Professional Documents
Culture Documents
LARGE
9” WIDTH X 5 1/2” HEIGHT
MEDIUM
7” WIDTH X 5 1/2” HEIGHT
no.200
This is an easy and simple pattern for begnners.
SMALL
5 1/2” WIDTH X 4 1/4” HEIGHT
INTERFACING
(1/8) Yard 44” wide light weight fusible
interfaing
MATERIAL LIST
Small _ Detail
FABRIC Detail FABRIC Patched Flap
44” wide heavyweight home decorator Cut 6 of 1 1/2” width x 3 1/4” Height
OR quilting weight cotton
(1/8) Yard for exterior front and back pieces
(1/16)Yard for exterior flap
(1/8) Yard for lining
TOOL LIST
Ruler, Scissors, Chalk pencil, Pencil, Sewing machine, Pins, Needle.
* Seam allowance 1/4” unless otherwise specified.* All units are inches.
Cut out the Fabric
With the wrong side of the fabric in a single layer, draw the patterns directly onto the wrong side of the
fabric. Make sure to transfer all points and references to the fabric. Cut out the exterior, lining and
interfacing. Iron the interfacing on the wrong side of the exterior fabric. Draw and cut the interfacing using
a lining pattern. Fuse the interfacing on wrong side of the lining following the manufacture’s guide.
Sewing label
Picture 1 Picture 2
Attach the magnetic snap onto the right side of the If you would like to add the sewing label, place the
lining flap and exterior front piece following the label and baste at your desired location, see Picture
manufacturer’s guide, see Picture 1. 2.
Picture 3 Picture 4
Sew around the exterior clutch, back tack on each Clip the rounded seam, see Picture 4.
ends, see Picture 3.
Picture 5
Repeat this process for the lining, see Picture 5.
1
Make the Flap
Picture 6 Picture 7
Pin the exterior flap and lining flap with right sides Clip the curved seam. Turn the flap right side out,
facing, see Picture 6. Stitch only rounded seam, see Picture 7. Press the flap; topstitch 1/8” away
leave a straight edge unstitched (for turning). from the curved seam only.
Open here
Exterior/right
Lining/wrong side
side
Picture 9 Picture 10
Press the exterior and lining seams open. Put the Pin the opening of the clutch. Sew along the
exterior into the lining with right sides together, opening of the clutch using a ¼” seam allowance,
sandwiching the flap in between the exterior and leave a 3” gap to turn it right side out, see Picture
the lining, see Picture 9. 10.
2
Trim the
corner
seams
Picture 11 Picture 12
Trim the corner seams, see Picture 11. Turn the clutch right side out, see Picture 12. Iron
the opening of the clutch.
Topstitch
Picture 13 Picture 14
Tuck the lining into the exterior. Topstitch all- Sew the button to the exterior flap as desired
around of the opening of the clutch, see Picture 13. location.
Only if you follow these conditions will I allow you to sell the finished products.
*Give full credit to ithinksew.com for the patterns (this applies to online and offline) For example, when you’re selling one of my
patterns online include a sentence like this; “This pattern was designed by ithinksew.com” A link to my shop will also be really
thankful. When selling the patterns offline, write this down on the tag.
* The finished products may only be made by crafters. It may not be mass produced.
3
SWEET AND SIMPLE CLUTCH(Small)
Flap
Exterior: Cut 1
Lining: Cut 1
Interfacing: Cut 1
1/4” seam allowance included
Magnetic
snap
Magnetic
snap