z
brps://www.akubihar.com
Code : 100102/100202
‘B.Tech 2nd Semester Special Exam., 2020
( New Course )
ENGINEERING GRAPHICS AND DESIGN
Time : 3 hours Pall Marks + 70
Instructions
(AU questions carry equal marks.
(i) There are NINE questions inthis paper.
(i) Attempt FIVE questions in al
(6u) Question No.1 és compulsory
A. Answer any seven questions
fo) Mame eiferent p60 of draw
instruments. ia
(2) Mow wat you test the set squace?
(What ate the standard sizes of drawing
sheet according to IS!?
@) What do you mean vy compositon of
(o) What do you understand by uniformity in
lettering?
20AK/839 (Pun Over }
bitps./www akubihar.com
z
brps://www.akubihar.com
(2)
What do you mean by mechanical lettering
devices?
(a) What do you mean by the term ‘notation of
dimensioning?
() What are the
dimensioning? -
(@ What is the difference between a
parallelogram and a rhombus?
@) What is the difference between a regular
and an irregular polygon?
aligned systems of
2. The following figure shows isometric view of an
object
Draw the following vie
(a) Front view
() End view
(9) Top view
20aK/899 ( Continued }
bitps./www akubihar.comorang nays
‘haps://www akubihar.com brps://www.akubihar.com
(3) (4)
left ‘A hexagonal, id,
font view, top low, Bolt vie 5. A Resagonal pyramid, side of base 25 mm and
8 Ora ao nd ghteside view of the given object axis 50 mm long, is resting on an edge of he bac
Sen toga areion mobo one sa en gt eso ee
parallel to VP. Draw its projections.
A square pyramid of 25 mm side of base and
60 mm height is resting on ite base. A section
Plane is making an angle 60° with the HP and
cutting its axis at a height of 40 mm from the
‘base. Develop the truncated pyramid
g_% Druw the top view and the font view of acute
z of 40 mm edge which is resting on horizontal
Plane with one of tr faces retedat Some
3 Wand perpendicular tthe He i
lowing figures show the top, front and side 5 8. A cylinder of 25 mm diameter and 45 mm long
+ Te ten a eae se & Retiree aaron aS ong
SER ee F Sena eae
Shee: he PB Sgecaat
T T . 9. A right circular eylinder of 30 mm diameter and
t 35 mam height of anf eat bys scion
| sl trcined at 80° to HP and passed 8 min"
1 aL brave along the aie, Draw the development of he
oh
eS —4
[++
ri
{pi
20ak-$40/839 cose + 100102/ 100202
20AK/839 (Turn Over }
bitps./www akubibar.com bitps./www akubibar.com