and shutting of backing door 124 storage of table
Opening and shutting of the door glass 129 mode 176
Opening and shutting of Moon roof 134 How to move up third
How to use of the remote control seat 184
of a wireless door lock. 138 How to make
How to use of a smart relaxation mode 189
door lock. 140 How to make Big cabin
Opening and shutting of Fuelrid (fueling mode 191
entrance) 148 How to make super-long
Opening and shutting of bonnet 151 space mode 193
154 of seats ..adjustment . . . . . . .. 196 of seat belts ..wearing . . . ..
Index 154 Correct wearing
Correct driving posture 155 of seat belt 196
Adjustment 157 of reception desk seat How to wear seat
Adjustment 161 of Secandoshet belt 199
Adjustment of third seat 168 How to wear two point expression
seat belt 202
Fixation of child seat . 204
Bar ..fixation.. 205 in &
Topptezarancar only for child
seat fixation for ISOFIX
..fixation.. 209 in seat belt
114
Contents
Warning
Basic
. earliness.. operation
Driving
Adjustment of steering wheel mirror . 212 248 of meter, display light, and Handling
Adjustment of steering wheel 212 warning lights ..view . . . . . . . . . .. device
Adjustment 213 of inner mirror Meter 248
Adjustment of door mirror 214 Display light 254
The
How . . . . 218 for engine to start Warning light 262
Handling indoor
How to use of the engine How to use . . . . 280 of the switches. equipment
switch. 218 The top and bottom of optical axis
Procedure of engine start 219 adjustment of 284 usage headlamps of instruction
How to use of gear-shift . 222 lever of 280 usage . good.. Safety
of ・
How to use of the gear-shift directions of light switch 285 To
theory Comfortable
of the Super ECT installation How to use of wiper & washer and
equipment
car. 222 switch. 286
How to use of the gear-shift How to use of Riyauindudefoggar How
of Super CVT i installation (cloudy remove) to attention
Index
115
Opening and shutting of door door the glass etc.
Opening and shutting of reception desk door Riyadoa
Lock
Unlocking
Forward of vehicle
Knowledge
When the driver's seat door is locked and unlocked with the key
All doors (Include the backing door) are locked and it is possible to unlock it.
However, when the driver's seat seat belt is installed, only the driver's seat door backing door is
locked and unlocked.
116 - As for the sign, the presence of the installation is different depending on the grade etc.
Opening and shutting of door door the glass etc.
Contents
Knowledge
Warning
About the specification of the key
The specification of the key becomes as follows by installing each function.
Anti-theft system installation car Exclude the anti-theft system installation car.
Basic
- Smart door lock installation car - Smart door lock installation car . earliness.. operation
Driving
Handling
The
Handling indoor
equipment
Smart keys are 2 pieces.
Maintenance
A sub-key is one.
Myriad
Oneの
と
き
- The number and the combination of keys might be different depending on the specification of the vehicle.
Index
117
Knowledge
About the Keenan bar plate
It clocked on the Keenan bar in not the key but the plate so as not to understand the Keenan bar excluding
the customer.
Keenan bar
- Keep the Keenan bar plate in places other than the vehicle importantly. -
When the key is lost by any chance, the key to a Toyota pure goods can be made from the Keenan
bar in the Toyota shop.
118
Opening and shutting of door door the glass etc.
Contents
Lock
Door lock switch Unlocking
Basic
. earliness.. operation
Driving
Handling
device
The
It locks when the front side of the switch is pushed, and when Gawa is pushed, it is unlocked. - Handling indoor
The lock and unlocking all doors (Include the backing door) can be done at the same time. equipment
Knowledge
. good.. Safety
About the operation condition of ・
To
- It is possible to use it regardless of the position of the engine switch. - theory Comfortable
When it keeps pushing the switch, it is likely not to operate. Separate the finger from the and
equipment
switch, and push again once.
How
to attention
About the security function
associate . drinking..
The function to stop the unlocking operation with the door lock switch to prevent the vehicle theft etc.
car
(Prevent it from being unlocked pushing the door lock switch from the space between the window frame and the door glass. )It
functions automatically when locking in the following way. -
Lock that inserts key in driver's seat door. (Refer to P.116. )-
Lock that uses remote control of wireless door lock remote control smart key.
Maintenance
(Refer to P.138,143. )-
Re-lock when door after unlocking is operated by remote control of wireless door lock remote control
smart key is not opened. (Refer to P.139,144. )-
Lock that uses smart door lock function. (Refer to P.141. )-
Myriad
Re-lock when door after unlocking is operated by smart door lock function is not opened. (Refer Oneの
to P.142. )- と
Lock outside car with lock lever. (Refer to P.120. ) き
Index
119
Method of lock and unlocking with lock lever
- Lock and unlocking in car
Lock lever
Lock
Unlocking
Door lever
It locks when the lock lever is pushed forward, and it is unlocked when drawing it out backward. -
The backing door is locked additionally and unlocked by the lock and unlocking with the lock lever
of the driver's seat door.
Lock lever
Lock
Door handle
The reception desk door adjusts the lock lever to the lock side, and closes the door with the
door handle pulled.
Riyadoa adjusts the lock lever to the lock side, and closes the door.
Knowledge
About a convenient function
The door opens when the driver's seat door pulls the door lever in the car even if the lock lever
is a lock side.
120
Opening and shutting of door door the glass etc.
Contents
Refer to "How to use of the remote control of a wireless door lock" of P.138.
Basic
. earliness.. operation
Method of lock and unlocking by smart door lock
Refer to "How to use of a smart door lock" of P.140.
Driving
Handling
Riyadoa
The
Unlocking
. good.. Safety
of ・
To
theory Comfortable
and
Lock equipment
The child protector lever is adjusted to the lock side and the door is closed. - associate . drinking..
Riyadoa cannot be opened with the door lever in the car. car
Knowledge
About the child protector
Maintenance
The child can mistake and it lock in the operation of the door lever in the car regardless of the position
of the lock lever while running so that Riyadoa should not open not to open the door and to exist.
Myriad
How to open door when child protector works Oneの
Put the lock lever into the state of unlocking, pull the door handle outside the car, and open it. Open the door glass, と
き
put the lock lever into the state of unlocking, pull the door handle outside the car, and open it when opening it
in the car by any chance.
Index
121
Confirm all doors have closed surely before
it runs.
- Confirm all doors have closed surely before it runs. It opens suddenly while
running if the door is not surely closed the door, might cause an unexpected accident, and is dangerous. -
Do not pull the driver's seat door lever while running. In the worst case, it reaches important injury
or, it is likely to lead to the death by the door's opening and being thrown out outside the car. -
Do not let the child operate the door.
蘆Important injury might be received by placing the hand, the head, and the neck, etc. when closing and it is dangerous.
蘆The door might be opened while running, the child throw out outside the car, and it reaches important
injury or, in the worst case, it lead to the death.
Knowledge
Ilminateddoentoreshistem
It synchronizes with unlocking that uses a key wireless, door lock smart door lock and the opening and
shutting of the door, and a reception desk personal lamp (When the switch is DOOR), the interior light (When the
switch is D OOR), and the engine key lighting are lit and turned off. -
Light when you open the door, and turn it off in about 15 seconds when closing. -
Light when all doors are closed, and the engine switch is made LOCK from ACC, and turn it off
in about 15 seconds. -
In the following cases, turn it off at once.
蘆When all doors are closed, and the engine switch is made ACC or to turn on.
蘆When you close all doors when the engine switch is ACC or is turned on.
蘆When all doors are closed, and the door in the driver's seat is locked.
122
Opening and shutting of door door the glass etc.
Contents
Knowledge
Warning
About the effect of the lock and unlocking while getting on
It locks while getting on, there are the following effects respectively about unlocking, and select it.
device
When parting from the car, the engine is obligated to stop without fail and to be locked by the law.
Moreover, the thing in the vehicle theft and the car might not be stolen, and do not put valuables
etc. in the car. The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
123
Opening and shutting of backing door
124
Opening and shutting of door door the glass etc.
Contents
Basic
. earliness.. operation
Driving
Handling
device
Backing door switch
. good.. Safety
- When closing of ・
To
1 Sell the backing door wholesale.
theory Comfortable
and
equipment
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
125
Confirm the backing door has closed surely before
it runs.
- Confirm the light shake of the backing door before it runs and the lock surely. It
opens suddenly while running if the backing door is not surely closed the backing door, might cause an
unexpected accident, and is dangerous. -
Do not place other people's hands etc. when you close the backing door. Moreover,
do not let the child operate the door. In the worst case, it reaches important injury by
placing the hand, the head, and the neck, etc. when closing when the child operates it or, it is likely to lead
to the death. -
Close the backing door pushing from the outside without fail. When the backing door is closed directly in the backing
door grip, the hand and the arm are placed between the backing door, and important injury might be received and it is dangerous. -
Never take the person in the luggage room. In the worst case, it reaches important
injury when time that slammed on the brakes and colliding or, it is likely to lead to the death. -
Do not run with the backing door opened. The backing door hits the one outside the car
etc. if running while opened, and it might cause an unexpected accident. Moreover, the vehicle exhaust
emission invades in the car, it becomes CO intoxication, and it reaches important injury or, in the worst case, it is
likely to lead to the death. Confirm the backing door has closed without fail before it runs. -
Do not close the backing door, and do not hang with Baccdoadamparsta.
It might cause an unexpected accident by placing the hand, and shifting when Damparsta is damaged
and is dangerous.
126
Opening and shutting of door door the glass etc.
Contents
Maintenance
Myriad
Oneの
About the safety feature
と
The backing door can be opened only while stopping because of safety. き
Index
127
Knowledge
About the emergency lever
The door lock can be released in the car by operating the emergency lever when the backing
door is not opened outside the car in the place where the battery goes up.
Emergency lever
3 Open the backing door.
Receive the check ahead of time in the Toyota shop when you break down.
128
Opening and shutting of door door the glass etc.
Driving
Handling
device
associate . drinking..
Operation display light
car
The door glass switch
Maintenance
Myriad
Oneの
と
き
129
- How to open and shut the door glass
It closes while it opens, and it has been pulling it up while the switch is being pushed below.
Stop at the position when you separate the hand from the switch.
Knowledge
About the operation condition
When the engine switch is turned on, it is possible to use it. However, neither the passenger's seat nor the rear
seat switch open and shut when the window lock switch (Refer to P.132) is turning on. -
The operation display light of each switch lights when the engine switch is turned on. -
Initialize the power window when the operation display light of each switch has
blinked. (Refer to next page. )
130
Opening and shutting of door door the glass etc.
Contents
Knowledge
Warning
About initialization
Initialize the power window when the connection with the battery is refused by the battery
exchange and the fuse exchange, etc.-
The following function doesn't operate if the power window has not been initialized. Basic
蘆Passenger's seat in driver's seat switch and opening and shutting of the rear seat door glass . earliness.. operation
蘆Automatic opening and shutting of the door glass
蘆The prevention mechanism placing and crowding.
蘆Key OFF latter harvest movement function
- The operation display light of the switch blinks to the door glass that the power window has not been Driving
initialized. Handling
device
- Method of initialization
Initialize the power window of the each door glass with each seat switch.
The power window of the passenger's seat and the rear seat door glass cannot be initialized with the driver's The
seat switch. Handling indoor
equipment
. set-up steps .
1 Turn on the engine switch.
. good.. Safety
2 Keep pushing the switch below, and open the door glass to the half. of ・
To
theory Comfortable
3 The door glass is . of close all up ..switch.. continuously can. and
equipment
It is possible to continue up the switch after closed all for about one second.
How
When the initialization of the power window is completed, the operation display light of the switch divides from blinking to attention
into lighting. associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
131
How to use of the window lock switch.
It changes into turning on and turning off whenever the window lock switch is pushed.
The power windows other than the driver's seat door glass do not open and shut when the switch
is turned on. -
When the switch is turned on, the operation display lights of the door glass switch other than the
driver's seat door glass switch are turned off.
Window lock switch Driver's seat switch Passenger's seat and rear seat switch
Produce neither hand nor the face from the window while running.
- Produce neither hand nor the face from the window while running. In the worst case, it reaches important injury
when it hits the one outside the car etc. or it slams on the brakes or, it is likely to lead to the
death. -
Place other people's hand, arm or neither head nor necks, etc. when the door glass is
opened and when it closes. It is placed between the door glass and it is rolled, and important injury might
be received and it is dangerous. -
Do not let the child operate the door glass. In the worst case, it reaches important
injury by the hand, the arm, the head, and the neck's, etc. placing and being rolled when the opened time and closing or,
it is likely to lead to the death.
132
Opening and shutting of door door the glass etc.
Contents
There is an area where the scissors crowding is not perceived in the part immediately before
the shutting cutting. Warning
- There is an area where the scissors crowding is not perceived in the part immediately before the shutting cutting to close
the door glass surely. Do not place the finger etc.-
It places, it crowds, and the prevention mechanism doesn't operate the switch in the state that was able to continue strongly. Do not place
the finger etc.- Basic
. earliness.. operation
When it places by any chance, it crowds, the prevention mechanism operates, and the door glass cannot be closed by the
automatic operation, the switch can be closed when it is possible to continue. -
Do not move the switch of the driver's seat switch and other doors in the opposite direction at the same time. It causes
the breakdown of the power window. -
Driving
After opening completely the door glass closed, all do not keep pushing the switch in be the same direction. It causes Handling
the breakdown of the power window.
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
133
Opening and shutting * of Moon roof
Switch
- When closing
When the SLIDE CLOSE side of the switch is pushed, automatic operation and . of close all. -
Push the switch again when you stop operating on the way. -
The roof can be closed a little by pushing the switch, and separating the hand at once.
134 - As for the sign, the presence of the installation is different depending on the grade etc.
Opening and shutting of door door the glass etc.
Contents
The tilt must improve by the automatic operation when you push the TILT UP side of the
switch when the Moon roof is closed. -
Push the switch again when you stop operating on the way. - Basic
. earliness.. operation
The tilt can improve a little by pushing the switch, and separating the hand
at once.
Driving
- When the tilt is downed Handling
When the TILT DOWN side of the switch is pushed when the tilt has improved, the tilt is device
downed by the automatic operation. -
Push the switch again when you stop operating on the way. -
The
When the switch is pushed, and the hand is separated at once, the tilt can be downed
Handling indoor
a little. equipment
Produce neither hand nor the face from the Moon roof while running. . good.. Safety
of ・
To
- Produce neither hand nor the face from the Moon roof while running. In the worst case, it reaches important theory Comfortable
and
injury when it hits the one outside the car etc. or it slams on the brakes or, it is likely to lead equipment
to the death. -
Note that other people's neither hand, head nor necks, etc. are placed when you close the How
to attention
Moon roof. It is placed between the Moon roof, and important injury might be received and it is dangerous. -
Is not the waist in the opening or disregard it. The roof dents, and it is thrown out from the car at the emergency, associate . drinking..
and, in the worst case, it is likely to lead to the death. - car
Do not let the child operate the Moon roof. In the worst case, it reaches important
injury by placing the hand, the head, and the neck, etc. when closing or, it is likely to lead to the death.
Maintenance
Myriad
Oneの
と
き
Index
135
Luggage must not overflow the roof.
- Luggage must not overflow the roof. It might cause an unexpected accident
by hitting the one outside the car. -
Time away from the car and confirm the Moon roof is completely closed when you wash
a car. Moreover, open it after confirming there are neither water nor a snow on the roof. When rain and
water enter indoors, and water splashes to electric parts under audio and the floor carpets etc. , it
might cause a fire and the breakdown. -
It places, it crowds, and the prevention mechanism doesn't operate in the state to have kept pushing the switch. Do not place
the finger etc.-
There is an area where the scissors crowding is not perceived in the part immediately before the shutting cutting to close
the Moon roof surely. Do not place the finger etc.-
Not to keep pushing of the switch to opening completely and close all the Moon roof. It causes the
breakdown of the Moon roof.
Knowledge
About the operation condition
When the engine switch is turned on, it is possible to use it.
136
Opening and shutting of door door the glass etc.
Contents
Knowledge
About the San shade Warning
Deflector
. good.. Safety
of ・
About initialization To
theory Comfortable
Initialize the Moon roof when the connection with the battery is refused by the battery and
exchange etc.- equipment
The following function doesn't operate if initialization is not done.
How
蘆Automatic opening and shutting of Moon roof to attention
蘆The prevention mechanism placing and crowding.
associate . drinking..
蘆Key OFF latter harvest movement function
car
- Method of initialization
1 Turn on the engine switch.
2 Put the Moon roof into the state of the tilt improvement. (Refer to P.135. ) Maintenance
Improve the tilt after of all closes keeping push the SLIDE CLOSE side
of the Moon roof switch when the Moon roof is open.
Myriad
3 Keep pushing the TILT UP side of the switch, and maintain the tilt improvement as it is for about two Oneの
seconds.
と
き
Index
137
How to use * of the remote control of a wireless door lock.
Lock Unlocking
UNLOCK switch
The emergency blinking light (Unlocking : the lock twice once) blinks when all doors (Include
the backing door) are locked, unlocked whenever the LOCK switch and the UNLOCK switch are
pushed, and operation is completed. -
Push the switch surely slowly. -
LED lights when the switch is pushed. -
Confirm the lock operation was done without fail when you do the lock operation
pushing the switch.
Remote control is electronic parts. It causes the breakdown when the high impact etc.
are given, and note the following points. -
Do not put it on the place that becomes a high temperature such as on dashboards. -
Do not resolve it. -
Do not drop, and do not give the high impact. -
Do not wet it to water.
138 - As for the sign, the presence of the installation is different depending on the grade etc.
Opening and shutting of door door the glass etc.
Contents
Knowledge
Warning
About the operation condition
- The distance that can be operated according to surrounding circumstances might change into remote control. Approach from the
car to about 1m to operate surely and operate it. -
The electric wave to the receiver is interrupted when remote control is operated from the rear side of the vehicle when the following Basic
one is pasted to the backing door glass and it applies it, the reception sensitivity decreases, and the distance that can be operated . earliness.. operation
might shorten.
蘆Window film that contains metal.
蘆Other metallic things. (antennas etc. other than Toyota pure goods)-
Neither the LOCK switch nor the UNLOCK switch operate when the key has been
Driving
inserted in the engine switch or either of door (Include the backing door) is open. - Handling
Even if it keeps pushing the LOCK switch and the UNLOCK switch, neither the lock nor unlocking the door device
are repeated. Push the switch again. -
When the door is not opened within about 30 seconds after the unlocking operation is done pushing the
UNLOCK switch, it is locked automatically. (The emergency blinking light blinks once. ) The
Handling indoor
equipment
About a convenient function
Ilminateddoentoreshistem(Refer to P.122. )
The lock and unlocking, etc. by remote control synchronize, and a reception desk personal lamp (When the . good.. Safety
switch is DOO R), the interior light (When the switch is DOOR), and the engine key lighting are lit and turned off. of ・
To
theory Comfortable
and
equipment
About the battery exchange
When no neither operation even if remote control is operated or nor L ED when the distance that can be How
remarkably operated shortens darkens or lights, the consumption of the battery is thought. Change a to attention
battery. associate . drinking..
If a precise driver on the market is used, the customer can exchange the exchanges of the batteries. Refer to
car
"Battery exchange of the remote control of a wireless door lock" of P.411. (The Toyota shop can
exchange it. )
Consult the Toyota shop at once to prevent the theft and the accident, etc. when you lose remote
control.
Myriad
Oneの
About the use
と
Remote controls can be used up to four in the same vehicle. Consult the Toyota き
shop in detail.
Index
139
How to use * of a smart door lock.
Lock the door after confirming being sure to put the parking brake, pulling
out the key from the engine switch, it not to be in the car room the smart key,
and the carrying of the smart key and when parting from the car.
Knowledge
- Range of operation of smart door lock function - Range of operation of wireless door lock remote
control function
Range of operation
Auto outdoor transmitter Within about 70cm in
surroundings from passenger's
seat side door steering wheel
140 - As for the sign, the presence of the installation is different depending on the grade etc.
Opening and shutting of door door the glass etc.
Contents
. unlocking .
Basic
. earliness.. operation
. lock .
Driving
Sensor Handling
Lock switch
device
Lock Unlocking
The
Handling indoor
equipment
Smart key
Grip the door handle to carry the smart key, and to touch the sensor in the
reception desk door steering wheel. -
All doors (Include the backing door) can be unlocked. - Maintenance
The emergency blinking light blinks twice when unlocking it.
Knowledge
Myriad
About the operation condition Oneの
The lock and unlocking the door become possible only when the ID code is automatically collated, and collation is corresponding と
when entering carrying the smart key within the range of operation of auto outdoor transmitter (Refer to last page). - き
It is likely not to operate normally when smart keys are in the neighborhood and a high place on ground even in
case of being in the range of operation.
Index
141
Knowledge
About the lock and unlocking
- If the smart key is in the range of operation of auto outdoor transmitter, it is possible to lock and to unlock it with
the reception desk door steering wheel excluding the person who is carrying the smart key. -
Confirm the lock surely pushing the lock switch of the reception desk door steering
wheel when you lock. -
The lock switch is ..earliness.. O and it is likely not to be locked when doing. -
When the key has been inserted in the engine switch, it is not possible not to lock and to unlock it
by using the smart door lock function. -
It is not locked even if the lock switch is pushed when either of door (Include the backing
door) is open. -
After it locks, about three seconds cannot be unlocked by using the smart door lock function. -
The unlocking operation by the smart door lock function cannot be done when locking by operating
the key. In that case, unlock it by operating the wireless door lock remote control function
or the key. -
Pull the door handle after confirming the grip of the sensor in the reception desk door
steering wheel surely, and unlocking when you unlock it.
Door handle
Sensor
- When the leather glove and the skiing gloves, etc. are installed in the hand and it touches the reception desk door steering
wheel, unlocking might not be delayed, and it be unlocked. -
Grip the reception desk door steering wheel within about five seconds after the smart key enters the range
of operation of auto outdoor transmitter to make it surely unlock. When five seconds pass, it is likely not
to operate. -
In an approach of a sudden auto outdoor transmitter to the range of operation and a sudden door steering wheel control, it is not likely
to be able to unlock it. In that case, pull the door handle again after confirming the door handle
returns to the position, and was unlocked never. -
It will be locked automatically in about 30 seconds if there is no opening and shutting operation of the door after it unlocks it. (The emergency
blinking light blinks once. )-
It will be locked automatically in about 30 seconds if there is no opening and shutting operation of the door though the smart
door lock function might work when bags of water hang to the door handle because of the carwash and the heavy rain, etc. when
the smart key is in the range of operation of auto outdoor transmitter, and the door unlock it.
142
Opening and shutting of door door the glass etc.
Contents
Basic
. earliness.. operation
Switch
Lock
About 1m in operation range Unlocking
Switch Driving
Handling
device
LED
The
Lock Unlocking Handling indoor
equipment
. good.. Safety
of ・
To
Blinking once Blinking twice theory Comfortable
and
equipment
- When the switch is pushed, all doors (Include the backing door) are locked.
How
- When the switch is pushed, all doors (Include the backing door) are unlocked. - to attention
The emergency blinking light blinks once when locking. associate . drinking..
The emergency blinking light blinks twice when unlocking it. - car
Myriad
Oneの
と
き
Index
143
Knowledge
About the operation condition
- The wireless door lock remote control switch doesn't operate when the key has been inserted
in the engine switch. -
The switch doesn't operate when either of door (Include the backing door) is open.
- SwitchEven if it keeps pushing the switch, neither the lock nor unlocking the door are repeated. Push
the switch again. -
When the door is not opened within about 30 seconds after the unlocking operation is done pushing the switch,
it is locked automatically. (The emergency blinking light blinks once. )-
The distance that can be operated according to surrounding circumstances might change into the wireless door lock
remote control switch. Approach from the car to about 1m to operate surely and operate it. -
The electric wave to the receiver is interrupted when remote control is operated from the rear side of the vehicle when the following
one is pasted to the backing door glass and it applies it, the reception sensitivity decreases, and the distance that can be operated
might shorten.
蘆Window film that contains metal.
蘆Other metallic things. (antennas etc. other than Toyota pure goods)
The electric wave might exert the influence on an electric equipment for the medical treatment like
the heart pacer etc.Confirm it to an electric equipment manufacturers for the medical treatment etc. beforehand.
Smart keys are electronic parts with built-in signal transmitter. It causes the
breakdown, and guard the following. -
Do not put it on the place that becomes a high temperature such as on dashboards. -
Do not resolve it. -
Do not torture, do not drop, and give the high impact. -
Do not wet it with water. -
Do not apply the key ring etc. that wear magnetism. -
Do not put it near a medical treatment electric equipment such as the equipment or the low frequency therapeutic
instrument machines that wear the magnetism such as the television audio. -
Do not wash it with the ultrasonic washing machine etc.-
The smart key might be transformed, and crack when the fuel, the Tsuya putting
out medicine such as gasoline, and oils and fats adhere to the smart key.
144
Opening and shutting of door door the glass etc.
Contents
Knowledge
Warning
About the operation condition
- A smart door lock uses a slight electric wave. In the following cases, the smart key and
the communication between vehicles are disturbed, and it is not likely to be able to operate it by the smart door
lock function and the wireless door lock function. In that case, operate it with the key (Refer to Basic
P.116). . earliness.. operation
蘆When there is equipment that generates a strong electric wave such as the television tower, the power plant, broadcasting stations, and airports to be near.
蘆When you carry wireless telecommunications equipments such as the wireless machines and cellular phones together.
蘆When the smart key touches the metallic one or is covered.
蘆When is to be near two or more smart keys.
Driving
蘆When you put the smart key near electrical appliances such as personal computers. Handling
蘆When you use the remote control of a wireless door lock in the vicinity. - device
When cutting, the smart key cannot operate the battery by the smart door lock function and the
wireless door lock function. In that case, operate it with the key (Refer to P.116).
The
When the door is locked when the engine stops, auto outdoor sending is regularly done in a smart door
How
lock. Therefore, the battery of the vehicle might go up when the vehicle is left for a long time. Moreover, to attention
the consumption of the battery of the smart key and the battery of the vehicle might go up when the smart key
associate . drinking..
and the vehicle are left for a long time in the state to communicate regularly when the smart key is always put
within the range of operation of auto outdoor transmitter (Refer to P.140). Then, do the following control car
automatically to prevent consumption and the battery rising of the battery of the smart key. -
Stop the smart door lock function when there is no response from the smart key for 15 days or more or is a
smart key within the range of operation of auto outdoor transmitter for ten minutes or more.
Do either of following operation when you return the smart door lock function. - Maintenance
Carry the smart key, push the lock switch of the reception desk door steering wheel, and do the lock operation. -
It approaches the vehicle, switches of the smart key are pushed, either of the switch is pushed, and Hodoco.
