Professional Documents
Culture Documents
Final Thesis
Final Thesis
Merging of Electric Generators: Solar Panel, Wind and Water Turbine with Water
Constantino, Marian B.
Cruz, Bingbong R.
March 2018
Merging of Three Electric Generators 2
BACKGROUND
This chapter expounds the information regarding the researchers’ topic “Merging
of Electric Generators: Solar Panel, Wind, and Water Turbine with Water Purifier and its
Effectivity as a source of Electricity and Potable Water”. These include the rationale of
the problem, setting of the problem, literature foundation, and seriousness of the problem,
general objective, and general purpose. Importantly are the statement of the problem,
scope and delimitations, significance of the study, and notes of the researchers.
Introduction
of electrical power or charge. Electricity is both a basic part of nature and one of the most
widely used forms of energy. Every individual consumes electricity for communication,
our daily living. But in the present time, electricity became scarce in the Philippines
through its increasing population and the water became contaminated and polluted. The
generator and water purifier. First, they create an alternative generator that uses
metals, solar panel, wind turbine, water turbine and direct current motor (DC motor) in
order to generate electricity. Then the alternative water purifier that turn rain into well-
Merging of Three Electric Generators 3
purified and potable water. It will help people in remote areas in particular in Barangay
Caysio, Sta. Maria, Bulacan with their electrical and water consumption.
their energy from existing flows of energy, from on-going natural processes, such as
sunlight, wind, flowing water, biological processes, and geothermal heat flows.
Renewable energy is clean source of electricity which has a good impact to the
Today, our world is facing major environmental problems. Climate change is the
most urgent environmental threat facing people and the planet. The greenhouse gases
responsible for it come from human activity. The most important of these gases is carbon
dioxide (CO2) which is pushing up average temperatures at the Earth’s surface, leading
to more severe weather events – floods, droughts and storms, as well as rising sea levels
and disruption to entire eco-systems. The impact on people across the world could be
To avoid dangerous changes to our climate we must curb rising global emissions
of CO2 within the next decade. As well as doing everything we can to save energy and
use it more efficiently, we need to switch to forms of energy that do not produce CO2 and
there are plenty of them. Renewable energy come from sources that don’t run out like the
sun, wind, tides, waves or plants. These natural sources can be harnessed to create
(https://www.foe.co.uk/sites/default/files/downloads/renewable_energy.pdf). The
researchers give emphasis on using solar energy, wind energy, and hydropower as source
of electricity.
Merging of Three Electric Generators 4
Solar energy is the cleanest and most abundant renewable energy source
available, and the U.S. has some of the richest solar resources in the world. Modern
technology can harness this energy for a variety of uses, including generating electricity,
providing light or a comfortable interior environment, and heating water for domestic,
Wind energy is now the second fastest-growing source of electricity in the world,
with a global installed capacity of 432,883 megawatts (MW) at the end of 2015. Wind
power utilizes energy in wind and turns it to electricity with the help of wind turbine.
Hydropower is one of the lowest cost forms of energy as it requires no fuel; this
by processing and controlling the flow of water through a dam. This is one of the most
According to Republic Act No. 9513 otherwise known as Renewable Energy Act
energy resources such as biomass, solar, wind, hydropower, geothermal and ocean energy
sources, including application of hybrid systems and other emerging renewable energy
technologies in the Philippines for the generation, transmission, distribution, and use of
unpreventable. One of the reasons of this shortage is too much population and limited
supply of energy from power plant such as Calaca 1, Malaya 1, QPPL, GN Power 2,
converts direct current electrical power into mechanical power. The most common types
rely on the forces produced by magnetic fields. Nearly all types of DC motors have some
direction of current flow in the parts of the motor. Most types produce rotary motion, a
linear motor that directly produces force and motion in a straight line. The DC motor will
serve as an alternative source of electricity because it will help the device to generate
electricity. With the use of renewable energy the DC motor will convert electrical energy
to mechanical energy.
This device has another feature that will help people or family in water
conservation and purification in remote areas in particular Barangay Caysio, Sta. Maria,
undesirable chemicals, physical contaminants, and suspended solids from the raw water
to make water safe for drinking. In short, water purification ensures that the water you
drink is free of contaminants and fit for consumption. The water supplied to our homes
come from various sources and is not fit for consumption. Without proper purification,
filtration, sedimentation and distillation help in purifying raw water to make it fit for
consumption.
The researchers selected Barangay Caysio, Sta. Maria, Bulacan as the location of
the research being undertaken because Barangay Caysio is housings and Bulacan is the
most populous municipality in Central Luzon and the 5 th most populous in the
(https://www.revolvy.com/topic/Santa%20Maria,%20Bulacan&item_type=topic).
Because of its large number of population, they need more supply of electricity for their
daily living.
As stated by Gonzales (2017), the Luzon power grid was placed under “red alert”
status on April 10, 2017 in the afternoon due to insufficient operating power and high
system demand. In an advisory, the National Grid Corporation of the Philippines (NGCP)
said available capacity was set at 9,300 megawatts compared to the peak demand of
9,370 MW. Red alert translates to high power deficiency, which means that electricity
reserves were below the minimum level. NGCP, the agency in charge of the country’s
transmission superhighway, declared the red alert from 1 p.m. to 3 p.m. It was an upgrade
from the “yellow alert” it declared on Monday morning from 9 a.m. to 4 p.m. The NGCP
also assured the public that their power transmission services remained “stable” despite
the 5.4 magnitude earthquake that hit northern Samar on Monday morning. “Power
transmission services of NGCP remain normal despite the 5.4 magnitude earthquake
which occurred 89km Northeast of Mapanas, Northern Samar at 8:43am today, 10 April.
The grid remains intact as there had been no reported cases of power interruptions and
Previous news shows that there is a possibility of sudden shutdown of power plant
electricity become more often and it is really a problem not only to the consumer but also
Merging of Three Electric Generators 7
to the suppliers. Knowing that the widest used sources today is non-renewable energy
which has a definite end; it could be a big problem to supply electricity all over the
country in the near future. Since the non-renewable energy is limited, the only thing that
could be possibly resolved and lessen the problem is to embrace the renewable energy
because these kinds of energy are sustainable, can generate endless electricity, and no
harmful effects to the environment. That’s why the researchers conducted a research and
came up with a device that will serve as a prototype that proves the effectiveness of using
renewable energy.
The researchers want to know how this device can resolve electrical problems and
shortage and produce well-purified and potable water in remote areas in particular
Barangay Caysio, Sta. Maria, Bulacan. Moreover, researchers want to know the
efficiency level of this device and recognize the benefits of it. Lastly, researchers want to
At this avenue, the purpose of this study is to give the people an idea on how the
alternative generator and water purifier would help them to save money, to improve
living standards, conserve water and electricity without harming the environment. This is
also for the purpose of producing well-purified and potable water and generating
The objectives of this experimental study is to analyze how this device can help
the people in remote areas in particular Barangay Caysio, Sta. Maria, Bulacan and to
3. In what way does this device will become valuable for people in remote
areas?
This study was focused on creating a device that can help people in remote areas
in particular Barangay Caysio, Sta. Maria, Bulacan during electricity shortage, electrical
problems and its effectivity as an alternative source of electricity and potable water.
Specifically, the study will be focusing on producing well-purified and potable water
through the alternative water purifier and merging three alternative electricity sources
which are solar panel, wind turbine, and water turbine. It also studies the electricity
made questionnaires and observation checklist regarding the efficiency of this device.
