Professional Documents
Culture Documents
amplifier.
9 Explain the concept of AC load line for large signal 5M May-2017
amplifiers.
10 Describe the working of class-AB amplifier. 5M May-2017
11 Explain the working of common emitter RC coupled amplifier 5M May-2017
12 Tabulate the efficiencies and conduction angles of power 5M May-2017
amplifiers.
13 Define amplification, gain, frequency response, bandwidth & 5M Nov-2017
input impedance as applicable to amplifier.
14 Explain the principle of transistor as an amplifier. 5M Nov-2017
15 Define operating point & describe the role of DC load line to 5M Nov-2017
locate it.
16 Explain the working of class-A series fed amplifier 5M Nov-2017
17 Explain the features of RC coupled amplifier. 5M Nov-2017
18 Define operating point. Describe the role of DC load line in 5M May-2018
locating it
19 Classify Amplifiers 5M May-2018
20 (a) Compare power amplifiers with reference to conduction 10M May-2018
angle and efficiency
(b) explain the principle of operation of transistor as an
amplifier
21 (a) Modify class B push-pull amplifer to overcome cross- 10M May-2018
over distortion
(b) Establish the relation between gains of individual
stages and overall gain in a multi stage amplifier
Unit-3 OP-AMP and applications
1 Define i) CMRR ii) Gain iii) Gain-bandwidth product iv) Slew 5M Nov-2016
rate v) Input impedance for an op-amp.
2 Explain the operation of op-amp comparator with waveforms. 5M Nov-2016
3 Construct op-amp integrator and sketch its response for square 5M Nov-2016
wave input.
4 Show that gain of an inverting amplifier is –Rf/Ri. 5M Nov-2016
5 Construct an op-amp circuit to add two voltages and amplify the 5M Nov-2016
same by 10 times.
6 If Vin=2V, R1 and R2 are 5KΩ, find the output voltage and 5M Nov-2016
voltage gain for the given circuit.
5M. Apr/May-2017
3 Implement two input EX-OR gate function using PAL. 5M. Nov/Dec-2016
4 A semi-conductor memory chip is specified 2K x 8. 5M. Nov/Dec-2016
(i)How many bit can this chip store?
(ii)How many addreslines are required to access this chip?
5 Write a note on flash memory. 5M. Nov/Dec-2016
5M. Nov/Dec-2017
5M. Apr/May-2018
6 Describe the working principle of SRAM. 5M. Apr/May-2017
7 Realize the full adder using PROM. 5M. Apr/May-2017
8 Explain the expanding of word size and capacity of memories with an 10M. Apr/May-2017
example. 5M. Apr/May-2018
9 Define the terms: (i) Memory address (ii) Memory read operation (iii) 5M. Nov/Dec-2017
Memory write operation.
10 Show that the PAL type array should be programmed to implement 5M. Nov/Dec-2017
function Y=ABC+ABC.
11 Explain the block diagram of PLD with neat diagram. 10M. Nov/Dec-2017
12 Explain Dynamic Random Access Memory Cell. 5M. Apr/May-2018
13 Compare fixed logic device and programmable logic device. 5M. Apr/May-2018
14 Implement and explain full adder using PAL write logic diagram and 5M. Apr/May-2018
truth table.
UNIT 6 Digital integrated circuits
1 Define fan in, fan out & propagation of delay. Power dissipation and 5M. Nov/Dec-2016
noise margin with respect to logic gates. 5M. Apr/May-2017
5M. Apr/May-2018
2 Give the classification of logic families. 5M. Nov/Dec-2016
3 Explain the CMOS inverter gate with circuit diagram. 5M. Nov/Dec-2016
5M. Nov/Dec-2017
4 List the five comparisons between TTL logic devices with CMOS logic 5M. Apr/May-2017
devices. 5M. Apr/May-2018
5 Explain the operation of TTL NAND gate with circuit & truth table. 5M. Apr/May-2017
5M. Apr/May-2018
6 List the features & merits of TTL logic . 5M. Nov/Dec-2017
7 Explain the interfacing of CMOS to TTL interface using 5v supply 5M. Nov/Dec-2017
voltage.
4 Determine the value of load resistance R for Transferring 10M Nov/Dec 2016
Maximum power to it in the circuit shown below. Also find
maximum power delivered to it.
12 Find the current through load resistor R using Norton’s 10M Nov/Dec 2017
Theorem.
13 Draw the Norton’s equivalent circuit for the network shown 5M April/May 2018
in the figure across 4ohm load.
14 Using norton’s theorem find the current through 8ohm 10M April/May 2018
resistor for the circuit shown in the figure.
Derive the expression for resonant frequency for a series 5M April/May 2018
resonant circuit.
6 Define filter, and give the classification of filters 5M April/May 2017
7 Derive expression for frequency of resonance, Q factor, 10M April/May 2017
Power Factor, Bandwidth and Selectivity for parallel
resonance.
8 Design a symmetrical T-type and π Type attenuator whose 10M April/May 2017
attenuation factor of 30db and characteristics resistance is
600Ω and Sketch the circuit.
9 What is a Attenuator. Classify Attenuator. 5M Nov/Dec 2017
6 What are transmission lines. Mention their classification 10M April/May 2017
and explain any one of them with neat figure.
7 Write a note on secondary constant of a transmission line. 5M Nov/Dec 2017
8 What is standing wave ratio. Derive its expression. 5M Nov/Dec 2017
9 Explain single and double stub matching with neat 10M Nov/Dec 2017
diagram.
10 Explain Co-axial cable with diagram. 5M April/May 2018
11 Define reflection Co-efficient and Standing Wave Ratio. 5M April/May 2018
Unit – 2 Transducers
1 List the factors for selection of a Transducer. 5 Nov-2016
5 Nov-2017
April – 2018
2 Explain the working principle of capacitive transducer. 5 Nov-2016
3 Sketch LVDT and explain the working principle. 5 Nov-2016
4 Write a note on PIR sensors. 5 Nov-2016
5 Explain briefly the Strain gauge transducer. 5 April-2017
6 Describe active and passive transducer. Give one example for each. 5 Nov-2016
7 Illustrate how load cell can be used for measuring Force. 5 Nov-2016
8 Explain how piezoelectric material can be used as a transducer. List any 5 Nov-2016
two piezoelectric materials.
9 Explain the principle of working of thermocouple. 5 April-2017
10 Explain working principle of piezo-electric transducer. 5 April-2017
April - 2018
11 Write about Proximity sensor. 5 April-2017