Professional Documents
Culture Documents
ANNEX E
( Clause 4.2 )
74
IS 3177 : 2020
75
IS 3177 : 2020
d) Any special motor lead or terminal requirements E-6.6.1 Location of Electrical Equipment Compartment
..................... for
E-6.4 Main Control Gear a) Fixed cabin cranes (below or above the bridge
platform, or above the cab)
E-6.4.1 Type of Control Panels (open or separate closed .. .. .. . .. . .. .. . .. . .. . .. . . .. . .. .. . . .. .. . . .. .. . ... ..
units)............ . . .. ... . .. ... .. . ... .. . .. .. .
E-6.4.2 Short Time Rating or Duty Cycle Ratings of b) Moving cabin cranes (above the bridge platform
Resistors: level, or above the cab), ... ... ... ... ... ...
a) Hoist motions ....................................................... E-6.7 Long-Travel System
b) Cross-travel motions ............................................
E-6.7.1 Provision of long-travel collectors (purchaser
c) Long-travel motions .............................................. or manufacturer) ..............................
E-6.4.3 Scheme of Protection for Main Control E-6.7.2 Details of mountings on bridge structure for
Circuits: long-travel collectors, if these are to be provided by the
a) Protection of each motion, or................................. purchaser..................................
b) Tripping out crane supply if overload on any
E-6.7.3 Details of long-travel conductors, if
motion ..................................................
long-travel collectors are to be provided by the
E-6.4.4 Any Requirement for: manufacturer.................................................
a) A special control system, or a control system E-6.7.4 Type of long-travel collectors if these are to be
other than automatic control of acceleration for provided by the manufacturer................................
any motion (for example, drum or mechanically
operated contactor controller) E-6.8 Cross-travel System
b) Emergency rheostatic braking on travel motions: E-6.8.1 Any requirement for flexible cable type of
1) cross-travel ....................………………….. cross-travel system... ... ... ... ... ... ... ... ... ... ... ... ... ...
2) long-travel …………………………………
E-6.8.2 Type of cross-travel conductors (rolled steel
c) an electrically operated main circuit-breaker section or wires)
...........................…..
d) special clearances of creepages .......……………. E-6.8.3 Maximum current density for cross-travel
conductors (if higher than that recommended in this
E-6.5 Auxiliary Switching specification ).............................
E-6.5.1 Any Requirement for: E-6.8.4 Provision of cross-travel collectors (purchaser
a) special position of: or manufacturer)
1) main isolating switch ……………….............. E-6.8.5 Details of mountings on the trolley for cross-
2) additional main isolating switch ........................ travel collectors, if these are to be provided by the
b) HBC fuse protection for main isolators purchaser ......................
c) auxiliary contacts on the main isolating switch to E-6.8.6 Type of cross-travel collectors, if these are to
operate the crane warning hights be provided by the manufacturer .…………….............
d) an isolating switch on the main circuit of each
E-6.9 Lifting Magnet and Equipment
motion
e) an isolating switch on the control circuit of each E-6.9.1 If lifting magnets and magnet control and
motion protective gear are to be provided:
f) special creeping button to by-pass lower hoist a) Type and size of magnets... ... ... ... ... ... ... ... ... ...
limit switches ... ... ... ...... ...
g) track switches (number, details and whether to b) Type of magnet control ( direct-on-line or
operate a warning signal, or trip the main circuit- potentiometer )... ......
breaker) c) Type of master controller for direct-on-
h) proximity warning devices (number, location and line control (hand or foot operated)............
duty) ……………………………………………........
E-6.6 Disposition and Housing of Electrical d) Type of potentiometer control (master drum or
Equipment mechanically operated contactor controller).
76
IS 3177 : 2020
77