Do the lock or the unlocking operation. (Refer to P.143. )-
Myriad
Start the engine. Oneの
と
き
Index
145
Knowledge
About keeping the smart key
Do not keep the smart key near the television, the personal computer, and the home appliance such as electromagnetic
cookers. The smart key mis-operates by the electromagnetic radiation of home appliance, and it always enters the state of the communication
and the battery is consumed remarkably.
146
Opening and shutting of door door the glass etc.
Contents
Warning
Basic
. earliness.. operation
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
147
Opening and shutting of Fuelrid (fueling entrance)
Fuelriddoorpnar
Open when you pull Fuelriddoorpnar () under the right of the driver's seat.
When closing, Fuelrid is closed to the place where "Catitsu" and the sound are heard
with the hand.
Switch
- When closing
It spends in the right until it has the switch of the cap, and
"Catitsu" and the sound are heard and it closes.
It closes.
148
Opening and shutting of door door the glass etc.
Contents
Basic
. earliness.. operation
Driving
Handling
device
Suspender
The
Handling indoor
equipment
Guard the following at fueling.
149
Do not use the fuels other than specification.
- A specified fuel is nonlead regular gasoline. Confirm the fuel specified when
refueling. -
The start of the engine might worsen, the knock be generated, and the output decrease if the fuels
(inferior gasoline, kerosene, and alcohol system fuel, etc.) other than specification are used. As
it is..use..accident to the engine..fuel..part..damage..fuel
..leak..cause..specification..fuel..excluding..use.-
Do not spill the fuel in the car while refueling. Paintwork might be violated.
Knowledge
About the position of Fuelrid
Fuelrid (fueling entrance) is behind the passenger's seat side vehicle.
150
Opening and shutting of door door the glass etc.
How to open it
1
Warning
Pull the bonnet opener.
The bonnet comes to the surface a little
when the bonnet opener under the right of the
Basic
driver's seat Instrument panel is pulled. . earliness.. operation
Driving
Bonnet opener Handling
device
. good.. Safety
of ・
To
theory Comfortable
Lever and
equipment
How
to attention
3 Insert Bonnettosta.
car
Myriad
Oneの
と
き
Bonnettosta
Index
151
How to close
1 Remove Bonnettosta.
Remove and fix Bonnettosta.
It opens when running without locking the bonnet, might cause an unexpected
accident, and is dangerous.
Resin part
152
Opening and shutting of door door the glass etc.
Contents
Warning
Basic
. earliness.. operation
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
. drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
153
Adjustment of seat
I n d e x
Adjustment of Secandoshet
Getting on going down of method . . . . . . . . . . . . . . . . . . . .
P.161 headrest of seat adjustment to raising and lowering . . . . . . . .
c. . . . . . . . . P.163 third seat . . . . . . . . . . . . . . . . . P.164
154
Adjustment of seat
Adjust the seat noting the following matter to take correct driving posture.
Warning
The center of the headrest must become behind the ear.
Basic
. earliness.. operation
Driving
Handling
device
Do not adjust the driver's seat seat while running. . good.. Safety
of ・
To
- Do not adjust the driver's seat seat while running. Driving is mistaken by the seat's suddenly moving theory Comfortable
while adjusting it, it might cause an unexpected accident, and it is dangerous. - and
equipment
Shake the seat before ..lightening.., and confirm fixation surely after
adjusting the seat. Important injury that moves if not fixed the seat, causes an unexpected accident, How
and is related to the life might be received and it is dangerous. - to attention
Do not put the one under the reception desk seat (Exclude it in a passenger's seat seat under associate . drinking..
tray). The one narrows, the seat is not fixed, it might cause an unexpected accident, and it is dangerous. car
Moreover, it causes the breakdown of the lock mechanism. -
Do not put the cushion (square cushion) of the back etc. between the drip and the back. Important injury that
is not demonstrated the effect of the seat belt and the headrest enough when cannot not only take correct driving posture
but also colliding and is related to the life might be received and it is dangerous. - Maintenance
Do not pile luggage to the passenger's seat and the rear seat. It dashes out when time that slammed
on the brakes and the car are turning luggage, might cause an unexpected accident by the nature's
hitting the crew, damaging luggage, and being taken in luggage, and is dangerous. -
Do not move while running ..get on to places other than the seat and in the car... It flies the body by Myriad
Oneの
inertia force when time that slammed on the brakes and colliding, and the head etc. are strongly stricken, the important
と
injury related to the life might be received, and it is dangerous. き
Index
155
In the SRS side air bag installation car, guard
the following.
- In the SRS side air bag installation car, guard the following. The SRS air bag might
not operate normally, and it swells by mistake, it reaches important injury or, in the worst case,
it lead to the death if it doesn't defend.
蘆Do not install the one other than a Toyota pure articles (seat cover etc.) only for this car
in the reception desk seat. If the SRS side air bag development department is covered with the one other than a
Toyota pure articles only for this car, it becomes an obstruction of normal operation of the SRS side air bag. Often
read the manual of the attachment, and install it in the commodity correctly when you
install the Toyota pure seat cover etc.
蘆Consult the Toyota shop when the installation, detaching, and the repair of repapering and the reception
desk seat of the reception desk seat epidermal are necessary. Moreover, do not remodel the
reception desk seat.
蘆Do not overpower as the SRS air bag development department like the reception desk seat side etc.
is strongly beaten.
Note the situation of the circumference such as those who multiply this and
luggage when you adjust the seat.
- Do not apply it to those who multiply this and luggage when you adjust the seat. Those who
multiply this might injure, and destroy luggage. -
Do not bring the hand close near the seat under and the moving part when you adjust
the seat. The finger and the hand are placed, and it is likely to injure. -
Note that it is likely to injure at the seat rail seat frame (foundation part in the
seat) etc. in the place where time when the room is cleaned and what dropped under the
seat is picked up when the hand is put under the seat enough.
156
Adjustment of seat
Basic
. earliness.. operation
Driving
Handling
Lever
device
Move the seat back and forth while pulled a lever and adjust it. The
Handling indoor
equipment
- Reclining adjustment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
Lever car
The back also must move the drip back and forth while pulled a lever and adjust it.
Maintenance
Myriad
Oneの
と
き
Index
157
- Top and bottom of the entire seat cushion adjustment
Driver's seat
It goes up.
It falls.
Steering wheel
Whenever the lever is moved under on, the height of the entire seat cushion is
adjusted.
The back also must operate the hand in the drip when the back also returns
the drip and operate the reclining lever along can.
- The back also must operate the hand in the drip when the back also returns the drip and operate the reclining
lever along can.
When the back doesn't suppress the drip and either the lever is operated, the back returns suddenly the drip, and might
be injured, too. -
When you move the seat, put neither hand nor the foot under the seat. It is placed between
the seat and it is likely to injure.
158
Adjustment of seat
Contents
Basic
. earliness.. operation
Button
Driving
Handling
device
Do not run with the headrest removed. A big impact joins the . good.. Safety
neck when colliding, the important injury related to the life might be received, and of ・
To
it is dangerous. Adjust height so that the center of the headrest may become behind theory Comfortable
and
the ear. equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
159
How to use of the armrest.
- Angle adjustment type *
1 Armrest..once..extremely..lift.
Bambo basketAfter that ..)..
Extremely..lower. 笆) 。
(Lower as it is when there are already
about 45. or more armrest
from the under up. )
Armrest
2 When the armrest is raised to the position
of the favorite up between from the under
to about 45. , it is fixed at the position.
- When the armrest is fixed, it is not
possible to lower below from the position
directly. -
When you lower below 1 It lowers to the under
according to ..drinking.. procedure.
Armrest
160 - As for the sign, the presence of the installation is different depending on the grade etc.
Adjustment of seat
Basic
. earliness.. operation
Driving
Handling
device
Lever Lever
The
Handling indoor
equipment
Move the seat back and forth while pulled a lever and adjust it.
. good.. Safety
of ・
- Reclining adjustment To
theory Comfortable
Seven person getting on car Six person getting on car and
equipment
How
to attention
associate . drinking..
car
Maintenance
と
き
The back also must move the drip back and forth while pulled a lever and adjust it.
Index
161
Do not position it while about running.
It moves suddenly greatly when slamming on the brakes the seat, is thrown out, and
might receive important injury that causes an unexpected accident and is related to the
life and is dangerous.
The back also must operate the hand in the drip when the back also returns
the drip and operate the reclining lever along can.
- The back also must operate the hand in the drip when the back also returns the drip and operate the reclining
lever along can.
When the back doesn't suppress the drip and either the lever is operated, the back returns suddenly the drip, and might
be injured, too. -
When you move the seat, put neither hand nor the foot under the seat. It is placed between
the seat and it is likely to injure.
162
Adjustment of seat
Contents
Basic
. earliness.. operation
Button
Driving
Handling
device
Do not run like the state to lower the headrest while . good.. Safety
of ・
removed. A big impact joins the neck when colliding, the important injury related to To
the life might be received, and it is dangerous. Use the headrest while theory Comfortable
and
raised without fail. equipment
How
to attention
The headrest is only for Secandoshet. Confirm hearing "Catitsu" and associate . drinking..
the sound and fixation when you install it. When it is not possible to
car
fix when other headrests are installed by mistake, and it collides, it
is likely to injure.
Maintenance
Myriad
Oneの
と
き
Index
163
Getting on going down to third seat
- When getting on
Clip
Reclining lever
Reclining lever
164
Adjustment of seat
Contents
the clip.
Refer to last page.
Basic
. earliness.. operation
The
Handling indoor
equipment
Band
. good.. Safety
of ・
To
Six person getting on car theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Band
Myriad
Oneの
と
き
Index
165
- After it gets on and it descends
3 Confirm fixation.
Confirm the light shake also of the back of the drip, and fixation surely.
The back also must operate the hand in the drip when the back also returns
the drip and operate the reclining lever along can.
- The back also must operate the hand in the drip when the back also returns the drip and operate the reclining
lever along can.
When the back doesn't suppress the drip and either the lever is operated, the back returns suddenly the drip, and might
be injured, too. -
When you move the seat, put neither hand nor the foot under the seat. It is placed between
the seat and it is likely to injure.
166
Adjustment of seat
Contents
Knowledge
Warning
About a convenient function
Armrest
Seven person getting on car
Belt It is possible to use it as an armrest by pulling the belt of a central Basic
. earliness.. operation
seat and knocking it down forward.
Driving
Handling
device
The
Handling indoor
When the drip is made to be Flricraininged to a right back of the equipment
How
to attention
associate . drinking..
- Confirm the light shake of the seat and fixation surely when you return it based on
car
a central seat.
Myriad
Oneの
と
き
Armrest
Index
167
Adjustment of third seat
Belt
The back also must move the drip back and forth with the belt pulled and adjust it.
168
Adjustment of seat
Contents
Basic
. earliness.. operation
Driving
Handling
device
. good.. Safety
Do not run like the state to lower the headrest while of ・
removed. A big impact joins the neck when colliding, the important injury related to To
theory Comfortable
the life might be received, and it is dangerous. Use the headrest while and
equipment
raised without fail.
How
to attention
associate . drinking..
The headrest is only for the third seat. Confirm hearing "Catitsu" and
car
the sound and fixation when you install it. When it is not possible to
fix when other headrests are installed by mistake, and it collides, it is
likely to injure.
Maintenance
Myriad
Oneの
と
き
Index
169
Seat arrangement
I n d e x
P.172
P.176
P.184
170 - As for the sign, the presence of the installation is different depending on the grade etc.
Seat arrangement
Contents
Warning
It is possible to arrange it according to the situation as follows by the use of the seat arrangement
introduces by the left-hand page.
Basic
. earliness.. operation
How to make relaxation mode
Seven person getting on car Six person getting on car
Driving
Handling
device
P.189 The
Handling indoor
equipment
How
to attention
P.191 associate . drinking..
car
Myriad
Oneの
と
き
P.193
Index
- As for the sign, the presence of the installation is different depending on the grade etc. 171
How to make * of table mode
The back of the passenger's seat also knocks down the drip, and it is possible to use it as a table.
172 - As for the sign, the presence of the installation is different depending on the grade etc.
Seat arrangement
Contents
Lever 5 The back also knocks down the drip to the horizontal position.
Warning
The lever on the part of seat is improved and the
back also knocks down the drip. -
The drip falls in the back only because of one
of lever operations though there are two levers. Basic
. earliness.. operation
Driving
Handling
device
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
173
When you return it
1 Park the vehicle to a smooth place, and the gear-shift綟Putting and Parkingb
Surely put Raki, and stop the engine.
3 Confirm fixation.
Confirm the light shake of the seat, and fixation surely.
- The gear-shift in a smooth place when it changes to the table mode, and it returns
it and綟Put, put the parking brake surely, and stop the engine. The
seat moves unexpectedly while operating it unleveled land and uphill, and hands and feet etc. are placed, and important injury
might be received and it is dangerous. -
Do not do the operation that is changed to the table mode, and returned while running. The important
injury related to the life when it applied the brakes and when it collides might be received and it is
dangerous. -
Do not run while made to the table mode. The important injury related to the life when
it applied the brakes and when it collides might be received and it is dangerous. -
Never get on on the table. The seat is damaged, and an unexpected injury might
be done and it is dangerous. -
Confirm the light shake of the seat and fixation surely when it makes to
the table mode, and it returns it. It moves while running if the seat is not surely
fixed the seat, causes an unexpected accident, might injure, and is dangerous.
174
Seat arrangement
Contents
Knowledge
Warning
About the table mode
- The back of the seat also knocks down the drip while parking, and the seat can be used
as a table. -
When making it to the table mode, the mark of the buckle might remain in the seat if the buckle of the Basic
seat belt is not knocked down forward before it changes to the table mode. . earliness.. operation
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
175
Method of Secandoshetodablforlding storage
It is possible to operate it according to a procedure similar as for six person getting on car though it explains
with Secandoshet of seven person getting on car.
176
Seat arrangement
Contents
Basic
. earliness.. operation
Driving
Handling
Seat lock release belt 7 Pull the seat lock release belt at the device
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
177
8 Cause the seat cushion
forward.
The seat cushion might be locked
when the seat cushion is rotated
while it causes it, and it not
return.
9 The back also knocks down the drip to the horizontal position.
Pull the reclining lever, and knock down the
back until the drip becomes the horizontal.
Reclining lever
178
Seat arrangement
Contents
Band
- Seven person getting on car must
confirm the central seat seat belt is
Warning
not caught to the band etc. on the part
of seat.
Remove when
caught. Basic
. earliness.. operation
Driving
Handling
device
The
- A right seat of 4WD car
漓 Handling indoor
How
to attention
associate . drinking..
car
と
き
Index
179
When you return it
1 Park the vehicle to a smooth place, and
the gear-shift綟Putting and parking bourreeSurely
put Ki, and stop the
engine.
澆 滷
180
Seat arrangement
Contents
Basic
. earliness.. operation
Driving
5 Fix the seat cushion.
Handling
device
Suppress the edge (part of the arrow) in
front of the seat cushion. -
The hook under the seat cushion The
hangs to the striker, and the Handling indoor
equipment
seat cushion is fixed.
Hook
How
to attention
associate . drinking..
car
6
と
き
Confirm fixation.
Confirm the lift of the back of the
seat cushion, and fixation surely. Index
181
Guard the following about the Secandoshetodablforlding
storage.
- The gear-shift in a smooth place when the seat is stored, and it returns it and
綟Put, put the parking brake surely, and stop the engine. The seat
moves unexpectedly while operating it unleveled land and uphill, and hands and feet etc. are placed, and important injury might
be received and it is dangerous. -
The back knocked down must not run taking the person after the drip either. The important injury related to the
life when time that slammed on the brakes and colliding might be received and it is dangerous. -
Do not do the operation that stores the seat, and returns it while running. The important injury
related to the life when it applied the brakes and when it collides might be received and it is dangerous. -
Shake the seat before ..lightening.. and confirm fixation surely when you
store the seat. Important injury that moves while running if not fixed the seat, causes an unexpected
accident, and is related to the life might be received and it is dangerous. -
Confirm the lift of the back of the seat cushion, and fixation surely when you
return it based on the seat. Important injury that moves while running if not fixed the seat, causes
an unexpected accident, and is related to the life might be received and it is dangerous.
The back also must operate the hand in the drip when the back also knocks
down the drip and operate the reclining lever along can.
- The back also must operate the hand in the drip when the back also knocks down the drip and operate the reclining
lever along can. When the back doesn't suppress the drip and either the lever is operated, the back falls suddenly the drip,
and might be injured, too. -
Do not run on the seat with the seat stored. The seat might be
missed, and it injure by placing the foot between seats. -
Confirm the seat belt and the buckle of Secandoshet are surely stored when the seat
is stored by seven person getting on car, and it returns it and (Refer to P.203). When
the operation that is stored without being stored, and returned is done, the seat might be
damaged, and the seat belt and the buckle be damaged. -
Confirm not caught to the band etc. on the part of ..central seat seat belt.. when you
store the seat by seven person getting on car. When it is caught and the back also knocks down
the drip forward, the seat belt storage pocket (Refer to P.203) causes the band to tear, and
to transform. -
Operate the seat cushion having it by the hand when the seat cushion is caused forward
or it knocks it down backward. The belt might cut if the seat lock release belt
is operated having it. -
Do not get on the foundation part of the seat cushion when you cause the seat cushion
forward. It is likely to damage it. -
When you move the seat, put neither hand nor the foot under the seat. It is placed between
the seat and it is likely to injure.
182
Seat arrangement
Contents
Warning
Basic
. earliness.. operation
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
. drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
183
How to move up third seat
It is possible to make the seat divided right and left moved up respectively. -
It is possible to operate it from the backing door side in the car.
Operation in car
- When moving up
4 The back also knocks down the drip to the horizontal position.
Pull the reclining belt, and knock down
the back forward full until the drip becomes
the horizontal.
Reclining belt
184
Seat arrangement
Contents
device
How
to attention
associate . drinking..
Reclining belt
car
4 Confirm fixation.
Confirm the light shake also of the back Maintenance
of the drip, and fixation surely.
Myriad
Oneの
と
き
Index
185
Operation from backing door side
- When moving up
4 The back also knocks down the drip to the horizontal position.
Fully pull the belt, release the lock, and
knock down the back forward until the drip becomes
the horizontal.
Belt
186
Seat arrangement
Contents
device
. good.. Safety
of ・
To
Belt theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
4 Confirm fixation.
Confirm the light shake also of the back Maintenance
of the drip, and fixation surely.
Myriad
Oneの
と
き
Index
187
Guard the following when you move up the third
seat.
- The gear-shift in a smooth place when the seat is moved up, and it returns it
and綟Put, put the parking brake surely, and stop the engine. The seat
moves unexpectedly while operating it unleveled land and uphill, and hands and feet etc. are placed, and important injury might
be received and it is dangerous. -
Return it based on Secandoshet when sitting on the third seat. The important
injury related to the life when time that slammed on the brakes and colliding might be received and it
is dangerous. -
The back knocked down must not run taking the person after the drip either. The important injury related to the
life when time that slammed on the brakes and colliding might be received and it is dangerous. -
Do not do the operation that stores the seat, and returns it while running. The important injury
related to the life when it applied the brakes and when it collides might be received and it is dangerous. -
Shake the seat before ..lightening.. and confirm fixation surely when you return
it based on the seat. Important injury that moves while running if not fixed the seat, causes an unexpected
accident, and is related to the life might be received and it is dangerous.
188
Seat arrangement
Basic
. earliness.. operation
Driving
Handling
1 Park the vehicle to a smooth place, and the gear-shift綟Putting and Parkingb
device
5 Adjust the positions most ahead before and behind the reception desk seat.
Maintenance
Refer to P.157.
6 The back of the reception desk seat also knocks down the drip backward until the difference Myriad
Oneの
with Secandoshet is lost.
Refer to P.157. と
き
Index
189
When you return it
Do according to a reverse procedure.
- The gear-shift in a smooth place when it changes to the relaxation mode, and it returns
it and 綟Put, put the parking brake surely, and stop the engine.
The seat moves unexpectedly while operating it unleveled land and uphill, and hands and feet etc. are placed, and important injury
might be received and it is dangerous. -
Do neither relaxation mode nor the returned operation while running. The important
injury related to the life when it applied the brakes and when it collides might be received and it is
dangerous. -
Shake the seat before ..lightening.. and confirm fixation surely when it
does to the relaxation mode or it returns it. Important injury that moves while running if
not fixed the seat, causes an unexpected accident, and is related to the life might be received and it is
dangerous. -
Do not run putting the person and luggage while made to the relaxation mode. The important injury
related to the life when time that slammed on the brakes and colliding might be received and it is
dangerous.
The back also must operate the hand in the drip when the back also returns
the drip and operate the reclining lever along can.
- The back also must operate the hand in the drip when the back also returns the drip and operate the reclining
lever along can. When the back doesn't suppress the drip and either the lever is operated, the back returns suddenly the
drip, and might be injured, too. -
Do not run on the seat while made to the relaxation mode. The seat might
be missed, and it injure by placing the foot between seats. -
Do not operate the relaxation mode with the person has gotten on the seat. It is
likely to injure by hitting the seat. -
When you move the seat, put neither hand nor the foot under the seat. It is placed between
the seat and it is likely to injure.
190
Seat arrangement
Basic
. earliness.. operation
Driving
Handling
1 Park the vehicle to a smooth place, and the gear-shift綟Putting and Parkingb
device
2
Handling indoor
equipment
Move the reception desk seat forward.
Refer to P.157.
. good.. Safety
3 Put it into the state to lower the headrest of Secandoshet and the third seat.
of ・
To
theory Comfortable
Refer to P.163,169. and
equipment
car
Refer to P.176. と
き
Index
191
When you return it
Do according to a reverse procedure.
The back also must operate the hand in the drip when the back also knocks
down the drip and operate the reclining lever along can.
- The back also must operate the hand in the drip when the back of Secandoshet also knocks down the drip and
operate the reclining lever along can. When the back doesn't suppress the drip and either the lever is operated, the back
falls suddenly the drip, and might be injured, too. -
Do not run on the seat while made to the Big cabin mode. Moreover,
move stepping on the center of the seat slowly when you move on the seat. The seat
might be missed, and it injure by placing the foot between seats. -
Do not operate the Big cabin mode with the person has gotten on the seat. It is
likely to injure by hitting the seat. -
When you move the seat, put neither hand nor the foot under the seat. It is placed between
the seat and it is likely to injure.
192
Seat arrangement
Basic
. earliness.. operation
Driving
1 Park the vehicle to a smooth place, and the gear-shift綟Putting and Parkingb
Handling
device
Surely put Raki, and stop the engine.
3 Put it into the state to lower the left seat headrest of Secandoshet and the
third seat. . good.. Safety
of ・
Refer to P.163,169. To
theory Comfortable
and
equipment
4 Make the passenger's seat a table mode.
How
Refer to P.172. to attention
associate . drinking..
5 Put a third seat left seat into the state of moving up.
car
Refer to P.184.
Adjust the positions most before and behind Secandoshet when you
adjust the positions from by previous most before and behind Secandoshet
Myriad
to. (Refer to P.161. ) Oneの
と
き
7 Store Secandoshet left seat in Dablforlding.
Refer to P.176. Index
- As for the sign, the presence of the installation is different depending on the grade etc. 193
When you return it
Do according to a reverse procedure.
The back also must operate the hand in the drip when the back also returns
the drip and operate the reclining lever along can.
- The back also must operate the hand in the drip when the back of the reception desk seat or Secandoshet
also returns the drip and operate the reclining lever along can. When the back doesn't suppress the drip and either
the lever is operated, the back returns suddenly the drip, and might be injured, too. -
Do not run on the seat while made to the super-long space mode. The seat
might be missed, and it injure by placing the foot between seats. -
Do not operate the super-long space mode with the person has gotten on the seat. It
is likely to injure by hitting the seat. -
When you move the seat, put neither hand nor the foot under the seat. It is placed between
the seat and it is likely to injure.
194
Seat arrangement
Contents
Warning
Basic
. earliness.. operation
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
. drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
195
Wearing of seat belt
Correct wearing of seat belt
The seat belt might reduce the effect by half, and be dangerous if it doesn't correctly
wear it. Those who drive must wear without fail according to the following use before it runs, and let me
wear it to those who multiply this.
The back also must adjust the drip, set up the upper part of the
Shoulder belt body, and sit ..waist.. deeply disregarding it.
Put it enough on the shoulder.
(Do not hang to the neck,
and shift from the shoulder. )
Do not twist.
Waist belt
The hipbone must stick to a low position
as much as possible. without fail
196
Wearing of seat belt
Contents
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
197
Wear the seat belt. Moreover, guard
the following when you wear it.
- The seat belt hits the neck and the jaw, and the child seat junior seat is used
for a small child who doesn't hang to the hipbone. Strong pressure is received when colliding
when not using it, and it reaches important injury or, in the worst case, it is likely to lead to the
death. Moreover, a small child of one sitting who cannot do must use the baby seat.
Consult the Toyota shop about the seat only for the child.
- The foreign body must not enter the buckle of the seat belt. In the worst case, the effect
with an enough seat belt is not demonstrated when the plate might not completely fit in the buckle when the
foreign body enters, and it collides, it reaches important injury or, it is likely to lead to the death. -
It becomes loose, it is possible to be worn out, and exchange the seat belt that doesn't operate normally at
once for the new article of pure Toyota. Moreover, receive the high impact due to the accident, and exchange the
seat belt that attaches the wound at once without using it for the new article. In the worst case, it doesn't work
normally when colliding when using it as it is, the effect with an enough seat belt is not demonstrated, it reaches
important injury or, it is likely to lead to the death. -
Remodel, resolve or neither installation nor detach the seat belt. The effect with
an enough seat belt is not demonstrated when colliding, and it reaches important injury or, in the worst
case, it is likely to lead to the death. Consult the Toyota shop about the installation, detaching,
and the exchange of seat belts. -
Do not use organic solvents such as benzine and gasoline to clean the seat belt. Moreover,
do not bleach, and do not dye the belt. Important injury that doesn't demonstrate the effect
with an enough seat belt when the performance of the seat belt falls, and it collides and is related to the life might
be received and it is dangerous. Do not use the seat belt until drying by using the soapless soap or
lukewarm water when you clean it.
198
Wearing of seat belt
The
How
to attention
associate . drinking..
Myriad
Oneの
と
き
Index
199
4 Wear the shoulder belt.
The shoulder belt makes it hang enough to the
shoulder without fail.
At this time, the belt doesn't hit the
neck, and it doesn't shift from the shoulder.
