You are on page 1of 11

Start- up

Procedures of installation

Fuji
Menu
1- CONNECTION OF MOTOR CABLES TO CONTROLLER

2- INVERTER START-UP

3- TEMPORARY INSPECTION CABLE UTILIZATION

4- INVERTER PARAMETERS
5- FIRST START PROCEDURE AFTER INSTALLATION
START- UP MOVILIFT

WARNING
It is important to set inverter without ropes
on motor

1-CONNECTION OF MOTOR CABLES TO CONTROLLER

1. Connect main power supply to R S T

2. Connect U-V-W like in picture n° 1

3. Connect thermistor, brake correctly like in picture n° 2

4. Connect encoder and its ground like in picture n° 3 e 4

It is important to make in the best way the shielding wiring of


motor cable and encoder otherwise there will be inverter
malfunctions. Most important thing is the distance between
encoder cable and motor cable: at least 50cm for the whole travel from
motor to controller
START- UP MOVILIFT

2- INVERTER START-UP

During setting of GEARLESS Lift there are some different procedures to


execute with attention.

We advise to start WITHOUT ROPES ON MOTOR.

WARNING:
We need angle acquisition:

- Set parameter L3=1 and move elevator in inspection for a few seconds, until
Run Contactors will be disabled form inverter.

- Try to move Lift in UP or Down direction and check if motor works.

- If the first start the inverter turn ON shows error Ere reverse the motor
direction (reverse the wires V with W) and try again angle acquisition L03=1.

If direction of motor rotation is contrary please set parameters E98=99


and E99=98 or reverse the wires in the terminals FWD and REV 'inverter,
and try again angle acquisition L03=1.

- If inverter shows error PG or again ER6 check encoder connections.


START- UP MOVILIFT

3-TEMPORARY INSPECTION CABLE UTILIZATION

• Give power supply to controller;


• Controller is supplied with temporary inspection cables that you have
used during mounting. You have these wires:
o White and Brown  ALT
o Green  COMMON OF DIRECTION
o Yellow  UP DIRECTION
o Grey  DOWN DIRECTION

Furthermore there are some clevis on safety circuits.


Please check white and brown wires are joint and so led on MV900 board
EXC,ALT,CS are light ON. On the contrary case elevator not work
START- UP MOVILIFT

4-INVERTER PARAMETERS

Parameters are already setted. May need to adjust the acceleration,


deceleration or roll-back at the start, here are some parameters that can be
used:

E12= Acceleration
E13= Deceleration
C07/C07= Creep speed (low speed - Hz)

C06/C06= Maintenance speed (Hz)

C11/C11= High speed (Hz)

C10= Intermediate speed (Hz) (IF AVAILABLE)

OTHER

P01 = N° Poli Motore


P02 = Motor power [kW]
P03 = Motor Current [A]
P06 = 0.00 No-load current

F03 = Maximum speed [rpm]


F04 = Rated speed [Hz]
F05 = Rated voltage [V]
L01= Encoder type (4 = endat)

L02= Encoder pulse

L36= ASR (high speed gain)

L38= ASR (low speed gain)

L68= Unbalanced Load compensantion (Roll-back to start)

(if at start appear a vibration decrease of 0.20. For example, if it is set to 2,


decrease 1.80).
START- UP MOVILIFT

How to calculate the slowing (deceleration distance)


V m/s
NOMI
NAL meters Deceleration (slowing)
SPEE
D

1,6 1,8 1,8 1,9 1,9 2,0 2,0 2,1 2,1 2,2 2,2 2,3 2,3 2,4

1,5 1,7 1,7 1,8 1,8 1,9 1,9 2 2 2,1 2,1 2,2 2,2 2,3

1,4 1,6 1,6 1,7 1,7 1,8 1,8 1,9 1,9 2 2 2,1 2,1 2,2

meters Deceleration (slowing)


