Professional Documents
Culture Documents
20BME0540
1
Atharva Ashturkar
20BME0540
Objective: To develop the PLC ladder logic diagram for given control sequences and to
simulate the program to the stated conditions using PLC software.
Procedure:
2
Atharva Ashturkar
20BME0540
2. Motor A should turn on when Push button 1 is pressed. It should go off when an
OFF button is pressed. As soon as motor A is switched off, motor B should go ON
and it should run for10 seconds and switched off.
Objective: To develop the PLC ladder logic diagram for given control sequences and
to simulate the program to the stated conditions using PLC software.
Procedure:
• Create ladder logic program using PLC software with comments.
• Simulate and run ladder logic program.
• Test ladder logic program with inputs.
• Document Ladder logic program and PLC connection diagram.
3
Atharva Ashturkar
20BME0540
3. Design a PLC program and prepare a I/O connection diagram for the following counter
specifications:
i)Counts the no. of times a push button is pressed.
ii)Decrement the counter value each time a second push button is pressed.
iii)Turns on a light any time the counter accumulated value is less than 8.
iv)Turns on a second light when the counter value is equal to or greater than 8.
v)Resets the counter to zero when a selector switch is closed.
Objective: To develop the PLC ladder logic diagram for given control sequences and to
simulate the program to the stated conditions using PLC software.
Components Required: PLC software (PICO Soft)
Procedure:
• Create ladder logic program using PLC software with comments.
• Simulate and run ladder logic program.
• Test ladder logic program with inputs.
• Document Ladder logic program and PLC connection diagram.