SRS curtain shield air 5 In the reception desk seat, adjust the
bag installation car height of the belt.
Anchor part Adjust the height of the belt as an
adjustable seat belt anchor.
. Raise
The belt must hang to the center of the
it. shoulder as much as possible when adjusting it. -
Have the anchor part, and move it as
it is when you raise it. -
. . Lower. Move the anchor part with the lock
button pushed, and adjust it at the best
. position when you lower.
Lock button Confirm hearing "Catitsu" and the
sound, and fixation surely.
Exclude the SRS curtain
shield air bag installation car.
The
anchor
part
. Raise
it.
. . Lower.
.
Lock button
200
Wearing of seat belt
Contents
Basic
. earliness.. operation
Button Driving
Handling
device
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
201
How to wear two point expression seat belt
Buckle
202
Wearing of seat belt
Contents
device
The
Knowledge Handling indoor
equipment
About the storage of Secandoshetobelt
associate . drinking..
car
Rubber band
203
Fixation of child seat
- Installation position
Seven person getting on car
Tag Label
Topptezarancar
Bar only for fixation
- There are a seat cushion and a back in the bar only for fixation for the drip, too.
蘆..tag (.. surface where bar only for fixation shows equipment「ISOFIX」 ・Back
Respect「 L A T C H 」 ) is seated to the seat. -
Topptezarancar is in Shetocstion Gawa.
蘆The label that shows equipment with Topptezarancar attaches.
204
Fixation of child seat
2 Improve the headrest of Secandoshet to the place where "Catitsu" and the Basic
. earliness.. operation
sound are heard.
Confirm the headrest is fixed.
Driving
Handling
device
The
Handling indoor
equipment
3 Confirm the position of bar & Topptezarancar only for the child
seat fixation for ISOFIX. . good.. Safety
of ・
Refer to last page. To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
205
4 Install the seat (child seat baby seat) only for the child
in Secandoshet.
Install the installation metal fittings of the seat only for the suited child in the bar only
for fixation. Next, install Tezarbelt in Topptezarancar.
*Read the manual of the attachment each commodity the installation method and how
to detach it.
- Install it after the back of the seat also adjusts the angle of the drip
for the back of the seat to do the space between seats only for the drip, the
seat cushion, and the child. -
Pass between headrests, and multiply Tezarfcc by vehicle side Topptezarancar
as shown in the figure below so that Tezarbelt should not twist. -
Strongly pull part A until Tezarbelt picks up the slack, and fix the
seat only for the child.
Child of less than 9kg(For Child of 9kg-18kg(..about
newborn baby - about nine months. ) four ability of nine months-... )
Topptezarancar
Topptezarancar
Tezarbelt
Tezarbelt
Tezarfcc Tezarfcc
Tezarbelt
Tezarbelt
Part A Part A
- The illustration is the one for the explanation, and it differs from the shape of the seat only for an actual child.
206
Fixation of child seat
Contents
- When the seat only for the child is installed, confirm there is neither foreign body
around bar & Topptezarancar only for the child seat fixation for ISOFIX is a god not all-in
of the seat belt etc.In the worst case, it flies when the seat only for the child is not fixed when the foreign
body and the seat belt, etc. are bitten and it crowds, and it collides, it reaches important injury or, it is likely Driving
Handling
to lead to the death. -
device
It might cause an unexpected accident by hitting the crew and the one, etc. when having applied the
brakes when indoors leaving it with the seat only for the child detached and is dangerous. -
Multiply the tension until Tezarbelt picks up the slack without fail when you install the seat only for The
the child. The important injury related to the life when colliding might be received if Tezarbelt
Handling indoor
doesn't correctly put it and it is dangerous. equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
- Pass Tezarbelt under the headrest. The important injury related to the
car
life when the seat only for the child is not firmly fixed when multiplying on the headrest, and it collides
might be received and it is dangerous.
Maintenance
Myriad
Oneの
と
き
Index
207
Guard the following when you fix the seat only for the
child with Topptezarancar.
- Do not lower the headrest after the headrest is improved and it fixes to Topptezarancar
when you install the seat only for the child with the headrest raised.
In the worst case, the seat only for the child moves when Tezarbelt's hitting the headrest if the
headrest is lowered, slackening, and colliding, it reaches important injury or, it is likely to
lead to the death. Headrest
Headrest
Tezarbelt
Tezarbelt
Store in the luggage room or remove from the vehicle and keep it when you do not use
the seat only for the child for a long term. The seat might discolor, and the
type collapse when it is left to install it in the seat.
Knowledge
208
Fixation of child seat
car
Shoulder belt
- The illustration is the one for the explanation, and it differs from the shape of the seat only for an actual child. Index
209
5 Confirm fixation surely.
Confirm the light shake of the installed seat, and fixation
surely.
Often read the manual of the attachment and obtain the installation
of the seat only for the child for the commodity correctly.
- In the worst case, it reaches important injury by flying when time that slammed on the
brakes and colliding if not correctly installed or, it is likely to lead to the death. -
It might cause an unexpected accident by hitting the crew and the one, etc. when having applied the
brakes when indoors leaving it with the seat only for the child detached and is dangerous. -
Do not let the child play with the child seat fixation mechanism addition seat belt. The belt
cannot be drawn out when it operates the child's playing with the seat belt and by mistake, and the belt coils
around the neck by any chance, and it reaches important injury like suffocation etc. or, in the worst case, it is
likely to lead to the death. Cut the seat belt with scissors etc. when it enters such a state
by any chance by mistake, and the buckle cannot be removed.
Store in the luggage room or remove from the vehicle and keep it when you do not use
the seat only for the child for a long term. The seat might discolor, and the
type collapse when it is left to install it in the seat.
210
Fixation of child seat
Contents
Knowledge
Warning
About the seat belt with the child seat fixation mechanism
- The seat belt with the child seat fixation mechanism is built into the seat belt
of Secandoshet. When the child seat baby seat is installed, it is convenient because the belt can be
prevented from moving in the direction of drawing out. - Basic
The child seat fixation mechanism might operate when big movement of the upper part of the . earliness.. operation
body is done with the seat belt worn. In that case, wear the seat belt again after
releasing the child seat fixation mechanism of unbuckling once, and winding up up the
belt fully.
Driving
Fix the seat only for the child who suits the security standard of the road Handling
transportation vehicle with bar & Topptezarancar only for the child seat fixation for ISOFIX in device
fixation by bar & Topptezarancar only for the child seat fixation for ISOFIX of this
car, and give to me in the seat belt of this car in the melting pot. The
(Refer to P.205 for bar & Topptezarancar only for the
Handling indoor
child seat fixation for ISOFIX. ) equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
211
Adjustment of steering wheel mirror
Adjustment of steering wheel
Lever
When it presses a lever down, the steering wheel is moved up and down, it makes to an appropriate position,
and the lever is improved, it is fixed.
- Do not adjust the handle position while running. It mistakes driving while adjusting it, might cause
an unexpected accident, and is dangerous. -
Confirm fixation surely after adjusting the handle position. It divides
as the position of the steering wheel is sudden if fixation is insufficient, might cause an unexpected accident, and is dangerous.
Knowledge
212
Adjustment of steering wheel mirror
Basic
. earliness.. operation
Driving
Handling
Main body of inner mirror
device
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
Lever
car
Use it with the lever under the mirror pushed forward usually.
Pull the lever forward when you dazzle the headlamp of the following car.
Maintenance
と
き
Index
213
Adjustment of door mirror
Main switch
1 Push the main switch on the adjusted
side.
R . right door mirror
L. Left door mirror
Method of storage
Storage switch State of switch State of mirror
ON
(storage)
OFF
(return)
It changes into turning on (storage) and turning off (return) whenever the storage switch is
pushed. Can it store and it return with the hand when the engine switch
is LOCK.
214
Adjustment of steering wheel mirror
Contents
device
Knowledge
The
About the operation condition Handling indoor
equipment
- When the engine switch is ACC or is turned on, it is possible to use it. -
The storage operation stops when the engine switch is made LOCK while the door mirror storage is operating. -
In the following cases, the mirror returns to the state of the storage switch even if the door mirror is stored and returned
with the hand. . good.. Safety
of ・
蘆When the engine switch is ACC or is turned on. To
蘆When you make the engine switch ACC or turn on after it operates it by hand power. - theory Comfortable
and
When the storage switch knocks it down forward on the hand while turned off (return) the door equipment
mirror, the mirror doesn't return even of ACC or turning on the engine switch. The storage switch must
be turned off again once after making the storage switch O N (storage) and it must return. How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
215
How to use * of the mirror heater.
Switch
Operate for about 15 minutes when you push the switch, and stop when pushing again while operating. -
The operation display light lights while operating.
The surface of the door mirror doesn't become hot while operating, and do not touch it.
The burn might be done and it is dangerous.
It causes the battery rising when continuously using it for a long time.
Knowledge
About the mirror heater
Warm the specular of the door mirror, and remove frost, dew, and the drop, etc.-
Riyauindudefoggar (Refer to P.290) operates simultaneously with the mirror heater.
216 - As for the sign, the presence of the installation is different depending on the grade etc.
Adjustment of steering wheel mirror
Contents
Warning
Basic
. earliness.. operation
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
217
How for engine to start
How to use of the engine switch.
When engine
stopsPosition in which the following electrical equipment can be used.
Door mirror etc.
Position engine's rotating.
All electrical equipments can
be used.
Position that can pull out key and open.
When the key is pulled out, the
steering wheel is locked. Position in which engine is started.
When the engine stops, it causes the battery rising when the engine switch is
left like turning on or ACC, etc. at the length time.
218
How for engine to start
1
Parking brake pedal
Confirm the position of the pedal.
Warning
Adjust the position of the seat to take
correct driving posture (P.155 reference), and
confirm each position of the pedal.
Basic
. earliness.. operation
Gas pedal
Driving
Brake pedal Handling
device
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
綟. . . . g o .
Myriad
Oneの
と
き
Index
219
4 Start the engine.
Spend the engine switch in START
turning on the engine switch, and without
stepping on the gas pedal.
- Never do the engine start outside the car. It might cause an unexpected
accident, it is dangerous, and get under the wheel. -
Do not stop the engine while running. It might cause an unexpected accident by the steering
wheel's working of the brake neither the brake twice power device nor the power steering's working,
worsening, and becoming very heavy and is dangerous if it doesn't engine starts. -
Start the engine when you move the car a little. It might cause an unexpected
accident when the car is moved by not starting up an engine, and using the slope and is dangerous.
Knowledge
About an anti-theft system
The anti-theft system installation car might not engine starts by an anti-theft
system (Refer to P.374).
About the exhaust sound
Increase the amount of the inhalation air to decrease exhaust gas when cold starts and warm the catalyst rapidly
in the car equipped with 1AZ-FSE engine. In that case, it is not abnormal though the exhaust sound might
temporarily become large.
220
How for engine to start
Contents
Warning
Basic
. earliness.. operation
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
. drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
221
How to use of the gear-shift.
How to use of the gear-shift of the Super ECT installation car.
Working of gear-shift
Parking and engine start
Retreat
R The gear is fixed to the retreat.
The buzzer rings. 緘It informs
(reverse) those who drive of.
D Running usually(advancement)
It changes the speed according to the stepping addition and
subtraction of the speed and the accelerator.
(drive)
222
How to use of the gear-shift.
Contents
Handling of gear-shift
- Operation of gear-shift Warning
device
D S D S
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
223
How to use of the sequential shift mode.
- How to sequential shift mode to switch
Sequentially
Shiftomaticc display light
Shift position
display light
The gear-shift 絲It becomes and a sequential shift mode, and it is Chen.
The changing the speed steps can be switched by + side or operating Gerebar
on the side. -
The Shekenshalshiftomaticc display light lights when changing to the
sequential shift mode. (Refer to P.259. )-
The gear-shift 綺And the sequential shift mode are made clear, and it
returns to a usual control.
Shift up
Move the gear-shift to + side when you do
the shift improvement.
Move the gear-shift to the side when you
do the down of the shift. -
It changes the speed by one step whenever the
gear-shift is operated.
Shift down
224
How to use of the gear-shift.
Contents
4 Divide from one velocity into the gear of four-speed automatic according to the speed and the
running condition.
Basic
Divide into the gear from 1 velocity to 3 velocities automatic according to the speed and the . earliness.. operation
3 running condition. -
A light engine brake is obtained in the downward slope. -
A smooth running that the changing the speed frequency is a little can be done in the acclivity.
Driving
Divide into the gear at one velocity or two velocities automatic according to the speed and Handling
The
. good.. Safety
Knowledge of ・
To
The gear-shift 綺から 緝About the shift position display of ..decrease.. Ki when it substitutes it theory Comfortable
and
The gear-shift 綺から 絲にすると. 笳However, it is displayed. equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
225
Knowledge
About the warning buzzer
There is a limitation in the shift operation to secure the driving performance for safety, and it is likely not to
be shifted to hoped the changing the speed steps. The warning buzzer rings when the down of the shift by the shift
operation is not done.
226
How to use of the gear-shift.
Contents
Warning
Basic
. earliness.. operation
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
227
1.8L car(4WD car)
Working of gear-shift
Parking and engine start
Retreat
R The gear is fixed to the retreat.
The buzzer rings. 緘It informs
(reverse) those who drive of.
D Running usually(advancement)
Divide into responding to the speed, and the
gear automatic from 1 velocity to four-speed.
(drive)
Running on slope(advancement)
228
How to use of the gear-shift.
Contents
Handling of gear-shift
- Operation of gear-shift Warning
L L
The
Handling indoor
equipment
Knowledge
About the safety
. good.. Safety
Shift lock system of ・
The system that prevents the gear-shift of the automatic car being mis-operated. - To
theory Comfortable
The gear-shift if you did not step on the brake pedal 綟It twines and Re bar cannot be operated. and
equipment
蘆When the engine switch is ACC or LOCK, it is not possible to operate it even if stepping on the
brake pedal.
How
蘆It is not likely to be able to operate it when stepping on the brake pedal with the gear-shift knocked down to the to attention
passenger's seat side. Operate it previously depressing the brake pedal.
associate . drinking..
- 綟The key doesn't come off in things except the engine switch.
蘆When you pull out the key from the engine switch綟Give to me. ( 綟The key is AC. car
It is not possible to spend from C in LOCK. )
- 緘And the buzzer ring.
蘆The buzzer rings. 緘It informs those who drive of.
蘆The person outside the car must not hear of the sound. (No warning sound to the person Maintenance
outside the car. )
229
How to use of the gear-shift of Super CVT i installation car.
Working of gear-shift
Retreat
R The gear is fixed to the retreat.
The buzzer rings. 緘It informs
(reverse) those who drive of.
D Running usually(advancement)
It changes the speed according to the stepping addition and
subtraction of the speed and the accelerator.
(drive)
230
How to use of the gear-shift.
Contents
Handling of gear-shift
- Operation of gear-shift Warning
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
231
How to use of doing sports the sequential shift mode.
- How to doing sports sequential shift mode to switch
Sportsshekenshalshiftomaticc
display light
Shift position
display light
The gear-shift 綯It becomes and doing sports a sequential shift mode.
The changing the speed steps can be switched by + side or operating the
gear-shift on the side. -
The Sportsshekenshalshiftomaticc display light lights when changing to
doing sports the sequential shift mode. (Refer to P.259. )-
The gear-shift 綺And doing sports the sequential shift mode are made
clear, and it returns to a usual control.
Shift up
Move the gear-shift to + side when you do
the shift improvement.
Move the gear-shift to the side when you
do the down of the shift. -
It changes the speed by one step whenever the
gear-shift is operated.
Shift down
- The changing the speed steps that have been selected between
1-7 are displayed in the shift position display light.
(Refer to P.256. )
232
How to use of the gear-shift.
Contents
Basic
. earliness.. operation
Driving
Handling
device
The
Handling indoor
The changing the speed steps are fixed to M1. equipment
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
233
Knowledge
About the warning buzzer
There is a limitation in the shift operation to secure the driving performance for safety, and it is likely not to
be shifted to hoped the changing the speed steps. The warning buzzer rings when the down of the shift by the shift
operation is not done.
234
How to use of the gear-shift.
Contents
Basic
SNOW . earliness.. operation
Driving
Handling
device
SNOW switch
The
It changes into the snow mode if the SNOW switch is pushed, and it is released when Handling indoor
pushing again. - equipment
The SNOW display light in the meter lights when changing to the snow mode.
(Refer to P.258. )
. good.. Safety
of ・
To
Knowledge theory Comfortable
and
equipment
About the snow mode
The engine power is controlled, and it is suitable for the start on a slippery road such as the snow roads. How
to attention
associate . drinking..
About the operation condition
car
- When the engine switch is turned on, it is possible to use it. -
When the engine switch is made ACC or LOCK, the snow mode is made clear.
Maintenance
Myriad
Oneの
と
き
Index
235
2.0L car(G grade)
Working of gear-shift
Parking and engine start
Retreat
R The gear is fixed to the retreat.
The buzzer rings. 緘It informs
(reverse) those who drive of.
D Running usually(advancement)
It changes the speed according to the stepping addition and
subtraction of the speed and the accelerator.
(drive)
Running on slope(advancement)
S A light engine brake is obtained in
the downward slope. A
(
Sports
drive ) smooth running that the changing the speed frequency
is a little can be done in the acclivity.
236
How to use of the gear-shift.
Contents
Handling of gear-shift
- Operation of gear-shift Warning
device
D S D S
B B
The
Handling indoor
equipment
Knowledge
About the safety feature
. good.. Safety
Shift lock system of ・
The system that prevents the gear-shift of the automatic car being mis-operated. - To
theory Comfortable
The gear-shift if you did not step on the brake pedal 綟It twines and Re bar cannot be operated. and
蘆When the engine switch is ACC or LOCK, it is not possible to operate it even if stepping on the equipment
brake pedal.
How
蘆It is not likely to be able to operate it when stepping on the brake pedal with the gear-shift knocked down to the to attention
passenger's seat side. Operate it previously depressing the brake pedal.
associate . drinking..
- 綟The key doesn't come off in things except the engine switch.
蘆When you pull out the key from the engine switch綟Give to me. ( 綟The key is AC. car
It is not possible to spend from C in LOCK. )
- 緘And the buzzer ring.
蘆The buzzer rings. 緘It informs those who drive of.
蘆The person outside the car must not hear of the sound. (No warning sound to the person Maintenance
outside the car. )
237
How to use of the SNOW switch.
SNOW
SNOW switch
It changes into the snow mode if the SNOW switch is pushed, and it is released when
pushing again. -
The SNOW display light in the meter lights when changing to the snow mode.
(Refer to P.258. )
Knowledge
About the snow mode
The engine power is controlled, and it is suitable for the start on a slippery road such as the snow roads.
238
How to use of the gear-shift.
Contents
Warning
Basic
. earliness.. operation
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
. drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
239
How to drive automatic car
Method of start
Brake pedal
Parking
Brake pedal
2 Release the parking brake with the left
leg.
Refer to P.246.
Gas pedal
240
How to drive automatic car
Contents
3 Release the parking brake with the left leg after confirming the feeling where the car Driving
Handling
begins to move, and start.
device
The
Operate the gear-shift with stepping on the brake Handling indoor
pedal firmly. equipment
- Operate the gear-shift when you start with stepping on the brake pedal
firmly. Especially, step on more unfaltering and the brake pedal so that the creep phenomenon may strengthen when
immediately after the engine start and the air conditioner operates. - . good.. Safety
of ・
It is not necessary to make a mistake in stepping confirming the position of the brake pedal and the gas To
pedal without fail when you drive. The car starts rapidly when the gas pedal is mistaken for the brake pedal and theory Comfortable
and
it steps, it causes an unexpected accident, and it reaches important injury or, in the worst case, it is likely to equipment
lead to the death. -
Never do the gear-shift operation by having depressed the gas pedal. How
to attention
It starts rapidly by the car, might cause an unexpected accident, and is dangerous.
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
241
Method of running
Usual running
The gear-shift 綺It runs with put. -
Accelerate and decelerate only by operating the accelerator and the brake.
To accelerate rapidly
Depress the gas pedal fully. It ..kicking down doing.. accelerates rapidly.
242
How to drive automatic car
Contents
- Downward slope
Working of the brake might worsen when the service brake is used too
Warning
much.
The gear-shift 綺When the speed goes out too much by
1.8L car(FF car)
Basic
The gear-shift 絲It runs, three velocities or two velocities. . earliness.. operation
- The gear-shift while running 緜Do not put. It might cause an unexpected accident How
to attention
because the engine brake doesn't work at all and is dangerous. -
The gear-shift while running to advance 緘Do not put. The wheel locks and an unexpected thing. associate . drinking..
Therefore, it might connect and is dangerous. Moreover, impossible power joins an automatic car
transmission, and it is likely to break down. -
Operate the brake pedal by the same right leg as the gas pedal. The brake operation by the
left leg might cause an unexpected accident as the reaction in the emergency is delayed and is dangerous. -
The gear-shift in 1.8L car (FF car) on the slope etc. 綺・ 絲、1.8L car(4WD car) Maintenance
Then,綺・ 笳・ 笆・ 綢、In 2.0L car (G grade) 綺・ 絲・ Silk gauze、2.0L car(Z grade)
Then,綺・ 綯I t r e t r e a t s w i t h . 緘Advancing with is an absolute mother-of-pearl.
Do not be. It stalls, it might cause a breakdown and an unexpected accident by the steering
wheel's working of the brake worsening, and becoming heavy, and it is dangerous. Myriad
Oneの
と
The gear-shift 緜It might cause the breakdown of the き
transmission when running to.
Index
243
Method of stop and parking
Method of stop
1 It pulls up a car. The gear-shift 綺The brake pedal by and the right leg
Step firmly.
The air conditioner operates intermittently by the temperature change. The idol improves
automatically, the creep phenomenon strengthens while operating, and note that
the car doesn't begin to move especially.
244
How to drive automatic car
Contents
Method of parking
1
Warning
Stop the car completely.
. good.. Safety
of ・
The gear-shift while running 綟D o n o t p u t . To
theory Comfortable
and
- The gear-shift while running 綟D o n o t p u t . A u t o m a t i c t r a n s m i s s i o n equipment
It drinks, is locked Uti mechanically, might cause an unexpected accident, and is dangerous. -
How
Do not rev while stopping. The gear-shift 綟・ 緜It is, and the car is a rapid departure. to attention
It might connect and is dangerous in the accident of ..advancement.. not trowed.
associate . drinking..
car
Stop the engine without fail and lock the door when parting
from the car.
Maintenance
- When it is left to start up an engine, the gear-shift : by any chance. 綟Cri at a certain time.
The car in the P phenomenon begins to be likely to move automatically, and when depressing it, to start
the gas pedal rapidly by mistake. -
Step on the gas pedal and the brake pedal at the same time, and the gear-shift in the acclivity綺のまま Myriad
Oneの
Do not stop the accelerator though it is deep. An automatic transmission overheats,
and it causes the breakdown. と
き
Index
245
How to use of the parking brake pedal.
Handling of parking brake pedal
Brake pedal
Depress the parking brake pedal with the left leg fully while firmly stepping
on the brake pedal by the right leg. -
The brake warning light lights.
Brake pedal
Depress the parking brake pedal with the left leg while firmly stepping on the brake pedal
by the right leg until "Catitsu" and the sound are heard, and separate slowly.
- The brake warning light is turned off.
246
How to use of the parking brake pedal.
Contents
Do not run with the parking brake put. The brake parts
are worn out early, and the brake overheats and effective might worsen. Warning
Knowledge Basic
. earliness.. operation
When putting it again
Step again after it releases it once when you want to put after the parking brake is put
again.
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
247
View of meter, display light, and warning light
Meter
Optitorommatar
Fuel gauge next page
Engine rotation meter next page
Analog meter
Engine rotation meter next page Speed meter next page
Knowledge
About the meter
When the engine switch is turned on, the indicator in the meter is not abnormal though are for
a short time about 0 scale slight movement situation.
248
View of meter, display light, and warning light
Contents
Fuel gauge
When the engine switch is turned on, the amount of the fuel remainder is shown. Warning
Knowledge Basic
. earliness.. operation
The
Handling indoor
equipment
Speed meter
The running speed of the vehicle is shown.
. good.. Safety
of ・
To
theory Comfortable
and
equipment
car
Drive so that the indicator should not enter Red Zone (range to have exceeded a permissible
rotational speed of the engine). The engine etc. are influenced harmfully when driving
that the indicator enters Red Zone is continued, and it is likely to damage it.
Maintenance
Knowledge
About the check on the engine system of 2.0L car Myriad
Oneの
The changing the speed ratio of the transmission might be changed for the check on the engine system
と
while running a constant speed, and engine revolutions be raised. However, there is no change at the speed き
of the vehicle.
Index
249
Information display
Do the following display when you turn on the engine switch.
- Odometer
Optitorommatar Analog meter
- Trip meter
Optitorommatar Analog meter
Display two kinds of section distances (trip A and trip B) by the unit of km.
- Illuminance adjustment
Optitorommatar
Display fuel cost after the engine is started, and running begins momentarily. -
When stopping, "0.0km/L" is displayed.
250
View of meter, display light, and warning light
Contents
Basic
. earliness.. operation
Update every about ten seconds and display the average fuel cost after trip A
is reset in 0. -
When the connection with the battery is refused, "0.0km/L" is displayed.
Driving
Handling
- Velocity of average car(km/h) device
Optitorommatar Analog meter
The
Handling indoor
equipment
Update every about ten seconds and display the velocity of the average car when you
turn on the engine switch after trip A is reset. - . good.. Safety
When the connection with the battery is refused, "0.0 km/h" is displayed. of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
251
Information display switch button
(trip meter reset button)
- How to switch information display
The display changes as follows whenever the switch button is pushed.
Odometer
.
Trip meter A
.
Trip meter B
.
Illuminance adjustment *
.
Fuel cost at moment
.
Average fuel cost
.
Velocity of average car
252
View of meter, display light, and warning light
Contents
2 Keep pushing the button for about one second or more while displaying the illuminance adjustment screen.
Driving
The frog can do the brightness level of meter lighting as shown in the table below. - Handling
Separate the hand from the button when becoming the brightness of the favorite. - device
When the light is turned off and it lights, each brightness level can be set.
The
Brightness level When light is turned off When light lights Handling indoor
equipment
It -
is 12
bright.
. good.. Safety
3 of ・
To
theory Comfortable
and
4 equipment
How
5 to attention
associate . drinking..
It
car
is dark.
- When the light is lit, no do decrease in lights of meter lighting when setting it to level 1.
