Professional Documents
Culture Documents
Problem 1. (20 pts) The preliminary design of a large shaft connecting a motor to a generator calls for the
use of a hollow shaft with inner and outer diameters of 4 in. and 6 in., respectively. Knowing that the
allowable shearing stress is 12 ksi, determine the maximum torque ( Unit: kip. in) that can be transmitted:
Answer:
1
Answer:
2
Problem 2. ( 20 pts) The horizontal shaft AD is attached to a fixed base at D and is subjected to
the torques shown. A 44-mm diameter hole has been drilled into portion CD of the shaft.
Knowing that the entire shaft is made of steel for which G=77 GPa, determine the angle of twist
at A.
Answer:
3
Answer:
4
Problem 3.(20 pts). A steel shaft and an aluminum tube are connected to a fixed support and to a rigid
disc as shown at the cross section. Knowing that the initial stresses are zero, determine the maximum
torque T0 that can be applied to the disc if the allowable stresses are 120 MPa in the steel shaft and 70
MPa in the aluminum tube. Use G=77 GPa for steel and G=27 GPa for aluminum
Answer:
5
Answer:
6
Problem 4. (20 pts). Two steel plates have been welded together to form a beam in the shape of a T that
has been strengthened by securely bolting to it the two oak timbers shown. The modulus of elasticity is
12.5 GPa for the wood and 200 Gpa for the steel. Knowing that a bending moment M =50 kN . m is
applied to the composite beam, determine (a) the maximum stress in the wood (b) The stress in the steel
along the top edge.
Answer:
7
Answer:
8
Problem 5: (20 pts). The double-web girder is constructed from two plywood sheets that are secured to
wood members at its top and bottom. The allowable bending stress for the wood is σ all=8 ksi and the
allowable shear stress is τ all=3 ksi. If the fasteners are spaced s=6∈. and each fastener can support 600
lb in single shear:
GOOD LUCK
Answer:
9
10