Professional Documents
Culture Documents
Level 3 NVQ Diploma in Plumbing and Domestic Heating Unit 304/024 Sample questions
1. The use of environment sensors located on north facing walls to alter boiler
output is known as
a. heating compensation
b. environmental compensation
c. weather compensation
d. safety compensation.
a. AoC.
b. FoC.
c. PoC.
d. CoP.
3. The building regulations use SAP ratings. What does SAP stand for?
4. Separate space heating zones are required in dwellings where the floor area is
greater than
a. 150m²
b. 180m²
c. 200m²
d. 500m²
5. Which one of the following is a type of ground loop collector for a heat pump?
a. Negative return.
b. Open coil.
c. Slinky.
d. Spring.
SmartScreen
Level 3 NVQ Diploma in Plumbing and Domestic Heating Unit 304/024 Sample questions
6. Which one of the following types of heating system is shown in the diagram
below?
a. C Plan.
b. Y Plan.
c. S Plan.
d. W Plan.
7. Which one of the following types of heating appliances can also produce
electricity?
8. In the diagram below, the boiler flow will be connected through which of the
following?
a. Port A.
b. Port B.
c. Port AB.
d. Port A and Port B.
SmartScreen
Level 3 NVQ Diploma in Plumbing and Domestic Heating Unit 304/024 Sample questions
9. What one of the following types of valve would you commonly find in a Y plan
system with no bypass?
a. Refrigerant.
b. Water.
c. Oil.
d. Natural gas.
11. Which one of the following is a design criterion that must be considered when
designing a heating system?
12. Which one of the following documents gives guidance on heating system
design?
a. CHeSS 2008
b. CHeTT 2008
c. BS 6400
d. CHeSH 2005
a. kWh
b. kW/m2
c. W/m2
d. BTUs.
14. Which one of the following is a major factor to be considered when calculating
heat loss?
15. The additional storage vessel that can be installed to store excess heat
produced by a renewable heat source is called a
16. Which one of the following British Standards relates to cable sizing and
electrical installation?
a. BS 7600
b. BS 6700
c. BS 7671
d. BS 6771
17. How should a fused spur be properly isolated before doing any electrical work
on the circuit?
18. Which one of the following types of engine is commonly used in a combined
heat and power unit?
a. Moss engine.
b. Sterling engine.
c. Silver engine.
d. Steam engine.
20. Which one of the following installation techniques is commonly used when
installing the first fix plastic pipework to a domestic dwelling?