Maintenance
Knowledge
About the operation condition of meter lighting
Light when you turn on the engine switch, and turn it off when making it to ACC or LOCK. Myriad
Oneの
と
き
Index
253
Display light
Optitorommatar
Sportsshekenshalshiftomaticc
display light 259
Shift position display light 256
Analog meter
4WD auto mode operation display light 260
Direction instruction display light 256 Headlamp upward display light 256
Light of width of car display light 256
The display light in all grades is published in figure. The display light set to an actual car is
different depending on the grade etc.
254
View of meter, display light, and warning light
Contents
Driving
Handling
Headlamp upward display Sportsshekenshalshiftomaticc
light display light device
The
Shekenshalshiftomaticc
Light of width of car display light Handling indoor
display light equipment
OFF How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
255
Shift position display light
The shift position that has been selected is displayed as follows. -
1.8L car (FF car): PRND(1. 4 *1) -
1.8L car (4WD car): PRND 3 2 L-
2.0L car (G grade): PRNDSB-
2.0L car (Z grade): PRND(1. 7 *2)
- 1 When the shift position is S, it is displayed. -
2 When the shift position is M, it is displayed.
Knowledge
When blinking quickens abnormally
The lamp cutting of the direction instruction light is thought. Confirm whether the direction instruction
light blinks.
256
View of meter, display light, and warning light
Contents
Light when you put TRC into the operation halt condition pushing device
the TRC OFF switch (Refer to P.294). -
Light when abnormality is found in the VSC system and the TRC
The
system and the EFI system.
Handling indoor
equipment
How
to attention
car
About the display light
Light when you turn on the engine switch, and turn it off after a few seconds.
Maintenance
Myriad
Oneの
と
き
Index
257
Slipping display light
VSC installation car
Blink when the VSC system or the TRC system
operates. (Refer to P.365-367. )
Moreover, blink when the vehicle seems to sideslip and becomes it.
Knowledge
About the display light
Light when you turn on the engine switch, and turn it off after a few seconds.
258
View of meter, display light, and warning light
Contents
Sportsshekenshalshiftomaticc
display light Warning
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
259
4WD auto mode operation display light
4WD car
- Become 4WD auto mode after it blinks twice if you
push 4WD auto mode switch at the FF mode and light.
(Refer to P.293. )-
Become FF mode if you push 4WD auto mode switch
at 4WD auto mode, and turn it off.
Knowledge
About the display light
- Light when you turn on the engine switch, and turn it off after a few seconds
at the FF mode. Light when you turn on the engine switch at
4WD auto mode. -
Blinking might continue when the difference of the rotational speed of the back and forth
circle is great etc.)(like FF mode while blinking.
In this case, separate the foot from the gas pedal once. -
4WD auto mode operation display light blinks when the state with a great difference of the
rotational speed of the circle continues for a long time while about running in 4WD auto mode.
Driving power distribution to the rear wheel is stopped for the protection of the drive and the system parts, and it
becomes FF mode while blinking the operation display light.
Leave the stop in the place of safety at once, and starting up an
engine in this case. It returns to 4WD auto mode if it divides after a while from
blinking into lighting. -
When abnormality occurs in 4WD system, 4WD auto mode operation display
light might be turned off. In this case, it becomes FF mode regardless
of the position of 4WD auto mode switch.
260
View of meter, display light, and warning light
Contents
Security display
Warning
Anti-theft system installation car
Blink when the key is pulled out from the engine switch, and an anti-theft
system becomes an operating state. (Refer to P.374. )
Basic
. earliness.. operation
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
261
Warning light
Optitorommatar
VSC warning light 268 Dischargeheddoramportorebering warning light 270
SRS air bag/pretensioner warning light 267
Charge warning light 275
Water temperature warning light 274
Engine warning light 272
Analog meter
Dischargeheddoramportorebering warning light 270
SRS air bag/pretensioner warning light 267
Half door warning light 277 Charge warning light 275 Water temperature warning light 274
Engine warning light 272
262
View of meter, display light, and warning light
Contents
Warning
Basic
. earliness.. operation
Driving
Handling
Passenger's seat seat belt non-wearing warning light 278 device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
The warning light in all grades is published in figure. The warning light set to an actual car is
different depending on the grade etc.
Index
263
. warning light table .
Warning light Warning light name Warning light Warning light name
Power steering warning light The fuel remainder amount warning light
Dischargeheddoramportorebering
warning Half door warning light
light
264
View of meter, display light, and warning light
Contents
Abnormality of the system is thought, and receive the check promptly in the
Toyota shop in the state of the following warning light's lighting. Warning
might not only occur in ABS but also the vehicle becomes unstable in the brake
How
of strengthening. - to attention
Abnormality of the system is thought, and receive the check in the Toyota shop
associate . drinking..
when the warning light becomes the following.
car
蘆When you do not light the engine switch of turning on.
蘆In the state of lighting while not turning off with the engine switch lights by
turning on or nor running.
It turns off afterwards even if it lights while running, and is normal if it doesn't light again.
Maintenance
Knowledge
Myriad
About the warning light Oneの
Light when you turn on the engine switch, and turn it off after a few seconds. と
き
Index
265
Abnormality of the system is thought, and receive the check promptly in the
Toyota shop in the state of the following warning light's lighting.
Knowledge
About the warning light
Light when you turn on the engine switch, and turn it off after a few seconds.
266
View of meter, display light, and warning light
Contents
Abnormality of the system is thought, and receive the check promptly in the
Toyota shop in the state of the following warning light's lighting. Warning
SRS air
bag/pretensioner warning light Basic
. earliness.. operation
Light when abnormality is found in the seat belt system
(Refer to P.358) with the SRS air bag system (Refer to P.344)
or the pretensioner.
Driving
Handling
at once in the Toyota shop when the warning light becomes the
following. When colliding, the seat belt with the SRS air
The
bag or the pretensioner normally doesn't operate, and be
Handling indoor
likely to be injured. - equipment
In the state of not lighting the engine switch of
turning on or nor lighting. -
When lighting while running.
. good.. Safety
of ・
To
theory Comfortable
Knowledge and
equipment
About the warning light
How
Light when you turn on the engine switch, and turn it off after a few seconds. to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
267
Abnormality of the system is thought, and receive the check promptly in the
Toyota shop in the state of the following warning light's lighting.
Knowledge
About the warning light
Light when you turn on the engine switch, and turn it off after a few seconds.
268
View of meter, display light, and warning light
Contents
Abnormality of the system is thought, and receive the check promptly in the
Toyota shop in the state of the following warning light's lighting. Warning
wheel control becomes heavy. Turn it off if the engine is started again and running begins
in this case.
. good.. Safety
of ・
To
Knowledge theory Comfortable
and
About the warning light equipment
Light when you turn on the engine switch, and turn it off after a few seconds. How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
269
Abnormality of the system is thought, and receive the check promptly in the
Toyota shop in the state of the following warning light's lighting.
Dischargeheddoramportorebering
warning light
Dischargeheddoramp installation car
Light when abnormality is found in auto leveling (upper and lower irradiation
direction self adjustment) system of Dischargeheddoramp. (Refer to
P.376. )
Knowledge
About the warning light
Light when you turn on the engine switch, and turn it off after a few seconds.
270
View of meter, display light, and warning light
Contents
Abnormality of the system is thought, and receive the check promptly in the
Toyota shop in the state of the following warning light's lighting. Warning
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
271
Abnormality of the system is thought, and receive the check promptly in the
Toyota shop in the state of the following warning light's lighting.
1.8L car
Light when abnormality is found in the engine electronically controlled system
and the automatic transmission electronically controlled system while the engine is
rotating.
Knowledge
About the warning light
Light when you turn on the engine switch, and turn it off when you start up an engine.
272
View of meter, display light, and warning light
Contents
Stop in the place of safety at once, and contact the Toyota shop in the state of
the following warning light's lighting. Warning
device
Stop in the place of safety at once and contact
the Toyota shop when the warning light becomes
The
the following.
Handling indoor
- In the state of lighting even if you release the parking brake while the engine is rotating. equipment
In this case, it might cause an unexpected accident as working of the brake worsens, and the
slip distance for brake becomes long and is dangerous. Step on the brake pedal hard
when effective is bad. - . good.. Safety
The warning light : the ABS& brake assistance warning light or in the state of lighting at the same of ・
To
time as ..the ABS warning light... theory Comfortable
and
In this case, abnormality might not only occur in ABS or the brake equipment
assistance (2.0L car <Z grade > and 4WD car) but also the vehicle becomes
unstable in the brake of strengthening. How
to attention
associate . drinking..
car
Abnormality of the system is thought, and receive the check in
the Toyota shop when the warning light becomes the following. -
When not lighting even if the engine switch puts the parking
brake by turning on. - Maintenance
When you do not light the engine switch of turning
on with the parking brake released.
It turns off afterwards even if it lights while running, and is normal
if it doesn't light again. Myriad
Oneの
と
き
Index
273
Stop in the place of safety at once, and contact the Toyota shop in the state of
the following warning light's lighting.
Knowledge
About the warning light
Light in red when you turn on the engine switch, and turn it off after a few seconds. -
It changes into a blue lighting after it lights in red between a few seconds when the temperature of the engine
cooling water is low. -
Even if machine is continued enough, abnormality of the temperature sensor is thought in the state
of the warning light's lighting in blue. Receive the check in the Toyota shop.
274
View of meter, display light, and warning light
Contents
Stop in the place of safety at once, and contact the Toyota shop in the state of
the following warning light's lighting. Warning
The
Knowledge Handling indoor
equipment
About the warning light
Light when you turn on the engine switch, and turn it off when you start up an engine.
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
275
Stop in the place of safety at once, and contact the Toyota shop in the state of
the following warning light's lighting.
Knowledge
About the warning light
Light when you turn on the engine switch, and turn it off when you start up an engine.
276
View of meter, display light, and warning light
Contents
device
Light when either of door (Include the backing door) is Handling indoor
equipment
not surely closed.
. good.. Safety
Do not run with the warning light lights. It opens of ・
suddenly while running because the door is not surely closed the door, might To
theory Comfortable
cause an unexpected accident, and is dangerous. and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
277
Deal promptly when the following warning light blinks.
Knowledge
About the warning light
- Detect the sensor when weight more than constancy certain is put on the passenger's
seat seat seat side (half). Therefore, might it detect when luggage etc.
are put, and the warning light blink. -
Weight might be distributed when the cushion (square cushion) etc. are paved on the
passenger's seat seat seat side, and the sensor not detect the crew.
278
View of meter, display light, and warning light
Contents
Warning
Basic
. earliness.. operation
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
. drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
279
How to use of the switch.
How to use of the light switch.
AUTO(automatic operation)
Switch
When the switch is spent in AUTO, the headlamp and the front position light, etc. are lit and turned off by the automatic
operation in proportion to surrounding brightness. -
Turn it off automatically when the engine is stopped, and the driver's seat door is opened. Light
again when you turn on the engine switch.
Knowledge
About the operation condition
When the engine switch is turned on, it is possible to use it.
About Conraitosensar
- Sensitivity can be adjusted and consult the Toyota shop when feeling that lighting and turning off the lamp
when it uses it by the automatic operation are early or are slow. -
The sensor might not operate normally
when the one is put on the sensor of
Conrait or the glass cleaner etc. are
sprayed.
Sensor
280 - As for the sign, the presence of the installation is different depending on the grade etc.
How to use of the switch.
Contents
Driving
Handling
Position of switch Lighting lamp device
Lighting漓 Front position light, taillight, number-plate light, and meter lighting *. each switch lighting
Lighting滷 漓+ headlamp of ..drinking.. lamp
The
- Analog meter installation car
Handling indoor
Conrait installation car equipment
How
to attention
When lamps are lit for a long time with the engine stopped, the battery
associate . drinking..
completely charged with causes the battery rising.
car
Knowledge
About the operation condition Maintenance
- When the engine switch is turned on, it is possible to use it. (When using it with AUTO. )-
It is possible to use it regardless of the position of the engine switch. ..(.. lighting漓・Lighting滷When you use. )
Myriad
About a convenient function Oneの
と
Forget light cancellation warning buzzer き
The light switch lights. 漓・Lighting滷The buzzer that warns lamps to forget to be erased rings when the key
is pulled out from the engine switch and the driver's seat door is opened.
Index
281
When you want to shine on forward far
Upward
Downward
lever
Upward(While it is pulling it. )
282
How to use of the switch.
Contents
Basic
. earliness.. operation
Switch
Driving
Light when you spend the switch in turning on, and turn it off when spending in turning off. - Handling
The reception desk fog lamp display light in the meter lights when the device
. good.. Safety
of ・
About the operation condition To
theory Comfortable
The light switch lights. 漓・Lighting滷, AUTO, and the front position light or the headlamp is a point. and
Light can be used. equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
- As for the sign, the presence of the installation is different depending on the grade etc. 283
How to use of the direction instruction lever.
The left
Lane change(left)
Lane change(right)
The right
Lever
- The direction instruction display light that blinks under on when operating it a direction instruction
light that is left or right, and exists in the meter also blinks the lever.
The lever returns automatically when the steering wheel is returned. Return it with the hand
when it doesn't return. -
Each direction instruction light while it is suppressing it and the direction instruction display
light blink to the under, and it turns it off when the hand is separated at the lane change.
Knowledge
About the operation condition
When the engine switch is turned on, it is possible to use it.
284
How to use of the switch.
Warning
Basic
. earliness.. operation
Dial
Driving
Handling
An optical axis of the headlamp (direction that light shines on) can be downward adjusted by
device
spending the dial. -
Use it at the position of 0(0)(An optical axis is the most upward) usually.
The
Knowledge
Handling indoor
About the top and bottom of optical axis adjustment equipment
- Spend the dial when the front side of the vehicle face upes by putting luggage and the person, and the
range that the headlamp shines on is different from always (It is more upward than usual) and make an optical
axis of the headlamp downward. Return the dial to the position of 0(0) after selling luggage . good.. Safety
of ・
and the person wholesale. - To
Adjust the following table according to the loading situation of the crew and the luggage room and adjust the dial position to theory Comfortable
and
the standard. equipment
< standard at dial position >
How
Loading situation of crew and luggage room Dial position to attention
associate . drinking..
When only driver's seat gets on 00
car
When it gets on driver's seat and passenger's seat 1
At three person getting on of driver's seat, passenger's seat, and third seat 2
When only driver's seat gets on and luggage room is fully loaded 4
Myriad
- Go after adjusting the dial to the position of 0(0)(most upward position) when you adjust an optical Oneの
axis by the car inspection etc.When と
き
About the operation condition
the headlamp lights, it is possible to use it.
Index
285
How to use of wiper & washer switch.
Temporary operatio(n M I S T )
Intermittent time"Length"
Stop
(OFF) Switch
Lever
Intermittent time"Short"
Intermittent operation
(INT)
Operate as shown in the above figure when you operate the lever. -
Intermittent time can be adjusted by spending the switch when intermittent operates
(INT) for about 3-12 seconds. -
As for operation (MIST), the wiper temporarily low-speed operates the lever from stop
(OFF) while it is pushing it up. It returns to stop (OFF) when the hand is separated.
- Riya
Low-speed operation(ON)
Intermittent operation
Switch
(INT) stop(OFF)
Operate as shown in the above figure when you spend the switch.
286
How to use of the switch.
Contents
Knowledge Driving
Handling
About the operation condition device
When the engine switch is turned on, it is possible to use it.
The
About the protection function Handling indoor
equipment
The breaker is built into the wiper motor as a protection function. The breaker might
operate when the situation with a large load of the motor continues, and the motor stop
temporarily. It comes to be able to use it by the breaker's returning when doing for about ten minutes
usually. . good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
287
How to jet washer liquid
- Reception desk
Lever
The washer liquid is jetted while the lever is being pulled forward. -
The wiper operates several times after jetting the washer liquid.
- Riya
Low-speed operation(ON)
Switch
Stop(OFF)
- When it is made to jet, the washer liquid is spent from low-speed operation (O N) of the switch
in the side while low-speed operating ..on...
- When the switch is spent from stop (OFF) in the side below, the washer liquid is F.
It shines.
288
How to use of the switch.
Contents
Driving
Handling
device
Knowledge
About the operation condition
The
When the engine switch is turned on, it is possible to use it.
Handling indoor
equipment
About the oil slick that attaches to the glass
The light etc. of the oncoming car reflect freely at wet night when there is an oil slick. Clean the surface of the
glass with the glass cleaner. . good.. Safety
of ・
To
theory Comfortable
About the replenishment of the washer liquid and
equipment
Refer to P.441 for the replenishment of the washer liquid.
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
289
How to use of Riyauindudefoggar
(cloudy remove) switch.
Switch
Operate for about 15 minutes when you push the switch, and stop when pushing again while operating. -
The operation display light lights while operating.
It causes the battery rising when continuously using it for a long time.
Knowledge
About Riyauindudefoggar
Warm the backing door glass in heat ray and take cloudy weather. -
The mirror heater installation car operates the mirror heater (Refer to P.216)
simultaneously with Riyauindudefoggar.
290
How to use of the switch.
Basic
. earliness.. operation
Driving
Handling
device
Switch
The
Operate for about 15 minutes when you push the switch, and stop when pushing again while operating. - Handling indoor
equipment
The operation display light lights while operating.
. good.. Safety
of ・
To
It causes the battery rising when continuously using it for a long time. theory Comfortable
and
equipment
How
Knowledge to attention
associate . drinking..
About the reception desk window shield glass with heat ray
car
Heat the surface under the reception desk window glass and prevent the glass and the wiper blade being
frozen.
Myriad
Oneの
と
き
Index
- As for the sign, the presence of the installation is different depending on the grade etc. 291
How to use of the emergency blinking light switch.
Switch
Turn it off when all the direction instruction lights blink, and push again while blinking when the
switch is pushed. -
The direction instruction display light in the meter blinks while blinking, too.
Do not use it for a long time when the engine has stopped to prevent
the battery from going up.
Knowledge
About the emergency blinking light
Use it to inform another car when the road is unavoidably parked due to the breakdown etc.
292
How to use of the switch.
4WD car
Warning
Basic
. earliness.. operation
Driving
Handling
Switch device
pushed.
. good.. Safety
of ・
To
Mode State of switch Display light theory Comfortable
and
equipment
4WD auto
Lighting turning off after it
mode How
to attention
FF mode blinks twice associate . drinking..
car
Knowledge
Maintenance
About the mode
4WD auto mode
When cornering, climbing up the slope, and starting, driving power (torque) distribution to the rear wheel is automatically controlled from
running according to various states of running such as roads slippery because of acceleration, the snow, and rain, etc. usually. Myriad
Oneの
FF mode と
き
FF is running. Improve the fuel cost performance by changing to the FF mode.
Index
293
How to use of the TRC OFF switch.
Switch
The operation of TRC stops when the switch is pushed, and it returns to the state that can be operated when
pushing again while stopping. -
The TRC OFF display light in the meter lights while stopping.
Knowledge
About TRC
TRC is a device that tries to control the idling of the drive wheel caused when starting and accelerating in a slippery road,
and to secure direction stability and driving power of the vehicle. (Read "TRC" of P.365 about
operation. )
However, the output of the engine might not go up even if the gas pedal is depressed if TRC
operates when escaping from mud and a new snow, etc. , and the escape be difficult.
The operation of TRC can be stopped by the TRC OFF switch at such
time.
294
How to use of the switch.
Warning
Basic
. earliness.. operation
Driving
Handling
device
Mark
The
Steering wheel The horn (horn) rings when the part around the mark is pushed. Handling indoor
equipment
Knowledge
. good.. Safety
About the operation condition of ・
To
It is possible to use it regardless of the position of the engine switch. theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
295
4
Contents
Warning
Index
297
Handling of air conditioner
How to use of an auto air conditioner.
Display part
Airconditioning switch
Push the AUTO switch. - Adjust it with the temperature adjustment dial.
The operation display light of the switch Spend left when you lower the right
lights while operating. side when you raise it. (0.5. can
be adjusted. )-
The preset temperature can be
adjusted between 18. -32. . -
The preset temperature is displayed in the
display part.
蘆LO in case of maximum air-conditioning.
蘆It becomes a display of
HI if it maximum heats it.
298
Handling of air conditioner
Contents
The air conditioner (air-conditioning and Push the turning off switch. -
dehumidification function) changes into turning on and The fan can be Handling
Driving
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
299
Do not operate it to prevent the battery rising while the
engine is stopping.
- Do not operate it to prevent the battery rising while the engine is stopping. -
Abnormality of the system is thought, and make it to turning on again after pulling up a car to the place
of safety, and turning off the airconditioning switch once when the operation display light of the
airconditioning switch blinks. Turn off the switch and receive the check in the Toyota shop when blinking
continues further.
Knowledge
When the temperature in the car is high
Operate the air conditioner after opening the window and letting heat go when the temperature in the car is high
after parking.
When you operate the MODE switch or the fan motor switch
When you have turned on the AUTO switch
- When the MODE switch (Refer to P.302) is operated, it becomes a set balloon entrance, and the operation
display light of the AUT O switch is turned off.
(The amount of the wind continues the self adjustment. )-
When the fan motor switch (Refer to P.302) is operated, it becomes the set amount of the wind, and the operation
display light of the AUTO switch is turned off.
(The balloon entrance continues the self adjustment. )
300
Handling of air conditioner
Contents
Warning
Basic
. earliness.. operation
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
301
Display part
The frog of the amount of the wind. The frog of the balloon entrance.
Switch the amount of the wind to seven stages with Switch the balloon entrance with
the fan motor switch. the MODE switch. (Refer to next page. )-
The amount of the wind is strong and . The balloon entrance changes
side and .... ..weakening.. push . side. - whenever the switch is pushed. -
The amount of the wind that has been selected is The balloon entrance that has been selected
displayed. - in the display part is displayed.
The fan operates when the
switch is pushed when the fan
has stopped.
302
Handling of air conditioner
Contents
Driving
Handling
device
Display of display part
When you ventilate it to
The
one's upper-body and one's feet Handling indoor
equipment
. good.. Safety
of ・
To
Display of display part theory Comfortable
and
When you ventilate it equipment
associate . drinking..
car
と
き
The peel FF and only the cold-weather model car of the car (Exclude E package) and 4WD car are ventilated.
Index
303
Switch an air introduction
Take the cloudy weather of the glass.
and a shy circulation.
It changes into an air introduction and a shy Push the reception desk defroster switch,
circulation whenever the inside and outside nature and make the inside and outside nature switch
switch switch is pushed. switch an air introduction. -
The fan operates automatically
Operation display light Mode
when the switch is pushed while the
fan is stopping. -
Air introduction
Lighting If the switch is pushed when the inside
Air has been
introduced. Use it
and outside nature switch switch circulates
at this position shyly, the air conditioner is automatically
usually. turned on. -
The operation display light of the switch
lights while operating.
Shy circulation
Air is
intercepted. Use it when air < balloon entrance >
Lighting
like the tunnel and congestion,
etc. wants to be dirty and and to
bring the effect of air-conditioning
when air conditioning and the
outside temperature degree are
high forward early by you.
304
Handling of air conditioner
Contents
Do not push the reception desk defroster switch when you operate the
air conditioner when humidity is very high. The surface of the outside of the window Warning
might disturb cloudy view by the temperatures fluctuate of air and the window.
Basic
Do not operate it to prevent the battery rising while the engine is stopping. . earliness.. operation
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
305
Knowledge
About the inside and outside nature switch
- It is effective when shyly circulating around the inside and outside nature switch switch when it doesn't want to put dirty air in the car
due to in the tunnel and congestion, etc. and when it wants to bring the effect of air-conditioning when air conditioning and the outside
temperature degree are high forward early. -
It is cloudy and ..glass.. becomes it when shyly circulating for a long time ..becoming empty...
306
Handling of air conditioner
Basic
. earliness.. operation
Driving
Handling
device
The
How to open and shut how to change it and balloon entrance of wind Handling indoor
equipment
Central balloon entrance Right and left balloon entrance Impane upper spouting mouth
associate . drinking..
Knob Close car
Opening
Maintenance
- The wind can be adjusted by moving the knob at the center and the right and left balloon entrance. -
The right and left balloon entrance and the Impane upper spouting mouth can open and shut
the balloon entrance by spending the dial.
Myriad
Oneの
と
き
Index
307
Knowledge
About the balloon entrance
- At air-conditioning, this is the one that occurs when the air saturated with moisture is suddenly cooled and
is not unusually abnormal though might seem to have spouted from the balloon entrance the fog. -
Adjust the dial of the Impane upper spouting mouth to the close side when you want to increase the amount of the wind in the front
seat at air-conditioning.
308
Handling of air conditioner
Contents
Warning
Basic
. earliness.. operation
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
. drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
309
Handling of ETC -
The ETC(Electronic Toll Collection) system is a system that adjusts the charge
by the automatic operation to pass the tollway smoothly.
Communicate the wireless between ETC units of a road side wireless device and the vehicle, and pull
down the charge from the bank account that the customer registered later.
潸
澆/潺
滷
漓
310 - As for the sign, the presence of the installation is different depending on the grade etc.
Handling of ETC
Note the following points when you use the ETC system.
Driving
Handling
After inserting the ETC card
device
Confirm the insertion of the ETC card surely, and the
normal operation.
The
- Confirm the insertion of the ETC card in the ETC unit surely beforehand,
Handling indoor
and the ETC unit operate normally when you use ETC. - equipment
The insertion of the ETC card in this side of the toll gate might cause the error by the time the
ETC unit attests the ETC card because it borrows for a few seconds.
. good.. Safety
of ・
To
When passing over the toll gate theory Comfortable
and
equipment
Going into of the ETC lane must go into it at a safe enough speed at the
How
distance between two cars and about 20 km/h or less. to attention
- Going into of the ETC lane must go into it at a safe enough speed at the distance between two cars and about 20 associate . drinking..
km/h or less. - car
It is likely not to open in the opening and shutting bar set up in the ETC lane when the
communication between the communication or the ETC unit and the ETC card between the ETC unit
and the antenna is not normally done. -
Pass after confirming it decelerates enough to stop safely in this side of the opening and shutting bar after the Maintenance
distance between two cars with the preceding vehicle is maintained, and the opening and shutting bar opened when you pass in
the ETC lane.
Myriad
Oneの
と
き
Index
311
How to use of ETC.
In this book, it explains only the operation of the ETC unit of the manufacturer
option. The state, the ETC registered information, and the use history of a present ETC
system can be displayed in the installation of this ETC unit together with the HDD navigation
system on the screen of the HDD navigation system, and the setting change etc. of ETC
be done. See "HDD navigation system manual" of the separate volume in
detail.
About the ETC unit
The ETC unit is in the passenger's
seat upper box.
