You are on page 1of 3

1990 Toyota 4Runner SR5

1988-90 AUTOMATIC TRANSMISSIONS Toyota A-340E, A-340F, A-340H & A-341E Overhaul

ACCUMULATOR BACK PRESSURE TEST (A-341E)

NOTE: Perform test at normal operating fluid temperature 122-176°F (50-80°C). Ensure
oil pressure gauge hose does not come in contact with exhaust pipe.

Line Pressure Test

1. Move right side heat insulator aside. Remove plug from transmission case and install Pressure Gauge
(09992-00094). See Fig. 45 .
2. Remove passenger side No. 2 under cover. Connect a jumper lead to terminal SLN of ECU wire harness
side connector, but DO NOT ground jumper at this time.
3. Apply parking brake. Block wheels. Start engine. Ensure idle speed is within manufacturer's
specification. Place transmission in "D" range.
4. Measure accumulator back pressure. See ACCUMULATOR BACK PRESSURE SPECIFICATIONS
table. Repeat procedure with jumper lead connected to ground. Compare all readings to specification.

ACCUMULATOR BACK PRESSURE SPECIFICATIONS


Application Back Pressure - psi (kg/cm2 )
"D" Range (Idle) Not Grounded (1) 26-37 (1.8-2.6)
Grounded (1) 0 (0)
(1) Condition of engine and ECT ECU terminal SLN.

sábado, 20 de marzo de 2021 09:54:57


09:54:48 Page 1 © 2011 Mitchell Repair Information Company, LLC.
1990 Toyota 4Runner SR5
1988-90 AUTOMATIC TRANSMISSIONS Toyota A-340E, A-340F, A-340H & A-341E Overhaul

Fig. 45: Checking Accumulator Back Pressure (A-341E)


Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.

Line Pressure Test Results

sábado, 20 de marzo de 2021 09:54:48 Page 2 © 2011 Mitchell Repair Information Company, LLC.
1990 Toyota 4Runner SR5
1988-90 AUTOMATIC TRANSMISSIONS Toyota A-340E, A-340F, A-340H & A-341E Overhaul

1. If accumulator back pressure is not as specified when terminal SLN is grounded, check for following:
Throttle cable out of adjustment, throttle valve defective, solenoid modulator valve defective, SLN
solenoid valve defective or accumulator control valve defective.
2. If accumulator back pressure does not become zero when terminal SLN is grounded, check for defective
SLN solenoid valve.

sábado, 20 de marzo de 2021 09:54:48 Page 3 © 2011 Mitchell Repair Information Company, LLC.

You might also like