Professional Documents
Culture Documents
reviewer2@nptel.iitm.ac.in ▼
Unit 9 - Phase
Movement and Entrainment Characteristics
Course
outline
Assignment: Module 8
The due date for submitting this assignment has passed. Due on 2018-03-21, 23:59 IST.
How to access
the portal Submitted assignment
Bubbling
Fluidization
Part 5: Gas and
solid
movements at
bubble
None of the above
Bubbling
Fluidization No, the answer is incorrect.
Part 6: Score: 0
Slugging Bed © 2014 NPTEL - Privacy & Terms - Honor Code - FAQs -
Accepted Answers:
A project of In association with
Entrainment
Characteristics
Part 1
3) According to the assumption of Davidson model, the pressure throughout the 1 point
Funded by
Quiz : bubble is
Assignment:
Module 8 Powered by
Variable
Assignment
Solution
Unpredictable
None of the above
Entrainment,
Elutriation and Constant
Attrition
No, the answer is incorrect.
Attrition, mixing Score: 0
and Segregation Accepted Answers:
Constant
Phase Dispersion
4) In case of flat-nose slug, the gas slugs occupy 1 point
Mass Transfer
and Heat Transfer The complete bed cross section
One third of the bed cross section
One fourth of the bed cross section
Half of the bed cross section
No, the answer is incorrect.
Score: 0
Accepted Answers:
The complete bed cross section
5) Slow bubbles regime is usual for beds of 1 point
Round-nose slug
Wall slugs
Flat-nose slug
All the above
No, the answer is incorrect.
Score: 0
Accepted Answers:
All the above
7) In case of fast bubble regime the following condition is applicable 1 point
Score: 0
Accepted Answers:
8) Inthe fast bubble regime, the fluid moves in which direction relative to the 1 point
bubble motion
Upward direction
Downward direction
Radial direction
None of the above
No, the answer is incorrect.
Score: 0
Accepted Answers:
Downward direction
9) The bubbles in the fluidized bed are accompanied by a ‘cloud’ while rising 1 point
through the bed. The cloud is usually
Very thin
Very thick
Moderately thick
None of the above
No, the answer is incorrect.
Score: 0
Accepted Answers:
Very thin
10)A gas is distributed into a bubbling fluidized bed (diameter 0.6 m) operated at a 1 point
minimum bubbling fluidization velocity. It is seen that the mean diameter of the bubble is
5 cm. Calculate the bubble rise velocity (Ubr)
49.8 cm/s
59.2 cm/s
None of the above
39.6 cm/s
No, the answer is incorrect.
Score: 0
Accepted Answers:
49.8 cm/s
11)When the bubble velocity increases, the cloud thickness 1 point
Increases
Decreases
Remains constant
None of the above
No, the answer is incorrect.
Score: 0
Accepted Answers:
Increases
12)In small particle bed, the bubbles are flatter. So, with the smaller particles, the 1 point
wake angle
Decreases
Remains constant
Increases
None of the above
No, the answer is incorrect.
Score: 0
Accepted Answers:
Decreases
15)According to Davidson, for three dimensional bed the upward flow rate of gas 1 point
into and out of the bubble is
16)In the fluidized bed a section of the bed between the surface of the dense phase 1 point
and the exit of the gas stream, is known as
Freeboard height
Bed diameter
Elutriation
Transport disengaging height
No, the answer is incorrect.
Score: 0
Accepted Answers:
Freeboard height
17)In a fluidized bed reactor the entrainment significantly affected by the 1 point
6.89 kg/m3
4.12 kg/m3
7.32 kg/m3
1.32 kg/m3
No, the answer is incorrect.
Score: 0
Accepted Answers:
1.32 kg/m3
19)The physical properties of the multiphase system like bulk density of the solid 1 point
and density of the gas have potential impact on the entrainment of the particles. The
entrainment of the system can be reduced by
Decreasing the bulk density of solid and Decreasing in density of the gas
Decreasing the bulk density of solid and increasing in density of the gas
Increasing the bulk density of solid and decreasing in density of the gas
Increasing the bulk density of solid and increasing in density of the gas
No, the answer is incorrect.
Score: 0
Accepted Answers:
Increasing the bulk density of solid and increasing in density of the gas
20)A fluidized bed reactor is being used to roast coffee beans by hot air. The 1 point
change of temperature may affect the entrainment characteristics of the reactor. Choose
the correct answer about the temperature effect on the entrainment
22)The wall effect predominant in slug flow based fluidized bed, when 1 point
Flat-nose slug
Wall slug
Round nose slug
None of these
No, the answer is incorrect.
Score: 0
Accepted Answers:
Flat-nose slug