ETC unit
- Do not put the foreign body etc. in the ETC unit. The ETC unit might
break down. -
Do not strike close to home to the ETC unit. The ETC unit might break down, and
be damaged. -
Do not touch the ETC unit by a wet hand, and put water (liquid etc.). Water
enters in the ET C unit, and it is likely to break down and to damage it. -
Wipe dirt off with a soft, dry cloth when becoming dirty. Never use wax or
neither thinner nor alcohol, etc.The ETC unit might be transformed and
break down. -
The opening and shutting bar at the gate might not open when two or more ETC units are installed
in one vehicle.
312
Handling of ETC
Contents
Knowledge
Warning
About the operation condition
When the engine switch is ACC or is turned on, it is possible to use it.
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
313
Name of each part
- About the ETC unit
Use history confirmation switch
Speaker
Green lamp
Bitter orange lamp
ETC card
Knowledge
About the ETC card
- It is necessary to apply to the ETC card by the customer oneself. Consult the Toyota
shop in detail. -
Note the theft and the loss of the ETC card. Contact the ETC card issuer at once
when the theft and it is lost by any chance.
314
Handling of ETC
Contents
When using it
- Operation when getting on Warning
2
Green lamp
Bitter orange lamp Insert the ETC card in the ETC unit firmly Driving
Handling
in a correct direction of insertion as shown
device
in a left chart.
"Pitsu" Something is heard, and a green lamp
blinks. The
Handling indoor
equipment
Index
315
- Operation when getting off
ETC card
2 Pull out the ETC card from the
ETC unit.
Do not pull out the ETC card while a green lamp is blinking.
- Do not pull out the ETC card while a green lamp is blinking. Data in the ETC card
might be damaged. -
Do not use it excluding the ETC card regularly issued. -
Insert the ETC card firmly in a correct direction of insertion. -
The bitter orange lamp blinks when the error occurs on the ETC unit and the ETC card.
Correspond according to the situation as follows.
蘆Follow the treatment that has been described to "Union error code list" (Refer to
P.323) when the voice is output to union error code (01-07).
蘆Stop the engine once, and start again when the error occurs when the
engine starts. Still, receive the check in the Toyota shop when the error continues.
蘆Pull out the ETC card once, confirm the direction of insertion, and insert it again when
the error occurs when the ETC card is inserted. Still, receive the check in the Toyota
shop when the error continues. -
Do not part from the car leaving the ETC card.
The ETC card might be transformed by the rise in heat in the car, and data in the
ETC card be damaged.
316
Handling of ETC
Contents
- When you can normally do the adjustment processing at the ETC gate
The
When abnormality is found in the operation of ETC Handling indoor
- When you insert a card different from the equipment
Bitter orange lamp: Blinking
ETC card
- When the inserted ETC card is correct and it is not
recognized . good.. Safety
- When abnormality is found in the ETC system of ・
To
- When it was not possible to communicate normally at the ETC gate theory Comfortable
- When you cannot do the adjustment processing at the ETC gate and
equipment
- When abnormality is found in the antenna of ETC
How
Bitter orange lamp: Lighting to attention
ETC :. car
Maintenance
Myriad
Oneの
と
き
Index
317
Knowledge
About the handling of the ETC card
- Do not part from the car leaving the ETC card. The ETC card might encounter
the theft. -
Close the passenger's seat upper box to prevent the theft when you have
inserted the ETC card. -
Contact the ETC card issuer promptly when you lose the ETC
card.
318
Handling of ETC
Contents
- The ETC gate (entrance) and examination of tickets place and previous notice antenna/ETC card Basic
uninsertion information antenna are passed. . earliness.. operation
Traveling direction
. Handling indoor
In this case, tell the toll gate clerk equipment
How
to attention
Do not pull out the ETC card in the ETC gate and the vicinity of the examination of
associate . drinking..
tickets place and the previous notice antenna.
car
Do not pull out the ETC card in the ETC gate and the vicinity of the examination of tickets place and the previous notice antenna. Data
in the ET C card might be damaged.
Knowledge Maintenance
319
- The ETC gate (for exit/adjustment) is passed.
Knowledge
About the voice guide of the traffic charge
The traffic charge guided by the voice might be actually different according to the discount etc.
320
Handling of ETC
Contents
Knowledge
Warning
When you pass the ETC gate
- Pass over the ETC gate (for exit/adjustment) or the examination of tickets place with the ETC
card used at the ETC gate (entrance). -
It is set up forward, and the previous notice antenna communicates with the ETC unit, and is an antenna Basic
of the toll gate to notify those who drive beforehand whether the ETC gate can be used through the . earliness.. operation
ETC unit. The previous notice antenna might not be being set up by the system on the road side in
the case to be set up. -
When it is set up forward, and it communicates with the ETC unit, and the ETC card of the toll gate
has not been inserted correctly, the ETC card uninsertion information antenna is an antenna to notify
Driving
those who drive beforehand through the ETC unit. The ETC card uninsertion information antenna might Handling
not be being set up by the system on the road side in the case to be set up. device
Do not confirm the use history in the ETC gate and the vicinity of the examination Maintenance
of tickets place and the previous notice antenna.
Do not confirm the use history in the vicinity of the ETC gate. It is not likely to be able to
communicate with a road side wireless device. Myriad
Oneの
と
き
Index
321
Knowledge
About the use history
- Because the use history is recorded on the ETC card, the maximum record number is different according to
the ETC card used. -
When the maximum record number of use histories is exceeded, the oldest use history is deleted. -
When there is no use history"There is no use history. " It is guided.
- When information on the use day is not correct"The use date is uncertain. "It is guided.
- When information on the traffic charge is not correct"The charge is uncertain. "It is guided.
The volume
Volume adjustment switch
- When enlarging it, the side of the switch.
- When reducing it, the side of the switch.
Push. -
Knowledge
About the volume adjustment
When you set the voice guide to discontinuance (volume 0)
- "Discontinue the voice guide. "The voice is output. -
When the error occurs, the voice is output by volume 1. -
The notification that the ETC unit unsets up is
not output.
322
Handling of ETC
Myriad
Oneの
と
き
Index
323
Code Abnormal state Assumed factor Treatment
Knowledge
About the union error code
- When communicating with the ETC card uninsertion information antenna etc."Error 07" With notification
No breakdown of the ETC unit though there is a fault. -
A wireless of ETC unit communication is used, and the parking lot management system is operated. When you
do a communication different from the charge payment of the tollway
"Error 01" Or, "Error 07" With the notification
No breakdown of the ETC unit though it is likely to be done.
324
Handling of ETC
Contents
Use history confirmation switch 1 Pull out the ETC card. Basic
. earliness.. operation
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
325
How to use of the indoor equipment goods.
Sun visor Interior light
Switch
Knowledge
Mirror
About the operation condition
- The slide is done, and open and use the cover for
It is possible to use it regardless of the position of
the direction of the arrow.
the engine switch.
326
How to use of the indoor equipment goods.
Exclude the Moon roof installation car. Moon roof installation car
Basic
. earliness.. operation
Switch
device
- Spotlight switch - Turn on the switch to
The light on the pushed side lights when always light. -
The
the switch is pushed, and it turns it off when Put it into the state that the switch
Handling indoor
pushing again. is not pushed to always turn it off. - equipment
Light and turn it off
- Main switch by Ilminateddoentoreshistem
- Turn off the switch to when you make the switch . good.. Safety
of ・
always turn it off. DOOR. To
theory Comfortable
- Light and turn it off Read "Ilminateddoentoreshistem" and
equipment
by Ilminateddoentoreshistem ( R e f e r t o
when you make the switch P.122) in detail. How
DOOR. to attention
( R e f e r t o car
P.122) in detail.
Maintenance
Do not light it for a long time to prevent the battery rising while the engine
is stopping.
Myriad
Knowledge Oneの
と
About the operation condition き
327
Down of ceiling LED light Luggage room lamp *
OFF
Light
Knowledge
About the operation condition
It is possible to use it regardless of the position of
the engine switch.
328 - As for the sign, the presence of the installation is different depending on the grade etc.
How to use of the indoor equipment goods.
H button
Warning
Basic
. earliness.. operation
:00 buttons Outside temperature degree display
M button
The outside temperature degree is displayed.
When you adjust Driving
"Time" and "Worth" Knowledge Handling
Index
329
Accessories socket
Fta
Knowledge
About the accessories socket
- When the engine switch is ACC or is turned on, it is possible to use it. -
Use an electric product of 10A or less in maximum current (maximum power consumption 120W) for
the electric product used with DC12V. -
The vehicle fuse might cut if an electric product that exceeds regulated capacity is used.
330
How to use of the indoor equipment goods.
Knowledge
Fta
Warning
About the storage place of the ashtray
It is possible to store it in the following place.
Driving
Handling
Cause and open Fta when you device
use it. - In central console tray(Refer
to P.332. )
FF car - The
Handling indoor
Guard the following to prevent breaking - equipment
out. -
Put in the ashtray after it completely erases
it, and close the fires such as matches and . good.. Safety
cigarettes surely. - of ・
To
Do not put the combustible one such as theory Comfortable
and
wastepapers in the ashtray. 4WD car equipment
- How
to attention
associate . drinking..
car
と
き
Index
- As for the sign, the presence of the installation is different depending on the grade etc. 331
Central console tray
332 - As for the sign, the presence of the installation is different depending on the grade etc.
How to use of the indoor equipment goods.
Warning
Do not add power that gives a lot of care to the
cup holder, the movable ashtray storage space, and
the partition, etc. , and is impossible. It is
likely to damage it. Basic
. earliness.. operation
Knowledge
About the cup holder Lever
Driving
- Store it after closing Fta of the Handling
container. - Pull a lever and open it. -
device
Do not store the glass etc. the paper When closing, it closes surely until
cup and made of the glass that includes "Catitsu" and the sound are heard.
the juices etc. when you run. The The
juice etc. might spill, and
Handling indoor
glassware crack. - equipment
The container might fall when rapidly accelerating
with stability even if it is not possible to store Do not run with Fta of the
by the size and the shape of the container and it glove box opened. It dashes out when
is possible to store it. - . good.. Safety
slamming on the brakes luggage, might cause of ・
Do not store 250ml can when you an unexpected accident, and is dangerous. To
theory Comfortable
use Gawa-cup holder of 4WD car at and
the position where B is partitioned. equipment
The can might fall.
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
333
Small putting
Cup holder
334
How to use of the indoor equipment goods.
Basic
. earliness.. operation
Fta
Cup holder
Knowledge
- Do not run with Fta of a small
putting opened. It dashes out when About the bottle holder . good.. Safety
slamming on the brakes luggage, might cause an of ・
- Store it after closing Fta of To
unexpected accident, and is dangerous. - the PET bottle. - theory Comfortable
and
Never use the multibox Do not store the glass etc. the paper cup equipment
as an ashtray. It might connect with and made of the glass that includes the
a vehicle fire with the burning cigarette end and juices etc. when it runs, and you open and How
is dangerous. shut a door. The juice etc. might to attention
spill, and glassware associate . drinking..
crack. - car
Knowledge It is not likely to be able to store it according
to the size and the shape of the PET bottle.
About the cup holder
- Store it after closing Fta of the Maintenance
container. -
Do not store the glass etc. the paper
cup and made of the glass that includes
the juices etc. when you run. The Myriad
juice etc. might spill, and Oneの
glassware crack. - と
It is not likely to be able to store it according to the き
Index
335
Passenger's seat seat
Under tray * Shopping hook *
Tray Hook
336 - As for the sign, the presence of the installation is different depending on the grade etc.
How to use of the indoor equipment goods.
Warning
Basic
. earliness.. operation
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
Hook To
theory Comfortable
Luggage can be fixed using the rope together with the net. - and
equipment
The net and the rope must use the one on the market.
How
to attention
Store it when you do not use the hook. An unexpected injury associate . drinking..
might be done by placing the finger. car
Maintenance
Myriad
Oneの
と
き
Index
- As for the sign, the presence of the installation is different depending on the grade etc. 337
Accessories outlet *
Main switch
- The operation display light lights, and it enters the state that the accessories
outlet can be used. -
The power supply changes into turning on and turning off whenever the switch is pushed. -
When you do not use the accessories outlet, confirm the main switch
is made O FF, and the operation display light has been turned off.
Fta
338 - As for the sign, the presence of the installation is different depending on the grade etc.
How to use of the indoor equipment goods.
Contents
device
Knowledge
About the operation condition
The
When the engine switch is turned on, it is possible to use it.
Handling indoor
equipment
About the accessories outlet
- An electric product can be used in the car. -
Use an electric product of the maximum power consumption 100W or less with AC100V. . good.. Safety
of ・
蘆The protection circuit works when an electric product for the maximum electric power consumption to exceed 100W is used, and it is To
theory Comfortable
not possible to use it. If the outlet is removed and power consumption becomes 100W or less in this case, and
it is possible to use it. - equipment
The following equipment might not operate normally if power consumption is as much as 100W or less.
How
蘆Equipment with large power consumption when starting (cathode-ray tube type television, compressor type refrigerator, to attention
electric pump, and power tool, etc.).
associate . drinking..
蘆Equipment (clock and audio, etc.) with switch (50/60Hz) of power supply frequency.
car
蘆Equipment (medical equipment and meter, etc.) that measures precise data.
蘆Others(lamp etc. with microcomputer control type electric blanket and touch sensor)-
The noise might enter the radio and the television according to the electric product used. -
The voltage of the accessories outlet cannot measure an accurate voltage with a tester on the market.
Maintenance
Receive the check in the Toyota shop when the confirmation of the voltage is necessary.
Myriad
Oneの
と
き
Index
339
Luggage box
Belt
The deck board installation car detaches and uses each board. -
Lift and detach the board with the belt when you detach the central
deck board. -
Detach the right and left deck board after the central deck board is detached
or it raises it.
340 - As for the sign, the presence of the installation is different depending on the grade etc.
How to use of the indoor equipment goods.
Antenna Contents
Forward
Basic
. earliness.. operation
Driving
Handling
Detach it.
Install it.
Spend the antenna and detach it from the device
installation part when detaching it.
The antenna must screw in in the installation
The
part, and fix firmly when you install it.
Handling indoor
equipment
Installation part
- The person in whom the radio was installed
. good.. Safety
Set up to the place with the moderation feeling and use it of ・
To
when you receive the radio. theory Comfortable
and
equipment
associate . drinking..
- Detach the antenna might damage the antenna when putting it on the automatic
carwash machine. - car
Store the antenna might damage the antenna at the following time.
蘆When the antenna hits the garage etc.
蘆When you put the car cover.
Maintenance
Myriad
Oneの
と
き
Index
341
5
Contents
Myriad
Oneの
と
き
Index
343
-
SRS Air bag
What is the SRS air bag?
Wearing a good posture and a correct seat belt is absolutely conditions for the SRS air
bag to demonstrate the effect of the SRS air bag by the one to assist the seat belt to the
last with the auxiliary equipment of the crew protection.
Moreover, the effect might not only be demonstrated when an effective SRS air bag also
does wrong handling if it correctly handles it but also the danger of injury or the
death is rather given to the crew.
344
SRS air bag
Contents
The SRS side air bag and the SRS curtain shield air bag on the side where the impact was
received swell when the SRS side air bag and the SRS curtain shield air bag receive the
high impact for the grievous harm to reach the crew in a reception desk seat and Secandoshet Basic
. earliness.. operation
right and left seat from the side to the vehicle guest room. The SRS side air bag along
with working to which the seat belt restrains the body works to make the impact power that the
reception desk seat and the Secandoshet right and left seat crew chiefly act on the head
as for the SRS curtain shield air bag distribute and eased in the upper part of the body such
Driving
as reception desk seat crew's chests. Handling
The SRS side air bag and the SRS curtain shield air bag swell even device
if there is no crew.
The
SRS curtain shield air bag
Handling indoor
equipment
SRS side air bag
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
- As for the sign, the presence of the installation is different depending on the grade etc. 345
Mechanism of operation of SRS air bag
The sensor cannot normally perceive the impact when the grill guard etc. are installed
forward of the vehicle, and normal operation of the SRS air bag might be ruined.
346 - As for the sign, the presence of the installation is different depending on the grade etc.
SRS air bag
It operates when there is a high impact to which the crew who has correctly worn the
seat belt might receive important injury, and it is not easy to operate by the impact
Warning
with a little fear to receive important injury.
device
The
Handling indoor
equipment
When it is not easy to operate
- Dual SRS air bag
When the impact that the following bodies receive is weak, it is likely not to operate. . good.. Safety
of ・
To
- It is likely ..hard wall like concrete that transforms and theory Comfortable
and
doesn't move.. not to operate at the time of about 30 km/h equipment
associate . drinking..
car
Myriad
Oneの
と
き
Index
347
Because the impact by the collision is loosened in the following cases, it is likely not
to operate.
- When the under of the carrier of the track etc. slip
and it collides.
- When you receive the impact from the person before the diagonal.
The operating velocity of the car rises because the impact by the collision is loosened
when colliding what is transformed or moves.
348
SRS air bag
Contents
- SRS side air bag and SRS curtain shield air bag
When the impact that the following bodies receive is weak, it is likely not to operate.
Warning
Basic
. earliness.. operation
Driving
Handling
- When you receive the impact to sides other than the guest room.
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
349
When you do not demonstrate an original effect
Do not demonstrate an original effect though it is likely to operate in the following cases.
- When you receive the impact from the side and the rear side.
- When it falls in the deep hole and the ditch or it gets it over.
350
SRS air bag
Contents
How
to attention
associate . drinking..
car
蘆Neither SRS side air bag installation car nor the SRS curtain shield air bag installation car
starts must not leaning against the door, and must approach the reception desk center rear pillar,
the roof side part, and the ceiling. When the SRS side air bag and the SRS curtain shield air
bag swell, the high impact might receive the important injury related to the receiving Maintenance
life and is dangerous in the head etc.Especially, be careful when the child is taken.
Myriad
Oneの
と
き
Index
351
Guard the following items to demonstrate the effect
of the SRS air bag enough.
蘆Do not run with the one put as the one is held on the knee between the crew
and the SRS air bag. It flies the one when the SRS air bag swelled and it strikes the face,
and normal operation of the SRS air bag is disturbed and it is dangerous. -
Guard the following when you take the child. In the worst case, it reaches
important injury if it doesn't defend by a strong impact when the SRS air bag swells or, it is likely
to lead to the death.
蘆The child must make it sit on the rear seat, and let me wear the seat belt.
蘆Install the seat only for the child in the rear seat and use it for a small child who cannot
correctly wear the seat belt.
蘆Never install the seat only for the child in the passenger's seat for. The high impact
joins the back of the seat only for the child when passenger's seat SR S air bag swells and it is dangerous.
..adjustment position.. install most before and behind the seat when it unavoidably keeps positive
and the seat only for the child is installed in the passenger's seat.
蘆Do not run in the state that makes the child stand in front of passenger's seat SRS air
bag, and holds on the knee.
352
SRS air bag
Contents
Driving
Handling
device
The
Handling indoor
equipment
蘆Consult the Toyota shop about the SRS side air bag installation car when detaching, the installation, the
resolution, and the repair, etc. of repapering and the reception desk seat of the epidermal of the reception desk
seat are necessary. Moreover, do not remodel the reception desk seat.
. good.. Safety
蘆The SRS curtain shield air bag installation car must not resolve and not repair the detaching surrounding of ・
To
of the reception desk center rear pillar, the roof side part, and the ceiling of the SRS of the installation theory Comfortable
etc. curtain shield air bag development department. and
equipment
How
to attention
associate . drinking..
car
Maintenance
蘆Do not remodel the suspension. Height changes or the hardness of the suspension
changes, and it causes the mis-operation of the SRS air bag.
蘆Do not repair the front of the vehicle or the vehicle guest room. The impact transmitted to the
SR S air bag sensor changes if an improper repair is done, and the SRS air bag doesn't operate Myriad
Oneの
normally.
と
き
Index
353
Guard the following items to demonstrate the effect
of the SRS air bag enough.
- Guard the following when you install the car articles etc.The SRS air bag might
not operate normally, and it reaches important injury by swelling by mistake or, in the worst
case, it lead to the death if it doesn't defend.
蘆Do not cover the development department of the SRS air bag with the cover and the sticker, etc.
Sticker
蘆Do not put the one of the aromatic substance etc. on the Instrument panel, and do not lean the
umbrella etc.It flies when passenger's seat SRS air bag normally is not operated or swells
and is dangerous.
蘆The SRS side air bag installation car must not install the one other than a Toyota pure articles
(seat cover etc.) only for this car in the reception desk seat. If the SRS side air bag development
department is covered with the one other than a Toyota pure articles only for this car, it becomes an obstruction of
normal operation of the SRS side air bag. Often read the manual of the attachment, and install it in
the commodity correctly when you install the Toyota pure seat cover etc.
354
SRS air bag
Contents
Driving
Handling
device
蘆The SRS curtain shield air bag installation car must not install accessories hands-free
mike suspenders etc. around the SRS curtain shield air bag development department such
as the reception desk window glass, the side door glass, the reception desk center rear The
pillar, the roof side part, assist grip, and ceilings. It flies when the SRS curtain
Handling indoor
shield air bag swells and is dangerous. equipment
SRS curtain shield air bag
development department
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
蘆The electric wave etc. of the wireless machine might negatively affect the computer associate . drinking..
that operates the SRS air bag, and consult the Toyota shop when you install the wireless car
machine etc.
蘆Consult the Toyota shop when you install the grill guard and the winch, etc. in the front of the
vehicle. The impact transmitted to the SRS air bag sensor changes if the front of the vehicle is remodeled,
and it causes the mis-operation of the S RS air bag. - Maintenance
The SRS air bag development department such as the upper part of the steering wheel pad Instrument
panel must not be overpowered as the strong beating etc.The SRS air bag doesn't operate normally, and
it reaches important injury or, in the worst case, it is likely to lead to the death. -
It is not necessary to touch the SRS air bag composition parts immediately after the SRS air bag's having swollen. Myriad
Oneの
Important injury such as the burns might be received because complete parts are very hot and it is
dangerous. と
き
Index
355
There is even when the SRS air bag operates normally in the
following cases.
- Because the SRS air bag swells at a very fast speed, the bruise file wound etc. might
be received by contact with the SRS air bag.
- No fire though the gas like white smoke is generated with the operation sound if the
SRS air bag operates. If this gas is breathed in, the person who has details for the respiratory system such as asthma
to suffer becomes painful breath occasionally.
In this case, confirm it is safe even if the crew goes out outside the car, and go out outside the car. Open the
window and the door and put fresh air when it is not possible to go out outside the car.
Moreover, flush it in water as soon as possible when traces (Cas etc.) when the SRS air bag
operates adhere to eyes and the skins. The person to whom the skin is weak occasionally stimulates his
skin unusually. -
The reception desk window glass of the vehicle might be damaged by passenger's
seat SRS air bag's swelling when colliding. -
The SRS air bag that operates once doesn't operate again in the collision since the second times. Exchange
it in the Toyota shop. The SRS air bag doesn't operate in the second collision if the SRS
air bag operates by the first collision when colliding similarly continuously. -
Consult the Toyota shop when you abandon the car and the SRS air bag. The SRS
air bag operates unexpectedly, and it is likely to injure.
356
SRS air bag
Contents
There is even when the SRS air bag operates normally in the
following cases. Warning
- Do not use as it is and exchange it in the Toyota shop when the pad, the reception desk
rear pillar, and the roof side part where the SRS air bag is stored have been damaged or
there is a crack. When colliding, the SRS air bag normally doesn't operate, and be likely
to be injured. Basic
. earliness.. operation
Reception desk pillar
Pad Roof side part
Driving
Handling
device
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
357
Seat belt relation
Working of seat belt
Pretensioner
&Seat belt with force limiter
Reception desk seat belt
- The pretensioner mechanism winds up up the seat belt instantaneously when the high impact for the
grievous harm to reach the crew in the front seat is received forward of the vehicle, and secures an
appropriate effect of the crew restraint. -
The force limiter mechanism eases the impact to the chest by maintaining the load
of the seat belt to a regulated value.
. It is necessary to wind up to the first stage of the collision up the seat belt instantaneously . . Draw out the seat belt while maintaining the specified load
when colliding .
358
Seat belt relation
Contents
The
The seat belt with the pretensioner cannot be used again. Handling indoor
equipment
- The seat belt with the pretensioner cannot be used again when operating once. It is not
possible to draw out, to wind up up the seat belt when operating, and to exchange it in
the Toyota shop. The pretensioner doesn't operate in the second collision if the pretensioner . good.. Safety
operates by the first collision when colliding similarly continuously. - of ・
To
No fire though the gas like white smoke is generated with the operation sound if the seat theory Comfortable
belt with the pretensioner operates. Moreover, there is not an influence on the human body either. - and
equipment
Consult the Toyota shop when you abandon the seat belt with the car and the
pretensioner. The seat belt with the pretensioner operates unexpectedly, and it is likely to How
injure. to attention
associate . drinking..
car
Knowledge
About the operation condition of the seat belt with the pretensioner
The seat belt with the pretensioner operates when the high impact is received forward of the vehicle. It Maintenance
is likely not to operate when the following impacts are weak. -
To a concrete wall at the head-on collision at the speed at about 30 km/h or less.
Do not demonstrate an original effect though it is likely to operate in the following cases. -
When you receive the impact from the side and the rear side. - Myriad
Oneの
When the vehicle turns sideways, and is overthrown.
と
き
Index
359
-
ABS 、Brake assistance
What are ABS and the brake assistance?
Working of ABS
ABS controls slipping by preventing the tire that happens when time that
slammed on the brakes and applying the brakes on a slippery road being locked (The
rotation must stop).
ABS
ABS none
Breaking beginning
360
ABS and brake assistance
Contents
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
361
When ABS and the brake assistance operate
About driving
- It is necessary to keep stepping on the brake
pedal hard as soon as possible at a rapid
brake so that ABS and the brake assistance may
demonstrate the effect.
Step to one's heart's content. Keep stepping. Do not loosen, and do the pumping.
About operation
It is not abnormal though the following phenomena might be generated
if ABS operates. -
The brake pedal might move, feel the vibration in the body and the steering wheel little
by little with the operation sound of ABS, and after the vehicle stops, it hear of the motor
sound. -
The brake pedal might enter the interior a little when the operation
of ABS ends.
362
ABS and brake assistance
-1
EBD . drinking.. Hataraki Contents
Distribute an appropriate braking effort corresponding to the state of running of the vehicle to the back and forth circle by
applying the control technology of ABS. As a result, appropriately do the braking power distribution of four wheels according
Warning
to the load change according to loading and the deceleration, and secure a high brake performance. In addition, control
the braking effort of a right and left circle when braking while turning and secure
roadholding.
