6-44
Windshield Wipers
GMC HYDRAULIC
GMC Motor Home.
DESCRIPTION
‘Mator home uses 0 variable speed hydraulic wiper system with
washers or stondord equipment. Mator is mounted to bracket
fon left side of vehicle in front of drivers toe board. The
hydraulic motor is powered by power steering fluid from dis:
charge side of power steering pump. Windshield wosher reser
voir and pump ore combined into one unit
REMOVAL & INSTALLATION
WASHER & PUMP ASSEMBLY
Removal ~ Disconnect bottery ground cable and then dis
connect two wire leads to washer motor. Disconnect hose at
Fear of washer reservoir, Lit reservoir from bracket ond
remove from vehicle.
Installation — Position reservoir in bracket and install two
wires to terminals on motor. Connect hose to back of reservoir.
Connect battery ground cable and check unit for proper
3GMa01
To Power
Steering Pump
WIPER MOTOR HOSE CONNECTIONS
PIVOT SHAFT & LINK
Removal — Remove wiper arms from pivot shafts by remov
ing plastic caps, retaining nuts and then wiper orms. Remove
Tinkage from wiper motor crank arm by sliding back clips
[away from motor). Remove thvee bolts from pivot shaft moun
ting bracket ond remove assembly
Installation — To install, reverse removal procedure,
WIPER MOTOR
NOTE — Windshield wiper motor is serviced os on ossembly
Do not attempt to repair the motor.
Removal — Disconnect hoses ot motor and tope ends of
hoses 10 prevent loss of fluid or entrance of dirt or water into
system, Loosen cable retaining screw at bottom of motor end
Femove pin from arm on motor assembly, Remove connector
forms by sliding back clips and disconnecting arms from motor
Remove belts securing motor te bracket and remove from vehi
de
Installation — To install, reverse removal procedures while
noting the following: When installation completed, check
ower steering fivd level, operate wipers on o wet windshield
‘ond recheck fluid level. Check hose connections for fluid leaks.
3Gmao2
Connector Arm
Motor Cra
‘Wiser Motor
Cable Retaining
‘Screw
REMOVING LINKAGE
‘ipo 200 Rapa ema Campa