The study considered remotes areas in particular Barangay Caysio, Sta. Maria,
Bulacan as the research locale of the experimentation because it has massive population
Merging of Three Electric Generators 9
that needs supply of electricity when there is electrical problems and shortage and wants
The limitation of this study is; it will be focusing only in merging the three
The analysis and findings of the study may provide more valuable understandings
on how we can generate endless supply of electricity out of renewable resources and
producing well-purified and potable water through the alternative water purifier. The
Environment, this device can help lessen the harmful effects of using electricity
and it may decrease pollutions because of its renewable sources. In addition, it will help
Community, this can boost public health of the community. It will also help to
save money because there will be no payment needed. If this device would be patronize
by the community it may lead to job creation. Moreover, it will result of having clean and
Squatters, this device will help them to have supply of electricity without paying
any amount and be an alternative source of electricity when there are electricity problems
and shortage. Also, having clean and free purified water came from the alternative water
purifier.
School, this device will be motivate the institution to influence its students to give
their interest and support in embracing the renewable energy and conserving water.
Merging of Three Electric Generators 10
Students, this may help them to recognize the benefits of supporting and using
STUDIES
studies and conceptual framework in which the researchers have emphasize on the topic
undertaken.
Theoretical Framework
resources are allocated in the most efficient manner, and it is obtained when a distribution
strategy exists where one party's situation cannot be improved without making another
party's situation worse. Pareto efficiency does not imply equality or fairness.
Water is very important to our daily lives and our body really needs it. Electricity
is the cornerstone of modern life. One of the purposes of our alternative water purifier is
to produce clean and free purified water and the alternative generator is designed to
generate electricity through renewable energy. Both of them are not wasting any
resources which implies the Pareto theory; showing that every water and electricity that is
which amounts to describing what makes them “options,” and then what makes them
Merging of Three Electric Generators 12
understanding the theory’s origins and boundaries and in developing and testing relevant
hypothesis. An option is a right, but not an obligation, to take some future specified
action at a specified cost. At its core is a fundamental decision asymmetry to take a future
decision (e.g., invest) only if it’s beneficial to the decision maker, but not otherwise. In
some organizational contexts, certain rights might be established through contracts (e.g.,
that a firm possesses (e.g., through learning by doing or research and development
(R&D).
Myers (1977) coined the term real options and envisioned bringing the theory of
financial options to the realm of strategic decision making. Real options were seen as
investor has the right to act to acquire a financial security (e.g., shares of stock) as the
underlying asset, yet in real options, the underlying is a “real” asset. Incremental cash
flows are tied to the construction or scale up of a plant, the development of a product in
The real options theory is suited to the study being undertaken because our study
is the best option or choice for investment. The more we invest in conserving water and
renewable energy, the more water we can use through the next generations and more
Merging of Three Electric Generators 13
renewable energy projects we can be able to do. Hence, we can conserve more water in a
better way and produce electricity with less generation charges. In addition, this theory
will help the researchers to patent their prototype and bring out it in the market in the
near future.
the needs of the present without compromising the ability of future generations to meet
their own needs. The sustainable development has three aspects: economic,
debt, and to avoid extreme sectoral imbalances which damage agricultural or industrial
functions, and depleting non-renewable resources only to the extent that investment is
stability, and other ecosystem functions not ordinarily classed as economic resources.
provision of social services including health and education, gender equity, and political
The sustainable development theory is fitted to our study because one of the
objectives of our study is to develop an alternative water purifier that helps in conserving
Merging of Three Electric Generators 14
water and alternative generator which use renewable energies as source of electricity. The
researchers hope that this will be the eye opener from the government or even people in
Organizational Theory
to identify the patterns and structures they use to solve problems, maximize efficiency
and productivity, and meet the expectations of stakeholders. Organizational theory then
uses these patterns to formulate normative theories of how organizations function best.
Therefore, organizational theory can be used in order to learn the best ways to run an
organization or identify organizations that are managed in such a way that they are likely
to be successful.
projects, we must consider the organizational theory. In the Philippines, there are lot of
organizations to make clear plans on how their companies or organizations will be the
Related Literatures
Philippine’s electricity like the high electrical bills, sudden electrical blackouts and
outages. People living here and even the foreign who visit Philippine deal with these
kinds of problem. In addition, the government also handle problem about electricity in
which they spend money for foreign trade in fixing such problems.
For the Philippine government and United Nations, installation of solar panel to
the country is good solution to the problem. This solution would help to decrease the high
electrical bills and lessen the sudden blackout and outages. It will also help to lessen the
money spent in paying electricity. It is really good solution because it can sustain enough
power to supply the country and if in the longer time, Philippine will no longer need to
pay electricity and also we don’t have to depend to the other countries. This solution
might not be good to other countries but it would be better to the Philippines.
According to Simeon and Rivera (2017), the East Zone Water Concessionaire
Manila Water Co. Inc. and the Department of Energy (DOE) assured Metro Manilans for
enjoying the summer without worrying about supply shortage and power interruptions.
comfortable level and will not trigger any water shortage in the next few months. The
level of Angat Dam is six meter higher than the same period last year. This result is an
indication for no tightness or shortage of supply. Last summer, the country suffered from
Merging of Three Electric Generators 16
the effect of El Nino phenomenon which affects the water supply throughout Metro
Manila and nearby areas. Sevilla, Manila Water spokesperson said that water supply was
affected throughout Metro Manila and nearby areas. He clarified that the outlook might
change depending on the changes of summer season and rainy season. On the other hand,
the DOE is banking on demand-side management to get by summer without any power
The literature states that there will be no any power shortage in the summer
seasons, but this kind of good news doesn’t last for a long time. There will be always
possibilities of having shutdown. The Angat Dam is in a good state but like in the last
summer, many people suffered from water interruption. One of the reasons is because of
the effects of El Nino. This phenomenon can be lessening by using renewable energies
which has good impact to our environment. In our research, we are focusing on relying to
energy source like renewable energy. If there will a continuous use of fossil fuel, we
might suffer from power interruption in longest time. Furthermore, in this case of water
interruption, our device will takes place in supplying either ordinary water or potable
water.
will be affected due to maintenance of Meralco from Saturday to Sunday. On June 24, lot
of buildings will experience power outage due to line rehabilitating work. On June 25, the
following areas will be affected by the preventive maintenance and testing work.
As this literature stated, there will be a coming shutdowns in parts of four cities in
Metro Manila. This shows that outages are not unusual especially to those who use
Merging of Three Electric Generators 17
electricity from fossil fuel. Outages are not avoidable since the non-renewable energy
have a limited source only and experience maintenance shutdown often. But when we use
renewable energy, shutdown can be lessening because it is in every household who will
According to Bongcac and et al. (2017), eight provinces of Visayas has been
trigger due to 6.5 magnitude earthquake in Leyte. The affected areas are Cebu, Bohol and
other provinces in Visayas -Leyte, Southern Leyte, Samar, Northern Samar and Biliran.
The system automatically shut down if something abnormal is detected results to the
shutdown to occur at 4:03 p.m. but at 5:01 p.m. the power was fully restored.
