Professional Documents
Culture Documents
52SS Page 1
INSTALLATION
(d) Align the straight pin on the No. 2 camshaft with the pin hole in the camshaft timing exhaust gear assembly and install the camshaft timing
exhaust gear assembly to the No. 2 camshaft.
NOTICE:
- If the straight pin cannot be aligned with the pin hole, hold the hexagonal portion of the No. 2 camshaft with a wrench and turn it slightly to
install the gear.
- Do not turn the No. 2 camshaft more than necessary.
- Do not forcibly push on the tip of the straight pin with the camshaft timing exhaust gear assembly.
(e) Using SST and a wrench, hold the hexagonal portion of the No. 2 camshaft and install the camshaft timing exhaust gear assembly to the No. 2
camshaft.
SST: 09249-37010
without SST - Torque: 54 Nm (551 kgf-cm, 40 ft-lbf)
with SST - Torque: 39 Nm (397 kgf-cm, 29 ft-lbf)
NOTICE:
- This torque value can be obtained by using a torque wrench with a fulcrum length of 260 mm (10.24 in.) and SST of 100 mm (3.94 in.)
See: Service Precautions.
- This torque value is effective when SST is parallel to the torque wrench.
(a) Using SST, install the No. 2 chain vibration damper with the 2 bolts.
SST: 09961-00950
without SST - Torque: 10 Nm (102 kgf-cm, 7 ft-lbf)
with SST - Torque: 5.5 Nm (56 kgf-cm, 48 in-lbf)
NOTICE:
- This torque value can be obtained by using a torque wrench with a fulcrum length of 180 mm (7.09 in.) and SST of 150 mm (5.91 in.) See:
Service Precautions.
- This torque value is effective when SST is parallel to the torque wrench.
(a) Turn the crankshaft clockwise 360° to set the No. 1 cylinder to TDC/compression and align the matchmark (cutout) with the "0" mark on the
timing chain (belt) cover.
(b) Check that the matchmark on each camshaft timing gear is positioned as shown in the illustration.
5. INSTALL CYLINDER HEAD COVER SUB-ASSEMBLY See: Service and Repair/Overhaul/Reassembly
6. INSTALL IGNITION COIL ASSEMBLY See: Powertrain Management/Ignition System/Ignition Coil/Service and Repair/Installation
7. INSTALL RADIO SETTING CONDENSER See: Service and Repair/Removal and Replacement/Engine Unit/Installation
8. INSTALL WIRE HARNESS
10. CONNECT FUEL VAPOR FEED HOSE ASSEMBLY See: Service and Repair/Removal and Replacement/Engine Assembly/Installation
11. CONNECT UNION TO CONNECTOR TUBE HOSE See: Service and Repair/Removal and Replacement/Engine Assembly/Installation
12. INSTALL NO. 2 CYLINDER HEAD COVER See: Service and Repair/Removal and Replacement/Engine Assembly/Installation