Basic
. earliness.. operation
car
Maintenance
Myriad
Oneの
と
き
- 1 As for EBD, "Electronic braking power distribution control" is meant by abbreviating Electronic Brake
force Distribution (electronic brake force distribution). Index
363
Knowledge
About the operation condition
- It comes to be able to operate ABS, brake assistance *, and 1 by the velocity of the car exceeding about
10 km/h. Moreover, stop operating when the velocity of the car falls up to about 5 km/h. -
It becomes easy to operate ABS because it is slippery if stepping on the brake on a seam and an under construction
iron plate of manhole Fta and the bridge etc. on the day of rain.
364
TRC・VSC
TRC ・VSC -
Working of TRC
The device that tries to suppress the wheel spin of the drive wheel caused by excessive driving power Warning
when starting and accelerating in a slippery road, and to secure direction stability and driving power
of the vehicle. -
The computer must perceive slipping by information from the sensor of the velocity Basic
. earliness.. operation
of the wheel when the wheel begins to slip, lower the output to the engine momentarily,
and apply the brakes if necessary. As a result, suppress excessive driving
power, and control slipping.
蘆Slipping display light (P.258) blinks when TRC operates. At
Driving
this time, this is due to the brake control, and it is not abnormal though the Handling
vibration of the vehicle might be felt. device
蘆When the engine power like the escape from mud and a new snow etc.
is necessary, the TRC system can be stopped by operating the TRC
The
OFF switch. (Refer to P.294. )
Handling indoor
equipment
Mechanism of TRC
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
The computer judges that slipping of the tire slips when signals from the Maintenance
sensor installed in four wheels are compared, and only either of signal is
more than other wheels. As a result, control slipping by applying the brakes, and
suppressing the output of the engine to temporary when suppress driving power Myriad
Oneの
of the slipping tire.
と
き
- As for the sign, the presence of the installation is different depending on the grade etc. 365
About the relation between TRC and the tire
The attitude of the signal changes when the tyre type is different because it operates
based on the signal from the sensor that is attached to the wheel even by one wheel in
four wheels, and the computer judges slipping TRC. -
The state of the tire greatly influences the system, and do close attention
to the state of the tire. Read "Attention of the tire" of P.75
well in detail.
Knowledge
About the operation condition
It enters the state that TRC can be operated usually (When you turn on the engine switch). -
TRC doesn't operate when the VSC warning light (Refer to P.268) lights.
366
TRC・VSC
Working of VSC
VSC is a system that tries to control the output of the brake and the engine automatically Warning
to control the ABS brake assistance and TRC. EFI, etc. cooperatively, and to control
the sideslip on a rapid steering wheel control and a slippery road etc. when turning, and
to secure the stability of the vehicle. - Basic
. earliness.. operation
The state of the tire greatly influences the system, and do close attention
to the state of the tire. Read "Attention of the tire" of P.75
well in detail.
Driving
Handling
Be not overconfident in VSC. There is a limit in securing the direction stability
device
of the vehicle, and an impossible driving might cause an unexpected accident and is dangerous also in
the state that VSC operates. Drive especially carefully when always it bears in mind, the VSC operation
warning buzzer (discontinuous sounds) rings or the slipping display light (Refer to The
P.258) blinks to the safe driving.
Handling indoor
equipment
Knowledge
. good.. Safety
About the operation condition of ・
To
- It comes to be able to operate VSC by the velocity of the car exceeding about 15 km/h. - theory Comfortable
VSC doesn't operate when the VSC warning light (Refer to P.268) lights. and
equipment
Maintenance
Myriad
Oneの
と
き
367
Super ECT
What is Super ECT?
1.8L car
Super ECT is controlling and automatic a transmission to unite the fuel cost
performance to a comfortable running by the Flex Lock-Up system and the Nobofsaca changing
the speed control system, etc.
Working of Flex Lock-Up system
The system that raises the transmission efficiency of the transmission, and improves the fuel cost performance. -
In the FF car, the gear-shift :. 綺・ 絲It is the operation stripes automatically if drinking and existing in 4 velocities.
Do. -
In 4WD car, the gear-shift :. 綺・ 笳It operates automatically.
368
Electronically controlled throttle (ETCS i- )
What is an electronically controlled throttle? Contents
Abnormality of an electronically controlled system is thought while running when the rise of the engine
rotational speed is slow even if the engine warning light (Refer to P.272) lights, and it steps on the
gas pedal. Driving
Handling
At this time, it is possible to run in low speed though the body vibration might increase.
Receive the check at once in the Toyota shop. device
It never returns normally until the engine is stopped even when abnormality of an
electronically controlled system cancels it while low-speed running by any chance of
The
this and the engine switch is made ACC or LOCK.
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
369
Super CVT. i
What is Super CVT i?
2.0L car
Super CVT i is an electronically controlled gearless transmission to make a smooth, comfortable running
united to the fuel cost performance by an integrated control etc. of the no steps changing the speed system,
the Lock-Up system, the Nobofsaca changing the speed control system, and four D engines.
370
Super CVT. i
Contents
Limit the improvement shift when it is judged that it climbs up the slope when it
makes to Rad) and it runs, and achieve a smooth running.
Moreover, the down shift is automatically done when stepping on the brake when judged Basic
. earliness.. operation
that Fsaca is done at Fsaca and the engine brake hangs.
Driving
Climbing up the slope corner Handling
device
The
Handling indoor
Down Improvement Down equipment
Usually shift shift shift Improvement shift Usually
There is no control.
Down
Usually Improvement shift limitation improvement shift shift Usually
Nobofsaca changing the speed control . good.. Safety
of ・
Brake ON To
theory Comfortable
and
equipment
car
Maintenance
Myriad
Oneの
と
き
Index
371
Active torque control 4WD
What is active torque control 4WD?
4WD car
4WD that automatically usually controls, demonstrates steady manoeuverability and roadholding from running
from the state of the FF running to the state of directly connected 4WD running according to various states
of running such as roads slippery because of acceleration, the snow, and rain, etc. when cornering,
climbing up the slope, and starting, and achieved an excellent fuel cost performance by the computer. -
When 4WD auto mode switch is turned on, it controls. Refer to
"How to use of 4WD auto mode switch" of P.293 for
the switch.
The attention when active torque control 4WD is handled has been
described to "Attention of 4W D car" of P.70. ..safe driving.. bear it in mind
because it often reads, and correct handling is understood.
4WD running
Operate when you turn on 4WD auto mode switch.
Drive
372
Active torque control 4WD
Contents
FF running
4WD auto mode switch is in the state of turning off. A Warning
Basic
. earliness.. operation
About the tire
Active torque control 4WD greatly influences the performance of the car the
state of the tire, and do close attention to the state of the tire. In detailRead
Driving
"Attention of the tire" of P.75 well. Handling
device
蘆When the difference of the air pressure of four wheels is remarkable. car
蘆When the air pressure shifts from a specified value.
- Rotate the tire around the wear-out of the tire to keep even, and to extend longevity to
four wheels. (Refer to P.409. )-
Do not install the disc wheels other than specification when you exchange the disc Maintenance
wheels. (Refer to P.453. )
Myriad
Oneの
と
き
Index
373
Anti-theft system -
The signal transmitter is built into a master key and a sub-key for anti-theft
of the vehicle, and the system that was not able to start the engine excluding the
key registered beforehand. -
The signal registered in the key is different in each car. -
The system operates when the key is pulled out from the engine switch, and the
security display light (Refer to P.261) blinks. -
The system is released when registered master key and sub-key are inserted in
the engine switch, and the security display light is turned off.
A master key and sub-key are electronic parts with built-in signal transmitter.
Guard the following to prevent the breakdown. -
Do not torture the key, and do not give the high impact. -
Do not put it on the place that becomes a high temperature such as on dashboards. -
Do not apply the key ring etc. that wear magnetism. -
Do not wash the key in the ultrasonic washing machine etc.
374 - As for the sign, the presence of the installation is different depending on the grade etc.
Anti-theft system
Contents
In the following cases, because the vehicle cannot accurately receive the
signal from the key, the engine might not be able to be started. Warning
- In the state of putting a metallic ring on the key grip.
Basic
. earliness.. operation
- When the metal part of other keys bounds to the key grip.
Driving
Handling
device
- When the key is a key (one with built-in signal transmitter) for the immobilizer system
of other vehicles and comes in succession.
The
Handling indoor
equipment
- When the key is near the key (one with built-in signal transmitter) for the
immobilizer system of other vehicles.
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
- When the metallic one touches the key grip. car
Maintenance
Knowledge
Myriad
About the key to an anti-theft system Oneの
The master key can use 5 or less and sub-keys for the key up to three in the same と
vehicle. Consult the Toyota shop in detail. き
Index
375
Dischargeheddoramp -
What is Dischargeheddoramp?
It emits light by using a gas and a metallic iodide, and Dischargeheddoramp is light that is whiter
than a usual lamp and a lamp of the valve jurisdiction with the distribution light with the extension
it expands.
Knowledge
About auto leveling (upper and lower irradiation direction self adjustment) system
The device that automatically adjusts an optical axis of the headlamp corresponding to the change in the vehicle posture by the loading
situation etc. of luggage.
376 - As for the sign, the presence of the installation is different depending on the grade etc.
Mirror glass relation
Mirror glass relation
Rancriaringmirar Contents
2.0L car
Make the rear side easy to see by being coated Mac to the specular of the door mirror, and expanding Warning
the drop of water that adheres to the specular such as rain like the film (effect of the hydrophilicity).
Usual door mirror Rancriaringmirar
Basic
. earliness.. operation
Driving
- The illustration is different in the one shown in the image from the actual one. Handling
device
- Mizmac clears up when the mirror heater is operated, and clearer view is
obtained. Read P.216 about the operation of the mirror heater. -
Usual maintenance is enough ..only doing it is washing in clear water... - The
The effect of the parents water decreases to a small amount of drops of water such as the fine rain and drizzle. - Handling indoor
equipment
In the following cases, recover gradually though the effect of the hydrophilicity is temporarily lost. Flush it
with bags of water after it washes it with the car shampoo and the glass cleaner, etc. when
you want to recover the effect of the hydrophilicity at once. (There is the one that
. good.. Safety
in the car shampoo and the glass cleaner, there is a silicone compound, of ・
To
too and read the ingredients label well. ) theory Comfortable
and
蘆When you wipe the dirt of the mirror off. equipment
蘆When the mirror becomes cloudy.
蘆When you wash wax with the automatic carwash machine. How
to attention
蘆A long term, when parking to the place where the day such as the basement car parks is not hit.
associate . drinking..
car
Defend the following notes to prevent the door mirror being
damaged to continue the effect of the hydrophilicity.
- Use neither water-repellent medicine (spray and solvent, etc. with the silicone) nor the oil slick removing
medicines (spray and solvent, etc. with the compound). Moreover, do not cover the specular of the door mirror with Maintenance
the towel etc. , and do not adhere to the door mirror when you use the water-repellent medicine, the oil slick removing
medicine, and wax for the door glass and the body. Flush it with bags of water after it washes it with the car
shampoo and the glass cleaner, etc. when you adhere by any chance. (There is the one that in the
Myriad
car shampoo and the glass cleaner, there is a silicone compound, too and read the Oneの
ingredients label well. )-
と
Operate the mirror heater or thaw without scraping it with a plastic board etc. き
by putting the warm water when the door mirror freezes. -
Wipe off with a beautiful towel when you wipe the dirt of the door mirror off.
Index
377
The glass with water-repellent function
The glass
- The illustration is different in the one shown in the image from the actual one.
There is a limit for the continuation period when the drop of water is shed. Defend the
following notes to make it last long.
- Clean it as ahead of time as possible with a soft, damp cloth etc. when the glass with a water-repellent
function is dirty. -
Open and shut the reception desk door glass after removing dirt when the dirt such as the
mud of the glass is awful. -
Use neither glass cleaner nor wax that the compound (polish powder) enters when you clean
the glass with a water-repellent function. Moreover, wipe off with the moist cloth when white
overcast when the glass cleaner is used. -
Wash a car after washing off the dirt such as the glass surface sludges with a water-repellent function when you use the
automatic carwash machine. -
Do not do the frost removing etc. by the metallic one. -
The glass with a water-repellent function is an articles of consumption. When shedding the drop of water worsens, it is necessary to repair.
Moreover, the coating can be removed. Look to the Toyota shop in
detail.
378
Mirror glass relation
Contents
Warning
Basic
. earliness.. operation
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
379
About driving rain on the day
Driving of rain on day
- A rapid brake, rapid acceleration, and a rapid steering wheel in a slippery road slip the tire, cannot
control the vehicle, might cause an unexpected accident, and are dangerous. -
An engine brake by the improvement shift down of the shift and a rapid change in the engine rotational
speed might cause an unexpected accident by sideslipping by the car and are dangerous. -
Confirm the brake works normally lightly stepping on the brake pedal after it runs of
the puddle. When the brake pad is wet, it worsens working of the brake, and is taken the steering wheel
effective only of one that has not been wet, might cause an unexpected accident, and is dangerous.
It might cause a serious vehicle breakdown to damage the engine by not only the engine
stall if running on the flooded road but also the inhalation of the short of electrical
equipment and water. Check the following item etc. in the Toyota shop when running
on the flooded road by any chance, and soaked in water. -
Effective condition of brake. -
Change in amount of oil and qualities such as engine transmission
transfers (4WD car) and Def. (Because water mixes when becoming cloudy,
the exchange of oil is necessary. )-
Lubrication is defective in the propeller shaft (4WD car) and each bear and
collaborate each.
382
Handling at the cold
Preparation and check before winter Contents
Basic
. earliness.. operation
Adjust the density of the washer liquid.
Dilute referring to the frozen temperature displayed in the bought washer liquid container
to prevent the washer liquid being frozen and replenish it.
Driving
Handling
device
Adjust the density of cooling water.
Adjust the density of cooling water to prevent cooling water being frozen. The
Handling indoor
Use region Dilution ratio Frozen guarantee temperature equipment
How
to attention
associate . drinking..
Check liquid measure and the specific gravity of the battery. car
The performance of the battery might decrease when the temperature falls, and it interfere
to the engine start. Liquid measure and the specific gravity of the battery are checked, and replenish of the
liquid and charge it if necessary. Maintenance
Myriad
Oneの
と
き
Index
383
Prepare the tire and the tire chain for winter.
- Refer to "Attention of the tire" of P.75 when fixing
a new tire. -
Prepare the tire chain suitable for the size of the tire. -
Use a Toyota pure goods of the wish specification. Consult the
Toyota shop in detail.
384
Handling at the cold
Basic
The snow and the frost that attaches to the glass . earliness.. operation
Drop the snow and frost in the inside and outside of the glass and secure view.
It is possible to drop without damaging the glass when the defroster is used.
Driving
Do not divide beating to remove the ice that attaches to the reception Handling
desk window glass. The inside of the reception desk window glass (inside of the device
car) might crack.
The
The lump of ice that attaches to the underside etc. Handling indoor
equipment
Remove so as not to damage the body etc.
. good.. Safety
The snow that piles in the air intake of ・
To
theory Comfortable
Operate the fan of the air conditioner after removing the snow that piles in the air and
equipment
intake at the front of the reception desk window.
The fan might break down, and the glass become cloudy when operating How
to attention
with the snow piles.
associate . drinking..
car
と
き
Index
385
When the door freezes
Melt ice sprinkling the hot water. Wipe moisture off enough
at once. When forcibly opening it, rubber in the door circumference might peel
off, and it damage it.
When pedals are operated, it slips, the indoor moisture might increase, the
glass become cloudy, and it freeze.
386
Handling at the cold
vehicle and might cause the accident. Start slowly, take the distance between two cars enough at the
speed of incommunicative, and run.
Decelerate beforehand in a frozen place such as on the bridge and shade, and Basic
. earliness.. operation
run carefully.
17-inch wheel installation car
215/50R17 91V tire values the grip performance when running in
general and is made. The grip performance decreases on the snowfall road and the frozen road compared Driving
Handling
with a general tire. Install the tire or the tire chain for winter without fail on the snowfall road
device
and the frozen road, and drive the speed with unassuming modesty. Drive the grip performance of the
rear wheel more carefully to be low even if you install the tire chain in the front wheel.
The
An engine brake by the improvement shift down of the shift and a rapid change in Handling indoor
equipment
the engine rotational speed might cause an unexpected accident by sideslipping by the
car and are dangerous.
. good.. Safety
The ice that attaches to the other side of the fender of ・
To
theory Comfortable
It influences running, and remove before sometimes confirming, and growing the and
equipment
lump of ice.
How
to attention
The ice that attaches to the brake equipment associate . drinking..
Working of the brake might become bad. Confirm the effective condition of car
the brake stepping on the brake pedal sometimes lightly.
と
Run by the correct air pressure suitable for the tire when the tire for winter is installed. き
Moreover, avoid the high speed operation for safety when you install the tire for winter.
Index
387
Tire chain
- Install the tire chain in the first wheel. -
Follow the tire chain the method of handling the tire chain and follow the
manual of the attachment. -
The tire chain must use the one suitable for the size of the tire. -
Use a Toyota pure goods of the wish specification. Consult the
Toyota shop in detail.
. procedure .
388
Handling at the cold
Contents
device
How
Note that neither the wheel nor the hubcap are to attention
damaged when you install the tire chain. associate . drinking..
- The steel wheel installation car must install the tire chain after removing car
the hubcap. When the tire chain is installed with the hubcap applied,
the hubcap might be damaged. -
When the aluminum foil installation car installs the tire chain in the aluminum foil,
the wheel might be damaged. - Maintenance
It lies to the body side if the tire chains other than a Toyota pure goods are used and the adverse effect
might be caused for running. Consult the Toyota shop in detail.
Myriad
Oneの
と
き
Index
389
When parking
The vehicle exhaust emission invades in the car, it becomes CO intoxication if the snow piles in the
circumference of the car while started up an engine, and it reaches important injury or, in the worst
case, it is likely to lead to the death.
390
Handling at the cold
Contents
part where the wind drives more than the imagination to prevent the battery performance decrease.
Basic
. earliness.. operation
The wiper arm is setting it up.
The wiper due to the cold is ..glass.. frozen at the snow. Set up and
park the wiper arm. Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
391
Economical driving
To do an environment friendly, economical driving
392
Economical driving
Contents
jet well. It becomes low fuel cost a little depressing the gas pedal and the stepping return.
in case of a constant running
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
393
Knowledge
, saying that "10.15 modes"
"10.15 modes" fuel cost that has been described to the vehicle catalog is fuel cost measured according to
specific conditions.
This mode is reproduction of running in the city, and the one to reproduce running on a road actual
on the chassis dynamometer, and to run in the pattern like Figure 2 after the machine of engine as shown
in Figure 1.
40
A typical though "10.15 modes" is the one that running in the city was reproduced to the last a
running pattern. Therefore, there must be a lot of cases different from an actual running,
and, for instance,
- The average of the running speed is lower than "10.15 modes".
- The stop ratio (ratio to which the car stops while driving) is high.
- Sudden acceleration was done.
It comes to get bad mileage by the difference of the condition.
- The numerical value is calculated based on fuel cost 11.7km/L of the passenger car of 2.0L class (automatic
car)(10.15 modes). (Read the vehicle catalog about the fuel cost of each vehicle model. )-
The amount of the CO2 exhaust is calculated by exhaust of CO2 for each gasoline 1L coefficient 0.64.
394
For the environmental protection
Used parts and the abolition oil do proper processing. Contents
- Because lead and sulfuric acid are used as for the battery, appropriate processing is
obligated by the law as a specific, industrial waste.
Warning
Request disposal in the shop that bought it when you exchange the batteries. -
If the individual burns, the tire generates a poisonous gas such as sulfurous
acid gass.
Request disposal to the shop that bought it. - Basic
. earliness.. operation
It infiltrates under the soil, and when the engine oil is left, it floats on water, and the
environment is deteriorated which effusing.
Request disposal to the shop that bought it. -
Antifreeze has the ethylene glycol that lowers the frozen temperature of cooling water. Driving
Handling
It causes water pollution when it throws into the river etc. , and consult the Toyota
shop about the exchange of antifreeze. - device
Fluorocarbon (regulated chlorofluorocarbons gas CFC12) for the air conditioner refrigerative advances the
depletion of the ozone layer when discharged into the atmosphere. The
Toyota completes all car switch ..hydrochlorofluorocarbon gas (HFC134a) that Handling indoor
doesn't rip up the ozone.. (completion for 93 years). equipment
Still, hydrochlorofluorocarbon gas (HFC134a) has working that makes the earth
clement.
Fill the gas after doing the gas not only is filled when working of the air conditioner . good.. Safety
of ・
is bad but also unifying the check of the gas leak, and repairing the leakage part. To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
395
396
For the environmental protection
Contents
Warning
Basic
. earliness.. operation
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
397
6
Contents
car to associate
Basic
. earliness.. operation
How
to attention
. drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
381
7
Contents
Warning
Maintenance
Basic
. earliness.. operation
Maintenance
Myriad
Oneの
と
き
Index
399
Maintenance of car
The usual maintenance
About painting
- The stepping-stone wound and the scratch cause corrosion, and repair with the
Toyota pure touch-up paint etc. ahead of time when finding it. -
Benzine..gasoline..organic..solvent..adhere..painting..damage..at
once..wipe off..wash a car.
400
Maintenance of car
Contents
Basic
. earliness.. operation
Driving
Handling
device
It causes deterioration in painting and the corrosion of the body and parts, etc. to be brought forward. -
The
When you do running of the coast zone. -
Handling indoor
When you run on the road where the antifreezing agent was scattered. - equipment
When coal tar, sap, and bird's excrement and insects' corpses etc. adhere. -
When you run in the place where a lot of descents such as smoke, lamp soot, dust, iron filings, and
chemicals exist. - . good.. Safety
of ・
When remarkably becoming dirty with dust and mud, etc. To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
401
Maintenance of exterior
402
Maintenance of car
Contents
2.0L car
Defend notes of "Glass with a water-repellent function" of Basic
"Rancriaringmirar" of P.377 and P.378 about maintenance. . earliness.. operation
. good.. Safety
of ・
Do not injure when you wash a car. To
theory Comfortable
and
- Do not injure to the hand when you wash the circumference and the underside in the under. - equipment
Use a hard neither brush nor scourer, etc. when you wash a car. Painting etc. are
damaged. - How
to attention
Be not do not wipe the surface of the lens of the lamp with organic solvents such as wax, benzine, and
gasoline, worth, and do not rub with a hard brush etc.Might it damage, and deterioration be brought forward. associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
403
Maintenance of interior
- Do not sprinkle water in the car when you clean the car. It causes the car breakdown, and when
water splashes to electric parts etc. that the audio and floor carpet under includes, it might connect with a
vehicle fire and is dangerous. -
Do not use organic solvents such as benzine and gasoline to clean the seat belt. Moreover,
do not bleach, and do not dye the belt. Important injury that decreases the performance of the
seat belt, doesn't demonstrate an enough effect at the collision etc. , and is related to the life might be received and it is
dangerous. Do not use the seat belt until drying by using the soapless soap or lukewarm water when
you clean it.
- Do not use an organic solvent, an acid such as the benzine gasoline or an alkaline solvent
when you maintain the interior. Discoloration and doing cause seeing. Moreover, these
elements might be included in various cleaners, and use it after it often confirms
it. -
Note no allowance of the interior goods (air conditioner and audio, etc.) aromatic substance's
(liquid, solid, gel, and plate type, etc.) direct touch, and spilling. It might cause discoloration
and seeing and the painting peeling off of doing according to the included element. -
Do not use the glass cleaner etc. when you clean the inside of the backing door
glass. Heat ray is disconnected, and it is likely not to operate. Wipe the cleaning lightly with the
cloth to contain water or lukewarm water along heat ray. -
Do not use the glass cleaner that the compound enters when you clean the inside
of the glass. Wipe the cleaning lightly with the cloth to contain water or lukewarm water.
404
Maintenance of car
Basic
. earliness.. operation
Exchange of clean air filters
1 Make the engine switch LOCK.
Driving
Handling
device
How
to attention
associate . drinking..
car
Maintenance
Pin
Myriad
Oneの
と
き
Index
405
3 Remove the filter case.
Pull a certain knob forward right and
left, and detach the filter case with
the filter case.
Filter case
Knob
2.0L car
(pollen removal type > < with deodorization function) 4 It changes a filter.
Filter Detach the filter from the detached
filter case, and exchange it for
a new filter. -
Install the filter in Tsme
of the filter case surely. -
F i l , 蚶UP" Make the arrow of
the mark become to the above and install it.
Tsme
1.8L car
(pollen removal type)
Filter
Tsme
406
Maintenance of car
Contents
How
Pin to attention
Damparsta
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
407
Exchange filters after making the engine
switch LOCK.
- Exchange filters after making the engine switch LOCK. -
It thinks about the amount of the wind of the air conditioner, and remarkably the glass decreases or was cloudy weather, becoming that becomes
empty, and stopped up of the filter is thought. Clean (Only 1.8L car :) or exchange filters.
Consult the Toyota shop about the cleaning of the filter. -
Filters of 2.0L car are exchanged types. Do not clean it by the unpleasantness of washing in clear
water air blow. -
Install the filter so as not to mistake the table for the back of the filter. -
Use the air conditioner with the filter installed. When the air conditioner
is used without installing the filter, it might cause the breakdown.
Knowledge
About the cleaning and the exchange of air filters
- The air filter is installed in the air conditioner. We will encourage a regular cleaning
(Only 1.8L car :) and the exchange to use it comfortably. -
Air filters can be exchanged without the tool. -
Consult the Toyota shop about the air filter of the air filter for the cleaning and the exchange.
Standard of cleaning(Only 1.8L car :. ). Each 15,000km. 7,500km. .
Standard 2.0L
car of exchange. Each 15,000km. 10,000km. .
1.8L car . Each 30,000km. 15,000km. .
. . : for the multi district (district where a lot of traffic and dust such as large cities and the cold districts exist).
408
Maintenance of car
Driving
Handling
Front wheel Front wheel
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
Check the tire as a daily check.
associate . drinking..
- Check the tire as a daily check. (Refer to P.75 "Attention of the car
tire". )-
Consult the Toyota shop when you exchange the tire disc wheel wheel
installation nuts. (Refer to P.89 "Other attention". )
Maintenance
Myriad
Oneの
と
き
Index
409
About the rotation direction instruction mark
17-inch wheel installation car
The direction of the rotation on the performance of the tire is specified. Install it so that the rotation
direction instruction on tire side mark may turn forward of the vehicle.
410
Maintenance of car
Cutting lack
. good.. Safety
of ・
Battery cover
3 Remove the battery cover of the module.
To
theory Comfortable
and
Detach the battery cover of the equipment
module.