This literature shows that the different calamities such as earthquakes, floods,
landslide and typhoons may affect the supply of electricity. In this article, earthquake that
hit Leyte causes eight provinces to suffer from brownout. It also shows that we cannot
avoid this immediate brownout because these provinces only get their supply of
electricity in one source of distributors. But when they have their own source, it would be
powerhouse of renewable energy wouldn’t be easy. Since the Renewable Act of 2008
passed the law, there are now 406 from 22 projects of renewable energy said by Juan
Miguel Zubiri. It was also said there that because of renewable energy, there’s about 3
million jobs for engineers and construction workers which is a sign of a booming industry
oppose the embracing of renewable energy though we could save more money with
renewable energy. Leandro Leviste, founder of Solar Philippines believed that the solar
energy can be affordable source of energy and instead of relying in dirty fossil fuel; we
This literature states that building a new source of electricity in the Philippines
such as renewable energy is not an easy step. But everyone knows that renewable
energies are better than currently using source. The researchers came up in creating an
easy to make device that will somehow show everybody how renewable energy really
become a good source of electricity. Like in our research, we foresee the increase of jobs
for engineers and construction workers. This literature is also the same as our research
when it comes to what is the goal. We believe also in embracing renewable energy can
the Philippines. They are expected to seal another investment deal involving renewable
energy. It’s not hydro, but still they are looking for other potentials. AC Energy had an
wind farm there. It is the first green offshore investments of AC with the other country.
As the researchers begin the research, like in AC Energy we are not stopping, we
continue to seek for more, that’s why we ended up combining three different renewable
energy sources because we know Philippines has a big potential in having an installations
of renewable projects. But in this literature, they focus in investing to other country
instead of investing to our own and produce more projects here in the Philippines.
Merging of Three Electric Generators 19
As cited again in Rappler.com (2014), the World Wide Fund for Nature stated
that renewable energy is the best long term solution to power crisis. Being the second
largest archipelago, Philippines would have difficult time in connecting all islands in grid
power supply and installing solar panels would make these islands self-sufficient.
Renewable energy must be the primary solution to power development and the
Philippines can learn from its own experience in renewable energy to prove that it is the
best. Much renewable energy is easy to be installed and produce a stable rate, not likely
to fossil fuel which may increase in cost in the next years. Department of Energy (DOE)
expected a shortfall in power supply which may affect the peak load. Other indigenous
renewable energies like hydro and biomass can be used to complement the existing
based-load.
This literature believes in renewable energy as best long term solution for power
crisis. It also said that because of archipelagic country which the second largest in the
world, it is difficult to connect every island. Because of this, our device is suitable to
every Filipinos since it is very affordable and reliable. The literature only focuses to solar
panel installations, but with the merging of three renewable energy sources, it might help
a lot and can generate more electricity. Using this evidence can help every Filipinos and
have a good effect to the environment. The researchers believed that renewable energy is
Philippines’ largest solar power project has begun. The project is one of the Southeast -
Asian’s largest solar farms where in 450,000 Solar panels will be installed across 150
hectares and it will be manufactured locally. The project costs an estimated 195m and
Merging of Three Electric Generators 20
produce enough power to supply the entire province’s need. This project shows that
building renewable energy sources costs lower than a coal based power plant, this will
help to achieve a greater energy security since the country is just like the other countries
(http://www.climateactionprogramme.org/news/the_philippines_pursues_renewable_ener
gy_expansion).
It was said that the Philippines has a plan of expanding renewable energy. There
will be a project of building 450,000 solar panels in 150 hectares. This shows that
building this kind of electric generators will cost lesser amount. As we do in our study,
also know that as the time passes by, the demand of electricity is getting higher because
of the increasing population. This renewable energy will secure our electricity supply for
Solar energy
An article written by Rivera (2015), states that experts believed that Philippines is
more than ready to join the world wide revolutionary of solar energy. Since the
Philippines is located at tropical zone, it has a strong potential in harnessing solar energy.
aside that adapting solar energy system is not that hard. Building solar energy system
should have proper infrastructure, maintenance and connection to make it work. Using
solar can be much greater that fossils fuels, hydro and wind as a source of electricity.
Merging of Three Electric Generators 21
The literature shows that the Philippines is ready to the revolutionary, one reason
why we conducted a research creating a device which use renewable energies like
hydropower, solar and wind energy. Since we are archipelagic country, this device is very
suitable to everyone. Unlike the usual source of electricity, every consumer has one
supplier only, if something happened and that source has been damaged, it may affect all
the consumers. But if every household has their own device, they don’t have to depend
to other source.
As stated by Lozada (2016), after super typhoon Yolanda hit the Philippines; it
left a severe damage to the country. In Iloilo, a 41 year old fisherman told everything him
and his co-workers they have experienced. His house was made of light materials that are
why their supply of electricity was also damaged including the most part of the province.
It would take 3 months before the electricity was restored in their area. The good thing is
the BBMA organization was the beneficiaries of solar panels. Fishermen used to buy
kerosene for electric generators, but because of renewable energy they just have to use
the money to other more important purposes. The solar panels helped them as they
This shows that renewable energy is very useful to everyone. Like in our device,
it is also useful for a calamity. We all know that we often experience typhoons and every
typhoon leaves a severe damage to any part of the Philippines. One of the damages is the
electric supply. After a powerful typhoon hit, it may leave some electrical post broken
down in the street resulting to an outage. Clearly this device can help become a solution
to that problem`.
Merging of Three Electric Generators 22
Hydropower
An article written by Magno (2017), said that renewable energy shared at least
26.44 of the country’s total power production from different renewable energy sources.
The plan of National Renewable Plan (NREP) is to triple our renewable energy
production sources we could make it even earlier. There are several factors that can help
us grow like we’ve been the world’s second largest producers of geothermal. The good
news is the technology producing energy from renewable energies progressed for the past
few years. Since we are archipelagic country, we opt to create mini hydro powers plants
unlike China which has three George Dam built. Instead building large capacity
hydropower plant, we could build many mini hydro power plants will be more
The techniques stated in the literature is the same as our device used. Because the
archipelagic location of the Philippines and there are thousands of island which are
surrounded by different bodies of water, creating mini hydro power is a better choice.
That’s why we included hydro power to our prototype because we know what kind of
According to Adriano (2017), there will be two more hydropower plants planning
to build in towns of Solsona and Nueva Era. Engr. Neil Guillen and Mirable May Perez,
Sanguiang Panlalawigan members to seek their support for this project. The said places
have potential sites for run-of- river type hydroelectric power development project. This
kind of power plants is cheap and clean unlike the wind power farms which need a black
Merging of Three Electric Generators 23
start power from the National Grid Corporation of the Philippines (NGCP). Hydropower
plants generate power depending on the volume of rain fall that flows down the river.
Knowing that the Philippines has a potential for hydro powers because of having
prototype. Like in our device, our hydro power also depends to the flow on rainfall, if the
Wind energy
According to Bautista and et.al (2017), Wind turbines are helping the Philippines
diversify its energy sources beyond fossil fuel and generating not only power, but jobs,
revenue and interest among thousands of union tourists. Wind power is slowly taking off
in the Philippines, which faces a huge challenge to find cheaper, cleaner and more
efficient ways to power what are one of the world’s fastest growing economies and
swelling population of over 100 million people. Creating wind turbines also supports
livelihoods like making wooden souvenirs of mini turbines. Wind energy is a work in
progress and farms like this produce only a fraction of the countries installed capacity.
