Professional Documents
Culture Documents
HOME FAULT CODES DIAGNOSTIC SOFTWARE CAT ELECTRONIC TECHNICIAN ALLISON TRANSMISSION
SEARCH...
PLC Programming
(16)
Basic Hydraulics
(12)
Caterpillar ET Software
Starting and Charging System
(10)
The Communications tab in the "Preferences" dialog box allows the
communication interface device and the ports necessary to run the service
Fuel System Caterpillar Engine
(9)
tool to be set. NOTE: The information in the "Communications" tab is
Setting Display
(8)
dependent upon the "Communication Interface Device" selected.
Electronic Engines
(6)
To set the communication preferences:
Radio Programming
(6)
1). Open Caterpillar ET Software, it will automatically connect to the ECM.
Automatic Lubrication System
2). Click Stop Connect. (5)
Competency Training
(5)
Generator Set
(5)
Manual Book & Datasheet
(4)
Air Compressor System
(3)
Fire Suppression System
(2)
Micro Motion
(2)
WOODWARD Load Sharing &
Speed Control
(2)
Contact Us
(1)
If using Caterpillar Comm Adapter 3, and mark on Enable Dual Data Link
Service.
NOTE: If the "Enable Dual Data Link Service" checkbox is selected, two
ECMS using two different data links may be serviced simultaneously
without switching the data link connection. When applicable, this checkbox
is selected by default.
If using Caterpillar Comm Adapter II, and setting Ports (example: COM1)
as your COM port at Device Manager
Figure 1.7 - Communication Adapter
#Driver Download:
-NEXIQ USB-Link
-Caterpillar Comm Adapter 3 - V2.0
-Caterpillar Comm Adapter 3 - V4.4
Figure 2.1 - Troubleshooting Guide
1). Select the Default Settings Tool tab from the Preferences dialog box.
2). Select the desired feature from the Startup Tool drop down menu and
click OK. The following can be set to display at startup:
ECM Summary
Status
Configuration
Active Diagnostic Codes
Logged Diagnostic Codes
Active Event Codes
Logged Event Codes
Figure 2.3 - Startup Display
NOTE: If the selected feature is not supported by the ECM, the ECM
Summary feature will be displayed at startup.
Blog.Teknisi
Subscribe
Related Posts :
Why rly 2 on our emcp4.2 is not energise during start up.This causes
us problem of not having good start....any help will be appreciated.Our
unit is cat.3412 with emcp 4.2 and peec.Thabk you
Reply
Comment as:
Google Accoun
Publish Preview
Newer Post Home Older Post
BLOG.TEKNISI