How
to attention
associate . drinking..
car
Module
4 It changes a battery.
Battery
An old battery is taken out, and do up Maintenance
and insert the new battery side.
Myriad
Oneの
と
き
Index
- As for the sign, the presence of the installation is different depending on the grade etc. 411
5 Fix the battery cover of the module.
Set the battery cover firmly as it is original.
Note that detached neither battery nor parts (Especially, the child :)
are swallowed. Important injury might be received when swallowing and it is dangerous.
Knowledge
About the battery
Use battery . . lithem battery CR2016
Buy the battery in the Toyota shop, the clock shop, and the camera shop, etc.
412
Maintenance of car
Driving
Handling
2 It changes a battery.
device
. good.. Safety
of ・
Pakkin To
3
theory Comfortable
and
Fix the cover. equipment
Obtain the cover firmly as it is
How
original. to attention
associate . drinking..
car
と
き
Index
413
Note that detached neither battery nor parts (Especially, the child :)
are swallowed. Important injury might be received when swallowing and it is dangerous.
- Note that neither Pakkin nor detached parts, etc. are lost when the batteries are exchanged. -
With the battery pole Make to the correct direction without fail and install the pole. -
Note that the electrode in the battery insertion part is not bent, and garbage and oil, etc. adhere. -
Do not damage, and do not twist and do not install Pakkin. -
The cover might be damaged, and remove after appropriating the cloth cutting to the
coin etc. when you detach the cover by using the coin etc.
Knowledge
About the battery
Use battery . . lithem battery CR2032
Buy the battery in the Toyota shop, the clock shop, and the camera shop, etc.
414
Maintenance of car
The ball cutting of blowing the fuse and the lamp is thought when the lamp doesn't go on and when
the device of the electrical system doesn't work.
Warning
Check the fuse and exchange it according to the following procedure. -
Consult the Toyota shop about the fuse.
1
Basic
. earliness.. operation
Make the engine switch LOCK.
. good.. Safety
of ・
To
theory Comfortable
and
equipment
Fuse box B
How
Tsme to attention
associate . drinking..
- 4WD car, Conrait installation car, and Dischargeheddoramp installation car
car
Index
415
3 Check the fuse.
Confirm the fuse that should be checked from the situation of the breakdown
with the fuse label, pull out the fuse, and check whether the fuse cuts. -
The fuse has the one that not is depending on the specification of the car either. -
Consult the Toyota shop about the fuse.
4 Exchange fuses.
Exchange it for the fuse of regulated capacity according to the display
of the fuse box when the fuse cuts. -
When lamps do not light, the lamp cutting is thought. -
In the following cases, receive the check in the Toyota shop.
蘆When the fuse cuts again even if it changes it.
蘆When the device of the electrical system doesn't work even if it changes it.
Do not use fuses other than regulated capacity. It overheats, damages wiring
by a fire, might connect with a fire, and is dangerous.
416
Maintenance of car
Contents
Basic
. earliness.. operation
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
Fuse name Amperage Device name of which fuse takes charge and
equipment
H-LP LH(UPR) 15A Headlamp (left) high beam
How
H-LP RH(UPR) 15A headlamp (right) high to attention
Zal H-LP LH(LWR) 15A beam headlamp (left) low associate . drinking..
car
H-LP RH(LWR) 15A beam headlamp (right) low
Maintenance
Myriad
Oneの
と
き
Index
417
- Fuse box B in engine room
418
Maintenance of car
Contents
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
419
- Passenger's seat side fuse box
420
Maintenance of car
Contents
笆 LIFT UP 30A
笙 AM1 25A
associate . drinking..
筅 WIPER 20A Wiper & washer
car
Straw mat ECU-IG 7.5A A B S
Myriad
Oneの
と
き
Index
421
Lamp (valve) exchanges of exteriors
In the exterior of this car, there is a lamp (valve) shown in the figure below. -
Read a pertinent page about the exchange of lamps that describe the number of pages.
- - Consult the Toyota shop about the exchange of lamps that describe the sign.
Number-plate light *
422
Maintenance of car
Contents
Driving
Handling
Handle the lamp very carefully.
device
- Drop because pressure in the glass is high, throw the thing or damage and the
glass might scatter damaging it, and handle the tungsten halogen lamp very
The
carefully. Moreover, wear beautiful gloves without touching by bare-handed. -
Handling indoor
Use lamps of the same number of W. (Refer to P.449. )- equipment
Install the lamp and the lamp fastening device surely. When the installation is imperfect, it
breaks down by the temporary halt etc. and it is likely to connect as it is inside of the lens and is cloudy. -
Work noting that the tool, the lamp or neither lamp fastening device nor the socket, etc. are
. good.. Safety
lost when you exchange lamps. of ・
To
theory Comfortable
and
equipment
Knowledge
How
to attention
About the cloudy weather of the lamp
associate . drinking..
The inside of the lens might become cloudy lamped of the headlamp etc. by use conditions of the rain running
and the carwash, etc.This is a similar phenomenon to fogging up the windows in the one by the temperatures fluctuate of the inside car
of the lamp and air such as rain, and doesn't have the problem on the function. However, receive the check in the Toyota
shop when water has collected in time when a big drop of water is attached in the lens and the lamp.
Myriad
Oneの
と
き
Index
423
Headlamp(low beam)
Exclude the Dischargeheddoramp installation car.
- Those who detach it
Tsme
Socket
3 Detach the socket from the lamp
pushing Tsme.
The work space broadens when the
passenger's seat side detaches the cover of the
fuse box in the engine room. About
how to detach the fuse box
Refer to P.415.
Tsme
424
Maintenance of car
Contents
Basic
. earliness.. operation
Driving
Handling
device
The
- Those who install it
Handling indoor
Install it according to a reverse procedure to equipment
detaching.
When the cover of the fuse box in
. good.. Safety
the engine room is removed and you work, of ・
To
confirm fixing the cover, and fixation theory Comfortable
and
surely. equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
425
Headlamp(high beam)
- Those who detach it
Lamp
426
Maintenance of car
Contents
Socket
Driving
Handling
device
The
Handling indoor
equipment
- Those who install it
Install it according to a reverse procedure to
detaching. . good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
427
Front position light
- Those who detach it
Lamp
Open the hood, spend the socket in the
direction of the arrow, pull out, and detach the
lamp from the socket.
Socket
428
Maintenance of car
Contents
Driving
Handling
device
The
Socket
Lamp
2 Spend the socket in the direction of the arrow Handling indoor
equipment
and extract the lamp.
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
When the socket is removed from the main body, it becomes easy for the socket to drop in the vehicle.
Work noting no fall.
Myriad
Oneの
と
き
429
Retreat light
- Those who detach it
Cover
Cutting lack
Socket
Lamp
430
Maintenance of car
Contents
How
to attention
associate . drinking..
car
Maintenance
Tsme Myriad
Oneの
と
き
431
3 Spend the lamp in the direction of the arrow and
take it out.
432
Maintenance of car
Contents
Warning
Basic
. earliness.. operation
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
. drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
433
Daily check
About the daily check
434
Daily check
Warning
Brakifludorizarbartanc
Basic
Engine oil injection entrance . earliness.. operation
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Engine oil level gauge
Maintenance
Washer liquid injection entrance
Myriad
Oneの
と
き
Index
435
Car equipped with 1ZZ FE engine(1.8L gasoline car)
Brakifludorizarbartanc
Confirm neither the tool nor the cloth, etc. are left behind in the engine room
check and after it exchanges it. It might connect with a vehicle fire because it causes the
breakdown, and it becomes a high temperature moreover in the engine room and is dangerous if it
leaves it behind by any chance.
436
Daily check
Contents
Basic
. earliness.. operation
MAX(upper bound)
MIN(lower bound)
Driving
Handling
device
The
Handling indoor
equipment
It worsens when brake Froude is insufficient working of the brake, might cause
. good.. Safety
an unexpected accident, and is dangerous. of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
437
Liquid measure of battery
The battery liquid side checks whether each Ekisou is between UPPER LEVEL
of the battery (upper bound) and LOWER LEVEL (lower bound) by shaking the vehicle.
Check regularly might connect with the damage of the battery rising
and the battery when the battery liquid is insufficient.
Knowledge
About the battery
As for the display of UPPER LEVEL. LOWER LEVEL, the design and the displayed place are different
according to the installed battery.
438 - As for the sign, the presence of the installation is different depending on the grade etc.
Daily check
Contents
Basic
FULL(upper bound) . earliness.. operation
Driving
Handling
device
Check regularly so that there is fear of the corrosion of the radiator and the engine
damage because of overheating when the amount of cooling water is insufficient. Moreover, . good.. Safety
of ・
use the super-long life coolant (antifreeze) in an appropriate density To
to freeze at the cold when using it with the glass, and to damage theory Comfortable
and
the radiator etc. equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
439
Amount of engine oil
Check whether the amount of the engine oil is between the upper bound and the lower bound of the oil
level gauge.
- Regularly check and exchange it for the rotation part to become defective lubrication due to oil shortage
and deterioration if a regular check is neglected, to cause burning etc. , and to damage the engine.
蘆The engine oil has lubrication in the engine and working cooled.
Usually..drive..piston..breathe in..?..exhaust..valve..lubrication..oil..partially..combustion
chamber..burn..oil..amount..run..decrease.Moreover, the decreasing amount is different depending
on the running condition etc.-
Do not put it too much when you replenish oil. -
Apply and check the cloth etc. so that oil should not adhere to the alternator etc.
when you check the engine oil. Wipe off completely when oil adheres by any
chance.
440
Daily check
Contents
Driving
Handling
device
The
LOW(lower bound) Handling indoor
NORMAL(upper bound) equipment
1
. good.. Safety
of ・
Open the cap. To
theory Comfortable
Open the cap at the washer liquid injection and
entrance. equipment
How
associate . drinking..
Close the cap at the return washer liquid car
injection entrance surely based on the guide
Cap part when replenishment ends.
Maintenance
Do not replenish the washer liquid when time when the engine is hot
and the engine start. It might break out when hanging to the engine etc. because
an alcoholic element is contained in the washer liquid and is dangerous.
Myriad
Oneの
と
き
Do not put soapy water etc. instead of the washer liquid. Painting
might become seeing.
Index
441
Check of circumference of car
- We will encourage the check with the air pressure gauge about once a month. -
Adjust when the air pressure is not proper to the specified air pressure.
The management of the air pressure of a super-flat tire (17-inch wheel installation
car) is especially important compared with a usual tire.
- The management of the air pressure of a super-flat tire (17-inch wheel installation car) is especially important compared
with a usual tire. Check regularly so that the air pressure may especially become proper because a super-flat tire is a
tire to which it gives priority to the driving performance. Check the air pressure once every two weeks (Once a month
even if it is the lowest) before the drive of the long distance. -
The stability of the vehicle not only is ruined when it is lower than the specified air pressure but also the tire does Catayomamets. The
tire is a burst (explosion), might cause an unexpected accident by standing wave phenomenon
* when high-speed running, and it is dangerous. Include the spare tire by the daily check, and
check that the tire inflation pressure is specified air always pressure.
- When running at high speed, the tire is a wave phenomenon.
Knowledge
About the specified air pressure
Confirm the specified air pressure by the table or
the maintenance data (Refer to P.448) of "Tire inflation
pressure" pasted to the body side where the driver's
seat door was opened. -
Check the spare tire. -
It serves as a reference if the bend by the
specified air pressure is confirmed to watching check
of the tire.
Table of "Tire inflation pressure"
442
Daily check
Contents
the nail, the stone, and other foreign bodies stick, and it is whether bitten and crowded are checked.
Basic
. earliness.. operation
Do not install an abnormal tire that there are a wound and a crack
in the side wall of a tire etc.
- When the tire in which abnormality is found is installed, I might feel a vibration that is taken the steering wheel
when running, and is abnormal.
Driving
The damage such as bursts (explosion) that cannot be repaired is given to the tire, and moreover, the tire Handling
might cause an unexpected accident as the sideslip etc. and it is dangerous. device
Promptly receive the check in the Toyota shop, and exchange it for a normal tire while running when
you feel an abnormal vibration. -
It might not be able not only to demonstrate the performance of the car (stability and slip distance for brake etc. of fuel cost and the The
vehicle) enough when the tire in which abnormality is found is installed but also cause an unexpected accident and be dangerous. Moreover, Handling indoor
it might cause the breakdown as parts are negatively affected. equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
443
Depth and abnormal wear-out of ditch of tire
Mark that shows position of slip sign Mark that shows position of slip sign
Slip sign Slip sign
. example: State that slip sign has not gone out . * . example: State that slip sign has gone out . *
Do not use the tire that exceeds the wear-out limit. If the tire of which the
tire and slip sign (wear-out limit display) with a little depth of the ditch of the
tire have gone out is used as it is, the slip distance for brake cannot become long, the
steering wheel be operated by hydroplaning * on the day of rain, and the tire is a
burst (explosion), might cause an unexpected accident, and it is dangerous. Exchange
it promptly for a normal tire when you exceed the wear-out limit.
- Phenomenon of steering wheel and brake's tire's water's entering between tire and road when
running at high speed on road where water collects, floating from road, and not working.
Knowledge
About the cloudy weather of the lamp
The inside of the lens might become cloudy lamped of the headlamp and the braking light, etc. by use conditions of the
rain running and the carwash, etc.This is a similar phenomenon to fogging up the windows in the one by the temperatures fluctuate of
the inside of the lamp and air such as rain, and doesn't have the problem on the function. However, receive the check in
the Toyota shop when water has collected in time when a big drop of water is attached in the lens
and the lamp.
444
Daily check
Basic
. earliness.. operation
Driving
Handling
device
Whether goodness is checked by being the taking tool combination. whether there is allophone when the engine Handling indoor
equipment
startsMoreover, it is checked whether there is allophone with the rotation ..state of idling..
a little raised.
. good.. Safety
of ・
To
Step on the brake pedal. theory Comfortable
and
equipment
Start the engine, depress the brake pedal fully, and check the space with
the alcove slab. Check whether to find abnormality also in the feeling of the pedal. How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
445
State of jet of window washer
Start the engine, operate the window washer, and check the
jet.
446
Daily check
usually.
Basic
It is a use limit of the brake pad to generate the warning sound ("Key key" sound) from . earliness.. operation
the vicinity of the brake continuously while running. Receive the check at once in
the Toyota shop. It is lost of the brake pad when keeping running with the
warning sound generated, damages the brake parts, and worsens effective, might cause
an unexpected accident, and is dangerous. Driving
Handling
device
. good.. Safety
of ・
Check of abnormal part until the day before To
theory Comfortable
and
Check whether there is obstacle in operation for the part in which abnormality was found when using it until equipment
the day before.
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
447
Maintenance data
Maintenance data
- The notch is moderation (sound "Catitsu") when the parking brake is put.
448
Maintenance data
Contents
Wattage of lamp
Warning
I t e m Maintenance data
Headlamp
Dischargeheddoramp installation car Basic
. earliness.. operation
- 60W of high beam . . . . . . . . . . . . (valve
type: HB3)
- 35W of low beam . . . . . . . . . . . . (valve
type: D2S)
Driving
Halogen headlamp installation car Handling
- 60W of high beam . . . . . . . . . . . . (valve device
type: HB3)
- Reception desk direction of 5W of front position light
................ The
Myriad
Oneの
と
き
Index
- As for the sign, the presence of the installation is different depending on the grade etc. 449
Amount and kind of cooling water and oils and fats
Capacity
I t e m Designated stock
L(reference value)
Toyota is pure.
Automatic car 8.4
CVT Froude TC Toyota
transaxle
Froude(FF car)
2.0L car 6.9 is pure.
Auto Froude type
Automatic 1.8L car transaxle 6.9 T- Ⅳ
transaxle
Froude Toyota is pure.
transfer Haipoidogiyaoil
transfer 0.9
oil(4WD car) SX (API GL 5 and
SAE85W 90)
pure gear oil supermarket
Riyadifarenshaloil(4WD (API GL
0.5
car) 5 and SAE75W 90)
Toyota Toyota
is pure.
Power steering Froude 0.8 Power steering
(2.0L car <Z grade > and 4WD car)
Froude Toyota
is pure.
Brake Froude ---- Brake Froude
2500H
450
Maintenance data
Contents
蘆SM5W. 30(API
1AZ-FSE 4.0 4.2 SM,EC/ILSAC
GF-4,SAE 5W -30)
蘆SM10W. 30(API Driving
Handling
Engine SM,EC/ILSAC
device
GF-4,SAE 10W -30)
蘆SL5W. 20(API
oil SL,EC The
SAE 5W -20)
1ZZ-FE 4.0 4.2 Handling indoor
蘆SL10W. 30(API equipment
SL,EC
SAE 10W -30)
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
451
- Specified engine oil
Outside temperature
( .)
Washer Capacity
3.5
tank L(reference value)
Capacity
Fuel
[L] Nonlead regular gasoline 60
(fuel tank)
(reference value)
452
Maintenance data
Contents
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
453
Vehicle specification
ANE11W Z
1AZ-FSE
(2.0L gasoline)
FF
ANE10G G
(front-wheel drive)
Wish
ZNE10G
1ZZ-FE
X
(1.8L gasoline)
4WD
ZNE14G
(four wheel drive)
454
Maintenance data
Contents
Warning
Basic
. earliness.. operation
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
455
8
Contents
Warning
At the emergency
Basic
. earliness.. operation
Maintenance
Myriad
Oneの
と
き
Index
457
Tool, spare tire, and Tahonootsts
Storage place of jack, tool, and spare tire
- The jack and the tool bag are stored in the cover on the luggage room passenger's
seat side.
蘆The tool bag is as follows.
will confirm no embarrassment at the emergency the usage etc. of the kind and Tahonootsts
of the jack and the tool beforehand.
458
Tool, spare tire, and Tahonootsts
Basic
. earliness.. operation
Switch
Cover
Driving
Handling
device
Tool bag
2 Take out the tool bag.
Remove the hook, and take out the The
tool bag. Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
Hook
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
459
3 Take out the jack.
Spend, loosen the part of A of the
It shuts. jack, and take out the jack.
It loosens.
Tighten the part of A so that the
A
jack may fix to the bracket when you store
it.
Bracket
Do not use the jack installed by the car excluding the tire exchange and
the tire chain detaching.
460
Tool, spare tire, and Tahonootsts
When detaching it
1
Warning
The deck board installation car
detaches the central deck board.
Refer to P.340.
Basic
. earliness.. operation
Maintenance
Myriad
Attachment Oneの
と
き
Index
461
When you store it
1 Install the attachment in the wheel hole.
Have the design side of the tire up and install the attachment.
(Refer to last page. )
Do not run for a long time with the removed standard tire stored in the spare
tire storage tool. It might cause an unexpected accident and is dangerous.
462
Tool, spare tire, and Tahonootsts
Contents
car
About the prevention of tightening too much mechanism of the operation bolt
The structure that hears the sound "Catitsu" when the operation bolt is tightened by the power of
tightening torque about 40N. m{400kgf. cm} or more when the tire is stored, and doesn't shut any more. This is the one
Maintenance
by working of the prevention of tightening too much mechanism of the operation bolt, and it is not abnormal.
Myriad
Oneの
と
き
Index
463
About the temporal spare tire
The temporal spare tire is a tire temporarily used when a standard tire blows
out. Exchange it for a standard tire as soon as possible.
- Check the air pressure of the temporal spare tire. It might cause an unexpected accident because the difference
of the diameter of the tire grows further if running in the state where the air pressure is insufficient and is dangerous.
Air pressure (gage pressure) when tire is cold: 4.2kg ..420kPa {../ 袱} -
The temporal spare tire installed by the car is only for customer's car. Do not combine with other tires
and the disc wheels, do not use for other cars, and use the temporal spare tire of other
cars for customer's car. It goes out to running the adverse effect, might cause an unexpected accident, and is
dangerous.
464
Tool, spare tire, and Tahonootsts
Contents
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
465
How to use of Tahonootsts.
Storage place
It is applied it in preparation for one's passenger's seat feet.
Tahonootsts
2 Ignite.
Print medicine Ignite when rubbing with the print medicine of
the head of the cap.
466
Tool, spare tire, and Tahonootsts
Contents
Driving
Handling
Do not use Tahonootsts in the tunnel etc.View is deteriorated with
device
smoke, and use the emergency blinking light in the tunnel etc.
The
Handling indoor
Knowledge equipment
About Tahonootsts
- Use the emergency blinking light together because the Tahonoo time is about five minutes. -
There is validity term in Tahonootsts. Buy it in the Toyota shop before the validity term displayed . good.. Safety
of ・
in the main body cuts. To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
467
When breaking down
When breaking down on the road
Pull over the car to the shoulder while blinking the emergency
blinking light (Refer to "How to use of the emergency
blinking light switch" for P.292) and stop.
Use the emergency blinking light to inform another
car when the road is unavoidably parked due to the
breakdown etc.
In the road only for the expressway and the car, put
the triangle reflector or the stop display light behind
the vehicle. (It is legally obligated. )
468
When breaking down
The
When it was not possible to move on the road Handling indoor
equipment
The gear-shift 緜Yas in the person in and the vicinity.
Have pushing to the place it is. -
The car cannot be moved in the emergency . good.. Safety
of ・
evacuation by maintaining the engine switch To
theory Comfortable
with START. and
equipment
How
to attention
associate . drinking..
car
Myriad
Oneの
と
き
Index
469
When blowing out
Exchange of tires
470
When blowing out
Contents
2 Do the trig.
Driving
Do the trig to tires in the position and the Handling
corner where the jack improves. device
Do the trig in front of the front wheel when it is
necessary to lift the rear wheel to Gawa of the rear
The
wheel when the front wheel is lifted. (Figure indicates
Handling indoor
the case where a right rear wheel is lifted. ) equipment
Trig
と
き
Index
471
5 Raise the jack.
Spend the part of A of the jack in the right by the
hand and raise it to the position where the body is
set the jack.
Cutting lack
6 Put the jack on the jack set position
(During the cutting lack).
Put the jack on a jack set
position near the changed tire.
Confirm the jack surely hangs to the
position where the body is set the
jack. -
The side mudguard installation car
Jack set position prevents the jack from hanging to the
side mudguard and puts it on the jack
set position.
472
When blowing out
Contents
device
car
Maintenance
A B - Wipe dirt in A. B respect in figure off.
Myriad
Oneの
A と
き
B
Index
473
12 Tighten the nut temporarily.
Spend the nut in the right up to extent to which the tire doesn't shake by the hand and tighten
temporarily.
Remove the dirt of the taper part of the screw and the nut of the disc wheel
installation bolt and the nut (other side of the washer in case of the aluminum foil)
and the foreign body.
- Frog Nipponia nippon in the steel wheel (Include the temporal spare tire) from the steel
wheel.
Bolt Tighten temporarily until the taper part
Taper part
of the nut lightly hits the seat of the wheel
hole.
Nut
Seat
- Frog Nipponia nippon in the temporal spare tire from the aluminum foil.
Bolt Tighten temporarily until the taper part
of the nut lightly hits the seat of the wheel
hole.
Nut
Taper part
Seat
- Frog Nipponia nippon in the aluminum foil from the aluminum foil.
Bolt Washer Tighten temporarily until the washer of the
nut hits the wheel.
Nut
Wheel
474
When blowing out
Contents
Basic
. earliness.. operation
Driving
Handling
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
475
15 Install the hubcap.
Match the cutting lack to the valve
of the tire (air entrance), and install
the hubcap surely when you install
Valve
the hubcap with the steel wheel
installation car.
Cutting lack
476
When blowing out
Contents
477
A special tool is needed, and when using it by mistake because special attention
is needed for handling, the vehicle is damaged, and when the jack improves
with jacks other than the jack installed by the car, it might cause an unexpected
accident and is dangerous. Moreover, when the jack improves in Riyasaspention
(FF car) etc. , the vehicle might be
damaged.
Consult the Toyota shop when it is necessary
to use jacks other than the jack installed
by the car. Moreover, hit it to the position
where the figure below is set the garage jack Garage jack
when you use the garage jack.
FF car
The jack
cannot improve.
The front side of vehicle
Badger 狠
4WD car
478
When blowing out
Contents
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
479
When the battery goes up
What is the battery rising?
Method of treatment
It is not possible to start by the jump-start.
Request the rescue car, connect the booster cable, and start the
engine. The battery of the rescue car must use 12V.
480
When the battery goes up
Contents
Earth point
Basic
Car(battery rising car) . earliness.. operation
Bolt
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
Another car(rescue car) and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
481
To prevent the battery rising
- Do not light a lamp with the engine stopped, and do not use the
audio air conditioner etc.-
Turn off the power supply of needless electrical equipment when stopping for a long time due to
congestion etc. while the engine is rotating.
- Guard the following. It ignites, it explodes to the combustible gas generated from the battery
if it doesn't defend, important injury such as the burns might be received, and it is dangerous.
蘆潺Connected car battery drinking Do not tie to the terminal. Direct in the battery.
And the spark are generated.
蘆When you connect the booster cable Never touch the terminal.
The spark is generated if it touches it.
蘆Do not bring the fire close to the battery. -
Do not approach the battery while charging it. Important injury might be received when the battery liquid
that is contained diluted sulphuric acid might spout, and it adheres to eyes and the skins and it is dangerous. Wash with
bags of water at once, and receive the doctor's examination when you adhere by any chance. -
Do not connect the booster cable, do not touch the fan and the belt, etc. when
detaching it, and approach. It might cause an unexpected accident by the hand and clothes',
etc. being rolled and is dangerous. -
Tighten the nut of clamping surely when you exchange the batteries. It might
connect with a vehicle fire by clamping coming off while running if it doesn't tighten surely, and
shorting and is dangerous.
- The battery of another car (rescue car) should be 12V. Go after confirming
the battery for 12V. -
Receive the check in the Toyota shop when it is easy to go up in the battery.
482
When the battery goes up
Contents
Warning
Basic
. earliness.. operation
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
. drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
483
When overheating
What is overheating?
Method of treatment
1 It pulls up a car.
Make it to turning off when the car is stopped to the place of safety, and the air conditioner
is used.
484
When overheating
Contents
Driving
Cooling fan Handling
device
. good.. Safety
of ・
To
theory Comfortable
Radiator cap
Rizarbartanc
5 Confirm the circulating water flow etc.
and
equipment
Confirm whether the radiator cap is removed
How
after the engine gets cold, neither the to attention
confirmation nor the radiator core part (heat associate . drinking..
radiation part) of the circulating water flow of car
the radiator and Rizarbartanc are remarkably
dirty nor garbage etc. do not adhere.
Maintenance
Index
485
6 Replenish cooling water.
Replenish cooling water with the radiator and Rizarbartanc when the circulating water
flow is insufficient. -
Replenish water in the emergency when there is no cooling water.