As we conducted the research, we foresee the possible help we could get from
renewable energy. Aside from energy resources, we could create more jobs and
investments. The researchers included water turbine in creating this device because it is
geothermal, hydroelectric, and biomass provide substantial benefits for our climate, our
health, and our economy. Renewable energy prevent climate change. Human activity
contributes harmful effects especially to our atmosphere. Emission of carbon dioxide can
damage our environment. But with the use of renewable energy, that comes from
different energy from our nature does not make nor create any kind of pollution to our
Mother Earth. Renewable energy improved public health and environmental quality. The
air and water pollution emitted by coal and natural gas plants causes some of the different
diseases while wind, solar, and hydroelectric systems generate electricity with no
associated air pollution emissions. In addition, wind and solar energy require essentially
no water to operate and thus do not pollute water resources or strain supply by competing
with agriculture, drinking water systems, or other important water needs. It is very
inexhaustible energy supply. Renewable energy sources are limitless and sustainable
unlike non-renewable energy; it only has a limit source of energy. Renewable energy is
kind of energy that we can rely on, because it is abundant and eco-friendly. Renewable
energy produces jobs and other economic benefits. Renewable energies source like water
turbine, wind turbine, and solar panel may help our community in terms of giving people
different jobs like installing such renewable energy sources in different types of buildings
and establishments in their community. Renewable energy has stable energy prices-since
the renewable energy is reliable and sustainable, energy prices are stable. Unlike fossil
fuels which are limited that results in changing energy prices anytime.
Merging of Three Electric Generators 25
All of the related literature has similar aims in embracing the renewable energy.
They all make plans, acquisitions and partnership for installing the renewable energy
systems. They are all stating the potential that the Philippines has and also the advantages
of using this energy like the possibilities to attract more tourist, create more jobs, large
investments, cheaper electric bill payments and the recommendation to stop using non-
renewable energy. On the contrary, most of these literatures differ in their source of
renewable energy. Some of them focus in solar energy that pertains to the high
temperature we are getting from the sun. Some focus in creating hydro power plants
because the water doesn’t have an end like the flow of the river. Lastly, some of them
opted to create wind turbine because there are places in the Philippines where land is
higher elevated which means high speed of wind they can get.
Bio-sand filter
it is of paramount importance to our health. When water has some impurities, it has to be
purified. We now have numerous technologies used in purifying it but in the developing
countries, they find it difficult to use. There are other techniques in purifying water
includes winnowing, through cloth, clay vessels, clarification and filtration through plant
material, jumping stone filter method, horizontal flow coarse media filter and up flow
gravel filter.
don’t have an access to clean drinking water. Point of use (POU) household water
treatment technology lets people to treat their drinking water even at home. One of these
Merging of Three Electric Generators 26
is the slow sand filter or bio-sand filter. Some experimentations, confirmed the 94% was
the reduction of E. coli. But there are still need further study to determine the factors
These literatures simply relate the needs of the researchers to happen for those
who don’t have access to clean drinking water. The results of the conducted test will
support the proposed objective which is to let people have their own alternative water
purifier at home. Furthermore, it gives foundation or basis that bio-sand filter is a good
Sources into Hybrid Renewable Energy Systems. The results showed that the
integration of different renewable energy sources into a unique electric energy generation
system improves generated energy quality as well as it increases the generation system
economic value, as it allows to provide power and energy according to well defined rule.
The study also showed that reinforcement of the economic value for hybrid generation
units based on renewable sources is obtained through the attribution of control services to
grid operators. Similarly, Eziyi (2013) also conducted a study entitled Distributed
Renewable Energy System for Sustainable Rural Development. The results showed
meets the energy and clean drinking water need of the rural population. Therefore, this
system should be adopted for rapid implementation in the rural districts to ascertain its
Merging of Three Electric Generators 27
Ghana showed results that the reorientation of the state as a developmental one
particularly for developing countries provides an effective avenue for the successful
develops a methodology for optimal design of stand-alone HRES and micro grids for
standalone HRES and micro grids is the most cost-effective solution. Consequently, one
of the more significant findings to emerge from this study is that the best alternative to
find the optimal design for the power generation infrastructure in group remote
communities is to consider the use of micro grids. It was also shown that valuable insight
is obtained when analyzing several communities with a single methodology. For instance,
we were able to determine the characteristics (i.e., climate conditions; and energy
consumption) of the remote communities where the implementation of HRES would have
the best performance. Therefore, this methodology is a valuable tool to inform policy
Hybrid Renewable Resources using HOMER exhibited results that PV, Diesel
Generator with battery and inverter is most economical solution for all three cases for the
load of laboratory of MMMUT. PV, Wind Turbine, Diesel Generator with battery and
inverter system is also a very good alternative solution having little higher cost of
electricity and net present cost. Although the cost of electricity from the proposed system
is higher than the cost grid electricity but due the necessity of environmental protection
Merging of Three Electric Generators 28
and farseeing the current living standard of rural communities such hybrid system will
play a very good role for the country like India having deficit electricity. Moreover,
Berglund and Engstrom (2014) conducted a research entitled Power to the Philippines -
energy supply systems exhibited results that the hybrid system is the best alternative for
the humanitarian aid village, as it can provide cheap energy with high energy security at a
relatively low environmental impact. Therefore, the “Power to the Philippines” project
can be deemed to be of interest to the humanitarian aid villages, as long as the energy
load of the humanitarian aid village is not solely provided by Power towers. A
hybridization of Power towers with the existing diesel generators can help lower the
environmental impact of the existing energy system, while simultaneously lowering the
cost of electricity.
These studies are similar to the study being undertaken because they both
embraced the use of renewable energy as an alternative source of electricity. The stated
studies above are the same with our study because they both focused in optimization and
hybrid system is a process to select the best combination of component and there cost that
are able to provide cheap, reliable and effective alternative energy resource. Similar to
the present study, they want to have best quality design for HRES. These HRES take part
Remote Destinations in Nepal displayed results that rural electrification along with grid
extension and locally installed capacity of solar power, bio-gas as well as micro-hydro
Merging of Three Electric Generators 29
are the best solution to overcome total energy shortage in rural communities. In addition,
Energy: Lessons from Wind Developments in Remote and Small Island Nations
revealed several key lessons that can enhance the penetration of wind energy in
developing contexts. Truly sustainable and beneficial applications of wind energy require
more than just funding or technical precision. The findings suggest that not only can
small island nations overcome the technical barriers to implementing wind energy
projects, but that certain models of wind development can indeed enhance development.
This study is parallel to the study being undertaken because they both give
that renewable energy is the best solution in electricity shortage especially in remote
areas in particular Barangay Caysio, Sta. Maria, Bulacan . In addition, renewable energy
will take part in prevention of climate change because it doesn’t emit carbon dioxide and
Lipana (2008) conducted a research entitled When Incentives Are Not Enough:
Renewable Power showed results that renewable powers may not only lower the rates of
electricity in the Philippines. It can also achieve the government’s goal to be less
renewable powers are the answer to the pressing concern about climate change. Having
said these, attracting renewable power investments to the country is a vital concern of the
advancement in RE technology; hence, the need to turn overseas for these much-needed
Merging of Three Electric Generators 30
Needs Assessment revealed a need and demand for increased renewable energy
programming in extension. This need became further evident after a nationwide inventory
discovered that only twenty-two of fifty states have distinct renewable energy
These studies are related to the research being undertaken because they both
electricity. They want to introduce, develop, and use renewable energy because one of the
advantages of renewable energy, aside from its being environment-friendly, are that it has
minimal operational cost - because of its very cheap or practically free raw materials:
wind, water, solar energy, etc. - compared to fossil fuels which are limited in supply and
Implementing Bio-sand Filters in Rural Uganda 1, showed results that for almost 200
years, the traditional slow sand filter has improved and modernized version which is bio-
sand filter. The bio-sand filter is small, about 3 ft. tall and 2 ft. wide. It is composed of
layers of selected sand and gravel. The sand removes the pathogens and suspended solids
contaminated drinking water. Dr. David Manz developed the household bio-sand filter in
the 1990’s. He also helps in influencing many organizations in using bio-sand filter. In
rural Uganda, many families only have access to low quality of drinking water. Same in
the developing country, if this continue to happen it may lead to some diseases.
