Professional Documents
Culture Documents
Api 510-Closed-5
Api 510-Closed-5
In a 30 mm thick cylinder shell the longitudinal as well as circumferential joints are double welded
1 butt welds with full penetration. Which of the following is true with regards to the longitudinal and
circumferential joints?
2 The MAWP of an existing vertical vessel will be affected in which of the following circumstances?
a. If the vessel part MAWP changes for any of the vessel parts
b. If the design pressure is reduced ( other factor remaining the same)
c. If the vessel height is changed by adding or deleting a shell course
d. Both A and C
a. 1100 mm
b. 1105 mm
c. 1095 mm
d. 1110 mm
4 In the thickness formula used to calculate internal pressure for a shell the term "E" refers to what?
5 The hydrostatic pressure caused by 10 ft. of liquid column (specific gravity equal to 1) will be?
a. 10 psi
b. 43.3 psi
c. 4.33 psi
d. None of the above
a. API 510
b. ASME Section 1
c. ASME Section VIII, Division 1
d. None of the above
7 The code rules for testing vessels in service are detailed in:
a. API 510
b. API 570
c. ASME Section VIII, Division 1
d. None of the above
a. Longitudinal joints
b. circumferential joints, shell to shell
c. Shell to hemispherical head joint
d. Both a A and C above
If all other conditions remain the same the design thickness of which dished head (Torispherical,
9
Hemispherical, Ellipsoidal) will be maximum?
a. Torispherical
b. Hemispherical
c. Ellipsoidal
d. All will have the same thickness
### Any Thickness-offset within the allowable tolerance shall be provided a minimum taper of:
a. 3 to 1 minimum
b. 4 to 1 minimum
c. 3 to 1 minimum
d. 1 to 2 minimum
ASME Section VIII, Divison 1 specifies different acceptance criteria for weld reinforcement, which of
###
the following statements are true?
A pressure vessel is designed with 0.85 joint efficiency and full penetration welds. The RT
###
requirement will be:
a. Nil
b. Spot
c. 100%
d. The T-joints will need to be radiographed
A vessel with a 50" O.D. and a 1 1/4" thickness is to be provided with standard torispherical heads
###
The heads shall be formed with crown radius and a minimu knuckle radius as follows:
a. 25 inches, 4 inches
b. 50 inches, 3 inches
c. 40 inches, 3 3/4 inches
d. 25 inches, 2 inches
If there is a confliuct between ASME Section VIII and API 510 codes, for vessel in service which of
###
the following shall take precedence?
Two head to shell joints, one joining a seamless hemispherical head to shell was radiographed for
### the full length and the other joint joining a seamless standard torispherical head to shell was spot
radiographed. The weld joint efficiency for each of these joints will be:
a. 1, 0.85
b. 1, 1
c. 0.85, 1
d. 0.85, 0.85
ASME Section VIII Division 1 recommends the use of U.T. in place of R.T. (for a fully radiographed
###
vessel) for:
### Vessel MAWP for a tall vertical vessel will normally be:
a. RT3 means E = 1
b. RT2 means E = 0.85
c. RT1 and RT2 may mean E = 1
d. RT4 means spot radiography
QUESTIONS ANSWER REFERENCES