486
When overheating
Contents
To prevent overheating
Always check whether there are water leakages in the amount and the ground of cooling water. Warning
Basic
Take care not to do the burn enough. . earliness.. operation
- Do not open the hood until steam doesn't occur when steam has occurred from the
bonnet. Important injury such as the burns might be received because the high temperature in the engine
room and it is dangerous. Moreover, there is a part that is the high temperature even when steam has not occurred.
Driving
Be careful enough when it opens the hood. - Handling
Do not open the radiator cap air pulling out valve when the radiator and the auxiliary device
tank are hot. Steam and the hot water spout, important injury such as the burns might be received, and it
is dangerous. Open the cap valve slowly wrapping by cutting the cloth after getting cold
enough the radiator and the auxiliary tank when you open the cap valve. - The
Do not touch the fan and the belt, etc. , and do not approach when the engine Handling indoor
turns. It might cause an unexpected accident by the hand and clothes', etc. being rolled. equipment
Do not put cooling water in when the engine is hot. When suddenly cold . good.. Safety
of ・
cooling water is put in, the engine might be damaged. Put cooling water To
theory Comfortable
in slowly after getting cold enough the engine. and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
487
About pulling
Method of pulling
When pulling it
1 Rope it.
Do not damage the body, and rope the pulling hook.
Pull it in the direction of advancement roping the pulling hook.
In the pulling rope, apply the cloth that it is white more than 0.3-meter
square (0.3m. 0.3m) to the center of the rope.
Hook for Catashiba
Pulling hook
Within about
5m about 25m
Direction of pulling
White cloth
488
About pulling
Contents
2 It starts up an engine.
Warning
The engine must start as much as possible. Make the engine
switch ACC or turn on when not engining starts.
3 Start.
Basic
. earliness.. operation
Make the pulling rope's not being made slacken, and note the braking light of the
device
previous car.
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
489
Drive the pulled car carefully.
- Drive the pulled car carefully. It might cause an unexpected accident and is dangerous
if it doesn't engine starts when driving in usually the same sense because working of the brake worsens,
and the steering wheel becomes heavy. -
Do not pull out the engine key, and do not make the engine switch LOCK. It becomes
impossible to do the steering wheel control it, is locked the steering wheel when the key has come off, might cause an unexpected
accident, and is dangerous. Moreover, the key might come off in case of LOCK. -
Do not drive the pulled car as a big impact joins the pulling hook and the rope like the jack
rabbit start etc.The pulling hook and the rope might be damaged. Moreover, the splinter hits
a surrounding person etc. in case of emergency, important injury might be given, and it is dangerous.
- Pull it with the tow car when it descends Nagasaka road. The brake overheats if it doesn't
pull it with the tow car and effective might worsen. -
Pull by four-wheel earth for 4WD car or transport it with four wheels while lifted.
Never do pulling that lifts only the front wheel or the rear wheel. Driving device
might cause burning, and the car dash out from Trekkers (truck).
Moreover, lift and transport four wheels when it seems that the drive and the system parts broke down.
- At the pulling speed, pull the pulling distance at about 30 km/h or less within about 80km in the direction
of advancement. Influence the transmission harmfully when pulling by exceed this speed and the distance
or pulling it in the direction of the junior, it is likely to damage, and lift and transport it
with four wheels by vehicle loading car etc. when you exceed this. -
Do not rope the suspension arm etc. when pulling it to another car
for the stack escape. The suspension arm etc. might be damaged. -
Do not use the wire rope. The bumper might be damaged. -
Do not forcibly pull, and request it to the Toyota shop and JAF, etc. when you stack
*. When the rope is pulled to the pulling hook and the suspension parts, etc. putting it,
the pulling hook and the suspension parts might be damaged.
- The drive wheel was not able to run idle on mud, sands, and the Miyuki road, etc. , and to move being buried and crowding.
490
About pulling
Contents
The hook for Catashiba is used to fix when ship Catashiba vehicle is
transported. Never use it for pulling. The vehicle might be damaged, and Warning
it cause an unexpected accident when using it for pulling. Another car cannot
be pulled with this car.
Driving
Handling
device
How
to attention
associate . drinking..
car
Myriad
Oneの
と
き
Index
491
When the accident happens
Do the following treatment without panicking.
492
When the accident happens
Contents
Warning
Basic
. earliness.. operation
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
493
Contents
Warning
Basic
. earliness.. operation
さくいん
. . . . . . . . . . that doesn't regret 50 tuning Driving
Handling
forks 506 ... . . . . . . . . . .. 496 warning lights
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
495
さくいん
50 tuning fork
The time that wants to be examined from the symptom and see the item of the coloring character about
the treatment at the emergency.
あ う
160 ..armrest Window
. . . . . . . . . .. washerPreparing and check . . . . . . . . of 452
Accessories..outlet. check method . . . . . . . . . . . . . of 441
.accessories..sock replenishment . . . . . . . . . . . . .
et..active..torque. capacity . . . . . . . . . . . of the liquid method
.control..auto..mo . . . . . . . . . . . of 441 jets before 288
de..operation..dis winter How to use of defogger (cloudy
play..light..auto.. remove)383 window switch . . . . . . . . . seat
mode..switch..warning belt non-wearing 344 driver's seat warning light
light..adjustable..seat . . . of 469 driver's seat SRS air bag . . . . . . .
lamp . . . . (warning light)132 warning
. . . . . . . . of lock switch . . . . . . of
い 290 windows when 262 were not able to move334
..Roaboccs . . . . . . . . . ... 278 driver's seats
belt..anchor..anti..lock.
.brake..system..ante
nna..mechanism..seat Food
belt..electronically Air conditioner
405 of 298 air conditioner gases
control..throttle..work..for..child (refrigerative) ..check . . . . . .. 405 exchange
. . . usages . . . . . . . . . . . . . .
seat..fixation..bar.. of clean air filter 360 ABS and brake
movability..ashtray. assistance . . . . . . 265 ABS& brake
.illustration..cont assistance warning light . . 266 ABS warning
ents..inner..mirror. light . . . . . . . . . . .
458 ..64 extensions . . . . . . . ..
attention . . . . . . . . . . of ABS
brake assistance, 461 344-..air bag
. . . . . . . . . . .. SRS warning light . . . . . .
of SRS air bag267 57 attention
. . . of SRS air bag 345 SRS curtain shield
air bag . . 345 SRS side air bag . . . . . . .
128 ..lever . . . . . . . .. SAE
viscosity . . . . (engine oil)452 emergencies
496
さくいん
Contents
LLC(cooling water)383
preparation and check . . . . . . . . engine か
oil before 450 winter in tank capacity and density Curtain..shield..air bag..outside Warning
......... temperature..display..exterior
451 injection entrance and 435 ..level gauge ..maintenance..exterior..lamp..va
position . . .. amount . . . . . . . . . . . . . lve..exchange..shop..hook..gasoli
of oil, When it was not possible to start n e . . f u e l . . u s e ..g a s ol i n e ..t a n k Basic
. earliness.. operation
from the room engine of 218 how . . . . . . . . . . capacity..cup..hol
to put it engines room of 218 switch der..garage..jack..environmental
. . . . . . . . . . engines of 219 procedure . . . . . . . . . protection..cold..handle..col
engines of 272 warning light . . . . . . . . . . . d..ground..for..wiper
engine of rotation meter . . . of 383 blade..key..key..latter harvest..movement..function. Driving
Handling
preparation and check . . . . . . . . engines . . . . . . . . . in
(tachometer)249 engines start which 136 keys cannot be spent 491 device
before 436 check 440 for 66 emergencies from prevention
winter of method . . . . . . . . . . . . . by
opener . . . . . . . . . . . . 484 check The
き
. . . . . . . . . . . . . . . 435 bonnet 151 engine Handling indoor
of forgetting pulling out chime equipment
stalls from which smoke (steam) has risen . 469.
. . . . . of 118 keys of bar
plate . . . . . . . of 122
お Keenan of shutting prevention
. good.. Safety
Oil function . . . . . . . of 218 keys of ・
(maintenance data). . . 450 amount tire entry . . . (smart, door To
theory Comfortable
. . . . . . . . . . . . of 66 automatic lock wireless door lock)138,140 and
transaxle of "Key key" and 122 keyless metallic equipment
attention . . . Froude Froude overheating sound ..hook
overheating of 240 automatic car of method How
. . . . . . . . . . . . .. heard value to attention
........... . . . . (maintenance data).
associate . drinking..
of 298 automatic car of 405 exchange . . . brake pad wear indicator
usages . . . . . . . . . . . . . . . . . . . . . . . . . 33 standard 448 kick car
driving of 464 auto air conditioner clean air down . . . . . . . . . . . . .
filter 450-452 temporal spare tires
............,
. . . . . when 86 attention . . . . Maintenance
overheating is done 250 ..484 Orpnarfuelriddoorpnar
. . . . 15 odometers . . . . . of attention
. . . . . . . . . . . of 148 bonnet opener Myriad
Oneの
. . . . . . . attention . . . . . . when
151 children are taken at the previous state と
き
39 going out (multiplication mileometer)..
Index
497
く さ
333 horn . . . . . . . . . . (horn)295 meter Arrangement index . . . . . . . . . . .
. . . . . . . . . . (meter)248 warning light display light
............... . . . . . . . . . . . . . 137 shade
262 warning lights in 454 glove 442 grade . . . . . . . . . . . . sun visor
name . . . . . . . . . . . . of . . . . . . . . . . . . of data . . . . . .
. . . . . . . . . . 290 horn . . . . . . . (horn)295 (maintenance data)448
creep phenomenon . . . . . . . . . . . . . ..250 184 method . . . . . . . . . . of 168
cloudy removing of mileometer . . . (trip moving up of method . . . . of 169 raising
meter) of air pressure . . . . . . . . . . and lowering . . . . . . reclining
(tire)453 sections (Riyauindudefoggar).. exchange adjustment of seat headrest of 345 side air
け し
. . . . of 66 clean air filters check bag . . . . . . . . . . thirds service Sans
. . . . . . . . . . of the circumference of 405 cars 326 sunroof . . . . . (Moon
box . . . . . . . . . . , . . . . when lighting roof)134 Shekenshalshiftomaticc . . . .
and blinking economical ..262.. driving 224 Shekenshalshiftomaticc 259 usage
. . . . . . . . . . . . mirror . . . . . . for ..............
392 make-ups (vanity) . . . . . . . . . . . 224 seat 170 third seat, 196
of 326 pulling430 of 285 retreat light lamps 154 adjustment . . . . . . . . . . . .
third 168 second in seat . . . . . . . . . . .
こ 161 reception desk in seat
. . . . . . . . . . 157 seat belt
(valve) ..exchange . . . . . . . .. top and
. . . . . . . . . . . . in seat . . . . . . . . . .
bottom of axis adjustment 458 light dial
a d ju s t a b l e of 4 2 a t t e n t i on
........
. . . . . . . . . seats per 189 how to make
488 tools . . . . . . . . . . . . . . . .
. . . . . seat of 191 how to make . . .
. . . . . . . . . . . . . . ..putting 47 small
cabin mode of 172 how to make . . . . . . Big
articles.. . . . . . . . . . . . when
of 193 how to make . . table mode of
. . . . . . . . . . 449W (wattage) breakdowns280
176 super-long space of method
..334 Conrait . . . . . . . . . . . . . ..
. . . . . . . . . . mode of 184 method . . .
attention . . . . . of seat only for 468 children
Secandoshetodablforlding storage of moving up
relaxation mode
Method of 209 278 non-wearing 51 attention
. . . . . seat belts per 358 working
. . . . . . . . seat belt of 200 seat belt
anchor . . . . . . seat belts warning light
. . . . . child seat fixed mechanism
. . . . . wearing
199-..seat belt . . . . . . . .. three points expression
202 ..expression seat belt . . . . . . . .. two points
498
さくいん
Contents
How to use . . . . . . . . . when the accident 384 ..snow tyre . . . . . (tire for
happens, the lock system of position display winter).. 428 exchange . . . . . . . light
light . . . . . . . light . . . . . . . (room switch of lamp (front position light) display Warning
lamp)326 room 326W(wattage) . . . . . . . . . . 449 light . . . . . . . . . . . . . of 232
shift 256 shifts of . . . . . . . . . 492-room Sportsshekenshalshiftomaticc 258 speed
equipment goods. meter . . . . . . . . . . of SNOW
. . . . . . . 226,229,234,237 display light . . . . . . . . . . . 249 Basic
. earliness.. operation
jacks spare tire . . . . . . . . . 458,461
458 storage position . . . . . . . . . . . . . Sportsshekenshalshiftomaticc
jack improvement . . . . . . . . . . . . . . . . . 259
Width steering wheel . . . . . . . . . . usage . . . . . . . . . . . . . . 232
83 point of attention . . . . (set position) small lamp (valve) . . . . . . 280、281 Driving
Handling
. . . . . . 471 jack 458 cars lights of jack 167 third in seat arm of 258 seconds of
improvement display light . . . . . . . . . . . of 413 device
428 exchange . . . . . . . light switch battery exchange . . . . . . slipping Wrest
of lamp (valve) . . . . . . 280、281 . . . . . . . . . . . seat of 140 W
48 ..seat . . (standard of selection).. 275 454 The
passenger's seats passenger's seats warning light of 164 getting on descending . . . . . car
. . . water temperature warning light . . . . . . . . . . . . . seat adjustment . . . . . . 280、281
water temperature warning light at 198 Console 332 of W . . . . . . . . . .
trices blinks in red Super ECT. . . . . . . . . . . 222 (wattage) ..tray . . . . . . .. 449 centers
Super C V T Maintenance
. . . . そ
About running
i. . . . . . . . . 230
When it was not possible to run . . . . . . 31 Myriad
when abnormally noticing while running of 447 Oneの
. . . . . . Super CVT i 370 371 no steps
check . . . . . . . . . . running in running doing と
changing the speed system's 370 Nobofsaca changing
noting . . . . . . . . . 22 き
the speed control system's working . . .
(About pulling. ) . . . . . . . 249
working . . . . . . working . . . . of 370 Lock-Up
..488 speedometers . . . . . (speed meter)..
system 235,238 ..SNOW switch . . . . . . .. Index
499
Handbrake (parking brake). 212 when 448
た standard value . . . . . . . . . . . .
Tire garrison stops by 246 checks ..lever . . . . . . .
442 410 rotation direction instruction mark (top and bottom of steering wheel adjustment)..
. . . . . . . . air pressure 193 34 super-long space
. . . . . . . . . . . . . . check . . . . . . . . . of of attention . . . . . . . . . mode
circumference of 453 cars spare tires
. . . . . . . . 384 ..chain . . . . . . .. て
458,461 tires, . . . . . . . of 388 tires/size
. . . . . . . tilt steering TRC
. . . . . . of wheel
. . . . . . . . . . . . . . . . . (traction control)365
tire . . . . . . . . . . . . for rotation
65 of TRC. VSC ..attention . . . . ..
. . . . . . . (tire position exchange)453
257 ..TRC OFF display light . . . . . . . ..
tire 409 winter attention . . . . . . . . of
270 warning light . . . . .
384 tires when 75 tires are exchanged . . . . .
Dischargeheddoramp of 376 system
for ..saying.. Ki (seat belt) ..correcting
. . . . . . . . . . . . Dischargeheddoramportorebering
155..196 Haco Coroshisei . . . . . . (seat)
of 294 TRC OFF switch
..correcting 249 by 470 tachometers . . . (engine
. . . . . . Dischargeheddoramportorebering
(upper and lower irradiation
ち direction self adjustment) is
rotation meter).. ..saying.. chain . . . . . . . . . . . . 449 differential oil of
(tire chain)384,388 . . 376 the W(wattage).
gear-shifts Super ECT. . . . . . . . . . 222 Light switch of mode . . . . . . . . . . .
Super CVT. i. . . . . . . . 230 450 amount . . . . . . . . . . . . . of
Child seat oil maintenance . . . . . . . . (maintenance
Fixation . . . . . . . . . . . with of car)400 table 172
bar & Topptezarancar only for the child taillights (taillight) . . . . . . 280、281
seat fixation for ISOFIX attention W of dual SRS air bag . . . . . . of 337 of
. . . . of the seat only for 205 children deck hook . . . . . . . . . . . . of 344 lamps
fixation . . . . . . . by 47 seat belts standard (valve)(watt) number . . . asking for standard
. . . . . . . . . of 209 selections How value . . (maintenance data)449 check
to use of 48,198 child protector . . . . . . . . . . (daily check)434 check 448 maintenance
. . . . . . . . . . . . . . execution . . . . . . . . . attention
. . . . . . . . . . . when parking 121427,429 ..292 light . . . . . . . . . when 14 checks and maintaining it 73
(emergency blinking electronically controlled throttle (ETCS i). 328
light)390 parking switch . . . . . . . . . . . . . ..down light . . . . . . . .. 369 ceilings LED
lamps (valve).. ..exchange . . . ...
245 of W . . . . . . . . . . (wattage)449
parking ..method . . . . . . . . . . . . ..
500
さくいん
Contents
と な
Door 434 ..inside and outside nature switch (air conditioner).. Warning
374 tool . . . . . . . . . . . . . . equipped maintenance . . . . . . . . . . . . of . . . . . 304
with 119 458 anti-theft system . . . . . . . . . .
of 214 129 door mirror に Basic
.............
interiors eternal check . . . . . . . . . . . . . . for 404 . earliness.. operation
of glass opening and shutting . . . . . . . . . . . . . . .
days Reception desk window with expression seat belt
of . . . . . . . . of 122 doors door
locks . . . . . . . . . . . . . clocks
. . . . . . . . . . . . . . . . 368 of opening and shutting Sleep
. . . . . . . . . . . . . . . ..changing the . . . . . . . . . two point 202 heat ray Driving
Handling
speed control system . . . . .. to have kept sounding 291 shield glass switch . . . . . .
, saying that "Pepe and Pepe" when 116 doors fuels device
are opened 329 Nobofsaca, 250 20 at 277 fueling 148 fueling at entrance . .
..meter . . . (section mileometer).. 450 amount (Fuelrid) ..attention . . . . . . . . . . ..
The
............. remainder amount warning light . . . . . . . . . .
of oil oil of amount . . . . . . . . . . . . of 452 tank capacity . . . . . . . . . . . . Handling indoor
equipment
of Froude Froude 371 transaxle 450 transfers trip fuel gauge . . . . . . . . . . . . . . 249 fuels
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
501
Number-plate light
は Light switch . . . . . . 280、281
256 426 exchange . . . . . . . headlamp upward 277 warning light . . . . . . . . . . . .
display light . . . . . of method steering wheels of W . . . . . . . . . . (wattage)449
. . . . . . . . . . . . . of operating 331 high beams half doors
(headlamp) of 36 ashtrays . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . at 24 and 32
of attention blowouts of adjustment . . . . . . . . . . . . of
. . . . . . . . . to 448 246 parking brake pedal position that became heavy 212 steering wheels Blinking
. . . . . . check standard value . . . . . . . . . . . . 222,228,230,236 . reverse (retreat)
vehicle exhaust emissions of 282 buzzer . . . . . . . . emergency ..repetition of
lamps (valve) 427,429 ..292 lamp (emergency . forgetting to pull out key prevention chime
blinking light)W (wattage) . . . . 122 "Pepepe" and long ..repetition.. sound of
. . . . . . . . . . 449-hazard switch . . . . . . . . . . . . . . forget light cancellation warning buzzer
lamps (valve).. ..exchange . . . .. . . . . 281 "Pepe and Pepe" long ,
The prevention mechanism placing W . . . . . . . . . . saying that 470 "Pe" to keep sounding and short
(wattage)449 and crowding.
How to use . . . . . . . . . . . Lamplight
. . . . . . . . . . 449-430W of exchange
sounds.. light
. . . . . . . of lamp (retreat light)466 backup
427,429 ..292 switch . . . . . . . . . . . . .
lamp (valve)(wattage) backing
lamps (valve).. ..exchange . . . ..
door of Honootsts. 130 Moon in power window
191 cabin mode . . . . . . . . of
. . . . . . . . . 136 on roof
W . . . . . . . . . . (wattage)449 Big
...........
light
Before 81 attention . . . . . . winter
Light switch . . . . . . 280、281
per . . . . 480 battery 438 batteries' of
. . . . . . . 326 ..avoiding (sun visor) for
method . . . . . . . . . . . . . of checking 378
254 days of 415 fuse . . . . . . . . . . . . . .
glass
display light . . . . . . . . . . . . . . . ..
. . . . . . . . . . batteries with 124 water-repellent
function of 128 emergency lever . . . . . .
opening and shutting . . . . . . . . . . . . . . .
going up, Froude Froude 450
of 132 power steering warning light . . . . . .
of . . . . where 129 power window
doesn't move of 131 window W of wear indicator
. . . . of 383 preparation and check . . . . . . . .
pads (brake
pad wear indicator)33 vanities (for make-up)
mirrors . . . . . . of 326 valves (lamp)(watt)
number . . . initialization
. . . . . . . . . . . . . of 449 power switches
. . . . . . . . . . . . . ..amount
. . . . . . . . . . . . .. 269 power steerings
502
さくいん
Contents
ふ へ
Attention..warning 251 fuel cost . . . . . . . . . . . . . . 251 Warning
light..belt..ch velocity . . . . . . . . . . . . . . of average car
eck..standard..value..force averages headlamps
limiter..mechan . . . . 424-426-exchange light switch of
ism.. 256 upward display light . . . . . . . . . . . Basic
. earliness.. operation
hook..pull..fuel..cap..opening lamps (valve) . . . . . . 280、281
a n d Adjustment of W . . . . . . . . . .
shutting..fuel..meter..fuel (wattage)449 headrests
gauge..fueling..entrance..opening 427,429 ..instruction light of 470 exchange
a n d . . . . . . directions lamp of 458 nut wrench Driving
Handling
shutting..winter..ahead..p . . . . . . . . of 453 wheels of size
reparation..check..wi . . . . . . . . . . . of 159 baby 48,198 wheel in device
nter..for..tire..pret
ensioner..mechanism..p ほ The
retensioner..warning
seat . . . (standard of selection) of 169 second
light..brake..assista Handling indoor
in third seat . . . . . . . . . . . 163 reception equipment
nce..brake..warning
desk in seat . . . . . . . . . . seat
light..brake..pedal..che
..........
ck..stan
wheels (tire)(valve).. ..exchange . . . ..
dard..value..brake..p . good.. Safety
. . . . . . . . . . . 484 from which smoke of ・
ad..wear..indicator..b To
(steam) has risen from holder . . . . . . . . . . .
rake..Fro theory Comfortable
284W of instruction lever and
ude..check..method..tank..position. equipment
. . . . . . . . . . of 256 direction instruction display
light . . . . . . . . . . directions (wattage)
Capacity..brake..step..k How
. . . . . . . . . . 449 phon . . . . . . . to attention
ey..key..sound..d
c. . . . . . . 295 bottle 335
o..Flex..Lock-Up..system..reception associate . drinking..
bonnet . . . . . . . . . . . . . 151 bonnets
car
desk..seat..arm..Wrest
..seat..
adjustment..method..h
eadrest..adjustment..
Maintenance
method..reception
desk..personal..lamp..wa
ttage..reception desk..fog
lamp..lamp..val Myriad
ve..exchange..wattage..reception Oneの
d e s k . . f o g と
lamp..display..light. き
Index
503
ま ゆ
Illuminance adjustment button 276-..warning light . . . . . . . . . . . . . ..
. . . . . . . of 248 meters of 134-meter 137 roof
initialization . . . . . . . . . . . . . of よ
oil
み pressure 4WD . . . . . . . . . . . . . . .
changing the speed (active torque control 4WD)372 271
216 no steps system . . . . . . . . . . of 4WD warning light . . . . . . . . . . .
214 mirror heater . . . . . . . . . . of 213 70 of 4WD car ..attention . . . . . . . ..
door mirror . . . . . . . . . . . . of
む ら
adjusting inner mirror . . . . . . . . . . of License plate lamp (number-plate
..multibox . . . . . . . . light) light switch . . . . . . 280、281
(with cup holder & coin pocket).. 281 warning forgetting cancellation W
attention . . . . . . . . at accident of 3,340,001 . . . . . . . . . . (wattage)449 lights buzzer
. . . . . . light switch . . . . . . . 280、281
め When overheating by 340 luggage in luggage
box . . . . . . . . . . 328W of room
of 87 mirrors of 370 Moon switch
lamp . . . . . . . . (wattage)
............. ..............
. . . . . . . . . . 449
448 ..data . . . . . . . . . .. 253 maintenance
radiators, buzzer . . . . . . .
435,436 . . . . . 484 tank cap position
. . . . glasses of cooling water 450
り
reverse (retreat) in density
and capacity . . . . . . . . .
222,228,230,236 Riyauindudefoggar . . . . .
290 Riyadifarenshaloil.
How to make . . . . . . of . . . not
opened 121 relaxation mode 326 in the car 450
Riyadoa of amount . . . . . . . . . . . . . of
る
oil ..lamp . . . . . . . (interior light)..
mirror . . . (inner mirror)189 room 213 rooms
. . . . . . . . . . 449 ..the W(wattage)...
504
さくいん
Contents
れ わ
Cooling water 402 411 wax . . . . . . . . . . . . . . of Warning
. . . . . when overheating 424,425 ..low battery exchange . . . . . . . . of 286
435,436 Rancriaringmirar . . . . . . at wireless door lock . . . . . . . . of wiper &
383 Rizarbartanc 484 check method washer . . . . . . . of 138 remote controls
. . . . . . . . . . . . . 439 density and capacity W (watt)449 ..number . . . . . . . . . . . .. Basic
. earliness.. operation
. . . . . . . . . . . . preparation and
checks . . . . . . . . before 450 winter
Furnace
Driving
positions . . . . 377 beam Handling
(headlamp) lamp (valve).. ..exchange . . . .. device
. . . . . . . . when breaking down on
W . . . . . . . . . . (wattage)449 roads
468 Lock-Up system . . . . . . . . 120 The
..lever . . . . . . . . . . . . .. 370 locks
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
505
Warning light
SRS air
bag/pretensioner warning Charge warning light P.275
light P.267
VSC VSC warning light P.268 Oil pressure warning light P.276
Dischargeheddoramportorebering
warning light Half door warning light P.277
P.270
Passenger's seat
Engine warning light P.272 seat belt non-wearing
warning light P.278
506
さくいん
Contents
Warning
Basic
. earliness.. operation
Driving
Handling
device
The
Handling indoor
equipment
. good.. Safety
of ・
To
theory Comfortable
and
equipment
How
to attention
associate . drinking..
car
Maintenance
Myriad
Oneの
と
き
Index
507