Merging of Three Electric Generators 31
Slow sand filter or bio-sand filter is one of the household filters used in many
houses and it is very attractive because the materials used are available in the locality. It
is layered with different sands and gravel and at the end; there is a faucet for the purified
water flow. If the time spent in filtration becomes longer, the sand and gravel must be
changed.
This study stated how the bio-sand filter was made and its features that could
Conceptual Frameworks
Materials needed:
Creating of Alternative generator
a.) Metals alternative generator a.) Alternative
b.) Welding rod and water purifier source of electricity
c.) Diode through:
d.) Tin cans Alternative water
e.) Lead a.) Sawing/Cutting purifier
f.) Copper wire metals, tin cans and a.) Alternative
\ g.) Direct current plastics source of well-
motor b.) Welding metals purified and potable
h.) Plastic/Metal c.) Connecting wire water
blade
i.) Charcoal
j.) Cloth
k.) Pebbles
Figure 1.1 Paradigm of the Study (A)
l.) Tube
Merging of Three Electric Generators 32
The figure 1.1 shows that in creating the alternative generator and water purifier,
the researchers must follow the indicated process above. The researchers will create the
device with full of care and with the help of other experts.
Merging of Three Electric Generators 33
Renewable energy
a.) Solar energy
b.) Wind energy
c.) Hydropower
Characteristics of
alternative generator
Inexpensive
Lowered electricity
Eco-friendly
rates
Moveable/
Improved electricity
Portable
Statistical analysis of generation
Sustainable
data through: Prevent climate
Well-designed change
Parts of alternative a.) Questionnaires Improved water
generator b.) Observation potability level
a.) Solar panel checklist Improved living
b.) Wind turbine
standards
c.) Water turbine
Characteristics of
alternative water
purifier
a.) It produces well-
purified water.
b.) It can help to
save money.
c.) It can help in
conserving water.
Parts of alternative
water purifier
Figure 1.2 Paradigm of the Study (B)
a.) Strainer
b.) Container/Water
tank
c.) Tube
Effectivity
Merging of Three Electric Generators 34
The figure 1.2 shows that the study being undertaken will be focusing to the
process indicated above. The main variable of this study is renewable energy and the sub-
alternative generator and water purifier, and their effectivity. The researchers will gather
checklist. After the researchers did the analysis of data, they came up in better results or
Hypotheses
electricity.
electricity.
2. If we use renewable energy, then those who live in remote areas will have their
If the remotes areas have this device, then there will be no hard time in
If we use this device, then it will not harm our environment unlike in non-
renewable energies.
4. If we embrace renewable energy, then we can save money, our environment and
If we continuously use fossil fuels, then we might suffer from electricity shortage
more often.
5. If you place the device in its sources for a longer time, then it will generate more
electricity.
If the water turbine runs faster, then it will convert more electricity.
If the wind speed is high, then the wind turbines will rotate faster resulting for
If you use more diodes and tin cans, then you can collect more energy from the
sun.
Research Problem 1: What are other alternative sources of electricity available in your
locality?
locality?
locality.
locality.
Research Problem 2: What are the impacts of using renewable energy as source of
electricity?
a.) Is the renewable energy can prevent global warming gas emissions?
b.) Is the renewable energy can improve public health and environmental quality?
environmental quality.
environmental quality.
Merging of Three Electric Generators 37
Null Hypothesis: Renewable energy can’t produce vast and inexhaustible energy
supply.
energy supply.
d.) Is the renewable energy can generate jobs and other economic benefits?
Null Hypothesis: Renewable energy can’t generate jobs and other economic
benefits.
Alternative Hypothesis: Renewable energy can generate jobs and other economic
benefits.
a.) Is the alternative generator efficient and can improve electricity generation?
Null Hypothesis: The alternative generator is not efficient and can’t improve
electricity generation.
electricity generation.
Merging of Three Electric Generators 38
Null Hypothesis: The alternative water purifier can’t make a drinking water well-
purified.
Alternative Hypothesis: The alternative water purifier can makes a drinking water
well-purified.
Null Hypothesis: The alternative water purifier can’t make potable water easily.
Alternative Hypothesis: The alternative water purifier can make potable water
easily.
c.) Is the water purified from alternative water purifier looks clean and clear?
Null Hypothesis: The water purified from the alternative water purifier doesn’t
Alternative Hypothesis: The water purified from the alternative water purifier
Null Hypothesis: The alternative water purifier can’t help to save money.
Alternative Hypothesis: The alternative water purifier can help to save money.
Null Hypothesis: The alternative water purifier can’t help in conserving water.
water.
Merging of Three Electric Generators 40
Definition of Terms
markets, and public understanding of energy and its interaction with the economy and the
environment.
and transmission service provider. The company operates, maintains, and develops state-
thousands of volts. Its functions include operations and maintenance, system operations,
and planning and engineering. The company was incorporated in 2008 and is based in
Winnowing - used when the water source is polluted by wind-borne impurities such as
dry leaves, stalks, and coarse particles. The raw water is passed through a winnowing
sieve, and the impurities are filtered. This type of filter is widely used in villages of the
Bamaka area, Mali.This method cannot be used when the raw water is highly turbid or
muddy, since the sieve cannot filter fine suspended particles in raw water.
Filtration through cloth - thin white cotton cloth or a discarded garment is used as the
filter medium. This filter can filter raw water containing such impurities as plant debris,
insects, dust particles or coarse mud particles. Filtration of suspended particles present in
water can be achieved only to a very small extent. Therefore, this type of filtration is not
suitable for highly turbid water. It is most suitable for filtration of well water. This
Merging of Three Electric Generators 41
practice of cloth filtration is quite common in villages in India, Mali, the southern part of
Niger and probably in many other parts of the developing world. In some of the Indian
villages, if the raw water is muddy and highly odorous, then wood ash of Sal tree (Shora
Filtration through clay vessels - used to filter highly turbid water. Turbid water is
collected in a big clay jar and allowed to settle down. Then the water in the jar will trickle
through the porous clay wall of the jar. This trickled water is collected in a vessel
(usually a clay pot) by placing it at the bottom of the porous clay jar. This method of
Water Clarification - helps remove suspended solids and particulate matter usually with
Filtration through plant material - it automatically filter the water in which they live
by adding oxygen and removing carbon dioxide. Some plants also remove heavy metals
and toxins while stimulating the growth of beneficial bacteria. Water lettuce and water
hyacinth are so effective that they are sometimes incorporated into the first step of
wastewater purification.
Jempeng stone filter method - developed in Saringan batu Jempeng, Bali, Indonesia.
Here, a small artificial pond or a by-pass channel is cut by the side to an irrigation canal,
Horizontal flow coarse media filter - uses coarse gravel or crushed stones as filter
media and is highly suited for turbid waters with turbidities greater than 50 NTU. A
combination of filtration and sedimentation of suspended solids take place during the
Up flow gravel filter - made by circulating the water from the under gravel filter back
validity and reliability of instrument and statistical treatment we will use in conducting
the research.
