Professional Documents
Culture Documents
Name Surname
ID
Section
Date
1
Name Surname:
ID:
PRELIMINARY WORK:
c) Construct the circuit in the Figure 4 onto the breadboard given in the Figure 2.
In the following stages, use the β, VBE(on) parameters from the datasheet of the BC238A.
β = ____ (average) VBE(on) = ____ V (typical)
2
Name Surname:
ID:
2. Analyze the common-emitter amplifier circuit that is given in the Figure 3 by using parameters
from Table 1 and fill out Table 2.
Construct the same circuit using PSpice and compare the results with your calculations. Add the
input and output voltage graphs, which belong to the highest output voltage oscillations without
any distortion.
3
Name Surname:
ID:
3. Analyze the common-collector amplifier circuit that is given in the Figure 4 using the parameters
of Table 3 and fill the Table 4.
Table 3: Circuit parameters of the common- Table 4: Calculated values for common-
collector amplifier collector amplifier
Construct the circuit on PSpice, check the result with Table 4 and add the input and output voltage
graphs to your preliminary work. According to your analytical solution, explain that is it possible to
double the gain?
(Extra point) To maximize the highest voltage oscillation, what are the most important parameters on
the circuit? Do simulations by changing resistor values and add your observations to your preliminary
work such as optimum voltages, limits etc. (Hint: Watch the VCEQ and Vce voltage carefully.)