You are on page 1of 19

Drawing Elbows and Bends with

AcornPipe Software

Elbows, Offsets, and Pipe Bends


90 degree Elbows Page 2

45 degree and Odd angle Elbows Page 9

Dimensioning the Offset Box Page 14

Page 1
Drawing Elbows and Bends with
AcornPipe Software

Page 2
Drawing Elbows and Bends with
AcornPipe Software

Page 3
Drawing Elbows and Bends with
AcornPipe Software

Page 4
Drawing Elbows and Bends with
AcornPipe Software

Page 5
Drawing Elbows and Bends with
AcornPipe Software

Page 6
Drawing Elbows and Bends with
AcornPipe Software

Page 7
Drawing Elbows and Bends with
AcornPipe Software

Page 8
Drawing Elbows and Bends with
AcornPipe Software

Drawing 45 degree and Odd angle Ells

Page 9
Drawing Elbows and Bends with
AcornPipe Software

Page 10
Drawing Elbows and Bends with
AcornPipe Software

Page 11
Drawing Elbows and Bends with
AcornPipe Software

Page 12
Drawing Elbows and Bends with
AcornPipe Software

Page 13
Drawing Elbows and Bends with
AcornPipe Software

Dimensioning the Offset Box (The run and the rise)

Page 14
Drawing Elbows and Bends with
AcornPipe Software

Left:
To Draw Pipe Bends, use the “Set”
menu, and select “Bend Radius and Tan-
gent”

Left: The “Bend Radius” entry screen


will allow you to tell AcornPipe your
bend factors, and will allow the calcula-
tion in inches or in mm.
Enter the tangent length in mm or
inches.
Click “Done”

Page 15
Drawing Elbows and Bends with
AcornPipe Software

Page 16
Drawing Elbows and Bends with
AcornPipe Software

Page 17
Drawing Elbows and Bends with
AcornPipe Software

Page 18
Drawing Elbows and Bends with
AcornPipe Software

Page 19

You might also like