Research Design
Fellow and Liu (2008), is a method that is typically adopted because they are scientific
methods and provide immediate results. Other reason for selecting this approach is that is
more efficient, can test hypothesis and always aimed at clarifying features, count them
and build statistical models to explain what is observed during research. This study
utilizes the experimental study method which according to Konrath (2013), involves the
certain outcome (dependent variable). Specifically, the researchers used the repeated
measures which the same participant takes part in each condition of the independent
variable.
The researchers chose this research design because in this study, they need to
gain insights and feedbacks to people or family in remote areas in particular Barangay
Caysio, Sta. Maria, Bulacan. They think that this is the better type of study to gather more
data or information needed in this study. The researchers will give two different types of
condition wherein each family will be ask before and after using the alternative generator
Merging of Three Electric Generators 44
and water purifier. Then, they will analyze whether the two alternatives are efficient or
not.
This design is suited to the present study since the focus is to analyze how this
device can help the people or family in remote areas in particular Barangay Caysio, Sta.
Maria, Bulacan and to determine the efficiency level of the device when it is in use.
Research Respondent
particular Barangay Caysio, Sta. Maria, Bulacan as the research respondent because
researchers want to know and analyze their insights and feedbacks regarding the research
being undertaken and its prototype or the alternative generator and water purifier. The
sampling where subjects are selected because of their convenient accessibility and
proximity to the researchers. The subjects are selected just because they are easiest to
select for the study and researchers did not consider selecting subjects that are
technique because it is fast, inexpensive, easy and the subjects are readily available to
response in the survey questionnaires. Researchers use convenience sampling not just
because it is easy to use, but because it also has other research advantages. In pilot
studies, convenience sample is usually used because it allows the researchers to obtain
basic data and trends regarding their study without the complications of using a
randomized sample. The researchers chose this sampling technique because the research
Merging of Three Electric Generators 45
being undertaken have a purpose of giving people an idea on how the alternative
generator and water purifier would help them to save money, using electricity without
harming the environment and conserving water. This is also for the purpose of generating
electricity for areas if ever electricity shutdown and electrical problems occur and
In this research, the researchers used questionnaires as the method while they
structured and unstructured questionnaires as the instruments. The data will be gather in
people or family in remote areas in particular Barangay Caysio, Sta. Maria, Bulacan and
it should be collected before and after they used the device or the alternative generator
and water purifier. Each participant or family has maximum of 1 hour in using the
alternative generator and water purifier and after that they will give their comments and
The questionnaires are divided into four sections; demographic profile, other
personal information, other electrical information and degree of judgement. The research
These methods and instruments are suited to the research because it is the easiest
The researchers used questionnaires as the method. This method is valid to the
research being undertaken because the questionnaires include questions that will allow
the researchers to know the background information of each respondent, also their
Statistical Treatment
the quantitative data. Descriptive statistics are procedures that researchers use to describe
data and inferential statistics are ways to infer or make judgements about the respondents
In order to use the descriptive and inferential statistics, the researchers must know
the parameter of the population. According to Kalla (2011), a parameter is any numerical
quantity that characterizes a given population or some aspect of it. This means that the
parameter tells us something about the whole population. The parameter of the
population in this study was fifty people or family members wherein the researchers will
The statistical test used in this study was non-parametric test since it has small
sample size while the statistical tools used in the research being undertaken was
order to test the hypotheses and answer the research problems. As already indicated in the
This chapter comprises the presentation, analysis and interpretation of the findings
resulting from this research. The analysis and interpretation of data is carried out based
on the results of the survey questionnaires, deals with a quantitative analysis of data.
Data gathered through the survey questionnaires was subjected to frequency counts.
In other words, the respondent responses for each individual question were added
together to find the highest frequency of occurrence. These responses to the questions,
which are quantified, are then presented in percentage forms. In addition, the researchers
obtained the weighted mean from the responses in each question. The researchers test the
hypotheses using the Chi-Square Goodness of Fit Test as an inferential tool which
determines the observed and expected frequencies of independent variables. This analysis
is presented in tabular form. The researcher used tables containing variable and in some
The percentages in the tables below showed that the allocation of survey
A. Demographic Profile
Table 1.1 shows the gender categories of respondents who took part in the
respondents are female while 8 or 16% of the respondents are male. In general, most of
25
20
15
10
0
20 and 51 and
21-30 31-40 41-50
below above
Frequency (f) 8 7 10 10 15
Percentage (%) 16 14 20 20 30
Merging of Three Electric Generators 49
The minimum range of age of the respondents is 20 and below while the
maximum range of age of the respondents is 51 and above. Table 1.2 indicated that 8 or
16% of the respondents are at the age of 20 and below. Then, 7 or 14% of the respondents
are at the age of 21 to 30 years old and ages 31 to 40 and 41 to 50 years old have 10 out
of 50 or 20% of the respondents. Lastly, 15 out of 50 or 30% of the respondents are at the
age of 51 and above. In general, most of the respondents are at the age of 51 and above.
50
40
30
20
10
0
11 and above
1-5 members 6-10 members
members
Frequency (f) 26 19 5
Percentage (%) 52 38 10
Table 1.3 shows the frequencies and percentages of the number of family
members of the family. Lastly, or 10% of the respondents have 11 and above family
members.
Merging of Three Electric Generators 50
number of family members affects the electrical consumption in every house resulting in
Table 1.4 shows the frequencies and percentages of electricity users in each
family of the respondents. It indicated that 24 out 50 or 48% of the respondents have 1 to
3 members of the family who used electricity in their daily lives. Then, 16 or 32% of the
respondents have 4 to 6 members of the family who used electricity in their everyday
lives. Lastly, 10 or 20% of the respondents have 7 and above electricity users in their
family. In general, most of the respondents have 1 to 3 electricity users in their family.
Merging of Three Electric Generators 51
Scale used:
∑fx 152
X= = = 3.04
∑𝑓 50
The table 2.1 shows that 8 out of 50 or 16% of the respondents strongly agreed.
Then, 36 or 72% respondents agreed and 6 or 12% of the respondents disagreed. Lastly,
no one strongly disagreed that the alternative generator is efficient and can improve
Merging of Three Electric Generators 52
electricity generation. In general, most of the respondents agreed that the alternative
The quantitative mean value is 3.04 which mean agree as its qualitative or verbal
equivalent. Hence, the alternative generator is efficient and can improve electricity
generation.
∑fx 131
X= = = 2.62
∑𝑓 50
The table 2.2 shows that 3 out of 50 or 6% of the respondents strongly agreed.
Then, 27 or 54% of the respondents agreed and 18 or 36% of the respondents disagreed.
inexpensive. In general, most of the respondents agreed that the alternative generator is
inexpensive.
Merging of Three Electric Generators 53
The quantitative mean value is 2.62 which mean agree as its qualitative or verbal
∑fx 131
X= = = 2.62
∑𝑓 50
The table 2.3 shows that 9 out of 50 or 18% of the respondents strongly agreed.
Then, 26 or 52% of the respondents agreed and 14 or 28% of the respondents disagreed.
Lastly, 1 or 2% of the respondent strongly disagreed that the alternative generator is easy
to use. In general, most of the respondents agreed that the alternative generator is easy to
use.
