You are on page 1of 9

D EUTSCHE NORM June 2001

Testing hardened concrete


Part 2: Making and curing specimens for strength tests
{
English version of DIN EN 12390-2 EN 12390-2

ICS 91.100.30

Prüfung von Festbeton – Teil 2: Herstellung und Lagerung von Probekörpern für Festigkeitsprüfungen

European Standard EN 12390-2 : 2000 has the status of a DIN Standard.

A comma is used as the decimal marker.

National foreword
This standard has been prepared by CEN/TC 104 ‘Concrete (performance, production, placing and compli-
ance criteria)’ (Secretariat: Germany), SC 1 ‘Concrete (performance, production, placing and compliance
criteria)’.
The responsible German body involved in its preparation was the Normenausschuss Bauwesen (Building
and Civil Engineering Standards Committee), Technical Committee 07.05.00 Prüfverfahren für Beton.
It should be noted that the conditions of curing the concrete specimens customary in Germany differ from
those specified in subclause 5.5.3 (see National Annex).

National Annex NA (informative)


Curing of concrete specimens when testing compressive strength and modulus of
elasticity
NA.1 General
This national annex describes the conditions customary in Germany for the curing of concrete specimens
intended to be used for compression tests and when testing the modulus of elasticity.
It is essential that the test parameters given in subclause NA.2 are adhered to, use of the parameters given
in footnotes 1) and 2) being recommended.

NA.2 Curing conditions


After preparation, the specimens shall be conditioned in moulds in a closed room at a draught-free location,
protected from loss of moisture (e.g. by covering with polyethylene sheeting), for (24 t 2) hours at a
temperature of 15 °C to 22 °C 1). During hardening, the environment shall be vibration-free.
After (24 t 2) hours, the specimens shall be demoulded, placed on gratings and cured for six days in water
at a temperature of (20 t 2) °C or, alternatively, in a cabinet at a temperature of (20 t 2) °C and a relative
humidity exceeding 95 %.
Seven days after preparation, the specimens shall be removed from the water cabinet, placed on gratings
and stored in a closed room at a draught-free location at a temperature of 15 °C to 22 °C 2).

EN comprises 7 pages.

1
) A temperature of (20 t 2) °C is recommended.
2
) A temperature of (20 t 2) °C at a relative humidity of (65 t 5) % is recommended.

© No part of this standard may be reproduced without the prior permission of Ref. No. DIN EN 12390-2 : 2001-06
DIN Deutsches Institut für Normung e. V., Berlin. Beuth Verlag GmbH, 10772 Berlin, Germany, English price group 06 Sales No. 1106
has the exclusive right of sale for German Standards (DIN-Normen).
10.01
Licensed to Mark Wisneski. ANSI order X_16801. Downloaded 8/27/2007 4:56 PM. Single user license only. Copying and networking prohibited.
Licensed to Mark Wisneski. ANSI order X_16801. Downloaded 8/27/2007 4:56 PM. Single user license only. Copying and networking prohibited.
EN 12390-2
October 2000

ICS 91.100.30

English version

Testing hardened concrete


Part 2: Making and curing specimens for strength tests

Essai pour béton durci – Partie 2: Prüfung von Festbeton – Teil 2:


Confection et conservation des Herstellung und Lagerung von Probe-
éprouvettes pour essais de résis- körpern für Festigkeitsprüfungen
tance

This European Standard was approved by CEN on 2000-02-03.


CEN members are bound to comply with the CEN/CENELEC Internal Regulations
which stipulate the conditions for giving this European Standard the status of a
national standard without any alteration.
Up-to-date lists and bibliographical references concerning such national stand-
ards may be obtained on application to the Management Centre or to any CEN
member.
The European Standards exist in three official versions (English, French, German).
A version in any other language made by translation under the responsibility of a
CEN member into its own language and notified to the Management Centre has
the same status as the official versions.
CEN members are the national standards bodies of Austria, Belgium, the Czech
Republic, Denmark, Finland, France, Germany, Greece, Iceland, Ireland, Italy,
Luxembourg, the Netherlands, Norway, Portugal, Spain, Sweden, Switzerland,
and the United Kingdom.

ÈÉË
European Committee for Standardization
Comité Européen de Normalisation
Europäisches Komitee für Normung

Management Centre: rue de Stassart 36, B-1050 Brussels

© 2000. CEN – All rights of exploitation in any form and by any means Ref. No. EN 12390-2 : 2000 E
reserved worldwide for CEN national members.

Licensed to Mark Wisneski. ANSI order X_16801. Downloaded 8/27/2007 4:56 PM. Single user license only. Copying and networking prohibited.
Page 2
EN 12390-2 : 2000

Contents
Page
Foreword . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
1 Scope . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
2 Normative references . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
3 Apparatus . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
4 Sampling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
5 Procedures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
6 Test report . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Licensed to Mark Wisneski. ANSI order X_16801. Downloaded 8/27/2007 4:56 PM. Single user license only. Copying and networking prohibited.
Page 3
EN 12390-2 : 2000

Licensed to Mark Wisneski. ANSI order X_16801. Downloaded 8/27/2007 4:56 PM. Single user license only. Copying and networking prohibited.
Page 4
EN 12390-2 : 2000

Licensed to Mark Wisneski. ANSI order X_16801. Downloaded 8/27/2007 4:56 PM. Single user license only. Copying and networking prohibited.
Page 5
EN 12390-2 : 2000

Licensed to Mark Wisneski. ANSI order X_16801. Downloaded 8/27/2007 4:56 PM. Single user license only. Copying and networking prohibited.
Page 6
EN 12390-2 : 2000

Licensed to Mark Wisneski. ANSI order X_16801. Downloaded 8/27/2007 4:56 PM. Single user license only. Copying and networking prohibited.
Page 7
EN 12390-2 : 2000

Licensed to Mark Wisneski. ANSI order X_16801. Downloaded 8/27/2007 4:56 PM. Single user license only. Copying and networking prohibited.

You might also like