1,3 1,5 1,5 1,6 1,6 1,7 1,7 1,8 1,8 1,9 1,9 2 2 2,1

1,2 1,4 1,4 1,5 1,5 1,6 1,6 1,7 1,7 1,8 1,8 1,9 1,9 2

1,1 1,3 1,3 1,4 1,4 1,5 1,5 1,6 1,6 1,7 1,7 1,8 1,8 1,9

1 1,2 1,2 1,3 1,3 1,4 1,4 1,5 1,5 1,6 1,6 1,7 1,7 1,8

0,9 1,1 1,1 1,2 1,2 1,3 1,3 1,4 1,4 1,5 1,5 1,6 1,6 1,7

0,8 1 1 1,1 1,1 1,2 1,2 1,3 1,3 1,4 1,4 1,5 1,5 1,6

0,7 0,9 0,9 1 1 1,1 1,1 1,2 1,2 1,3 1,3 1,4 1,4 1,5

0,6 0,8 0,8 0,9 0,9 1 1 1,1 1,1 1,2 1,2 1,3 1,3 1,4

F08
1,3 1,4 1,5 1,6 1,7 1,8 1,9 2 2,1 2,2 2,3 2,4 2,5
slowing Parameter

Example: With speed to 0.7 m / s and a deceleration (parameter F08) to 1.8 sec the slowing space
is 1.1 meters.
START- UP MOVILIFT

If motor has rollback please make these:

1) make again Pole Tuning

2) Increase L68 until rollback is expired (increase each time of 0,50) ;

3) If rolleback is disappeared but there is noise, decrease parameter L68


to the previous value and decrease L66 and F24 of 0,10

Example: L66 = 1.00 ---> 0.90 and see if it improbe


START- UP MOVILIFT

It 'important to connect
the ground of the
encoder

fig.3

Connection Example
Heidenhain
ECN1313/ECN413

fig.4
START- UP MOVILIFT

Connections:

Brake FR/FRO= +,+/-

Brake switch BR1/BR2=


white/brown

Thermistor TMS/TMS=
grey/brown TH

fig.2

CLASSIC LEGEND NEW LEGEND


Colors Heidenhain ECN1313/ECN413 Colors Heidenhain ECN1313/ECN413

Marrone/verde = PO (Brown/Green) Grigio/Rosa = PO (Grey/Pink)

Bianco/verde = CM (White/Green) Rosso/Blu = CM (Red/Blue)

Rosso/nero = PB- (Red/Black) Bianco = PB- (White)

Blu/nero = PB+ (Blue/Black) Marrone = PB+ (Brown)

Giallo/nero = PA- (Yellow/Black) Viola = PA- (Violet)

Verde/nero = PA+ (Green/Black) Rosso = PA+ (Red)

Giallo = CK- (Yellow) Rosa = CK- (Pink)

Viola = CK+ (Violet) Verde = CK+ (Green)

Rosa = DT- (Pink) Blu = DT- (Blue)

Grigio = DT+ (Grey) Giallo = DT+ (Yellow)


START- UP MOVILIFT

5-First Start Procedure after installation

RS RD IF ICV Green blinking= OK

Yellow blinking= some faults in


memory

Red Fixed= Board in error

WARNING!
After installation please remove all short
circuit jumpers and Temporary Inspection
Cable (on Safety Circuit, GND/RS/RD).
1- Move cabin on Ground floor. Display will show 1011
(sensors switch indication).

2- EXC and ALT leds have been ON and also CS (with closed doors)
(otherwise please check Safety Circuits on electrical drawings).

3- If display doesn’t show UNI0 but another message, please check “immediate information” that
is actual state of board.
(more info on MV900 user manual)

4- If display shows an error, please try to reset it with RESET button .


(check Fault List and probably solutions on MV900 user manual)

5- Make a call on the next floor by buttons DATO and UP


START- UP MOVILIFT

More Frequent Faults Description


38-39 Selector Count Failed

41 Pre-limit sensors opened

56 Thermal control of pump PTC

62 Serial connection in car not found

63 External Serial connection not found

67 Re-open contact, photocell or open door button ON

80 Travel time expired

81 Cabin on Limit switch

You might also like