The quantitative mean value is 2.62 which mean agree as its qualitative or verbal
∑fx 139
X= = = 2.78
∑𝑓 50
The table 2.4 shows that 8 out of 50 or 16% of the respondents strongly agreed.
Then, 24 or 48% of the respondents agreed and 17 or 34% of the respondents disagreed.
Lastly, 1 or 2% of the respondent strongly disagreed that the alternative generator is eco-
friendly. In general, most of the respondents agreed that the alternative generator is eco-
friendly.
The quantitative mean value is 2.78 which mean agree as qualitative or verbal
70
60
50
40
30
20
10
0
Strongly Strongly
Agree Disagree
Agree Disagree
Frequency (f) 12 23 12 3
fx 48 69 24 3
Percentage of the
24 46 24 6
Frequency (%)
∑fx 144
X= = = 2.88
∑𝑓 50
The table 2.5 shows that 12 out of 50 or 24% of the respondents strongly agreed.
Then, 23 or 46% of the respondents agreed and 12 or 24% of the respondents disagreed.
movable or portable. In general, most of the respondents agreed that the alternative
The quantitative mean value is 2.88 which mean agree as its qualitative or verbal
∑fx 148
X= = = 2.96
∑𝑓 50
The table 2.6 shows that 9 out of 50 or 18% of the respondents strongly agreed.
Then, 32 or 64% of the respondents are agreed and 7 or 14% of the respondents
generator can improve living standards. In general, most of the respondents agreed that
The quantitative mean value is 2.96 which mean agree as its qualitative or verbal
∑fx 147
X= = = 2.94
∑𝑓 50
The table 2.7 shows that 13 out of 50 or 26% of the respondents strongly
agreed. Then, 23 or 46% of the respondents agreed and 12 or 24% of the respondents
generator is well-designed. In general, most of the respondents agreed that the alternative
generator is well-designed.
The quantitative mean value is 2.94 which mean agree as its qualitative or verbal
Table 2.8 shows the summary of distribution of effectivity level and characteristics of
generator, majority of the respondents said that it is really efficient and can improve
electricity generation.
Table 3.1 shows that all of the respondents are using commercial electricity as
their electrical sources in their home and no one used solar energy and other electrical
sources. According to Bongcac and et. al (2017), different calamities such as earthquakes,
floods, landslide and typhoons may affect the supply of electricity since commercial
interruptions.
Table 3.2 shows that 7 out of 50 or 14% of the respondents are using commercial
electricity as their electrical source in their home for about 1 to 5 years. Then, 42 or 84%
of the respondents used this kind of electrical source for about 6 to 10 years. Lastly, 1 or
2% of the respondent used this kind electrical source for more than 11 years.
In general, most of the respondents in Barangay Caysio, Sta. Maria, Bulacan are
using commercial electricity as their electrical source in their home for about 6 to 10
years.
Merging of Three Electric Generators 60
In this table, the respondents have multiple answers since it talks about electrical
problems that they experiencing in their everyday lives. It indicated that 22 respondents
are suffering from frequent electrical surges and brownout. Then, 3 respondents are
bills.
In general, most of the respondents in Barangay Caysio, Sta. Maria, Bulacan are
suffering from paying high electrical bills. At this avenue, the alternative generator we
built will help the people in particular lessen their electrical bills, since our alternative
generator will produce electricity through hydropower, solar and wind energy.
Merging of Three Electric Generators 61
The table 3.4 shows that 17 out of 50 or 34% of the respondents have an electrical
bill of 1 to 500 pesos. Next, 18 or 36% of the respondents pay their electrical bill for 501
to 1000 pesos. Lastly, 15 or 30% of the respondents have more than 1000 pesos as their
electrical bill. In general, most of the respondents in Barangay Caysio, Sta. Maria,
In this table, the respondents have multiple answers since it regards on gadgets
and appliances in their home. It indicated that 32 respondents have cellphone and 19
In general, most of the respondents in Barangay Caysio, Sta. Maria, Bulacan have
electric fan in their home. But majority of the respondents have multiple gadgets and
In this table, the respondents have multiple answers since it pertains on electrical
sources in their locality. It indicated that 2 out of 50 or 4% of the respondents said that
their locality has solar panel or use solar energy as source of electricity. Then, 15
respondents said that their locality has diesel generator. Lastly, 43 respondents said that
In general, most of the respondents in Barangay Caysio, Sta. Maria, Bulacan said
that their locality has no other alternative source of electricity. In this manner, the
alternative generator we built will be their alternative source of electricity in their locality
that produces electricity for free or without paying any electrical bills instead the
In this table, the respondents have multiple answers since it regards on impacts of
using renewable energy. It indicated that 31 or 19.5% of the respondents said that using
renewable energies can prevent global warming gas emissions and 27 or 16.99% of the
respondents said that using renewable energy can improve public health and
environmental quality. Then, 33 or 20.75% of the respondents said that renewable energy
is vast and inexhaustible energy supply and 25 or 15.72% of the respondents said that
using renewable energy can generate jobs and other economic benefits. Lastly, 29 or
18.24% of the respondents said that renewable energy has stable energy price and 14 or
8.81% of the respondents said that using renewable energy can result to habitat loss. In
general, most of the respondents in Barangay Caysio, Sta. Maria, Bulacan said that
renewable energy is vast and inexhaustible energy supply. As stated in previous chapter,
embracing and using renewable energy have various impacts to people, environment,
economic and etc. All the listed impacts of renewable energy is the usual benefits of
using it.
Merging of Three Electric Generators 65
Scale used:
∑fx 154
X= = = 3.08
∑𝑓 50
The table 5.1 shows that 11 out of 50 or 22% of the respondents strongly agreed.
Then, 32 or 64% of the respondents agreed. Then, 7 or 14% of the respondents disagreed.
Lastly, no one strongly disagreed that the alternative water purifier makes drinking water
well-purified. In general, most of the respondents agreed that the alternative water
The quantitative mean value is 3.08 which means agree as its qualitative or verbal
equivalent. Hence, the alternative water purifier makes drinking water well-purified.
120
100
80
60
40
20
0
Strongly Strongly
Agree Disagree
Agree Disagree
Frequency (f) 8 34 8 0
fx 32 102 16 0
Percentage of the
16 68 16 0
Frequency (%)
∑fx 150
X= = =3
∑𝑓 50
The table 5.2 shows that 8 out of 50 or 16% of the respondents strongly agreed.
Then, 34 or 68% of the respondents agreed and 8 or 16% of the respondents disagreed.
Lastly, no one strongly disagreed that the alternative water purifier makes potable
drinking water easily. In general, most of the respondents are agreed that the alternative
The quantitative mean value is 3 which mean agree as its qualitative or verbal
equivalent. Hence, the alternative water purifier makes potable drinking water easily.
Merging of Three Electric Generators 67
∑fx 146
X= = = 2.92
∑𝑓 50
The table 5.3 shows that 13 out of 50 or 26% of the respondents strongly agreed.
Then, 21 or 42% of the respondents agreed and 15 or 30% of the respondents disagreed.
Lastly, 1 or 2% of the respondents strongly disagreed that water purified from alternative
water purifier looks clean and clear. In general, most of the respondents agreed that water
The quantitative mean value is 2.92 which mean agree as its qualitative or verbal
equivalent. Hence, water purified from alternative water purifier looks clean and clear.
Merging of Three Electric Generators 68
∑fx 140
X= = = 2.8
∑𝑓 50
The table 5.4 shows that 12 out of 50 or 24% of the respondents strongly agreed.
disagreed. Lastly, 2 or 4% of the respondents strongly disagreed that the alternative water
purifier can help to save money. In general, most of the respondents are agreed that the
The quantitative mean value is 2.8 which mean agree as its qualitative or verbal
∑fx 152
X= = = 3.04
∑𝑓 50
The table 5.5 shows that 13 out of 50 or 26% of the respondents strongly agreed.
Then, 28 or 56% of the respondents agreed. Then, 7 or 14% of the respondents disagreed.
Lastly, 2 or 4% of the respondents strongly disagreed that the alternative water purifier
can help in conserving water. In general, most of the respondents are agreed that the
The quantitative mean value is 3.04 which means agree as qualitative or verbal
Purifier
Table 5.6 shows the summary of distribution of effectivity level and characteristics of
alternative water purifier. It indicated that among all the characteristics of alternative
water purifier, majority of the respondents said that it can really make drinking water
well-purified
Hypothesis testing was done using the Chi-Square test. The formula used to get
(𝑂−𝐸)2
the Chi-Square computed is 𝑋 2 = ∑ , for the degree of freedom is df = k-1 at α =
𝐸
𝑛
0.05 and for the expected frequencies is 𝐸 = 𝑘 . The tabulated value was 7.82 as shown in
Table 6.1: Is the alternative generator is efficient and can improve electricity generation?
Interpretation:
then the null hypothesis is rejected and alternative hypothesis is accepted. This means
that the alternative generator is efficient and can improve electricity generation.
Interpretation:
then the null hypothesis is rejected and alternative hypothesis is accepted. This means
Interpretation:
then the null hypothesis is rejected and alternative hypothesis is accepted. This means
Interpretation:
then the null hypothesis is rejected and alternative hypothesis is accepted. This means
Interpretation:
then the null hypothesis is rejected and alternative hypothesis is accepted. This means
Strongly Agree 9 13 -4 16 4
Agree 32 13 19 361 27.77
Disagree 7 13 -6 36 2.77
Strongly Disagree 2 13 -11 121 9.31
Interpretation:
then the null hypothesis is rejected and alternative hypothesis is accepted. This means
Strongly Agree 13 13 0 0 0
Agree 23 13 10 100 7.69
Disagree 12 13 -1 1 0.08
Strongly Disagree 2 13 -11 121 9.31
Interpretation:
then the null hypothesis is rejected and alternative hypothesis is accepted. This means
Purifier
Hypothesis testing was done using the Chi-Square test. The formula used to get
(𝑂−𝐸)2
the Chi-Square computed is 𝑋 2 = ∑ , for the degree of freedom is df = k-1 at α =
𝐸
𝑛
0.05 and for the expected frequencies is 𝐸 = 𝑘 . The tabulated value was 7.82 as shown in
Table 7.1: Is the alternative water purifier makes a drinking water well-purified?
Interpretation:
then the null hypothesis is rejected and alternative hypothesis is accepted. This means
Table 7.2: Is the alternative water purifier makes potable water easily?
Interpretation:
then the null hypothesis is rejected and alternative hypothesis is accepted. This means
Table 7.3: Is the water purified from alternative water purifier looks clean and clear?
Strongly Agree 13 13 0 0 0
Agree 21 13 8 64 4.92
Disagree 15 13 2 4 0.31
Strongly Disagree 1 13 -12 144 11.08
Interpretation:
then the null hypothesis is rejected and alternative hypothesis is accepted. This means
that the water purified from alternative water purifier looks clean and clear.
Merging of Three Electric Generators 78
Table 7.4: Is the alternative water purifier can help to save money?
Interpretation:
then the null hypothesis is rejected and alternative hypothesis is accepted. This means
Table 7.5: Is the alternative water purifier can help in conserving water?
Strongly Agree 13 13 0 0 0
Agree 28 13 15 225 17.31
Disagree 7 13 -6 36 2.77
Strongly Disagree 2 13 -11 121 9.31
Interpretation:
then the null hypothesis is rejected and alternative hypothesis is accepted. This means
CHAPTER 5
This chapter presents the research that has been carried out. First, the brief review
of the research is presented. At this avenue, all issues such as the research objectives, the
framework and research methodology are briefly discussed. Subsequently, the major
findings of the study are discussed. In this section, the findings from the descriptive and
inferential statistics derived from data analysis are stated. Then, the implications of the
current research and its contributions are discussed. Finally, the elaboration of
This study wants to prove the efficiency of the emerged electric generators as an
alternative source of electricity and how it will help people especially in populated area
with a problem experiencing in electricity. In addition, it also wants to prove that the
traditional sand filter is a better alternative water purifier. Conducting this research has
purposive goal in which is to help people to have an accesible electric generator and
Summary of Findings
Majority of the respondents are female who belongs to 51 and above age bracket.
their family are frequently used electricity. Furthermore, all of them used commercial
Merging of Three Electric Generators 81
electricity as their source of electricity for about 6 to 10 years. Also, they are all having
multiple gadgets and appliances in their home resulting in paying high electrical bills.
Data
What are other good alternative sources of electricity available in your locality? In
the area of good alternative sources of electricity, Barangay Caysio, Sta. Maria, Bulacan
didn’t have any kind of alternative sources of electricity. As a result, citizens are
Conclusions
Even though there are no any good alternative sources of electricity in Barangay
Caysio, Sta. Maria, Bulacan, they chose to live there. I believe that citizens or even the
barangay officials should think better way on how they can generate electricity when
Recommendations
Bulacan by means of our alternative generator. It will easily generate electricity through
the use of renewable energies. The generated electricity can able to operate different
appliances, lightning a bulb and etc. We want to persuade citizens and barangay officials
to budget their money to avail our alternative generator to serve as their alternative source
of electricity.
Merging of Three Electric Generators 82
Data
What are the impacts of using renewable energies as source of electricity? At this
avenue, using renewable energies causes a lot of impacts in people, environment, and
economic growth and development. It can prevent global warming gas emissions;
improve public health and environmental quality; vast and inexhaustible energy supply;
leads job and other economic benefits; stable energy price and habitat loss.
Conclusions
As people living on a planet, we must embrace and use renewable energies in able
to attain its impacts that will result to better quality of living standards.
Recommendations
Data
In what way does this device will become valuable in people in remote areas? The
alternative generator and water purifier will be efficient to citizens in Barangay Caysio,
Sta. Maria, Bulacan in terms of generating electricity and producing well-purified and
potable water.
Merging of Three Electric Generators 83
Conclusions
Since Barangay Caysio, Sta. Maria, Bulacan is a remote area; citizens are
frequently experiencing some electrical problems. Moreover, some people there cannot
afford to avail mineral or alkaline waters. Thus, we as researchers, create a device that
can be an alternative source of electricity and water purifier which can produce well-
Recommendations
on how these machines can be distributed easily to the families in remote areas. Also how
these devices can improve the lives of those who used it.
Data
What are the characteristics of the alternative generator? The alternative generator
Conclusions
up in efficient and usable device that can generate electricity through renewable energies
Data
What are the characteristics of alternative water purifier? The alternative water
Water purified from alternative water purifier looks clean and clear.
Conclusions
come up in efficient and usable device that can produce drinking water for the people in
Data
What are the benefits of using the alternative water purifier? In this manner,
citizens in particular locale can save money and help in conserving water since the
Conclusions
Recommendations
what are the benefits they can get in using an alternative electric generator and an